2013 International Prostar

Defect. Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk. Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.

Remedy. Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.

Defect. Navistar, Inc. is recalling certain model year 2013-2014 International ProStar and DuraStar trucks manufactured April 26, 2012, to April 4, 2013, WorkStar trucks manufactured April 27, 2012, to March 29, 2013, LoneStar trucks manufactured May 21, 2012, to April 2, 2013, and TranStar trucks manufactured April 30, 2012, to March 25, 2013. In the affected vehicles, the accelerator pedal position sensor can move and result in a high engine idle.

Risk. A high engine idle may make downshifting the transmission difficult and the engine brake may be disabled. These factors may hinder slowing down the truck when descending a long grade, thereby increasing the risk of a crash.

Remedy. Navistar will notify owners, and dealers will recalibrate the electronic control module (ECM) to allow it to recognize that the pedal is at the idle position, free of charge. The recall began on January 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 15517.

Defect. Navistar, Inc. (Navistar) is recalling certain model year 2011-2014 International ProStar trucks manufactured May 18, 2010, to April 5, 2013, 2012-2014 International LoneStar trucks manufactured September 7, 2011, to March 25, 2013, and 2011-2013 International TranStar trucks manufactured October 18, 2010, to February 20, 2013. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may fail to operate or to properly engage.

Risk. If the fifth wheel and locking mechanism are sufficiently damaged, the locking mechanism may fail to operate as intended and the trailer may unexpectedly detach from the tractor, increasing the risk of a crash.

Remedy. Navistar will notify owners, and Fontaine dealers will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 18, 2015. Owners may contact Navistar customer service at 1-800-448-7825, or Fontaine customer service at 1-844-597-7393.

Defect. Navistar, Inc. (Navistar) is recalling certain model year 2011-2015 International DuraStar, ProStar, TranStar and WorkStar, 2012-2015 International TerraStar, 2013-2015 International LoneStar and IC Bus HC, and 2014-2015 IC Bus AC vehicles. A vehicle double battery jump start or electrical load dump event could result in an overvoltage condition of a component within the HVAC system linear power module (LPM) which is used to control the blower speed. The overvoltage condition could result in the overheating and failure of the LPM.

Risk. If the LPM overheats and fails, there is an increased risk of a fire.

Remedy. Navistar will notify owners, and dealers will replace the LPM with an upgraded one, free of charge. An interim letter was mailed to owners on June 18, 2015. A second notification will mailed when parts become available. The recall began on August 6, 2015. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 15509.

Defect. Navistar, Inc. (Navistar) is recalling certain model year 2010-2015 International Lonestar vehicles manufactured October 12, 2009, to June 16, 2014, and 2009-2015 International ProStar vehicles manufactured December 16, 2008, to June 20, 2014. In the affected vehicles the electrical harness that supplies power to the HVAC system may not be of sufficient size for the electrical load of the circuit. This can result in an increase in resistance and heating at the connectors.

Risk. An increase in resistance and heating at the connectors could cause a vehicle fire.

Remedy. Navistar will notify owners, and dealers will replace the 60 amp relay and battery harness with a 150 amp relay and battery harness, free of charge. Navistar issued an interim notification to owners on December 29, 2014. The recall began on March 2, 2015. Owners may contact Navistar customer service at 1-331-332-1590. Navistar's number for this recall is 14516.

Defect. Navistar Inc., is recalling certain model year 2012-2013 International Lonestar, Paystar, Prostar, Workstar and 9900 trucks, equipped with feature code 0504501, 0504504, or 04EWM Reduced Stopping Distance (RSD) brake linings and with or without feature code 04WCS Greased For Life front air S-cam brakes. In the affected vehicles, the brake S-cam brackets may fracture.

Risk. S-cam bracket fractures may result in an inoperative brake on the affected wheel. This will cause the vehicle to pull to one side unexpectedly during braking and/or increase the stopping distance. Either result may increase the risk of a crash.

Remedy. Navistar will notify owners, and dealers will replace the S-cam brake assemblies with a brake assembly with cast spiders and S-cam tube bracket assemblies with reinforced gussets, free of charge. The recall began on March 27, 2014. Owners may contact Navistar at 1-331-332-1590. Navistar's number for this recall 14501. Note: This recall is an expansion of recall 13V231.

Defect. Navistar, Inc. is recalling certain model year 2013-2014 International ProStar sleeper cab vehicles manufactured December 12, 2012, through August 8, 2013 and equipped with feature code 16XSA, 16XSB, 16XSC or 16XSD chassis skirts. In the affected vehicles, the rear chassis skirt upper horizontal support S-bracket may rub the fuel tank causing a hole in the tank.

Risk. A hole in the tank would allow fuel to leak onto the roadway causing dangerous driving conditions, which could result in a vehicle crash, property damage, personal injury, or death.

Remedy. Navistar will notify owners, and dealers will reinstall the chassis skirt with proper clearance, free of charge. If necessary, the fuel tank will be replaced. The recall began on March 31, 2014. Owners may contact Navistar at 1-800-448-7825. Navistar's recall number is 13517.

Defect. Navistar, Inc. is recalling certain model year 2008-2013 International LoneStar, ProStar, and TranStar trucks manufactured February 20, 2008, through July 29, 2013 and equipped with an electronic fifth wheel jaw release system (feature code 0595BAW or 0595BAY). Due to an assembly error, the air lines at the isolation/vent valve may not be oriented correctly.

Risk. Because of the improper orientation, in the event of an air leakage at the isolation/vent valve, the 5th wheel jaw may release, unexpectedly releasing the trailer from the tractor, increasing the risk of a vehicle crash.

Remedy. Navistar will notify owners, and dealers will inspect the air line routing. If necessary, the air line routing will be corrected free of charge. The recall began on October 10, 2013. Owners may contact Navistar at 1-331-332-1590. Navistar's recall number is 13514.

Defect. Navistar is recalling certain model year 2012-2013 International brand ProStar and TranStar commercial trucks, manufactured from August 01, 2011, through July 10, 2012, and equipped with front brake linings listed as feature codes 0504501, 0504504, or 04EWM. The brake S-Cam tube bracket assemblies on the steer axles may fracture.

Risk. Brake assembly fractures may result in an inoperative brake on the affected wheel. This will cause the vehicle to pull to one side unexpectedly during breaking and/or increase the stopping distance. Either result may increase the risk of a vehicle crash.

Remedy. Navistar has already notified all affected owners about the defect during the course of the 2012 campaign that did not launch due to parts delays. The remedy began on September 12, 2013. Dealers will replace the S-Cam tube bracket assemblies, free of charge. Owners may contact Navistar at 1-800-448-7825. Navistar's number for this recall is 12530. This recall supersedes recall 12V-546.

Defect. Navistar is recalling certain model year 2011-2012 International Lonestar, model year 2012-2013 International Terrastar and model year 2011-2013 International DuraStar, ProStar, TranStar, and WorkStar commercial trucks manufactured from June 1, 2010, through March 7, 2012 and equipped with day cab codes 16CAB, 16030, or 16196 and feature codes 16WCE, 16WCR, 16XWD, 16XWE, 16XWV, 16XXB, 16XXD, 16XXE, 16XXG, or 16XYN sun shades. The sun shade may not be properly secured to the cab roof panel which may result in partial or full separation of the sun shade from the roof panel.

Risk. If the sun shade separates from the cab roof during vehicle operation, the sudden release of the sun shade could distract the driver increasing the risk of a crash.

Remedy. Navistar will notify owners, and dealers will inspect and strengthen the sun shade mounting, free of charge. The safety recall began on September 10, 2013. Owners may contact Navistar at 1-800-448-7825. Navistar's campaign number is 13505.

LOS INJECTORES TIENEN PROBLEMAS Y EL CAMION TIENE MENOS DE 75K MILLAS , SE PIENZA QUE HAY UN DESGASTE EN EL ARBOL DE LEBA PRODUCTO A AL PROBLEMA DEL INJECTOR , QUE CUESTA EL ORIGINAL 850.00 SEGUN EL DEALER

MY DRIVER WAS HEADING UP THE 93/95 RENO WHEN THE FRONT SEAL BROKE ON THE NAVISTAR MAXXFORCE ENGINE. MY TRACTOR RELEASED ALL OF THE OIL ONTO THE HIGHWAY. WHICH CAUSES ENGINE TO SHUT DOWN. I WAS TOLD BY THE TECH THAT THIS PROBLEM IS VERY COMMON WITH THIS PARTICULAR ENGINE I'VE ALREADY REPLACED TWO TWO FRONT SEALS WITH MY OTHER TRACTORS WHICH ARE 2013 PROSTAR MAXXFORCE ENG

WHILE IN MOTION THE ALUMINUN HANGARS ON MUD FLAP SPLASH GUARD ASSEMBLY BROKE OFF AT HANGAR SECURMENT AREA WEAKENED IN FRONT OF DUAL TIRES FAILED AT 465;000 MILES BOTH BRAKETS FAILED LEFT AND RIGHT AND FELL OFF ON TO ROAD, HANGAR, MUDFLAP ASSEMBLY DUE TO POOR TENSILE DESIGN OF ALUMINUM SERATED.. I REPLACED AT $500.00 BOTH HANGR AND MUD FLAP COST TO ME NOTIFIED NAVIISTAR INYTERTNATIONAL AND CREATED A CASE FILE THERE 3775108 LAST MAY. SUBSEQUENTLY, LAST WEEK 7.18.2017, THE HOOGD GRILLE CLIPS FAILED ON BUMPY RAODS AND THE GRILLE ASSEMBLYFLEW OFF. THERE ARE 4 BOLTS ON ON THE BOTTOME OF THE GRILLE SECUREING THE GRILL TO THE BODY. CLIPS AT THE TOP HOLD THE GRILL IN BUT FAILED OVER BUMPY ROADS AND GRILL FELL FOREWARD IN MOTION CRACKED OFF BROKE PLASTIC SECUREMENT 4 SCREW PLASTIC HOLDERS PART OF THE HOOD BODY AND RIPED OFF. NAVISTAR NOW HAS 4 MORE BOLTS AT THE TOP ON THEIR 2016, 2017 NEW TRUCK MODELS ADMITTING 4 BOLTS WERE NOT A VIABLE ENGINEERING SECUREMENT. MUD FLAPS ASSEMPBLEY 2 OF THEM ARE ON THE ROADS AND A GRILE FROM POOR NAVISTAR INTERNATIONAL ENGINEERING. FLEET NEEDS TO BE GROUNDED. PEOPLE WILL GET KILLED. SO, IN 3 MONTHS 2 MUD FLAPS FELL OFF THE TRACTOR AND THE GRILLE FLEW OFF DUE TO IMPROPER SECUREMENT TO THE TRACTOR. ENGINEERING DID A CHEAP JOB. MORE WILL FAIL. MORE COMPONENTS WILL FAIL ON 1,000S OF TRACTORS OUT THERE. I EXPECT TO BE REIMBURDSED IN FULL. REPAIRS OVERALL WILL COST ME $20,000 IN LOST LOADS DUE TO NAVISTAR ENGINEERING FAILING ON MY GRILLE, HOOD, MUD FLAPS AND

TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. WHILE DRIVING VARIOUS SPEEDS AND APPROACHING A STOP, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE RETURNED TO NORMAL AFTER IT WAS RESTARTED. THE FAILURE RECURRED ON VARIOUS OTHER OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000.

TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE REVVED WITHOUT WARNING. WHEN THE DRIVER ATTEMPTED TO TURN THE IGNITION OFF, THE VEHICLE FAILED AND THE ENGINE STALLED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TURBO SEAL FAILED AND PUMPED OIL INTO THE ENGINE, WHICH CAUSED THE ENGINE TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 301,272.

TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE DRIVER'S SIDE HEADLIGHT FAILED. UPON INSPECTION, IT WAS FOUND THAT THERE WAS A WIRING ISSUE. LATER, THE ENGINE COMPARTMENT BECAME ENGULFED IN FLAMES WHILE THE CONTACT WAS ASLEEP IN THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND DETERMINED THAT THE FIRE ORIGINATED AT THE DRIVER'S SIDE HEADLIGHT. THE PASSENGER SUSTAINED A BROKEN ANKLE FROM JUMPING OUT OF THE VEHICLE AND BOTH THE CONTACT AND PASSENGER SUFFERED FROM SMOKE INHALATION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 115,097. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2013 INTERNATIONAL PROSTAR. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE ENGINE COMPARTMENT SUDDENLY BURST INTO FLAMES. THE CONTACT PERSONALLY EXTINGUISHED THE FLAMES. THE FIRE AND POLICE DEPARTMENTS WERE SUMMONED. THE CONTACT AND PASSENGER SUFFERED FROM SMOKE INHALATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WAS NOT AVAILABLE.

I HAVE A 2013 NAVISTAR PROSTAR THAT I'VE HAD TO TAKE INTO THE DEALER FOR VARIOUS REPAIRS. CURRENTLY, I HAVE EXPERIENCED A PROBLEM WITH THE DIESEL EXHAUST ENTERING THE CAB THAT HAS CAUSED MY EYES TO BURN, A LACK OF STRENGTH AND OTHER HEALTH ISSUES THAT ACCORDING TO MY DOCTOR, I SHOULD NOT BE DRIVING UNTIL THE PROBLEM IS RESOLVED. THE DEALER HAS OFFERED LITTLE OR NO ASSISTANCE CLAIMING THEY WILL HAVE TO REMOVE THE CAB TO INSPECT THE EXHAUST. ALSO, I HAVE A PROBLEM WITH THE CRUISE CONTROL NOT SLOWING THE TRUCK DOWN WHEN GOING OVER A HILL. I HAVE TO TAP THE BRAKES IN ORDER DEACTIVATE THE SYSTEM AND THEN USE THE JAKES BRAKE AND REGULAR BRAKE TO SLOW THE TRUCK DONW.