2021 Ford Escape Hybrid

Defect. Ford Motor Company (Ford) is recalling certain 2021 Escape Hybrid vehicles. The engine crankshaft may have been manufactured incorrectly, which can result in engine damage.

Risk. Engine damage can cause a vehicle stall or fire, increasing the risk of a crash or injury.

Remedy. Dealers will inspect the crankshaft and replace the engine, as necessary, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed March 2, 2022. Owner notification letters were mailed on March 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S10.

On Saturday at approximately 8:25 p.m., my 2021 Ford Escape Hybrid SEL abruptly entered limp mode while traveling on a major highway. The vehicle's speed rapidly dropped from approximately 60-65mph to 20 mph in heavy, high-speed (many driving over 70mph)traffic. I immediately activated my hazard lights and exited the highway at the first opportunity, narrowly avoiding a serious fatal collision. Today, Crossroads Ford in Apex, North Carolina, informed me that the issue was caused by a faulty engine sensor. Given the severe safety hazard this created and the existing recalls associated with this vehicle model, I am requesting that this matter be fully addressed. I am currently being told that I will be required to pay for these repairs out of pocket, which I do not believe is appropriate for a critical safety failure. Thank you for your prompt attention to this urgent matter. I look forward to your response regarding how this issue will be resolved.

The fuel door actuator malfunctioned, rendering the emergency release ineffective. This necessitated a replacement at 30,000 miles or four years from the manufacturing date. We believe that an inoperable fuel door presents a significant safety concern.

The contact owns a 2021 Ford Escape. The contact stated that while driving approximately 45 MPH, the vehicle suddenly decelerated and failed to properly accelerate while depressing the accelerator pedal. The vehicle was parked on the side of the road and was later towed to the local dealer. The vehicle was serviced by the dealer. No further information was available. The contact stated that after retrieving the vehicle, the vehicle unintendedly accelerated and erroneously accelerated into an intersection. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 50,000.

Seatbelt locks in position on the passenger side. Must stop car let seatbelt retract all the way and reattach seatbelt. Dealer wanted $225 to diagnose problem if they could not find and/or duplicate issue.

After picking my vehicle up from a day and a half of recall repairs, I immediately experienced a rubbing sound and a shuddering when I turned my wheels to the right and moved forward as I attempted to drive away from the parking space. There were no issues when turning the wheels to the left to back out of the parking space. I immediately pulled into the service bay to report the problem. A maintenance tech came out and asked to drive it. When the vehicle was returned, I was told they felt it was the rear differential but would need to schedule another appointment so they could listen to it more, at a cost of $130 to diagnose. I researched this issue and found out that a recall has been issued for a different lot of VINs for 2021 Ford Escapes for this same issue due to installation errors or incorrect lubrication.

Subject: Formal Complaint – Recall 23B56 & 23S27 + Rental Car Reimbursement Demand – McCombs Ford (7111 NW Loop 410) To Whom It May Concern, I am writing to file a formal complaint regarding the unacceptable service I experienced at McCombs Ford West, located at 7111 NW Loop 410, San Antonio, TX, concerning two open safety recalls on my 2021 Ford Escape, VIN: [XXX] and to formally request reimbursement for out-of-pocket expenses caused directly by the dealership's failure to prepare for my scheduled appointment. I scheduled a service appointment in February 2026 to address two outstanding safety recalls: •Recall 23B56 – Inspect front door check-arm reinforcement spot welds •Recall 23S27 – Underhood fire risk After waiting nearly five months, I was given an appointment on July 7, 2026. I dropped off my 2021 Ford Escape on July 7, 2026 as scheduled. At drop-off, I was informed the repairs would take multiple days, and I was told no loaner vehicle would be provided. Based on that, I rented a vehicle at my own expense to cover my transportation needs. The following day, I received a call from the service department informing me: 1.Recall 23B56 (Door Reinforcement): The dealership was unable to perform the repair because they had never ordered the required replacement door — despite having five months' notice from my original February 2026 booking. They stated they would "order it now." This is entirely unacceptable and reflects a clear failure of basic service planning. 2.Recall

While driving the vehicle it lost power and all the check lights came on. Had to have it towed to a dealership where they stated it needed a new motor and new high voltage battery. The car has only 116000 miles on it. There should be a total recall for this type of vehicle if I would have been at a higher speed I would have injured myself or others. This car is riddled with problems and has over 19 recalls as of date.

While vehicle is set on cruise control , set at 70 MPH , ( or set to any other speed) , anytime the speed limit changes to 80 MPH (or other change) Car accelerates and cruise control is set to 100 MPH . It also accelerates and resets to 90 -100 MPH at random . It is frightening and dangerous to have my car randomly accelerate. I have attempted to pass a vehicle, when my car randomly accelerates to 100 MPH . This is very dangerous and can happen at any random time . The lane assist is also dangerous when car can not see lines separating lanes . I have had my car jerk the wheel when I was detoured through construction. I am very concerned with my car accelerating. Not only does it leave me vulnerable to receiving a speeding ticket , it also increases the likelihood of hitting an object or having an accident.

I own a 2021 Ford Escape Hybrid SEL, VIN [XXX]. The vehicle currently has approximately 104,708 miles. The vehicle has developed a shuddering, vibration, and chatter condition during low-speed turns, parking maneuvers, backing up, and other tight turning situations. The condition is most noticeable while turning in parking lots and at low speeds. The vehicle was inspected by a Ford dealership while it was being repaired for a separate engine concern. During that inspection, the dealership diagnosed a rear differential/internal clutch concern and provided an estimate of approximately $2,709 for repair. After receiving the diagnosis, I learned that Ford issued TSB 25-2351 regarding low-speed turning chatter, vibration, and shudder concerns on certain Ford Escape vehicles. My vehicle is experiencing symptoms consistent with those described in the bulletin. In addition to the vibration and chatter during turns, I have also noticed abnormal noises from the vehicle during low-speed maneuvering and when shifting into park. The condition appears to be worsening with continued operation. I contacted Ford Motor Company and opened a customer assistance case regarding this concern. I later contacted Ford again to update my case and advise them that my vehicle is experiencing symptoms consistent with TSB 25-2351. Ford advised me that there are currently no recalls, special coverage programs, or customer satisfaction programs available for my VIN. I was advised to keep my repair records an

My driver front door latch assembly failed at 42,153 miles. I had it inspected and repaired at the dealership. I had to pay out of pockets due to no longer being covered by the 3/36 warranty. The symptoms were that the driver front door would not lock at all. It took a while to figure this out as I just thought maybe we left it unlocked. Also this vehicle has the perimeter key fob so it automatically unlocks when you have the fob with you and attempting to open. This had been going in fine moths u til we figured out the problem and took it to the dealership. They did offer a discount since I purchased it there but they said due to the design it messed an entire assembly and was over $1k before the discount. They also had parts in stock and I did confirm they had seen this failure before. While we did not have an actual incident happen with us, our vehicle was vulnerable and we had no idea, because the lock appeared to work and it still moved visually, it just wasn’t actually doing anything inside the door. This is my wife’s vehicle so my fear was either someone breaking into the vehicle or even worse, attempting to enter the vehicle while she was inside but she would be unable to lock the doors. As mentioned, the dealer did repair the vehicle and it is worked properly for now. Thought we did have to pay out of pocket.

The display screen goes black and freezes for long periods and during navigation use; Reverse camera is black or doesn't display; FordPass doesn't connect

The contact owns a 2021 Ford Escape. The contact stated that while the vehicle was being Emissions tested, the contact was informed that the OBD Port was inoperable, and the emissions test could to be performed. The vehicle was taken to the dealer where it was diagnosed with a failed OBD Port. The contact was informed that the OBD Port needed to be replaced. The vehicle was repaired. The contact was informed that the repair was not covered under an unknown recall or warranty. The vehicle was repaired. The manufacturer was made aware of the failure, and a case was filed, and the case was denied. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 36,702.

There was a clunking sound when I opened the sun roof. Later when we closed the sun shade, it seems to be hesitating. The next time we opened the sun shade, it seems to be catching. As I drove there was a sliding sound that we finally identified as coming from the sunroof. Something could be seen from the sunshade: an outline of something that continued to slide around in all directions. I looked it up on the internet, concerned about what it could be and discovered that there have been 2021 Escapes with the panoramic sunroof that have a manufacturing defect resulting in poor adhesion of the fixed glass panel and/or front panel to the roof frame. There was a warning that The roof panel or front panel could detach from the vehicle while driving. Detachment could result in injury or death to road users. It can also lead to water leaks and wind noise which it links to the drip rails. I am concerned that this item sliding around is going to tear the headliner and fall on me or a passenger and am not sure it IS a drip rail.

The contact owns a 2021 Ford Escape. The contact was informed at a State Inspection that the gateway module had failed and needed to be replaced to complete the State Inspection. The vehicle was taken to the dealer, where the gateway module was updated. The contact related the failure to Ford Campaign Number: 22N15. The manufacturer was notified of the failure but denied reimbursement for the repair. The failure mileage was approximately 14,300. A complaint was filed with the manufacturer as well as the NHTSA.

I was leaving work and my 2021 Ford Escape hybrid started but then a triangle warning light came on, a "stop safely now" warning appeared and the car shut off. There were no problems prior to this event. I had the vehicle towed to a Ford dealership in February where they replaced the 12v battery and the machine needed to diagnose the electrical issue was down. Yesterday I finally got news that it was firing code P0DE6 and the hybrid battery needs replaced as well. There have been several recalls related to hybrid batteries with these same warning indicators, however my car's VIN was not included in the recall. Could the recall be extended to include other vehicles that this is happening to? It seems as if there are many more out there than what the recall covered and it's a much bigger issue than Ford may realize. People's cars could just shut down in the middle of the road with little to no warning.

The liner for the panoramic sunroof has come off the tracks on the sides so the liner hangs down into the car and obstructs the view.

The contact owns 2021 Ford Escape. The contact stated that the rear passenger’s side window failed to operate as designed and was stuck in the open position and failed to close. The vehicle was taken to the local dealer who repaired the vehicle. No further information was available. The contact stated that the failure recently reoccurred with the rear driver’s side window. Additionally, the instrument cluster malfunctioned, and the contact was unable to view the speedometer and fuel gauge. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was unknown.

My engine failed while driving. Towed to Ford dealership, found out about recall 23S27. Symptoms were the EXACT same but ford is refusing to cover warranty repairs because they said it did not throw the proper code. However ford has offered to cover half of the engine replacement, leaving me with a $4000 bill. Do I have any options? Is there a system of checks and balances that assures that ford is doing everything correctly on their end?

From the Ford website: "Power window switch chrome tip replacement Campaign/NHTSA# 22N17 Issue Date 2023-05-16" The tips peeled off and I get cuts on my fingers. Ford dealership, Golf Mill Ford in Niles IL, informed me this is a VIN specific issue and I needed to file this claim. Please advise.

The contact owns a 2021 Ford Escape. The contact stated while driving 35 MPH, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed that the high-voltage battery had failed and needed to be replaced. The contact stated that the dealer reset the check engine warning light. The contact stated that the following day after the reset, the check engine warning light illuminated a second time. The contact related the failure to NHTSA Campaign Number: 21V869000 (ELECTRICAL SYSTEM, HYBRID PROPULSION SYSTEM); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 129,000.