2016 Audi A3

Defect. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.

Risk. A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy. Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.

Defect. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016 Audi TT Roadster, TT Coupe, S3 Sedan, R8 Coupe, A3 Sedan, A3 Etron, A3 Cabriolet, 2016 Golf Sportwagen, Golf R, Golf GTI, Golf A7, and E Golf vehicles. During air bag deployment, the front passenger air bag may explode or deploy improperly.

Risk. An inflator explosion may result in sharp metal fragments striking occupants, resulting in serious injury or death. An improper air bag deployment may not properly restrain the occupant, increasing their risk of injury in a crash.

Remedy. Dealers will replace the front-passenger air bag module, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Audi's customer service at 1-800-253-2834. Volkswagen's number for this recall is 69DY and 61C1.

Defect. Volkswagen Group of America, Inc. (Audi) is recalling certain 2015-2020 Audi S3 Sedan, A3 Sedan, 2016-2018 A3 Etron, 2017-2020 RS3 Sedan, and 2015-2019 A3 Cabriolet vehicles. The passenger occupant detection system (PODS) may malfunction and switch off the passenger air bag even when the seat is occupied.

Risk. A deactivated passenger air bag increases the risk of injury during a crash.

Remedy. Dealers will replace the PODS sensor mat and update the PODS control module, free of charge. Owners letters were mailed December 23, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 69BY.

The contact owns a 2016 Audi A3. The contact stated that the front passenger’s side air bag occupant sensor failed to identify a passenger seat in the seat. A dealer was contacted. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that PODS had failed and needed to be replaced. Additionally, the engine was consuming an excessive amount of engine oil. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 19V474000 (AIR BAGS); however, the VIN was not included in the recall. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 44,000.

Electrical problems and fuel leak

This vehicle was involved in a rear end collision in late 2025. The vehicle was just sold at auction with a clean title even though it has frame damage that is more than 100% of the cost of this vehicle. It is sold with a clean title and I am worried that a used car dealership will try to sell it with no accident history and clean title to an unsuspecting person.

FUEL LEAKED ALL MY GARAGE ALMOST CAUSING A FIRE IN MY HOME WHILE I WAS SLEEPING. I HAVE HAD THE FUEL TANK REPLACED 3 TIMES. AND I HAD TO PAY OUT OF POCKET TO HAVE IT REPLACED BECAUSE AUDI WOULD NOT REPLACE THE RECALL OF IT SO I AM REACHING OUT TO YOU SO YOU CAN REACH OUT TO AUDI ABOUT NOT STANDING BY THE RECALL PROCEDURE!

My 2016 Audi A3 Sportsback E-tron vehicle was parked at my house. When I went to start it the engine did nothing, no power. The message “Driver System Fault” and a red triangle with a red ! in the middle was displayed on the instrument panel. I was unable to start or operate the vehicle. I called AAA and they towed the vehicle to a Recharge Hybrid pump location near my house. I tired to charge the battery and it would just turn off. Then I called AAA again and they towed my car back to my house and checked the small 12 volt battery to see if that was the problem, they determined that the 12 volt battery still had 75% life in it. They were unable to get my vehicle started. The same message is still on the dashboard “Driver System Fault." The failure mileage is approximately 81,567. I want to know before I call the Dealer and get it towed again if this issue is the Hybrid High-Voltage Battery or the housing bonded seam could have lead to corrosion the service recall from a while ago. Service Action Code 93D2

The contact owns a 2016 Audi A3. The contact stated that while the vehicle was parked with the engine running, the vehicle experienced a sudden loss of motive power. During the failure, the message “Driver System Fault” was displayed on the instrument panel. The contact was unable to restart or operate the vehicle. The vehicle was towed to the dealer, where it was diagnosed and determined that the Hybrid battery had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 83,000.

Passenger airbag not activated when passenger is seated

Passenger Occupancy Detection System is malfunctioning. Pre-sense system fault

The rearview camera is failed. Yes I can have an inspection done. Yes, dealer confirmed that camera is failed but wanted hundreds of dollars to troubleshoot. Has not been inspected by police or insurance. No it just stopped working one day.

The rear wiper hose is consistently getting completely clogged so that no fluid comes out when the spray mechanism is engaged. The dealership has replaced it for a fee two or three times. At the last service they told us they cleaned it and did not charge a fee. However, within two months it was clogged again. I have noticed that the issue is more likely to occur after (intentionally or accidentally) using the rear window defroster. I am therefore wondering whether the hose is made of a plastic that is too soft, causing it to change shape as a response to the defroster heat.

Mechatronics unit failed, stalled on freeway nearly caused an accident behind me.

Passenger air bag not working light of airbag system stays on

The contact owns a 2016 Audi A3. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer who diagnosed that the front passenger’s seat air bag sensor had failed and needed to be replaced. The vehicle was repaired under NHTSA Campaign Number: 21V198000 (Air Bags). The air bag warning was illuminated approximately one and a half years later. The vehicle was returned to the dealer who informed the contact that the repair was no longer covered under warranty. The vehicle had not been repaired. The manufacturer was made aware of the failure and a claim was opened. The failure mileage was approximately 67,000.

The **mechatronic unit** (integrated into the S-Tronic dual-clutch transmission) is the primary component that fails. This unit controls gear shifts, clutch engagement, and hydraulic pressure within the transmission. Common failure points include: - Internal electronic control module (ECU) faults. - Malfunctioning solenoids or pressure valves. - Software glitches or calibration errors. **2. Safety Risks** Mechatronic failure poses significant safety risks: - **Erratic Gear Shifts**: Sudden jerks, delayed engagement, or refusal to shift gears could lead to loss of vehicle control, especially in traffic or during overtaking . - **Limp Mode**: The transmission may default to a single gear (e.g., 3rd gear), severely limiting acceleration and braking responsiveness . - **Complete Gear Loss**: Loss of reverse or multiple forward gears increases collision risks during parking or low-speed maneuvers . --- **3. Confirmation by Dealers/Service Centers** Dealers and independent specialists can reproduce and confirm the issue through: - **Diagnostic Scans**: Fault codes like "implausible gear ratio," "valve electrical faults," or "clutch adaptation limits" often indicate mechatronic failure . - **Physical Testing**: Symptoms such as harsh shifting, RPM fluctuations, or transmission warnings (e.g., flashing PRNDS lights) are observable during test drives . - Audi has issued **Technical Service Bulletins (TSBs)** for related transmission issues, though the 2016 A3 e-tron’s mechatronic unit

The contact owns a 2016 Audi A3. The contact stated while driving 60 MPH, the Electronic Power Control System (EPC light) malfunctioned, and the vehicle lost power. The contact stated that the vehicle lost motive power, the temperature gauge raised with the radiator fan activated. The contact pulled over to the side of the road and the vehicle restarted immediately. No warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The vehicle was not repaired. The check engine warning light and the electronic power control system warning light was illuminating on and off. The manufacturer was notified of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

The contact owns a 2016 Audi A3. The contact stated that while the vehicle was parked, there was a strong fuel odor coming from the vehicle, and the vehicle hesitated while starting. Additionally, the contact stated that the failure persisted before starting. The vehicle was driven to an independent mechanic where it was diagnosed that there was an engine misfire and a leak in the fuel pump. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 16V647000 (FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING). The manufacturer was not notified of the failure. The approximate failure mileage was 92,000.

225/45r17 Dry rot on all four tires less than three years old - and actually used for fewer than 18 months as alternated with winter tires - crack runs entire circumference of tire - deep - at joining of sidewall to tread. Nokian has said that this is “cosmetic sidewall cracking” - there is nothing cosmetic about it and each tire dealer I have visited reports that the tires are unsafe and need to be replaced. This is also supposedly a known issue that Nokia has acknowledged but not provided any extra coverage for.

The contact owns a 2016 Audi A3. The contact stated that while refueling the vehicle, fuel started leaking from the vehicle. The contact stated that the vehicle was sputtering while being started. The failure occurred intermittently. There were no warning lights illuminated. The contact removed the EVAP hose and became aware that the hose was filled with gasoline. The contact became aware of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline); however, the VIN was not included. The dealer was contacted and made aware of the failure. The dealer confirmed that there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 95,000.

The contact owns a 2016 Audi A3. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine and low oil warning lights illuminated. The contact also became aware that there was fuel leaking from the charcoal canister. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer and was diagnosed and determined that the evaporative emissions and charcoal canister needed to be replaced. The contact was informed that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unavailable.

Audi continues to tell me that this recall has been completed yet Audi’s website clearly states of the recall has not been completed your website. States of the recalls not completed and car fractures that recalls not been completed. Yet they refuse to complete the recall in my car.