1998 Prevost H3-45

Defect. ON CERTAIN MOTOR COACHES AND MOTOR HOMES, THE STEERING COLUMNS MAY BE MISSING THE LOWER BOLT AND NUT. A REPLACEMENT BOLT AND NUT WAS INSTALLED TO CORRECT THIS SITUATION ON THE PRODUCTION LINE. IF A REPLACEMENT BOLT HAS BEEN USED AND NOT TIGHTENED PROPERLY, THE COLUMN MAY COME OUT OF THE INPUT SHAFT WHEN THE STEERING COLUMN ADJUSTMENT MECHANISM IS USED.

Risk. IN SUCH A CASE, A LOSS OF STEERING WOULD OCCUR.

Remedy. DEALERS WILL VERIFY THE SIZE OF THE BOLT AND NUT AND REPLACE THEM IF NEEDED. OWNER NOTIFICATION BEGAN APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PREVOST AT 1-418-831-5432.

Defect. VEHICLE DESCRIPTION: TRANSIT COACHES. THE REINFORCEMENT BRACKETS WERE NOT WELDED ON THE TAG AXLE.

Risk. THIS CONDITION COULD RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL WELD THE BRACKETS ON THE TAB AXLE.

Defect. VEHICLE DESCRIPTION: TRANSIT COACHES. IF A FRONT COLLISION SHOULD HAPPEN, THE EMERGENCY EXIT WINDOW WOULD UNLOCK IF THE WINDOW STOPS STRIKE THE LOCKING LEVERS AND BREAK THEM, DUE TO A RELATIVE DISPLACEMENT BETWEEN THESE PARTS.

Risk. A VEHICLE OCCUPANT COULD BE INJURED.

Remedy. DEALERS WILL CUT THE TOP OF THE STOP.

Defect. VEHICLE DESCRIPTION: TRANSIT BUSES. THE BOLTS FIXING THE RADIUS ROD LOCKING TAB PLATES WERE NOT LUBRICATED BEFORE BEING TIGHTENED.

Risk. IMPROPER TIGHTENING CAN CAUSE LOOSENING OF THE ATTACHMENT OVER A PERIOD OF TIME INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

Remedy. DEALERS WILL INSPECT THE BOLTS, LUBRICATING THEM, INSTALLING A NEW LOCKING TAB PLATE, AND RETIGHTENING THE BOLTS.

Defect. VEHICLE DESCRIPTION: TRANSIT COACHES. THE ALTERNATOR AND BATTERY CABLES WERE NOT PROPERLY INSTALLED.

Risk. THIS CONDITION CAN CAUSE THE NUTS TO LOOSEN OVER A PERIOD OF TIME CAUSING A SHORT CIRCUIT AND POSSIBLE FIRE HAZARD.

Remedy. DEALERS WILL INSPECT, REMOVE AND RE-INSTALL THE ALTERNATOR AND BATTERY CABLES.

Defect. VEHICLE DESCRIPTION: TRANSIT BUSES WITH DRIVE AXLE EQUIPPED WITH DRUM BRAKES ONLY. THE DESIGN OF THE DIFFERENTIAL CROSS-MEMBER REINFORCEMENT CAN CRACK UNDER CERTAIN APPLICATIONS.

Risk. THIS CONDITION COULD REDUCE THE STEERING CAPABILITY MAKING IT DIFFICULT FOR THE DRIVER TO DO ACCURATE TURNS.

Remedy. DEALERS WILL INSTALL TWO OTHER REINFORCEMENTS TO SOLIDIFY THE CROSS-MEMBER ASSEMBLY.

TL-THE CONTACT OWNS A PREVOST H345 BUS. THE CONTACT STATED THAT ALL OF THE TIRES ON THE VEHICLE HAVE BLOWN OUT. THE MILEAGE ON THE TIRES IS 1,000. HE STATED THAT THERE WAS TREAD LEFT ON THE TIRES. THE TIRES DID NOT IMPACT ANYTHING LIKE A POTHOLE,ETC. THE TIRES WERE SENT TO CONTINENTAL IN MT VERNON,IL. THE CONTACT STATED TO ME LATER THAT SOME INFO THAT WAS NEEDED , HE COULD NOT SUPPLY BECAUSE THEY HAVE A FLEET OF BUSES. LM