2020 Tiffin Allegro Bus

Defect. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2016-2024 Allegro Bus, and 2017-2024 Zephyr motorhomes. The 240-Volt induction cooktop may not be grounded, which can create an electrical shock hazard if the wires short-circuit.

Risk. An electrical shock can increase the risk of injury.

Remedy. Dealers will install a ground for the metal junction box, free of charge. Owner notification letters were mailed October 20, 2023. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-133.

Defect. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Risk. Unsecured passengers have an increased risk of injury in the event of a crash.

Remedy. Dealers will inspect and repair the seat belts as necessary, free of charge. Owner notification letters were mailed October 29, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-118.

The contact owns a 2020 Tiffin Allegro Bus. The contact stated that while operating the vehicle the odor of diesel fuel was present inside the motorhome. Upon inspection it was discovered that the diesel fuel was leaking from the high pressure fuel rail onto the reburner causing smoke to be present. The fire dept was call to the scene but no action was needed. The vehicle was towed to the local service center who diagnosed that the high pressure fuel rail was faulty and needed to be replaced. The contact indicated that the vehicle was previously serviced under the NHTSA recall campaign number 21v306000(fuel system) for the same failure but after the recall repair the same failure had occurred. The failure mileage was 15,000.

The contact owns a 2020 Tiffin Allegro Bus. The contact received a notification for NHTSA Campaign Number: 21E320000 (Fuel System, Diesel). The dealer had been notified about the recall and informed him that if the fuel rails were stable upon inspection of the vehicle, they could make needed reinforcements and return the vehicle; however, if the fuel rails needed replacement, the vehicle would have to remain in the dealer's possession until parts became available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.