2018 Kia Optima

Defect. Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."

Risk. A person inside the trunk compartment may become trapped, increasing their risk of injury.

Remedy. Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.

Defect. Kia Motors America (Kia) is recalling certain 2017-2018 Kia Optima hybrid vehicles. These vehicles are equipped with a Voltage Protection Device (VPD), designed to protect the high voltage battery module, that may activate inadvertently.

Risk. If the VPD activates while the vehicle is being operated in Electric Vehicle (EV) mode, there may be a loss of power, increasing the risk of a crash.

Remedy. Kia will notify owners, and dealers will remove the VPD switch and install two newly designed Battery Management Systems (BMS) that contain Overvoltage Protection Devices (OPDs), free of charge. The recall is expected to begin May 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC162.

My 2018 Kia Optima has the Theta II 2.4L engine. In February 2026, the dealer performed an engine/powertrain computer reprogramming. In August 2026, the engine failed and the vehicle was taken to an authorized Kia dealer, where the engine was replaced under the Theta II engine warranty. The vehicle was at the dealer from August 8 until the repair was completed on September 29, 2026. When I picked up the vehicle on October 9, it felt shaky and vibrated on the drive home. On October 11, the vehicle began giving off a distinct, unfamiliar smell that is not like burning fuel or oil. On October 21, I found the vehicle leaking an opaque, milky tan fluid onto my garage floor. The type and source of the fluid are UNKNOWN. I have photos of the leak. My family and I have stopped driving the vehicle because we believe it is unsafe. We were driving it with our children before these symptoms appeared. Given the history of Theta II engine failures, we are concerned about the risk of engine failure, stalling, or fire while driving. The new symptoms have not yet been diagnosed or confirmed by a dealer. I am arranging for the vehicle to be towed to a Kia dealer for warranty diagnosis. The vehicle and leak are available for inspection. I have reported these issues to the manufacturer under an open customer case.

The contact owns a 2018 Kia Optima. The contact stated that upon starting the vehicle, the vehicle jerked abnormally. The failure persisted while driving, and the vehicle lost motive power. The contact was able to restart the vehicle; however, the failure persisted while driving. The vehicle was towed to a dealer to be repaired under an unknown recall for an engine software update and key fob replacement; however, the dealer failed to honor the recall repair and recommended purchasing a new vehicle. The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 126,000. The VIN and License plate number were unavailable.

The contact owns a 2018 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate and failed to exceed 52 MPH. The vehicle shut off. The contact stated that the engine was running rough while stationary and the vehicle shut off without warning. The vehicle was taken to an Auto Parts Store, where it was diagnosed, and it was determined that the vehicle was in LIMP Mode with knock sensor codes displayed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 136,000.

See attached document for complaint.

I was run off the road by a drunk driver I hit a tree at 35MPH MY AIR BAGS DID NOT DEPLOY NOR DID MY SEAT BELT LOCK!!!! I NOW HAVE MULTIPLE INJURIES I HAVE BROKEN BONES ALL THROUGHOUT MY FACE!!!!! A SEVERE CONCUSSION!!!!! Any time I call the the customer care center and try and get information or call someone I either get hung up or gave the run around and then hung up on my mother in law has also tried calling and have received the same response this is so unacceptable and unprofessional.

I’ve had my 2018 kia optima for round about two years.I only got this car because they refused to replace my previous engine on my 2015 Kia optima,even though I had a warranty but that’s another story(Kia on the Blvd).This car have given me problems from the start.Going through oil in less than a month,which they can never find a leak,not being able to go over a certain speed before I start to hear noises.Ive complained about noises,they act like they can’t hear,and said nothing is wrong with the engine when previously checked.My check engine light has came on twice and both times the car was malfunctioning on the highway resulting in me have to get a tow.First it was plugs replacement now I need a whole new engine.I really don’t know what to do at this point.I believe they sold me a faulty car

Purchased vehicle from a used car dealership. Had it a few months before brake pedal started losing pressure and going to floor. Had master cylinder replaced. A few months later, brake light started coming on when accelerating. New master cylinder had leaked into brake booster. Had master cylinder replaced along with brake booster. A few weeks later and brake pedal is losing pressure again

The car burns oil within a week of getting an oil change. It was only driven a 200 miles before all of the oil was burned out. This has been a consistent issue with this car that the oil burns at an extreme rate. This is a safety risk as it could lead to engine overheating, the engine could stall out due to the fast burning of the oil, or a potential fire hazard while driving. The oil light will come on for a second and at that point, the oil is already EXTREMELY too low. I brought the car to the mechanic and they have told me multiple times that there is no leak or anything. The mechanic says that the car simply is burning oil too fast.

The contact owns a 2018 Kia Optima. The contact stated that while driving at an undisclosed speed, there was an abnormal odor and a knocking sound coming from the engine. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the issue. The vehicle was not repaired. The issue persisted. The contact stated that the vehicle was later returned to the dealer to be repaired under a service campaign involving the engine control unit (ECU). Shortly after the vehicle was repaired, the ECU failure message was displayed. The vehicle subsequently became inoperable. The vehicle was not repaired. The manufacturer was notified of the issue. The approximate failure mileage was 1,500.

2018 Kia Optima Dealer Ed Voyles Kia Smyrna began Recall SC340. Vehicle drove in running. Dealer flashed ECM software, discovered non-original engine/ECU. Vehicle now won’t start. Dealer document states 'will not start after recall.' Dealer refuses to restore to running condition citing prior repairs. This violates 49 USC 30120

The contact owns a 2018 Kia Optima. The contact stated that while attempting to accelerate from a standing start the vehicle had experience sever jerking and hesitation. Also, the vehicle has experience oil consumption problems and the contact constantly added engine oil. The cause of the failures were not determine. Also, the hood latch had malfunctioned and the hood could not opened to add oil to the engine. The cause of the failures were not determined. The local dealer and manufacturer were notified of the failures but no assistance was offered. The failure mileage was 121,000.

2018 Kia Optima LX, 2.4L GDI Theta II engine. Approximately 128,000 miles. Reporting severe internal oil consumption that has progressed to engine misfire and shaking, consistent with late-stage Theta II connecting rod bearing failure. The vehicle is now unsafe to drive and has been parked. Timeline: Purchased as a Certified Pre-Owned vehicle in December 2021. Excessive oil consumption began shortly after purchase. For approximately 4.5 years I have added about 1 quart of oil every 2 weeks to keep the engine from running dry. No external leaks have ever been found by any mechanic. Multiple independent mechanics attempted diagnosis and repair over this period. None resolved the issue. The vehicle has now developed a pronounced shake and apparent engine misfire, the textbook progression to rod bearing failure documented in NHTSA investigation PE19-004 and prior recalls/campaigns 17V-224, SC147, and SC172. Safety concerns: Sudden engine seizure or stall at highway speed creates a serious crash risk for me and surrounding traffic. Theta II 2.4L GDI rod bearing failure has been associated with under-hood fires. The defect develops gradually with no warning to the driver beyond elevated oil consumption, which is frequently dismissed as normal until catastrophic failure occurs. I am filing this complaint to document the failure and to add to NHTSA's data on the Theta II GDI 2.4L engine in 2018–2019 Optimas. This model year was excluded from the original 2017 recall but is included i

Consuming fuel to the amount of roughly 1/2 quart per 150 miles. Vehicle has been inspected by mechanic and the oil pan, oil filter, and PCV valve has been replaced and engine oil UV dye added and cycled with no leaks found. The risk is that if not rigorously checked often, the engine will malfunction because the car runs out of oil. I have had my mechanic checking this car since I purchased it in January 2026. We have had to replace the oil pan and do two full oil changes with three separate quarts of oil being added in between all of that to keep it topped up. My mechanic agrees that the engine is consuming oil at an extremely high rate. My mechanic and a mechanic at the dealership where I purchased it are the only one who has inspected the car for this issue so far. The mechanic at the dealership is who recommended we replace the oil pan to see if that fixed the leak, which my personal mechanic did. Yes the critical engine failure lamp illuminates on the dashboard when the oil ran out the first time while I was driving it. This was how I discovered that there was an oil leak. This specific incident occurred three weeks after I purchased the car which I bought in mid-January of 2026.

I am submitting this complaint regarding ongoing and persistent mechanical issues with my vehicle since the time of purchase. The vehicle has repeatedly shut off unexpectedly, creating a serious safety concern. Initially, I suspected the issue might be related to the battery, and I have replaced the battery twice within the past 4 years. However, the problem has continued. In January, the vehicle began shaking and shutting down again. I took it to a mechanic, who diagnosed the issue as faulty spark plugs and an ignition coil. The diagnostic codes provided were P0303 and P0456, and the recommended repairs were completed. Approximately one month later, the vehicle began shutting off again. I then took it to the dealership, where I was advised that the valve cover gasket needed to be replaced, along with the belts, and that a fuel system cleaning was required. I subsequently had these repairs completed by my mechanic. Less than a week after completing those repairs, the vehicle once again began shutting down. A diagnostic scan then produced code P123300. In addition to these repeated shutdowns, the vehicle consumes an excessive amount of oil, has poor acceleration, and continues to stall unexpectedly both while driving on the road and while idling, such as in a drive thru. These recurring issues have made the vehicle unreliable and unsafe. I am concerned about the risk of the vehicle shutting off while in motion, which could lead to a dangerous situation. I am requesting that th

My teenage daughter regularly drives this vehicle. The vehicle began experiencing significant oil consumption, oil leaks, and intermittent loss of power. During an early inspection at an independent repair facility, a check engine code P1326 was identified. Due to the symptoms and diagnostic code, the repair facility advised that the vehicle could be heading toward engine failure and recommended that the vehicle be taken to an authorized dealership because potential engine issues may fall under manufacturer warranty coverage. The vehicle was then towed to an authorized dealership. During the first visit, the dealership retained the vehicle for an extended period of time, approximately two months. During that visit, several recommended services were completed, including replacement of spark plugs, ignition wires, and replacement of the valve cover gasket along with other recommended maintenance. During that visit, it was also stated that the vehicle has a known issue with excessive oil consumption. Because of this, the oil level is checked weekly and oil is added as needed. I also informed the dealership that the independent repair facility had identified code P1326, but I was told that the dealership diagnostic codes were different. After these repairs, the vehicle experienced another incident where it lost power and began idling roughly while being driven on a busy highway. The vehicle was taken back to the dealership. During that visit, it was stated that the fuel injector

About a month ago my paint on my 2018 Kia Optima snow white pearl car started bubbling, then it turned into peeling and has since then been coming off more and more. It is occurring right under the back seat of the drivers side window. Reading into this issue more, it is happening to many who own a Kia Optima owners, especially those who own the snow white pearl color. Kia is not helping customers who are out of warranty but since this is a manufacturer defect they should be, even if they are out of warranty.

It started with the oil. I constantly have to add oil. when it first started that’s what I was doing just adding oil. Then it got worse the engine light started to come on and it no longer gives me the low oil warning. I took it to the dealership and it was there for about three weeks. They said that the car needed a system update, they updated it and i took it home after that. Its been about a year since then and my car is still having the same issue and getting worse. I had to change the spark plugs a few times since then i also have oil coming out the back pipe and it’s been doing this since before I took it to the dealership. I also had to spend money on a rental car while it was at the dealership.

I turned the car off, it had difficulty turning back on and the brake pedal got really hard. I had to wait about 30-45 minutes and then I was able to get the car started and brake pedal back to normal and no lights. Recently, I left the car on to run into a shop real quick and come back out. When I got back to the car, the power steering light, battery, and warning light?(amber triangle with ! In the center of it) were all on. I rev the engine and the issue went away for a quick second but then came back on. To avoid turning my car off and being stuck, I just shift to reverse and tried to leave. I’m backing out of the spot and now the backup camera is going in and out lights flashing on the dash and I’m trying to brake but the brake pedal isn’t registering and next thing you know, I’ve backed into a guard rail. On the way to drop my kids off at the babysitter, I was coming to a stop sign, and my car wouldn’t brake, i went through oncoming trafic and had to run off the road. KIA did a multi point inspection a few months apart from one another. One the car tested fine, then the second time they are saying a brake booster and no engine oil in the vehicle and that the car is basically trash. The oil light goes on and off and I can smell burning oil. I still owe 7 grand on this car and I just bought it last year and it was seamingly fine.

I was sold an unsafe vehicle at J and J Auto house 6446 Wilshire Bl LA,CA 90022. Dealer withheld condition of car . Had car three months and was stranded on highway. Car was towed to Kia dealer and diagnosed with complete engine failure. Dealer will not honor limited warranty, shady sales practices withheld recall info during sale, won’t allow his mechanic to look at car, dodged calls, denied request to return car for refund

Steering column coupler went bad. Unable to swap out the coupler alone ($12 part) and had to get a whole new column (over $1200). Some of the Kia's around this one's make and model were recalled but not this one. Without this repair driving would have been dangerous.

My engine is under the Kia class action lawsuit for the KDS with the rod bearing clearance issues. I have done all my oil changes with paper work available. I got the update to the ECU several years ago as needed to be covered. Now my engine has failed and I took to the dealer to check but they said I didn't have a specific code and that they can't do any testing to verify it would be under the warranty. I called Kia Customer Care and have talked to them several times. They have told me there wasn't a need for the code and that the dealer could do other testing. The dealer stated that they can't do the BCT test due to a cylinder not having compression. I told Kia this is all related to the bearing going out and they said they can't do anything if the dealer said it's not under warranty. So I have now been going in circles with kia and dealer since 11/18/25. I sent kia another email on 12/15/25 and another on 12/18/25 due to not receiving a response. It's now 12/23/25 and still no response. They have a service bulletin that I seen online that was for dealers if any issues with testing they had other options but still nothing has been done.

While driving my 2018 Kia Optima S, the car suddenly jerked, lost power, and stalled in traffic. Multiple warning lights came on at the same time including the oil light, battery light, and check engine light. I had no acceleration and the brakes became very hard to press. The vehicle had to be towed for safety reasons. The Kia dealership inspected the vehicle and confirmed internal engine failure due to “cylinder failure” and stated the engine needs complete replacement. This failure occurred without any external leaks and without warning other than the sudden loss of power. The dealer stated the issue is not covered, even though it is clearly an internal engine malfunction. This is a major safety hazard because the stall happened while I was in active traffic. A sudden loss of power and braking ability puts me and others at risk of an accident. The problem has been confirmed by the Kia dealership through diagnostic testing. The vehicle is still available for inspection. Warning lamps appeared only at the moment of failure, giving no advance warning. This appears to be related to the ongoing engine defects in Kia vehicles involving oil starvation, loss of compression, cylinder scoring, and internal engine failure. Cylinder failure and sudden stalling should be investigated as part of the known safety-related engine defects affecting this model.

Paint on all four door handles are bubbling and chipping. I rarely use the backseat handles and passenger door, which makes it more likely to be a malfunction in whatever paint was used for the handles. There is no fading, chipping, or bubbling on other parts of my car.

Paint peeling from driver side door.

Car keeps stalling while driving

I was rearended, all air bags deployed except steeringwheel

On August 26, 2025, I brought my 2018 Kia Optima Plug-In Hybrid to an authorized dealer for recall SC218 (engine inspection and KSDS software update). The dealer verbally stated both SC218 and SC278 recalls were completed, and the repair order (RO #XXX) lists them as performed. In September 2025, Kia America emailed me showing recall SC218 still open, and a warranty coverage report dated September 26, 2025, again listed SC218 as unclosed. On November 4, 2025, NHTSA’s official VIN lookup confirmed the recall remains “Incomplete.” On October 21, 2025, Kia America emailed me under Case #XXX stating that SC218 was “confirmed completed” and that the dealer performed a software update to the ECU, referencing RO #XXX. However, NHTSA’s database still lists recall SC218 as incomplete. This contradiction between Kia America’s internal record, the dealer’s invoice, and the federal NHTSA database raises a serious safety concern that the recall inspection or software update was never actually performed or was never reported correctly. I have requested written proof and diagnostic data (Battery SOH report) multiple times but have not received them. If accurate, this means I was led to believe my vehicle’s engine-safety recall had been repaired when federal records still list it as open. I am requesting NHTSA to review this reporting discrepancy, ensure Kia America and the dealer produce verifiable proof of completion, and confirm that the federal record is corrected. INFORMATION REDACTED P

Trunk latch broke leaving it impossible for someone in the trunk to get out and very difficult for someone on the outside to open the trunk

I’ve had my car for 6 months and it constantly burns oil I’ve had 4 oil changes because it Is completely disappearing but my mechanics can not find any leaks. Then I changed all my spark plugs and two were completely burnt and they were changed a month ago and now one of them went again and this time is completely covered in oil

The engine of my 2018 Kia Optima is burning oil. When it started, I had 72,000 miles, and it's burning one quart of oil every thousand miles. There is no oil leak. I will take it back to Kia on October 2, 2025. The mechanic reported that it has an internal engine issue.

The oil consumption is burning at a faster rate than normal. My oil changes are always on time but for months I have been having to take it for an oil change about 2,000 miles below mileage time. I have had it inspected but found no oil leaks. This is a major problem for the engine and safety.

Engine seized and stopped working. While I could not find any recall information based on the VIN, it is a 2018 Kia which was subject to the Kia Engine Settlement (In re: Hyundai and Kia Engine Litigation , No. 8:17‑cv‑00838‑JLS‑JDE and Flaherty v. Hyundai Motor Company, et al. , No. 18‑cv‑02223 (C.D. Cal.)). Was never notified of such settlement as the VIN would have triggered this notification by Kia but they obviously did not list this in the recall.

I was driving on the highway with my children and the engine started to knock and lock up. I had to swerve onto an exit and roll into a gas station. My check engine light was on. I had it serviced in 2023 at a kia dealership. I had electrical issues to my battery that I opted to get fixed elsewhere. The dealership was aware of the recall on my engine, when I had it towed to them in 2025. Dealership said I opted out of a recall on my engine.

Car would convulse and shake very wildly metal parts spread around engine. It has very rough idle. 4th cylinder went out and car only has about 99060 miles. The valve went out. My safety was very bad as car was not driving safely and shaking like a person having a seizeure each time it would stop. Vehicle has been inspected by a Kia dealer. This problem I had seems to get an issue many other people with Kia Optima have.

My 2018 Kia Optima has a cracked oil pan, which caused an excessive oil leak —up to 5 quarts in a matter of hours. This eventually led to my engine going out.

Car suddenly stopped working; it was struggling to stay on. Mechanic stated cylinder is not functioning at full force.

My cars bulbs have been blowing on a regular basis for two years..some of the bulb connections are catching fire and exploding .Ive changed on numerous occasions but doesn’t matter even with new fittings…obviously an electric problem

The contact owns a 2018 Kia Optima. The contact stated that while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal with the oil warning light flashing on the instrument panel. The contact's friend initially inspected the vehicle and discovered that the engine oil was empty. The vehicle was taken to a dealer where a diagnostic test was performed, and the mechanic discovered oil around the engine; however, the source of the leak was not discovered. The contact was informed that an engine valve was sealed and that the failure was repaired. Despite the repair, the failure persisted, and the oil light was frequently illuminated on the instrument panel. The engine oil level was checked and was extremely low. The dealer had not offered any additional assistance for the repair. The vehicle was not repaired. The contact made several attempts to reach the manufacturer but was unsuccessful. The failure mileage was approximately 10,000.

My 2018 Kia Optima went into limp mode while exiting the freeway. I had it scanned and received a P1326 code, which is directly tied to the known engine knock sensor / bearing wear issue in Kia models. The engine light came on and the car lost power suddenly. This created a very unsafe situation. I contacted Kia, and they confirmed that my VIN is not included in the engine recall (KSDS campaign), even though my symptoms exactly match the covered vehicles. I am now stuck with an undriveable car and no recall coverage, even though I’m facing the same failure risk. I believe this VIN should be included, and that this is a clear safety issue. I am requesting the NHTSA to investigate and push Kia to expand coverage to include more affected vehicles.

My 2018 Kia Optima LX began using excessive oil (>3 quarts/1000 miles) just over 100K miles. I researched and found that the Theta II engine in my car is known for this. When I took my car to dealership (Stokes Hodges Kia, North Augusta, SC), with the check engine light on, they told me me plugs were fouled (they were just replaced 1 yr prior), cylinder 3 misfiring, and that I needed to pay a few thousand dollars to have repaired. When I asked them to guarantee the soaking process they recommended, they responded that they couldn't, that it "only worked 80% of the time." I have the KSDS download since 2019 and asked them to follow the guidelines of their TSB ENG 222 for the class action lawsuit and start a 1000 mile oil consumption test. they refused, basically telling me the only way to get a new engine from Kia, since my car is over 100K miles, is to drive it until the engine seizes. I expressed my fear for personal safety, but they wouldn't help me. I am original owner and have all services, etc documented. I called Kia customer affairs, then was told only local dealership could help. they stuck me in a loop between them without helping. Please help me.

Kia is aware of the engine oil consumption causing misfires, failed emissions test, blowing a rod and engine lock up. THEIR SOLUTION WAS A CLASS ACTION LAWSUIT THAT STATE ONCE THE CAR IS LOCKED UP OR ROD HAS BLOWN THROUGH THE ENGINE THEN THEY WILL FIX IT. I HAVE HAD TO ADD OIL AT LEAST 3 TIMES EVERY 3000 MILES AND CONTINUE TO REPLACE THE OIL FILTER AS WELL. THE SPARK PLUGS HAVE BEEN REPLACED MUTLIPLE TIMES ALSO TO HELP WITH THIS ISSUE. KIA ADVISED THAT MY VEHICLE DID NOT FALL UNDER THIS RECALL EVEN THOUGH MY VEHICHLE IS HAVING THE SAME ISSUES AS THE RECALL STATES. THIS IS A KNOWN ISSUE WITH THIS MAKE AND MODEL AND THEY SHOULD NOT BE ABLE TO GET AWAY WITH SELLING DEFECTIVE VEHICLES AND NOT REPAIRING THE ISSUES THEY KNEW THEY HAD PRIOR TO SELLING THE VEHICLES. SOMETHING NEEDS TO BE DONE.

Engine failed despite maintenance and repairs. The car is part of the active class action for Kia Engine Defects. The KSDS software was never installed as we were never notified about the recall by kia. As a result, Kia denied coverage under the engine defect class action settlement. We need this vehicle repaired or compensation for replacement

Purchased car about 4 months ago, before warranty ran out, the shop looked at it told me it was fine, it wouldn't accelerate. Few weeks later same issue but all my oil was gone, they found 11 things wrong with the vehicle, told me warranty wouldn't take care of it unless the engine blow up. The salesman Scottie Mitchell told me check Kia for recalls, called Kia 3 recalls, they were trying to finance another car higher, back wanted to know why the dealership didn't know about recalls, Kia place did call a Robert. One of the owners did know about recalls, why dealership didn't pass them on. They trying to sell me a higher vehicle to keep cover the cost of the one I got 1st

The car is literally burning through oil so bad every other week I am putting more in, the electrical system continues to fail and shorts, the motor sounds like it is ticking now due to the oil consumption.

The 2.4L Theta II engine in my 2018 Kia Optima is failing, exhibiting excessive oil consumption, with oil loss documented at over 1 quart per 1,000 miles, leading to secondary failures in the catalytic converter, clogged with oil carbon and breaking into pieces that may damage the cylinder walls, and the spark plugs, which are fouled with carbon, causing misfires. The engine and related components remain intact and un-repaired, pending Kia’s required 3,000-mile consumption test. Safety of drivers have been put at significant risk. The excessive oil consumption and potential engine seizure threaten sudden loss of power, especially on freeways where car fails to accelerate to city and highway speeds, increasing the chance of a collision. The clogged catalytic converter poses a fire hazard, (reported by NHTSA investigations into Theta II) where oil leaks or debris can ignite on hot surfaces. Risk is heightened during the mandated 3,000-mile test as well. Problem has been confirmed by both a dealer and an independent service center as recent at 1 July, '25, documenting oil loss and new engine recommendation. Symptoms began with noticeable oil loss during oil changes, starting at least 1 quart per interval on May 10, 2023 (mileage 43,374), with the loss increasing over time. Misfires and RPM loss during acceleration first appeared after the oil valve gasket replacement in late May 2025, and freeway pickup issues became apparent around mid-June 2025. The full engine failure was con

Got an oil change, and they advised that it was low on oil. (I had just replaced it recently) I took it to the dealer and they advised a part was bad, that they replaced. I was driving and the check engine light and oil light came on . I had to tow car. Dealer said the engine was burning oil, and that the engine is covered, but I would have to drive it until it got worse.

Subject: Urgent Request for Engine Replacement – 2018 Kia Optima Dear Kia Consumer Affairs, I am writing to formally report a recurring and increasingly dangerous engine issue with my 2018 Kia Optima, and to request immediate assistance, including consideration for an engine replacement due to ongoing safety and reliability concerns. Since June 2024, I have routinely visited the Kia dealership on a near-monthly basis for service due to persistent problems with excessive oil consumption and spark plug failures. Each visit has resulted in service-related expenses, despite my efforts to maintain the vehicle in accordance with manufacturer recommendations. Unfortunately, the issue has not been resolved and continues to worsen. Most recently, on [XXX], I experienced a critical incident. While driving, the engine began shaking aggressively, the check engine light illuminated, and smoke was detected coming from the engine compartment. Out of concern for my safety, I immediately pulled over and had the vehicle dropped off at a nearby garage for emergency inspection. This incident, combined with the repeated monthly service visits and associated costs, clearly indicates a systemic issue that may be linked to known engine defects in similar Kia models. I urge Kia to review my case for warranty coverage, recall eligibility, or goodwill engine replacement assistance. I have attached supporting documentation including service records, receipts, and oil consumption logs. Please advise on t

There is already the theta 2 campaign on my Kia optima but Kia is not upholding their warranty for a new engine. Kia customer care told me that untill my car actually throws a rod then they will not fix it. So I could be doing 80 down the freeway and jeopardize not only my safety but everyone else's for them to uphold their lifetime warranty? Also upon doing further investigation and I don't know how many cars this pertains to but the fuse box in my 2018 actually belongs to a 2016 which if you look it up yes they are comparable but don't offer all the same functions or power that my 2018 needs to run I fully believe Kia knew this when they were being built on the factory line because it just so happens that there is about 6 different versions to the pcb relay that can fit from a 2016 to a 2020 k5 but for some odd reason every car got something different why?

The contact owns a 2018 Kia Optima. The contact stated while driving 70 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact turned off the cruise control; however, the failure persisted, and the vehicle stalled. The contact stated that the check oil warning light was illuminated. The contact was able to coast to the side of the road. The vehicle failed to restart, and the vehicle was towed to a service station. The vehicle was then towed to a dealer where it was diagnosed and determined that the high-pressure fuel pump had failed, causing fuel intrusion into the engine and engine failure. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,000.

The contact called on behalf of his son who owned a 2018 Kia Optima. The contact stated that while driving at approximately 25 MPH, the front of the vehicle crashed into the rear end of the vehicle that was in front of him whom made a sudden stop. The contact was concerned that the air bags were not deployed. No warning lights was illuminated. A police report was filed. No medical attention was sought, and no injuries were sustained. The vehicle was pronounced totaled at the scene. The contact attempted to contact the manufacturer however, received no response. The failure mileage was 96,145.