2002 Mini Cooper complaints

POWER STEERING FAILURE--THE POWER STEERING IN MY MINI COOPER S 2002 BEGAN "CUTTING OUT" AND BECAME MORE FREQUENT OVER A FEW DAYS. THE "CUTTING OUT" HAPPENS WITHOUT WARNING AND IS POTENTIALLY QUITE DANGEROUS AS THE VEHICLE BECOMES ALMOST UNMANAGEABLE WHEN MAKING A TURN. THIS MAKES DRIVING THE VEHICLE VERY UNSAFE. UPON RESEARCHING THIS PROBLEM, THIS IS A VERY COMMON PROBLEM WHICH WILL EVENTUALLY OCCUR WITH MOST MINI COOPERS EVEN THROUGH FAIRLY RECENT YEARS OF MANUFACTURE AND OFTEN AT FAIRLY LOW MILEAGE ACCUMULATION. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE POWER STEERING PUMP CONTINUED TO RUN WHILE THE ENGINE WAS TURNED OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 49,000.

BOUGHT THIS CAR IN 2008 AND HAVE HAD VERY FEW ISSUES. THIS MONTH (NOVEMBER 2011) THE CVT (AUTOMATIC TRANSMISSION) WENT OUT. ONLY REPAIR APPARENTLY IS "REPLACEMENT" - RECEIVING QUOTES BETWEEN 7K AND 9K FROM THE DEALER AND AAMCO. NOW FINDING OUT THIS IS A VERY COMMON PROBLEM WITH ALL MINI COOPER CVT'S. THIS IS UNACCEPTABLE. REPAIR COST NOW EXCEEDS CAR'S VALUE. WON'T DO IT. FOOL ME ONCE... SHAME ON YOU. *TR

POWER STEERING FAILURE. THIS OCCURS INTERMITTENTLY. MOST RECENTLY, LAST WEEK, IT WAS OUT FOR 3 DAYS AND THEN IT STARTED WORKING AGAIN. *TR

THE POWER STEERING FAILED WHEN DRIVING. IT BECAME IMPOSSIBLE TO STEER. IT WAS AS THOUGH THE CAR STEERING BECAME LOCKED. I WAS VERY LUCKY TO HAVE A POLICE CAR STOP TO ASSIST ME TO MOVE ME TO A SAFE SPOT ON THE STREET. *TR

POWER STEERING FAILED WHILE GOING DOWN A MULTI-STORY PARKING LOT. VERY SCARY. CAR CORRECTED ITSELF. LATER THAT DAY IT HAPPENED AGAIN. CALLED MY MECHANIC (A MINI MECHANIC) AND WAS TOLD THIS HAPPENS ALL THE TIME WITH 2002-2005 MINI COOPERS. WILL NEED TO REPLACE PUMP AND FAN WHICH WILL COST ME $1200 INC. LABOR. THIS IS A PROBLEM THAT MINI USA IS VERY AWARE OF. THEY RELEASED A CAR WITH KNOWN PROBLEMS (INC. CVT TRANSMISSION ISSUES) HOW CAN THEY DO THIS? SO FAR O ONE HAS BEEN KILLED (THAT WE KNOW OF) BUT I KNOW IT WILL HAPPEN ONE DAY. THIS IS A VERY DANGEROUS ISSUE. *TR

TL*THE CONTACT OWNS A 2002 BMW MINI COOPER. THE CONTACT STATED THE STEERING FAILED WHILE DRIVING AT A LOW SPEED AND HAD TO BE HELD WITH FORCE WITH BOTH HANDS IN ORDER TO TURN IT, OR KEEP THE VEHICLE UNDER CONTROL. THERE WERE NO WARNING LIGHTS BEFORE OR AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC TEST THAT LOCATED THE FAILURE IN THE POWER STEERING PUMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THE FAILURE WAS NOT RECALLED, AND THEY WOULD NOT ASSIST WITH THE REPAIR. THE FAILURE AND THE CURRENT MILES WERE 114,000. UPDATED 07/20/11*LJ THE CONSUMER STATED THE VEHICLE THEN BEGAN TO MAKE A HUMMING SOUND IN WHICH THE POWER STEERING PUMP WAS RUNNING WHEN THE VEHICLE WAS OFF, WHICH CAUSED THE BATTERY TO DIE. UPDATED 08/01/11

I WAS DRIVING FROM EAST LOS ANGELES TO WEST LOS ANGELES (PLAYA DEL RAY) ON THE 105 WEST HGWY WHEN THE CARS TRANSMISSION WENT OUT. THIS HAPPENED IN THE MIDDLE OF THE FREEWAY IN LA DURING RUSH HOUR. I HAD TO SLOWLY MOVE OVER TO THE RIGHT HAND SIDE OF THE HIGHWAY UNTIL I COULD FIND AN AREA WITH A SHOULDER. I BARELY MADE IT TO THE SHOULDER AND COULD HAVE DIED FROM ONE OF THE CARS SPEEDING PAST ME. LUCKILY I MADE IT. I CALLED AAA AND THEY BROUGHT A TOW TRUCK WHICH TOWED THE CAR INTO A SHOP WHICH STATED THAT THEY WOULD NOT BE ABLE TO REBUILD THE TRANSMISSION. THEY SAID I WOULD HAVE TO REPLACE THE WHOLE THING WHICH WOULD COST $7,000 MINIMUM. I CALLED MULTIPLE OTHER DEALERS AND SHOPS, WHOM ALL GAVE THE SAME ESTIMATE. I DONATED IT TO MY LOCAL NPR STATION BECAUSE I DID NOT WANT TO PAY THAT AMOUNT OF MONEY TO REPLACE A FAULTY TRANSMISSION, WITH ANOTHER FAULTY TRANSMISSION. *TR

POWER SYSTEM ON MY 2002 MINI COOPER WENT OUT. THIS SEEMS TO BE A COMMON OCCURRENCE. AND VERY DANGEROUS AND COSTLY. BMW HAD BETTER DO SOMETHING ABOUT THIS BECAUSE I ALMOST CREAMED A COP... *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE HEADLIGHTS AND CABIN LIGHTS WOULD REMAIN ILLUMINATED AFTER THE VEHICLE WAS SHUT OFF. IN ADDITION, THE CONTACT STATED THAT HE WOULD OFTEN BECOME LOCKED INSIDE OR OUTSIDE OF THE VEHICLE INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HIM THAT THE CONTROL MODULE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

TL* THE CONTACT OWNS A 2002 MINI COOPERS. THE CONTACT WAS DRIVING 40 MPH WHEN THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO A MECHANIC SHOP WHERE THEY INFORMED HIM THAT THE FUSE THAT CONTROLLED THE POWER STEERING CHARGING SYSTEM HAD BLOWN. THE COMPONENT WAS REPLACED AT A THE CONTACTS EXPENSE. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS 36,000. UPDAT ED 06/03/11 *BF UPDATED 08/08/11

I ALWAYS MAINTAINED MY 2002 MINI COOPER AND AT 80K MILES THE TRANSMISSION BLEW UP JUST BEFORE I WAS TO ENTER A VERY BUSY FREEWAY IN LOS ANGELES, DOWNTOWN AREA. THERE WAS PLENTY OF OIL IN THE TRANSMISSION. I WAS TOLD IT WAS NOT A FAULT OF MY CARE AFTER THE MECHANIC LOOKED AT IT UPON TOW IN. IT JUST STOPPED FAST AND SHORT WITH A HUGE JERK FORWARD AND EXPLOSIVE NOISE. THE MECHANIC SAID IT BLEW IN BIG CHUNKS. I COULDN'T MOVE IT FROM TRAFFIC IN NEUTRAL AND HAD IT TOWED TO THE SHOP. 80K IS EARLY FOR SOMETHING LIKE THIS AND I SEE MANY PEOPLE ARE REPORTING THIS HAPPENED WITH EVEN LESS MILEAGE, 34K, 48K ...NO REPLACEMENTS AND SO MANY FAILURES LIKE THIS? MINI TURNS THEIR HEADS; WOULD NOT REPLACE OR EVEN TALK TO ME. PREVIOUSLY TOO THE POWER STEERING PUMP ALSO JUST STOPPED AND NO MOVEMENT ON THE WHEEL. SERIOUSLY DANGEROUS. I WAS TOLD BY THE DEALERSHIP ONE TIME IN MOUNTAIN VIEW, I HAD AN OIL LEAK. AT THE TIME THE AMOUNT THEY WANTED ME TO PAY WAS HIGH, 700.00 OR SO (JUST AFTER WARRANTY ENDED). I TOOK IT TO ANOTHER MECHANIC. HE TOOK ME UNDER THE CAR AND SHOWED ME THERE WAS NOT A SPOT OF OIL UNDER THAT CAR IN ANY NOOK OR CRANNY. IN THINKING ABOUT THIS AFTER TRANSMISSION PROBLEM I REALIZE THESE THINGS ARE TELLING ME MINI KNOWS ABOUT THEIR MINI MECHANICAL PROBLEMS. ALSO WHEN THE NEW ($4350.00) TRANSMISSION WAS PURCHASED, LA, MINI TOLD THE MECHANIC THEY HAD 5 TRANSMISSIONS IN STOCK IN THEIR PARTS DEPARTMENT AT ALL TIMES BECAUSE THIS WAS SO COMMON. THAT'S PROOF THEY KNOW IT'S A PROBLEM. YET NO R

TL*THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 25 MPH AND ATTEMPTING TO MAKE A LEFT OR RIGHT TURN THE STEERING WHEEL WAS DIFFICULT TO TURN. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE AND THE CURRENT MILEAGE WAS 82,426. UPDATED 05/03/11*LJ UPDATED 05/16/11

I BOUGHT A 2002 MINI COOPER AND WHILE DRIVING THE POWER STERERING QUIT WORKING. I CONTACTED A MINI REPAIR SHOP AND FOUND THAT THE POWER STEERING PUMP IS ELECTRIC AND IT'S RELAY OR OR ONE FOR IT'S COOLING FAN MIGHT HAVE FAILED. THEY TOLD ME THAT IT IS VERY COMMON AND WOULD COST OVER $1000. TO FIX IT. HAD I BEEN IN THE WRONG MODE OF DRIVING THIS FAILURE COULD HAVE KILLED ME. *TR

POWER STEERING FAILURE ON MY 2002 R50 MINI COOPER. THE POWER STEERING WOULD ACT UP THE PREVIOUS COUPLE OE WEEKS BY THEN RESUME AS IF EVERYTHING WAS FINE. THEN PRIOR TO FIRST OF THE YEAR, IT JUST WENT OUT TOTALLY. *TR

I DRIVE A 2002 MINI COOPER AND AT 9:50AM THIS MORNING I DROVE MY CAR ABOUT A MILE TO MY OPTOMETRIST APPOINTMENT AND ALL WAS WELL WITH MY POWER STEERING. I WAS THERE FOR 45 MINUTES, LEFT, AND GOT IN MY CAR PULLED OUT OF MY SPOT WITH NO TROUBLE AT ALL, BUT ABOUT 20 FEET AWAY FROM MY PARKING SPOT I WENT TO TURN ONTO A THOROUGHFARE ONLY TO FIND THAT MY POWER STEERING HAD FAILED. I HAD TO WRENCH THE STEERING WHEEL WITH MUCH STRENGTH TO AVOID TRAFFIC AND PULLED OVER. I CHECKED THE STEERING FLUID AND THERE IS PLENTY IN THERE. I BELIEVE IT IS AN ELECTRICAL PROBLEM. THE PROBLEM REMAINS CONSISTENT AFTER TURNING MY CAR ON AND OFF. I'VE CHECKED ONLINE TO FIND THAT MANY OTHERS HAVE HAD THIS SAME PROBLEM IN THEIR 2002 MINI COOPERS AND YET NO RECALL HAS BEEN MADE. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP WHERE THE AIR BAG LIGHT WAS RESET. THE FAILURE RECURRED WITHIN 28 MILES OF DRIVING. THE CONTACT WAS INFORMED THAT BECAUSE THE LIGHT WAS ILLUMINATED, THE AIR BAGS WOULD NOT FUNCTION IN THE EVENT OF A CRASH. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 69,000.

MY 2002 MINI COOPER'S POWER STEERING FAILED SILENTLY AS I DROVE HOME FROM WORK A WEEK AGO, THOUGH WAS FINE AFTER RESTARTING THE CAR. SINCE THEN, IT HAS STARTED FAILING CONSISTENTLY. THIS LEADS TO VERY DANGEROUS DRIVING CONDITIONS BECAUSE I HAVE NO IDEA HOW HARD I WILL HAVE TO TURN ON THE WHEEL FOR ANY GIVEN TURN AND THUS MAKES ME HIGHLY SUSCEPTIBLE FOR HITTING A PEDESTRIAN OR ANOTHER CAR.. INVESTIGATIONS IMPLY THAT I HAVE TO REPLACE THE POWER STEERING PUMP, WHICH COST $1000+. MY CAR HAS ROUGHLY 36,000 MILES ON IT. *TR

2002 MINI COOPER POWER STEERING FAILURE AFTER POWER STEERING PUMP REPLACED. THE CAR HAD NO POWER STEERING WITHIN 700 MILES OF HAVING THE POWER STEERING PUMP AND PUMP FAN REPLACED AND NOW AM TOLD IT IS THE POWER STEERING PUMP CABLE. *TR

RECENT NEWS REPORTS ALERTED ME ABOUT THE INVESTIGATION INTO MINI POWER STEERING FAILURES IN 2004-05 MINI COOPERS. I AM WRITING TO REPORT THAT A FEW YEARS AGO, I EXPERIENCED INTERMITTENT POWER STEERING FAILURE IN MY 2002 MINI COOPER (AT ABOUT 70K) MAKING STEERING VERY DIFFICULT. BECAUSE THE PROBLEM WOULD COME AND GO, IT WAS DIFFICULT FOR MY REPAIR SHOP TO FIND THE ROOT CAUSE. EVENTUALLY, THE POWER STEERING PUMP WAS REPLACED. *TR

POWER STEERING IN MY 2002 MINI COOPER FAILED. STEERING VEHICLE BECAME VERY DIFFICULT WITH LITTLE ABILITY TO TURN VEHICLE. REPAIR REQUIRED A NEW ELEC. STG PUMP AND COOLING FAN ($602) PLUS LABOR OF $384 FOR A TOTAL OF $986. *TR

TL*THE CONTACT OWNS A 2002 MINI COOPER. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 2 MPH, THERE WAS A LOSS OF POWER STEERING WHICH CAUSED DIFFICULTY IN TURNING THE STEERING WHEEL. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION. THE FAILURE OCCURRED FOUR DIFFERENT TIMES. THE CONTACT STATED THE POWER STEERING FLUID READING WAS AT THE CORRECT CAPACITY LEVEL. ALSO, HE MENTIONED THAT THE POWER STEERING FAN MOTOR COULD HAVE POSSIBLY OVERHEATED, CAUSING THE FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 98,500.

JUST DRIVING ALONG AND CAR BEGAN TO SPUTTER, AND THEN TRANSMISSION LET GO. ENGINE REVVED, BUT THE GEARS WERE GONE. NO FORWARD OR REVERSE. NOTHING. *TR

TL*THE CONTACT OWNS A 2002 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH AND THE POWER STEERING FAILED. HE STATED THAT THE POWER STEERING FAILURE OCCURRED NO MATTER THE SPEED AND HAS OCCURRED AT OTHER SPEED LEVELS. HE CALLED THE DEALERSHIP AND WAS TOLD THAT THEY WOULD NOT INSPECT THE VEHICLE WITHOUT HIM PAYING A DIAGNOSTIC FEE. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000. THE CURRENT MILEAGE WAS APPPROXIMATELY 67,500.

SUDDEN FAILURE OF THE MANUAL 5 SPEED TRANSMISSION CAUSING CAR TO COME TO A SUDDEN STOP IN AN INTERSECTION, ENDANGERING THE DRIVER AND BLOCKING TRAFFIC. SOMETHING INTERNAL FAILS IN THE TRANSMISSION, CAR COMES TO T SUDDEN STOP, CANT BE PUSHED AS THE WHEELS LOCK UP AND MUST BE TOWED FROM THE ROAD. APPEARS TO BE A COMMON PROBLEM ON MESSAGE BOARDS ON THE WEB. TRANSMISSION MUST BE REPLACED. *TR

1. NORMAL AROUND TOWN DRIVING. PASSENGER REAR LOWER CONTROL ARM SNAPPED ... STEEL FAILED UNDER STRESS ONE OF SEVERAL MANUFACTURE HOLES PUNCHED INTO THE MEMBER. 2. CAUSED THE VEHICLE TO BECOME INOPERABLE. 3. REQUIRED REPLACEMENT CONTROL ARM. BMW HAS SINCE RE-ENGINEERED THE CONTROL ARM. REPLACEMENT ARMS ARE MADE STRONGER. *** I CAN PROVIDE ONLINE FORUM POSTINGS FROM NORTHAMERICANMOTORING.COM AND MINI2.COM (US AND UK ONLINE FORUMS FOR MINI OWNERS) WHICH DEMONSTRATE THAT THIS MEMBER IS ROUTINELY BREAKING ON OTHER VEHICLES OF THE SAME VINTAGE. PHOTOS OF MY FAILURE AND THE FAILURES OF OTHERS AVAILABLE. MINI IS ROUTINELY DENYING RESPONSIBILITY FOR THIS VEHICLE SAFETY ITEM CITING IMPROPER DRIVING HABITS. *** *TR

2002 MINI COOPER, POWER STEERING PUMP SHORTED OUT CAUSING A SMALL FIRE WHICH DESTROYED THE PUMP,FAN,WIRING HARNESS,POWER STEERING LINE. CAR HAD LESS THAN 50,000 MILES ON IT. COST OF REPAIR OVER 1200 DOLLARS. *TR

2002 MINI COOPER. POWER STEERING QUIT (MY WIFE DRIVING AND BY HERSELF) IN A TURN WITH ONCOMING TRAFFIC. NO INJURIES BUT VERY CLOSE. *TR

TL*THE CONTACT OWNS A 2002 MINI COOPER. THE VEHICLE SHUT OFF WHILE DRIVING APPROXIMATELY 25 MPH. THERE WERE NO WARNINGS PRIOR TO THE TRANSMISSION FAILURE. THE CONTACT FEELS THAT THIS IS A SERIOUS SAFETY ISSUE BECAUSE A CRASH COULD HAVE OCCURRED. THE FAILURE MILEAGE WAS 63,000.

I HAVE A 2002 MINI COOPER, I PURCHASED NEW. I HAVE HAD AN ONGOING PROBLEM SINCE IT WAS UNDER WARRANTY. MY AIR BAG WARNING LIGHT COMES ON. I HAVE HAD IT BACK TO THE DEALER AT LEAST 20+ TIMES FOR THE SAME PROBLEM. THEY STILL CAN NOT SEEM TO GET A PERMANENT FIX FOR THIS(NEXT APPOINTMENT JULY 9, 2009). *TR

I DROVE MY 2002 MINI COOPER APPROXIMATELY 6 MILES TO DROP OFF A FRIEND WHO WAS VISITING FROM OUT OF TOWN. I WAS HELPING MY FRIEND REMOVE HIS SUITCASE AND STANDING TO THE PASSENGER SIDE REAR OF THE CAR WHEN MY LEG MADE CONTACT WITH THE TAILPIPE CAUSING ABOUT A 2 INCH CRESCENT SHAPED BURN. THE TAILPIPE WAS HOT ENOUGH THAT MY SKIN STUCK TO THE PIPE - IT IS A PRETTY NASTY SECOND DEGREE BURN. *TR

2002 MINI COOPER POWER STEERING HYDRAULIC ASSIST FAILS WITHOUT WARNING MAKING CAR DIFFICULT TO STEER. FAILURE IS INTERMITTENT AND MAY OCCUR ON THE HIGHWAY OR ON SURFACE ROADS. IN EITHER CASE THERE IS ABSOLUTELY NO WARNING. *TR

TRANSMISSION WHINING NOISE EVENTUALLY LEADING TO TRANSMISSION FAILURE. MINI IS AWARE OF THIS PROBLEM WITH CVT TRANSMISSIONS AND REFUSES TO ADMIT FAULT. VERY COMMON PROBLEM OCCURRING IN MOST 2002 VEHICLES WITH ONLY 40,000-60,000 MILES ON THEM. COST IS 7000 TO REPLACE. MINI DOES NOT OFFER REPAIR ON THIS PART. *TR

TRANSMISSION BEARINGS FAILURE AFTER 82,000 MILES. NO BEARINGS KIT REPLACEMENT OFFERED. *TR

DRIVER'S SIDE AUTOMATIC WINDOW DOES NOT WORK; WILL BE REPLACING WINDOW MOTOR. *TR

PURCHASED A USED 2002 MINI COOPER ABOUT 3 1/2 YRS AGO W/ ABOUT 12K MILES. AT AROUND 15-17K MILES THE TRANSMISSION BASICALLY EXPLODED WHILE I WAS ON THE HIGHWAY. I WAS TOLD THAT THERE WAS A CRACK IN THE TRANSMISSION. MINI REPLACED IT WITH I'M GUESSING A REBUILT TRANSMISSION. AT THE TIME OF THE REPAIR I ASKED THEM IF THEY WERE PUTTING IN A NEW CLUTCH AND THEY SAID NO, WHICH I FOUND STRANGE. NOW AT 60K MILES THE CLUTCH IS BASICALLY DONE. WHEN THE CAR IS COLD IT SHIFTS PRETTY NORMALLY, BUT AFTER 15-25 MINUTES OF DRIVING THE FIRST TWO GEARS BECOME HARD TO ENGAGE AND THEY SLIP. THIS IS NOT MY FIRST FIVE SPEED AND I'M SHOCKED THAT THIS CLUTCH IS DONE AFTER SUCH LITTLE MILEAGE. SHOULD THEY HAVE REPLACED THE CLUTCH WHEN THEY REPLACED THE TRANSMISSION? I'M NOT A MECHANIC BUT TO LOSE A CLUTCH AT 60K MILES DOESN'T MAKE ANY SENSE. MY DRIVING HABITS ARE PRETTY NORMAL. I'M NOT LIGHTING UP THE TIRES AT TRAFFIC LIGHTS OR RACING PEOPLE. THIS IS AN EVERYDAY CAR MOSTLY USED ON THE HIGHWAY. I'M BRINGING THE CAR IN TO HAVE IT LOOKED AT THE MINI SERVICE CENTER IN FREEPORT NY ON 12/29/08. ALSO HAD A PROBLEM WITH OVERHEATING ABOUT 4 MONTHS AFTER CAR WAS PURCHASED. AND AIR BAG LIGHT STAYS LIT. HAVE HAD THIS PROBLEM CORRECTED ONCE OR TWICE. BUT THE LIGHT STILL STAYS LIT. *TR

MY 2002 MINI COOPER ELECTROHYDRAULIC POWER STEERING (EHPS) PUMP WILL NOT SHUT OFF CAUSING ASSOCIATED WIRING TO BECOME DANGEROUSLY HOT (SMELLS LIKE AN ELECTRICAL FIRE). THIS IS A COMMON PROBLEM WITH THE MINI COOPER AND THERE NEEDS TO BE A RECALL. I AM TRYING TO FIGURE OUT HOW TO KEEP MY MINI FROM CATCHING FIRE. *TR

ABRUPT FAILURE OF THE POWER STEERING SYSTEM IN A 2002 MINI COOPER. *TR

BACK IN FEB 2008 THE STEERING ON MY 2002 MINI COOPER JUST WENT OUT WITH NO WARNING. I WAS LEFT WITHOUT POWER STEERING IN THE MIDDLE OF THE 101 FREEWAY, WHICH IS VERY DANGEROUS! I FIXED THE PROBLEM, WHICH WAS VERY EXPENSIVE AS IT WAS THE ENTIRE STEERING SYSTEM THAT FAILED AND FILED A COMPLAINT WITH MINI, I NEVER HEARD BACK BUT CONTINUED TO DRIVE THE CAR. RECENTLY, SEPTEMBER 2008 THE TRANSMISSION IN THAT SAME CAR NEEDS TO BE REPLACED. I HAVE HAD NOTHING BUT MAJOR PROBLEMS WITH THIS CAR AND FEEL IT MAY BE A LEMON. MINI IS UNWILLING TO HELP ME AS MY CAR IS NO LONGER UNDER WARRANTY. I FEEL AS THOUGH THESE PROBLEMS COULD RESULT IN SERIOUS INJURY AS THERE IS NO PRIOR WARNING AND I AM CONCERNED FOR ALL PRESENT AND FUTURE MINI COOPER DRIVERS. *TR

CLUTCH AND CABLES FAIL AT 100 000KM. RATTLING NOISE AT START UP. VERY LOUD HUMMING NOISE COMING FROM THE STEERING. TRANSMISSION GONE AT 103 000KM. *TR

THE WARRANTY ON MY 2002 MINI COOPER RAN OUT AT 50K MILES. AT 53K MILES THE TRANSMISSION FAILED AND HAD TO BE REPLACED WITH A REBUILT TRANSMISSION FROM MINI. THE TOTAL COST OF THE REPAIR WAS $4,200. I HAVE BEEN IN CONTACT WITH MANY OTHER PEOPLE WHO ARE SUFFERING THE SAME FATE BECAUSE MINI WILL NOT TAKE RESPONSIBILITY FOR THEIR FAULTY TRANSMISSIONS. *TR

THE AUTOMATIC TRANSMISSION OF MY 2002 MINI COOPER FAILED WHILE MY FRIEND WAS DRIVING MY CAR. SHE WAS ON A WINDING COASTAL ROAD AND THE CAR DIED ON A BLIND CURVE, PUTTING HER AT GREAT DANGER. FORTUNATELY NOBODY WAS HURT. THE CAR WAS TOWED TO THE SAN FRANCISCO BMW DEALERSHIP, WHERE I WAS INFORMED I NEEDED A $8500 "REFURBISHED" TRANSMISSION, AS THE TRANSMISSION IS NOT EVEN MADE ANYMORE. RESEARCH ON LINE SHOWS THAT THIS BECOMING A FREQUENT PROBLEM WITH "FIRST GENERATION" MINIS WITH THE "CVT" AUTOMATIC TRANSMISSION. I DECLINED THE REPAIR AND SOLD THEM THE CARCASS OF MY CAR. THIS IS A DANGEROUS PROBLEM AND BMW/MINI IS NOT ACCEPTING RESPONSIBILITY. *TR

I WAS DRIVING MY 2002 MINI ON THE FREEWAY AT 65 MPH AND I FELT A SUDDEN JOLTING AND SENSED A BACKWARD FORCE IMPEDING IT FROM GOING FORWARD. LUCKILY, IT WAS NIGHT TIME AND THERE WEREN'T MANY CARS, BECAUSE MY MINI STOPPED GOING FORWARD AND WAS MERELY RUNNING ON MOMENTUM. THE CAR GOT WORSE AND STARTED MAKING A LOUD CLUNKING SOUND FROM WHERE THE TRANSMISSION SITS AND THE CAR CONTINUED JOLTING NOT GOING FORWARD AS I BARELY HAD ENOUGH MOMENTUM TO PULL TO THE SHOULDER. AFTER TURNING OFF THE ENGINE AND CHECKING THAT EVERYTHING WAS FINE BY APPEARANCE (NO OIL LEAK, NO BLOWN GASKET, ETC), I RESTARTED THE CAR FINE, BUT THE CAR NEVER AGAIN ENGAGED INTO GEAR UNTIL I SPENT A WHOPPING $7,000 TO FIX IT. I WOULD SHIFT INTO D AND THE ENGINE WOULD REV, BUT THE CAR STAYED INERT. THE TRANSMISSION IS A CLOSED SYSTEM AND WHEN NO HARM IS DONE TO IT AND NO FLUID IS NOT LEAKING, TRANSMISSIONS SHOULDN'T POSE ANY PROBLEMS AT CONSIDERABLY LOW MILES (99K). I STARTED RESEARCHING ON THE POSSIBLE PROBLEMS WITH THE TRANSMISSION AND SURE ENOUGH, THERE WAS A LONG LIST OF COMPLAINTS ON THE FAULTY DESIGN. NEXT, I HAD TO SHOP FOR MECHANICS. ALL THE EXPERIENCED MINI MECHANICS TOLD ME THAT BMW OFFERED NO REPLACEMENT PARTS BECAUSE OF A PATENT THE INVENTOR HAD ON THE CVT DESIGN. I HAD TO HAVE THE WHOLE TRANSMISSION REPLACED BECAUSE THERE WERE NO OPTIONS BMW LEFT FOR THE CONSUMER. IT WAS EITHER YOU PAY $7,000 OR YOUR MINI WILL BE SCRAPPED AND NEVER RUN AGAIN. MY MECHANIC WAS NICE ENOUGH TO CHOP OPEN THE TRANSMISSION AND

BOTH PASSENGER AND DRIVER'S SIDE WINDOW MOTOR FAILURE (WITH WINDOW IN UP POSITION). PROBLEM WAS INTERMEDIATE OVER THE PAST THREE OR FOUR YEARS WITH FAILURE TWO OR THREE TIMES A YEAR. CURRENTLY DRIVER'S SIDE WINDOW HAS NOT WORKED FOR WEEKS. *TR

I AM THE SECOND OWNER (BOTH OLDER LADIES), OF A 2002 AUTOMATIC MINI COOPER WITH 46,000 MILES. YESTERDAY WHILE DRIVING HOME FROM WORK THE TRANNY FAILED. IT DOWNSHIFTED OR SOMETHING AND THE EP WARNING LIGHT CAME ON, WHICH MEANS TRANSMISSION FAILURE AND I WAS TWO FEET AWAY FROM BEING REAR ENDED! I COULD HAVE BEEN KILLED. AFTER RESEARCHING ON LINE, I HAVE READ GREAT AMOUNTS OF CONSUMERS WITH THE SAME COMPLAINT. IT IS DANGEROUS AND VERY COSTLY ACCORDING TO THE FIGURES I'VE READ OF PEOPLE WHOSE HAD THEIRS FIXED OR REPLACED. THESE CARS WITH THE CVT TRANSMISSIONS NEEDS TO BE ANNOUNCED TO THE PUBLIC FOR SAFETY REASONS ALONE NOT EVEN TO MENTION THE COST! SINCERELY, BONNIE QUINN *TR

TRANSMISSION BLEW AT 34 THOUSAND MILES. *TR

THE AIRBAG LIGHT IN THE VEHICLE GOES ON, AND THE DEALER TOLD ME THAT NOTHING WAS WRONG, NOW THE AIRBAG LIGHT IS CONSTANTLY ON. *TR

CVT TRANSMISSION FAILED AFTER 32,000 MILES, NEEDING COSTLY REPLACEMENT. *TR

I RECENTLY HAD A 60K SERVICE ON MY 2002 MINI COOPER. A COUPLE DAYS LATER I DROVE FROM MONTEREY, CA TO LOS ANGELES, CA AND MY CAR WAS RUNNING FINE. ALL OF A SUDDEN OUT OF THE BLUE, MY POWER STEERING WENT OUT. I WAS DRIVING ON THE 101 FREEWAY AND COULD NOT TURN MY CAR. I WAS ABLE TO GET IT TO A REPAIR SHOP WHERE THEY TOLD ME MY POWER STEERING PUMP HAD BROKE. $1,000 LATER THE PART OF REPLACED. LUCKILY I WAS SAFE, AS WAS THE PASSENGER IN MY CAR. BUT WHAT IF I HAD BEEN ON A VERY CURY, BUSY HIGHWAY? I COULD HAVE DRIVEN OFF A CLIFF! THIS IS NOT A PART THAT SHOULD SIMPLY WEAR OUT OR BREAK, WE ARE TALKING PEOPLE'S LIVES! I LOVE MY MINI AND AM A PROUD MINI OWNER AND DRIVER BUT AFTER THIS I DON'T THINK I WILL EVER BUY ANOTHER MINI OR BMW. *TR

I WAS DRIVING MY 2002 MINI COOPER. I HAD DRIVEN 1/4 MILE AND THOUGHT I HEARD SOMETHING CRACK OR SPARK UNDER THE DASHBOARD ON THE PASSENGER SIDE OF THE VEHICLE. THEN I SAW SMOKE, PULLED OVER, GOT OUT, AND THE WHOLE CAR WENT UP IN FLAMES. *TR