1995 Ford Contour

Defect. FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.

Risk. THE NUTS INCLUDED IN THE PACKAGING FOR THESE BALL JOINT ASSEMBLIES ARE MISSING THE INTENDED PREVAILING TORQUE (SELF-LOCKING) FEATURE. IF THE INCORRECT NUT WAS TO BECOME LOOSE, THE JOINING MEMBERS MAY LOOSEN LEADING TO A SEPARATION OF THE BALL JOINT. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. FEDERAL MOGUL WILL NOTIFY OWNERS AND REPLACE THE PARTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 22, 2008. OWNERS CAN CONTACT FEDERAL MOGUL AT 877-489-6659.

Defect. CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Risk. LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Remedy. AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Defect. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1997 FORD CONTOUR AND MERCURY MYSTIQUE VEHICLES. THE HEATER BLOWER RESISTOR COULD OVERHEAT CAUSING THE ATTACHED ELECTRICAL CONNECTOR TO MELT.

Risk. THIS COULD CREATE THE POTENTIAL FOR A FIRE.

Remedy. FORD WILL PROVIDE ADDITIONAL WARRANTY COVERAGE FOR THE HEATER BLOWER SWITCH FOR 10 YEARS FROM ORIGINAL DATE OF SALE OF THE VEHICLE OR 150,000 MILES, WHICHEVER COMES FIRST. DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS FREE OF CHARGE.

Defect. VEHICLE DESCRIPTION: 1995 PASSENGER VEHICLES EQUIPPED WITH THE 2.0L AND 2.5L ENGINES, AND 1996 VEHICLES EQUIPPED WITH 2.5L ENGINES. TIGHTENING OF THE ENGINE COOLING FAN MOTOR BEARINGS, UP TO AND INCLUDING MOTOR STALL, CAN RESULT IN INCREASED MOTOR TORQUE AND HIGHER THAN NORMAL MOTOR CURRENT AND ACCOMPANYING HIGH MOTOR TEMPERATURES.

Risk. OVERHEATING OF THE COOLING FAN MOTOR DUE TO EXCESSIVE CURRENT CAN RESULT IN SMOKE AND ODORS FROM BEARING GREASE, INSULATION AND OTHER INTERNAL MOTOR COMPONENTS. IF ELECTRICAL CURRENT CONTINUES TO BE APPLIED TO THE MOTOR, INTERNAL MOTOR COMPONENTS COULD IGNITE POSSIBLY IGNITING OTHER ENGINE COMPARTMENT COMPONENTS.

Remedy. DEALERS WILL INSTALL A POSITIVE TEMPERATURE COEFFICIENT DEVICE IN-LINE WITH EACH FAN MOTOR. FORD WILL ALSO EXTEND THE WARRANTY ON THE ENGINE COOLING FAN ASSEMBLY TO A TOTAL OF 8 YEARS OF SERVICE OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2001.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Risk. THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Remedy. DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE TRACTION CONTROL OPTION. THE THROTTLE CABLES WERE DAMAGED DURING VEHICLE ASSEMBLY LEADING TO FRAYING OR SEPARATION OF THE THROTTLE CABLE.

Risk. THIS CONDITION COULD PREVENT THE ENGINE FROM RETURNING TO IDLE.

Remedy. DEALERS WILL REPLACE THE THROTTLE CABLE WITH A REVISED DESIGN THAT IS LESS SUSCEPTIBLE TO BENDING OR KINKING DURING INSTALLATION.

Defect. THE FUEL TANK FILLER PIPE OPENING REINFORCEMENT, CONSTRUCTED FROM TWO SEPARATELY MOLDED PIECES, CAN LEAK AT THE WELD.

Risk. FUEL LEAKAGE CAN RESULT IN A FIRE.

Remedy. DEALERS WILL REPLACE THE FUEL TANK ASSEMBLIES WITH UNITS CONTAINING ONE-PIECE MOLDED REINFORCEMENTS.

Defect. CRACKS HAVE BEEN FOUND IN THE FRONT SAFETY BELT OUTBOARD ANCHOR TABS DUE TO A COMBINATION OF HYDROGEN EMBRITTLEMENT OF THE TAB AND STRESS INTRODUCED DURING ATTACHMENT OF THE ANCHOR TAB TO THE SEAT FRAME. THIS DOES NOT CONFORM WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."

Risk. CONSEQUENCE OF NON-COMPLIANCE: A FRACTURE OR SEPARATION IN THIS AREA WOULD REDUCE THE LOAD THAT THE ANCHOR AND THE FRONT SAFETY BELT ANCHORAGES COULD SUSTAIN, INCREASING THE RISK OF INJURY IN A VEHICLE COLLISOIN.

Remedy. DEALERS WILL INSPECT AND INSTALL AN ANCHOR TAB REINFORCEMENT OR REPLACEMENT OF THE COMPLETE FRONT SEAT BELT ASSEMBLY IF AN ANCHOR TAB IS FOUND TO HAVE FRACTURED.

Defect. THE PASSENGER SIDE AIR BAG HAS AN INFLATOR BODY THAT CRACKED DURING FORMING OF THE CURL THAT RETAINS THE IGNITER PLUG IN THE END OF THE INFLATOR. ALSO THE IGNITER END CAP CAN SEPARATE FROM THE INFLATOR.

Risk. THE PASSENGER SIDE AIR BAG MAY NOT INFLATE PROPERLY RESULTING IN REDUCED OCCUPANT PROTECTION IN A VEHICLE ACCIDENT. IF THE IGNITER END CAP SEPARATES IN A FRONTAL COLLISION, HOT GASES CAN BE RELEASED AND IGNITE FLAMMABLE MATERIAL OR CAUSE BURN INJURIES.

Remedy. DEALERS WILL REMOVE AND REPLACE THE PASSENGER SIDE AIR BAG MODULE.

Defect. THE GLASS TEMPERING PROCESS ON THE RIGHT HAND REAR DOOR WINDOWS WAS NOT CORRECTLY PERFORMED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 205, "GLAZING MATERIALS."

Risk. CONSEQUENCE OF NON-COMPLIANCE: IF THE WINDOW BREAKS, THE GLASS FRAGMENTS OF THE REAR WINDOWS EXCEED THE SIZE SPECIFICATIONS OF FMVSS NO. 205.

Remedy. DEALERS WILL REPLACE THE RIGHT REAR DOOR GLASS.

Defect. THE FUEL TANK FILLER PIPE OPENING REINFORCEMENT CAN LEAK AT THE WELD.

Risk. FUEL LEAKAGE CAN RESULT IN A FIRE.

Remedy. DEALERS WILL INSPECT AND, AS APPROPRIATE, REPLACE THE FUEL TANKS.

Defect. A METAL SHIELD ON THE OUTSIDE OF THE PLASTIC FUEL FILLER PIPE CAN DEVELOP A STATIC ELECTRICAL CHARGE DURING REFUELING OF THE VEHICLE.

Risk. A STATIC CHARGE CAN DISCHARGE AND SERVE AS AN IGNITION SOURCE FOR FUEL VAPORS IN THE AREA OF THE FILLER PIPE, RESULTING IN A FLASH VAPOR IGNITION AND A VEHICLE FIRE.

Remedy. DEALERS WILL INSPECT AND, IF NECESSARY, MODIFY THE VEHICLES BY ADDING A GROUND STRAP BETWEEN THE FILLER PIPE SHIELD AND THE BODY.

There is no summary currently available

There is no summary currently available

There is no summary currently available

There is no summary currently available

There is no summary currently available

Odi opened this investigation on august 18, 1999, based on four reports of fire involving the engine cooling fan.the reports allege the electronic cooling fan caught fire with resultant damage to the fan and wire harness and/or the harness connector.in its pe response, FORD provided information relevant to 46 additional alleged fire incidents and 47 alleged failures of the cooling fan involving thermal damage to the fan.this investigation has been upgraded to further study the issue.

There is no summary currently available

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT

SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT AND/OR EGR DIAGNOSTIC TROUBLE CODES 332, P0401, P1407 (LACKOF EGR FLOW). *TT

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT

OWNER NOTIFICATION PROGRAM REGARDING ADDITONAL COVERAGE FOR THE ENGINE COOLING FAN. *TT

SOME VEHICLES EQUIPPED WITH A 2.5L DURATEC ENGINE MAY EXHIBIT AN ENGINE OVERHEAT CONDITION DUE TO LACK OF CIRCULATION OF COOLANT. *JB

TL* THE CONTACT OWNS A 1995 FORD CONTOUR. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AFTER FIFTEEN MINUTES AND DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT A NEW TRANSMISSION SENSOR WAS NEEDED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000. MA 10/2 UPDATED 11/28/2017*CN

TL* THE CONTACT OWNS A 1995 FORD CONTOUR. THE CONTACT STATED A BURNING ODOR WAS EMITTED FROM THE AIR VENTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS, WHERE THE MECHANIC STATED THAT THE INSULATION ON THE WIRING HARNESS HAD MELTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V367000 (ENGINE AND ENGINE COOLING). THE APPROXIMATE FAILURE MILEAGE WAS 158,140.

TL* THE CONTACT OWNS A 1995 FORD CONTOUR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE TIRE WAS FLAT. THE TIRE WAS REPLACED WITH A SPARE, WHICH WAS ALSO PUNCTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE FRONT DRIVER AND PASSENGER SIDE COIL SPRING WOULD HAVE TO BE REPLACED AS WELL AS THE SPARE TIRE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

TL* THE CONTACT OWNS A 1995 FORD CONTOUR. THE CONTACT STATED THAT WHILE PARKED, A BURNING ODOR BEGAN TO EMIT FROM THE VENTS. IN ADDITION, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS, WHERE THE MECHANIC STATED THAT THE INSULATION ON THE WIRING HARNESS MELTED. THE MECHANIC REPLACED THE THERMOSTAT, RADIATOR, OXYGEN SENSOR, FUEL PUMP AND FUEL FILTER. THE FAILURE CONTINUED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 00V367000 (ENGINE AND ENGINE COOLING) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED A SECOND TIME. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 2/23/12 *CN

TL* THE CONTACT OWNS A 1995 FORD CONTOUR. THE CONTACT STATED THAT THE VEHICLE WAS ON WHILE IN PARK WHEN A FUSE BLEW AND THE VEHICLE STALLED. THE DEALER INFORMED THE CONTACT THAT THE WIRING HARNESS FAILED AND NEEDED TO BE REPLACED. A PRIVATE MECHANIC THEN CONFIRMED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE FAILURE AND CURRENT MILEAGES WERE 97,000.

TL* THE CONTACT OWNS A 1995 FORD CONTOUR. THE CONTACT STATED THAT THE ENGINE WIRING UNDER THE HOOD WAS FRACTURING FROM THE PLASTIC COVERING AND THE WIRES WERE TOUCHING WHICH MADE THE VEHICLE INOPERABLE. IN ADDITION, THE CONTACT WAS CONCERNED ABOUT THE POTENTIAL OF THE WIRES SHORTENING OR CAUSING A FIRE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHO ADVISED THAT THE FAILURE OF THE WIRING WAS SO SEVERE THAT THEY WERE UNABLE TO SUCCESSFULLY RUN A DIAGNOSTIC TEST. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.

I HAVE A 1995 FORD CONTOUR AND JUST FOUND OUT ALL ALONG THERE WAS A CAMPAIGN ON THE WIRING HARNESS IN THE ENGINE COMPARTMENT . THIS IS VERY UNSAFE AND IS CAUSING THE CAR TO ACT ERRATICALLY IT IS A FIRE HAZARD DUE TO THE FACT THE WIRING HARNESS IS FRAYED IF I TOUCH ANY OF THE WIRES THE INSULATION JUST FALLS OFF WHAT HASN'T ALREADY FELL OFF. ENGINE DIES AND STALLS ALL THE TIME AND CAR IS UN DRIVABLE CALLED FORD AND THEY SAID THERE WAS A CAMPAIGN AND RECALL ON WIRING HARNESS . BUT IS UNAVAILABLE NOW BUT I COULD BUY ONE FOR $1300.00 IT HAS CAUGHT SMALL FIRE DUE TO THIS. *TR

THE ENTIRE WIRING HARNESS IN THE ENGINE COMPARTMENT IS DEFECTIVE. THE PLASTIC COVERING THE WIRES IS CRACKED AND PEELING OFF IN THE ENTIRE SYSTEM CAUSING THE CAR TO OCCASIONALLY BRAKE FOR NO REASON AND TO KICK AND SPUTTER WHEN DRIVING ESPECIALLY WHEN IT HAS BEEN RAINING. THE FORD DEALER ADMITS IT IS A COMMON PROBLEM CAUSED BY AN EXPERIMENTAL PLASTIC THAT WAS USED THAT YEAR BUT THE COMPLAINT IS NOT COVERED UNDER ANY RECALLS SO WE HAVE HAD TO HAVE MINOR REPAIRS DONE TO THE WIRING EVERY TIME THE CAR DIES DUE TO A SHORT IN THE SYSTEM. THE CAR IS IN PERFECT SHAPE MECHANICALLY AND THE BODY IS IN GREAT SHAPE ALSO. I AM WONDERING WHY NO ONE HAS ADDRESSED THIS PROBLEM BEFORE BECAUSE I HATE TO THINK OF HOW MANY OTHERS THERE ARE JUST LIKE ME WHO MAY HAVE TO JUNK A PERFECTLY GOOD CAR BECAUSE THEY CANNOT AFFORD TO KEEP PAYING FOR WIRING PROBLEMS. I HAVE NEVER HAD ANOTHER CAR THAT THE WIRING WAS THE FIRST TO GO. ESPECIALLY ONE THAT IS AS WELL MAINTAINED AS THIS ONE IS. IF YOU HAVE ANY SUGGESTIONS OR SOLUTIONS PLEASE LET ME KNOW. IT WOULD BE NICE TO KNOW THAT THE GOVERNMENT WAS LOOKING IN AT THE PROBLEM TRYING TO HELP THE CONSUMERS AS I HAVE NOT SEEN IT MENTIONED ANYWHERE ELSE YET. *TR

I RECENTLY PURCHASED A 1995 FORD CONTOUR AND I NOTICED ITS BEEN SMOKING THE MECHANIC KEEPS SAYING THERE IS NOTHING WRONG OR THEY CANT DETECT A PROBLEM. I NOTICED THIS MODEL CAR HAS HAD SEVERAL RECALLS. COULD THIS USED CAR BE AFFECTED BY A FAULTY PART AND CAN I QUALIFY FOR A RECALL PART REPAIR IF THIS CAR HAS A DEFECTIVE PART? *TR

TL*THE CONTACT OWNS A 1995 FORD CONTOUR. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE AND THE STEERING COLUMN BEGAN OVER HEATING CONTINUOUSLY. ON SEVERAL OCCASIONS, THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE BURNING SMELL; HOWEVER, THE VEHICLE CAUGHT FIRE. AT TIMES, THE KEY WAS TOO HOT TO REMOVE FROM THE IGNITION. THE CURRENT AND FAILURE MILEAGES WERE 83000 WHEN THE FIRE OCCURRED.

MY '95 FORD CONTOUR HAS BEEN OVERHEATING, SMELLING HOT, WITH THE STEERING COLUMN HEATING UP TO THE POINT OF THE CAR KEY, IN THE IGNITION, GETTING TOO HOTTO HANDLE--FOR SOME TIME, NOW. FEARING THAT THERE MIGHT BE A FIRE HAZARD, I TOOK IT TO MY LOCAL FORD DEALER. HE SAID MY CAR, PER IT'S VIN NO., HAS NOT BEEN RECALLED; SO HE DID NOTHING ABOUT MY CONCERNS. NOW, A WEEK AGO TODAY (12/3/09), AND A WEEK OR SO AFTER BRINGING MY CAR IN FOR THE FIRST TIME, I WAS DRIVING 20-30 MPH, DOWN A CITY STREET IN MY SMALL TOWN, WHEN, SUDDENLY, I HEARD A POPPING SOUND; AND THE ELECTRICITY IN THE CAR TURNED OFF. THE CAR STOPPED DEAD IN IT'S TRACKS, AS I WAS TURNING INTO A PARKING LOT! I TRIED TO PUT THE HAZARD LIGHT ON; BUT IT WOULD NOT TURN ON. THE STEERING WHEEL & STEERING COLUMN WERE VERY HOT. I TURNED THE KEY, IN THE IGNITION, IN AN ATTEMPT TO TURN THE CAR BACK ON. INSTEAD, IT MADE ANOTHER POPPING SOUND; AND DIED COMPLETELY! SMOKE STARTED COMING FROM UNDER THE HOOD. WHEN I OPENED THE HOOD, THE BATTERY WATER WAS BOILING OVER, SIZZLING, AND SMOKING. WHEN I CALLED MY INS. ROADSIDE ASSIST, AND TOLD THEM WHAT HAPPENED, THEY TOLD ME TO CALL THE FIRE DEPT. SO, I CALLED THE FIRE DEPT. THEY CAME AND DISCONNECTED THE BATTERY; AND NOTED THAT THE BATTERY WAS SMOKING. THEY PUSHED MY CAR TO A PARKING SPOT, FROM WHERE I HAD IT TOWED IT TO MY LOCAL FORD DEALER. THE FORD DEALER MAN SAID THEY COULD DO NOTHING ABOUT IT; AND I LEFT IT THERE, IN THEIR PARKING LOT. I'M AFRAID TO DRIVE THE CAR, FOR FEAR IT MIGHT STAR

I HAVE A 1995 FORD CONTOUR WHICH HAS A FAULTY WIRING HARNESS THAT LED TO VEHICLE PROBLEMS. AFTER RESEARCH ON THE INTERNET I FOUND THAT A RECALL (99M03) WAS ISSUED FOR FAULTY WIRES. MY CAR WAS NOT INCLUDED IN THAT RECALL EVEN THOUGH IT HAS THE SAME PROBLEM THAT WAS MENTIONED IN THE RECALL. WHY WERE NOT ALL OF THE CARS WITH THIS DEFECT RECALLED? *TR

I TOOK MY 1995 FORD CONTOUR IN TO MY LOCAL PERRY LINCOLN FORD DEALER, ON HITCHCOCK ST., IN SANTA BARBARA, CA--TODAY (10/12/09. I STATED TO THE REPAIRMAN THAT I NOTICED, ON THE INTERNET, THAT THE '95 FORD CONTOURS HAD BEEN RECALLED FOR IGNITION FIRES. I TOLD HIM THAT MY IGNITION SWITCH HEATS UP, EVERY TIME I DRIVE IT, EVEN A SHORT DISTANCE OF 3 MILES TO WORK, EVERY DAY. I TOLD HIM THAT THE IGNITION SWITCH GETS SO HOT, THAT MY KEY IS TOO HOT TO HANDLE!! THE ENTIRE DRIVER'S WHEEL COMPONENT, THAT INCLUDES THE IGNITION SWITCH, GETS HOT. THE REPAIRMAN, AT FORD, TOOK MY VIN NO.; AND RESEARCHED MY CAR, ON HIS FORD COMPUTER; AND MY VIN NO. DID NOT SHOW A RECALL. I TOLD HIM, I THOUGHT THE RECALL WAS FOR ALL 1995 FORD CONTOURS, NOT JUST SOME. DO I HAVE TO WAIT FOR A FIRE TO START, IN THE IGNITION SWITCH, BEFORE ANYTHING IS DONE ABOUT IT? I AM A WORKING REGISTERED NURSE; AND WOULD RATHER PREVENT A FIRE THAN WAIT FOR ONE TO BURN MY FACE AND BODY; AND DESTROY MY ENTIRE CAR. THE FORD REPAIRMAN DID NOTHING ABOUT MY CONCERNS. HE JUST SAID THERE HAS BEEN NO RECALL ON MY PARTICULAR CAR!!! WHAT CAN I DO TO PROTECT MYSELF FROM INJURY AND HARM, ESPECIALLY SINCE MY IGNITION SWITCH, CAR KEY--AND ENTIRE DRIVER'S WHEEL DEVICE OVERHEATS? ALL YOUR 4 QUESTIONS, BELOW AND TO THE RIGHT OF THIS BOX ARE CUT OFF EXCEPT FOR THE "APPROX. INCIDENT DATE!!"! YOUR QUESTIONNAIRE ALSO DOES NOT ALLOW ME TO CHOOSE "IGNITION SWITCH" FOR THE DEFECTIVE PART!! *TR

TL*THE CONTACT OWNS A 1995 FORD CONTOUR. THE CONTACT'S VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 00V367000(ENGINE AND ENGINE COOLING) IN 2004. FIVE YEARS LATER, THE FAN MOTORS HAVE OVERHEATED AND CAUSED THE ELECTRICAL COMPONENTS TO MELT. THE DEALER AND MANUFACTURER STATED THAT THEY WOULD NOT ASSUME RESPONSIBILITY FOR ANY REPAIRS BECAUSE THE VEHICLE WAS PREVIOUSLY REPAIRED ACCORDING TO THE RECALL. THE CONTACT IS IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 58,109. UPDATED 07/28/09 *BF UPDATED 07/30/09.*JB

THIS WAS AN "OWNER NOTIFICATION" OR A FORD RECALL (NOT ORDERED BY THE FED GOV.) NUMBER 99M03, WHEREIN FORD REPLACED UNDER WARRANTY THE MAIN WIRING HARNESS ON 1995 FORD CONTOUR VEHICLES. THIS IS A SAFETY ISSUE AND HAS NOT BEEN PERFORMED ON THIS PARTICULAR VEHICLE. I PURCHASED THE VEHICLE AFTER THE NOTIFICATION TO OWNERS EXPIRED AND WISH TO HAVE FORD STAND BY THEIR WARRANTY AND COMPLETE THIS TASK UNDER THE WARRANTY/RECALL. *TR

ITS 1995 FORD CONTOUR ALL WIRING UNDER HOOD HAS INSULATION CRACKING AND FALLING OFF ALL THE WAY TO HOT CABLES AT POWER DISTRIBUTION BOX. CHECKED SEVERAL CARS AT WRECKING YARD FOR GOOD HARNESS ALL WERE THE SAME CAR DOESN'T RUN NOW WIRES GOING TO CRANK SENSOR SHORTED OUT CAR HAS 57,000 MILES ON IT. *TR

TL*THE CONTACT OWNS A 1995 FORD CONTOUR. WHILE DRIVING 35 MPH, THE VEHICLE COMPLETELY SHUT OFF. THE CONTACT WAS NOT ACCELERATING OR DECELERATING PRIOR TO THE FAILURE, BUT MAINTAINED THE SAME SPEED THE ENTIRE TIME. ALL POWER WAS LOST, INCLUDING THE BRAKES. THE VEHICLE TOOK APPROXIMATELY TWO HOURS TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE FORD MANUFACTURER WAS CALLED AND STATED THAT THERE WAS A RECALL, IN WHICH THE PREVIOUS OWNER DID NOT HAVE REPAIRED. THE RECALL DATE HAS CURRENTLY EXPIRED AND THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COST. THE FAILURE MILEAGE WAS 95,000.

TL*THE CONTACT OWNS A 1995 FORD CONTOUR. WHILE DRIVING APPROXIMATELY 20 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT SMELLED A STRONG ODOR OF FUEL COMING FROM THE VEHICLE. SHE ALSO OBSERVED A SMALL AMOUNT OF FUEL SPILLING FROM THE FUEL TANK. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE MECHANIC STATED THAT THE FAILURE WAS RELATED TO THE FILLER PIPE IN THE FUEL TANK SYSTEM. THE TECHNICIAN DISCOVERED NHTSA CAMPAIGN ID NUMBER 94V203000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP) FOR THE IDENTICAL FAILURES; HOWEVER, THE VIN WAS EXCLUDED FROM THE RECALL. THE FAILURE MILEAGE WAS 37,000 AND CURRENT MILEAGE WAS 38,000.

TURN CAR ON WHEN CAR REACHES TO NORMAL TEMP CHECK ENGINE LIGHT COMES ON AND STALLS MOST OF THE TIME AT A COMPLETE STOP SHUT ENGINE OFF AND CHECK ENGINE LIGHT IS OFF TILL RUN FOR A MIN WHEN ENGINE IS CALLED LIGHT STAYS OFF TILL ENGINE IS WARM AGAIN. *TR

LTR FROM REGARDING COMPLAINTS ABOUT THE ELECTRICAL SYSTEM IN HIS 1995 FORD CONTOUR. THE CONSUMER STATED THE UNDERHOOD WIRING HARNESS WAS BRITTLE AND THE INSULATION COATING WAS PEELING OFF EXPOSING THE WIRE HARNESS. *JB

MY AUTOMATIC TRANSMISSION SHIFT POSITION INDICATOR MOUNTED ON MY FLOOR CONSOLE HAS DISINTEGRATED OVER TIME, AND NO LONGER EXISTS. THIS FAILURE HAS BEEN RECOGNIZED PREVIOUSLY, AND IS DUE TO DEFECTIVE, POOR QUALITY, PLASTIC MATERIAL THAT THE SHIFT INDICATOR IS MADE OF. THE CONSEQUENCE OF THIS FAILURE IS THAT ONE CANNOT DETERMINE WHICH GEAR THE TRANSMISSION IS OPERATING IN, AND CAN CAUSE OVERHEATING OF THE TRANSMISSION AND/OR ENGINE, AND POSSIBLY CAUSE AN AUTO ACCIDENT, OR FIRE. THIS HAS BEEN A RECOGNIZED DEFECT FAILURE AND WAS REPORTED AS A SAFETY RECALL AS EARLY AS 1998. HOWEVER UPON CONTACT WITH THE FORD DEALERSHIP AND ALSO THE FORD MOTOR COMPANY REPRESENTATIVES, THEY DENY THAT MY 1995 CONTOUR IS INCLUDED IN THE SAFETY RECALL. THERE ARE NUMEROUS 1995 CONTOUR VEHICLE OWNER COMPLAINTS FILED WITH THE FORD MOTOR COMPANY ON THIS DENIAL OF SAFETY RECALL APPLICATION BY OTHER 1995 FORD CONTOUR OWNERS WHO HAVE EXPERIENCED THAT SAME LACK OF SUPPORT THROUGH THE FORD MOTOR CO REPRESENTATIVES. THIS MATERIAL DEFECT IS A GENERIC PROBLEM THAT AFFECTS ALL 1995 CONTOURS, HOWEVER THE FORD REPRESENTATIVES DENY THAT MY VIN IS INCLUDED IN THE SAFETY RECALL. *TR

WHILE DRIVING TO THE STORE ONE EVENING AS IT WAS GETTING DARK I NOTICED THAT MY INSTRUMENT PANEL WAS DARK. I ASKED MY BOYFRIEND TO GET OUT AND CHECK IF I HAD TAIL LIGHTS (REMEMBERING MY SISTER HAD A SIMILAR PROBLEM WHEN I WAS LITTLE) INDEED I DIDN'T HAVE TAIL LIGHTS OR DASH LIGHTS AND WHEN THE SWITCH WAS TURNED TO JUST HAVE PARKING LIGHTS ON THEY DIDN'T WORK EITHER. HOWEVER I STILL HAD TURN SIGNALS, HEADLIGHTS, HAZARD LIGHTS AND BRAKE LIGHTS. WE TESTED FUSES AND CONSULTED A PARTS STORE WITH THE PROBLEM, FINALLY MY BOYFRIEND TOOK APART THE HEADLIGHT SWITCH WHERE HE FOUND THE WIRING HARNESS WAS PARTIALLY MELTED.....HE TRIED TO BEND THE LITTLE PRONGS BACK SO THEY WOULD MAKE CONNECTION WITH THE SWITCH AGAIN AND PUT EVERYTHING BACK TOGETHER AND NOW MY LIGHTS WORK. I AM HOWEVER ORDERING NEW PARTS FOR MY CAR AND THE SALES MAN SAID THAT IT WAS ODD TO HAVE A PROBLEM THERE SINCE IT WAS A LOW HEAT AREA AND SUGGESTED LOOKING ON NHTSA FOR RECALLS DUE TO THIS PROBLEM. *TR

MY 1995 FORD CONTOUR WAS REPAIRED UNDER THE RECALL WHEN THE ENGINE COOLING FAN AND WIRING HARNESS BURNED UP. HOWEVER THEY REPLACED ONLY THAT PART OF THE WIRING HARNESS THAT IS DIRECTLY CONNECTED WITH ENGINE COOLING FANS, THE REST OF THE UNDERHOOD WIRING IS FAILING DUE TO OVERHEATING CAUSING THE INSULATION TO BREAK DOWN. I HAD TO REPLACE THE CONNECTOR TO THE ENGINE TEMPERATURE SENSOR BECAUSE IT HAS TURNED INTO A SOFT GELATIN LIKE SUBSTANCE CAUSING SHORTS. I BELIEVE THE ENTIRE UNDERHOOD WIRING HARNESS SHOULD HAVE BEEN REPLACED WHEN THE FANS CAUGHT ON FIRE. CURRENTLY THERE IS A SHORTER MAYBE AN OPEN CIRCUIT IN THE ENGINE WIRING CAUSING THE CHECK ENGINE LIGHT TO COME ON AND STAY ON AT TIMES BUT IT SETS NO TROUBLE CODES. *TR

TL*THE CONTACT OWNS A 1995 FORD CONTOUR. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE LOST POWER. THE CONTACT COASTED TO THE SIDE OF THE ROAD UNTIL COMING TO A COMPLETE STOP. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO A LOCAL MECHANIC. THE MECHANIC INFORMED HIM THAT THERE WAS AN ELECTRIC FUEL INJECTION FAILURE, RESULTING FROM INSTALLATION PARTICLES BECOMING DETACHED FROM THE ELECTRICAL WIRING. THE CONTACT RESEARCHED RECALLS ON HIS VEHICLE AND REALIZED THAT HE WAS EXPERIENCING THE SAME FAILURES DESCRIBED IN NHTSA CAMPAIGN ID NUMBER 00V367000 (ENGINE AND ENGINE COOLING). FORD STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 150,000.

I HAD BOTH FRONT COIL SPRINGS ON MY 1995 FORD CONTOUR FAIL (LEFT SPRING BROKE INTO TWO PIECES, THE RIGHT INTO THREE). RESULTED IN CAR DRIFTING BACK AND FORTH. NO RESPONSE FROM DEALERSHIP. *TR

FORD'S CONTOUR AND ITS SISTER CAR THE MERCURY MYSTIQUE HAVE DEFECTIVE WIRE HARNESSES. THE WIRE SHIELDS CRACK CAUSING SHORTS, WHICH LEAD TO MECHANICAL BREAK DOWNS AND CAN LEAD TO ENGINE FIRES. FORD ISSUED AN OWNER NOTIFICATION PROGRAM #99M03, WHICH ADMITS TO THIS PROBLEM AND EXTENDS COVERAGE TO NOTIFIED INDIVIDUALS BUT LIMITS THE TERM OF COVERAGE. WIRE HARNESSES ARE NOT A NORMAL WEAR COMPONENT AND SHOULD NOT FALL APART FOR NO REASON. HUNDREDS OF THOUSANDS OF THESE VEHICLES ARE ON THE ROAD AND HAVE NOT BEEN REPAIRED. FORD HAS EXPRESSED NO INTEREST IN HELPING NOTIFY CONSUMERS. FURTHER, FORD'S DEALERS ARE UNABLE TO LOCATE REPLACEMENT HARNESSES. *TR

UNDER HOOD WIRING HARNESS GOT HOT AND MELTED THE INSULATION OFF THE WIRES,CAUSING SMOKE AND BURNT SMELL OF PLASTIC AND ON SOME OF THE SENSORS THAT CONTROL THE ENGINE,RESULTING IN HIGH ENGINE SPEED,LACK OF STOPPING POWER AND STEERING,I PARKED THE CAR AT HOME AND NOW WILL NOT START. *TR

1995 FORD CONTOUR REAR DOORS DO NOT HAVE CHILD LOCKS. CUSTOMER STATES THAT THE REAR DOORS DO NOT HAVE CHILD LOCKS AND HER CHILD CAN OPEN THE BACK DOOR WHEN IT IS LOCKED. *KB THE CONSUMER STATED THE FRONT SEAT BELTS DO NOT HOLD TIGHT ENOUGH. *JB UPDATED 01-16-08. *KB THE DRIVER'S DOOR DIDN'T OPEN WHEN THE MASTER LOCK IS ON.

I HAVE EXPERIENCED SEVERAL INCIDENTS WITH THE TRANSMISSION IN MY VEHICLE. AFTER YOU DRIVE THE VEHICLE LONG ENOUGH FOR IT TO WARM UP GOOD, THE TRANSMISSION WILL QUIT PULLING. YOU CAN BE DRIVING DOWN THE ROAD AND IT ACTS AS IF IT JUST KICKS INTO NEUTRAL. YOU CAN PULL OVER AND PUT THE CAR INTO PARK AND THEN INTO DRIVE AGAIN AND IT WILL GO A LITTLE FARTHER BEFORE IT WILL DO IT AGAIN. THE CAR HAS ONLY A LITTLE OVER 70,000 MILES ON IT AND IS NOW BASICALLY JUNK. I HAVE BEEN TOLD BY SEVERAL MECHANICS THAT THESE CARS ALL HAVE TRANSMISSION PROBLEMS AND THAT REBUILDING THE TRANSMISSION DOESN'T USUALLY WORK FOR VERY LONG. *TR

TL* - THE CONTACT OWNS A 1995 FORD CONTOUR. THE SPEEDOMETER WORKS INTERMITTENTLY. SHE STATED THAT THE TRANSMISSION WAS CONTATANTLY SKIPPING GEARS, AND DOWNSHIFTS WHEN IT SHOULD CHANGE GEARS. THERE IS A SAFETY RECALL ON BOTH OF THE COMPONENTS THAT ARE FAILING ON HER VEHICLE. POWER TRAIN:AUTOMATIC TRASMISSION: LEVER AND LINKAGE:FLOOR SHIFT-98V233000, AND VEHICLE SPEED CONTROL CABLES-97V225000. THE CONTACT DID NOT KNOW THE CURRENT OR FAILURE MILEAGE BECAUSE THE ODOMETER IS BROKEN.

EXPERIENCED TRANSMISSION ISSUES, WITH INTERMITTENT ROUGH SHIFTING AND INTERMITTENT FAILURES TO ENGAGE IN DRIVE OR REVERSE. IT MYSTERIOUSLY STARTED TO RUN FINE FOR SEVERAL DAYS. ONE MORNING I DROVE A SHORT DISTANCE FOR AN APPOINTMENT. UPON RETURNING AND STARTING THE CAR I NOTICED SMOKE EXITING THE LEFT SIDE OF THE ENGINE COMPARTMENT. I TURNED OF THE VEHICLE AND INSPECTED THE ENGINE COMPARTMENT, AND I COULD STILL SEE SOME SMOKE COMING FROM THE LEFT-REAR PART OF THE ENGINE COMPARTMENT. AFTER THIS INCIDENT, SEVERAL OF THE VEHICLE'S ELECTRICAL FUNCTIONS FAILED, INCLUDING PARK/BRAKE SHIFT INTERLOCK, HEATER FAN, BACKUP LIGHTS, DIRECTIONAL FLASHERS. FOLLOWING THE INCIDENT, THE TRANSMISSION ISSUES HAVE RESUMED. UPON INSPECTION, I NOTICED SEVERAL WIRES HAD CRACKING INSULATION, AND SOME EVEN HAD BARE WIRE EXPOSED. *TR

I HAVE A 1995 FORD CONTOUR AND I PAID OVER $16,000.00 FOR IT. I HAVE HAD NOTHING BUT TROUBLE SINCE I GOT THIS CAR. I HAVE 50,888 MILES AND THE TRANSMISSION HAS BEEN REPLACED 2 TIMES AND WORKED ON 4 TIMES. WATER PUMP WENT OUT, AIR WENT OUT ALL WIRING COVERS HAS CRUMBLED OFF LEAVING EXPOSED WIRES TO START A FIRE AND MUCH MORE. I HAVE BEEN TREATED LIKE I WAS A CHILD AND DIDN'T KNOW ANY BETTER WITH THE DEALERSHIP AND FORD MOTOR COMPANY. I NOW HAVE A CAR THAT I CAN'T DRIVE BECAUSE IT IS A FIRE HAZARD. I WANT SOMETHING DONE TO MY SATISFACTION. I KNOW THEY QUIT MAKING THE 1995 FORD CONTOUR BECAUSE THERE WERE SO MANY MANUFACTURER PROBLEMS. I AM NOW TOLD THEY CAN'T GET PARTS TO FIX THE CAR AND I CAN'T TRADE IT IN ON ANOTHER ONE. I AM A FEMALE AND I AM TIRED OF THE TREATMENT I'M RECEIVING FROM FORD. MY CAR HAS ALWAYS BEEN SERVICED AT A FORD DEALERSHIP. I HAVE CONTACTED SEVERAL AGENCYS CONCERNING MY PROBLEMS. *JB

MY CAR HAS CONTINUALLY TO RUN HOT, THE PART THAT SENDS THE INFORMATION THE ENGINE FOR THE FAN TO COME ON WAS DEFECTIVE. I TOOK MY CAR TO THE DEALERSHIP TO TRY TO PURCHASE THE PART AND THE DEALERSHIP TOLD ME THAT THIS PART WAS A RECALL PART. BY THIS PART BEING DEFECTIVE IT HAS DAMAGED MY ENGINE AND THE DEALERSHIP TOLD ME THAT MY CAR WAS OVER THE MILES AND THE RECALL DATE WAS OVER AND THEY WAS NOT GOING TO HONOR THE RECALL. THEY TOLD ME THAT I CAN PURCHASE THE PART, BUT THEY WAS NOT GOING TO REPLACE MY ENGINE. THIS PART HAS DAMAGED MY ENGINE AND THEY SHOULD NOT ONLY REPLACED THE DEFECTIVE PART WITH NOT CHARGE, BUT THEY SHOULD ALSO REPLACE MY ENGINE DUE THE DEFECTIVE PART. THE DEALERSHIP SERVICE CENTER STATED THAT THEY WERE ONLY FOLLOWING FORD MOTOR COMPANY GUIDELINES.

TL*- THE CONTACT STATED THAT THE COMPARTMENT WIRING HARNESS INSULATION ON THE 1995 FORD CONTOUR'S ENGINE BECAME BRITTLE AND CRACKED. THE CONTACT STATED THERE WAS FORD RECALL NUMBER 99M03 WHICH STATED THAT THE REASON FOR THIS WAS DUE TO HEAT AND MOISTURE. THE CONTACT STATED MOST OF THE INSULATION HAS FALLEN OFF. THE CONTACT WAS UNABLE TO START THE VEHICLE, AND HAD NOT TAKEN THE VEHICLE TO THE DEALERSHIP FOR REPAIR. THE VEHICLE CURRENTLY HAD 18,8000 MILES. *AK UPDATE 4/9 *TR

MY 95 CONTOUR STARTED FOR TWO SECONDS, THEN DIED. IT WOULD NOT START AFTER THAT. MY MECHANIC DETERMINED THAT THE FUEL PUMP QUIT. I ONLY HAD THE CAR TWO DAYS FROM PURCHASE, SO I CHECKED ONLINE FOR SERVICE ISSUES, RECALLS, ETC., AND FOUND OUT ALL THE VARIOUS FUEL, ELECTRICAL, EMISSION AND OTHER PROBLEMS THIS VEHICLE HAS, MY BIGGEST CONCERN BEING THAT IT COULD CATCH FIRE(I DO HAVE A FAMILY TO DRIVE AROUND), I AM VERY DISAPPOINTED ABOUT THE UNCOOPERATIVE COMING FROM THE DEALERSHIPS CONCERNING ALL THIS, I AM VERY LOW-INCOME, I SPENT $1000.00 FOR THIS CAR THINKING IT WAS A GOOD DEPENDABLE CAR, AND NOW FIND MYSELF WONDERING HOW I WILL BE ABLE TO AFFORD ALL THE REPAIRS ON MY SINGLE INCOME, FORD, SHAME ON YOU!! *JB

TL*- THE CONTACT STATED THAT WHILE DRIVING THE 1995 FORD CONTOUR WITH 36000 FAILURE MILEAGE AT 55 MPH THE FRONT FRONT DRIVER'S SIDE AIRBAG DEPLOYED WITHOUT ANY WARNING. THE VEHICLE WAS TOWED TO THE DEALER. THE FORD ENGINEER CHECKED THE VEHICLE, AND DETERMINED THAT THERE WAS NO DAMAGE TO THE VEHICLE, BUT HE DETERMINED THAT THE SENSOR WAS FAULTY. THE VEHICLE HAS BEEN REPAIRED. THE DRIVER RECEIVED MINOR INJURIES.*AK

WIRING ON 95 FORD CONTOUR, WE DID A VALVE JOB TO THIS CAR AND AT THIS TIME WE NOTICED THE WIRING HARNESS WAS A MESS THE COATING WAS COMING OFF THE WIRES, WHAT COATING THAT IS THERE IS DRY AND BRITTLE EXPOSING THE WIRES, THE BARE WIRES TOUCHING AT PLACES, WENT AND GOT ONE FROM THE RECYCLE PARTS YARD AND IT WAS THE SAME WAY NOW WE ARE HAVING A HARD TIME FINDING A GOOD ONE TO PUT BACK ON THE CAR A NEW ONE IS SO EXPENSIVE I BELIEVE I WAS QUOTED AROUND $1300.00 . *NM

DT*: THE CONTACT STATED WHEN THE VEHICLE WAS TAKEN TO AN INDEPENDENT CERTIFIED MECHANIC FOR A NORMAL TUNE UP; IT WAS DISCOVERED THAT THE ELECTRICAL WIRING HARNESS WAS DETERIORATED. DUE TO THE POTENTIAL RISK OF FIRE WHILE REPAIRING THE VEHICLE, THE CONTACT WAS ADVISED TO GO TO THE DEALER. WHEN THE VEHICLE WAS TAKEN TO THE DEALERSHIP, THE PARTS TO REPAIR THE DETERIORATED ELECTRICAL WIRING HARNESS WERE DISCONTINUED. THE MANUFACTURER WAS CONTACTED, AND PROVIDED A TELEPHONE NUMBER TO A PARTS STORE. THE STORE DID NOT CARRY THE PARTS EITHER. THE JUNK YARD WAS ALSO CHECKED FOR AVAILABILITY OF REPLACEMENT PARTS. THE PARTS AT THE JUNK YARD WERE IN A WORST CONDITION THAN THE CONTACT'S VEHICLE.

CONSUMER 1995 CONTOUR DIED WHILE BACKING OUT OF THE DRIVEWAY. *TS THE CONSUMER WAS TOLD THE VEHICLE HAD WIRING PROBLEMS UNDER THE HOOD. *JB

DT*: THE CONTACT STATED WHILE DRIVING 20 MPH, THERE WAS AN INTERMITTENT GROANING AND CRUNCHING NOISE COMING FROM THE FRONT RIGHT TIRE. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, WHERE IT WAS DETERMINED THAT THE HUB WAS PUNCHING OUT THE SEALED BEARINGS. THE BEARINGS WERE REPLACED. PRIOR TO THIS INCIDENT, THE VEHICLE HAD ALSO BEEN TAKEN TO A SERVICE DEALER WHO REPLACED THE AXLE SHAFT. NEITHER THE DEALER NOR THE PRIVATE REPAIR SHOP WAS ABLE TO REPAIR THE PROBLEM COMPLETELY.

DT*: THE CONTACT STATED WHILE DRIVING AWAY FROM A STOP SIGN, THE GAS PEDAL BECAME STUCK, THE ENGINE RACED AND THE VEHICLE ACCELERATED. THE CONTACT TURNED THE IGNITION OFF AND PULLED OFF OF THE ROAD. THE VEHICLE WAS TOWED TO A DEALERSHIP WHERE THEY DETERMINED THE PROBLEM WAS WITH VEHICLE SPEED CONTROL: CABLES. THERE IS AN NHTSA RECALL, # 97V225000, REGARDING THE VEHICLE SPEED CONTROL: CABLES. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 1/17/2007 - *NM

GASOLINE LEAK WHERE FILLER PIPE MEETS GAS TANK . EXCESSIVE LEAKING OF GASOLINE WHICH CAN LEAD TO A FIRE. *NM

FORD "OWNER NOTIFICATION PROGRAM" 99M03 DESCRIBES, AND OFFERS TO FIX FOR FREE, A PROBLEM IN WHICH ENGINE WIRING HARNESS INSULATION ROTS DUE TO CERTAIN ENVIRONMENTAL FACTORS. PROGRAM INVOLVES A WARRANTY EXTENSION TO 10 YEARS BEYOND ORIGINAL WARRANTY, OR 100,000 MILES, WHICHEVER COMES FIRST. SYMPTOMS OF THE PROBLEM VARY WIDELY. IN MY CASE, THE CAR JUST SHUT DOWN WHILE DRIVING. WHILE THERE WERE NO INJURIES, THIS WAS AN OBVIOUS SAFETY HAZARD. IF IT HAD HAPPENED ON THE INTERSTATE INSTEAD OF ON A SIDE ROAD, THE RESULT COULD HAVE BEEN DISASTROUS. IN RESPONSE TO THIS PROBLEM, FORD ISSUED 99M03, WHICH THEY CALL AN "OWNER NOTIFICATION PROGRAM". THE PROBLEM IS THAT, ACCORDING TO MY OWN EXPERIENCE, AND ACCORDING TO THE PERSONNEL AT MY LOCAL DEALER'S SERVICE DEPARTMENT, OWNERS WERE NOT NOTIFIED UNLESS THEY BROUGHT THE CAR IN FOR SOMETHING THAT TURNED OUT TO BE CAUSED BY THE WIRING HARNESS PROBLEM. THIS PROGRAM NEEDS TO BE ELEVATED TO A RECALL SO THAT ALL OWNERS ARE AWARE OF THE RISKS AND ARE ABLE TO TAKE APPROPRIATE ACTION TO PROTECT THEMSELVES. *NM

CAR CUTS OFF WHEN YOU TURN THE LIGHTS ON OR PRESS THE BRAKES. *AK

I OWN A 1995 FORD CONTOUR GL THAT WAS PURCHASED NEW. I RECENTLY OPENED THE HOOD TO FIND THAT THE ELECTRICAL WIRING INSULATION IS BRITTLE AND FALLING APART AND EXPOSING THE BARE WIRE. THIS MAY CAUSE A FIRE IF TWO OF THE EXPOSED WIRES TOUCH AND CREATE A SPARK. I TALKED TO FORD MOTOR COMPANY WHO TOLD ME THAT A CUSTOMER SATISFACTION BULLETIN WAS SEND OUT IN 1999. THIS SHOULD BE A SAFETY RECALL AND NOT A SERVICE BULLETIN. THE BULLETIN EXPIRES AT 100,000 MILES OR 10 YEARS AFTER WARRANTY. THE WIRING IS MADE SO THAT WHEN THE VEHICLE REACHES A CERTAIN AGE, THE PLASTIC WILL FALL OFF AND THE METAL WIRES CAN BE RECYCLED. THE CARS ARE KNOWN TO MECHANICS AT FORDS DEALERSHIPS AS THROWAWAY CARS AFTER TEN YEARS, BECAUSE OF THE BIO-DEGRADABLE WIRING. *NM

DETERIORATION OF THE WIRING HARNESS, FORD CONTOUR 95 WERE MADE WITH A DEFICIENT ENGINE WIRING HARNESS ISOLATION SYSTEM. VERY DANGEROUS ! SHORT CIRCUITS! THEY JUST EXTENDED THE WARRANTY FOR 7 YEARS OR 100,000 MILES, MY CAR HAS ONLY 45,000 AND THE WIRING HARNESS IS IN SUCH BAD CONDITIONS I AM AFRAID TO DRIVE MY CAR, AS RECOMMENDED BY MECHANICS. THE FORD AND DEALER SAYS IT HAS TO BE CHANGED OUTSIDE OF THE ALREADY EXPIRED WARRANTY, ABOUT 3,500 DOLLARS (BY TROPICAL FORD IN ORLANDO) IT IS IMPOSSIBLE, THE CAR PRICE IS 3,500 D. ( TOTAL LOST) IT IS FABRICATION DEFECT , THE CAR HAS ONLY 45,000. WHY IT IS NOT A RECALL ? THE AFFECTED CUSTOMERS WERE NOT TOLD THE CAR WILL EXPIRE IN 2005! BECAUSE NOBODY WILL PAY THE CAR VALUE TO FIX IT! I SHOULD KEEP DRIVING UNTIL THE SHORT CIRCUIT COMES ! WOULD YOU BE COMFORTABLE WITH YOUR DAUGHTER DRIVING THIS CAR? I BELIEVE IT IS NOT FAIR! FORD SHOULD FIX THE PROBLEM IF THE CAR HAS LESS THAN 100,000 M AT LEAST! CURRENTLY I HAVE LIGHTS TURNING ON BY THEMSELVES ON MY DASHBOARD!*JB

I BOUGHT THE CAR FROM MY SISTER SHE SOLD IT TO ME BECAUSE WHEN IT RAINS, RUN OVER A PUDDLE OR THE WATER IS UP SOME THE CAR STARTS SPUTTERING -IF THE RAIN IS HEAVY THE BRAKES LOCK AS WELL AS THE STEERING WHEEL. SHE HAS TAKEN IT TO SEVERAL MECHANICS, THEY SAY THEY CAN'T FIX 1995 CONTOUR--HAS IT BEEN RECALLED--OR IS THERE A POSSIBLE WAY TO FIX THIS??*JB

DT: CONSUMER FELT VEHICLE HAD BAD WIRING HARNESS. THE ENGINE LIGHT CAME ON AND OFF. THERE WERE NO AIR CONDITIONER/ HEATER/ COMPRESSOR OR FAN . TOOK VEHICLE TO AN A MECHANIC, IT WAS THERE THAT MECHANIC DETERMINED THAT THE WIRING HARNESS WAS FAULTY, AND HAD A POTENTIAL FOR CATCHING ON FIRE. NO REPAIRS WERE MADE. CONSUMER CONTACTED DEALERSHIP AND FORD MANUFACTURER ABOUT THIS PROBLEM. CONSUMER WAS ADVISED OF AN EXTENDED WARRANTY THROUGH CUSTOMER RELATIONS FOR 10 YEARS OR 100,000 MILES. CONSUMER DID NOT APPLY FOR EXTENDED WARRANTY BECAUSE VEHICLE WAS OVER 100,000 MILES, AND DEALER NEVER MADE CONSUMER AWARE OF THIS IN THE PAST. NO REPAIRS WERE MADE. *JB

DT: CONTACT STATES UNDERNEATH THE HOOD THE HARNESS WIRING MELTED. . RECALL CAMPAIGN 011009000 WAS ISSUED. CONSUMER DID NOT RECEIVE A RECALL NOTICE FROM THE MANUFACTURER. HOWEVER, MANUFACTURER PROVIDED CONSUMER WITH RECALL 00S44, CONCERNING ELECTRICAL FUSE CONNECTORS AND RECALL 99M03 REGARDING UNDERHOOD WIRE HARNESS. THE SERVICE DEALER STATED THE RECALL CAMPAIGN HAS EXPIRED. *AK

DT: CONSUMER STATES THAT ON HIS 1995 FORD CONTOUR HE FOUND THE WIRES IN THE ENGINE WERE FRAYED, HE WAS CHANGING THE AIR COMPRESSOR, AND HE CALLED FORD MOTOR COMPANY AT THAT TIME HE WAS TOLD THERE ARE TWO RECALLS ON THAT VEHICLE. THE FORD RECALL NUMBERS ARE 00544, FOR THE ENGINE FUSE FAN, AND 99M03, FOR THE HOOD WIRE HARNESS. THERE ARE NOT ANY NHTSA RECALL NUMBERS. LILLIAN AT FORD TO GO AND GET THE RECALLS FIXED AT THE DEALERSHIP. WHEN HE CONTACTED THE DEALERSHIP HE WAS TOLD THE RECALL HAD EXPIRED AND THE WORK WOULD NOT BE DONE FREE OF CHARGE. HE THEN CALLED THE MANUFACTURER BACK AND THEY CALLED THE DEALERSHIP AND WAS STILL TOLD IT WOULD NOT BE FIXED. *NM