2022 Hyundai Tucson

Defect. Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.

Risk. Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 290. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 20, 2025.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.

Risk. A detached roof molding could become a road hazard, increasing the risk of a crash.

Remedy. Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.

Risk. Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.

Remedy. Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after …

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional …

Certain 2022 – 2025 model year Santa Cruz and 2022 – 2025 model year Tucson vehicles may have front wipers that do not return to the designated park position due to a loose wiper motor crank arm nut. At Hyundai, we are committed to providing vehicles of outstanding quality and value. In an effort to meet this commitment, the warranty coverage for the Wiper …

Some Tucson (NX4A and NX4M) and Santa Cruz (NXT) vehicles may have front wipers that do not return to the designated park position due to a loose wiper motor crank arm nut. Hyundai is extending the warranty coverage for the wiper motor crank arm nut under this condition to 10 years / 100,000 miles from the date of original retail delivery or date of first …

Some Tucson (NX4A and NX4M) and Santa Cruz (NXT) vehicles may have front wipers that do not return to the designated park position due to a loose wiper motor crank arm nut. Hyundai is extending the warranty coverage for the wiper motor crank arm nut under this condition to 10 years / 100,000 miles from the date of original retail delivery or date of first …

Some Tucson (NX4A and NX4M) and Santa Cruz (NXT) vehicles may have front wipers that do not return to the designated park position due to a loose wiper motor crank arm nut. Hyundai is extending the warranty coverage for the wiper motor crank arm nut under this condition to 10 years / 100,000 miles from the date of original retail delivery or date of first …

Some vehicles equipped with a 2.5L GDI Theta III engine (non-Turbo) may exhibit one or more misfire DTCs due to the GDI fuel injectors leaking internally. This may be caused by internal filter breakage in the injector. Follow the procedure in this TSB to replace all 4 injectors on affected vehicles, using the kit in the Parts Information section.

Some vehicles equipped with a 2.5L GDI Theta III engine (non-Turbo) may exhibit one or more misfire DTCs due to the GDI injectors leaking internally. This may be caused by internal filter breakage in the injector. Follow the procedure in this TSB to replace all 4 injectors on affected vehicles, using the kit in the Parts Information section.

The windshield wipers were set to auto during a torrential downpour. When they increased to a high speed of wiping, we heard a large crack and the windshield wiper had completely broke on us. We were going around 45 MPH on a highway and were 1 hour away from our destination. We had little to no visibility for the remainder of the car ride as it continued to downpour and was the most terrifying drive. We went to Dick Hannah's in Portland, OR to get it fixed. My fiance, who is an automotive engineer, told them what he believed happened; something in the arm itself has malfunctioned or misaligned to cause this. The dealership claimed it was the windshield wipers that caused them to break. I had purchased the car from carmax a few months prior, so they told us it wasn't covered. We went back and forth as we were certain it wasn't the wipers, but took their word for it. They "fixed it". Then, it happened for the second time. I was driving 55 MPH on the freeway while it was down-pouring and again, while set to auto, the wipers broke. It's hard not to panic. I immediately turned off the wipers before more damage could happen and lost visibility completely, causing more panic. I tried to switch it to low to get some visibility and took the next exit I could. I never made it to my destination and drove home instead on inside roads just in case. I don't understand how this isn't a recall. It has put us in such dangerous situations. High-speed highways/freeways, downpours, and no visibi

The contact owns a 2022 Hyundai Tucson. The contact stated that while driving 60 MPH, the sunroof glass shattered without impact. The vehicle was taken to an independent mechanic, and the sunroof glass was replaced. The vehicle was repaired. The failure mileage was approximately 70,800.

The contact owns a 2022 Hyundai Tucson. The contact stated that while attempting to operate the windshield wipers, the wiper blades froze. The contact attempted to restart the wiper blades cycle, but the failure reoccurred repeatedly. The contact stated that the failure created a safety hazard while driving in inclement weather. The dealer was contacted and a diagnostic test was pending. The failure mileage was 30,000.

The fuel door doesn't work. My safety is at risk because I cannot put gas in my car. If i can't put gas in my car then it will stop working. If it starts working, the car becomes useless. There were no warning lights or anything. This is a common problem and should have a lifetime warranty.

Approximately one week after having my oil changed at a Hyundai dealership, I began experiencing intermittent collision safety alerts and multiple dashboard warning lights. On three separate occasions when I started the vehicle, warnings appeared for the forward and rear collision systems, along with multiple other sensor warnings and engine warning lights. During one incident while driving in traffic, the forward collision warning activated and the vehicle abruptly applied the brakes. I was nearly rear-ended as a result. I have taken the vehicle back to the dealership on two separate occasions. The dealership reported replacing a sensor, but the warning lights and collision system issues have continued to occur intermittently. I am concerned that the vehicle may unexpectedly apply the brakes again, creating a risk of a collision.

The contact owns a 2022 Hyundai Tucson. The contact stated while driving at 5 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the vehicle independently accelerated. The contact stated that the brake pedal was depressed with force and the vehicle stopped. The failure was intermittent at first but became more persistent. The dealer was contacted by phone and made aware of the failure. The failure mileage was approximately 20,000.

On three occasions my car suddenly stopped transferring power by not accelerating when the gas pedal was pressed. The first time the engine light came on and when I brought it for service they said it was a sensor covered by warranty and repaired it. The second time it happened while I was trying to merge with traffic on the highway. I took an exit and managed to get to the dealer. They replaced the fuel injector and fuel line. The third time, first the car struggled to start after work. Then, I was pulling out of the parking lot, crossing a very busy road. The car could barely get up to and past 20 mph. Once I got it to 35 or so, I stayed on local roads with my hazards on, and managed to get it to the dealer. No engine light came on and they haven’t been able to replicate the issue. This is a very serious safety concern! I am afraid to drive it now since the car can stop without warning and without any brake lights coming on. I am fully covered by warranty but am worried they won’t want to cover the cost to make my vehicle safe. Google shows engine problems like this as one of the known issues on the 2022 Tucson Limited.

My car suddenly broke down on the side of a busy highway halfway through my workday. When attempting to restart it, all warning lights came on on the dashboard and I could see white smoke coming out of the exhaust pipe while the car shook. I had it towed to the nearest Hyundai dealership and they confirmed it was broken fuel injector(s). I do not have the broken piece to show as it is with the dealership. It has not been examined by police or insurance. No warning lights came on until after the car had suddenly slowed to a stop and I attempted to restart it.

Vehicle Fuel Injector code P053F84 Reading on 9/9/26, this is the second time vehicle was taken to the dealership for the exact same problem, the idle button in orange, and displayed, first visit while vehicle within warranty limits technician stated couldn't find anything wrong, now vehicle is out of warranty and dealership wants $1300 to fix the same issue.also the Engine was hesitating at each occurrence.

I had just started accelerating from a stop light at 715 am on a clear morning. I was not close to any other cars and there was no traffic entering. Without warning my collision warning came on and brought the car to a sudden stop. This is damgerous and I am lucky I was not rear ended

The car was shaking, idling and accelerating and engine lights on.

The contact owns a 2022 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the right turn signal indicator light failed to illuminate on the instrument panel upon depressing the turn signal lever to make a right turn. No warning lights illuminated. Additionally, upon depressing the turn signal lever to make a left turn, the left turn signal indicator light failed to illuminate. The contact stated that the failure progressed. While driving at various speeds, the brake lights failed to illuminate when the brake pedal was depressed. The vehicle was taken to an independent mechanic, where it was diagnosed that the wiring harness needed to be replaced. The vehicle was repaired. The contact associated the failure with NHTSA Campaign Number: 25V893000 (Trailer Hitches); however, the VIN was not included in the recall. The dealer and the manufacturer were notified of the failure, and a case was filed. The failure mileage was approximately 69,000.

In April 2026 (29,805 miles) I was on an interstate underpass U-turn and when I went to accelerate from the U-turn, the vehicle “revved”, had difficulty accelerating, and appeared to not go into the next gear for a roughly 10 seconds, meaning I was unable to accelerate and get out of the way from oncoming traffic. Traffic slowed and the vehicle suddenly returned to normal (no warning lights appeared) and I drove home cautiously with hazards on. When attempting to leave less than 45 minutes later, the vehicle started, then as I placed it into drive, it began lunging and the check engine light appeared. Because it was running rough and kept lunging, I parked and had it towed to the dealership. The DTC code listed was PO30300 (DTC system powertrain and subsystem EMS). Per the dealership, fuel injector #3 was bad and needed to be replaced. When I picked up the vehicle, notes stated “ GDI FUEL INJCTR REPL (ALL4)”. I picked up the vehicle after the repair. In August 2026 (30,923 miles), with less than 1,000 miles driven since repair, I started the vehicle and it immediately “died”. I restarted it and the check engine light came on and it began lunging out of my driveway. I also had difficulty getting the vehicle to brake and almost hit our community entrance/exit gate. A notification appeared on my infotainment system stating: “A possible condition with your Engine Control System has been detected. A full system check is recommended to be done soon. Please contact your local dealer

Vehicle turned itself off with no warning while being driven @ 40 moh. Dealer suspects fuel injectors, but could be ignition coil.

The contact owns a 2022 Hyundai Tucson. The contact stated while driving at an undisclosed speed, several unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with ECU software error. The contact was advised to contact the dealer. The dealer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 108,565.

On August 26, 2026, while driving to work, my 2022 Hyundai Tucson unexpectedly lost power and shut down while the vehicle was being driven. This created a serious safety concern because the vehicle became inoperable while in traffic. This vehicle has had a history of repeated problems and has been taken to Hyundai dealerships for repairs on numerous occasions. Despite these previous dealership visits and repair attempts, the vehicle continues to experience problems. The latest incident, in which the vehicle shut down while being driven, has significantly increased my concern regarding the safety and reliability of the vehicle. The vehicle is being made available for inspection and diagnosis. At this time, the exact component or cause of the failure is unknown. I am requesting that this complaint be documented because of the sudden loss of power while driving and the vehicle's history of repeated dealership visits and repairs. I am concerned that this condition could cause a crash if the vehicle unexpectedly loses power again while traveling in traffic or at highway speeds.

Fuel injector went bad causing vehicle engine to misfire and shake rapidly. Check engine light is on. The vehicle only has 40,000 miles on it. Seems to be a very common concern for this make and model and roughly the same years. Will not accelerate instantly and will surge a bit when it does. Will still shake when the vehicle is idle.

My wife was driving my SUV while I was a passenger. We were in the left lane, and put the left turn signal on while traveling south bound approaching an intersection to take a left turn (traveling approximately 3-5 Miles Per Hour and slowing) at the traffic light (traffic light was green). There was a car in front of us that had stopped waiting for oncoming traffic to clear and make the same left turn onto the same road as us. While traveling in this lane we hit a deep pot hole (not very visible while driving), just as we were approaching the vehicle stopped in front of us. When hitting the pot hole, our SUV seemed to leap forward a bit and when the brakes were applied to slow and stop, the braking system failed (appeared to freeze) and the brakes did not work, and because the braking didn’t work, our vehicle hit the car in front of us. Prior to and after hitting the pothole, no audible warning sounds or visible alerts appeared and no emergency braking was activated. The airbags in our vehicle never deployed. Our safety (my wife and I) as well as the safety of the 2 passengers in the other vehicle were at risk as we all could have been injured in the accident. As we needed the vehicle for transportation, we immediately began filing all the necessary police and insurance reports and brought our vehicle into an Auto Body Repair Shop to be repaired the next day. During the repair work, some of the responsible components may or may not have been replaced and the Auto Body Repair

The contact owns a 2022 Hyundai Tucson. The contact stated that the check engine warning light illuminated and was cleared; however, the warning light returned hours or days later. The dealer had cleared the check engine warning light approximately 15-16 times. The vehicle occasionally stalled while driving at various speeds. The dealer diagnosed the vehicle with terminal engine failure. The contact was informed that the fuel system needed to be overhauled, and the fuel injectors and caps needed to be replaced. The vehicle was repaired twice. The failure persisted after the contact had confirmed the diagnosis with a certified mechanic. The vehicle was returned to the dealer, who replaced the engine. The vehicle was parked for several hours, and the contact attempted to turn on the headlights, but the headlights failed to illuminate. While driving the vehicle, the vehicle hesitated several times. The following day, the vehicle failed to start approximately four times. The vehicle was driven to the dealer but hesitated several times along the way and failed to start once at the dealer. The dealer diagnosed the vehicle and determined that the battery and other parts needed to be replaced; however, the vehicle was not repaired. The manufacturer was made aware of the failure, and a complaint was filed. The failure mileage was 3,212.

While driving at night, the headlights on my 2022 Hyundai Tucson Hybrid shut off randomly, including when using the turn signal. The lights will turn off without warning at highway speeds, creating a serious safety hazard. Using the turn signal can cause the headlights to turn off, and sometimes using the turn signal will temporarily turn them back on. The headlight mode also changes by itself while driving (AUTO to OFF to ON to OFF). Additionally, when the vehicle is turned off, the headlights often stay on no matter what mode the switch is in. I have to restart the vehicle and manipulate the turn signal/headlight stalk multiple times to get the lights to turn off. This is a recurring and dangerous failure that affects nighttime visibility and safety for me and my family. No other electrical issues are present. This is available for inspection. Safety for my family and all others on the road put at risk as the headlights randomly shut off at night. The problem was reproduced by the dealer. The dealer quoted a $1,500 repair, but this a safety‑critical defect in the lighting control system.

Front brake rotors warped causing violent brake pedal pulsating and steering wheel vibration. My vehicle has only 18000 miles. The dealership Hyundai reported problem as a service bulletin TSB 23-BR-004H. I believe this a safety issue and a recall should be annouced.

The contact owns a 2022 Hyundai Tucson. The contact stated that while his wife was operating the vehicle, the vehicle lost headlight functionality without warning. In addition, the contact stated that the radio intermittently failed to operate while driving the vehicle. The contact stated that the headlight became operable when his wife was near to her destination. The vehicle was not diagnosed or repaired. Upon investigation, the contact discovered NHTSA Campaign Number: 21V938000 (Electrical System, Exterior Lighting); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 25,800.

While driving the car stalled and then the engine shutdown, caused by a misfired fuel injector. Myself and the passengers in the car were minorly safe, as this incident occurred while driving through the Yellowstone National park; having to pull over on the side of the road with no shoulder. The Woody Smith Hyundai Dealership in Idaho Falls confirmed that the feul injectors had misfired, and then replaced them. Prior to the failure, there was no warning until the car was actively stalling and failing (battery light and check engine light came on).

Unintentional and unexpected activation of emergency collision or adaptive cruise control, causing the vehicle to stop and become immobile in the lane of traffic. I was driving down the interstate with the adaptive cruse control on and the lane keeping assistance on. These both were on for about 20 minutes as I was driving down the highway. There were no vehicles in front of or behind me for a quarter mile or so. I as all alone with nothing around me. All of a sudden it seemed like the collision avoidance system activated. The car came to a complete stop in the right lane of the highway. I tried to proceed and could see the emergency brake was on, the engine was running the car was in drive but it would not move. Flipped on the hazard flashers and traffic caught up to me while sitting in the right lane of the highway waiting to get rear ended. Vehicles were barely getting by at 70 MPH. The car would I pressed the accelerator and the car move d forward enough to get off the highway, this took a minute or two. Once off he highway, I could see the emergency brake would not release. I turned the engine off went out to inspect all the forward sensors. There was no visible issue. I restarted the car after a minute or so and it proceeded normally. That was Saturday, this is Sunday, I am taking the vehicle to Hundai tomorrow for inspection.

On July 24, 2026, while driving on a marked city street with no vehicle, pedestrian, or obstruction ahead, the Forward Collision-Avoidance system on our 2022 Hyundai Tucson Limited AWD applied emergency braking on its own, three to four separate times, each lasting one to two seconds. Traffic behind us nearly struck our vehicle. My family was in the car. This is the latest event in a progressive electrical fault history. In June 2025, under warranty at 48,037 miles, a Hyundai dealer documented recurring multi-system warning cascades (forward safety, lane keeping, high beam assist, speed limit warning) and a failed auto start/stop system. The dealer's listed resolution was "battery voltage / replace battery"; their invoice records that no repair was performed. We replaced the battery at our own expense. The faults continued. In June 2026, the start/stop system shut the engine off at a red light and the vehicle would not restart, leaving us disabled in a live traffic lane. Power was only restored by cycling the hood release. Since then, TCM and ECU software updates and a battery harness replacement (our expense, approx. $1,200) have been performed. The faults persisted after these repairs and have now escalated to uncommanded emergency braking. Date- and time-stamped video and photographs exist for multiple events. Two Hyundai dealerships have not identified a root cause. Similar phantom braking reports exist from other owners of this model year. We no longer consider the vehic

On XXX, while approaching a stop sign, the vehicle did not engage the brakes as expected. I had to press the brake pedal multiple times, and the vehicle jerked several times before it came to a stop. Given that a brake failure of this kind poses an immediate risk to my safety and the safety of others on the road, I had the vehicle towed in for service right away. I took the vehicle to Courtesy Hyundai of Tampa (3810 W Hillsborough Ave, Tampa, FL 33614) on Monday, XXX (Repair Order #XXX). Service Advisor Dominick DeLeva documented the complaint and had the vehicle test driven. The dealership's notes state that the issue could not be duplicated, no fault codes were present, and the brake fluid level was correct. A multi-point inspection was also completed. The vehicle was returned to me on July 14, 2026, with no repairs made and no explanation for the braking irregularity I experienced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Phantom braking while driving under a bridge. No cars around but Tucson warned collision while driving under a bridge and slammed on the brakes! This has happened multiple times. This fake safety feature is actually a hazard!

When driving have been reviving a warning that says adaptive cruise control failure followed by a short time were the car may unexpectedly break on the interstate.

I became aware of a Technical Service Bulletin that Hyundai published in Jan 2025 acknowledging that many vehicles (of which mine is one) have a faulty fuel injector and it will fail. Hyundai elected to not issue a recall on this issue so the public has no idea they are driving vehicles that are just awaiting for a malfunction in their engine. It appears the reason Hyundai is doing this is because fuel injectors are only covered on the manufacturer’s limited 5-year 60,000-mile warranty so they are hoping the faulty injectors last long enough to get beyond that point and customers don’t know the injectors were even faulty to begin with (because TSBs are not public knowledge). Hyundai can then charge for full repairs and omit admittance that the injectors were faulty and blame it on wear and tear. Mine failed beyond 60,000 miles and I am in this predicament. I imagine most customers with 2022 vehicles have not driven as much as me and haven’t had this come up. It seemed like something I should inform someone about. Do with this what you wish

My 2022 Hyundai Tuscon came to a complete stop on the highway in Colorado twice in the last 2 months for no apparent reason. There weren't any obstacles or cars in front of me that would have caused the car to brake suddenly. I had passengers in the car and we were jolted forward. The air bags did not inflate and we were not hit from behind, but we could have been severely injured or killed. There are numerous "phantom braking" reports like this here on the NHTSA site for the 2022 model as well as more recent models. Yet Hyundai has only issued recalls for the 2025 and 2026 models. How are you addressing this issue?

Fuel door actuator failed to unlock had to take the car into the dealership to replace a malfunctioning actuator. Left me stranded at a gas station unable to fuel the car.

On 3 occasions over my 18-month ownership of this certified pre-owned Hyundai 2022 Tucson, the vehicle surged suddenly forward WITH BRAKE APPLIED at creeping (parking) speeds of 3-4 mph. No warning lamps were observed. On the most recent (3rd) occasion, a crash over a sidewalk and into a storefront caused $10,000 damage. No pedestrians were harmed, no airbags deployed and neither passenger was harmed. The service department is "unable to duplicate" the surging behavior and declares the car mechanically "safe to drive."

My 2022 Hyundai Tucson Experience, a sudden transmission failure at approximately 92,520 miles. The vehicle develop shifting issues and abnormal noises before losing propulsión. While driving. Hyundai diagnosed and internal Transmission failure and approved transmission replacement. I’m concerned about the sudden loss of proportion and the safety risk this creates. Hyundai proposed repair is to replace the transmission with a rebuild remanufacture transmission rather than a new transmission. I am concerned about the reliability of the repair following a complete transmission failure.

I am submitting this complaint regarding my 2022 Hyundai Tucson equipped with the 2.5L engine. The vehicle has experienced multiple incidents of severe engine misfiring while driving. During these events, the engine begins to shake violently, the entire vehicle vibrates, and engine power is significantly reduced. The vehicle becomes unable to accelerate normally, creating a serious safety hazard, especially when driving on highways or in traffic. The malfunction has occurred several times. Diagnostic trouble codes P0302 and P0303 have been recorded, indicating cylinder misfires. In some cases, turning the engine off and restarting it temporarily restores normal operation. On other occasions, adding fuel system cleaner appeared to temporarily improve the condition. However, the problem eventually returns. Because the condition is intermittent, the Hyundai dealership has been unable to reproduce the failure during inspection and therefore has not performed a repair under warranty. Despite multiple visits, the root cause remains unidentified. I am concerned that the sudden loss of power and severe engine vibration could result in an accident if the vehicle is unable to maintain speed or accelerate while traveling at highway speeds. This issue has significantly affected the safe operation of the vehicle. I request that this matter be investigated, as it appears to be a recurring safety-related defect.

I was told there was a known issue with the electrical system with the front bumper harness and wiring harness need to be replaced due to water damage & Vehicle's horn keeps on going out and has to be replace

The contact owns a 2022 Hyundai Tucson. The contact stated that the fuel door had failed to open intermittently. The contact stated that the failure had progressively worsened, causing the contact to seek assistance to open the fuel door. The vehicle was taken to the dealer where it was being repaired. The manufacturer was not contacted. The failure mileage was approximately 50,000.

About once a month on average my Tucson's emergency system braking comes on without an emergency. It seems to occur mostly when taking an exit on the highway, but a few times it has been completely random. All of these instances have had no other vehicles around or any roadway barriers present. When it activated, lighting comes up on my dash telling me the emergency braking is activating. Sometimes it brakes, other times it does not seem to. Mostly, it seems that if I keep pressing down on the gas pedal it just turns itself off. I've never had my car come to a complete start but I have had it hit the brakes hard a few times. I bought the vehicle brand new and have had it for 4.5 years, and it has always done this. I've had the dealership reinstall the software that controls the braking system, but it had no affect. I ask the dealer every time I go in if others are complaining about this and I am always told no. However, I saw a similar recall was just put into place for the newer years of the Tucson, and it makes me think they are told to tell people no one is complaining about this.

I have experienced the Emergency Braking System Warning and Sudden Application of my Brakes when traveling at highway speeds for what seems to be no apparent reason. I thought it had to be a glitch related to just my car; However, this has happened twice in the past month and it is an unnerving experience. As I just read about this same problem occurring in later models of my car I want to document that this same problem exists in my 2022 Hyundai Tucson.

Multiple DTC codes on car at 25,120 miles,32,344, 34,324, 47,484, 51,853, 53,521, Consistent Fuel Injector failing under warranty, prior to 60,000 miles and not replaced correctly, as I have had to see dealership 4 times for ineffective fuel injector replacement and consistent problem. First DTC code reading @ 25,120 miles as stated on DTC coding Reports through Hyundai/Bluelink app. SEVERE Fuel leak into interior cabin and Fuel failure due to Powertrain/Injector Issues from 25,120 miles, and many more mileage as seen above. AUTO start does not work, Catalytic Converter is in need of replacement as codes read DTC code past readings and Engine Failure: P04567A, P030300, P022200,P012300,P210013,P042033,P042033 With FUEL INJECTOR/Powertrain Error. Caused car to engine fail in middle of driving!! *SAFETY CONCERN. I Have started multiple cases with Hyundai Motor America, and they had done nothing to report the problem or keep car for further testing and safety priority. Car is brand new, has about 66,800 miles on it now, had to replace all FUEL INJECTORS, FUEL RAIL, and now needing to replace Catalytic Converter due to Hyundai not covering issue that was consistent with Fuel Injector and initial GAS leak into Cabin. I had to visit the doctor many times due to GAS FUMES. 2025-2026-DTC codes stated under individual mechanic, and within my Hyundai Blue Link app as reading multiple DTC codes that Hyundai Refused to cover or fix initially. (Wrights Car Care, Atlanta, GA) stated that ca

The contact owns a 2022 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 25V893000(TRAILER HITCHES); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer and local dealer was not contact made aware of the issue. The contact had not experienced the failure.

Unintended acceleration, brakes unable to stop vehicle. Almost hit a car stopped at red light. I was able steer right avoiding hitting the stopped car and quickly put the car in neutral and then applied the brakes again. I was able to drive home another 10 miles. I had the car towed on 5/18/2026 to the car dealership for inspection. This put the car stopped and me and my wife at risk of injury. Car dealership has inspected the car and can not duplicate the problem. No warning lights before the event.

The rocker arm of the engine has failed, causing a repair for a full engine replacement. The car has always undergone maintenance timely, and upon inspection by the dealership technician, the report state the vehicle was up to adequate level. There were no symptoms before the issue occurred, only the sudden catastrophic engine failure.

This recall still hasn’t been resolved. why hasn’t the manufacturer found a fix for this problem I have owned the vehicle for 4 years they should have known about this and fixed it by now. NHTSA recall number: 25V-893 Hyundai recall number: 290

Check engine light appeared, Car began shaking and struggling to accelerate. Independent mechanic and OReileys test stated cylinder 3 misfirw. Dealership stated GDI fuel injectors were leaking and is a known issue in several 2022 Hyundai Tuscon and needed to be replaced.

The contact owns a 2022 Hyundai Tucson. The contact stated that while maneuvering into a handicap parking space, the vehicle suddenly accelerated on its own while the brake pedal was depressed. The vehicle climbed over a concrete parking bollard and struck a handicap sign, resulting in unintended acceleration. The vehicle was damaged in the undercarriage. No air bags were deployed. No injuries were reported. Property damage was a handicap sign. The vehicle was occupied by 2; the driver and passenger. A police report was filed. The vehicle was taken to the dealer, but has not been diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 26,100.

At a slow speed the car lurched, paused, in traffic. The engine light is on. It could be dangerous.

1st Incident: Merging on to the freeway car started to stall but was able to safely make it off the freeway at next exit. Less than 2 miles was unable to accelerate to properly merge on freeway. A slow merge & slow driving on to a freeway is extremely dangerous. 2nd Incident: 6 months later, Nov. 2023. Driving about 65-70 MPH on the freeway with my son, the car started to stall again. I was able to safely move from the 2nd lane, to the shoulder. Waited over 2 hours in the dark for AAA to safely move us. 1st time documented issues with Hyundai dealership. Fuel injector was main issue and was replaced. No check eng light. 3rd Incident: May 2024 was driving about 75MPH in the fast lane when the car stalled. I was unable to move fully out of the lane as the car just died. I was half in the shoulder and the fast lane. I was crying with fear while I had to wait for CHP to move me. Multiple times feared other cars would hit me at 80MPH+ while I waited 30mins+ for CHP to stop traffic and move me to the shoulder. Took the car to the dealership for the second time to be "fixed" for the same issue as Nov. 2023. Fuel injector, and catalytic converter were "replaced". This now being the second time for the fuel injector issue. No check eng light. 4th Incident: April 2026 driving on a school night home from dinner with my son at about 9:45pm. It was raining and was traveling at about 55MPH on the highway. Car started to stall/ shut down again. Was able to go about15MPH to a safe spot and w

I PURCHASED THIS 2022 TUCSON LIMITED HYUNDAI NEW. IT HAS 25,000 MILES ON IT. THE CAR CHECK ENGINE LIGHT CAME ON AND A POWER REDUCTION BEGAN ALONG WITH SHAKING OF THE CAR. I WAS ABLE TO CLEAR THE INTERSECTION SAFELY. I WAS ABLE TO TURN INTO A SAFE SPOT AND SHUT DOWN THE CAR. IT WAS TOWED TO THE DEALER WHO THEN INFORMED ME THAT IT WAS AN INJECTOR KNOW ISSUE FOR THIS YEAR AND WOULD BE COVERED UNDER THE 5 YEAR WARRANTY. HOWEVER, AS THIS IS A ENGINE/POWERTRAIN PROBLEM, IT SHOULD BE COVERED ON THE 100,000/TEN YEAR WARRANTY. A TSB (23-FL-002H-1) ALERT HAD ALREADY BEEN ISSUED, BUT NOT A RECALL. MANY OWNERS HAVE REPORTED HAVING THIS PROBLEM REPEATEDLY, AS A SAFETY ISSUE AND A KNOWN MFG DEFECT. WHEN IS THE GOVERNMENT GOING TO STEP UP AND DEMAND A REAL FIX BE DONE BEFORE SOMEONE IS KILLED? OWNER ARE CURRENT LEFT FIGHTING WITH THE DEALERS OVER THE WARRANTY LIMITS OR TAKING LEGAL ACTION. IF YOU GOOGLE THIS PROBLEM, YOU CAN FIND OUT THE NATIONAL LEVEL OF THIS PROBLEM, FROM ACCIDENTS WHICH CAUSED FIRES OR ACCIDENTS FROM POWER LOSS. MY CAR IS STILL AT THE DEALER WAITING ON PARTS. ITS TIME TO FORCE A RECALL! I WILL BE DEMANDING THAT IT IS COVERED FOR THE 10 YEAR WARRANTY PERIOD AND CONSIDERING TAKING ACTION UNDER THE LEMON LAWS. IF THE GOVERNMENT FAILS TO ACT ON THIS SOON, THAN THEY ARE JUST AS LIBEL AS THE MANUFACTURER. YOUR IMMEDIATE ATTENTION TO THIS ISSUES IS REQUESTED.

When braking my 2022 Hyundai Tucson to come to a stop, the vehicle continues to accelerate. I have to release the brake and re-apply the brake to fix the acceleration problem. I check the internet on this problem. They internet says it is a software problem. The vehicle shows no code and the dealer says they don't have a problem. The dealer has not check for the problem since there is no code. No warning lamps or messages show up on dash. This happened 4 times in the last few months. Latest date was 4-4-2026

The car is dead if you do not drive it every 4 days. The battery and system have no power. It has happened multiple times over the past year. Have taken the car to Castle Hyundai of Downers Grove, IL. To date no resolution has been reached wh6 my car looses power. The dealer ran computer checks. Verified the battery had to be reset multiple times. Could not identify any issues with battery or hev system. Contacted Hyundai. Support stated their technical specialist conclusion waste make sure i drive the car for a half hour every other day. That was their "resolution". A car should be able to sit in a garage under normal temperatures for longer than 4 days without the battery system being dead for unknown reasons. The car is unreliable and does not meet safety standards as if they don't know why it's battery system is dead if it sits what to say it won't happen when I am driving down the highway.