2009 Dodge Ram 2500

Defect. Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Risk. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy. Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

Defect. Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Risk. In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy. Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

Defect. Chrysler Group LLC (Chrysler) is recalling certain model year 2008-2012 RAM 2500 4X4 and 3500 4X4 trucks, 2008-2012 Dodge RAM 3500 4x2 Cab Chassis, and model year 2008 Dodge RAM 1500 Mega Cab 4x4. The left tie rod assembly may break.

Risk. A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.

Remedy. Chrysler notified owners on January 16, 2014 that dealers would inspect vehicles and replace the steering linkage assembly, if necessary. On or about February 27, 2014, Chrysler ceased its recall remedy program due to parts quality concerns, and then re-initiated it on or about April 14, 2014. In July 2015, and under a consent order with NHTSA, the company agreed to offer owners three options for remedying their vehicles: perform the original remedy, offer to repurchase the vehicle at the fair market value plus 10%, or offer an additional incentive offer towards the purchase of a new Dodge, Jeep, Chrysler, or Fiat vehicle. Chrysler will notify owners of the new recall options in a letter expected to be mailed on August 31, 2015. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N49.

Defect. CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008-2011 DODGE RAM 2500/3500 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; MODEL YEAR 2008-2011 DODGE RAM 3500 CAB CHASSIS 4X2, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; AND MODEL YEAR 2008 DODGE RAM 1500 MEGA CAB 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH AUGUST 15, 2008, BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE. THIS CONDITION TENDS TO OCCUR DURING LOW SPEED PARKING LOT TYPE MANEUVERS WHEN THE CUSTOMER IS MAKING A TIGHT TURN. ADDITIONALLY, MODEL YEAR 2003-2008 DODGE RAM 2500/3500 VEHICLES MAY HAVE RECEIVED THE AFFECTED TIE ROD ASSEMBLY AS A REPLACEMENT PART DURING NORMAL SERVICE.

Risk. THIS CONDITION COULD RESULT IN THE POTENTIAL LOSS OF DIRECTIONAL STABILITY IN THE LEFT HAND FRONT WHEEL, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL INSPECT THE TIE ROD ENDS FOR RELATIVE ORIENTATION AND REPLACE THE LEFT OUTER TIE ROD AS REQUIRED AND PERFORM A FRONT END TOE ALIGNMENT AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 3, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Defect. CHRYSLER IS RECALLING 32,782 MY 2008-2009 DODGE RAM 2500, 3500 AND 3500 CAB CHASSIS PICKUP TRUCKS EQUIPPED WITH POWERS AND SONS STEERING LINKAGE. THE STEERING LINKAGE DRAG LINK INNER TIE ROD TO PITMAN ARM BALL STUD MAY FRACTURE. ALSO THE STEERING LINKAGE DAMPER ATTACHING THE BRACKET MAY YIELD AND SHIFT ON THE LINKAGE.

Risk. THIS COULD RESULT IN A LOSS OF STEERING CONTROL AND THE RESTRICTED ABILITY TO TURN THE VEHICLE IN ONE DIRECTION INCREASING THE RISK OF A CRASH WITHOUT WARNING.

Remedy. DEALERS WILL REPLACE THE STEERING LINKAGE DRAG LINK INNER TIE ROD END ASSEMBLY, AND INSPECT THE STEERING LINKAGE DAMPER BRACKET FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 16, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

The contact owns a 2009 Dodge Ram 2500. The contact stated that there was an abnormal odor coming from the exhaust at start-up. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the exhaust manifold bolts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 140,000. The VIN was not available.

The contact owns a 2009 Dodge Ram 2500. The contact stated while operating the vehicle, the check engine warning light remained illuminated, the headlights flashed off and on, and the battery failed to remain charged. The contact diagnosed an electrical ground short, a low voltage to the intake air heater relay, and the engine grid heater was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the Extended Warranty coverage for the failure. The failure mileage was 162,000.

The contact owns a 2009 Dodge Ram 2500. The contact stated while driving 20-60 MPH, the front end of the vehicle, the steering column, and the steering wheel were shuddering significantly. The contact stated that the vehicle had experienced the death wobble. The contact stated that the failure increased significantly while driving on bumpy road surfaces. The vehicle was taken to several independent mechanics, where the vehicle was diagnosed but the cause of the failure could not be determined; however, the failure persisted. The contact stated that the tires were replaced twice by two tire facilities; however, the failure persisted. The vehicle was previously taken to an unknown dealer; however, the cause of the failure could not be determined. The manufacturer was not notified of the failure. The failure mileage was unknown.

INITAL PROBLEM, FUSE BOX FIRE - 2020 REPEATED PROBLEM AGAIN IN 2020, 2021, 2023

The contact owns a 2009 Dodge Ram 2500. The contact stated that the vehicle was corroded. The vehicle was severely corroded at the rear passenger’s side door frame and a half of the subframe located at the rear passenger’s side was also severely corroded. The center of the main subframe exhibited had holes. The contact stated that the corrosion was not due to salt on the road. The vehicle was not repaired. The manufacture was contacted. The failure mileage was 140,000.

VEHICLE SWAYS BACK AND FORTH DUE TO STEERING LINKAGE

WENT OUT TO START AND IT WOULD CRANK OVER BUT NOT START UP IT WAS SITTING IN MY DRIVEWAY ON FAIRLY LEVEL SURFACE THEN THIS MORNING IT STARTED UP IMMEDIATELY WITH NO TROUBLE. SECOND TIME THIS HAS HAPPENED.

IN MOTION THE BLINKERS WOULD TURN ON WITHOUT ME TOUCHING THE SWITCH. WHEN I APPLIED THE LEFT BLINKER THE RIGHT ONE WOULD TURN ON AND VICE VERSA. FINALLY THE FLASHERS TURNED ON AND I COULDN'T TURN OFF. IT STARTED MALFUNCTIONING WHILE I WAS DRIVING DOWN THE HIGHWAY AT 60MPH.

UNCONTROLLABLE STEERING OR FRONT END WOBBLING. AKA DEATH WOBBLE, ACCORDING TO MY VEHICLE HISTORY THERE ARE RECALLS THAT ARE FOR STEERING AND THE DESCRIPTION OF ALL THOSE RECALLS SAY WHAT COULD HAPPEN WHICH IS A LOSS OF STEERING CONTROL RESULTING IN A CRASH. ALL THE RECALLS THAT I KNOW OF HAVE BEEN REPLACED. BUT I STILL HAVE INCIDENTS WHERE I LOSE CONTROL OF STEERING AND IN ORDER FOR IT TO STOP, I HAVE TO STOP THE VEHICLE. I HAVE HAD MANY MANY CLOSE CALLS, AND HOPING THAT THIS DOESN'T RESULT IN A LOSS OF A VEHICLE OR EVEN DEATH. IT'S A VERY BIG CONCERN TO ME CONSIDERING THERE HAS BEEN RECALLS FOR THE STEERING AND FRONT END. IT WILL OCCUR AS SOON AS I HIT A BUMP JUST RIGHT NOT EVEN AT HIGH SPEED IT HAPPENS AT 35-70 MPH NO MATTER IF IT'S FLAT GROUND OR NOT. THE ENTIRE TRUCK SHAKES AND FEELS LIKE THE WHEELS ARE BOUNCING OFF THE GROUND. AT THAT POINT BEING ON THE FREEWAY HAVING NO CONTROL OF MY STEERING THE ONLY OPTION I HAVE IT TO SLAM ON MY BREAKS, IT'S A MATTER OF TIME BEFORE SOMETHING REALLY BAD HAPPENS

TL* THE CONTACT OWNS A 2009 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 60 MPH AT NIGHT, THE INSTRUMENT PANEL LIGHTING WENT OUT. THE INSTRUMENT PANEL WAS CHANGED THREE OTHER TIMES BY BRYANT MOTORS (2901 S LIMIT AVE, SEDALIA, MO 65301), BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED FOR THE RECENT FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 49,000.

AFTER HITTING A BUMP IN THE ROAD AT HIGHWAY SPEED THE TRUCK BEGAN SHAKING VIOLENTLY. REFERRED TO AS A DEATH WOBBLE. NEEDED TO SLOW TRUCK TO BRING IT BACK UNDER CONTROL.

BRAKES FAILED DUE TO A CORRODED BRAKE LINES AT THE MASTER CYLINDER. HAPPENED IN DRIVEWAY BEFORE I GOT TO THE HIGHWAY.

DODGE. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH THE AIRBAG CLOCKSPRING. *LD THE CONSUMER STATED THE CLOCKSPRING WAS REPLACED ON THREE SEPERATE OCCASIONS, BUT THERE IS STILL A RECURRING PROBLEM WITH THE VEHICLE. *TR

CPSC: THE TRUCK BROKE DOWN IN THE MIDDLE OF THE HIGHWAY ENDANGERING MY YOUNG CHILD AND MYSELF. DT THE CONSUMER STATED THE VEHICLE WAS UNDER WARRANTY AND IN POSSESSION OF THE DEALER UNTIL IT CAN BE REPAIRED. THE MANUFACTURER WAS NOTIFIED. *JS

WHILE DRIVING AT HIGHWAY SPEED TERRIBLE FRONT END WOBBLE, VERY SCARY. HAS HAPPENED ON MULTIPLE OCCASIONS. HUSBAND NORMALLY DRIVES TRUCK THIS IS FIRST TIME THIS HAS HAPPENED TO ME WHILE DRIVING ON THE INTERSTATE.

TRACK BAR MOUNT CAME OFF OF THE FRAME OF THE TRUCK ......PULLING ONTO ROAD FROM DRIVEWAG

MY 2009 DODGE RAM 2500 STARTED HOPPING AFTER I HIT A SLIGHT BUMP IN THE ROAD. I WAS GOING ABOUT 50MPH WHEN THUS HAPPENED. I COULD DO NOTHING BUT TAKE MY FOOT OFF THE GAS TO SLOW THE TRUCK DOWN. IT LITERALLY HOPPED DOWN THE ROAD , IT FELT LIKE WE WERE IN A PAINT MIXER BOUNCING DOWN THE ROAD. THIS HAS HAPPENED SEVERAL TIMES BEFORE BUT WAS NEVER AS BAD AS THIS TIME. MY WIFE WAS WITH ME THIS TIME AND COULD NOT BELIEVE WHAT IT WAS DOING. SHE TOLD ME IF SHE HAD BEEN DRIVING SHE WOULD HAVE PANICKED AND MOST LIKELY WRECKED THE TRUCK. EVERYTHING IN THE TRUCK WAS BEING TOSSED AROUND. THIS ISSUE MUST BE CORRECTED BEFORE SOMEONE GETS HURT OR WORSE.

2009 DODGE RAM 2500 HAS WHAT IS DESCRIBED BY MANY AS "DEATH WOBBLE". AT FREEWAY SPEEDS (70MPH HERE IN MI) IF SOME EVEN MINOR BUMPS, POT HOLES ARE RUN OVER THE FRONT END OF THE TRUCK STARTS TO SHAKE UNCONTROLLABLY. TO GET CONTROL OF THE VEHICLE AGAIN YOU MUST SLOW TO BELOW 55MPH. MANY TIMES JUST THE DRIVERS SIDE FRONT TIRE AS BOUNCING OR WOBBLING, RECENTLY THE ENTIRE FRONT END. VEHICLE HAS HAD BOTH PRIOR RECALLS FOR TIE-ROD ENDS COMPLETED. HAD FRONT SHOCKS CHANGED IN CASE THEY WERE THE ISSUE NO CHANGE, HAD TIRES CHANGED IN CASE THERE WAS AN ISSUE WITH ANY OF THE TIRES, NO CHANGE. HAD BELLE TIRE TECHS LOOK FOR ISSUE WITH BOUNCING/WOBBLING TIRES THEY SAID EVERYTHING WAS TIGHT AND IN WORKING ORDER. ALSO HAS ANOTHER GARAGE LOOK AT IT FOR THE SAME ISSUE THEY DID NOT FIND ANY ISSUES. THIS PROBLEM THAT LOOKS TO BE PRETTY WIDESPREAD WITH OWNERS OF 2009 RAM 2500S MAKES THIS VEHICLE UNSAFE AT HIGHWAY SPEEDS UNTIL A FIX IS FOUND. I WILL ASK DEALER ABOUT BOUNCING/WOBBLING FRONT END AGAIN BUT IF THIS IS ON MANY OF THESE TRUCKS THE PROBLEM WILL END UP RESULTING IN ACCIDENTS SHOULD A DRIVER NOT BE ABLE TO SLOW DOWN QUICKLY TO REGAIN CONTROL OF THE STEERING. THIS PROBLEM HAS BEEN HAPPENING FOR OVER A YEAR ON AND OFF, I HAD AVOIDED DRIVING ON THE FREEWAY UNTIL THE LAST REPAIRS WHERE THE TIRES WERE CHANGED AND THE TECHS SAID EVERYTHING WAS GOOD WITH THE FRONT END. FIRST TIME ON THE FREEWAY AT 70MPH IT HAPPENED AGAIN WHEN A FEW SMALL BUMPS WERE RUN OVER, THE ENTIRE CAB OF THE TRUCK WAS SHAKING,

TL* TAKATA RECALL. THE CONTACT OWNS A 2009 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V352000 (AIR BAGS) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE SO THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACTS VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT WAS NOT EXPERIENCING A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TAKATA RECALL - WE RECEIVED NOTICE DATED 7/1/2016 REGARDING PASSENGER BAG RECALL. WE HAVE NOT RECEIVED INFORMATION REGARDING THIS RECALL. 6 MONTHS IS A LONG TIME, IS THERE A TIME FRAME LIMIT?