2023 Ford Maverick Hybrid

Defect. Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick Hybrid and 2020 Escape Hybrid vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

Risk. A loss of drive power increases the risk of a crash.

Remedy. Dealers will update the HPCM software, free of charge. Owner notification letters were mailed February 12, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 15, 2026. This is an expansion of Recalls 24V330 (24S33) and 25V133 (25S16).

The welds broke on the front driver side door. Door has a creaking sound and the door has visibly growing stress crack near the door check arm. I took it to the dealer and here' s their repair comments. "B. CUSTOMER STATES DRIVERS SIDE DOOR CREAKS WHEN OPENING AND CLOSING. X MUST GO TO BODY SHOP DOOR WELDS ARE BROKEN (DOOR)" It seems to be the same issue as Ford's customer satisfaction program 23B56 "inspect front door check-arm reinforcement spot welds", for the Ford Excape, coming from the same factory as the Maverick, but the Maverick didn't get a customer satisfaction program for this issue.

Truck started to shake when accelerating past 50 mph. The shaking would stop once the speed limit was reached and you let off the accelerator. Web search results showed 2022, 2023 & 2024 Ford Maverick hybrids are known for CV axle failures with those symptoms. Vehicle was around 48,000 miles. Dealership replaced both CV axles under the 5 year/60,000 mile warranty.

At around 27K miles the two front CV axles began to fail. I brought it to the Ford dealership and they confirmed that both needed to be replaced. It was a $1600 repair. There have been a lot of complaints from Ford Maverick owners who have had CV axle failures at very low miles on their vehicles. These parts typically last 100K to 150K miles and it's not unusual for them to last the lifetime of the vehicle. There is no reason both front CV axles should be failing with 27K miles on a vehicle. This should be covered by a recall.

The truck was being towed behind a motor home, while making a normal left turn from a complete stop the truck began swing wildly from side to side (death wobble). After stopping I found a dash warning "Steering Assist Fault, Service Required" and "Drive Mode Not Available". At that time the truck steering was very difficult to turn, the truck was not drivable. This is the second time this has happened. In June 2024 the exact same thing happened. Ford replaced the steering assembly (twice, the first part was defective) under warranty. I believe this to be a safety hazard. I tow the truck behind the motor home in order to have reliable transportation when I arrive to a destination and also to provide a safe way to get help if some incident occurs while on the road (motor home break down) or for an emergency at the destination. Both steering assist incidents occurred when I was in a remote area with no cell service or internet service. Had there been any kind of medical emergency it could have had unwelcome results.

Significant disruptive vibration upon acceleration at high speeds due to premature failure of front CV Axles. Confirmed failure of both axles by manufacturer at approximately 61,000 miles.

The Ford Maverick has a known issue with "grabby brakes." I recently took my vehicle in for service and was advised the vehicle had an outstanding service bulletin to solve this problem. The repair given by Ford is ineffectual. There is a potential problems, even at low speeds, for sudden braking and collisions. This is ongoing at every stop and experienced by other Maverick owners.

12 volt electrical system no power. Dealer changed battery cable wiring harness. Received vehicle back. One week later vehicle exhibited no 12 volt power. Informed that it could be the Thinkware dash cam. Which was purchased from Ford and Ford dealer installed. Now informed that it could be the dash cam itself. The dash cam was installed via the OBD port which is always powered. This will drain the 12 volt battery unless vehicle is driven for extended periods. Ford is aware of the issue but no remedy for over 3 weeks. I have told the Ford dealer to have the dash cam installed so that when the ignition is on the dash cam is also powered on and off when the ignition switch is turned off. Using this method negates the parking mode on the dash cam. Another issue is when the drivers side door is opened the interior lights do not activate. Ford notified. Problem not resolved. Low 12 volt battery issue?

12-Volt battery gets extremely hot and gives off invisible fumes. Model number is BAGM-H14. Vehicle was towed to dealership for diagnostic evaluation. Also, dashboard shows various warning messages. Battery could not be charged, plus does not maintain charge.

This vehicle has chronic clicking when turning , when taken to a mechnanic i was informed the CV Axles both were torn and that it was a common issue for the 22 ford mavericks and they issue replacements for free. However when it comes to this they don’t cover it. The issue is still present and left untreated could be a dangerous issue.

Receiving daily Battery Saver Mode notices telling me some remote features including lock/unlock may temporarily be unavailable. Not to use my AC and go for longer rides, which I have done with no change. My interior lights are not coming on. My radio powers off and on while driving. Constant clicking and noises come from the vehicle when turned off. Difficulties starting the vehicle at times. Feel power losses when driving and accelerating, feel like I could be rear ended when this happens. In doing some online research, I am clearly not alone in this issue, when I contacted Ford and the dealership they both acted as if this is not a current issue and I would have to it inspected by a Ford dealership with no guarantee that the inspection would be covered. I found a recall 24S24 that sounds like my exact issue, yet they say it's not been authorized for my vehicle.

Eninge started knocking, flashed warnings to pull over immediately. I did and had the vehicle towed to Westway Ford in Irving. Their investigation showed the engine needs a full rebuild and they are claiming it is not covered under warranty. They shared pictures & a written repair estimate. Doing an analysis of the pictures they took and their description of what happened, combined with what I experienced and observed, this appears to be a textbook case of the behavior and outcome of the mechanical failure described in recall 23S27.

Recall 24S51 from Ford says that 87,000 Maverick trucks have had the wiper motor fail due to moisture getting into the housing due to a sealant problem with the supplier. The recalled VINs can have a free inspection and replacement. I believe my VIN is also impacted by this problem because 37 months and 31,000 miles into my car, my wipers failed. I was driving in light rain and the wipers would only go up about 6" from their resting position before returning to the resting position, then repeat the same thing. Thankfully the rain wasn't so heavy that I had to stop and could continue driving home (very carefully!). We've had a very dry winter, so I haven't used my wipers in months. The prior week before the failure, we had a big snow/rain storm spanning two days with about 1.5" of moisture coming down. Hence, I think this storm precipitated, literally, my issue. I took my Maverick to the Ford dealership for a hitch recall, asking about this wiper motor recall problem at the same time. I picked up my truck today and after it's been sitting in the sun, my wipers work again. It sure seems that when moisture is getting into the housing, the wipers fail, then the sun dries it out, then the wipers work. Note, my truck is not garaged. I believe my VIN should be part of the 24S51 or 24-594 recall. Since in my almost 60 years of driving, I've never had a failure of a windshield wiper motor in this way, it seems to be a very rare thing to occur. With a recall of this part in other Maver

While driving the vehicle at low speed (roughy 25mph) a loud sqeek was heard. This occured a few more times so I stopped to inspect. I countinued my trip after not finding the source of the noise. When it occured again, I pulled into a parts store and had them run codes. After finding none I purchased a code scanner so that I could monitor while under way. Once on the highway the sound became more frequent, after just a few miles warning lights appeared on my dash and the vehicle had a complete loss of power. I was able to coast to the side of the road. At that time the vehicle did have code P1061. Dealer diagnosted the truck with a failed transmission. I removed the trasmission and disassembled it. The main shaft had been stripped of it's splines on the gear that connects to the engine. I have a video of the gears and shaft here: [XXX] I saved the parts and will be happy to provide them for investigation if needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

CV axles bad, intense shuddering during acceleration and between 25-55mph. Severe enough to shake side to side in my lane on occasion. Serious safety concern and seems to be a ubiquitous issue.

Both front CV axles on my 2023 Ford Maverick Hybrid are failing at approximately 60,000 miles. The vehicle experiences violent shaking and vibration during acceleration, most noticeably at speeds above 30 mph and on inclines. The shaking is severe enough to affect steering control and reduce driver confidence, particularly during highway merging and uphill acceleration. The problem was diagnosed and confirmed by San Leandro Ford dealership, which identified both front CV axles as defective and in need of replacement. No warning lamps or message appeared prior to or during the issue. The vehicle is available for inspection upon request. This appears to be a widespread manufacturing defect. Numerous owners of 2022-2023 Ford Mavericks have reported identical premature CV axle failures at mileages ranging from 10,000 to 60,000 miles, as documented in online forums and prior NHTSA complaints. Some owners have had axles replaced multiple times. The defective CV axles pose a safety risk as the severe vibration compromises vehicle control during normal driving conditions.

The contact owns a 2023 Ford Maverick. The contact stated that while driving 5 MPH and making a right turn, the vehicle lost power, and the transmission slipped into neutral(N). While driving 25 - 30 MPH and approaching a red light, the transmission slipped into neutral. The contact associated the failure with NHTSA Campaign Number: 24V330000 (Power Train) and 25V133000 (Power Train). The local dealer was contacted and confirmed that the VIN was included in the recalls. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 17,000.

The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was a fuel odor on the exterior and interior of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured fuel seal. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact was informed that a diagnostic test was needed to determine the cause of the failure. The dealer declined to provide a free diagnostic test. The contact referenced the notification of NHTSA Campaign Number: 23V380000 (Engine); however, the VIN was not associated. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 45,300.

Per the dealership my vehicle is throwing the same codes P1061 and P032F as the recall that is less than a month from when my vehicle was built. My vehicle knocks and then the speed drops to less than 35 miles and it happened to me in traffic. It is very dangerous and again this is the same issue as the recall for my 2023 that is for other 2023 vehicles. I have called Ford to get help and file a complaint but am getting zero help. Again this is a very dangerous event that is happening and could cause damage not only to my vehicle but to others. I have to work so driving the vehicle is my only option right now and I can't afford the $9,000 to fix something that is a Ford issue. Please review and have Ford pay for the safety issue they already know they have. Thanks

While driving highway speeds the vehicle suddenly lost power. Had to immediately pull to the shoulder of the highway with heavy traffic that got very close to my rear bumper due to the sudden decrease in speed. There was no advance warning of power loss. Upon stopping on the shoulder the vehicle was put in park and the key turned to the off position. After a short wait the ignition key was turned to the on position and was able to resume trip at highway speeds. Notified Ford close to my location and it was checked for fault codes and road tested with no defect found., Now concerned that the vehicle might fail again day or night leaving us stranded or causing a vehicle accident due to the sudden reduction in speed.

I am reporting a premature and dangerous failure of the front CV (Constant Velocity) axle assembly on my 2023 Ford Maverick. While driving at 50 mph the vehicle began experiencing violent, uncontrollable shaking and shuddering in the front end, particularly under acceleration. This is an issue which affects all Mavericks for this model year. Ford has recalled/reimbursed replacements for the 2022 model year but not other ones yet. This failure causes significant instability and compromises steering control, creating a high risk of a crash when merging into traffic or maintaining highway speeds. The vibration is severe enough to distract the driver and could lead to a total loss of motive power if the axle snaps or the joint fully separates.