2015 Mini Cooper

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop 2 door vehicles manufactured February 25, 2014, to May 16, 2015, 2014-2015 MINI Cooper S Hardtop 2 door vehicles manufactured March 28, 2014, to May 9, 2015, 2015 MINI Cooper Hardtop 4 door vehicles manufactured October 17, 2014, to June 2, 2015, and 2015 MINI Cooper S Hardtop 4 door vehicles manufactured November 24, 2014, to June 11, 2015. During a service appointment, the affected vehicles received replacement front passenger seat cushions (which contain integral Capacitive Interior Sensing (CIS) functions). The CIS functions may have been incorrectly calibrated, and if so, would cause impaired occupant classification and thus inappropriate air bag activation/deactivation.

Risk. Inappropriate air bag activation/deactivation can increase the risk of occupant injury in the event of a vehicle crash.

Remedy. MINI will notify owners, and dealers will inspect and, if necessary, replace the front passenger seat cushion, free of charge. The recall began on December 28, 2015. Owners may contact MINI customer service at 1-866-825-1525 .

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2014-2016 MINI Cooper S and MINI Cooper two-door vehicles, 2015-2016 MINI John Cooper Works and MINI Cooper S and MINI Cooper four-door vehicles and 2014-2015 BMW i3 vehicles. Due to a manufacturing error, the passenger frontal air bag may not deploy properly in a low speed crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Risk. In the event of a vehicle crash, an air bag that does not deploy properly increases the risk of injury to the front seat passenger.

Remedy. MINI and BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began on November 25, 2015. Owners may contact MINI customer service at 1-866-825-1525 and BMW customer service at 1-800-525-7417.

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper and MINI Cooper S Hardtop 2 Door vehicles and 2015 MINI John Cooper Works Hardtop 2 Door vehicles. The affected vehicles do not meet the side impact performance requirements for the rear seat passengers. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection."

Risk. If the side impact performance requirements are not met, rear seat passengers may be at a higher risk of injury during a crash.

Remedy. MINI will notify owners, and dealers will install additional energy absorption material between the rear interior side panels and the exterior vehicle body, free of charge. The recall began on September 4, 2015. Owners may contact MINI customer service at 1-866-825-1525. Note: this recall supersedes 14V-815.

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop two door vehicles manufactured December 1, 2013, to December 14, 2014. The affected vehicles may have been manufactured with an incorrect maximum capacity weight stated on the Tire Information Placard. Thus, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 110, "Tire Selection and Rims and Motor Home/Recreation Vehicle Trailer Load Carrying Capacity Information for Motor Vehicles with a GVWR of 4,536 kilograms (10,000 pounds) or less."

Risk. The maximum weight listed on the label is incorrect (too low) and therefore does not comply with Federal Regulations.

Remedy. MINI will notify owners, and dealers will replace the incorrect labels with corrected labels, free of charge. Owners were mailed interim notification on March 18, 2015. The recall began on October 15, 2015. Owners may contact MINI customer service at 1-866-825-1525.

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2014-2015 MINI Cooper Hardtop 2 Door, and Cooper S Hardtop 2 Door vehicles manufactured January 6, 2014, to October 17, 2014. During service appointments, dealers may have inadvertently reprogrammed the transmission control unit with software that may allow drivers to exit the vehicle when the transmission is not in Park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 114, "Theft Protection and Rollaway Prevention."

Risk. If the driver exits the vehicle without the transmission being in Park, the vehicle could roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy. MINI will notify owners, and dealers will reprogram the transmission control module with the correct software, free of charge. The recall February 4, 2015. Owners can contact MINI customer service at 1-866-825-1525.

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2015 MINI Cooper Hardtop 2 Door vehicles manufactured August 12, 2014, to September 2, 2014. In the affected vehicles, the driver and front passenger seatback adjustment mechanism may not be fully engaged.

Risk. If the seatback adjustment mechanism is not fully engaged, the seatback may fold during a rear impact collision, increasing the risk of injury to the seat occupant.

Remedy. MINI will notify owners, and dealers will re-align and re-tighten the seatback adjustment mechanisms, free of charge. The recall began December 29, 2014. Owners can contact MINI customer service at 1-866-825-1525.

Anytime the wipers are on and the speed is above 50 mph, this car periodically applies the brakes to keep the rotors dry. It's an automated system that BMW's and Mini's have. However, for some reason, the vehicle now pulls hard to the right, which veers the car into the other lane. The brake pads and rotors are all new. The tires are new and the alignment is good. The brake fluid was just changed and bled. There is literally nothing wrong except for this bizarre system which is now only applying some brake pressure to the front right rotor. The car slows and pulls right suddenly without applying the brake lights. I'm worried I will get rear ended or side swipe somebody. I've resorted to using Rainx and not using the wipers or simply avoiding driving in the rain. This is a serious issue that should be a recall. Thank you!

On my 2015 MINI Cooper Hardtop 4 Door (VIN: [XXX]), the driver's side halogen headlight suddenly stopped working. When I attempted to replace the bulb, I discovered that the headlight connector/pig tail had melted on one side, one of the electrical wires had burned completely through, and there was a strong odor coming from the rear of the headlight assembly. This was not simply a burned-out bulb. The connector and wiring sustained heat damage that appears to have resulted from an electrical failure. Because of the melted connector, burned wiring, and strong burning small, I believe this created a potential fire hazard. It must be noted that there have not been any changes to the lighting or electrical system since purchasing my car and I am the first and only owner. I contacted my mini dealership and was informed that the connector is not available separately for my year, make, and model for my car and the only option is the purchase the entire headlight assembly. The cost for the assembly is $615 and while the exact charge for labor is not known at this time, from my experience, it will be between $200-$500. After researching his issue. I found reports from other MINI owners describing similar failures involved melted headlight connector and burned wiring on vehicles with halogen headlights. Based on these reports and my own experience, I am cornered this may represent a recurring safety-related defect rather than normal wear and tear. I am submitting this complaint so NHTS

Selector lever wrongly not locked in park. Put up a code for transmission (egs). I believe it falls under the transmission control unit recall on mini coopers 2 door hardtop.

Lower Engine Support and Passenger Engine Mount damaged as per routine inspection by dealer in Feb2025. Never diagnosed before. Repair done by independent service center in Feb2025 and I have receipt of approximately 1K. Also, since 22feb2025, I am not able to add fuel to the tank because the pump stops constantly and causes spill of fuel. This can cause fire. Never happened before. Tried at least 4 different gas station and same result. Dealer charges over $200 to perform inspection/diagnostics. Not done yet. Repairs to fuel tank are in the thousands. No warning in the car dashboard for none of the issues. Car with less than 80k miles.

While driving the rear view mirror suddenly tilted downward (drooped). What happened, was that the tension ring popped off. As it turns out, this is a known issue per internet Mini Cooper pages. On hot days the ring loosens and, since the design does not include anything to prevent the ring from sliding off, it does slide off, resulting in the rear view mirror drooping. I reinstalled the ring. This occurred again the next day. I ended up uninstalling the rear view mirror, reinstalling the ring and gluing it in place. Thus far this has held.

The contact owns a 2015 Mini Cooper. The contact stated that while driving at an undisclosed speed, the rear convertible glass suddenly separated from the convertible compartment and fell on the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or local dealer. The contact stated that while searching online, he became aware that the failure had been a very well-known failure since 2017 with similar vehicles. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 62,000.

The sensors do not work. The car does not tell me when oil is needed, when my tires are low. No sensors work in the car. The dealer, Mini Of Edison, states FOUND INTERNAL HARDWARE FAULTS. But are stating its costs 2300.00 to fix. This is a huge safety issue.Ive been having to guess when my oil is low and when my tires are low. This has been going on since September 2023, the car was only bought in May 2023.

The fuel filling nozzle turns off repeatedly while trying to fill the fuel tank and spills out causing a safety and environmental hazard, regardless of the pump being used. As a result, no fuel goes into the gas tank, instead it goes all over the car and the ground.

What component or system failed or malfunctioned, and is it available for inspection upon request? CONTROL ARMS AND BUSHINGS How was your safety or the safety of others put at risk? CONSTANT CREAKING AND CLUNKING OF FRONT SUSPENSION Has the problem been reproduced or confirmed by a dealer or independent service center? MANY OTHER OWNERS OF THE SAME YEAR AND GENERATION HAVE THIS SAME ISSUE Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NOT YET Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO

Without any warning lamps,The vehicle started pulling left when the brakes were applied a certified mechanic looked at it and feels that is the due to a defective DSC/ABS control unit. The unit hasn't been otherwise inspected but is available for inspection

Fuel tank causes gas pump to click off after dispensing a tenth gallon of gasoline. Gas spills from gas tank while removing pump creating a safety and environmental hazard. Fuel tank will not accept gas at pump. No warning lamps, messages, or symptoms were present prior to the failure. Mini Cooper dealership stated that service valve in tank has failed and entire fuel tank must be replaced.

While driving on freeway in 109 degree temp the service engine light came on. Proceeded with trip home (approx 2 hrs). Made a service appt online with Mini of Stevens Creek which was for 3 days later. Upon inspection it was found that vehicle had multiple problems. Service Advisor would not allow me to drive vehicle home while awaiting parts that were on B/O. Estimated it could be as long as 2 months before repaired because there were 391 units coming in next delivery but my vehicle was number 403 on the list requiring this part and would have to wait for the following months delivery. I was quite alarmed of the repairs needed since my vehicle has <28,000 miles and well maintained.

The contact owns a 2015 Mini Cooper. The contact stated that after the vehicle was taken to a local dealer for a routine oil change, the mechanic also determined that the valve cover gasket needed to be replaced and an unknown engine software needed to be updated. The vehicle was not repaired. The manufacturer was made aware of the failure, and the contact was advised to file a complaint with the NHTSA Hotline. The approximate failure mileage was 78,000.

The horn does no longer work. Had to press harder and harder on the horn button and in different places as time went on. Also have the same problem in a 2005 Mini Cooper.

When refueling, fuel is rejected after dispensing about 1/8 US gallons, about 4 oz. Of course, fuel spills are a hazard - both in possibly of fire, and to the environment - by contaminating ground water. Dealer said that there are several solenoid operated valves and replaced fuel tank and fill pipe, a cost to me of $2400.00. There are many reports of this on social media, one person suggested holding the fuel nozzle upside down which made a larger spill.

When refueling, nozzle kept shutting off, a gallon was pumped after nine attempts, also fuel erupted as the fill tube was filled with gas. reluctant to drive this car not knowing how much gas is in the tank. The needle shows less than 1/4 and miles remaining fluctuates between 80 and 110 miles. We are told that this problem exists in many mini automobiles, dealer has replacement gas tanks, but same problem exists Parking our Mini, indication of "roll back" is possible when car is parked. Shifter unit was replaced due to torsion spring.

The proportioning value that controls brake function had a catastrophic failure and caused the brake calipers especially the left front to lock suddenly. The caused the left front wheel to lock and caused the car to pull hard to left and become difficult if not impossible to control. The car pulled hard left and risked the car moving uncontrollably into on coming traffic. The failed part was saved and is available for inspection. The safety of the driver(my wife) was put at risk during the loss of control of the car. Other cars in the area were also put at risk simply due to the loss of control of our car. The problem was confirmed by the independent service center. The vehicle was not drivable and was towed to the dealership. The dealership thought the root cause was the brake master cylinder. This turned out not to be the case. The root cause was the failed proportioning valve. This caused the calipers to lock. The discs, rotors, calipers and proportioning value were replaced. There were no warning lights and the car had been taken for regular service at the dealership which was included in the purchase of the car. We were told that there is no warning light for a failure of this part.

On display I am getting warning " secure vehicle with parking brake when stationary" whereas my car is in park position with hand brake applied. The warning still shows up. The gearbox works fine the car drives fine. Its the warning that doesn't seem to go away. On diagnostics is shows code "420106" . DEFECTIVE GEAR SHIFT LEVER SPRING

On July 12 early morning hours I left Maryland drove to Augusta GA and continued on to Decatur GA totaling 704 Miles. Within an hour of me arriving to Atlanta, I attempted to leave the house again and the car would not crank. I had it towed to Global Mini there in Chamblee, GA. The key stopped communicating with the car, and I was asked to give them my spare key-I did not travel with my spare key and the key fob design does not have a replaceable battery per the dealership the fob is designed to charge while driving. I had to pay for someone to overnight my second key-which did crank the car. I had to purchase another key and I had to rent a car until they ordered another key to have sent to the dealer because the dealer does not make keys. This is a safety issue because i made several stops for gas and restroom breaks and what if this happened in the middle of nowhere? It was a scary situation and I feel that we should have been notified as owners that this could be a possible event. I purchased this vehicle brand new in 2015.

The fuel filling nozzle turns off repeatedly while filling the fuel tank, regardless of position of nozzle, pressure used, station used. In an attempt to remedy, Mini Service Technicians replaced tank vent valve but it did not correct the issue. I am unable to fill my gas tank.