2012 Mercedes-Benz C300

Defect. Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012 C250, C250 Coupe, C300, C350, C350 Coupe, C63 AMG, and C63 AMG Coupe vehicles equipped with a front passenger air bag assembly replaced under a prior recall. An incorrect replacement front passenger air bag may have been installed.

Risk. An incorrect passenger air bag may not provide adequate protection, increasing the risk of injury in the event of a crash.

Remedy. MBUSA will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020060011.

Defect. Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2014 C250, C300 4Matic, C350, C63 AMG, E350 4Matic Coupe, E350 Cabrio, E350 Coupe, SLS AMG Cabrio, SLS AMG Coupe, 2014-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, GLK 350, GLK250 BlueTec 4Matic, GLK350 RWD, 2015-2017 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2014-2017 E550 Cabrio, and 2014-2016 E550 Coupe vehicles sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally, MBUSA is recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio, 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2011 C300, 2011-2014 C300 4Matic, C350, C63 AMG, E350 Cabrio, E350 Coupe, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2011-2016 E550 Cabrio, E550 Coupe, 2011-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." MBUSA is also recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2010-2011 C300, 2010-2014 C300 4Matic, C350, C63 AMG, E350 Coupe, 2011-2014 E350 Cabrio, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2016-2017 E550 Cabrio, 2010-2016 E550 Coupe, 2010-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MO, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the passenger or other occupants resulting in serious injury or death.

Remedy. MBUSA will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 29, 2019. Owners may contact MBUSA customer service at 1-800-367-6372.

Defect. Mercedes-Benz USA, LLC. (MBUSA) is recalling these vehicles: 2014-2018 CLA250, CLA250 4Matic, CLA45 AMG 4Matic, 2015-2018 GLA250, GLA250 4Matic, GLA45 AMG 4Matic, C300 4Matic, C63S AMG, 2012-2014 C250, C350, C300 4Matic, E550 4Matic, 2013-2014 C63 AMG, 2012-2015 C250 Coupe, C350 Coupe, C63 AMG Coupe, 2013-2015 C350 4Matic Coupe, GLK250 4Matic BlueTec, GLK350, GLK350 4Matic, 2016-2017 C350e, C43 AMG, 2015 C400 4Matic, 2016-2018 C63 AMG, GLC300, GLC300 4Matic, 2017-2018 C300 Coupe, C300 4Matic Coupe, C43 AMG, C63 AMG Coupe, C63S AMG Coupe, C300 Cabriolet, C300 4Matic Cabriolet, C43 AMG Cabriolet, C63 AMG Cabriolet, C63S AMG Cabriolet, GLC300 4Matic Coupe, GLC43 AMG, GLC43 AMG Coupe, 2014 E350 Coupe, E350 4Matic Coupe, E350 Cabriolet, E400 Hybrid, 2015-2017 E400 Coupe, E400 4Matic Coupe, E400 Cabriolet, 2014-2017 E550 Coupe, E550 Cabriolet, B250e, 2014-2016 E250 BlueTec, E63 AMG 4Matic Wagon, 2012-2013 E350 BlueTec, 2012-2016 E350, E350 4Matic, 2015-2016 E400, E400 4Matic, 2012 E63 AMG, 2014-2015 E250 4Matic BlueTec, 2013-2016 E350 Wagon, 2017 GLC300d 4Matic, and 2018 GLC350e 4Matic. The driver's air bag may unexpectedly deploy due to insufficient grounding of the steering components if an electrostatic discharge occurs and the air bag clockspring is broken.

Risk. If the driver air bag inadvertently deploys, it can increase the risk of injury and a crash.

Remedy. MBUSA will notify owners, and dealers will add sufficient grounding to the steering components, free of charge. The recall began in December 6, 2017. Owners may contact MBUSA customer service at 1-877-496-3691.

Defect. Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2016 AMG GT-S, GLC300, CLA250 and GLE300d 4Matic vehicles, 2013 C250, E350 BlueTec and G63 AMG vehicles, 2008-2014 C300 vehicles, 2013-2014 C300 4Matic and ML350 4Matic vehicles, 2009 C350 vehicles, 2014 CLS550, E350 4Matic, E350 Coupe 4Matic, E350 Wagon 4Matic, GLK350 and SL550 vehicles, 2012 CLS550 4Matic vehicles, 2012-2016 E350 vehicles, 2016-2017 GL450 4Matic vehicles, 2012-2014 ML350 4Matic BlueTec vehicles, 2015 S550, S550 4Matic and C300 4Matic Sedan vehicles, 2015-2016 C300 Sedan vehicles, and 2017 SL63 AMG vehicles. Various control units on these vehicles may have been updated with incorrect software, potentially affecting the correct deployment of the air bags in the event of a crash.

Risk. If the air bags do not deploy as intended in the event of a crash, there would be an increased risk of injury in the event of a crash.

Remedy. MBUSA will notify owners, and dealers will update software in the affected control units, free of charge. The recall began April 21, 2017. Owners may contact MBUSA customer service at 1-800-367-6372.

Defect. Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2012 C300 4Matic, C250, C250 Coupe, C350, C350 Coupe 4Matic, C350 Coupe, C63 AMG, C63 AMG Coupe, E350 Coupe 4Matic, E350 Cabrio, E350 Coupe, E550 Cabrio, E550 Coupe, GLK350 4Matic, GLK350, SLS AMG Cabrio, and SLS AMG Coupe vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above MBUSA is recalling certain 2009 C300 4Matic, C300, C350 and C63 AMG vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above MBUSA is recalling certain 2008 C300 4Matic, C300, and C350 vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Risk. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy. MBUSA will notify owners, and dealers will replace the front passenger air bag modules, free of charge. Owners were sent an interim notification in March 2017. Second notices started going out in October 2018 and continue to be mailed as parts become available. Owners may contact MBUSA customer service at 1-877-496-3691

Defect. Mercedes-Benz is recalling certain model year 2011-2012 S400, S550, S550 4Matic, S63 AMG, C300, C300 4Matic, E350, GLK350, GLK350 4Matic, CL550 4Matic, and CL63 AMG vehicles manufactured from April 18, 2011, through July 12, 2011. Due to an irregularity stemming from the molding process of the fuel filter flange, the fuel filter flange may crack when operated in high temperatures.

Risk. If the fuel filter flange cracks, it will leak fuel which may lead to a fire if an external ignition source is present.

Remedy. Mercedes-Benz will notify owners, and dealers will replace the fuel filter, free of charge. The recall campaign is expected to begin in February 2013. Owners may contact Mercedes-Benz at 1-800-367-6372.

Did a winter inspection of vehicle and found rust on the rear frame. Rust has already made a hole on the subframe and hair line crack already forming, only a matter of time before it brakes.

Fuel tank is rusting. Leaking fuel, heavy fuel smell inside cabin. My saftey and anyone around the vehicle would be at risk due to fire chance. Confirmed by independent service center Vehcile has only been inspected by me and the shop Only symptom that appeared was fuel smell in my garage and a puddle of gasoline underneath the vehicle.

The rear sub frame has rusted and part of it has failed

Vehicle: 2012 Mercedes-Benz C300 4Matic Sport Problem Component: Fuel / Propulsion System Safety Issue Description: My 2012 Mercedes-Benz C300 developed a serious fuel tank leak at approximately 106,460 miles which created overwhelming gasoline fumes and rendered the vehicle unsafe to operate. The gasoline fumes were extremely strong and entered the passenger area. The fumes were severe enough that I became physically overwhelmed from the gasoline exposure and discarded clothing due to gasoline contamination and odor. A local repair facility identified the leaking fuel tank. I was informed the replacement fuel tank was allegedly on extended backorder through Mercedes-Benz channels. Because the vehicle was unsafe to drive and replacement parts were allegedly unavailable for several months, I was forced to tow the vehicle from [XXX] to [XXX] at my own expense in order to locate a repair facility that could obtain a replacement fuel tank and safely repair the vehicle. The repair invoice states: “Installed used lt fuel tank incl switchover fuel pumps replace section of steel fuel line front of tank from lower braided line.” I am submitting this complaint due to: serious gasoline leak safety concerns, severe gasoline fume exposure, potential fire hazard, and the alleged extended unavailability of replacement fuel tanks. Mercedes-Benz USA Case Number: 22302114 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have a rust free, relatively lower mileage car I bought for my teen daughter. Despite being such a clean car the rear subframe has rusted and rear suspension has broke off while driving, hitting the fuel tank and is unstable. We avoided an accident but the car is not drivable.

Mercedes of Danbury replaced the rear sub frame CODE 3441 47, since my mechanic (Newtown Auto Repair) told me that the Front subframe is in real bad shape, rotten/rusted, that it is dangerous to drive the car in this condition since the wheel and steering components are part and attached to it, the car would be out of control and all over the road any of these components fail and pull / brake away from the rusted out Sub Frame. When I brought the car in was under the impression that Mercedes Benz would replace front and back Sub Frames. But now they informed me of only recall on rear subframe, rear subframe will let go wheels will collapse, front controls the car and failing could kill people and total the car. frames.

The contact owns a 2012 Mercedes-Benz C300. The contact stated the fuel tank was emitting a fuel odor. The contact stated that the fuel odor was extremely strong and could be smelled inside the residence while the vehicle was parked in the garage. There were no warning lights illuminated. The vehicle was taken to a Certified Mechanic, who diagnosed that the leak was coming from the top of the fuel tank; however, the mechanic was unable to specify the cause. The vehicle was towed to the dealer, but the vehicle was not diagnosed. The vehicle was not repaired. The contact became aware of NHTSA Campaign Number: 12V557000 ( Fuel System, Gasoline) online; however, the VIN was not included. The manufacturer was informed of the failure and informed the contact that the VIN was not under recall. The failure mileage was approximately 98,000.

Rear subframe rotted out and broke due to corrosion. Rear crossmember is broken and needs replaced. My safety as well as the safely of other was put at risk. Loss of control at high speed could have been deadly. Luckily, I wasn’t going very fast at the time of incident or else who knows what would have happened to me or bystanders. Independent service center inspected and confirmed that incident was due to corrosion in the rear. They informed me of the extended warranty (20 years, unlimited miles) on 2008-2015 C300 models for this particular issue as my safety and the safety of others was put at risk. There were some symptoms leading up to the incident. At the time of braking the car would become unstable and feel skittish in the rear. It felt as if the rear was sliding to one side. The vehicle would also make some metal clinking noises at sharper turns. The symptoms had been more frequent in the prior 2-3 months of incident. The vehicle has been inspected and diagnosed by one shop and is currently getting a second opinion from another independent service center.

Rear subframe crossmember rotting, needs replacement. It seems to be a common problem with this vehicle and the assumption by most professional is that it a faulty part supplied by a third party to Mercedes. The rest of the cars undercarriage is pristine, making me wonder why just this one part would rust out.

I was driving normally last week when the driver's head restraint system (known by Mercedes as Neck Pro) unexpectedly and without warning blew at my head. The noise was very loud, and the headrest slammed against my head. Luckily, I was driving approximately 20-25 miles per hour, daytime, on a residential street without too many other vehicles. I was able to pull over to investigate what happened and ensure I wasn't injured and did not collide with any objects in the road. If this had happened on the highway at highway speeds with a less attentive driver, I could see this potentially resulting in a major collision. The road was fat, no bumps, weather was clear. There is no reason why this happened. From what I can tell, the system looks like it failed (plastic clips broke off) and the system did not intentionally deploy. It has not been repaired and is available for inspection. I have not taken it to the dealership for review. The vehicle is in perfect condition with no warnings. It very recently passed Maryland state inspection.

I was replacing rear tail light bulb. Now I'm getting an error message on instrument cluster. I tried to fix the issue but couldn't do to the fact the wiring harness has melted. Mercedes Benz had a recall back in 2013 saying this is a safety issue. No recall for our car.

Took the car in for an oil change and asked them to look at the brakes and rear as there was a strange noise. Vehicle was inspected and found the entire subframe is rotted. Was advised this is a common problem with Mercedes and there were some recalls. Unfortunately no open recall on this vehicle and it is now not driveable as this is a safety risk. Car has been driven 60 miles/day for the past 3 months and could have had serious consequences.

The contact owns a 2012 Mercedes Benz C300. The contact stated that while driving at various speeds, the vehicle would shake without warning. The vehicle was taken to an independent mechanic for a tire rotation; while there, the mechanic discovered severe corrosion on the vehicle's subframe and the contact was advised to no longer drive the vehicle. The manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 160,000. The VIN was not available.

The subframe has developed extensive rust and corrosion, which I believe is a result of faulty manufacturing. This corrosion has severely compromised the structural integrity of the subframe, posing a serious safety risk. The corrosion appears to be inherent to the materials or design used in the manufacturing process, leading to the rapid deterioration of the subframe. There are also no warning lights or failure indicators for this issue. As a result, the subframe is at risk of collapsing, which could cause catastrophic failure of the vehicle's suspension and steering systems. This situation creates an immediate danger to both the occupants of the vehicle and others on the road.

Brake line corrosion

My 2012 c300 has a rotted rear subframe making the car not able to be driven. It has major ,life threatening, costly damage and this issue already has a recall all over the world but not in the United States. If I can get the assistance to pay this repair, it will be gladly appreciated.

We are having issues when braking. The backend of the car wiggles when braking hard. Shop advised that the subframe on the passenger side completely broke away and on the driver side it is very rotted. They advised this is a safety issue since the broken side could pierce the gas tank. I googled this and found that there was a warranty extension for the same year and make car (document MC-10233796-0001) Spoke to the service department and they advised this did not apply to our VIN. I called the corporate number on the warranty extension letter and they advised the same. My complaint is that several other Mercedes models and makes have this issues and are covered. Why isn't ours? Based on images I found online it looks to be the exact failure mode. My son was supposed to drive the car 4.5 hours on the 4th and could have gotten into an accident or been stranded. I also read that in Germany they are fixing all vehicles with this issue.

The contact owns a 2012 Mercedes-Benz C300. The contact stated that while the vehicle was parked, the passenger’s side rear taillight was inoperable. The vehicle was taken to a local dealer but was not diagnosed or repaired since the VIN nor the model year was not included in NHTSA Campaign Number: 14V177000 (Exterior Lighting). The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000.

The contact owns a 2012 Mercedes-Benz C300. The contact stated that after opening the sunroof and then attempting to close the sunroof, the sunroof failed to fully close. The contact had to open and close the sunroof several times before the sunroof closed. Additionally, the contact stated that there was water entering the vehicle from the sunroof which caused electrical failures. The contact stated that the vehicle was drivable, but the "Anti-Theft" warning light illuminated. The contact stated that several other warning lights were later illuminated, and the vehicle would not start. The contact had the vehicle towed to a dealer who diagnosed the vehicle and determined that water had damaged the driver’s side electrical wiring harness. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 169,000.

Took my car for a doorknob repair and was told the whole subframe is rotted. They told me not to drive the car on the highway. The car brakes very hard to the right and always goes right while making cranking noises. Car feels very unsafe. I paid a lot of money for this and own a 2012 c300 4matic.

This is a low mileage car with odometer reading of 25668 (less than 2000 miles per year), used sparingly and always parked in the garage. On 05/07/2024 I noticed brake fluid flowing from the left rear side of the car; on examination this seemed to come from the flexible hose that connects the brake fluid line to the brake caliper. I called my Mercedes-Benz (MB) dealer and arranged for further inspection and service. The technician identified that the brake fluid lines to the rear were both totally corroded and in need of immediate replacement. Since the lines were embedded behind the subframe it necissated lowering the subframe to access. Other parts were also severely corroded and required replacement. (see attached PDF of Invoice) The total cost of the repair was $4,592.93. The dealership applied a discount of $150.00 to this for an amount due of $4,442.93. As an engineer, I believe the material used for the brake fluid lines were unsuitable and furthermore were unprotected for the harsh environment experienced under the car, and I believe MB with all their experience in automobiles manufacturing over the years clearly should have known and forseen this fact; I do believe that MB is responsible for this premature failure of the brake lines of my car aven driven only 25,666 miles to date. I am therefore requesting NHTSA to require MB to reimburse me for the unnecessary expense of the costly repairs. It is only fortunate that this failure was identified in my garage and not o

Subframe rusted and broke. It is available for inspection. Burlington Mercedes inspected the vehicle and told me it was not safe to drive. Mercedes-Benz USA is aware of the problem. They issued a letter extending the warranty covering only the subframe to twenty years and unlimited miles. Burlington Mercedes refused to do the subframe replacement without installing all new arms, which are currently not damaged. The cost to install all new arms is $2826.54. Mercedes-Benz USA is offering a warranty extension that their dealerships refuse to honor. This needs to be turned into a recall instead of a warranty extension. This subframe issue is dangerous. It affects Mercedes vehicles dating back to 2005 and encompasses many of their models including: SLK- Class, CLS-Class, SL-Class C-Class Sedan/Coupe, GLK-Class E-Class Sedan/Wagon, E-Class Coupe/Cabrio

The contact owns a 2012 Mercedes-Benz C300. The contact stated while driving at an undisclosed speed, he heard an abnormal sound coming from the rear of the vehicle, prompting him to pull to the shoulder of the roadway. After a visual inspection, the contact observed that both trailing arms had become detached. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who determined that extensive frame corrosion had caused both trailing arms to detach. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 143,000.

Vehicle will not start, possible ESL/EIS failure.

Car has a rear subframe damage from corrosion

While I was driving my 2012 MB C300 4Matic Sport Sedan in Nov', 2023 with history of regular maintenance, noticed a pretty load knocking noise, shudder and drifting to left a bit when it brakes from the driver's rear side especially on the highways. I took it to our local mechanic who was horrified to report that the sub frame was broken and completely rotten out too specifically rust issue with the rear suspension-rear subframe. He gets other German Cars like BMW & Audi even older and more miles in Chicago but none have rusted so much as these MB C-Class cars. Knowing the Dealers wont accept it a manufacturing defect, he was planning to repair it (no chance of wielding that thin metal sheet as the likelihood of breaking it is high). I was surprised to see 2010 Chevy Impala having a much more robust under the cover protection and no rusting with 115k miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Took my 2012 Mercedes c300 to my mechanic and the Rear Sub frame is rusting out.

Vehicle sub-frame is cracked rusted corroded.

The rear subframe broke while in motion and caused the car to drift and bounce while i was cornering the traction control and stability control intervened and i also counter steered once back in straight line i braked and the car tilted on the side, we lifted the car in a mechanic shop and found a rotten subframe one side broke the other was almost giving up.

The contact owns a 2012 Mercedes-Benz C300. The contact stated that the front driver's side interior door handle was fractured. The contact was unable to open the door from inside the vehicle. An independent mechanic inspected the vehicle and referred the contact to the manufacturer for assistance. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 95,000.

A rusted rear subframe is more prone to crack when a driver hits a pothole or wants to brake quickly, which can lead to instability in the vehicle's rear suspension.

My rear subframe has corroded and has snapped, which is a major safety issue as while driving when I come to a stop the rear end of the car swags sideways. It do not stop straight.

I started hearing noises about a week ago while driving. Last night while driving home in the evening traffic, I braked and car violently jerked and veered to the right almost hitting the car in the front. I took the car to a shop this morning and they found that the rear subframe had collapsed due to rust and advised the car was extremely dangerous to drive.

Rear driver side wheel was making a clicking noise leading us to believe there was an issue with the strut and/or shock. Due to the nature and severity of the noise, we took the vehicle to our mechanic ASAP. Upon inspection, mechanic identified that the sub-frame had completely rusted through which could lead to other catastrophic issues making vehicle no longer safe to drive unless repaired. Due to the age of the vehicle being 11 years old, the cost to repair was almost the value of the vehicle basically making this a complete loss. I understand that Mercedes Benz has extended the warranty to 20 years for this issue for other models identifying that it is a design/parts defect but not the C300 although I have found that this is also an issue for this model.

The contact owns a 2012 Mercedes-Benz C300. The contact stated while driving 35 MPH, he smelled a rubber burning odor. A message indicating that the turn signal was inoperable was displayed. The contact stated that he pulled to the side of the road and inspected the vehicle. The contact noticed that there was smoke coming from the rear passenger's side taillight. The contact stated that he opened the taillight panel and noticed that the interior and the bolt had melted. The contact was able to continue driving. The contact related the failure to Mercedes-Benz Campaign Number: 2014050001; however, the dealer informed the contact that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the campaign. The failure mileage was approximately 30,000.

Rear subframe is corroded, rusted through, and cracking.

The contact owns a 2012 Mercedes-Benz C300. The contact stated that the vehicle was making a loud bang sound towards the rear of the vehicle while driving over bumps in the roadway. The contact took the vehicle to the dealer and was informed that the rear subframe and the rear brake line were severely rusted. The subframe was replaced under an extended warranty coverage; however, the brake line was not covered under the extended warranty. The brake line was not replaced. The manufacturer was made aware of the failure. The approximate failure mileage was 110,000.

I was driving on the highway and came to a sudden stop and the car fishtailed putting our safety and the safety of others at risk. I brought my car to a mechanic and I changed my tires. When I went for a wheel alignment the mechanic found that the K bar subframe was corroded and cracked. There was no warning prior to the failure. I had no idea there was a problem because the K bar is behind the snow flap and was hidden.

Recently we had he brakes replaced and new tires put on to prepare for a trip out to Minnesota in a couple of weeks. My son felt like the car wasn’t driving correctly and took it to the shop and upon being put on the lift the service department called and said the rear subframe rusted out and was broken and the gas tank was scratched do to the subframe rubbing against it. When he called Mercedes they told him there was an extended warranty put on these cars which I never received a letter concerning this issue. *The car is waiting to be towed to Mercedes, they would not give us back the keys, it was too dangerous to drive. *my son unknowing drove this car on the highway putting himself and others in danger for who knows how long. If he did not take it in for a check before driving himself and his father to Minnesota they could have been killed. Perhaps a fire due to the gas tank damage. *confirmed by independent repair shop but will be seen when the car is towed to Mercedes. *there was no warning to the dangerous situation my family was placed in. The cars should have been recalled. We were told by Mercedes they were fixing the problem as it arises, luckily no one was injured or killed when this problem arose!

Failure of rear subframe causes car to lose control. Only found out about the problem after I received a Mercedes extended Warranty in mail March 2023, roughly 6 months after OEM Undercarriage failed and forced me to purchase another Undercarriage in cash/no insurance involved because part back ordered for many months. Car thus inoperable for roughly 4 months. At moment of the OEM failure, total loss of control. Mercedes refuses to reimburse for cost of replacing undercarriage regardless of the fact that failure occurred before notification and regardless of fact that part unavailable for months

I found out about the Mercedes Subframe failure issue after having problems on the road, that could have killed me, and being warned not to drive anymore by an authorized repair shop because my vehicle was not safe for me to drive. This has caused many other issues with my cars mechanics due to this defect from the Mercedes factory.

The drivers door handle broke. In researching online, this has been an issue with Mercedes Benz since they are made of weak plastic. Apparently, they have a more stronger version now. It’s a safety concern as you cannot open the door from the inside.You have to roll down the window, and open the door using the outside handle. What if the power window didn’t work?This is a severe safety concern. If you have to exit the vehicle in a hurry, due to a fire, or accidentally started submerging in water. This should be a recall, we should not have to pay for a replacement to the newer door handle

The contact owns a 2012 Mercedes-Benz C300. The contact stated that while his wife was driving at an undisclosed speed, she heard an abnormal sound coming from the rear of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the subframe wheel assembly needed to be replaced. No warning lights were illuminated. The vehicle was repaired; however, the contact stated that he received an unknown manufacturer’s recall for the subframe assembly which it was then taken to the dealer, and the contact was informed by the technician that the rear brake line was leaking and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 120,000.

The contact owns a 2012 Mercedes-Benz C300. The contact stated while driving at various speeds, extra brake travel time was needed to stop the vehicle. There was no warning light illuminated. The contact had taken the vehicle to an independent mechanic where the vehicle was purchased, and he was informed that the failure was caused by the new brake pads placed on the vehicle. The contact eventually took the vehicle to a dealer and was informed that the fuel tank and brake lines were corroded; and the contact was provided an estimate for the repair. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 96,000.

The rear subframe rusted prematurely and broke off important mounts for the suspension and steering. I was driving and had to hard brake. This cause the back end of the car to swerve and almost lose control. I then heard a knocking sound when I pressed the brakes, prompting me to take it into the shop. There I was informed the the subframe was rusted and the vehicle wasn’t safe to drive. I filed a claim with my insurance, but they said it’s wear and tear.

I was driving on the freeway and had to hard brake due to unexpected stopped traffic. When I braked the vehicle veered hard to the left and almost lost complete control of the car and nearly caused a serious accident. I drove immediately to a local MB dealer and they confirmed what I was afraid and suspected which was the right rear subframe needs replaced. This car was recently sold to me by a dealer less than a month ago and not a single warning light or indicator warning me of this issue. The repair is over 7500 and the shop highly recommended I no longer drive until it’s replaced. This problem is very common and MB actually covers the cost in Europe and Canada.

The left rear weld of the subframe on my 2012 C300 4matic has rotted through and appears to be a manufacture's part defect. I found out about this issue from a brake inspection and told it is a safety concern, which Mercedes Benzes is aware of but has no recalls for the defect.

It is a wide-spread issue and commonly known issue that when the car battery is replaced in Mercedes-Benz vehicles, the climate control stops working, as well as the blower. The safety issues: •Car battery needed to be replaced during non-daylight hours during the winter. •Climate control stopped working immediately upon battery replacement, and issues with blower arose. •I drove home in the dark, during winter, without the ability to defrost my windows. A quick Google search for this issue will uncover an abundance of consumer complaints and common themes regarding this issue.

A problem with the rear subframe had occurred in which it had started to rust. Due to the severity of the issue I noticed my car started veering when hitting the brakes as well multiple concerning sounds and stability issues with the vehicle. Mercedes has not contacted me about replacing the part nor has their been any warning lights or any indication of the issue being present other than when the subframe had already been rotted. When speaking to MB about the issue their was nothing they could do for me which is questionable being that the cause of this is a manufacturing issue. I have yet to receive any information as to how the issue may be resolved. Not only does this put myself at my family at risk but as well as the community around me. Wether when braking my vehicle may veer and cause a collision or an issue where the subframe fails and causes an accident.

The subframe assembly on my car is defective, as I learned today from my mechanic. This issue is known for my model of car and widely reported online. The mechanic says they have seen this issue before. I heard a strange noise while driving so I took the car to the shop after 60 days of enduring the sound. The shop immediately deemed the car unfit for driving and unsafe. In their words, if I had hit one bad pothole, the wheels could have come off the back of my car, and my gas tank could have been punctured, leading to a potentially catastrophic accident. I am lucky to have gotten this defective part identified before being injured, and others need to be protected from this outcome before a serious injury occurs. As of now this has only been inspected by the shop doing the fix. People online have indicated that Mercedes will not fix the problem free of charge - and in fact they charge a premium to other places to replace this faulty subframe. There were zero warning indicators of this dangerous issue - the car drove completely normally aside from an infrequent knocking sound that would occur every 5-10 minutes under normal city driving conditions.