2007 Chevrolet Corvette

Defect. General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.

Risk. The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.

Remedy. GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.

Defect. GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.

Risk. IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.

Remedy. DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.

A mismatched gear indicator where the dashboard shows "Park" but the transmission is actually in "Reverse" is dangerous that creates a severe rollaway risk.When this first happened I pulled into my garage and put the car into park and took my foot off brake and with out me realizing the car was moving backwards I nearly ran over someone. Could've been very serious.I had the vehicle inspected at the dealer and told them this is serious safety issue, they said they could do nothing about it because the car was no longer under warranty. the car has about 14000 miles on it.

The contact owns a 2007 Chevrolet Corvette. The contact stated that while the vehicle was parked at the residence, after exiting the vehicle, the contact became aware of an abnormal fuel odor inside the vehicle. A dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that a special coverage had expired. The failure mileage was 11,500.

Fuel smell - possible fuel leak - the issue had been previously addressed with replacement of fuel subassembly in both saddle tanks. I believe that it is happening again ...

There was a strong fuel smell after the last 2 times I drove it. I took it to the shop and they tell me the evap canister was saturated and the fuel pump had small cracks in it likely seeping when the car heats up. I am having the fuel pump replaced, the evap canister and several seals/hoses in hopes it won't leak again.

After filling the tank with fuel, I was immediately aware of a strong smell of gas. I am always extremely careful not to overfill causing any fuel to escape. The heavy smell/escape of fumes is such that the car simply can’t be put in my garage. The risk of igniting and fire is a risk that is unacceptable. General Motors knows about this issue as they did notify me in 2017 that my car could have this condition and that if it did, they would fix it at no charge. I didn’t have the issue at that time so didn’t take the car in. So, now that I the problem, I have taken the car to Bradley Chevrolet in my town, Lake Havasu City, AZ and am told that in order to inspect the car for this issue, I will have to pay for 10 hours of labor ($2200) and only then will they see if they can find a new tank at another dealer. You see, GM no longer makes or has the tanks (according to their parts department). I have contacted their Customer Service Department and have a Case (#[XXX]). I am told that they will not participate going forward unless I spend the $2200 and then if they can’t find a new tank, they will put the car back together and send me home with it! It’s my belief that since this is a documented safety defect resulting in an apparent fire hazard that they would/should take care of it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fuel smell but no leaks detected, can't store car in garage because of fumes. Worried when driving a fire will occur Had a service bulletin 150682 special vehicle adjustment, need help.

Fuel smell inside and outside when car is parked.

The contact owns a 2007 Chevrolet Corvette. The contact stated while starting the vehicle, there was a loud creaking and popping noise coming from the sunroof. The dealer was contacted; however, the vehicle was not repaired. The contact was concerned about the safety of the vehicle. The manufacturer was made of the failure and advised the contact to reach out to NHSTA Hotline for assistance. The failure mileage approximately was 22,000.

The fuel tank leaks after filling with fuel, resulting in gas vapors filling the garage. This is a known issue with many C6 corvettes. May result in a fire or explosion

Fuel pump had hairline cacks on top. Gas leak under pressure. Strong fumes while in garage. Gas leaks down on exhaust pipes

There is a strong smell of gasoline coming from the outside of the car. It is strongest once the car has been sitting in my garage overnight. Some evidence of fuel under the car.

There is a fuel leak most likely coming from the fuel pump or gasket from within the 2 gas tanks. Gas fumes are building up in my garage causing a horrible smell. Very dangerous please do something about this. Chevrolet has no recalls for this common problems.

Strong fuel smell inside car as well as in garage. Drivers side tank does appear to have a leak when filled. Doing a search online it appears this is a common issue with this vehicle and that a recall/repair was created for owners however my 2007 (not the original owner) I suspect has since expired. In my opinion any defects that puts the owner and personal property at risk should be covered regardless of age.

Strong smell in car of gasoline and around car

We are having an issue with our vehicle leaking fuel on left side fuel tank. The vehicle is constant smell of gas on that left side. It has been a safety concern for us and the dealer wants us to pay at least $1200 just for diagnostic alone. There was a Special Coverage Adjustment for this issue but we were never notified. The notice is Special Coverage Adjustment 15682. I spoke with GM/Chevrolet Customer Assistance and spoke with [XXX] he said I would have to get diagnostic and that the fee could be applied to repair. I understand there is a time limit on most things but it seems that something that relates to safety issue should not have and end date. This is a type of car that most people just have as a collector car and you can see by the low miles that this is the case. I am not trying to get a repair on a vehicle that has 100,000 or more miles. It may seem trivial but this is important to me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Very strong fuel smell from driver side wheel well and inside of car. When car is parked inside garage it is unbearable.

For last 3 years whenever I fill my vehicle with gas the garage smells of gas until the tank is less than half a tank... The other major issue is the vehicle will not come out of park multiple time. This has put me in embarrassing situations many times. I stay away from driving the vehicle so many times when I could be in physical danger .

The Body Control Module has failed and there are no replacement parts available except used parts. The BCM is hard coded with the VIN. If you use a BCM from another car, certain safety systems are deactivated such as the air bags. The BCM is central to the electronic architecture so all other systems are at risk. The unit can be responsible for the car not starting, the headlights not working, the power windows and door locks failing, or in my case the active suspension not functioning. Since BCM's are widely used, this is a looming major safety issue for the nation because GM quit making new ones, no one else makes these parts, no one can repair the units. I know a number of C6 Corvette owners are using used parts which deactivates the air bags and the security system.

I started smelling gas from my car two weeks ago. I discovered on Corvette Forum.com that this is a common problem. If the car is filled up over 1/2 tank gas will come out of the top and drip on the exhaust, which is very concerning. Chevrolet claims that the cars with this issue were recalled, but mine was not. This is one of two reoccurring issues with the C6 Corvette, and unfortunately, I am a victim of both. The other is the shifter locks in place, and the car will not come out of park. Chevrolet does not own up to the responsibility for this defective engineering as well. Please add me to the complaints for these two recallable issues as Chevrollet refuses to address the issue. Fuel dripping on the exhaust preplexes me why NHTSA has not got involved already.

There is a very strong fuel odor coming from the car when I shut it down, especially when I park in the garage. The smell is overwhelming. Seems like it's coming from the rear part of the car, drivers side. I don't see fuel leaking nor on the garage floor, but it is very evident there is a problem. This is a safety issue that needs to be addressed. thank you