2019 Hyundai Santa FE

Above average

Owners filed 203 complaints about this vehicle with federal regulators, most often about the engine. It has been recalled 2 times.

Avoid One of the Hyundai Santa FE years to avoid: an unusual share of fires, crashes and deaths for a car of its age. Which Hyundai Santa FE years to avoid →

When it fails
020k40k60k90k120k200k
10,000 milesMedian miles at failure

65 complaints record an odometer reading. Failures cluster around 0–10,000 miles.

Most common 2019 Hyundai Santa FE problems

62 of the 203 complaints (31%) are about the engine.

ComponentReportsCrashesFiresInjuries
Engine62
060
Unknown or Other33
532
Power Train · transmission18
101
Electrical System18
020
Structure › Body · body and frame14
000
Steering9
000
Service Brakes · brakes9
211
Air Bags · airbags7
505
Visibility/Wiper · wipers4
000
Vehicle Speed Control · throttle and acceleration4
300

2 safety recalls

Part 573 reports
Trailer Hitches23V181000Park outside
Filed Mar 17, 2023584,784 vehiclesHyundai Motor America

Defect. Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk. A fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.

Air Bags › Side/Window18V715000
Filed Oct 11, 20188,204 vehiclesHyundai Motor America

Defect. Hyundai Motor America (Hyundai) is recalling certain 2019 Hyundai Santa Fe vehicles. The Side Curtain Air Bag (SCAB) mounting bolts may interfere with and damage the air bags during deployment.

Risk. In the event of a crash, if the air bags become damaged during deployment they may not inflate properly, increasing the risk of injury.

Remedy. Hyundai will notify owners, and dealers will install a protective cover over the SCAB installation bolts, free of charge. The recall began December 3, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 177.

All 2 campaigns on file, newest first.

What owners reported

Newest filings
Power Train
Filed Oct 17, 2026AZ

After Hyundai 9C2 update the transmission bucks or searches for gear causing what seems to be up and down shifting.

Power Train
Filed Oct 5, 2026MT

Driving at highway speed, vehicle stuttered/lurched. The check AWD, engine light, tire pressure warning lights came on. Check by mechanic resulted in error code P0741 (Torque Converter Clutch Circuit Performance or Stuck Off). Search of error code P0741 indicates that there is a Technical Service Bulletin TSB-23-AT-005H regarding this KNOWN problem. A stutter or lurch of the vehicle can cause the driver to over react, stop or swerve suddenly in traffic potentially causing an accident not to mention possible being struck on the side of the road while waiting for a tow/service truck. Vehicle/components have not been checked by manufacturer--only diagnostic code by Mechanic. Warning lights after incident included the AWD system, Check Engine Light, and Tire Pressure sensor light. Vehicle is being towed to a Hyundai Dealership as Mechanic advised it is not safe to drive.

Electrical SystemFire
Filed Oct 2, 2026NJ

On August 14 2026, I drove my 2019 Hyundai Santa Fe approximately one mile from my residence to work at approximately 5:00 AM. The vehicle was operating normally and I experienced no warning lights, unusual noises, odors, smoke, or other indications of a problem. I parked the vehicle in an outdoor parking lot and the vehicle remained parked and turned off for approximately four hours. At approximately 9am, I was notified that my vehicle was smoking. A person who was walking past the vehicle observed the smoke, obtained a fire extinguisher, and extinguished the fire. The fire department subsequently responded, disconnected the vehicle battery, and opened the rear of the vehicle to ventilate it. The fire and resulting heat damage were concentrated on the driver's side rear of the vehicle, directly behind the driver's-side rear tire and in the area of the rear bumper. The plastic at the base of the bumper melted, and melted bumper material was observed dripping onto the ground. The responding fire marshal inspected the vehicle and indicated that the electrical box located in this area may be associated with the origin of the fire. Wiring from this area runs to a non-original/non-Hyundai-installed trailer/tow attachment. The exact cause and origin of the fire have not yet been conclusively determined. The vehicle had otherwise operated normally during my ownership, with little to no significant problems prior to this incident. The vehicle is currently being preserved for inspecti

Engine
Filed Sep 23, 2026TX

On 03/26/2026, my 2019 Hyundai Santa Fe received Hyundai Service Campaign 9C2 (TSB 26-01-013H-1), which included an Engine Control Module (ECM) software update for Theta II emissions improvement. The vehicle did not have the following drivability problem before this software update. Immediately after the 9C2 update, the vehicle began jerking/bucking slightly at low speeds, most noticeably around 10-20 mph when coasting with no accelerator input or when applying very light throttle. Acceleration response also feels slower than before the update, with noticeable hesitation when the accelerator is pressed. The problem is most noticeable during the beginning of a drive when the vehicle is cold. After driving for some time and the vehicle warms up, the symptoms improve, although the change in drivability remains noticeable compared with operation before the update. There have been no warning lights or warning messages associated with the problem. The issue began immediately following the ECM software update. The vehicle has not yet been returned to the dealer for diagnosis or confirmation and is available for inspection. I am concerned about the safety implications of delayed or unpredictable acceleration response, particularly when entering traffic, crossing an intersection, or merging when timely acceleration may be necessary. I am reporting this because the condition began only after Hyundai Service Campaign 9C2 was performed and I believe NHTSA should evaluate whether this ECM

Engine
Filed Sep 21, 2026HI

The vehicle experienced a sudden, intermittent engine stall while driving, specifically when slowing down or coasting to a stop in live traffic. When the engine dies, the vehicle immediately loses engine power, power steering, and power braking assist, creating an extreme safety hazard. After stalling, the vehicle refuses to restart for several minutes. An authorized Hyundai dealership previously replaced the high-pressure fuel pump under warranty to address this issue, but the dangerous stalling has persisted over the last 2,000 miles. The vehicle continues to randomly shut off without throwing a permanent check engine light or diagnostic trouble code, and the manufacturer has failed to correct this critical safety defect.

Engine
Filed Sep 17, 2026CA

The car started having problems immediately after replacement with a new battery. The issue with the ISG (Idle Stop and GO System) started appearing. When the Auto Stop Indicator turns green, the car stalls which puts my life at risk. I have spoken to a number of mechanics and I am not getting a satisfactory answer on how to fix this problem.. One mechanic told me it was the starter which turned out not to be true. I have also spoken with a number of other mechanics and they are clueless on how this problem can be remedied. And the Hyundai dealter wanted $275 just to look at it but with no guarentee. The whole issue is putting my life and other motorists at risk.

EngineFire
Filed Sep 11, 2026PA

2019 Santa Fe with 80,000 miles showed signs of excessive oil consumption. Service was scheduled with licensed Hyundai franchise service center. Known oil consumption issues on Theta II engines for that year. Testing requires 3 steps. First step is to change the oil and document levels. Engine is tested for 1000 miles then returned to service center. After 1000 miles, service center reports 2.5 qts of oil per 1000 miles. Hyundai corporate was contacted where they approved warranty work for the vehicle. Step two requires Combustion Chamber Cleaning. During this portion of the work, service center calls about fire that took place immediately after a test drive. Dealership states engine and components destroyed.

Fuel/Propulsion System
Filed Sep 7, 2026NY

My vehicle had a very strong gas smell inside and outside of the car. I found a gas puddle under the car coming from the back of the vehicle. Car was hesitating when I stepped on the gas. I was afraid it may stall. I drove the vehicle to my regular service station. Vehicle has an active fuel leak and this is a fire hazard. I was very concerned whether the vehicle would stall and cause an accident. Warranty coverage was denied.

Engine
Filed Sep 2, 2026VA

Update Re: ODI Complaint Number: 11759237 Subsequent Actions and Manufacturer Refusal to Remediate Safety Defect: ​Following the [XXX], acute safety incident—where the vehicle lost motive power and entered severe limp mode on [XXX] immediately upon release from Sheehy Hyundai of Chantilly—the vehicle remained in dealer custody for 11 days (August 20–August 31, 2026). ​Failure to Diagnose Core Defect: Despite recurring total power loss, active diagnostic trouble code P00AF00 (Turbocharger Boost Control Module Performance), and four consecutive turbocharger destructions within 20,000 miles, the authorized dealership refused to conduct internal engine diagnostics, drop the oil pan, inspect the oil filter, or perform borescope checks. ​Physical Contamination Documented: On August 29, 2026, an on-site physical inspection confirmed sparkling metallic particulate suspended in the engine oil on the dipstick and substantial oil blow-by/intrusion into the turbocharger air intake line. ​Formal Denial of Safety/Warranty Coverage: On August 31, 2026, dealership management and Hyundai Motor America (Consumer Affairs Case #[XXX]) formally denied warranty assistance and refused engine teardown under the Theta II Lifetime Engine Warranty Settlement. Coverage was declined citing "outside influence" due to an aftermarket turbocharger assembly, while Hyundai refused to investigate the underlying engine failure contaminating and destroying the forced-induction system. ​Evidence Preservation: On A

Fuel/Propulsion System
Filed Aug 28, 2026WI

My vehicle recently received the Hyundai 9c2 emissions upgrade they required and since then the vehicle has had predictable acceleration issues for the first several minutes after the vehicle. While trying to slowly accelerate the vehicle with unpredictably lurch forward. Many people have been reporting this.

Power Train
Filed Aug 24, 2026VA

The vehicle suffers from recurring, sudden loss of motive power and transitions into engine "limp mode" while driving in active, heavy traffic. This severe drivability defect has occurred on four separate occasions under Diagnostic Trouble Code (DTC) P00AF00 (Turbocharger/Supercharger Boost Control "A" Module Performance) and related boost/MAP faults (P0234). During these episodes, the vehicle abruptly loses acceleration capability without warning, creating an acute collision risk when navigating highway traffic and intersections. The turbocharger assembly has required replacement three separate times due to recurring oil contamination from the engine crankcase. Despite meticulous maintenance (documented synthetic oil changes every 3,000–5,000 miles since new), the manufacturer and dealership have repeatedly blamed peripheral turbo components rather than diagnosing or repairing the root cause (I suspect excessive engine crankcase pressure/piston ring blow-by based on the significant oil deposition on the turbo, map sensor, and pooling in the intake line).

Power Train
Filed Jul 22, 2026NY

Transmission was replaced under warranty by Hyundai in Nov 2024. Engine was replaced at 100600 miles in Nov 2025. Issues with the transmission were happening at that time but ignored by dealership as issues related to failing engine. Our mechanic confirmed in April that transmission was failing and told us to go to Hyundai. We went to dealer in April 2026. They confirmed transmission needed to be replaced. They were going to contact Hyundai USA. We received no updates despite many calls to the dealer. We had to call Hyundai USA directly. They opened a case. Dealer finally called and took car in and requested good faith repair by Hyundai USA. Hyundai USA responded 2 weeks later and is not covering anything. They replaced our transmission in Nov 2024 with a refurbished transmission that they NO LONGER MAKE. Clearly due to the fact that the refurbished part doesn’t work. They now want me to pay $8000 to repair transmission. My car has been maintained on schedule by my mechanic. All paperwork available. I have had Toyotas, Hondas and chevys that have lasted close to 20 years. This has been a horribly disappointing experience. And I now need to buy a new car for my 17 year old instead of handing down. I will NEVER buy another Hyundai. I want everyone to be aware of my experience. Disgusting customer service by Hyundai USA.

Engine
Filed Jul 12, 2026GA

COMPLAINT SUMMARY: [XXX] / ENGINE THERMAL FIRE RISK / WARRANTY DECEPTION My 2019 Hyundai Santa Fe (2.4L GDI Engine) is experiencing severe powertrain degradation under the known Theta II engine defect class-action framework. On November 7, 2025, the vehicle logged a Permanent Diagnostic Trouble Code (DTC) P1326 via an independent scan, indicating catastrophic internal rod bearing wear. On XXX, the vehicle was brought to Hyundai of Milledgeville for safety recall verification. Instead of executing the mandatory corporate-directed Bearing Clearance Test (BCT) to replace the failing engine block, the service department committed technical campaign malpractice. The technician forced the 9C2 ECU Software Update directly over the locked mechanical fault to suppress the dashboard warning lights and alter the vehicle's ROM ID parameter limits. When caught via a photograph of their active GDS diagnostic tablet showing 7 historical system faults, the service manager provided a truncated printed report hiding Page 1 and omitting the critical P1326 powertrain code count to evade a warranty engine replacement. Due to these unmitigated delays, the vehicle has suffered severe consequential safety damage. The advanced engine degradation and oil consumption have flooded the exhaust system, melting the catalytic converter substrate and triggering a new DTC P042000 (Catalyst Efficiency) fault immediately after the dealer visit. The extreme engine vibrations have also damaged the transmission's

Engine
Filed Jun 5, 2026PA

My 2019 Hyundai Santa Fe 2.4L (VIN: [XXX]) is experiencing a severe safety defect involving rapid engine oil starvation. The vehicle recently failed an official oil consumption test conducted by Fred Beans Hyundai of Abington, where it was documented that the engine consumed 1 quart of oil in just 881 miles (PA Request #XXX). This vehicle is equipped with the Theta II engine, which currently has active warranty extensions (TXXC and TXXI) specifically covering connecting rod bearing failure. Despite the documented severe oil loss—which is the primary known cause of connecting rod bearing wear and sudden engine seizure—Hyundai Corporate (Case #XXX) is refusing to evaluate the vehicle under these warranties. They have improperly classified my claim as a denied "goodwill" request and are refusing to perform a connecting rod bearing clearance test to determine if the bearings have been damaged by this starvation. Because Hyundai refuses to perform the required diagnostic safety protocols, the vehicle must be driven in an oil-starved condition. This poses an imminent and severe safety risk of sudden engine seizure, stalling, and complete loss of motive power at highway speeds without warning, which could result in a catastrophic crash. The manufacturer is ignoring their own failure thresholds and putting driver safety at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine
Filed Jun 5, 2026MD

On March 04, 2026, I took my 2019 Hyundai Santa Fe to the local dealer for oil change service. As part of that service visit, they performed Hyundai recall 9C1 which was supposed to lower tailpipe emissions. The next morning, and ever since, my vehicle ran differently. The engine had several 1000rpm surges and was sluggish at other times. This behavior has continued. Particularly when I first start out in the morning and the engine is cold. Never after the engine is warmed up. A visit to the Hyundai forum shows a growing list of other Hyundai owners who are experiencing the same issues. This recall is defective and should be corrected.

Power Train
Filed May 30, 2026NY

In December 2025, a Hyundai dealer performed Service Campaign 9C2 (TSB 25-01-087H), an ECU software update for the 2.4L GDI Theta II engine, during a routine annual NY state emissions inspection. Immediately following this update, the vehicle began exhibiting an RPM flare of approximately 1,200-1,500 RPM during upshifting under light acceleration. This behavior did not exist prior to the update. The condition occurs when ambient temperature is above 50°F and the vehicle has been parked 2+ hours after a prior drive. No warning lamps or fault codes have been present at any point. The issue has been confirmed across four dealer visits at two Hyundai dealerships over five months. Attempted remedies included transmission ECU updates and adaptive resets — none resolved the condition. On the fourth visit, the technician personally experienced the issue and identified reinstalling the pre-update ECU calibration as the likely fix, but stated the prior software version was unavailable. The repair order was nonetheless closed as "vehicle operating as designed." The case has been escalated to Hyundai Motor America National Consumer Affairs and forwarded to Hyundai engineering with no resolution to date. Multiple other 2019-2020 Santa Fe owners report identical post-9C2 symptoms on public forums, indicating a pattern associated with this campaign's ECU calibration. The unexpected RPM surge and erratic shifting during acceleration creates an unpredictable driving experience that could caus

Unknown or Other
Filed May 21, 2026OK

Vehicle: 2019 Hyundai Santa Fe, VIN [XXX] , exterior Quartz White Pearl. Component: Exterior factory paint (paint/trim). Complaint: This vehicle exhibits a systemic, progressive factory paint defect — excessive peeling and bubbling of the white finish that spreads from one body panel to the next. This is a known defect across this vehicle generation; Hyundai acknowledged it by issuing Warranty Extension Z05 (TSB 25-BD-004H), which extends paint coverage to 10 years/unlimited miles for affected white-paint vehicles including the 2019 Santa Fe. Hyundai repaired the hood under this warranty in 2025, during which the vehicle was out of service for 77 consecutive days. Since that repair, the defect has migrated to the adjacent fender and has also appeared on a door, demonstrating that it is spreading across the vehicle. Hyundai has offered to repaint only the single currently-visible panel rather than addressing the systemic defect. I am filing this complaint to document the defect and its progression, and to support the public record regarding factory paint failure on these vehicles. No crash, injury, or fire has resulted. The vehicle is owned by my spouse; I am submitting as authorized representative. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Unknown or Other
Filed May 11, 2026TX

Hyundai recently had a service campaign that was issued to address an emissions related issue in CA. The service campaign was 9C2 and the TSB was 25-01-087H. After this software update was applied to my vehicle the engine is now sluggish on a cold start and the transmission is shifting differently at low speeds and low gears. It appears that the performance of my vehicle has been compromised. There is a Hyundai forum where many Santa Fe owners are experiencing the same issues after the software update. I have notified the service advisor at my local Hyundai dealership.

Engine
Filed May 6, 2026NY

Engine is burning a tremendous amount of motor oil. Dealer does acknowledge engine is burning oil. No warning lights on. Told burning motor oil is normal for a hyundai engine. Engine can seize during driving with no warning and is a safety issue. Front struts are also failing. No warning and is a safety issue: Currently trying to get dealer to cover defective components under warranty. Nothing has been repaired or resolved as of yet.

Power Train
Filed Apr 30, 2026CA

Vehicle Information: 2019 Hyundai Santa Fe Mileage at failure: approximately 109,000 miles Manufacturer: Hyundai Motor Company The vehicle experienced a complete failure of the automatic transmission system. The failed component is available for inspection upon request. At approximately 98,000 miles, the vehicle’s check engine light illuminated. I brought the vehicle to an authorized Hyundai dealership for diagnosis while it was still within the 100,000-mile powertrain warranty period. The dealership inspected the vehicle and advised that no issue was found, and no repairs were performed at that time. Approximately 11,000 miles later, the vehicle experienced severe transmission problems, which progressed to complete transmission failure at approximately 109,000 miles. Safety Risk: The transmission failure resulted in a sudden loss of power and reduced vehicle operability while driving. This condition presents a potential safety risk to the driver and surrounding traffic, particularly during normal roadway and highway use. Prior Inspection / Diagnosis: The issue was not identified or reproduced during the dealership inspection at approximately 98,000 miles when the check engine light was present. Other Inspections: The vehicle was inspected by a Hyundai dealership at approximately 98,000 miles. No inspection by police, insurance representatives, or manufacturer engineering personnel has occurred since the transmission failure. Warning Signs: Check engine light illuminated at a

Engine
Filed Apr 21, 2026PA

Engine continuously burns oil excessively and the dealership is falsifying the oil consumption test. At my local oil change shop, there is no oil left on dipstick at 3,000 mile interval. When I took it to dealer for consumption test, they checked dipstick after 1,000 miles and it was OVER THE FULL LEVEL. How can the oil be over the full level? This indicates they overfilled it to begin with and invalidated the test. Hyundai corporate is doing everything they can do avoid addressing this issue with the 2.4 engine in these models. Additionally, the transmission already failed less than 70k miles on the car.

Engine
Filed Apr 13, 2026UT

We took it in to be looked at after it had a o2 sensor go bad I changed the sensor and checked fluids I noticed the oil was a touch low and it had metal on the dipstick. I took in to dealership for repair / replacement and Hyundai denied the claim. Even after I have video proof from the dealer technician saying there is metal and bearing material in the oil. I took it to another dealership and they found metal in the oil control valve and still denied it. We got the car back because we were not provided a loaner or a rental. I called back in with concern that the car had a weird burning smell and the car would die. Then it started sounding weird as well. Then called again Saturday because I checked oil and it had fuel smell in the oil. Now today it left my family stranded on the highway. I have th 100,000 mile ten year warranty and the car is only at 83480 miles now when this all started it was at 82000. I have expressed my concern of safety before it finally left my family vernable to be injured in the lane that it died in This afternoon. Many denied claims and now very dangerous situation that was preventable and could have cause fire or death. I brought to manufactures attention early to prevent a accident happening. I was denied all the way through the process .

Structure › Body
Filed Apr 5, 2026PA

The door was completely shut - I was driving on the highway - no alarm on the instrument panel, fully stage 2 latched ( even if it is just stage 1 latched - the instrument panel gives an alarm - there was no alarms about door not fully closed) everything was normal. 15 minutes into the drive - I was exiting the highway, making a right hand turn - the door suddenly popped open, alarm went off on the instrument panel - thankfully did not swing open, I was able to hold onto the door. I shut the door again - drove for 200 Miles - no issue again. This was the first ever time I saw this issue at 90K miles

Structure › Body
Filed Mar 2, 2026CA

The trunk hatch is no longer functioning. The car beeps, but does not unlatch. Once the gate is manually open from a latch inside the trunk, it will not close by pushing the gate close button. It just stopped working. I went into the grocery store, and when I returned with groceries, it stopped working. Hyundai says it's out of warranty and will cost $1800 to repair.

Structure › Body
Filed Feb 26, 2026WA

Paint is significantly peeling on the hood of my car.

Engine
Filed Feb 12, 202687,000 milesOR

The contact owns a 2019 Hyundai Santa Fe. The contact stated that while driving approximately 45 MPH, the vehicle hesitated while accelerating with the accelerator pedal depressed and the RPM raised. The contact stated that the vehicle occasionally failed to start. No warning light was illuminated. Additionally, while driving at various speeds, the vehicle lost automotive power. The vehicle was taken to a local dealer, where it was diagnosed, and determined that there were metal shavings in the oil pan. Hyundai Eugene (89320 N Game Farm Rd, Eugene, OR 97408) was contacted; however, the failure was not identified. Upon further investigation, the Hyundai Blue Link App retrieved DTC associated with the Power Train EMS and Power Train TCU. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 87,000.

Engine
Filed Feb 7, 2026NC

Since December my car has been burning oil at a fast rate. My husband has already had to add an additional 4 quarts since my last service 3000 miles ago. I have read and heard from others with a Santa Fe that they are having to replace their engines because of this. They are under warranty. Unfortunately I am not. I’ve already dealt with a white paint issue with Hyundai. I called couple weeks ago and was told someone would email me and they have not. I’m not sure where to turn now.

Engine
Filed Feb 6, 2026TX

The vehicle was burning through oil excessively. I was adding 1 quart of oil a week. Dealer did an oil consumption test. They confirmed the engine needed replacement. These vehicles are getting to be known for this issue and the dealer is making me pay 40% of the repairs. They should be covering 100% because the issue is not isolated to my vehicle only.

Engine
Filed Jan 22, 2026MD

My Hyundai Santa Fe 2019 Limited is burning oil. It started after the Turbo broke in October 2024. The turbo began leaking oil and then died. I took it to the dealership as it is still under warranty and they replaced the turbo. As a result, I have had issues ever since and now my car burns oil at a fast rate. In between oil changes I need to put oil in the engine to avoid it being drained. I am able to go about 3k miles on Synthetic oil and by 2.5-3k it is almost empty. It has been doing this now since 2024. I just had my 90k mile check up complete and with that I got an oil change. This was done in November 2024. Syntehtic oil was used. On January 16, as I was driving my car mileage decreased, the car began to shake and the engine light came on. I was able to safely stop and have the car towed. It was found that after driving just 2k miles the oil had completely burned off. I currently have an appointment at the dealer for them to run diagnostics on why it is burning. I saw there was a class action lawsuit against other Hyundai's doing the same thing and as a result Hyundai has to replace the engine. I also have read numerous forums where everyone is reporting the same thing with this particular model of it burning oil. I wanted to report this in case there were other owners of the same car experiencing the same thing.

Engine
Filed Jan 21, 2026CA

Complaint: Safety Defect - Engine Failure Risk (Stalling/Fire) My 2019 Hyundai Santa Fe has the defective Theta II 2.0L Turbo engine (G4KH), subject of class action In re: Hyundai and Kia Engine Litigation and multiple TSBs. The engine has a known manufacturing defect causing premature connecting rod bearing failure, leading to catastrophic engine seizure. SAFETY CONSEQUENCE: This defect presents a clear, unreasonable safety risk: Sudden Stalling: Engine can seize without warning while driving, causing loss of propulsion and power steering/brakes, leading to a crash. Engine Fire: Failed engines can leak oil onto hot components, causing fires. MANUFACTURER'S INADEQUATE REMEDY: Hyundai's "Knock Sensor Detection System" software update (Campaign 966) only attempts to detect failure moments before it happens. It does NOT fix the underlying mechanical defect. The engine remains a ticking time bomb. PERSONAL EXPERIENCE: My vehicle has suffered multiple related failures (turbocharger, fuel injectors) costing over $5,700, confirming the powertrain's deterioration. I fear driving it, especially with my teenage daughter. The defect is well-known, yet Hyundai's settlements fail to protect subsequent owners like myself, leaving unsafe vehicles on the road. REQUEST: I urge NHTSA to investigate the ongoing safety risk these engines pose to all owners, compel Hyundai to issue a true safety recall for a permanent repair (e.g., engine long-block replacement), and mandate clear disclosure of t

Engine
Filed Jan 17, 2026WA

Internal mechanical failure of the piston rings and cylinder walls. Misfire on Cylinder #2. Further testing revealed that Cylinder #2 is at 80 PSI, which is significantly below the manufacturer's specification. A subsequent leak-down test showed a 90% loss of pressure with air escaping through the oil filler hole. The issue stated above can cause severe mechanical failure of piston rings and cylinder walls can absolutely lead to connecting rod bearing problems by creating excessive debris, poor lubrication, abnormal piston motion, and increased stress, causing premature wear, overheating, and eventual bearing failure, often resulting in catastrophic engine knocking and damage. Diagnostics completed by Hyundai dealer and stated an engine replacement. Vehicle became difficult to steer and then warning lamp came on. Vehicle was difficult to turn left and right and almost caused a collision.

Engine
Filed Jan 13, 2026PA

On my 2019 Sante Fe 2.0T, I started having oil consumption/engine issues after 85, 000 miles. Under warranty, I had several minor repairs made over the last year (since 87,000 miles) at the dealership. In September 2025, at 97, 500 miles, I had it into the dealership complaining of burning oil and excessive consumptions in between oil changes. They AGAIN made a few minor repairs, I signed a one-owner warranty form since it was prior to 100,000, and they said come back if I experience further issues. On December 21, at 9pm at night, I broke down on the side of the PA turnpike. My engine light came on after my car started shaking vigorously, and wouldn't accelerate beyond 30mph. Being a Sunday night, I called the dealership in the morning- I was told no appointments for 3 weeks. Took it to a mechanic- where they diagnosed engine failure- hole in intake vale and floating valve not seated. Towed to dealership where it was INITIALLY diagnosed spark plugs and engine coil. Once a mentioned I had a prior diagnosis and pictures, Hyundai did bioscope- found burnt valve and now need all new intake values and part of the engine rebuilt. Hyundai wants me to pay for repairs. I don't think I should have to pay a dime- I've been complaining for over 15,000 miles BEFORE my warranty expired. And now, at 102, 000 miles, the engines blown?? This is a known manufacturer defect with the Theta II engines, and the pistons. I would expect Hyundai at the VERY LEAST to cover the cost of the repairs. Qu

Engine
Filed Jan 6, 2026NC

Driving on interstate when the car all of a sudden started shaking and the check engine light came on. Had it towed to repair place who said they could not touch it and had to go to Hyundai. Towed it there. Just advised today of the issue and that Hyundai wouldn't cover it. Car has just over 100k miles on it. The engine should not fail this soon. Cylinder 2 no compression was the reported issue. Without a car for several weeks.

Engine
Filed Jan 4, 2026CA

After several oil changes and going from ever 5000 miles to every 3000 miles for oil changes to the need to add additional oil before hitting 3000 for being low on oil. Was told this vehicle just burned oil often and nothing really i was able to do. Check engine light turned on. Car stalled, shook and even turned off after being idle too long. Diagnostic found a leak in a cylinder and no combustion in engine. Out of warranty coverage. No warning lamps came on prior. Was on the freeway when light came on luckily was able to pull over safely. Seen many other cars with similar year, make model and engine had similar issues with oil consumption leading to the need of a full engine replacement. Further reading into issue showed several class actions and recalls to similar situation.

Engine
Filed Dec 13, 2025CA

Vehicle is consuming oil at an exceptionally fast rate. In October 2025, when taken in for an oil change and my complaint of a burning smell upon quick acceleration, the technician documented no oil was found on the dipstick. Just a month later, in November 2025, the oil level was already extremely low, the vehicle was taken back to the dealer, and an oil consumption test is currently being administered. The vehicle is scheduled for an engine replacement in January 2026 after the consumption test is concluded.

Engine
Filed Nov 25, 2025WA

Overly excessive oil consumption 2 Quarts every 3 or 4 days.no leaks. Engine gets so hot I don't have to turn on heater In winter. On going issue since 100,000 miles. EBS light stays on electronic parking brake switch does not work. Parking brake will randomly engage after vehicle is turned off. Dealership cannot duplicate issue. If cruse control is turned on the vehicles warning lights all of them will suddenly illuminate and the vehicle shuts off. alternator and battery replaced. Have not used cruse control since. Airbags never inflated in a front end crash at 45mph Most recently I started experiencing I intermittent trouble staring the car. Then one day it didn't start at all and smoke was coming from under the hood. Towed to mechanic , starter burnt up 155,000. $ 900 to replace then a couple days later I lost power on the freeway and the car started jerking and vibrating. Stopped Vehicle cut off and would not start. After 1hr I started and limped home. Vibration under 2000 RPMs and when stopped. Knocking noise under hood. Brand new spark plugs. Mechanic stated Cylinder 3;missfire was identified as a hole in a valve due to weak material now I have to replace engine. Oil consumption and excessive friction and heat is to blame. My car has been cared for like a baby it's all I have. I should not have to be responsible for this very cheaply made engine that was doomed to fail.

Engine
Filed Nov 12, 2025VA

Engine oil consumption issue. I have taken the vehicle in 4 times due to this they have. Changed hoses and even the oil pan but the engine still runs out of oil. On several occasions the oil light comes on within 1000 miles of a oil change and when I check it the system is completely out of oil. This means the lubrication system is running with no oil and likely has metal particles in it. I have contacted Hyundai corporate and the issues still has not been resolved. There needs to be a recall on these engines before they start blowing up. I uploaded files of thw most recent service nov 5th and the current odometer reading and oil level. 7 days later the oil level is low.

Engine
Filed Nov 6, 2025AL

This vehicle requires 1-2 quarts of oil to be added to it weekly. It's all over the internet that many different models of Hyundais consume excessive amounts of oil. This puts others at risk due to damaging the engine and the possibility that the car will just stop completely while driving it. We have records to show how often and how much we have to add more oil every week.

Steering
Filed Oct 24, 2025PA

I purchased my 2019 Hyundai Santa Fe on October 29, 2021. Since then, I’ve experienced a series of mechanical and electrical failures that I believe are far beyond normal for a vehicle of this age. - The remote start has never worked. - On October 20, 2023, the hatch latch failed. The only way to open it now is by climbing into the back and manually pulling the latch. - On October 27, 2023, the electric power steering failed. I had to replace the entire steering column at a cost of $4,000. - The paint began deteriorating prematurely and required a full repair. Hyundai covered this under warranty, but the cost was $8,000. - In early spring 2025, all coil packs had to be replaced due to misfires, costing approximately $500. - September 4, 2025, The car stalled while I was driving on a main road and I had to pull over. There were no warning lights and I started home. About a mile from home check engine light came on so contact mechanic. Ended up towing to a dealership and was told the engine must be replaced because the oil had burned off without any warning from the oil light indicator. The turbo also needs replacement. - The combined cost is $14,000. These failures have caused significant financial hardship and stress. I am currently $17,000 underwater on the loan, and the repair costs are overwhelming. The lack of warning before catastrophic engine damage is especially concerning. I believe these issues reflect systemic defects in the vehicle’s design and manufacturing. The r

Engine
Filed Oct 15, 2025KY

The car is burning oil and Hyundai advises to change the oil every 7500 miles. The car holds 5.1 qt of oil and is currently burning about 1 qt of oil for every 5,000 miles. How is this not a forced recall? People are blowing up their motors all over the country. They knew it was an issue and bought their way out of a class action lawsuit. This endangers any driver if it happens on the interstate. Hyundai/Kia are being allowed to skirt accountability with these motors.

Electrical System
Filed Sep 13, 2025IL

This car has been cutting off for a month and no type of codes popping up alternator has been replaced two brand new batteries has been replaced which is dangers car cutting off while I am driving this vehicle is not safe at all needs to be recalled asap mechanic can’t even find the problem .

Structure › Body
Filed Sep 5, 2025NY

Paint peeling and chipping will cause rust.

Engine
Filed Sep 4, 2025MD

I was driving home Friday August 29th 2025 around 10:30 am on I-70 W when I began to have trouble accelerating my vehicle. There were vehicles trailing closely behind me so I increased pressure on the gas pedal. I would feel my car forcibly trying to compensate and the RPMs on the vehicle increased significantly. The check engine light then illuminated and the car stedily beagan to decelerate although RPMS were increasing and the force on the gas pedal was at its maximum. I could no longer get past 30 MPH. The cars behind me had to quickly change lanes behind me to avoid rear end collision and I finally pulled over to the shoulder of the highway but it was a very narrow shoulder so my safety and the safety of those driving around were compromised because they could have easily resulted in a high speed rear-end collision that could have been fatal and the location of my car on the shoulder was not safe and I could have been side-swipped waiting for a friend to come get me and for me to move my car off hat narrow shoulder. I was frantic and very emotionally distressed by this incident because all the maintenance on the car was up to date and there was no check engine light on in the car prior to this incident. The unexpected and decelleration and inability to compensate on the highway was very unsafe. I have taken my car to the delearship and they have yet to address my engine issues or the safety concerns. The rep actually laughed while I was recounting the events. I also call

Structure › Body
Filed Jul 24, 2025VA

Paint coming off of hood, no contact of any kind. Took to dealer and was told past its warranty sorry. Cost me over $1K to fix the problem.

Engine
Filed Jul 2, 2025SD

Oil consumption on vehicle engine leading the engine to run low on oil for extended periods of time

Unknown or Other
Filed Jun 26, 2025FL

Rear backup camera not working. Put car in reverse gear multi function screen goes black

Structure › Body
Filed May 7, 2025SC

White paint peeling off 2019 Santa Fe since 2023 ... Hyundai says they are aware of the defective paint issue but denied any recorse or responsibility. Paint comes off while driving and reduces visibility.

EngineFire
Filed May 4, 2025CT

Yesterday afternoon after running errands, my car was off and in my driveway. Within 15 minutes I noticed it was smoking. When I opened the hood. The engine was on fire. I attempted to put it out but was unsuccessful. 911 was called and responded to put the flame out. The car was destroyed. I recently had my engine resealed and turbo replaced at a Hyundai dealership. I picked up my car following repairs on April 18th.

Structure › Body
Filed May 3, 2025NY

I am the owner of a 2019 Hyundai Santa Fe in Pearl White (paint code SWP). The paint on my vehicle has begun peeling extensively on the hood, and other exterior panels. This appears to be the same paint defect that Hyundai previously acknowledged for the 2017–2018 Santa Fe Sport under a Customer Satisfaction Program (TXXW), but the 2019 model is not covered. The paint is bubbling and lifting without any impact or damage, suggesting a manufacturing defect. This significantly affects the vehicle’s appearance and may compromise corrosion protection. Numerous other owners of 2019 Hyundai models have reported similar problems. I am requesting that NHTSA investigate this issue as a potential widespread defect and urge Hyundai to include affected model years in any extended warranty or recall efforts.

Forward Collision Avoidance › Automatic Emergency Braking
Filed Apr 26, 2025AZ

Was at a complete stop at a light with a car in front me, I had plenty of space when I started accelerating and then suddenly the automatic system braked hard. Like there was literally NO REASON for what the car did. It took a few seconds to get out of that issue but then was able to proceed as normal. There have been at least 2 other times where a side sensor was triggered while on the freeway violently jerking me to the left, nearly putting into another lane.

Complaints 1-50 of 203, newest first, reproduced as filed.

Across model years

Worst on record: 2017
YearComplaintsRecallsFiresDeathsAssessment
202637400Routine
2025137500Routine
2024156710Routine
2023214140Above average
2022202510Above average
2021168720Routine
2020218290Above average
2019 — this page2032130Above average
2018110250Routine
20179726230High concern
2016236320Above average
20152552130Above average
20144933300High concern
20136053410High concern
20123551170Above average
2011181381Fatalities reported
2010260361Fatalities reported
2009359353Fatalities reported
2008541670Above average
2007684982Fatalities reported
2006106130Routine
2005216302Fatalities reported
2004303370Above average
2003308450Above average
2002165420Routine
2001209440Above average

Compare every Santa FE year →

Reading this record

Complaint volume is well above typical for a single model year.

Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.

Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.

Most recent recall on file: Mar 17, 2023. Source: NHTSA Office of Defects Investigation.