2015 Audi S6

Defect. Volkswagen Group of America, Inc. (Audi) is recalling certain 2013-2017 A8, S6 Sedan, S7, S8, and 2014-2017 RS7 vehicles. The turbocharger oil supply strainer can become blocked, causing wear to the bearings due to lack of lubrication.

Risk. Worn bearings can cause the turbine wheel to contact the turbocharger housing or cause the shaft to break, causing an engine stall and increasing the risk of a crash.

Remedy. Dealers will replace the oil strainer and perform an oil change, free of charge. Owner notification letters were mailed August 4, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 21H7.

Defect. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2018 Audi S6 and S7, 2012-2018 A7 and A6 Sedan, and 2014-2018 RS7 vehicles equipped with basic seats (with or without heating). Stress or wear of the body-sensing mat within the front passenger seat may cause the Passenger Occupant Detection System (PODS) control module to malfunction.

Risk. If the PODS module malfunctions, the front passenger air bag may not deploy properly in the event of a crash, increasing the risk of injury.

Remedy. Volkswagen will notify owners, and dealers will install a PODS system repair kit, free of charge. The recall began November 29, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74D5.

Steering Module went out for no apparent reason. I was able to find a used one and have it repaired for just under $1000. I had git two quotes for to auto shops that specialize in Audi repairs and they were both over $5300 to repair this steering module. This is unacceptable.

Turbos blew causing the vehicle to lose power while trying to merge in traffic.

Multiple turbo failures. Engine shook violently then suddenly stopped in the middle of the road. This same issue happened 3 times affecting both turbos. It may be due to faulty oil filter/strainer. From online research (link below) this is a common problem for C7 Audi s6. https://www.audizine.com/forum/showthread.php/851578-2016-S6-4-0T-Turbo-Failure

I WAS DRIVING DOWN THE HIGHWAY AND MY SUNROOF EXPLODED. THERE WAS A LOUD BANG AND I SAW AND FELT AIR AND DEBRIS COME IN THROUGH MY SUNROOF VISOR VENTS. WHEN I PULLED OVER AND GOT OUT OF THE CAR I SAW MY SUNROOF HAS EXPLODED. I SAY EXPLODE BECAUSE IT IS CLEARLY VISIBLE THAT THE SUNROOF IS BROKEN FROM THE INSIDE OUT. THERE WERE NO TRUCKS AROUND TO KICK UP DEBRIS AND IT WAS NOT HIT BY A ROCK. AUDI STILL CLAIMS NO FAULT EVEN THOUGH THERE WERE CONSUMER REPORTS ARTICLES AND RECALLS DONE ON OTHER MODELS. LUCKY FOR ME MY SUNROOF VISOR WAS CLOSED IF IT WAS NOT I WOULD HAVE BEEN RAINED DOWN ON BY THOUSANDS OF SHARDS OF GLASS CAUSING A SAFETY ISSUE. THE GLASS EXITING THE VEHICLE HAS SCRATCHED THE ROOF AND TRUNK LIKE A SHOTGUN BLAST. AS IT IS THE SOUND OF THE SUNROOF EXPLODING WAS ENOUGH TO STARTLE MANY PEOPLE INTO AN ACCIDENT. IT IS A SHAME THIS STILL GOES ON TODAY AND AUDI DOES NOT WANT TAKE RESPONSIBILITY FOR THIS FAULT. NON-THE-LESS I AM FORCED TO FILE AN INSURANCE CLAIM TO GET THIS REPAIRED.

DRIVING ON THE NEW JERSEY TURNPIKE AND BOTH TURBOCHARGERS FAILED. CAR LOST POWER AND I HAD TO STEER TO SIDE OF THE HIGHWAY WITHOUT POWER STEERING AND BRAKES FROM FAR LEFT LANE. AUDI SERVICE SAYS BEARINGS STARVED OF OIL AND SEIZED. THEY SAID THIS IS A COMMON PROBLEM WITH THE 4.0 TWIN TURBO AUDI ENGINES AND THAT THE OIL FEED LINE GETS BLOCKED AND STARVES THE TURBOCHARGERS OF OIL, RESULTING IN BEARING FAILURE. REPAIR COST IS $9,000. CAR HAS LESS THAN 70,000 MILES. AUDI HAS A TECHNICAL SERVICE BULLETIN ON FILE WITH THE NHTSA THAT SPECIFICALLY ADDRESSES THIS KNOWN PROBLEM. AUDI NORTH AMERICA WILL NOT ASSIST WITH COST OF REPAIRS.