1999 Chevrolet Express 3500

Defect. CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.

Risk. THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.

Remedy. HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.

AN ASE/AAA CERTIFIED MECHANIC INSTALLED A PASSENGER CAR RATED TIRE ON THE VEHICLE, INFLATED TO 36 PSI. THE PLATE ON THE VEHICLE IS FOR AN E RATED TIRE (LT245/75R16E 80 PSI). THE TIRES INSTALLED WERE DOT R88Y 25BR0418 (OHTSU P245/75R16). WHEN ORIGINALLY CHALLENGED, THE SHOP ATTEMPTED TO HAVE ME KEEP THE TIRE ON THE VEHICLE. AFTER COMPLAINING THROUGH AAA THE TIRE SHOP ACCEPTED RETURN ON THE TIRES. AS I WAS REQUIRED TO WAIT FOR SOME TIME TO GET THE ORIGINAL SHOP TO ACCEPT RETURN I WENT TO ANOTHER SHOP TO HAVE THE P TIRES REPLACED WITH LT E-RATE TIRES. AT ANOTHER SHOP (A NATION CHAIN RETAIL CENTER) I WAS OFFERED FOR SALE C-RATE TIRES. NOW THAT THE FORD EXPLORER / FIRESTONE RECALL IS NOW A FADING MEMORY, I AM CONCERNED THAT MULTIPLE TIRE SHOPS OFFERED FOR SALE UNDER RATED TIRES FOR MY VEHICLE.

TL* THE CONTACT OWNS A 1999 CHEVROLET EXPRESS 3500. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO FIVE DIFFERENT DEALERS. THE TECHNICIAN DIAGNOSED THAT THE CRANK SHAFT SENSOR, OXYGEN SENSOR, FUEL FILTER, DISTRIBUTOR, COIL SPARK PLUG WIRES, TIMING GEARING CHAIN, AND FUSES WERE FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED OVER FIVE TIMES, HOWEVER, THE FAILURE RECURRED EACH TIME. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 1999 CHEVROLET EXPRESS G3500. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP, THE BRAKE PEDAL SUDDENLY FAILED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DETERMINED THAT THE BRAKES LINE WERE CORRODED UP TO THE MASTER CYLINDER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 128,000.

BADLY RUSTED FRAME. *TR