2008 Ford F-550 SD

Defect. CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Risk. THIS DEFECT COULD RESULT IN A FIRE.

Remedy. CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.

Defect. FORD IS RECALLING 87,515 MY 2008 F250, F-350, F-450, AND F-550 VEHICLES FOR FAILING TO COMPLY WITH ALL THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." SOME 40% SPLIT AND CAPTAIN'S CHAIR DRIVER'S SEATS, EQUIPPED WITH LUMBAR SUPPORTS, MAY HAVE IMPROPER WELDS AT THE JOINT OF THE SEAT BACK PIVOT BRACKET AND THE SEAT BACK FRAME.

Risk. IN THE EVENT OF A CRASH, THE SEAT SIDE PIVOT BRACKET MAY CRACK OR BREAK, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.

Remedy. DEALERS WILL ADD A REINFORCEMENT TO THE DRIVER'S SEAT BACK FRAME ON THE 40% SPLIT OR CAPTAIN'S CHAIR SEAT EQUIPPED WITH LUMBAR SUPPORT OR, IF NECESSARY, THE SEAT BACK FRAME WILL BE REPLACED. THE RECALL BEGAN ON MARCH 28, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Defect. ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.

Risk. LACK OF POWER OR ROUGH OPERATION, UNUSUAL NOISES FROM THE ENGINE OR EXHAUST, WHITE SMOKE FROM THE EXHAUST, AND POTENTIALLY A VISIBLE FLAME OUT THE TAILPIPE CAN OCCUR.

Remedy. DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Defect. ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, INSUFFICIENT CLEARANCE OF THE BATTERY POSITIVE (B+) WIRE TO THE RIGHT HAND SPLASH SHIELD BOLT MAY RESULT IN THE BATTERY B+ WIRE CONTACTING THE SPLASH SHIELD BOLT.

Risk. LONG TERM CONTACT COULD CAUSE WIRE CHAFE, RESULTING IN COPPER WIRE BEING EXPOSED. IF THIS CONDITION OCCURS, THE BATTERY B+ WIRE COULD SHORT TO GROUND INCREASING THE RISK OF A FIRE.

Remedy. DEALERS WILL INSPECT THE BATTERY B+ WIRE LOCATION AND, IF NECESSARY, REPOSITION THE WIRE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Brought the truck in to ford and they told me that paint lining from the tank may of gone into the fuel lines and system so they suggested that we replace the tank and they also replaced 2 injectors and the wiring harness for the injectors and reset the check engine light drove fine till the check engine light come on then its in limp mode and only drives at 40 miles per hour it is unsafe to drive on the highway and I do like this truck

TRANSMISSION DOWN SHIFTS TO LOW GEAR WHILE DRIVING AT HIGH SPEEDS ON THE INTERSTATE.

TL* THE CONTACT STATED THEIR COMPANY OWNS A 2008 FORD F-550 SD. THE CONTACT STATED THE VEHICLE'S HEATER CHORD HAD FAILED A TOTAL 5 TIMES IN THE PAST 2 YEARS. THE VEHICLE HAD BEEN TAKEN TO THE DEALER (ROESH FORD LOCATED AT 303 W GRAND AVE BENTONVILLE IL 60106 PHONE NUMBER: 630-279-6000) WHO REPLACED THE HEATER CHORD A TOTAL OF THREE TIMES, HOWEVER, THE FAILURE PERSIST. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2008 FORD F-550 SD. WHILE DRIVING 65 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT AND THE VEHICLE STALLED. THE CHECK ENGINE AND ENGINE OVERHEATING INDICATORS ILLUMINATED DURING THE FAILURE. THE VEHICLE WAS TOWED TO CHAPMAN FORD OF HORSHAM (1100 EASTON RD, HORSHAM, PA 19044) WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE MILEAGE WAS 33,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2008 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 55 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND A "STOP SAFETY NOW" MESSAGE DISPLAYED. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EXHAUST FUEL TEMPERATURE SENSOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ISSUED A RECALL FOR THE 2011-2012 MODEL YEAR VEHICLES ASSOCIATED WITH NHTSA CAMPAIGN NUMBER: 13V535000 (ENGINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

WE BOUGHT THIS TRUCK AND PAID OVER 30K AND PUT DOWN 10K. THEY NEVER GAVE US THE FULL REPORT HISTORY OF THE TRUCK... WITH TWO TO THREE MONTHS THE ENGINE WENT OUT. WE TOOK IT TO THE MECHANIC AND HE TOLD US ITS NOT WORTH IT. THE ENGINE IF REPLACED WILL GO OUT AGAIN. FORD HAD A DIFFERENTCOMPANY BUILD THE ENGINES AND ALL OF THERE ENGINES WERE BAD. I BELIEVE FROM 2006 TO 2008 UNTIL FORD TOOK OVER. SO, WE BOUGHT THIS TRUCK FROM 1900 HAMNER AVE, NORCO, CA 92860 (951) 737-6151. WE CONTACTED THEM AND THEY DID NOTHING ABOUT IT. SO, NOW I AM STILL MAKING MONTHLY PAYMENTS OF 543 A MONTH AND THE TRUCK BROKE DOWN AROUND JUNE JULY OF2014. I'VE BEEN PAYING FOR STORAGE PLUS MONTHLY TRUCK PAYMENT. THIS COMPANY KNEW THE HISTORY OF THE TRUCK BUT THEY WENT AHEAD AND SOLD IT TO US. I FOUND OUT THE HISTORY BECAUSE THE LAWYER RECOMMENDED THAT TO ME. I GUESS ITS HARD FOR LEMON COMMERCIAL TRUCK TO HANDLE. I JUST WANT MY MONEY BACK AND FOR THEM TO TAKE THE TRUCK BACK. THEY HAVE BEEN FRAUDULENT ABOUT THIS. *TR

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

THE TRUCK HAS NOT RUN PROPERLY SINCE IT WAS PURCHASED, AND THE MOTOR WAS REPLACED BACK IN 2013 WITH MILEAGE OF 31,00 DUE TO OIL BEING SPLATTERED ALL OVER AND NO POWER. WE HAD SPEND OVER 10,000.00 TO FIX THE DEFECTIVE ISSUES. NOW ALMOST 2 YEARS TO THE DAY THE ENGINE HAS AGAIN FAILED. FORD OFFERS NO HELP OR EXPLANATIONS AS TO WHY THIS CONTINUES TO HAPPEN.. *TR

AT FORTY FIVE MILE AN HOUR THE TRANSMISSION LITERALLY FELL APART INTERNALLY. MY F-550 HAS ONLY PULLED A TRAILER FIVE TIMES AND IT HAS A COMPLETE TOW PACKAGE. I WAS NOT TOWING ANYTHING NOR DID I HAVE ANY OTHER WEIGHT ON THE TRUCK WHEN THE TRANSMISSION MADE A LOW CLUNK AND STOPPED FUNCTIONING. THE F-550 HAS LESS THAN 75000 MILES ON THE ODOMETER, AND HAS BEEN USED VERY SELDOM TO HAUL ANYTHING. I HAVE SPOKEN TO SEVERAL DEALERSHIPS CONCERNING THIS ISSUE AND FIND THAT MANY OF THESE SAME TRANSMISSIONS HAVE LIKEWISE FAILED.

THE RIGHT FRAME RAIL HAS COMPLETELY SEVERED AT THE RIGHT FRONT SHOCK. THE LEFT FRAME RAIL AT THE LEFT FRONT SHOCK IS 80% CRACKED. THE ENGINE CRADLE CROSS MEMBER ATTACHES IN THIS AREA. THE ENTIRE FRONT END OF THE TRUCK HAS DROPPED TWO INCHES. THE FAN SHROUD HAS DROPPED TO THE POINT THAT THE FAN HAS CUT A GROOVE IN IT. THIS IS A CAB/CHASSIS. *TR

BOTH FRAME RAILS ARE CRACKED AT THE LEFT AND RIGHT FRONT SHOCKS IN THE AREA OF THE ENGINE CRADLE CROSS MEMBER. THIS IS A CAB/CHASSIS TRUCK. *TR

VEHICLE OVERHEATS AND LOOSES POWER AT DIFFERENT SPEEDS; WE HAD OVER $1100.00 IN REPAIRS DONE AND IT STILL OVERHEATS WITH THE WRENCH LIGHT COMING ON, TOOK IT BACK TO MECHANIC AND HE RAN THE CODES AND NOW SAYS IT IS THE OIL COOLER NOT WORKING. FORD SAID THEY DO NOT HAVE A RECALL ON THIS AND THE HEART OF TEXAS FORD PLACE IN BRADY, TX MECHANIC SAID THERE ARE ALOT OF COMPLAINTS ON THIS OIL COOLER PART FOR THE F550 6.4 DIESEL. *TR

FORD 6.4L DIESEL ENGINES (2008-2010) IN F-250, F-350, F-450, AND F-550 TRUCKS CONTAIN RADIATORS THAT WERE IMPROPERLY CONSTRUCTED AND UNABLE TO WITHSTAND ENGINE PRESSURES AND LEAK COOLANT, AND CAN CAUSE CATASTROPHIC ENGINE FAILURES DUE TO OVERHEATING. FORD REPLACED COUNTLESS RADIATORS IN ITS 6.4L VEHICLES UNDER WARRANTY AND ISSUED A NUMBER OF SERVICE BULLETINS RELATED TO ITS 6.4L RADIATOR FAILURES. HOWEVER, EVEN ITS REDESIGNED RADIATORS CONTINUE TO FAIL. IN OUR VERY LOW MILEAGE F550 DIESEL, THE RADIATOR FAILED AT 23000 MILES EVEN AFTER BEING INSPECTED BY FORD AND "APPROVED" AS ADEQUATE. FORD REFUSES TO PROVIDE A FIX. THE FORD DEALERSHIP TELLS US THAT SOME CUSTOMERS HAVE REPLACED RADIATORS AS MANY AS 10 TIMES, OR MORE. AN INTERNET SEARCH (E.G., GOOGLE) FOR "FORD 6.4L RADIATOR" SHOWS COUNTLESS OTHERS HAVE EXPERIENCED MULTIPLE RADIATOR FAILURES. AGAIN, FORD IS UNWILLING TO RECALL THE DEFECTIVE ENGINE PARTS OR PROVIDE A WARRANTY REPLACEMENT. *TR

TL* THE CONTACT OWNS A 2008 FORD F-550. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP WAS CLOGGED DUE TO THE FUEL TANK DELAMINATING. AS A RESULT, BOTH THE FUEL PUMP AND THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED TO PAY THE REPAIR COSTS FOR THE FUEL PUMP AND A PERCENTAGE OF THE FUEL TANK REPAIR EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 32,000.

AN FORD F-550 DRIVEN BY [XXX], AN EMPLOYEE OF WIREGRASS CONSTRUCTION USDOT-[XXX], HIT MY WIFE'S CAR PUNCTURING THE DRIVER'S SIDE REAR TIRE AND RUINING RIM. UPON THE EXCHANGE AND THE VESTAVIA POLICE REPORT, DRIVER PRODUCED A PROOF OF INSURANCE OF TRAVELER'S INSURANCE THAT HAD EXPIRED. THIS VEHICLE WAS NOT IN POSSESSION OF THE CURRENT PROOF OF INSURANCE AND HAS STILL NOT RESOLVED OUR CLAIM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I AM ORIGINAL OWNER OF A 2008 F-550 SUPERDUTY USED FOR MY BUSINESS. IT HAS APPROXIMATELY 108,000 AND HAS REQUIRED THE REPLACEMENT OF ENTIRE ENGINE ASSEMBLY TWICE. BOTH INSTANCES THE TRUCK WAS TRAVELING DOWN THE INTERSTATE AT HIGHWAY SPEEDS WHEN THE FAILURES OCCURRED AND THE DRIVER WAS UNABLE TO GET TO SHOULDER OF ROAD. BOTH FAILURES ALSO GAVE NO WARNING. FIRST FAILURE OCCURRED IN AUGUST 2009 @ 32,225 WHEN DRIVER HEARD A LOUD NOISE COMING FROM ENGINE AND IT IMMEDIATELY STALLED. TRUCK WAS TOWED TO DEALER UPON WHICH IT WAS DETERMINED A CONNECTING ROD HAD GONE THROUGH BLOCK. THERE WAS NO EXPLANATION PROVIDED EXCEPT THE ENGINE WAS STILL UNDER POWERTRAIN WARRANTY. SECOND FAILURE OCCURRED APRIL 2012 @ 107,000 WHILE DRIVER WAS ON HIS WAY TO DEALER TO GET RADIATOR FIXED DUE TO A LEAK. HE WAS ON THE BELTWAY WHEN HE IMMEDIATELY STARTED TO LOOSE POWER, IT STALLED WITH A CHANCE OF GETTING TO SHOULDER. WHEN TOWED TO THE DEALER, IT WAS DIAGNOSED AS EXCESSIVE COOLANT IN OIL PAN (3 GALLONS) WHICH CAUSED INTERNAL FAILURE TO THE BEARINGS/CRANK/RODS. ENGINE HAD TO BE REPLACED AGAIN. THIS TIME FAILURE WAS CAUSED BY THE WATER PUMP FRONT COVER THAT WAS SEVERELY PITTED ALLOWING COOLANT TO ENTER ENGINE. THIS FRONT COVER HAD BEEN REPLACED AROUND 71,000 FOR SAME PROBLEM, WHICH ACCORDING TO THE MECHANIC, IS COMMON WITH 6.4L ENGINE. I HAVE SERVICED THIS TRUCK ACCORDING TO FORDS RECOMMENDATIONS. HAVE HAD THE OIL CHANGED MORE FREQUENTLY THAN 10,000 MILE THAT IS RECOMMENDED FOR THE TYPE OF USAGE. DEALER AGR

TL* THE CONTACT OWNS A 2008 FORD F550 SD DIESEL. THE CONTACT STATED THAT THE VEHICLE WOULD INDEPENDENTLY DECELERATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE THE PROBLEM. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

VEHICLE - EATON HYBRID FORD F550DR BUCKET TRUCK VIN [XXX]. DRIVING ON IH 35 AT APPROX. 50 MPH, TRAFFIC CAME TO AN ABRUPT STOP. I HIT THE BRAKES ON THE HYBRID TRUCK AND THE BRAKE PEDAL WENT TO THE FLOOR ( I WAS PUSHING THE PEDAL VERY HARD ), THE FRONT AND REAR TIRES DID NOT LOCK UP NOR DID I FEEL THE BRAKE PEDAL PULSATE INDICATING THE ABS HAD BEEN ACTIVATED. I HIT A VAN FROM BEHIND HARD ENOUGH TO PUSH IT FORWARD AND THEN HIT IT A SECOND TIME AND PUSHED IT UNTIL THE VAN BROUGHT US TO A STOP. I BELIEVE THE BRAKES FAILED, IT OCCURRED ONLY ONCE, RESULTING IN A COLLISION. I THINK THAT THE ADDED WEIGHT OF THE BATTERIES AND THE AERIAL TOWER ON THE 550 CHASIS IS MORE THAN THE BRAKES ON THE TRUCK ARE ABLE TO HANDLE. THE TRUCK WAS SENT FOR BODY REPAIR AND THEN TO RIATA FORD IN MANOR TX FOR THE BRAKES TO BE CHECKED. ACCORDING TO THE QUALITY CARE REPORT " TEST DRIVE VEHICLE AND BRAKE SYSTEM IS OPERATING PROPERLY. " NO PARTS WERE REPLACED. *TR

TL*THE CONTACT OWNS A 2008 FORD F-550. WHILE DRIVING APPROXIMATELY 50 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE CONTACT SMELLED A STRONG ODOR OF EXHAUST FUMES INSIDE THE CABIN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY REPLACED THE EXHAUST INLET PIPE AND OXIDATION CATALYTIC CONVERTER. THE FAILURE MILEAGE WAS 43,975. UPDATED 12/05/2011 *LN

TL*THE CONTACT OWNS A 2008 FORD F-550 SUPERDUTY. THE CONTACT STATED THAT THE ACR COOLER FAILED WHICH CAUSED ANTIFREEZE TO BE INJECTED INTO THE ENGINE FORMING A FUEL CLOUD BEHIND THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS TOLD TO MONITOR THE COOLANT AND CHANGE IT EVERY 15,000 MILES. THE DEALER INSTALLED A NEW ACR COOLER BUT THE FAILURE CONTINUED. THE CONTACT CALLED THE MANUFACTURER AND WAS AWAITING A RESPONSE. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 60,000. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.