2016 Hyundai Santa FE

Defect. Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Risk. An engine compartment fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS multi-fuse, as necessary, free of charge. Owner notification letters were mailed May 31, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 218.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.

Risk. If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.

Remedy. Hyundai will notify owners, and dealers will replace the secondary latch cable, free of charge. The recall began on August 4, 2017. Owner's may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for the recall is 163.

Defect. Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Santa Fe vehicles manufactured September 1, 2015 to February 12, 2016. In the affected vehicles, the wires in the front seat belt buckle harnesses may be damaged by the seat's height adjuster mechanism, resulting in a failure to provide an audible warning when front seat occupants do not fasten their seat belts. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Risk. Without a warning to remind the front seat occupants that their seat belts are not buckled, they may forget to buckle their seat belt, increasing their risk of injury in the event of a crash.

Remedy. Hyundai will notify owners, and dealers will inspect and reroute the wires in the front seat belt buckle harnesses to their proper locations, as necessary, free of charge. The recall began on April 27, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 141.

1. Component/System Failure & Availability: The failed component is the engine's internal Camshaft Variable Valve Timing (CVVT) phaser backing bolt within the 3.3L V6 engine assembly. An internal factory bolt unthreaded, backed out, and physically pierced directly through the upper valve cover. The vehicle and intact failed engine are currently located at an authorized Hyundai dealership service center in [XXX], and remain fully available for immediate physical inspection by federal investigators upon request. 2. Safety Risk: An internal engine bolt unthreading and puncturing through the valve cover creates an extreme safety hazard. A high-velocity metal bolt piercing the engine casing causes immediate engine seizure, sudden loss of motive power at highway speeds, loss of power steering/braking assistance, and massive pressurized oil discharge directly onto red-hot exhaust manifolds, posing a severe risk of sudden catastrophic vehicle fire and multi-vehicle highway collisions. 3. Dealer/Independent Confirmation: Yes. The failure was formally inspected, reproduced, and confirmed by an authorized Hyundai dealership service department. Dealership technicians logged official diagnostic findings under Prior Authorization Case #XXX. 4. Inspection by Manufacturer/Others: Yes. The defect was inspected and escalated directly to Hyundai Motor America (HMA) Corporate Engineering. Corporate engineering officially verified the defect and issued Techline Case #XXX, confirming that an inter

WHAT FAILED: The engine — the 3.3L Lambda II GDI V6 (engine family GHYXV03.31XE per the federal emissions label) — failed catastrophically: a connecting rod penetrated the engine block. The failed engine IS available for inspection on request. It has been preserved unrepaired since the failure, the rod penetration of the block is externally visible, and the vehicle is currently at Niagara Hyundai in New York. WHAT HAPPENED / SAFETY RISK: On [XXX], I was driving at approximately 65 miles per hour on [XXX] southbound near Bath, New York, with four occupants aboard, when the engine failed suddenly and without warning — no warning lamps, messages, or symptoms preceded it. The vehicle immediately lost all motive power at highway speed. I was forced off the roadway and through brush and debris to bring the vehicle to a stop. The sudden total loss of power at highway speed created an immediate loss-of-control hazard to my occupants and to surrounding traffic. CONFIRMED BY OTHERS: The tow was dispatched through a 911 emergency call. A New York State Trooper was at the scene and observed the debris trail. The towing company's invoice (T&R Towing and Service, Call #[XXX], [XXX]) records "Break Down," winch recovery, vehicle not drivable, and the tow operator's handwritten condition description: "Motor go Boom." The vehicle is now in the possession of a Hyundai dealership (Niagara Hyundai), and Hyundai Motor America has an open case (#[XXX]); however, Hyundai has refused to inspect or d

I filed a complaint when the first engine seized. It's a miracle we got off the road safely that day. While it was at the dealership, the engine was replaced with a used engine and covered by my extended warranty from Vroom. I believe the cost was approximately $14,000. I was told the engine had around 30,000 miles on it. I've put around 20,000 miles on this engine and the same thing happened again. This time, the engine had been knocking for a few months. When it started knocking, I took it to the dealership because the new extended warranty by Hyundai was in effect and I assumed it would be covered. Immediately, Autonation Hyundai in Savannah, GA said it would not be covered because it was a used engine. I don't understand why when the engine can be traced and the mileage known by the number on the engine. On XXX, my [XXX] granddaughter took her driving test in the vehicle. About 2 hours later, the engine seized with her driving. We were on the same road and it was about the same time of day. Once again, it was a miracle we got off the road safely. I just talked to Hyundai and we'll see what they say. From the stories I've seen, they'll do anything they can to avoid covering these engines and they get away with it. The people who get hurt the most from this are the ones who can least afford it. I'm a [XXX] widow raising my 5 grandchildren by myself and believed I was getting a good vehicle, mainly due to the report by Consumer Reports magazine. Even after the first engine f

Purchased a used Santa Fe in January 2026 with 129k mile and at 131k my vehicle's CEL came on and did not function properly while operating. While driving the vehicle failed to accelerate above 25 mph when I pushed the gas. I pulled over to get out of the way of traffic and avoid any accidents. I shut the car off and sat for several minutes before restarting my vehicle. It successfully restarted and I drove home and parked it. I ran CEL diagnostic and received the code P0021. I had the vehicle towed to the local Hyundai dealer and they also pulled the same code and indicated I have an oil consumption issue explained as follows "Timing over advanced. Timing components driven by oil pressure. Inspected cylinders and borescope and found cylinder wall scoring and faulty piston rings. Radiator has crack causing coolant leak. Engine will have to be replaced to remedy oil consumption. Radiator will need to be replaced to remedy leak." resulting in over $12k of repair work. The vehicle's temperature gauge did not indicate any abnormalities nor did the oil light come on to indicate any oil consumption issues. The vehicle was driven from the dealer to my home within city limits/speed and has not replicated the acceleration issue but the CEL remains on as the repair is too costly and is more than what was paid for the vehicle.

Rod bearing failure while driving, engine made a clanking noise. Engine made a loud bang and shut off. It was difficult for the driver to get control of the vehicle and get it to the side of the road. Engine threw the rod and piston through the oil pan causing catastrophic internal damage. The oil had been changed the day prior. The company that changed the oil sent an inspector to evaluate car at the scene. He stated this is a known problem with this engine. He pulled up pictures of other cars that had the same problem, also took pictures of the car oil pan and compared the pictures, they were exactly the same. Car was towed to Hyundai dealership that is refusing to replace the engine.

Beginning about a month ago, I noticed a rattle upon the engine start up that lasted for a 1-2 seconds then stopped and everything sounded normal. I thought it could be b/c of the cold weather. I went in to get a routine oil change on 03/11/2026 and they said the oil looked fine, but it was about a quart low, indicating it was burning some oil somehere. They said to check in in a few months and they would top it up if needed. I asked them about the rattle and they thought is might be from a bad (timing chain tensioner) but said I should get it checked out. I called on Friday 03/13/26 to schedule an appt at my local Hyundai Dealership on 03/17 . The night before(03/16), I was driving my vehicle and suddenly on the road, I heard a loud noise in the engine, and the power shut off, the Engine and oil light came on and I just had enough time to pull off the busy state route. My car would not start or turn over. I had it towed to the dealership and they did determine that it was a "Rod Bearing Failure" that caused the engine to sieze. I provided them evidence of my oil changes which from 10k-93k miles on my car since I have owned it. I have had the oil changed 10 times. They are saying they only allow 8k between oil changes to honor the warranty and have initially denied my claim. The service associate at the dealership said my valvetrain was 'somewhat' dirty, but nothing to where it was the cause for this issue. And since it was the Rod bearing that failed, the exact part that was

The motor began to making a knocking noise and started smoking like a fire was starting. We immediately turned off the vehicle preventing from a full fledge fire. We had children in the car as well which posed a safety concern for them. We had no prior warning lights or issues. It has yet to be inspected by anyone.

The contact owns a 2016 Hyundai Santa Fe. The contact stated that while driving 60 MPH and attempting to depress the accelerator pedal, the vehicle decelerated and failed to respond as intended. The contact coasted to the right side of the road, turned off the vehicle, and the vehicle failed to start. Neither an independent mechanic nor a dealer was contacted. The vehicle was towed to an independent mechanic; however, the vehicle was not diagnosed. The contact was informed that the vehicle was scheduled to be diagnosed. The vehicle was not repaired. The contact stated that the failure had occurred on four occasions. The manufacturer was not notified of the failure. The approximate failure mileage was 150,000.

My engine failed at 113,000 miles. It just sounded like a diesel truck when I started it one day. There were no warning messages at all. It did not have any power above 45 mph. I took it to a Hyundai dealer and showed him the extended warranty letter I received from Hyundai. The letter said my specific engine should qualify for an extended warranty. However, the dealer (Castle Hyundai of Downers Grove, IL) said because my engine failed due to timing chain failure and not connecting rod failure, Hyundai would not honor the extended warranty. That infuriates me! Hyundai should honor the extended warranty because their engine failed and it wasn't my fault. They know they have an engine problem but because my engine didn't fail exactly the way they projected it would fail, I'm [XXX] of using my car. It also meant I had to purchase a new car which obviously wasn't a Hyundai. I hope you can push Hyundai to provide me financial relief or at least expand the engine warranty for others. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2016 Hyundai Santa Fe lost all power, shutting off and stopping abruptly in the middle of the road with no warning lights or “limp mode” being set off requiring my partner and I to push it into someone’s driveway with our two children in the car to get them to safety. We took the vehicle to a mechanic shop where we were told that to engine was seized and needed to be fully replaced with an initial quote starting at 8 thousand dollars for a replacement engine. I contacted my local Hyundai dealership and was told over the phone that the vehicle would be covered under Hyundai service bulletin TXX8 that was issued last year due to ongoing issues with this engine (3.3l V6 Lambda II). We paid to have the vehicle towed to this dealership only to be told that the warranty would not be honored due to a lack of maintenance records. I was able to provide Hyundai with all maintenance records from my ownership as well as records on the CarFax report. They rejected the claim again stating that due to a lack of records not from my ownership they won’t cover it. After looking at the records I had access to again in critical detail I was able to find records that Hyundai missed, but they are unwilling to reevaluate the claim without me providing what they call additional records. I have contacted Hyundai, to try and resolve the issue and have gotten no resolution. The Prior Authorization team has stated that I have “adequate records” but still insist on denying the claim. The dealer has qu

The contact owns a 2016 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the contact stated that the brake pedal was inoperable. The contact stated that the vehicle vibrated while depressing the brake pedal. There was no warning light illuminated. The vehicle was restarted. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the ABS module had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 119,000.

Engine oil runs out quickly

The contact owns a 2016 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The vehicle was towed to the dealer, where the same diagnostic information was provided. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,322. The VIN was not available.

This is my 2nd engine on my 2016 Santa Fe Sport. My car has 190,000 miles and had a catastrophic engine failure, it’s been at the dealership for 2 months. Hyundai said my lifetime warranty on my engine is not covered cause I had a misfire in the #4 cylinder with less than 2,000 miles on the spark plugs. Hyundai warranty department only spoke to the dealership directly and had me speak to a case manager (which did nothing, they never even talked to the warranty department only the dealership) So in December I dropped my car off, it took over 2 weeks to take pictures and send them in to Hyundai warranty department, a week later Hyundai asked the dealership to further take the engine apart and get pictures of the rocker’s. The dealership is down to 2 technicians and said they will get to it when they can (remember I’m without a car and waiting for approval for my engine so they can get me in a rental car while my engine gets replaced). Over 3 week later the dealership finally sends the pictures in of the rocker’s, I know cause I called and asked the dealership. I then asked why does the warranty department need pictures of the rockers for my engine failure (misfire in 4th cylinder) and they said to check for sludge. They also pointed out my engine isn’t bad and don’t have sludge so the warranty department should approve my engine replacement. A week later my case manager called and said that they will only approve 50% and I said NO there a lifetime warranty and I’m the original

While driving down the highway at 65mph my 2016 Santafe Sport experienced engine failure. We sat on the side of the highway, next to an on ramp with high traffic beside a cement wall. When the tow truck arrived the driver was nearly ran over! There was no way to get the car to a safer location. After being towed to the dealership they said the engine failure would be submitted under warranty due to an issue with the connection rod bearing damage causing the engine to fail. It was denied because I was not the initial owner. A week later I received information about a class action suit against Hyundai for this very problem. As part of the suit they had extended the warranty. The dealership resubmitted my information and it was turned down again, this time for high mileage. Several months later the dealership wanted my car removed from their property, I asked them to submit it again. This time turned down because the KSDS was not updated prior to the engine failure. I now have a like new vehicle that I owe $9,000 on with a known defect that was never corrected because the required KSDS update was listed as a service campaign rather than a recall and so went unnoticed by the dealership I bought it from, or the NY inspection centers during my annual inspection and unknown to myself because when I checked for recalls there were none. Recently I found a Hyundai best practice document that states the KSDS update is no longer a prerequisite. I had my car towed once again to the dealer

The contact's husband owns a 2016 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle failed to accelerate upon depression of the accelerator pedal. The check engine warning light appeared on the instrument panel during the failure. Despite the vehicle operating in LIMP Mode, the vehicle was taken to an independent mechanic where an oil change was performed. The mechanic warned after the service was performed that there may be an ongoing failure with the engine. Several days later, the contact stated that while in stop and go traffic, the vehicle stalled with the check engine warning light illuminated. Due to the failure, the vehicle was towed to an independent mechanic where a diagnostic test was performed; and the contact was informed that the failure might be related to the cam shaft. The contact had the vehicle towed to a dealer and informed that the failure was probably related to the high-pressure fuel pump. The high-pressure fuel pump was replaced; however, the failure persisted. The contact was then informed by the dealer that the engine needed to be replaced. The manufacturer was not notified of the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 200,000.

Car started to present problems at around 100k miles when it would start to hard shift any time it shifted in to 2nd gear. On several occasions it would fail to accelerate beyond 25 mph one of these instances happened while driving at speed on the interstate where pressing the gas pedal to the floor did not accelerate the car. Resently the engine would not turn over instead all of the display and indicator lights would flicker on and off rapidly. In all of these instances the car never through any codes with the exception of one time i May 2024 and were inconsistent enough that it was difficult to replicate issues when brought in for inspection. All of the above symptoms were alleviated by adding about a quart of oil every 1,000 miles or so. Again when asking about these issues the repair shops could never give a reason for why it was going through so much oil.

Four weeks ago, I noticed my 2016 Santa Fe was not blowing any heated air into the cabin. A/C would come out fine, but room temperature air at best even when thermostat set to max. I took it in for diagnosis at a local mechanic who informed me that coolant was leaking out of the engine block and into the exhaust. I took the car to the dealership who informed me that the engline block itself had somehow gotten a tear in its side. No telling how the damage occurred, yet the warranty company (Costguard) in acquisition of my powertrain policy rejected the claim because (without ever personally inspecting the vehicle) there "was no discrepency as to how the damage occurred." Every mechanic at the dealership who has seen my car disputes their answer. I have been up to date on all maintenance on my vehicle throughout my ownership and have receipts, but cannot add them as they are all in my glovebox and the car is still at the shop. While I find it personally ridiculous that a warranty company would deny this, it is important for me as well to add to the list of engine complaints about this car. Likely the damage to the engine block has also been the cause of reduced mileage I have experienced lately.

Hard Shift occurs between gear 1 and gear 2. The hard shift lurches the entire car. It occurs on both upshift and downshift. The hard shift occurs on cold starts. The problem goes away when you turn the vehicle off and then back on. There are no check engine lights. The dealer can't replicate the problem.

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine failure due to oil consumption How was your safety or the safety of others put at risk? Car attempted to die on a highway, this could have been dangerous had I been in the outside 'fast' lane when it struggled. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the dealer has confirmed the engine needs a full replacement Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, only the dealers service center has inspected the vehicle Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. There was a blink engine light shortly before the car engine died. However, there was no indication the oil was low in the engine. The oil light did not come on.

I purchased this vehicle less than a year ago from a dealership, used. I noticed the oil consumption after the first few months was unreasonably high. I have to keep a large jug of oil in my car and add the oil at least every two weeks or so depending on the miles I drive. I noticed other Hyundai owners complain of the same issue and some being resolved. However, my VIN is showing no open recalls at the moment.

Engine has serious recall that I was not made aware of during purchase. My car has been burning oil and the engine has been on. I've taken out to several local mechanics who said "these model Hyundai's burn oil once they are over 100,000 miles" and that I would just need more frequent oil changes. I was also told the engine light was either an old code being thrown, or the pump valve, but nothing to worry about because it really only effects gas milage. My engine went out and I had to get it towed to another mechanic, who upon seeing the car, knew it had an engine recall and could hear a distinctive knock in the engine due to a failing rod bearing. Upon Hyundai's request, we towed it to a dealership to have them inspect it. They agree it's the engine that's bad, but since a "knock sensor" was never installed by the previous owner, they say they are not liable to cover the repair, and that since the recall is "public knowledge", it was my responsibility to find out. If you go onto the NHTSA.gov website, and type in my VIN number, the information says "0 unrepaired recalls", therefore making it impossible for me to have known about the recall without Hyundai letting me know, which they didn't.

Driving on a slight upgrade, lost power and smoke started to come out of the vents and from under the hood. Had no brakes and by the time we were able to drift to a stop, the engine compartment was on fire. There was no warning lights. Witnesses saw fire under the car while we were coming to a stop. The car and all contents were totally consumed. Following some research on NHTSA vin decoder we found that this car has the same engine (GDI THETA II) that has been involved in many fires and is involved in class action suits. Even though this car has the same engine, it was never recalled. That may indicate that there are other cars out there that may have the same problem but have not been informed.

Engine shuts off and slows down while driving.

None

I was rear-ended and the driver's seat did not maintain it's position and fell into the seat behind it.

We were driving through our neighborhood at about 25 mph and we heard a slight knocking noise and then the engine shut off, no warnings or lights, just engine failure. The electronics worked, but car wouldn’t start. Had it towed to a local mechanic where he said the engine is seized. We were thankful this happened at a low speed in a safe place, can’t imagine how awful it would have been if we’d been going 75 mph down the 4 lane interstate. Of note, we have always kept the vehicle current on oil changes/maintenance. Prior to this, the car drove great! Never had any issues that would point to impending trouble.

Was driving on a 5 hour car ride at 5pm on August 16th and was going up a hill, the vehicle quickly lost all power and the engine light lit. I was able to pull the car to the side of the road with the momentum that the car already had, but was not able to get the car to a safe space (its about 6 inches from an exit ramp lane), as the car would not drive. Once I got the car to the side of the road, I checked the engine and did not see any excessive heating or anything out of the ordinary. I tried to restart the car and the check engine light is lit and the battery system for the car turns on but the car will not start or try to turn over the engine. The car is currently sitting on the side of the road. My wife and my dog were in the car and we had to quickly move to a safer place away from the 70 MPH traffic. Calling a tow truck tomorrow to take it to a dealership. It was a little scary that the engine power cut out like that without giving an engine light notice in advance or giving time for me to navigate to a more safe space to park it.

The door on the drivers side does not lock. It appears that something came out of place causing the door to remain unlocked even with the use of the fab. The car is not drivable because the door swings open. It has happened in a few occasions where the lock appears to get stuck but was always fixable. On this occasion it was not. Thankfully, I was parked when this occurred.

Abs system is randomly locking up calipers causing a dangerous speed wobble. Dealership can't re create so won't diagnose. Have had to replace all brake calipers and components were near new but ruined because of abs applying brakes when unnecessary. Vehicle is very unsafe to drive, pulled hard to left at one point veering me into oncoming traffic. Independent mechanic has made caliper release by manually releasing abs system. Same results were not found by releasing pressure at master cylinder making abs the obvious culprit. No warning lights but I just replaced two cracked rotors on rear at 130k miles. That should not happen. Has caused hub readings of 270 on three different tires at 3 different times. Santa fe has recall on this system for every year but mine, very curious as to why not. If this was not a dealership only part , it might not be such a big issue, but being it is main source of stopping a 4000 lb vehicle, I have concerns. Hyundai dealership was very condescending and of little to no help. I have an Independent are certified mechanic who is happy to talk with you if needed. Please help, as of right now am.making payments on an unsafe vehicle with not much hope of it being fixed.

Vehicle was driven on a highway approximately 45-50 mph when a loud knocking sound occured. The vehicle began to shake erratically and a bunch of lights displayed. I pulled over at a safety point and turned the vehicle off to inspect it. A large amount of smoke poured from under the hood. The vehicle sat for about 45 minutes to cool down before I attempted to start it again. The engine continued to make a loud knocking sound and kept stalling. At the given time of engine failure, I was driving on a fairly busy highway with my two toddlers where we were forced in a dangerous situation to be struck by a vehicle. Hours later, I went back to start the vehicle where I was able to get it started and drive approximately 15 mph to a safer area for the vehicle to be parked. The vehicle has been at the Hyundai Bowser Chippewa location in Beaver Falls, PA. I was denied for any assistance through Hyundai and the BBB-Hyundai due to 3 open recalls, mainly the engine knock system not being updated. All issues and diagnostics were conducted at the dealership where the vehicle is being stored. No police report has been filed, nor was an insurance claim conducted. No lights or warnings came about until the engine started to noticably fail. I didn't receive any notifications from Hyundai regarding recalls, and nothing is displayed on the NHTSA site.

On July 3, 2024 my husband was driving our 2016 Santa Fe with a v6 engine on a highway. He was coasting down a hill going approximately 65mph when he heard a loud bang and saw something shoot off to the left of the vehicle. When he tried to brake, he realized the car had shut off and he did not have automatic steering or breaks. He managed to get the car safely pulled off the highway by using all his weight to stand on the brakes and turn the car. The car did not start up again. When we got the car towed home, we were looked under the hood and found that the engine had shot a rod. We found pieces of the engine/rod along the bottom of the engine bay. We called local mechanics as well as Hyundai service center and got quotes for repair ranging from $9-20k. The car was purchased in July of 2023, the engine had 97k miles on it, with 8k miles being put on from July 2023-July 2024. The vehicle passed PA state inspection on June 2, 2024 by the dealership’s service center.

The vehicle began making a knocking sound upon starting. I contacted the local dealership for a service appointment and learned that they were out a couple of months on their appointment schedule. A day or two later, my vehicle shut off while driving, I was fortunate to have enough momentum to pull of the road safely. Upon having it towed to a local mechanic, I learned that the engine seized and needed to be replaced. I contacted Hyundai and they have scheduled me for an appointment next week. Keeping my fingers crossed they will do right by me since I have always had the vehicle serviced at their Hyundai dealership. The car has approximately 118,300 miles on it.

The contact owned a 2016 Hyundai Santa Fe. The contact stated while driving 50 MPH, he heard an abnormal knocking sound coming from the engine compartment. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that there was a misfire in cylinder #3, and the catalytic convertor system efficiency was below threshold. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 94,000. The VIN was not available.

Car started making noise after the check engine light came on. Check engine light was on for just a few days then by the third/fourth day the car starting making noise, turned off on me a few times then just died. We replaced a few sensors and the battery and starter. Two mechanics have told me the engine is locked and needs to be replaced.

Was driving on the highway going about 65mph when the engine just lost power. Pressing the accelerator and there was nothing happening. Had the car towed home. And then to a mechanic who told me the rod was bent. I’ve always kept up on oil changes and maintenance. I just had an oil change less than a month prior. There were no warning signs leading up to this incident.

On May 23, 2023 Was inspected for an oil leak and was informed the oil was leaking from the drain bolt (oil pan was cracked), valve cover was leaking. Was replaced with a Pan assembly-engine oil, gasket-rocker cover (with GDI High Pressure Pump gasket), and gasket- fuel pump. . However on oil leak continued and cause massive engine failure. Turned it in 5/26/2024 Had to replace engine.

On 5/15, I was entering the highway when the vehicle refused to accelerate. I pushed the gas pedal all the way to the floor, and the vehicle did not respond. I checked to see if it had stalled, but the engine was still running. I watched the rpm meter as I pushed the accelerator, and noticed that the rpm’s stayed at 1.5 the entire time. I pulled over to the shoulder and turned off the vehicle as I was afraid of causing an accident as I was not at highway speed at the time. I turned the vehicle back on and when it was safe, attempted to reenter the highway. The vehicle responded appropriately. The check engine light had come on 2 days prior to this (5/13) and I was in the process of trying to make an appointment to get it fixed. My husband ran the engine code (P0014 and P0024). The check engine light had turned off upon restarting the vehicle but turned back on about 3 minutes after resuming driving. I took the vehicle to a mechanic to have it looked at, and they noticed that the engine had lost 4 quarts of oil. There had been no oil leakage noted at any time. They added 3 quarts of oil to the engine and noticed that the knocking sounds remained. Their determination was that the car was pretty much totaled. There were no indicator lights on the dashboard to notify me that there was low oil at any time. The only indicator that showed was the check engine light 2 days before.

Around three weeks ago, we start listening to a knocking noise in the engine. As soon as we heard this noise, we took it to a mechanic near our home and the mechanic told us that there was an internal problem with the engine and we needed to take it to an official Hyundai dealership to solve this problem. Moreover, they told me this is a common problem in Hyundai's cars and the dealership would do it for free. When I took it to the dealership, they told me that I had to replace the chain timing, tensioners, CVV, and many other stuff needed (I'm sending the receipt attached, see "car report 2024.pdf"). It was going to take 10 hours of work. Importantly, this was not covered by the Hyundai warranty or recalls. I bought the car 3 years ago, and both the previous owner and I did the year service to the car. I'm sending all the receipts and CARFAX of the services. Best regards, [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

6 months ago my rod bearing broke in my engine, and I needed a new engine. From the engine recall. With a broken rod bearing you get an oil consumption problem. Oil consumption ruing your cat converter. But they aren’t telling anyone that. 6,000 miles after my new engine, my catalac converter broke. These cars are dangerous. They’re not telling anyone that this is the next problem. They just put you back on the road. Not to mention bad for the environment!

Engine light came on while driving and vehicle began to malfunction with bogging and little power to move the vehicle properly. Vehicle was towed to Hyundai dealership for diagnostics. Determining that there is rod bearing failure in the motor. Contacted Hyundai corporate who denied warranty claim citing I did not properly maintain the vehicle per owners manual although they were provided with records of proper maintenance, however it was disregarded by Hyundai warranty people as proper maintenance. I have contacted BBB and PA Attorney General for assistance but to no avail. There are countless others with the same exact issues where Hyundai Motor America is denying warranty claims for identical mechanical motor issues.

-Premature complete engine failure, at approximately 72,000 miles. -Luckily, was able to get vehicle to manufacturer dealership prior to complete immobilization of vehicle while on the road. -Engine “bearing” failure per dealership. Requires complete engine assembly for repair. Complete engine assembly no longer available, only manufactured for 6 years, and requires 150+ parts to be assembled at dealership for “short block”. -Dealer serviced maintenance documented at correct intervals. -Incident occurred without any warning lights, first and only symptom was a loud knock from the engine that increased in volume and and speed with increasing RPMs. -Vehicle remains at dealership, pending resolution. -Dealership states no active manufacturer recall on issue with this particular engine, but is aware of many other similar complaints and engine failure with this model of engine, 3.3L Lamba II GDI engine. Desire to add my complaint to any others as this poses a safety risk to other owners. Online research reveals an active investigation by the NHSTA and a class-action suit regarding this issue. Please help, and contact me if you have any questions or concerns. Thank you.

The contact owns a 2016 Hyundai Santa Fe. The contact stated that while driving at 55 MPH, the vehicle lost power and the engine began to knock and then the vehicle stalled. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that an engine replacement was needed. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Action Number: DP22003 (Engine). The manufacturer was contacted, who opened a case. The failure mileage was approximately 87,000.

Engine failed me driving 75 MPH down I-10. Completely stalled. No warning indication lights. Car did not over heat. Just shut down and never started again. I had to coast over 4 lanes of traffic, pulled off the road using my emergency flashers for a short period until those went out as well. Car did have oil and all fluids. I had to have car towed home 3 hours from home. I have had vehicle looked at and have been told engine seized up on me. I have had this vehicle not even a year and I am a single disabled woman. I have found several others have had this issue as well and have a really hard fight to get these thinks fixed. I have put a brand new motor and had the alternator checked it passed the test. Battery did not, was drained. I bought a new battery and all electronics are working and car goes into ON position with the push start but no engine life at all. No clicks, No life at all. I can hear fuel pump doing its normal things and I can do any electrical thing on inside. I have had no ride, no sleep at night, anxiety attacks over my car just stalling out now being told engine seized up 2016 Santa Fe Sport 2.0 T

Engine knocking/failure at 75000 miles. No warning/check engine lights prior to failure. Dealership quoting $17k to rebuild engine.

My car started accelerating on its own, out of nowhere. There were no prior indications. No prior damage. It began accelerating on its own. After shutting the vehicle off and turning it back on, the issue has persisted. Anytime it is in drive or reverse, it accelerates at an extreme rate. It also disabled the brake, when the acceleration began.

The contact owns a 2016 Hyundai Santa Fe. The contact stated that while his granddaughter was driving at an undisclosed speed, the vehicle hesitated, and there was white smoke emanating from the exhaust pipe, after which the vehicle inadvertently lost motive power. The driver was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the cylinder head bolts, resulting in damage to the cylinder head gaskets and requiring a replacement engine. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 87,000.

Someone backed out of a parking lot and I crashed into their rear passenger side. Other party at fault but my air bags for 2016 Hyundai Santa Fe Sport did not deploy.

In May 2023, I booked an appointment to get the software update for the immobilizer issue on my Hyundai Santa Fe Sport 2016. Issue resolved. In February 2024, the vehicle was vandalized in a driveway but was NOT stolen. However the alarm did not trigger unless it was 'tripped.' Why???? Today it is March 15, 2024 and vehicle is still at collision shop getting everything repaired.

Had an accident where driver side front of vehicle was hit. The severity of crash resulted in total loss. The driver was hurt and concussed due to her head hitting the side window, driver side. The vehicle was equipped with front side impact and curtain airbags and all failed to deploy. The other vehicle's side curtains were deployed.