2019 Hyundai Tucson

Defect. Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.

Risk. An engine compartment fire can increase the risk of injury or crash.

Remedy. Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, …

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional …

Certain vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is …

Certain Santa Fe (TMA), Santa Fe Sport (AN), Sonata (LFA), and Tucson (TL) vehicles equipped with Theta II engines may exhibit elevated engine-out emissions. This bulletin provides instructions for updating the Engine Control Module (ECM) to address this condition.

Certain Santa Fe (TMA), Santa Fe Sport (AN), Sonata (LFA), and Tucson (TL) vehicles equipped with Theta II engines may exhibit elevated engine-out emissions. The California Air Resources Board has determined that these vehicles may be releasing air pollutants which exceed Federal and California standards.

Following completion of Service Campaign 9C2 (Theta II Emissions Improvement), certain vehicles may exhibit a brief hesitation or rough shifting condition during cold start operation. If present, this condition is expected to occur only within approximately the first 1-3 minutes after engine start, while the catalyst is reaching its normal operating …

Some vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin outlines the combustion chamber cleaning procedure for vehicles diagnosed with this condition. All internal combustion engines consume some engine oil during normal operation, depending on driving conditions and mileage, and this …

Certain vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin provides the inspection and repair procedures for vehicles exhibiting this condition. All internal combustion engines consume engine oil as part of normal engine operation. Oil consumption rates may vary based on mileage, …

Some Tucson (TL) vehicles equipped with a 2.0L engine may exhibit a continued DTC P132600 after an ECM logic update has been performed per TSB 24-01-068H, Engine Monitoring Logic (Service Campaign 966). This bulletin provides instructions to inspect and resolve other engine mechanical issues and if DTC P132600 remains, then a procedure and manual mode …

Following completion of Service Campaign 9C2 (Theta II Emissions Improvement), certain vehicles may exhibit a brief hesitation or rough shifting condition during cold start operation. If present, this condition is expected to occur only within approximately the first 1-3 minutes after engine start, while the catalyst is reaching its normal operating …

Certain 2019 – 2020 model year Santa Fe, 2017 – 2018 model year Santa Fe Sport, 2015 – 2019 model year Sonata, and 2018 – 2021 model year Tucson vehicles may exhibit elevated engine-out emissions. Hyundai is conducting a service campaign to update the Engine Control Module (ECM) Software for vehicles equipped with the (2.4 GDI) Theta II engine to improve …

NHTSA Safety Complaint – 2019 Hyundai Tucson Engine Failure I am reporting a serious engine safety concern involving my 2019 Hyundai Tucson AWD 2.0L (VIN: [XXX]). On XXX, the red engine oil-pressure warning light suddenly illuminated while I was preparing to drive home. Concerned about possible engine failure, I stopped using the vehicle and had it towed to Pohanka Hyundai in [XXX]. On XXX, the dealership provided a diagnostic video indicating that the engine was defective and needed replacement. A written estimate dated XXX quoted $7,823.58 for an engine replacement. Despite this diagnosis, the dealership later declared the vehicle drivable and returned it after adding oil, without providing a satisfactory explanation for reversing its original findings. The engine problems continued, and the vehicle had to be returned to the dealership. This presents a serious potential safety hazard. An unresolved engine or oil-pressure problem could cause sudden engine failure, loss of propulsion, or a breakdown while driving on a highway or in heavy traffic, increasing the risk of a collision and injuries to occupants and other motorists. I am particularly concerned that a vehicle initially diagnosed as needing engine replacement was subsequently declared safe to drive without documented evidence that the underlying problem had been corrected. I request that NHTSA investigate whether this engine failure represents a broader safety defect affecting 2019 Hyundai Tucson vehicles and whether

While driving on the highway 65 mph in our 2019 Hyundai Tucson AWD, the vehicle suddenly experienced a severe power loss, loud engine knocking, engine light flashing, and the car in limp mode. This caused a terrifying hazard. We exited to safety, the car was towed and is at a Hyundai dealership. It pulled a diagnostic engine trouble code P1326 (Knock Sensor Detection System). The dealership confirmed the code, but is refusing to replace the engine under the Hyundai Engine II Class Action Settlement without an out-of-pocket 'combustion cleaning' fee, which, as seniors, we cannot afford on a fixed income. The dealership service manager told us that he requested Goodwill from Hyundai Corporate for the combustion engine cleaning. And because of a past denial, corporate denied it a 2nd time. So, we contacted our Hyundai Corporate case manager, who said our request for “the engine replacement” was still pending and in review by their team. She saw no denials, except for a loaner, which would be approved, upon repair approval. We added the dealership service manager on this call to discuss confusion about goodwill be denied by Corporate for the “combustion cleaning”. He said this case manager would not see the combustion cleaning requirement, because it was instructed by another department. His then pivoted the topic & said we received an estimate for combustion cleaning. My response “we never received an estimate & have no estimate in my email”. His response “I hate to use this wor

While driving at highway speeds, my 2019 Hyundai Tucson SE suddenly loses acceleration and drops into a 30 mph 'limp mode' while the engine overheats. This creates an immediate highway safety hazard with an imminent risk of a rear-end collision. The vehicle also suffers from excessive oil consumption, requiring manual top-offs twice a week. The servicing dealership diagnosed a fuel system failure, quoting $5,847 to replace the fuel pump, fuel injectors, and oil gasket. Hyundai Corporate (Case #43358088) officially denied warranty coverage on October 12, 2026, falsely claiming wear and tear despite active TXXM 150,000-mile extended warranty framework protections. Furthermore, there is a data discrepancy: the dealership pulled diagnostic trouble code P0172, but corporate claims the vehicle threw code P0173 and is withholding the physical diagnostic printout behind a fee paywall.

I have had 2 catalytic converters the original and a 2nd one. Now I need a 3rd due to excessive oil consumption. Corporate did a good will for a combustion cleaning and that did nothing. The dealership checked my oil and said there was excessive oil consumption and submitted for an engine replacement and it was rejected. Absolutely ridiculous.

The new 2019 Hyundai Tucson equipped with the Nu2.0L GDI engine, I purchased in 1/2020 as the original owner to this day has been diagnosed with a burnt exhaust valve due to heavy oil consumption that has been an uncorrected documented manufacturer’s defect within Hyundai motor corporation. The excessive engine oil consumption has poisoned and destroyed the first catalytic converter, has fouled the combustion chamber which has consequently choked and burnt the exhaust valve with the excess oil ash and carbon buildup. The car was approved for a second catalytic converter install last week which my car currently sits at 125,000 miles and the dealership through the authority of approval with Hyundai motor America has replaced under warranty however subsequently running the excess consumption test, the car now has a burnt exhaust valve which Hyundai motor America is extending a “good faith” proposal which they are willing to replace 60% of the burnt valve and I’m responsible for the 40% even though I have complied fully with the dealership’s recommended preventive maintenance schedule which has been solely performed at the same dealership since the day I bought the car and drove off the lot up until the 100K mile warranty. And now discovering my particular motor has been extended to the 15/150,000 warranty due to the lawsuit settlement. I have continued with my diligence with keeping up with the oil, instead of ignoring the issue that the car burns excessive oil to potentially ha

The contact owns a 2019 Hyundai Tucson. The contact stated that while driving 50 MPH, there was a burning odor coming from the vents, with the battery warning light illuminated. The vehicle was taken to the service center, where it was diagnosed with alternator failure. The contact was informed that the alternator needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the alternator had been replaced three times with aftermarket parts and a fourth time with an OEM part. After inspecting the alternators, the contact noticed that the copper wires inside each alternator were black due to the failure. The contact was concerned that a previous recall associated with the failure did not properly fix the vehicle. The manufacturer was made aware of the failure by telephone, and a case was opened. The contact also requested a buyback of the vehicle. The failure mileage was approximately 61,000.

The contact owns a 2019 Hyundai Tucson. The contact stated that while driving 40 MPH, the vehicle lost motive power. A Forward Collision Avoidance message was displayed. The vehicle was able to restart. The vehicle was taken to the dealer, where the contact was informed that the failure could not be duplicated. The failure mileage was approximately 135,700.

I had bought my car in May of 2025 and within 12 hours of owning it. The check engine light came on. They replaced the sensor well. A couple days later, the check engine light came on again, and they had to rebuild my whole engine had the car for a month at this time. When they rebuilt the engine, they had the car for over a month. And ever since I got it back, it's always something the same thing has to get repaired. Well, I took it to the shop. Yesterday because it was misfiring, and I needed to have some spark plugs replaced, and they said that the Ignition coil needed to be replaced, but there was a recall on that not too long ago. And they fixed that on the recall. There's no reason that should have already went a few months later. Well, the problem is when I bought my car, I bought it from tar. Hyundai, it's now rusty, while it's Hyundai. They charged me $200 just to get my car out of their lot. Because I refused service because they were trying to charge me. $2500 to fix my car. Now mind you, I've already put over $4000 extra into this car. After purchasing it for over 21000 now they're not wanting to honor any work that Tara. Hyundai done because they don't be responsible. They don't want to honor the tar. Hyundai warranty or anything I've had it with this Hyundai company. I've been driving this lemon. It is yet again in the shop. Being fixed, although the engine was rebuilt a year ago, there is no reason. This car should keep having engine failure. They don't want to

My 2019 Hyundai Tucson repeatedly shuts off while driving , without any warning. It rolls backwards while in park. The car could easily hit me taking things out of the trunk or hit my neighbors walking past my drive. The car has no power. It can’t get up to speed. It shakes and I have to get someone to add oil to it frequently. The first time this happened was in April of 2023. The engine seized up and it was towed to Driver’s Village in Cicero, NY. They replaced the engine block. But not the converter. Now, it is happening again. I have had 2 diagnostic tests done. One by my mechanic and the other by Advanced Auto Parts. Both tests say that the problem is the catalytic converter, but Hyundai refuses to fix the problem and will not honor my extended warranty. I have written and called them numerous times for almost 2 years now, about this and they say they will call me back, but they do not. None of the dealerships will even look at my car. I need someone to look at my vehicle. This vehicle is not safe. Other Tucson owners have the same problems with their cars, that I am complaining about. There is a federal emissions warranty that Hyundai claim they have never heard of, that would fix my car and make it safe to drive. I just want Hyundai to stand behind their warranty and fix my car before it kills someone.

While traveling northbound on [XXX] in Florida traffic came to a stop, and when I stopped, my engine seized, I attempted to restart, but was unable to get a restart. My attempts to restart caused the starter to start burning smoke was coming from under the hood this put me at serious risk being on an interstate highway in the left lane at [XXX]. It was very difficult for me to push the car to the side of the road in this dangerous situation, recalling how Harry Chapin died in New York, because his car failed, and was struck by another vehicle. I was able to get the car onto the shoulder away from the moving traffic. The engine that seized is a 2.0 GDI engine and that engine has been identified to have multiple failures and being replaced after failing . Hyundai sent a letter. I believe this engine should be recalled and replaced before others are put in the same dangerous situation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Hyundai Tucson. The contact stated that while the vehicle was parked in the driveway and turned off, the vehicle rolled backwards and occasionally ended up in the street in front of the residence. The contact stated that while driving 55 MPH, the vehicle stalled in the middle of traffic and other vehicles to go around the vehicle. The vehicle was restarted and was pulled over to the side of the road and the vehicle stalled. The vehicle was towed to a dealer where it was diagnosed and determined that the engine block needed to be replaced. The contact stated that there was ice built up underneath the tires, and an unknown ring was replaced. The vehicle was repaired, but the vehicle reversed inadvertently while parked and stalled while driving at various speeds, and the vehicle failed to accelerate as intended, and the vehicle was shaking abnormally on several occasions. The vehicle was taken to the same dealer but was not diagnosed; however, the contact was notified that the failure might be associated with the catalytic converter. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.

OnXXX my car experienced sudden knocking in the engine. I pulled over to the service station on the [XXX] and had my car towed to Empire Hyundai in [XXX]. I had just changed oil on XXXand upon inspection oil level was fine. Problem is the theta 2 engine and though the car is under extended warranty Hyundai is requesting maintenance records before repairing this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ABS light on dash is illuminated due to no known cause. Mechanic explained that the ABS system will not work when the light is illuminated which, I believe, contributed to a "fender bender" my vehicle was involved in due to the ABS system failure.

When the vehicle in front of me stopped quickly, I braked quickly but did not hit the car. At that time, all the lights on my dashboard went off and were still on when I took the car to dealer for a diagnosis.

The contact owns a 2019 Hyundai Tucson. The contact stated that while driving approximately 30 MPH and depressing the brake pedal, the vehicle responded as intended; however, several unknown warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the ABS had failed and needed to be replaced. The vehicle was repaired at the owner's expense. The contact became aware that notification for NHTSA Campaign Number: 20V543000 (Service Brakes, Hydraulic); was previously received; however, the VIN was no longer included in the recall. The contact was unsure if the recall repair was performed. The contact requested a reimbursement from the dealer, but the request was denied. The manufacturer was not notified of the failure. The failure mileage was approximately 56,000.

I have noticed that the engine oil level in my vehicle drops significantly between regular oil changes. Despite adhering to the manufacturer's recommended maintenance schedule, I frequently have to add a quart of oil after driving only about [800~1,000 마일] miles.I understand that this is a widely reported issue with Hyundai Owners Forum affecting 2019 models. Many experts and fellow owners have identified that this rapid oil loss is often caused by manufacturing defects, such as faulty piston rings, which can eventually lead to catastrophic engine failure.As a Hyundai owner, I am highly concerned about the safety, reliability, and decreased resale value of my vehicle. Running low on oil without warning creates a high risk of sudden engine breakdown while driving on the highway.I kindly request that Hyundai Corporate or my local authorized dealer investigate and resolve this matter. Specifically, I am asking for:An official engine inspection and a proper Oil Consumption Test.Necessary repairs or a full engine replacement under the applicable powertrain warranty at no cost to me.

The 2019 Tucson has 60,413 miles. My daughter drives it very low mileage - a couple of miles a day back and forth to school. Friday she was driving and the car lost engine power and it stopped driving. No warning lights. There was a cloud of smoke and it smelled like burning plastic. She was on a busy road but pulled over and quickly exited the vehicle. I had it towed and the mechanic says the engine oil was empty and the engine has seized. We do regularly scheduled oil changes. No lights or warnings and the car just stopped in traffic.

While driving, the check engine light began flashing and the vehicle shook severely due to engine misfiring. The vehicle has had a recurring cylinder 3 misfire throughout ownership. Spark plugs and ignition coils were first replaced around 40,000 miles and replaced again in December 2025 for the same recurring issue. A Hyundai dealership inspected the vehicle and found codes P0300 random misfire and P0303 cylinder 3 misfire. The dealership technician documented that the piston rings did not look good and confirmed the catalytic converter was damaged as a result of the misfires. The vehicle has had an engine rattle at idle, oil consumption, and blow-by since early in ownership. The engine defect is progressive and predates the current mileage. The flashing check engine light and severe shaking while driving at highway speeds created an unsafe condition with other vehicles on the road. The problem has been confirmed by a Hyundai dealership. Hyundai Motor America was contacted and denied goodwill warranty assistance. The vehicle is available for inspection upon request.

The vehicle will not get to highway speed causing it to impede traffic and presenting a safety risk for collision.

The contact owns a 2019 Hyundai Tucson. The contact stated while the contact's husband was driving, the contact noticed an abnormal loud sound. In addition, the contact noticed smoke coming from the front of the vehicle. No warning lights were illuminated. The contact noticed an unusual odor in the interior of the vehicle. The contact's husband drove the vehicle to the shoulder of the road. The contact stated that the engine seized. In addition, the contact stated that the smoke and the unusual odor subsided. The vehicle was towed to the contact's residence. In addition, the contact stated that when the failure occurred, the contact's minor children were occupants of the vehicle. The contact stated that the minor children were frightened. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The contact was informed of an open recall associated with the contact's VIN, NHTSA Campaign Number: 20V543000 (Service Brakes, Hydraulic). In addition, the contact was informed that her contact information was not updated in the database. The failure mileage was approximately 49,400.

The contact owns a 2019 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the contact noticed an abnormal sound and the engine seized. The check engine warning light illuminated. The contact stated that while attempting to start the vehicle, the vehicle started. The failure reoccurred. The contact stated while attempting to start the vehicle, the vehicle started and the engine spuddered. The vehicle was towed to an independent mechanic where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was towed to the dealer where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to take the vehicle to the dealer for diagnostic testing. The contact was later informed that the repair was not covered under the recall because of open recalls associated with the contact's VIN. The failure mileage was approximately 81,000.

I purchased this vehicle from CarMax about 5 months ago. It had 74,XXX miles. CarMax showed no open recalls and a printed sheet from your site showing the same. Several weeks ago, while driving, the engine seized. I sent it to one of the local Hyundai dealers for repair. Hyundai said because recall Campaign #966 had not been performed, they would not replace the engine under the extended warranty. When I purchased the vehicle, I had the foresight to purchase an extended warranty from Assurant. Eventually I found they will cover the repair. I have to pay the $600 deductible, plus a $350 labor charge for diagnostic work. Here is my problem, CarMax told me there was no open recalls (based on your web site), and I counted on CarMax having an accurate knowledge about this when I purchased the vehicle. This is particularly disturbing because in 2022 CarMax settled out of court with 30+ states in part, for failure to disclose open recalls on vehicles they sold. True, I could have checked myself, but how did your entity report no open recalls on this VIN, and CarMax reported no open recalls on this VIN, but Hyundai was aware of the open recalls, and denied an engine warranty repair because the recall campaign had not been completed? There are two other open campaigns, # 933 and #P33 as well. The Hyundai dealer is going to perform these recalls after the repair. To summarize, I purchased this vehicle in good faith that the information provided on the NHTSA sheet, and the CarMax sheet

On March 21st, while driving my Hyundai vehicle, I noticed the vehicle began making a ticking sound. After stopping the vehicle, it slowly began catching on fire. The fire ultimately spread and resulted in the vehicle becoming a total loss. This created a serious safety concern and placed me at risk. I later learned there was a recall associated with the vehicle. However, I never received any recall notices because Hyundai reportedly had the wrong address on file. Had I been properly notified of the recall and potential safety risks, I would have done everything in my power to ensure the vehicle was inspected, repaired, and safe to drive. Because I was unaware of the recall issue, the vehicle continued to be operated without my knowledge of the potential danger. The incident caused significant financial and transportation hardship, including loss of reliable transportation and additional financial strain. Hyundai later reached a determination regarding the matter, but I remain concerned about the serious safety risk and the fact that I did not receive proper recall notification before the incident occurred. I am submitting this complaint because I believe the recall notification process and handling of this matter should be reviewed further due to the serious safety risk involved.

The contact owns a 2019 Hyundai Tucson. The contact stated while parked and occupied in the vehicle, attempting to close the drive side door, and he heard a raddling noise coming from the front of the vehicle and his wife existed the vehicle and noticed the noise was coming from the windshield. The contact mention his wife also noticed mold and water near the drive side part of the windshield. The vehicle was taken to the dealer or an independent mechanic for diagnoses. The vehicle was not repaired. The manufacturer was notified of the failure, and they informed him we no recall they could not provide assistance. The failure mileage was 88,686.

2019 Hyundai Tucson experienced catastrophic engine failure, including internal damage. Vehicle previously had Hyundai Campaign 966 (engine monitoring logic) completed. Despite this, engine failed without sufficient warning. Concern that prior campaign did not prevent engine failure

Oil consumption is at an all time high. At last oil change I had Milage 71847 on 3/8/26. I checked my oil on 4/26/26 with 73182 miles, oil was at the add mark on the dipstick which means 2 quarts was gone from my engine at about 1500 miles put on my car since the oil change. Upon reading up on this issue, it is a wide spread issue with several Hyundai models. I bought it used at a car dealship when it was only a year old, so the warranty is only for the original owner. I still owe $3400.00 on this car and I am afraid the engine will go before it is paid off.

The vehicle has had two catalytic converters replaced in 70,000 miles

The contact owns a 2019 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stalled and was idling roughly. The message “Stop Driving” was displayed. The contact stated that the vehicle failed to accelerate and lost automotive power. The failure had occurred several times. On one occasion, the vehicle had to be towed. The vehicle was able to restart after several failures. The vehicle was taken to the dealer, where it was diagnosed with engine failure due to excessive oil consumption. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 59,000.

The component involved is the engine and associated knock detection system (KSDS). The system triggered a P1326 code indicating abnormal engine knock associated with a known defect condition. On February 14, 2023, while driving on the freeway, the vehicle suddenly entered reduced power (“limp mode”) and lost acceleration capability in active traffic. This created a safety risk, as the vehicle was unable to maintain speed with surrounding traffic or accelerate as needed for normal driving conditions. There were no sufficient warnings prior to the event to allow safe planning or avoidance of the loss of power condition. The system activation itself (P1326 and limp mode) was the first indication of the severity of the issue. The problem has been reproduced multiple times, with repeated P1326 events occurring after the initial incident. The condition has been inspected and partially confirmed by a Hyundai dealership. In March 2026, dealership records documented that oil contamination was causing catalytic converter failure, indicating ongoing engine-related deterioration consistent with the defect condition identified by the knock detection system. Despite these findings, the underlying engine condition has not been resolved. The KSDS system is designed to detect a potentially serious engine defect and limit engine power to prevent further damage. However, it does not correct the underlying defect. As a result, the vehicle may continue to operate with a known compromised conditio

While driving at highway speed, the engine suffered a sudden connecting rod bearing failure (Cylinder 3) with no prior warning lamps, messages, or symptoms. The vehicle made a slapping noise, a belt came off, the engine died, and would not restart. The vehicle was towed to an authorized Hyundai dealership. The driver, a [XXX] [XXX] , was able to safely guide the vehicle to a stop without injury. The dealership inspected the engine and confirmed a complete Cylinder 3 connecting rod bearing failure. The technician contacted Hyundai Techline, who confirmed the diagnosis and recommended engine replacement. The estimated repair cost is $6,500. The failed engine is available for inspection at the dealership. This vehicle is a 2019 Tucson with the Nu 2.0L GDI engine, which is covered under the E2 Class Action Settlement for connecting rod bearing defects. Hyundai Service Campaign 966 provides a KSDS software update designed to detect abnormal bearing noise before catastrophic failure occurs. This update was never performed on the vehicle. The 2019 Tucson was not added to Campaign 966 until April 2022, after the vehicle had already been purchased used. The owner was never effectively notified of the campaign and the vehicle was never at a Hyundai dealership where the update could have been performed. Hyundai denied warranty coverage solely because Campaign 966 was not completed, despite confirming the failure is the exact defect type the campaign and settlement were designed to addre

While driving a flashing engine light came on in my 2019 Hyundai Tucson. This made the car slow down and have no power. I brought the car to the nearest mechanic, they told me it was the knock sensor and told me it was a recall for this car, I should bring it back to the dealership. I called the dealership and they had told me to bring the car in. They inspected the car on 8/30/24 at 44,990 miles and told me it was the knock sensor and replaced it. On 11/4/24 at 46,246 miles the car was brought back in for the same issue and the car was inspected again, it was the knock sensor. This time the software was replaced. On 1/29/25 at 48,042 while driving on a highway going 70 mph the flashing light comes on again, brought it back to the dealership and I was given a loaner. The reached out to me and told me it was the knock sensor. They had the car for about 5 days. On 2/14/25 at 48,248 again, driving on a highway the flashing engine light appears again. Called the dealership and brought in the car and again, the knock sensor. On 12/31/25 at 56,712, driving on the highway, the flashing light appears again...On 1/2/26 the car goes back to the dealership, they call me and said that it's the strangest thing, the serpentine belt is worn, and it was making a banging sound which was setting off the knock sensor. At this point they offered to put in a new serpentine belt. I refused because after 5 failed attempts, I decided to bring it to my mechanic (I had lost all confidence with Hyundai

The contact owns a 2019 Hyundai Tucson. The contact stated that upon entering the vehicle, there was water overflowing from the front passenger's side floormat. The vehicle was taken to the dealer, but the water entry point could not be determined. Additionally, the contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer, where a brake sensor was replaced; however, the failure recurred. The vehicle was taken back to the dealer, where another brake sensor was replaced; however, the failure persisted. The vehicle was taken to the dealer, who diagnosed that the wiring harness had sustained water damage and corrosion due to a clogged sunroof drain. The dealer determined that the wiring harness needed to be replaced. The vehicle was not repaired due to the cost. The contact stated that the repair should be covered by the manufacturer because the failure was a factory defect. The manufacturer was not contacted. The failure mileage was approximately 30,000.

The engine consumes oil and requires catalytic converter replacement every year at inspection. The engine has been maintained with regular oil and filter changes and the oil is continuously needing to be topped off between changes. I have owned the vehicle for 5 years and have replaced the catalytic converter 3 times. The first time I had it replaced it was still under warranty and it was replaced by the dealership. The technician stated that it was a known issue with these vehicles. It was about six months before the check engine light was on again and showing the same code and problem. Every year I am replacing the catalytic converter to pass inspection. I have taken it to different locations every year to try to find a solution to this and they all say the engines are burning too much oil and causing catalytic converter failure.

Catalytic converter and oil leak which is causing the vehicle to lose power. The catalytic converter was replaced in 2024 and now is bad again in 2025. Oil consumption has been a problem since 2024. Hyuandi is refusing to repair the vehicle. Despite the engine making a knocking noise and the check engine light is flashing the vehicle is still under the 150,000 power train warranty

Oil extremely hot and burnt to oil stick. Running really hot. Dangerous possible fire hazard

Low oil, burnt oil on dip stick, engine running dangerous hot, lights on on dash, engine knocking

The vehicle has consumed the oil and no light came on. I drove and i checked when the running engine start doing a dry noise and loose the power. The stick was completely dry, i filled with 2 litters and now the stick show in the half. My vehicle has 60k miles and tomorrow will check on the servis. It is unacceptable first how the vehicle consumed the oil and the second the system didn't notify risking an overheat and posing an elevated risk to spop in the middle of the road causing an accident or starting a fire due to overheat.

My windshield wipers quit working in the middle of a snow storm. I’ve seen there’s a re all on some 2019 Hyundai Tucson’s for the wiper motor. Wondering why mine isn’t included.

On three occasions while the vehicle was idling, the dashboard screens and interior lights went completely black, and the steering wheel jerked abruptly in my hands. This sudden electrical failure creates a serious safety concern, particularly if it were to occur while driving at higher speeds. The dealer has not been able to reproduce the problem. There were no warning lamps, messages or other symptoms prior to the failure. There were no warning lamps after the problem occurred. The vehicle has been inspected multiple times by a Hyundai dealership. On one occasion, the dealership retained the vehicle for approximately two months but reported no definitive findings despite error codes being present. On a later visit following another failure, no error codes were recorded. The dealership replaced the head/stereo unit and confirmed no active recalls, yet the issue continues. This problem first occurred while the vehicle was covered under an extended warranty, but due to its intermittent nature, it was not resolved before the warranty mileage threshold was exceeded. I have since found numerous similar complaints online from owners of the same model year describing electrical blackouts and steering-related concerns. A Hyundai service manager advised me to dispose of the vehicle, which further reinforces my concern that the defect may be known but unresolved. I believe this issue represents a potential safety defect and warrants documentation and review. Thank you for your attenti

My 2019 Hyundai Tuscan has been burning oil and the oil has to be topped off every 1,000 miles or so. There are multiple check engine lights illuminated: abs, front collision, traction. These lights have flashed off and on for 3 years but are not light up solid. This sounds like an issue.

Limp mode, knocking , engine light. Only has 62,768 miles on it. I can't fill out campaign 966 or 982 on the official web site for extended coverage.

Purchased this car used 3 years ago. Followed owner's manual for oil and filter changes. On 1/2/26 the engine seized, had it towed to Hyundai dealership and they will not approve a replacement for the engine because they said I hadn't followed maintenance guidelines. I submitted all receipts and they still are denying. I had the KSDS and all Hyundai campaigns addressed which was to extend the warranty and they still deny. NO WARNING LIGHTS whatsoever came on until the engine seized on the parkway. Hyundai knows there is an issue with these engines but still won't step up.

Car is burning oil quickly. Had 2 oil changes within 3 months. Way before it was needed. No oil leaks detected. Oil gets dark fast and is burning off quickly. Take to Pep Boyz and other repair shops. Not yet taken to dealership.

Hello, my 2019 Hyundai Tuscan I have owned for 3 years-4 years. Unfortunately it is a GDI Motor, it uses oil so bad, even though I do change the oil every 3,000 miles, and do every maintenance on the vehicle that is told to me done, ever time I change the oil it is low, even though I top it off through out the 3,000 miles. I have no leaks at all and it is just evaporating, I do not think this is right for a 2019… there is several issues and concerns from other buyers with this issue. There should be a fix to this, asap

My 2019 Hyundai Tucson previously required an engine replacement due to a known defect. After the engine replacement, the check engine light remained on. Recently, the check engine light began flashing, and the vehicle was towed to the dealership. I was informed the vehicle has a radiator/cooling system failure. Given the history of engine defects and warning lights, I am concerned about vehicle safety and reliability.

I am submitting this complaint regarding excessive and abnormal oil consumption in my 2019 Hyundai Tucson. Despite regular maintenance and oil changes performed according to manufacturer recommendations, my vehicle consumes oil at an excessive rate, requiring frequent oil top-offs between oil change intervals. I have experienced low oil levels with little to no warning, which poses a serious safety concern due to the risk of engine failure while driving. The vehicle does not show visible oil leaks, suggesting internal oil consumption. This issue appears to be consistent with numerous consumer complaints involving Hyundai vehicles of similar model years and engines. The dealerships have been unhelpful and dismissive, often stating that the oil consumption is “within normal limits” or requiring lengthy oil consumption tests without offering a permanent solution. I feel I am being given the runaround rather than receiving a meaningful repair or accountability for what appears to be a known defect. Excessive oil consumption can lead to engine damage, stalling, or sudden engine failure, which is a significant safety hazard for myself, passengers, and other drivers. Hyundai dealerships have failed to adequately address or correct the issue, despite the widespread nature of similar complaints and known engine issues associated with Hyundai vehicles. I am requesting that NHTSA investigate this matter further, as this defect affects vehicle safety and reliability and appears to be par

Oil component failure causing extreme heating within the engine and catalytic converter which poses risk for engine fire. This oil consumption issue was addressed by the dealership who ran a test to see how much oil was consumed. The test results showed that the vehicle was burning oil at a high rate and would ultimately result in engine failure. The low-oil light has never come on indicating a need for an oil change. Despite this, I have constantly pulled my own dip stick and got changes every 2,000 miles. For this make and model, they required a change every 5,000 miles. When I notified Hyundai Corporate over this concern. They claimed due to it being outside of warranty, that it does not matter what my engine light has been doing since I got the car, nor the issue with the oil consumption, they refuse to address any of these problems as being a manufacturing problem. The maintenence has been kept up since I got the car, so the manufacturer is not acknowledging the constant issue with Hyundai Tuscon engine dangers. If a fire were to occurr, I was told this is not Hyundai's responsibility due to me not being the first owner and it not falling within warranty. After the combustion test, Hyundai claimed that they refilled my oil. When I checked my dip stick after only driving 100 miles, the image attached will show the resulting levels. My oil light is still not coming on despite this. Even when it has been much lower than the pictured level. This, paired with the super heated

My 2019 Hyundai Tucson, VIN [XXX] , has developed engine knocking, which may indicate internal engine failure. A mechanic has suggested a possible loss of cylinder compression, though the exact cause has not been confirmed. Hyundai vehicles from similar model years have experienced engine failures related to bearing wear and metal debris, leading to stalling, loss of power, and complete engine failure. These failures present a serious safety risk, particularly if the engine fails while driving. I am concerned that this defect could result in sudden loss of power or engine seizure, increasing the risk of an accident. I am submitting this complaint to ensure the issue is properly investigated and addressed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2019 Hyundai Tucson, VIN [XXX] , has developed engine knocking, which may indicate internal engine failure. A mechanic has suggested a possible loss of cylinder compression, though the exact cause has not been confirmed. Hyundai vehicles from similar model years have experienced engine failures related to bearing wear and metal debris, leading to stalling, loss of power, and complete engine failure. These failures present a serious safety risk, particularly if the engine fails while driving. I am concerned that this defect could result in sudden loss of power or engine seizure, increasing the risk of an accident. I am submitting this complaint to ensure the issue is properly investigated and addressed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact's daughter owns a 2019 Hyundai Tucson. The contact stated that his daughter had parked the vehicle and left it unattended while in the on position. After approximately 10-15 minutes, the daughter attempted to shut off the vehicle by turning the ignition key from the front passenger side, but after powering off the vehicle rolled backwards down the driveway, also dragging the daughter. While rolling backwards, the front passenger door hit the concrete mail box, and the vehicle continued to roll across the street before stopping in the neighbor's yard. During the incident, the daughter attempted to activate the emergency brake, but was unsuccessful. As a result, the daughter sustained several bruises to the right leg/knee and the back area, which did not require medical treatment. The passenger side door and the concrete mail box were damaged. The police were called to the scene, but no report was filed. The cause of the failure was not determined. The manufacturer and local dealer were not yet notified of the incident. The failure mileage was unknown.