1993 Ford Bronco

Defect. FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Risk. AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy. DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Defect. ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy. DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Defect. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

Risk. SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.

Remedy. THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.

Defect. THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.

Risk. WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.

Remedy. A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

Defect. THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.

Risk. IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.

Remedy. INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.

Defect. THE TRANSFER CASES HAVE BEEN BUILT WITH THE WRONG ELECTRIC SHIFT MOTOR. THE TRANSFER CASES CAN SLIP OUT OF THE 4 X 4 HIGH GEAR POSITION DURING COASTING IN FORWARD GEARS OR WITH POWER APPLIED IN REVERSE GEAR.

Risk. IF THIS OCCURS, THE VEHICLE CAN ROLL FREELY AS IF INNEUTRAL POSITION REGARDLESS OF THE TRANSMISSION GEAR SELECTOR POSITION. THIS CANRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

Remedy. REPLACE DEFECTIVE TRANSFER CASES WITH THE CORRECT VERSION.

MY 1993 FORD BRONCO HAS AN ESOF (ELECTRONIC SHIFT ON THE FLY) TRANSFER CASE. WITH FOUR WHEEL DRIVE ENGAGED, ON ROAD AND OFF, WHENEVER THE VEHICLE IS COASTING THE TRUCK WILL SUDDENLY ACT LIKE IT IS NO LONGER IN GEAR. SHIFTING INTO PARK AND AND BACK WILL NOT CHANGE ANYTHING. THE TRUCK MUST BE TAKEN OUT OF FOUR WHEEL DRIVE IN ORDER TO START DRIVING AGAIN. I BELIEVE THIS TO BE DANGEROUS AS IT COULD ALLOW ME TO NOT REACT IN THE CASE OF AN EMERGENCY. IT THINK THAT IT IS A SIMILAR PROBLEM TO THE RECALL 93V089000.

TL* THE CONTACT OWNS A 1993 FORD BRONCO. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND CAUSED ANOTHER VEHICLE TO CRASH INTO THE CONTACT'S VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE UNKNOWN INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION. IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT DID NOT DISCLOSE WHERE THE VEHICLE WAS TAKEN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 05V017000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHILE COASTING HE ATTEMPTED TO ACCELERATE AND THE VEHICLE WOULD NOT RESPOND. THE CONTACT STATED THAT THE DEFECT WAS ONLY OCCURRED AFTER THE VEHICLE WAS COASTING. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE TRANSFER CASES SLIPPED OUT OF THE 4X4 GEAR DURING THE INCIDENT. THE CONTACT INDICATED THAT HE EXPERIENCED THE SAME DEFECT LISTED IN THE NHTSA CAMPAIGN NUMBER 93V089000 (POWER TRAIN) BUT THE MANUFACTURER DID NOT INCLUDE THE VEHICLE IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 37,000. UPDATE 4/7/14 VA THE CONSUMER REQUESTED ASSISTANCE WITH HAVING FORD REIMBURSE THE $1,500 FOR REPAIR OF THE VEHICLE. THE CONSUMER BELIEVES THE VEHICLE SHOULD HAVE BEEN INCLUDED IN THE RECALL. *JS

TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT STATED THAT WHILE PARKED, THE EMERGENCY BRAKE WAS ENGAGED AND FAILED TO RESPOND. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 94V169001 (PARKING BRAKE). THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE EXPIRED RECALL. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT STATED THAT WHILE PARKED HE ATTEMPTED TO APPLY THE PARKING BRAKE BUT IT DROPPED TO THE FLOOR BOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE BRAKES WOULD HAVE TO BE REPLACED. AFTER THE REPAIRS THE FAILURE RECURRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 94V169001 (PARKING BRAKE:CONVENTIONAL) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

TL*THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL (NHTSA CAMPAIGN ID NUMBER 07V336000). THE DEALER STATED THAT THE PARTS WOULD NOT BE AVAILABLE UNTIL DECEMBER OF 2007. THE CONTACT FELT THAT THE WAIT TIME FOR THE RECALL REPAIR WAS EXCESSIVE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 126,000. UPDATED 10/26/07. *JB

1993 EDDIE BAUER BRONCO RIGHT FRONT TIRE BLEW OUT. *TS WHEN THE TIRE BLEWOUT THE CONSUMER LOST CONTROL O THE VEHICLE AND ENDED UP IN A SHALLOW DITCH. THE CONSUMER WAS ABLE TO GET THE VEHICLE BACK ON THE ROAD AND PUT THE SPARE TIRE ON. THE REMAINING TIRES WERE DRIVEN ANOTHER 10000 MILES THEN REMOVED DUE TO BULGES IN THE SIDEWALL. THE TIRES WERE T HEN STORED IN THE CONSUMER'S SHED. THE CONSUMER RECEIVED A RECALL ON THE TIRE AND CONTACTED THE MANUFACTURER. THE CONSUMER WAS TOLD TO TAKE THE TIRE TO THE TIRE DEALER AND HAVE THE TIRE SENT TO THEM. THE CONSUMER RECEIVED A LETTER FROM THE MANUFACTURER STATING THAT THE TIRES WERE NO LONGER UNDER WARRANTY BECAUSE THEY WEREN'T ON THE TRUCK. *NM

RIGHT SIDE DASH BOARD LOOSE. NEED TO REPLACE THE BRACKET I THINK THERE WAS A RECALL ON IT.*AK

ON TWO SEPERATE OCCASIONS, TIRE TREAD SEPARATED FROM THE TIRES WHEN TRAVELING 60-65 MPH. THE TIRES ARE FIRESTONE FIREHAWK ATX 33X12.50R15LT MOUNTED ON A 1993 FORD BRONCO. ON THE SECOND OCCASION, THE TREAD SEPARATION RESULTED IN LOSS OF CONTROL OF THE VEHICLE AND A SINGLE CAR ACCIDENT INTO A GAURD RAIL. THE SECOND FAILED TIRE IS STILL AVAILABLE. ALL FIRESTONE TIRES HAVE SINCE BEEN REPLACED ON THE VEHICLE.

ON APRIL 25, 2003, I WAS DRIVING TO KANSAS CITY, MO. FROM TULSA, OK. ON I-44. PURSUANT TO THE POSTED SPEED LIMIT, I WAS TRAVELLING AT OR NEAR 75 M.P.H. THERE WAS ONLY MYSELF AND MY DOG IN THE CAR. SUDDENLY, THERE WAS A LOUD NOISE FROM THE BACK OF MY CAR, A 1993 FORD BRONCO. ACTUALLY, IT SOUNDED MORE LIKE AN EXPLOSION. THE CAR IMMEDEATLY WENT UP ON TWO WHEELS TOWARDS A BARRICADE. I TRIED TO CORRECT IT AND LOST CONTROL THE OTHER DIRECTION. THE DOG, A ONE HUNDRED POUND LAB, WAS THROWN INTO THE FRONT SEAT. I THOUGHT I WAS GOING TO GET KILLED AND SHUT MY EYES. WHEN I OPENED THEM, I WAS PERPINDICULAR TO TRAFFIC ON THE INTERSTATE. I REGAINED MY COMPOSURE AND PULLED TO THE SIDE OF THE ROAD. I GOT OUT TO INVESTIGATE THE ANAMOLY AND FOUND A FIRESTONE WILDERNESS AT, SIZE: 31X10.5, DOT #VD60 AW3 497. WITH THE TREAD 3/4 DETACHED. THE MUFFLER WAS SMASHED, THE WHEEL WELL WAS SHOVED INTO THE BACK SEAT WELL PAST THE POINT WHERE IT WAS WHEN I HAD LAST OBSERVED IT. THE ELECTRICAL SYSTEM (I.E. BRAKE LIGHTS AND TAIL LIGHTS) WAS INOPERABLE. I PUT A SPARE ON THE CAR AND HAD IT CHANGED A FEW HARROWING HOURS LATER AFTER DRIVING ON THE SHOULDER FOR SOME TIME AT 25 M.P.H. AS I HAD NO IDEA WHAT TYPE OF STRUCTURAL DAMAGE MAY HAVE OCCURED. I DID WAIT FOR A STATE TROOPER FOR SOME TIME BUT NONE SHOWED. I STILL MAINTAIN POSSESSION OF THE TIRE.

REAR BRAKES DON'T STOP FRONT BRAKES. REAR BRAKES WERE DETACHED FROM VEHICLE, CAUSING A COLLISION. AK

THE VEHICLE WAS REPAIRED AT CHICO AUTO CARE LOCATED AT 724 W. 9TH ST. IN CHICO , CA. 95928 (530) 894-7165. THE MECHANICS REPAIRED THE ELECTRICAL SWITCH THAT IS CONNECTED TO THE TOP OF THE IN-TANK FUEL PUMP, LOCATED ON THE TOP OF THE FUEL TANK. THE MECHANICS STATED THAT THEY HAVE BEEN SEEING THIS MORE FREQUENTLY ON THE FORD TRUCKS AND THAT I WAS LUCKY IT DID NOT BLOW UP. WHEN TRYING TO GET A REPLACEMENT PART, IT WAS LEARNED THAT FORD HAS DESIGNED A NEW SWITCH FOR THIS PART AND THAT IS WHAT NEEDED IN PLACE OF THE OLD PART. IF THIS WAS A FAULTY SWITCH THAT WAS SHORTING OUT AND BURNING AND FORD CHANGED THE DESIGN, WHY WERE THE OWNERS NOT NOTIFIED. THANK YOU FOR YOUR TIME. *AK

WHILE DRIVING WITH THE TOUCH DRIVE ELECTRIC SHIFT 4X4 IN THE VEHICLE STOPPED MOVING, CONSUMER BELIVES THE PROBLEM IS THE SAME AS RECALL 93V-089 BUT CUSTOMER SERVICE CLAIMS THEY KNOW NOTHING ABOUT THE RECALL. NLM

REAR BRAKES FAILED AFTER GOING OVER BUMPY TERRAIN THE REAR BRAKES CAN FAIL DUE TO AIR IN THE HYDRAULIC SYSTEM. *AK

FRONT ROTORS WARP QUICKLY AFTER BEING TURNED. GETS WORSE AFTER HARD BRAKING SHIMMYS WHOLE VEHICE. PULLS L OR R RANDOMLY.*AK

TREAD SEPARATED AND BEGAN TO PEEL AWAY ON LEFT SIDE OF LEFT REAR TIRE LEADING TO TIRE DEFLATION AT HIGHWAY SPEED.*AK (DOT NUMBER: VN60AXC107 TIRESIZE: 31X10.5R15)

COMPLETE TREAD SEPARATION AT 70MPH CAUSED DAMAGE TO VEHICLE. NO OBVIOUS VISUAL DEFECTS WHEN INSPECTED 5 HOURS EARLIER. *AK (DOT NUMBER: VDHL1M4 TIRESIZE: P235/75R15)

TIRE APPX 1 1/2 YRS OLD. FIRESTONE RADIAL ATX 235-75-R15. SERIAL# H4BNDFA399 TREAD RIPPED AWAY FROM TIRE. FIRESTONE PAID INSD 80% FOR TIRE AND TOOK TIRE. (CLAIM# 16-N113-825) *MW

OUTPUT SHAFT FELL OUT WHILE TRAVELING AT 25 MPH AND LOST CONTROL OF VEHICLE. ALSO, PROPERTY DAMAGE. DEALER/MANUFACTURER WERE NOT NOTIFIED. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

WHILE DRIVING UP HILL OR CHANGING GEARS, SUCH AS FROM REVERSE INTO DRIVE, VEHICLE WILL STALL UNEXPECTEDLY WHICH MAY CAUSE A CRASH. PEP BOYS CANNOT DETERMINE THE CAUSE. PLEASE PROVIDE FURTHER INFORMATION.*AK