2002 Mini Cooper

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.

Risk. If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.

Remedy. MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.

Defect. DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Defect. K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Defect. CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE STANDARD REQUIRES THAT THE RELATIONSHIP BETWEEN THE TIRE SIZE AND MAXIMUM TIRE PRESSURE BE INDICATED ON THE VEHICLE'S TIRE INFORMATION LABEL. THIS RELATIONSHIP IS NOT PRESENT.

Risk. TOO LOW OR TOO HIGH TIRE PRESSURE CAN CAUSE PREMATURE WEAR AND/OR TIRE DAMAGE, AND COULD LEAD TO UNFAVORABLE DRIVING CONDITIONS.

Remedy. OWNERS WILL BE PROVIDED WITH NEW TIRE INFORMATION PLACARDS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT MINI AT 1-866-275-6464.

Defect. ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE TRANSMISSION SHIFT CABLE CONNECTS THE GEARSHIFT LEVER IN THE VEHICLE INTERIOR TO THE SHIFT LINKAGE ON THE TRANSMISSION. IT IS POSSIBLE FOR THE SHIFT CABLE TO DETACH FROM THE TRANSMISSION SHIFT LINKAGE WHILE THE DRIVER IS ATTEMPTING TO CHANGE GEARS. IF THE CABLE DETACHES FROM THE SHIFT LINKAGE, GEAR CHANGES WILL NO LONGER BE POSSIBLE AND THE TRANSMISSION WILL REMAIN IN THE LAST GEAR SELECTED.

Risk. IF SHIFT CABLE DETACHMENT OCCURS AND THE TRANSMISSION REMAINS IN ANY FORWARD GEAR, THE VEHICLE CAN STILL BE DRIVEN IN THAT GEAR ONLY. HOWEVER, IF THE TRANSMISSION MOVES INTO NEUTRAL AND REMAINS THERE, THE ABILITY TO ACCELERATE OR MAINTAIN SPEED WILL BE LOST, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL INSPECT THE SHIFT CABLE AND, IF NECESSARY, INSTALL A RETAINING CLIP OVER THE END OF THE SHIFT CABLE TO PREVENT IT FROM DETACHING FROM THE TRANSMISSION. OWNER NOTIFICATION BEGAN AUGUST 6, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-866-ASK-MINI (1-866-275-6464).

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.

Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.

Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It was night, I was sitting in middle of my lane, unable to start Mini. Good samaritans helped push it into parking lot while waiting for assistance. After 15 minutes, car started and was driven home. I had slight injuries from being hit by hard material projectiled across cabin. Very thankful I was the only occupant because if a passenger had been in the seat, they would have most definitely sustained injuries. I had to cut the airbags out in order to have clear lines of sight before driving the following day. I’m fearful that the drivers side air bags may do this as well. I have owned this vehicle since 2004. Not aware of history prior to 2004;(accidents, original airbags?). only know it came from a Dealer in CA. (Possibly “Friendship” may be name of town or dealership). I have not had repairs made yet. I don’t drive this vehicle daily. There are no police reports since there was no need. No insurance claims since 2002 model. There were no malfunctions with the warning light prior to incident. However, the following day when I drove, the airbag indicator light came on for passenger side. I did not find a recall but not sure if I would for a 22 year old vehicle.

MY MINI COOPER NEEDS RECALL WORK DONE. I AM IN BILLINGS, MT AND 392 MILES FROM THE CLOSEST CERTIFIED PLACE TO GET IT REPAIRED. I CAN'T TRAVEL THAT FAR IN A 2002 VEHICLE WITH HIGH MILES DURING A PANDEMIC. I AM A SENIOR CITIZEN AND HAVE ISSUES THAT DO NOT ALLOW ME TO TRAVEL THAT FAR. I AM STUCK WITH A VEHICLE THAT MAY HAVE A POTENTIAL STEERING ISSUE WITH NO WAY TO RESOLVE IT. I NOW CAN'T SELL THIS VEHICLE EITHER BECAUSE IT WOULD BE MORALLY WRONG TO PASS THIS PROBLEM ON TO A NEW OWNER. I CAN'T AFFORD THIS KIND OF SAFETY AND FINANCIAL PROBLEM. I NEED HELP TO GET THIS WORK DONE AND MINI COOPER CALLED ME AFTER MY INQUIRY AND SAID I AM BASICALLY OUT OF LUCK. THEY HAVE NO RESOLUTION FOR ME OR ANY OTHER MINI COOPER OWNERS THAT LIVE IN RURAL STATES AND ARE NOT NEAR A CERTIFIED DEALERSHIP. I NEED THIS REPAIRED AND AM HOPING YOU CAN HELP ME AND ALL THE OTHER MINI COOPER OWNERS IN THIS DANGEROUS SITUATION. THE NUMBER THE MINI REPRESENTATIVE CALLED ME FROM WAS 800-831-1117.

SO I BOUGHT A 2002 MINI COOPER LESS THAN A YEAR AGO AND IT CURRENTLY HAS 74K MILES AND ATTEMPTING TO PULL INTO A PARKING SPOT AT THE GROCERY MY STEERING GOES COMPLETELY OUT WHILE I WAS TRYING TO TURN INTO MY SPOT AND RIPPED OFF A BLACK MOLDING THAT GOES OVER THE FRONT PASSENGER WHEEL AND A SIGNIFICANT DING AND SCRATCH.

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. THE CONTACT, A CERTIFIED MECHANIC, DIAGNOSED THAT THE STEERING PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WATER WAS ENTERING THE VEHICLE FROM THE SUN ROOF, WHICH CAUSED THE COMPUTER IN THE VEHICLE TO GET MOIST AND NOT OPERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF RUBBER CONNECTOR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING 15 MPH OUT OF A PARKING LOT, THE VEHICLE MADE A LEFT TURN AND THE GEAR SHIFTER FAILED. IN ADDITION, THE GEAR SHIFTER CABLE DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V201000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

AT 140,000 MILE: + AIR BAG LIGHT CAME ON. DEALER SAID THAT THE AIRBAG COMPUTER MODULE WILL COST $1,000 TO REPLACE. I SEE ON-LINE BLOGS AND NHTSA HAVE HAD NUMEROUS COMPLAINTS ON THE AIR BAG DASH LIGHT COMING ON AND NHTSA IS STILL INVESTIGATING.

ABS DASH LIGHT AND BREAK LIGHT SUDDENLY CAME ON. IN ADDITION TO THE AIR BAG LIGHT THAT SUDDENLY CAME ON, THE DEALER SAID THE COMPUTER MODULE FOR THE ABS WILL COST $1,000 (IN ADDITION TO THE AIRBAG MODULE OF $1.000). I SEE ON INTERNET BLOGS AND NHTSA THAT THIS IS A COMMON INCIDENT TOTAL AIR BAG AND ABS COST WILL BE $2,000

THE DASH LOW TIRE AIR LIGHT SUDDENLY CAME ON; IT COMES ON AFTER DRIVING FOR ABOUT 5 MINUETS. I'VE CHECKED ALL TIRES AND THEY ARE IN COMPLIANCE. I SEE THAT ON-LINE BLOGS THIS IS A MAJOR ISSUE

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE POWER STEERING WOULD SUDDENLY MALFUNCTION CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE POWER STEERING PUMP HAD OVER HEATED CAUSING THE POWER STEERING FLUID TO EVAPORATE. THE CONTACT INDICATED THAT SINCE 2012 THE POWER STEERING PUMP HAD BEEN REPLACED FIVE SEPARATE TIMES AND RECENTLY WITH THE NEW REDESIGN PUMP BUT THE VEHICLE CONTINUED TO HAVE THE SAME FAILURE OCCUR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 30,000.

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE ELECTRONIC LEARNING MODULE AND THE PYRAMID WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT SEVERAL COMPONENTS WERE REPLACED DUE TO MANUFACTURER DEFECTS. THE GEAR LEVER, TRANSMISSION, BRAKE PEDAL, MOTOR, CLUTCH, FRONT AND REAR AXLES, AND THE ACCELERATOR PEDAL POSITION SENSOR WERE ALL REPLACED. THE FAILURE MILEAGE WAS 118,457.

THE VEHICLE WAS PURCHASED USED IN 2011, SOON THERE AFTER THE AIR BAG LIGHT CAME ON, IT WAS TAKEN TO A LOCAL REPAIR SHOP AND THE AIR BAG LIGHT WAS RESET, I WAS ADVISED BY THE SHOP OWNER THAT THIS IS A COMMON PROBLEM IN THE OLDER MINI. HE ALSO ADVISED THAT IT IS EXTREMELY EXPENSIVE, AS MINI USA BASICALLY THROWS ALL NEW PARTS AT IT AT THE OWNERS EXPENSE WITHOUT REALLY GETTING TO THE BOTTOM OF THE PROBLEM. THE AIR BAG LIGHT ILLUMINATED AGAIN IN JULY OF 2015, RIGHT AFTER I HAD RETURNED FROM VACATION, APPARENTLY THE PARKING VALET HAD SLID THE SEAT BACK AND MOST LIKELY STRETCHED THE AIR BAG SEAT HARNESS. THIS IS A PROVEN DEFECT WHICH MINI USA HAS FINALLY ADDRESSED WITH A RECALL OF 2005 TO 2008 MODELS ONLY. IT IS RELATED TO A FAULTY SEAT HARNESS THAT CANNOT DETECT WHETHER A PASSENGER IS IN THE RIGHT SEAT. IT IS ALSO BEEN SHOWN THAT IN MOST CASES THE AIRBAGS WILL NOT DEPLOY IN AN ACCIDENT.

DRIVING CAR NORMALLY WHEN POWER STEERING WENT OUT CAUSING A GREAT DEAL OF LOSS OF VEHICLE CONTROL, MAKING TURNING VERY DIFFICULT. ENDED UP SWERVING INTO OTHER LANE, FORTUNATELY NO CARS WERE IN THE LANE AT THE TIME. HAD TO RE-START VEHICLE TO GAIN STEERING BACK. HAS HAPPENED NUMEROUS TIMES SINCE THIS DATE. MINI USA KEEP DODGING THE ISSUE FOR A FULL ON RECALL, INSTEAD EXTENDING THE WARRANTY, BUT MY VEHICLE MISSED THE WARRANTY BY 3 MONTHS SO THEY WILL NOT REPLACE WITHOUT A HEFTY AMOUNT OF MONEY INVOLVED.

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE TRANSMISSION FAILED ON THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE AND STATED THAT THE TRANSMISSION WAS FAILING. THE VEHICLE WAS NOT REPAIRED. WHILE DRIVING HOME, THE TRANSMISSION SEIZED. THE VEHICLE WAS THEN TOWED BACK TO THE DEALER, WHO DETERMINED THAT THE DRIVE SHIFT CABLE FAILED. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 02V201000 (POWER TRAIN). HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 136,000.

POWER STEERING PUMP IS VERY LOUD WHEN TURNING THE VEHICLE. CAN BE VERY HARD TO TURN WHEEL AT TIMES AND SOMETIMES THE POWER STEERING HAS CUT OUT WHILE DRIVING. MINI HAS A RECALL BUT WONT FIX FOR ME. *JS

EVER SINCE BUYING THIS CAR USED IN JANUARY OF 2012, THE SRS WARNING LIGHT HAS BEEN ON. THE CAR STORE WE BOUGHT THE VEHICLE FROM DID CANCEL THE CODE WHEN WE DISCOVERED IT WAS ON AFTER PURCHASE. HOWEVER, THE CODE CAME BACK. WE BROUGHT IT TO BE FIXED, AND I BELIEVE SOMEONE ELIMINATED THE COUPLER UNDER THE PASSENGER SEAT, WIRING THE SEAT TO THE ECU DIRECTLY, BY CRIMPING WIRES TOGETHER. STILL, THE LIGHT CAME BACK ON. IT HAS BEEN ON CONSTANTLY FOR OVER A YEAR NOW. I HAVE SOLDERED THE WIRES UNDER THE PASSENGER SEAT TOGETHER, AS ONE CONNECTION SEEMED BROKEN, HOPING THIS WOULD ELIMINATE THE LIGHT. I BOUGHT A CODE READER TO RESET THE LIGHT, BUT THE CODES ONLY TEMPORARILY DISAPPEAR AND AFTER BLINKING A FEW TIMES THE LIGHT IS BACK ON. I DO NOT KNOW, NOR DO I HAVE CONFIDENCE IN KNOWING, WHETHER OR NOT THE AIR BAG WOULD DEPLOY IN CASE OF AN ACCIDENT. I HOPE NEVER TO FIND OUT, OF COURSE. BUT I DO KNOW THAT THE AIR BAG LIGHT BEING ON IS A CONSISTENT AND PERSISTENT PROBLEM WITH MINI COOPERS BUILT FROM 2002 - 2006. AND I KNOW THAT THERE HAS BEEN NO RECALL, NOR AN EXTENDED WARRANTY THAT WOULD COVER WORK THAT APPARENTLY WILL COST AROUND $2,000 AT A DEALER REPAIR SHOP. WITH THE RECENT RECALL OF AIR BAGS MADE BY JAPANESE AIR BAG MAKER TAKATA, INCLUDING THOUSANDS OF BMWS MADE IN A SIMILAR TIME FRAME AS THE AIR BAGS IN MY MINI COOPER, I AM ALSO WONDERING IF THE MINI AIR BAGS ARE MADE BY TAKATA, AND SENSIBLY WORRY ABOUT THEIR SAFETY SHOULD THE IN FACT DEPLOY AS DESIGNED. BMW HAS RECALLED SOME OF THEI

WHILE DRIVING MY MINI COOPER ON A MAJOR ROAD IN HEAVY TRAFFIC MY MINI COOPER EXPERIENCED A COMPLETE LOSS OF POWER TO THE WHEELS (SUDDEN TRANSMISSION FAILURE). MY ONLY OPTION TO AVOID BEING REAR-ENDED WAS TO STEER THE CAR OFF THE ROAD ( WITH THE REMAINING FORWARD MOMENTUM INTO A FAST FOOD PARKING LOT IN ORDER TO AVOID BEING INVOLVED IN AN ACCIDENT. DESCRIPTION OF FAILED COMPONENT/AFFECTED PART: MINI COOPER'S CVT TRANSMISSION HAVE A KNOWN HISTORY OF SUDDEN FAILURE AT 80K-120K. BMW THE MANUFACTURER OF THE MINI HAS KNOWN ABOUT THE DEFECTIVE TRANSMISSION IN THEIR VEHICLE FOR YEARS, AND HAS NEVER INFORMED OWNERS OF THEIR VEHICLES OF THE TRANSMISSION PROBLEM OR THE POTENTIAL RISK FOR ACCIDENTS, INJURY, OR DEATH THAT COULD RESULT FROM THE SUDDEN FAILURE OF THE MINI'S TRANSMISSION AND RESULTING TOTAL LOSS OF POWER. BMW HAS NEVER ISSUED A RECALL OR OFFER TO REPLACE THE DEFECTIVE TRANSMISSION UNDER THE VEHICLE WARRANTY. ADDITIONALLY, BMW HAS ISSUED SERVICE ADVISORIES TO THEIR SERVICE MANAGERS ABOUT THE PROBLEMS ASSOCIATED WITH THEIR MINI COOPER'S CVT TRANSMISSION, BUT AS MENTIONED HAS NOT COMMUNICATED THIS PROBLEM TO MINI OWNERS. *TR

2002 MINI COOPER, MANUAL TRANSMISSION. LOW MILEAGE, ONLY 22,000 MILES ON IT. WHILE DRIVING IS CITY TRAFFIC, THE TRANSMISSION FAILED TO ENGAGE WHEN I SHIFTED INTO 1ST AND LIFTED THE CLUTCH TRYING TO START FROM A RED LIGHT. THERE WAS A SMALL "SPUTTER" AND THEN THE CAR COULD NOT BE DRIVEN. I WAS ABLE TO PUSH IT TO THE SIDE OF THE ROAD AND THOUGHT THAT THE CLUTCH WAS OUT. THE REPAIR SHOP FOUND OUT THAT THE ENTIRE MANUAL TRANSMISSION HAD DISINTEGRATED. IT HAD TORN ITSELF APART OVER THE YEARS. THE REPAIR SHOP SAID THAT HE WAS AWARE THAT THIS IS A COMMON FLAW WITH THE EARLY MINI COOPERS. THIS WAS A $2500 REPAIR. *TR

WHILE DRIVING EAST ON SHERIDAN DR. IN THE TOWN OF TONAWANDA, I EXPERIENCED A COMPLETE FAILURE OF THE POWER STEERING. I WRESTLED WITH THE CAR FOR THE REST OF THE DAY, AND WHEN I GOT HOME, I HEARD THAT THE POWER STEERING COOLING FAN WAS RUNNING CONTINUOUSLY, EVEN THOUGH THE CAR WAS SHUT OFF IN THE DRIVEWAY. I ASSUMED IT WOULD STOP EVENTUALLY, BUT WAS WRONG AND RETURNED TO A TOTALLY DEAD BATTERY. I CALLED THE DEALER, TOWNE MINI IN WILLIAMSVILLE, NY, AND WAS TOLD THEY WERE BOOKED TO JUNE 17TH, BUT THAT I COULD BRING IT IN. MIDWAY BETWEEN MY HOME AND TOWNE, WHILE ON THE 290, MY POWER STEERING RETURNED. WHEN I GOT TO TOWNE, THEY AS MUCH AS CALLED ME A LIAR, AND REFUSED TO REPLACE THE PUMP AND FAN. THEY DID HOWEVER, FIND $1300 WORTH OF OTHER WORK THAT "NEEDED" TO BE DONE TO PASS NYS INSPECTION. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE POWER STEERING ASSIST FAILED AND CAUSED THE VEHICLE TO BECOME DIFFICULT TO OPERATE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED ABOUT THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 107,000.

I HAVE 2002 MINI COOPER ORIGINAL OWNER AND I HAD WINDSHELD, TRANSMISSION REPLACED. MAIN ISSUE I STILL HAVE IS STREERING LOOSE POWER. I GOT A LETTER FROM MINI SAID IT EXTENDED WARRANTY NOT A RECALL. MINI CO. NEVER RECALL ANY ISSUES. CALL DEALER FOR THIS STREERING PROBLEM BUT MY 2002 MINI IS NOT UNDER THIS CAMPAIGN. I HAVE THAT STREERING LOOSE POWER MIDDLE OF DRIVING BUT THIS IS NOT EVEN RECALL? I HAVE TO PAY FOR DIAGNOSE FEE FOR EXTENSION WARRANTY PER DEALER. MINI/BMW WILL NOT RECALL THIS ISSUE UNTIL DRIVERS GET SERIOUSLY HURT. *TR

I WAS EXITING FROM 35TH STREET IN NEWPORT NEWS, VA ONTO THE WARWICK BLVD OFF RAMP IN TRAFFIC, COASTING WITH THE BRAKES AT ABOUT 5 MPH, WHEN I WAS REAR ENDED BY A NAVY OPERATED FLAT NOSE SCHOOL BUS, WHICH FORCED MY VEHICLE INTO A LATE MODEL CHEVY TRAILBLAZER. MY AIR BAGS (FRONT AND SIDE) DID NOT DEPLOY, AND WHEN I CAME TO REST MY SEAT BACK HAD RECLINED AGAINST MY CHILD'S CAR SEAT (CHILD WAS NOT IN VEHICLE). THE RIGHT REAR UNIBODY WAS CREASED DUE TO THE IMPACT FROM THE BUS. I SUFFERED NECK, BACK, AND SPINE TRAUMA. THE DRIVER OF THE TRAILBLAZER COMPLAINED OF NECK PAIN AT THE SCENE. LOCAL NEWPORT NEWS FIRE AND RESCUE UNITS ARRIVED ON SCENE, AS WELL AS A VIRGINIA STATE TROOPER. THE TROOPER HANDLED THE ACCIDENT. *TR

THE POWER STEERING PUMP FAILED IN MY 2002 MINI COOPER FOR THE SECOND TIME. FIRST TIME IT HAPPENED WAS IN 2011 AND I GOT A NEW PUMP AND HAD IT PROFESSIONALLY INSTALLED. TODAY, 08/26/2013 MY SECOND POWER STEERING PUMP FAILED. THIS IS A KNOWN ISSUE WITH THIS VEHICLE AND THERE HAS NOT BEEN A RECALL. I DO NOT HAVE THE TIME OR THE MONEY TO KEEP REPLACING A PART THAT SHOULD HAVE BEEN RECALLED YEARS AGO. *TR

THE CAR HAS GONE BACK TO A MINI DEALER 4 TIMES SINCE WE'VE OWNED THE CAR BECAUSE OF THE AIR BAG LIGHT ON. LITTLE DID WE REALIZE WHEN WE TOOK IT ON A TRIP TO FLORIDA, THE WHOLE SYSTEM WAS SHUT DOWN. TOOK IT TO A MINI DEALER IN FLA. ON FEB. 15, 2012.....$2126.04 LATER. DROVE IT HOME TO HAVE THE LIGHT GO ON AGAIN , TOOK IT TO MINI OF BEDFORD, NH ON 5/28/13, PICKED IT UP ON 6/4/2013.....$1527.09 LATER. DROVE IT HOME ON 6/4/2013, ONLY TO HAVE THE LIGHT GO BACK ON APPROX 6/10/2013. AAA HAD TO USE A RAMP TRUCK TO BRING IT BACK TO BEDFORD, NH.....BECAUSE THE DRIVERS SEAT TIPPED OVER BACKWARDS WHILE DRIVING & ALMOST CAUSED A SERIOUS COLLISION. ALSO THERE IS A NEW PROBLEM WITH STEERING WHEEL. BOTH LATER ISSUES OCCURRED AFTER THEY HAD TORN IT APART IN DEALERSHIP & KEPT IT FOR A WEEK "FIXING THE PROBLEM". NOW IT SITS AT MINI OF BEDFORD..& THEY ARE TELLING US ANOTHER AIRBAG SENSOR HAS TO BE REPLACED...IT NEED A NEW SEAT....AND THEY'RE NOT SURE ABOUT THE STEERING WHEEL, BECAUSE THEY CAN'T TEST UNTIL THEY PUT IN A NEW SEAT. EVERYTHING IS ON HOLD AT THE MOMENT...#1 WE CAN'T KEEP PAYING FOR SHODDY WORKMANSHIP...#2 WE ARE VERY CONCERNED ABOUT THE SAFETY OF THIS CAR. HAVE BEEN READING SOME WEBSITES & SEE STORIES SIMILAR TO THIS AIR BAG PROBLEM. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE BECAME EXTREMELY DIFFICULT TO STEER. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT NO CAUSE FOR THE FAILURE WAS IDENTIFIED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 130,000.

I WAS ON THE FREEWAY WHEN MY POWER STEERING FAILED AND I NEARLY CRASHED WHILE TRYING TO CHANGE LANES AND EXIT THE FREEWAY. *TR

POWER STEERING FROZE UP CAR COULD NOT BE STEERED IN ANY DIRECTION. *TR

I WAS TRYING TO GET ONTO AN OFF RAMP AND WHEN I WAS INTO THE TURN I ALMOST RAN INTO A CONCRETE BARRIER BECAUSE THE WHOLE STEERING WHEEL LOCKED UP. THE STEERING WHEEL ALWAYS LOCKS UP SOMETIMES IT WITH A FEW MILES AND OTHERS IT IS GOOD UNTIL IT LOCKS UP. VERY DANGEROUS. *TR

AFTER A SHORT TRIP, I HAD JUST PARKED THE MINI. FORTUNATELY, IT WAS OUTDOORS AND WITHIN 50FT OF MY TOOL CHEST. ON TURNING OFF THE IGNITION AND REMOVING THE KEY, I NOTICED AN UNUSUAL NOISE; THE [ELECTRIC] POWER STEERING PUMP CONTINUED TO RUN. A FEW SECONDS LATER, SMOKE APPEARED. I RACED TO MY TOOL DRAWER, GRABBING THE FIRST SUITABLE TOOL, CHANNEL LOCK PLIERS, AND PROCEEDED TO HASTILY DISCONNECT ONE OF THE BATTERY TERMINALS. SMOKE WAS HEAVY AT THAT POINT. DISCONNECTING POWER PREVENTED FURTHER DAMAGE, AND WAS FORTUNATELY DONE IN TIME, BEFORE THE WIRING HARNESS WAS INCINERATED, OR THE SITUATION BECAME A SELF-SUSTAINING CONFLAGRATION. APPARENTLY, ALTHOUGH THERE IS A 100A FUSE PRESENT, THE FAULT PROTECTION ON THE POWER STEERING PUMP CIRCUIT IS INADEQUATE. I REMOVED THE POWER WIRE TO THE PUMP, TO ALLOW THE VEHICLE TO BE DRIVEN, WITH HEAVY [NON-ASSISTED] STEERING, PENDING SERVICE. SINCE THE OUTCOME IS NOT SO BAD, WHY SHOULD I COMPLAIN? CONSIDER IF THE VEHICLE WERE PARKED INDOORS, AND/OR IF THE SAME EVENT WERE TO HAPPEN TO SOMEONE WITH LESS ELECTRICAL APTITUDE. I DON'T EXPECT ACCESSORIES TO LAST FOREVER; THE VEHICLE IS 11 YEARS OLD WITH 123K MILES. I DO OBJECT TO THE FAILURE MODE, IN WHICH THE POWER STEERING PUMP CIRCUIT BECOMES AN INCENDIARY DEVICE... *TR

POWER STEERING FAILS- CAR LOSES ALL POWER ASSISTED STEERING PUPM CONTINUES TO RUN AFTER ENGINE SHUT OFF, POSSIBLE FIRE RESULT. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STARTED THE IGNITION AND SHIFTED INTO REVERSE HOWEVER, THE GEAR SHIFTER FAILED TO MOVE OUT OF REVERSE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO ADVISED THAT THE SHIFT CABLE WAS DETACHED FROM THE TRANSMISSION SHIFT LINKAGE. THERE WAS A RECALL ASSOCIATED WITH THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 02V201000 (POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY) HOWEVER, THE CONTACT'S VIN WAS INELIGIBLE FOR RECALL REPAIRS. THE PART WAS ORDERED AND THE VEHICLE WAS SCHEDULED FOR REPAIRS WHEN THE PART BECAME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 148,200. ....UPDATED 12/20/12 *BF UPDATED 12/27/2012*JS

I TURNED THE SEAT HEATER ON AND IT MELTED A HOLE IN THE LEATHER SEAT AND THE FOAM PADDING STARTED TO BURN. *TR

MY POWER STEERING FAN CONTINUES TO RUN EVEN AFTER THE CARE IS TURNED OFF. IT COMPLETELY DRAINED MY BATTERY SO I REPLACED THE BATTERY. TWO WEEKS LATER THE SAME THING HAPPENED AND I LEARNED THAT MY POWER STEERING PUMP AND FAN ARE DEFECTIVE. ALSO INTERMITTENT LOSS OF POWER STEERING WHILE DRIVING AND NEEDLESS TO SAY THIS CAN BE VERY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 20 MPH THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE CONTACT WAS ABLE TO PARK THE VEHICLE BUT STATED THAT THE POWER STEERING HAD BECOME INOPERABLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 45,065.

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT WAS TRAVELING 20 MPH WHEN THE POWER STEERING ASSIST FAILED. THE VEHICLE WAS NOT TAKEN TO DEALER FOR INSPECTION AND THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 66,000.

FAULTY POWER STEERING PUMP CAUSING A LOSS OF COMPLETE CONTROL OF THE VEHICLE. 80,000+ INCIDENTS REPORTED WITH THIS MAKE/MODEL OF VEHICLE WITH THE KNOWLEDGE OF VEHICLE MANUFACTURER. THE PUMP HAS SINCE BEEN RE-MANUFACTURED TO FIX THE ISSUES BUT MINI OF NORTH AMERICA REFUSES TO ISSUE A RECALL FOR THE SERIOUS SAFETY ASPECT OF THEIR FAILING PART. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT WAS DRIVING 20 MPH WHEN THE STEERING ASSIST FAILED. THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE STEERING RACK, POWER STEERING PUMP AND THE FAN MIGHT HAVE TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 102,000.

THE AIRBAG LIGHT WAS ON IN MY MINI. THERE WAS A RECALL ON THE CABLE TENSIONER, BUT ON MODELS OF 2003 AND ABOVE. I AM WANTING YOU TO RECONSIDER THE YEAR OF THIS RECALL TO INCLUDE 2002. I NEEDED TO REPLACE THE REP CABE F SEAT SIDE AIRBAG, REP CABLE BEL TENSIONER, CABLE STRAP, CABLE CONNECTOR, SHRINKING HOSE AND CABLE STRAP WITH BRACKET FOR A COST OF 800. THE AFFECT OF THIS DEFECT IN THE CAR IS FOR THE CAR TO BE UNABLE TO DETERMINE THE WEIGHT OF THE PASSENGER IN THE CAR IN ORDER TO DEPLOY THE AIRBAG PROPERLY. *TR

MY WIFE HAS BEEN COMPLAINING OF INTERMITTENT LOSS OF POWER ASSIST. I DRIVE HER CAR VERY LITTLE HOWEVER I RECENTLY HAD THE PROBLEM HAPPEN TO ME. ONE OF MY HOBBIES IS SPORT CAR RACING (MOST RECENTLY AT SUMMIT POINT RACEWAY IN WV) SO I DO EXPECT THE UNEXPECTED HOWEVER IT IS SO INTERMITTENT IT IS OFTEN FORGOTTEN. IT WILL BE FINE FOR WEEKS THEN IT HAPPENS AGAIN. THOUSANDS OF REPORTS IN THE UK AND CANADA ISSUED A RECALL. YOU DON'T LOSE YOUR STEERING JUST THE ASSIST. NEXT TIME YOU ARE ALONE ON A BACK ROAD WITH A CURVE TURN YOUR CAR OFF AND YOU WILL SEE WHAT THE DESCRIBED PROBLEM FEELS LIKE. LETS NOT HAVE A SERIOUS INCIDENT BEFORE BMW RESOLVES THIS ISSUE. THIS HAS BEEN GOING ON FOR YEARS. *TR

I WAS DRIVING ALONG AND LOST THE POWER STEERING. IT WAS VERY DIFFICULT TO STEER. I GOT HOME PARKED THE CAR AND LET IT GO. THE NEXT MORNING IT WAS FINE. HOWEVER, THIS MORNING, 6/8/2012, IT HAPPENED AGAIN AS I WAS TURNING IN AN INTERSECTION. FORTUNATELY FOR ME THERE WEREN'T MANY CARS ON THE ROAD, AS IT WAS VERY DIFFICULT TO TURN. IF THIS HAD HAPPENED IN EVEN A SEMI-BUSY INTERSECTION, I WOULD HAVE BEEN IN TROUBLE. *JS

WHILE DRIVING STEERING BECAME STIFF. ALMOST UNABLE TO TURN WHEEL WHEN I SLOWED TO PARK. AFTER TURNING CAR OFF AND BACK ON, PROBLEM RESOLVED. STILL HAPPENS AT LEAST ONCE PER DAY USUALLY WHILE SLOWING OR DOWNSHIFTING. ALWAYS RESOLVES AFTER RESTARTING CAR. *TT

POWER STEERING PUMP STOPPED FUNCTIONING MAKING CAR UNSAFE TO DRIVE. *TR

I WAS DRIVING THE CAR IN LACEY WA. SMOKE STARTED ISSUING FROM THE CAR. I IMMEDIATELY PULLED INTO A PARKING LOT. I OPENED THE HOOD AND SMOKE WAS ISSUING FORTH. AFTER 5 MINUTES, I SPOTTED FLAMES. I HAD A SMALL FIRE EXTINGUISHER BUT IT WAS INSUFFICIENT TO PUT OUT THE FLAMES. A PASSING MOTORIST ARRIVED WITH A LARGER EXTINGUISHER AND PUT OUT THE FLAMES. AN INSURANCE ADJUSTER INFORMED ME THAT THE FIRE WAS DUE TO A FAULTY POWER STEERING PUMP. *TR

COMPLETE LOSS OF POWER STEERING WHILE IN ONCOMING TRAFFIC LANE DURING OVERTAKING ON TWO LANE ROAD. STEERING REQUIRED AN EXTREME AMOUNT OF EFFORT. BARELY MANAGED TO MOVE BACK TO RIGHT HAND LAND BEFORE GETTING DANGEROUSLY CLOSE TO ONCOMING TRAFFIC. POWER STEERING DID NOT RECOVER FOR ANOTHER 2.5 MINS OF DRIVING. PULLED OVER TO SIDE OF ROAD, TURNED CAR OFF, ON AGAIN, POWER STEERING RETURNED. ELECTRIC POWER STEERING PUMP NOW RUNS CONTINUOUSLY EVEN WHEN KEY IS TURNED OFF. INDICATIVE OF ELECTRIC POWER STEERING PUMP CONTROLLER FAILURE. I CONTINUE TO HAVE CONCERNS THAT POWER STEERING MAY CUT OUT AT ANY TIME AGAIN, AND THAT IF THE PUMP CONTINUES RUNNING CONSTANTLY EVEN WHEN THE KEY IS REMOVED IT MAY START A FIRE AT SOME POINT. I HAVE TO DISCONNECT THE NEGATIVE TERMINAL OF THE BATTERY TO PREVENT THE PUMP FROM RUNNING CONTINUOUSLY. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE TRANSMISSION HESITATED IN A JERKING MOTION AND BEGAN TO DOWN-SHIFT INTO ANOTHER GEAR CONTINUOUSLY. IN ADDITION, THE ENGINE WARNING INDICATOR AND EP CODE ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO STATED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED DUE TO INTERNAL DAMAGE. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 56,416.

POWER STEERING FAILED WHILE CAR WAS BEING DRIVEN. LUCKILY THE CAR WAS AT LOW SPEED AT THE TIME AND I WAS ABLE TO GET TO A SAFE STOP BY USING BRUTE FORCE TO STEER THE CAR. POWER STEERING THAN REAPPEARED INTERMITTENTLY OVER THE NEXT FEW DAYS, FINALLY FAILING COMPLETELY. MECHANIC SAYS POWER STEERING PUMP FAILED AND THAT IT IS A COMMON PROBLEM WITH MINIS. COST WILL BE OVER $1200 TO REPAIR. IT APPEARS THE ISSUE IS ALREADY BEING INVESTIGATED BY BMW, YET THEY HAVE TAKEN NO ACTION TO RECALL OR FIX. *TR

I WOULD LIKE TO REPORT A POWER STEERING FAILURE ON MY PREGNANT WIFE'S 2002 MINI COOPER. THE CAR ONLY HAS 61K MILES ON IT. SHE WAS DRIVING LAST NIGHT, IN THE RAIN, AND THE POWER STEERING PUMP WENT OUR AS SHE WAS ON A FREEWAY TRANSITION RAMP AT A SPEED OF 40-50 MPH. SHE ALMOST LOST CONTROL OF THE VEHICLE AND ALMOST HIT THE SIDE RAILS. FORTUNATELY SHE WAS ABLE TO AVOID CRASHING. THE POWER STEERING PUMP STARTED TO WORK INTERMITTENTLY AFTER THE CAR WAS SHUT OFF AND RESTARTED. THIS IS A HUGE SAFETY PROBLEM AND MINI/BMW NEEDS TO ADDRESS THIS PROBLEM BEFORE SOMEBODY GETS SERIOUSLY HURT OR DIES.

WHEN I LEFT MY HOME I TURNED ON THE HEATED SEATS. AS I TRAVELED APPROXIMATELY A HALF MILE I FELT LIKE BOTTOM SEAT WAS EXCEPTIONALLY HOT AND TURNED THE BOTTOM OFF . SHORTLY THEREAFTER I SMELLED SMOKE AND FOUND THAT A HOLE HAD BURNED THROUGH THE SEAT BEHIND MY BACK. THERE WAS SMOKE, A HOLE ABOUT THE SIZE OF A SILVER DOLLAR AND MY COAT HAD BEEN BURNED . MY COAT DID NOT CATCH FIRE BUT HAS A PERMANENT BLACK BURN MARK. *TR