2003 Buick Regal

Defect. General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Risk. Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy. The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Defect. GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

Risk. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy. DEALERS WILL REPLACE THE ENGINE’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINE’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

Defect. DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Risk. A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Remedy. DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Defect. DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Risk. IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

Defect. GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.

Risk. CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.

Remedy. DEALERS WILL REPLACE THE ENGINE’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINE’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

I BACKED THE CAR IN DRIVE AND THE GUAGES WERE NORMAL. WHEN I GOT OUT I SAW A SMALL AMOUNT OF SMOKE COMING FROM UNDER CAR BUT WITHIN A MINUTE THERE WERE FLAMES COMING FROM UNDER THE CAR AND WITHIN A FEW MINUTES THE FLAMES WERE ABOVE THE CAR. I CALLED 911 WHEN I SAW FLAMES AND KNEW I WASN'T GOING TO BE ABLE TO PUT THE FIRE OUT MYSELF. THE FIRE DEPT ARRIVED, IT TOOK THEM AT LEAST 30 MINUTES TO PUT THE FIRE OUT. A COUNTY DEPUTY ARRIVED AND THERE IS A POLICE REPORT (I TRIED TO UPLOAD IT AND IT FAILED EACH TIME). THE DAMAGE HAS BEEN INSPECTED BY AN INSURANCE REPRESENTATIVE FROM THE OWNER OF THE HOUSE (UPLOAD FAILED.

TL* THE CONTACT OWNS A 2003 BUICK REGAL. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE VEHICLE REPEATEDLY SHUT OFF WITHOUT WARNING AFTER MULTIPLE ATTEMPTS. UPON INSPECTION OF THE VEHICLE, THE CONTACT'S FRIEND OPENED THE VEHICLE'S HOOD AND DISCOVERED THAT THE ENGINE WAS ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENT WERE CALLED TO THE SCENE AND THE FIRE WAS EXTINGUISHED. POLICE AND FIRE REPORTS WERE FILED AT THE SCENE, NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. TWO MONTHS LATER, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA RECALL NUMBER: 09V116(ENGINE AND ENGINE COOLING) WHICH HE LINKED TO THE FAILURE. THE MANUFACTURER NOR THE DEALER WERE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

MY DAUGHTER WAS SITTING IN THE PASSENGER FRONT SEAT. THE SEAT KEPT HEATING UP ALMOST UNBEARABLE. THE NEXT DAY CAR WAS OFF ALL NIGHT MY BATTERY DIED AND THE HEATED SEAT WAS STILL HOT NEVER SHUT OFF ALL NIGHT LONG I FOUND A SENSOR UNDER THE SEAT AND UNPLUGGED THAT BUT AM NERVOUS OF MY DRIVER SEAT ALSO SHE HAS NEWBORN BABY WAS WITH US AND THE SEAT DEFINITELY COULD HAVE STARTED ON FIRE VERY DISTURBING ALSO VERY DANGEROUS.

WHILE MY VEHICLE IS IN MOTION I CAN SMELL OIL BURNING FROM SOME WHERE

RECALL #15757 WAS PERFORMED BY DEALER ON 2/24/2016. THE VEHICLE AT THE TIME OF THE REPAIR HAD 255,300 MILES ON IT WHEN I TOOK IT TO THE DEALER (BROOKDALE CHEVROLET BUICK.GMC ON 5/30/18 WHEN I TOOK IT BACK TO THE DEALER FOR OIL DRIPPING ON THE MANIFOLD IT HAD 258,200. THERE IS SMOKE COMING FROM UNDER THE HOOD. WE HAD IT IN STORAGE AFTER THE REPAIR AND TOOK IT OUT THIS SPRING. THE WIFE SAID IT SMOKED AND THEN I DROVE IT AND I HAD A LOT OF SMOKE COMING FROM UNDER THE HOOD. SINCE THE REPAIR WE ONLY PUT 2,900 MILES ON THE VEHICLE. SURELY IF THE REPAIR WAS DONE CORRECTLY WE SHOULDN'T BE WORRYING ABOUT OUR SAFETY. THE CAR CAN'T BE DRIVEN AS IS. THE DEALER FLATLY SAID THEY WERE NO LONGER RESPONSIBLE FOR ANY MORE REPAIRS UNLESS I PAY THEM $1,100 TO REPLACE THE VALVE COVER AND VALVE COVER GASKET. THE CAR IS REGISTERED AT THE DEALER UNDER NL COMPANIES BECAUSE I HAVE A RENTAL. THEY CAN'T SEEM TO PUT IT UNDER MY NAME. I CAN APPRECIATE THEIR RELUCTANCE TO REDO THE REPAIRS BUT THERE IS NO WAY OIL SHOULD BE LEAKING AGAIN ON THE MANIFOLD AFTER 2.900 MILES. THEY WROTE DOWN THE WRONG MILEAGE ON THEIR 5/30/18 INVOICE. THERE SHOULD BE 4 DOCUMENTS ATTACHED IF I DID IT CORRECTLY.

THE BRIGHT /DIM HEADLIGHT CONTROLLER HITS THE BACK OF THE STEERING WHEEL IF THE STEERING WHEEL IS IN A POSITION DURING A RIGHT DIRECTION CURVE IN THE ROAD. THIS HAS CAUSED THE SWITCH TO CATCH IN BETWEEN SETTINGS AND THE HEADLIGHTS TURN OFF. AN EXAMPLE OF THAT USE WOULD BE GOING AROUND A CURVE AND NEED TO TURN BRIGHT LIGHTS OFF DUE TO ONCOMING TRAFFIC. TO GET THE HEADLIGHTS BACK ON, THE BRIGHT / DIM SWITCH HAS TO BE ACTIVATED AGAIN. THIS VEHICLE WAS PURCHASED NEW BY MYSELF IN 2003 AND HAS BEEN A PROBLEM FOR AS LONG AS I CAN REMEMBER SINCE OWNING THE CAR. I FORGET ABOUT THE PROBLEM WHEN I GET HOME SO NOW I FINALLY REPORT IT IN 2018. THE PROBLEM APPEARS TO BE A FACTORY DEFECT BECAUSE THE SWITCH AND STEERING WHEEL ARE NOT DAMAGED. THE INFORMATION ABOUT WHEN THE INCIDENT HAPPENED IS ONLY THE LAST INCIDENT.

PASSENGER SEAT BELT LIGHT STAYS ON

ALL WINDOW COMPONENTS MOTORS AND REGULATORS HAVE BEEN DEFECTIVE IN ALL 4 DOORS BRAKE SHAKING TRANSMISSION SLIPPAGE

2003 BUICK REGAL. CONSUMER WRITES IN REGARDS TO NO PARTS AVAILABLE TO REPAIR RECALL NOTICE - VEHICLE VANDALIZED AT DEALERSHIP - REFUSES TO BE HELD RESPONSIBLE FOR DAMAGES. *SMD THE CONSUMER DID NOT REFERENCE A RECALL. *JB

UNANNOUNCED TO PURCHASERS, THE BUICK REGAL HAS A REDUNDANT AND DEFECTIVE SECURITY IGNITION SYSTEM THAT PREVENTS THE VEHICLE FROM BEING ABLE TO START WITH THE KEY AFTER THE BATTERY IS DISCONNECTED. IT MUST NOW BE TAKEN TO A DEALERSHIP TO BE DIAGNOSED AND FOR A COSTLY REPAIR. IT WAS STATIONARY, AND THE BATTERY DRAINED DOWN WITH A PHONE CHARGER HOOKED UP. EVEN FOLLOWING THE FACTORY KEY SEQUENCE, THE BATTERY RUNS DOWN BEFORE THE CODE CAN BE CLEARED AND RE-ESTABLISHED.

MY 03 BUICK REGAL LS WILL SHUTOFF SOMETIMES WHEN TURNING LEFT, OR WHEN USING THE TURN SIGNAL. I CAN NOT FIND THE PAPERWORK, BUT I REMEMBER A RECALL FOR THIS ABOUT 5 TO 8 YEARS AGO. WE DID HAVE IT ADDRESSED, BUT THE PROBLEM HAS COME BACK. TODAY'S DATE IS 1/9/17 AND MY WIFE HAD THIS HAPPEN AGAIN TO HER ON 1/4/17 WHILE MAKING A LEFT HAND CURVE. SHE WAS NOT TURNING OR USING HER TURN SIGNAL. I ONLY HAD IT HAPPEN TO ME ONCE WHILE MAKING A LEFT TURN USING MY TURN SIGNAL. MY MOTHER ALSO HAS AN 03 REGAL GS AND ALSO EXPERIENCED THIS SAME PROBLEM. I CONTACTED THE DEALER WHERE I PURCHASED THE CAR AND THEY TOLD ME THERE IS NO CURRENT RECALL NOR WAS THERE EVER ONE FOR THIS PROBLEM, BUT I KNOW WE HAD IT ADDRESSED ABOUT 5 TO 8 YEARS AGO.

SERPENTINE BELT CAME OFF AS I WAS DRIVING DOWN 65 S HEADING TOWARD BRANDON FROM SPRINGFIELD, CAN'T GET BELT ON, AND IT WON'T EVEN TURN OVER WITHOUT A JUMP.

TL* THE CONTACT OWNS A 2003 BUICK REGAL. AFTER DRIVING THE VEHICLE AND SHIFTING INTO PARK, THE KEY FAILED TO EJECT FROM THE IGNITION SWITCH PROPERLY. THE IGNITION SWITCH WAS IN THE OFF POSITION AND TOOK MORE THAN TWENTY ATTEMPTS FOR THE KEY TO BE REMOVED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT DID NOT FEEL SAFE IN THE VEHICLE. THE FAILURE MILEAGE WAS 39,000.

TL* THE CONTACT OWNED A 2003 BUICK REGAL. WHILE DRIVING 5 MPH, THE BRAKES MALFUNCTIONED AND ANOTHER VEHICLE STRUCK THE PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE BACK, THE ENTIRE RIGHT SIDE OF THE BODY, THE FOOT, AND THE NECK. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS TOWED TO A DEALER. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN. UPDATED 11/29/16*LJ UPDATED 12/13/16.*JB

TL* THE CONTACT OWNS A 2003 BUICK REGAL. AFTER PARKING THE VEHICLE, SMOKE APPEARED UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. A FIRE REPORT WAS NOT FILED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 188,000.

TL* THE CONTACT OWNS A 2003 BUICK REGAL. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND ALL THE WARNING INDICATORS FLASHED ON THE INSTRUMENT PANEL. THE VEHICLE EVENTUALLY RESTARTED. THE VEHICLE STALLED FIVE TIMES THE SAME DAY. THE CONTACT STATED THAT THE FAILURE OCCURRED TWELVE TIMES BEFORE THE LAST FAILURE. THE DEALER REPLACED THE IGNITION SWITCH. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 69,800.

OIL LEAKS,05/22/2016. I HAVE DAD SEVERAL HARD BREAKING TIMES -HIGHWAY-AND I HAVE SENSE NOTICED OIL LEAKING AND SMELLED OIL SMOKE FROM ENGINE.I HAD RECALL #15757 BACK IN 02/2016.CALLED ABOUT PARTS TO FIF PROBLEM.THEY SAY THEY CANT GET PARTS,-ON BACK ORDER- BEEN ALMOST 6 MONTHS,STILL NO PARTS.LOUDACROUS.NO EXCUSE.

TL* THE CONTACT OWNS A 2003 BUICK REGAL. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART FOR THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2003 BUICK REGAL. WHILE DRIVING 20 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY WHEN THE ACCELERATOR PEDAL WAS NOT DEPRESSED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER TRAIN CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 82,000.

TL* THE CONTACT OWNS A 2003 BUICK REGAL. WHILE DRIVING APPROXIMATELY 40 MPH THROUGH A BUSY INTERSECTION, THE VEHICLE SUDDENLY SHUT OFF. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 148,000.