1990 Ford Bronco

Defect. THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Risk. THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Remedy. DEALERS WILL REPLACE THE IGNITION SWITCH.

THE SEAT PAN UNDER THE SEAT TRACKS HAS CRACKED IN MY 1990 BRONCO WITH CAPTAIN CHAIRS. THE VEHICLE WAS IN MOTION WHEN THIS HAPPENED ON A PUBLIC PAVED STREET, AND COMING TO A NORMAL STOP. BACK IN OCTOBER 1990, I RECEIVED SAFETY PROGRAM NUMBER (B(93) ABOUT THIS POTENTIAL PROBLEM. I IMMEDIATELY BROUGHT THE VEHICLE TO THE DEALERSHIP OF PURCHASE, JOHN FOSTER FORD, UPON RECEIPT OF THE NOTIFICATION. I DO NOT LET ANY SAFETY ISSUES GO. THEY LOOKED AT THE VEHICLE AND DID NOT MAKE THE REPAIR. BECAUSE THE VEHICLE IS SO KINDLY DRIVEN IT HAS TAKEN MANY YEARS FOR THE FLAW IN THE FORD SEAT PAN DESIGN TO DEVELOP. I SPOKE WITH FORD AT THE CUSTOMER SERVICE 800 NUMBER AGAIN TODAY AND HAVE BEEN IN TOUCH WITH THE REGIONAL SERVICE MANAGER AND THEY REFUSE TO PERFORM THE REPAIR OR ACKNOWLEDGE THAT THE VEHICLE WAS INVOLVED IN THE SAFETY PROGRAM. I STILL HAVE THE LETTER AND ORIGINAL ENVELOPE FOR WHICH IT CAME. THERE SHOULD BE A RECORD OF THE INITIAL INSPECTION CHARGE DONE BY THE DEALERSHIP IN SOME COMPUTER RECORD WHEN THEY TURNED IN THEIR INSPECTION CLAIM, BUT THEY DO NOT OR AT LEAST WILL NOT ADMIT TO IT. THERE APPEARS TO BE A COMPUTER ISSUE WITH MY VIN, BECAUSE OBVIOUSLY THE REPAIR WAS NOT PERFORMED AND I HAVE DEMONSTRATED WITH THE SECOND SAFETY NOTICE ON THE IGNITION SWITCH (FSA 95S28) THAT I IMMEDIATELY BROUGHT THE VEHICLE INTO THE DEALERSHIP FOR REPAIR AT WHICH TIME THEY ALSO DID NOT MAKE THE SEAT PAN REPAIR ON NOVEMBER 22, 1996. I HAVE COPIES OF THAT NOTICE AND THE BENSON FORD DEALERSHIP (SAME DEAL

CRACKED SEAT MOUNTS ON FLOOR BOARD. 1990 BRONCO, BUCKET SEATS, HAVE THE SAME PROBLEM AS THE 89-90 BRONCOS WITH CAPTIANS CHAIRS, THE FLOOR BOARD CRACKS AROUND THE BOLTS. THIS MAKES THE FRONT SEATS WOBBLE, BOUNCE, AND MOVE, INCREASING THE STRESS ON THE FLOOR PAN, UNTILL THE FLOOR PAN BREAKS AND THE BOLT NO LON GET HOLDS ANYTHING. EXISTING RECALL FOR MODELS WITH CAPTIANS CHAIR, DO NOT APPLY TO BUCKET SEATS, IT NEEDS TO BE EXPANDED OR A NEW RECALL PUT OUT. THIS IS VERY UNSAFE, AND IS CLEARLY A MANUFACTURING DEFECT, ATTACHED IMAGES SHOW NO RUST OR OTHER CORROSION THAT COULD HAVE CAUSED THIS.

I WAS HEADING TO THE STORE WHEN MY GAS PEDAL FOR STUCK. I PRESSED THE BRAKES AND HELD THEM DOWN TO NO AVAIL. I ENDED UP CRASHING THROUGH SOMEONES YARD AND HITTING THEIR PROPERTY. MY BRONCO FINALLY STOPPED ABOUT 15 SECONDS LATER. THE WHOLE INCIDENT WAS ABOUT TWO MINUTES LONG. *TR

FLOOR PAN UNDER DRIVERS SEAT HAS CRACKED WHERE THE SEAT IS ATTACHED IN 1990 BRONCO. CAUSES SEAT TO SHIFT, SINK AND BOUNCE AND NOT FEEL SECURE TO VEHICLE. IDENTICAL PROBLEM IN MY 1989 FORD BRONCO AND WAS REPAIRED BY DEALER AS A RECALL DEFECT. CANNOT FIND ANY RECALL INFORMATION REGARDING THE 1990 BRONCO WITH THIS ISSUE OR FOR 1989 BRONCO DESPITE DEALERS REPAIR. *TR

1990 BRONCO EQUIPMENT FAILED CAUSING AN ENGINE COMPARTMENT FIRE. *TS A NEW POWER STEERING PUMP HAD BEEN INSTALLED PRIOR TO THE FIRE. *NM

A PATTERN OF SAME SIZE CHUNKS ON THE SAME CIRCULAR COLUMN OF THE TIRES ARE BREAKING OFF. TIRE PSI AND BALANCING ARE EXCELLENT. NO OFF ROAD OR AGGRESSIVE DRIVING. TIRE ONLY 6 MONTHS OLD. *JB

1990 FORD BRONCO IGNITION SWITCH FAILED. (SAFETY RECALL #96V071000 OF NOV95) FORD DEALER SAID NO RECALLS ON THIS VEHICLE AND CHARGED ME $476.00. I CHECKED THE FORD WEBSITE AND THEY ONLY LIST RECALLS FROM JAN96, IS THERE A STAUTE OF LIMITATIONS ON SAFTEY RECALLS AND HOW LONG?

1990 FORD BRONCO I BROUGHT THIS VEHICLE IN TO JIM DOYLE FORD ON DELAWARE AVENUE IN KENMORE N.Y, LAST WEEK. THE IGNITION SWITCH BROKE, AND WAS TO BE REPLACED VIA RECALL. THE IGNITION SWITCH MALFUNCTIONED, AND I SMELLED FIRE.SAW SMOKE. TURNED KEY OFF TO NO AVAIL, IMMEDIATELY RAN IN THE HOUSE, GRABBED FIRE EXTINGUISHER, CALLED FIRE DEPT (CAR WAS PARKED BETWEEN 2 HOUSES) AND RAN OUT AND CUT BATTERY CABLE. AFTER DETERMINING PROBLEM (DEFECTIVE IGNITION SWITCH) I HAD THE VEHICLE TOWED TO JIM DOYLE FORD. THEY OFFERED THE FREE REPAIR, AND CALLED ME STATING THAT SOMETHING INSIDE THE IGNITION COLUMN WAS BROKEN, AND THEY WOULD CHARGE ME 60 DOLLARS PLUS TAX JUST TO DIAGNOSE. I DECLINED, WENT TO THE DEALER, AND THE IGNITION SWITCH WAS JUST HANGING OUT FROM THE HARNESS UNDER THE DASH, THE MECHANIC USED A SCREWDRIVER TO PUSH THE SWITCH AND STARTED THE VEHICLE FOR ME. I THEN TOOK THE VEHICLE TO BUFFALO KEY AND LOCK, AND THE TECHNICIAN (RON CHASE) FOUND THAT THE INTERNAL MECHANISM IN THE STEERING COLUMN HAD BROKEN, AND HE STATED THAT IT IS A COMMON PROBLEM SINCE THE DEFECTIVE (RECALLED) IGNITIONS GENERALLY MELT AND WELD THEMSELVES IN THE "START" POSITION, WHEN THE DRIVER ATTEMPTS TO TURN IT OFF IT CAUSES THE RACK AND RODS INSIDE OF THE STEERING COLUMN TO BREAK, RENDERING THE IGNITION KEY ETC INOPERABLE. THIS IS DIRECTLY ATTRIBUTABLE TO THE DEFECTIVE IGNITION SWITCH THAT WAS RECALLED. FORD STATED THAT THEY WOULD NOT PAY FOR THIS SINCE THE ONLY THING COVERED WAS THE IGNITION SWITCH ITSELF. $295.

1990 FORD BRONCO DESTROYED IN FIRE. SPONTANEOUS FIRE ORGINATED IN ENGINE COMPARTMENT OR UNDER DASH INSIDE VEHICLE WHILE PARKED ON STREET. VEHICLE WAS NOT RUNNING AT THE TIME. VEHICLE IS A TOTAL LOSS.

WHILE DRIVING THE VEHICLE AT 10MPH, THE VEHICLE SUFFERED SUDDEN ACCELERATION, AND HAD A FRONT COLLISION WITH A GARAGE DOOR. MR THE DEALER STATED THAT THIS WAS CAUSED BY THE THROTTLE BODY INJECTION BEING DIRTY. SCC

CONSUMER STATES THE THICK FILM IGNITION MODULE IS NOT USABLE UNLESS THE TEMPERATURE IS 70 DEGRESS OR COOLER, OTHERWISE THERE IS AN UNCONTROLLABLE STALL THAT OCCURS, CONSUMER HAS CONTACTED THE MANUFACTURER ON SEVERAL OCCASIONS TO TRY AND GET THE PART REPAIRED OR REPLACED.*JB

VEHICLE STALLS INTERMITTENTLY AT ANY SPEED/IN WARM WEATHER/OR ON INCLINES, AND DOWN GRADES. DEALER REPLACED THE FUEL PUMP, WHICH DID NOT REMEDY THE PROBLEM. *AK THE CONSUMER STATES THAT FORD HAS NEVER PROVIDED ANY DATA OR SERVICE TO SOLVE THE PROBLEM-BY THEIR USE OF DISTRIBUTOR MOUNTED THICK FILM IGNITION MODULE. (TFI PROBLEM) THE VEHICLE WILL CRANK BUT WON'T START. *SCC

A VEHICLE FIRE STARTED UNDER THE DASH WHILE DRIVING. DEALER AND MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION, AND PLEASE FILL IN VEHICLE MILEAGE.*AK

CONSUMER WAS TRAVELING ABOUT 65MPH ON HIGHWAY AND HEARD A NOISE COMING FROM UNDERNEATH OF VEHICLE. ENTIRE FRONT OF CAR DROPPED DOWN/. IT WAS LEFT AXLE. DEALERSHIP WAS AWARE OF PROBLEM. *AK

I HAVE DONE RESEARCH ON THE PUMP. THERE IS A UPGRADE BUT THE PRICE IS NOT RIGHT. I BELIVE THE DEALER SHOULD REPLACE IT FREE OF CHARGE OR AT LEAST LOWER THE COST. IT HAS BEEN KNOWEN TO MELT THE PLUG ON TOP BUT SOMTIMES IT WELL SPARK AND START A FIRE. *AK

ENTIRE LEFT SIDE OF DASH COMPLETED BURNT/MELTED. TOTAL BURN DAMAGE TO LEFT FRONT SEAT, LEFT INTERIOR OF DOOR, ROOF, FLOOR. NO DAMAGE TO ENGINE.

NO SUMMARY

TRED COMPLETELY STPIPED, TREAD LOOKED BRAN NEW. *AK (DOT NUMBER: W2UL1M399 TIRESIZE: 205/75R15)

TIRE BLEW,FITS DESCRIPTION OF CURRENT RECALL- THREAD SEPARATES,LOST OF CONTROL. THESE ARE NEW TIRES,LESS THAN 2 YEARS OLD. LOCAL FIRESTONE REFUSED TO REPLACE ALL 4. STATES NO DEFECT WITH OTHERS.( DOT NUMBER: VDVKAXC147 TIRE SIZE: 32X11.5X15 )

PE00 020; CONSUMER WAS TRAVELING ABOUT 50MPH ON HIGHWAY AND VEHICLE STARTED TO SHAKE. ABOUT TEN SECONDS LEFT REAR TIRE TREAD SEPARATED, AND THEN TIRE RIPPED REAR BUMPER/ PASSENGER'S DOOR, AND THEN SLID INTO ONE LANE TO THE LEFT, AND FIVE LANES INTO TRAFFIC. THERE WERE NO INJURIES INVOLVED. TIRE WAS A FIRESTONE WILDERNESS. CONSUMER WILL FILL ADDITIONAL INFORMATION.*AK