2001 Ford F-550 SD

Defect. FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Risk. A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy. FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Defect. CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Risk. WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Remedy. FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Defect. ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Risk. IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Remedy. DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Defect. ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Risk. OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy. DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Defect. VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.

Risk. LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.

Remedy. DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Defect. VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.

Risk. IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.

Remedy. DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Defect. VEHICLE DESCRIPTION: TRUCKS EQUIPPED WITH COMMERCIAL TRUCK TIRES THAT HAVE STEEL CORDS IN THE TIRE SIDEWALL. THE VALVE STEMS MAY HAVE BEEN TORN OR DAMAGED DURING ASSEMBLY AND COULD LEAK CAUSING SIDEWALL DAMAGE.

Risk. IF NOT MAINTAINED, COULD RESULT IN A SIDEWALL ZIPPER FAILURE. A ZIPPER FAILURE DURING INFLATION OF A DAMAGED TIRE COULD RESULT IN INJURY TO SOMEONE NEAR THE TIRE.

Remedy. DEALERS WILL INSPECT THE VALVE STEMS FOR LEAKAGE, AND WILL REPLACE BOTH THE VALVE STEM AND THE TIRE IF LEAKAGE IS PRESENT. OWNER NOTIFICATION BEGAN MARCH 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

I was waiting at a red light and my truck started smoking and caught fire

FUEL TANK DELAMINATION LEADING TO STALLING AND EVENTUAL REPLACEMENT OF TANK AT MY COST.

SEAT BELT WILL NOT STAY LATCHED WHILE DRIVING VEHICLE. APPEARS TO BE LATCHED BUT WHEN VEHICLE ENGAGES THE SLIGHTEST BUMP ON THE ROAD THE BUCKLE RELEASES. I KNOW THIS WILL NOT HOLD IN THE EVENT OF A CRASH. RECALL WAS PERFORMED IN 2002, WHICH WAS JUST AN INSPECTION AT THAT TIME BUT REPLACEMENT WAS NOT PERFORMED AT THAT TIME.

THIS BEING 2ND DIESEL FORD TRUCK THAT HAS HAD SAME ISSUE....LOSING POWER , BLOWING SMOKE. ON THIS 2001 , I HAVE REPLACED NUMEROUS FILTERS, DRAINED TANK TO CLEAN ,WIRE HARNESSES,FUEL INJECTORS ONLY TO REPLACE MOTOR WITHIN A MONTH OR SO DUE TO CONTAMINATION TO SYSTEM ALSO TRANSMISSION WAS REPLACED BEFORE NEW MOTOR WHICH I FEEL COULD OF BEEN DUE TO STRAIN ON VEHICLE....NEEDLESS TO SAY THE TRUCK HAS STARTED THE SAME PROBLEM AGAIN.I HAVE SANK SO MUCH INTO IT I'D NEVER GET MY MONEY OUT OF IT IF SOLD.I FEEL THAT FORD SHOULD BE HELD RESPONSIBLE FOR THIS ISSUE AND ALL THE MONEY PEOPLE HAVE PUT OUT TO CORRECT THE ISSUES OCCURRING, WITH HUNDREDS OF OTHERS. THIS ISSUE IS VERY DANGEROUS WHEN YOUR TRYING TO GET HOME AND IT STALLS OUT WHEN DRIVING DUE TO LOSS OF POWER. *TR

TL* THE CONTACT OWNS A 2001 FORD F-550 SD. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE PAINT INSIDE OF THE FUEL TANK WAS CHIPPING AND CONTAMINATING THE FUEL SYSTEM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2001 FORD F-550 SD. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FAILURE OCCURRED AS A RESULT OF PAINT DELAMINATING INSIDE OF THE FUEL TANK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.

I HAVE A 2001 FORD F550 SUPER DUTY FLATBED TOWTRUCK, THE TRUCKS DESIGN IS A COMBINATION FROM FORD AND INTERNATIONAL, WHICH DUE TO THE FAULTY FUEL TANK DELAMINATING AND CAUSING A FINANCIAL LOSE OF NOT ONLY A DAYS WORK, BUT ALSO THE NEED OF HAVING A TWO VEHICLES WHICH WHILE IN TOW STOP TRAFFIC WHEN ALL OF A SUDDEN THE TRUCK LOOSES POWER AND SERVICE ENGINE SOON LIGHT TURNS ON. COST OVER 1000.00 JUST IN WRECKER BILLS, AND NOT TO MENTION TRASHED THE INJECTORS, PUMP, AND FILTER SYSTEM AND ALL THE LINES. FORD OR INTERNATIONAL WILL NOT TAKE ANY RESPONSIBILITY FOR A BAD FUEL TANK RECALL. TRUCK IS STILL DOWN AND SEEMS THAT I WILL PROBABLY HAVE TO REPLACE ALL PARTS MENTIONED AT MY COST. *TR

WE OWN A LANDSCAPE CONST BUSINESS AND WE HAVE 3 FORD F550'S AND ALL 3 HAVE LEAKS IN THE GAS TANKS. THIS IS A VERY LARGE SAFETY HAZARD AND WE WOULD LIKE THIS ADDRESSED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WE OWN A LANDSCAPE BUSINESS IN SOUTH JERSEY. WE HAVE 3 FORD F550'S AND ALL 3 HAVE LEAKS IN THEIR GAS TANKS. IM FILING A COMPLAINT FOR EACH ONE. WE WOULD LIKE THIS INVESTIGATED, ITS A MAJOR SAFETY HAZARD. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WE HAVE 3 FORD F550'S THAT HAVE GAS TANK LEAKS. *TR

TL* THE CONTACT OWNS A FORD F550. WHILE DRIVING APPROXIMATELY 70 MPH THE VEHICLE STALLED WITHOUT WARNING AND WAS TOWED TO AN INDEPENDENT MECHANIC. THE MECHANIC ADVISED THAT THE FUEL TANK WOULD NEED TO REPLACE BUT THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE PART WAS NOT AVAILABLE BECAUSE THERE WAS A HIGH DEMAND FOR THE FUEL TANK. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

JUNE 21, 2007AT SHOP FOR STATE INSPECTION ALSO ENGINE MISSING. REPLACE FUEL FILTER DURING REGULAR SERVICE DUE TO MISSING ENGINE. JUNE 17, 2008 - VEHICLE MISSING AND STALLING, DIAGNOSTICS DONE , REPLACED WIRE ASSEMBLY AND GASKET VALVE COVER, CLEANED MOTOR SEPT. 23, 2008- MISSING IN ENGINE AND STALLING, DIAGNOSTICS DONE, REPLACED CAMSHAFT SENSORS AND CARB CLEANER ADDED SEPT. 25, 2008 - MISSING AND STALLED WOULD NOT START TOWED TO SHOP. DIAGNOSTICS DONE, DRAINED FUEL TANK DISCOVERED PEELING AND SLIVERS, REPLACED FUEL PUMP, GASKETS AND WIRE ASSEMBLY, FUEL INJECTORS AND REPLACED FUEL TANK. *TR

I AM HAVING PROBLEMS WITH MY FORD TANK FALLING APART INSIDE - HAVE DONE MY RESEARCH AND READ ABOUT 100+ POSTS FROM OTHER PEOPLE WITH THE SAME PROBLEM, NO CAUSED BY THE FUEL, BUT BY THE TANKS CHEAP DESIGN. ITS GOING TO COST THOUSANDS OF DOLLARS TO FIX - THIS IS NOT FAIR - FORD KNOWS OF THIS PROBLEM, AND THEY SHOULD FIX IT!!!!! *TR

TL*THE CONTACT OWNS A 2001 FORD F550. WHILE DRIVING APPROXIMATELY 55 MPH ON NORMAL ROAD CONDITIONS, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURE WAS RELATED TO THE COMPUTERIZED SYSTEM. THE VEHICLE WAS REPAIRED. RECENTLY, THERE WAS CORROSION IN THE FUEL TANK. THE FUEL TANK WAS REPLACED AND THE VEHICLE IS CURRENTLY OPERATING PROPERLY. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE VIN AND MILEAGES WERE UNKNOWN.

I HAVE BEEN EXPERIENCING POWER FAILURE, FUEL STARVATION ON MY 2001 F550 DIESEL TRUCK. I REPLACED THE FILTERS TODAY AT THE ONSET OF THE INCIDENT, BUT JUST REPLACED THEM ABOUT A MONTH AGO WITH MY MECHANIC. IT RUNS FINE ON LEVEL GROUND, BUT AT AN INCLINE IT LOSES POWER AND BARELY MAKES IT UP A HILL. I REMOVED THE TANK PUMP FROM THE TOP OF THE TANK AND LOOKED IN TO IT WITH A FLASHLIGHT. THE LINING OF MY TANK IS PEELING OFF. AFTER INVESTIGATING ONLINE, I FIND THIS IS A SERIOUS ISSUE WITH FORD. I CANNOT AFFORD TO REPAIR THIS VEHICLE AGAIN. I RUN A SMALL BUSINESS, AND RELY ON THIS ONLY TRUCK TO SUPPORT MY FAMILY OF 7 KIDS, WIFE AND MOTHER. I HAVE PUT 3 TRANSMISSIONS IN THIS VEHICLE IN ITS 110,000 MILE LIFETIME, AND NOW THIS. *TR

FORD RECALL # 05S28, SPEED CONTROL DEACTIVATION SWITCH. HAVE A MOTORHOME UNDER THIS RECALL. HAVE BEEN TRYING SINCE SEPTEMBER TO GET IT FIXED. FORD CONTINUES TO PUT OFF AVAILABILITY OF PARTS. IT'S IS NOW IN JANUARY. TIME SPENT IN THE MOTORHOME IS NERVOUS TIME, NOT KNOWING IF FIRE WILL ERUPT AT ANY TIME. WHAT CAN BE DONE? THANKS *TR

VEHICLE PARKED IN GARAGE OVERNIGHT WITH BLOCK HEATER PLUGGED IN. BLOCK HEATER POWER CORD FAILED RESULTING IN FIRE. VEHICLE ENGINE COMPARTMENT BURNED AS WELL AS THE GARAGE. *NM

DT: THE CONSUMER STATED 2001 FORD F550 SUPER DUTY CAUGHT ON FIRE UNDER THE DASH BOARD. CONSUMER'S HUSBAND WAS DRIVING THE VEHICLE WHEN IT CAUGHT ON FIRE, GOING APPROXIMATELY 45 MPH. ACCORDING TO THE HUSBAND, HE SMELLED SMOKE AND SAW FIRE. PULLED OVER TO TRY AND PUT THE FIRE OUT. THE OTHER PEOPLE IN THE VEHICLE GOT THE ITEMS OUT OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND TOLD THE CONSUMER THERE WAS A WRONG FUSE IN IT, INSTALLED BY THE CONSUMER'S MECHANIC. THIS HAPPENED ON JULY 13, 2005. THERE WAS NO ONE INJURED, NEITHER THE FIRE OR POLICE DEPARTMENT WAS NOTIFIED. CONSUMER HAS NOT NOTIFIED THE MANUFACTURER, BUT THE DEALERSHIP SAID THEY DID. CONSUMER IS NOT SURE WHETHER ANYTHING IN THE CAB OF THE VEHICLE WAS DAMAGED.*AK

SIX OF THE VEHICLE'S WHEELS LEAKED AIR. *NM *SC

CONSUMER STATES HAS HAD 3 BLOWOUTS DUE TO DEFECTIVE TIRE VALVE STEMS. VALVE STEMS ARE LEAKING CAUSING TIRES TO DEFLATE RESULTING IN THE BLOWOUTS. TS