2019 Hyundai Santa FE complaints

Vehicle is shuddering/jerking upon acceleration due to a defect in the 8 speed automatic transmission. This condition was reproduced by Hyundai of Plymouth, MA and documented on the repair order. Dealer states that a new transmission is required to fix this problem. Safety is at risk due to shuddering upon acceleration which causes hesitation in acceleration. My Hyundai Santa Fe is available for inspection. There should be a recall on this vehicle.

One cylinder of the engine is misfiring. When I bought it used in 2021, I realized it had a problem. At red lights or stop signs, the car would randomly not accelerate when it was time for me to go. I would have to turn it off, then on; shift to park then drive; or mash hard on the gas for the car to recover. For example, it happened at these days and times in 2024 (I didn't write down every time since ownership began): 1/24/24 and the key icon lit up; 3/14/24 at 9:20 am; 4/20/24; 7/19/24; 8/7/24; 8/18/24; 8/21/24 at 10:40 am; 8/25/24; 8/27/24; 9/7/24 at 12:30 pm and 3:21 pm; 9/12/24 at 10:38 am; 9/20/24; 9/21/24 at 1:43 pm; 9/23/24 at 7:38 am; 11/12 at 9:36 am; 10/26/24; and 10/27 at 4:37 pm. It was scary! I took the car to the Hyundai dealership in September 2022 and in October 2022 for this issue and the alert that Forward Collision Assist warning wasn't working. I was told both time that they didn't know why the first happened and recommended I replace the entire bumper for the second (it's no longer happening and I did not replace the bumper). I reported it to Hyundai Customer Care and nothing happened. The car also required 4-5 quarts of oil every 2000 miles. I believe these were precursors to what happened this month. On April 5, 2025 the car completely stopped while I was driving on the highway. I added oil and it chugged to an oil change shop where the diagnosis was a problem with coil 3 in the engine. I went to an auto parts store and replaced coil 3, and the car ch

A year after I purchased vehicle the paint started peeling off the wheel. When I took it to the dealership they kept telling me they were still addressing problem and would get back to me. Contacted them several times and they still didn’t have the problem solved. Then the dealership changed ownerships. New dealership says not their problem. And it was too late at this point. I also have the paint on my hood of my car peeling. Both of these problems are gonna be very expensive to repair! I see this is a known problem. Hyundai needs to be accountable. I live in Auburn Al

When accelerating the transmission slips. My mechanic said Hyundai has a memo saying they are making a new torque converter due to these problems, and I will need a new torque converter. The torque converter is on backorder and according to my mechanic, will not be available for many months; thus indicating there are many other folks with the same problem. This is very dangerous when accelerating, as the speed drops off due to the slippage, and can put me in a dangerous position if I need to accelerate to avoid a potential situation. It has also presented issues from a dead stop, pulling out into traffic, where the slippage puts me at risk. This has been going on for quite some time, and my mechanic has been doing what Hyundai memos instuct.

The contact owns a 2019 Hyundai Santa Fe. The contact stated that while attempting to accelerate from a stoplight, the vehicle failed to respond. The Auto START/STOP feature failed to restart the engine as designed. The contact stated that the Turbo light was illuminated as if the turbo was activated, even though the contact had not activated the feature. The vehicle was taken to a Certified mechanic who determined that the turbo had failed. The turbocharger was replaced. After the vehicle was repaired, the failure reoccurred while the vehicle was idling or parked. There were no warning lights illuminated. The dealer was informed of the failure however, the vehicle was not taken to be diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the dealer for assistance. The failure mileage was 90,000.

The contact owned a 2019 Hyundai Santa Fe. The contact stated that as his daughter was driving at 20 MPH on the highway, she depressed the brake pedal, the brakes failed to respond, and the vehicle started to smoke from the engine and into the cabin. There were no warning lights illuminated. The contact's daughter then tried to depress the brake pedal again, and the contact's daughter then jumped out of the vehicle on the ramp. The vehicle was coming down on the intersection unoccupied, engulfed in smoke, initially hitting a stop sign and then another unknown sign and sequentially coming to a stop. The contact then saw the vehicle at the hillside engulfed with fire and smoke and tried to break a window, however, the contact heard his daughter and stopped. The Fire Department and Police Department were on scene and extinguished the remaining of the fire and the hillside. The origin of the fire was on the engine. The manufacturer was not made aware of the failure. The vehicle was consumed by the fire and the remainder were taken to Lenzi Automotive. The contact was the only occupant in the vehicle and sustained scrapes and bruises to her elbow, finger, right thigh, buttocks, and back rib that require medical attention. The failure mileage was approximately 77,200.

Car turns off at lights /stop signs. Automatic break system activates. Have to wait at least five minutes to be able to restart car z same happens after driving and parking. Turbo and battery were replaced. I make sure not to use the automatic on/off feature which make issue worse. This is my fourth attempt to contact you. I cannot trade car in bc of mileage and still owing $. I love me vehicle and just want issue recognized and taken care off.

The contact owns a 2019 Hyundai Santa Fe. The contact stated while at a red light, the vehicle stalled. The failure had occurred on several occasions. No warning light was illuminated. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.

The contact owns a 2019 Hyundai Santa Fe. The contact stated while the vehicle was either stationary, parked, or being driven, the seat belt buckle failed to operate as designed. The seat belt warning light was illuminated. The contact stated that during the colder months, the seat belt buckle was more difficult to latch securely. The local dealer was contacted; however, the vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.

White body paint chipping.

Wipers are in the office position, but suddenly go up and down 2 inches, while off, and won't turn on. It snowed the day before, but wasn't while I was driving. Also, my hood is peeling. I have white paint.

Auto stop/go disables car’s ability to resume driving after stopping at a light etc. This is without activating feature. You have open and close door and press button on/off over and over. Turbo was changed bc mechanic assumed it was the problem. Now it is happening after reaching destination and then attempting to leave if not sitting long enough. New battery and $2000 turbo!

This has been an ongoing issue since the date of purchase 10/23. I've been taking my vehicle for regular check ups and oil changes. My vehicle appears to be consuming oil. I have to put a quart in every week, but no one can find the issue. The dealership told me there is a recall on these particular vehicles engine.

The contact owns a 2019 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle lost motive power while depressing the accelerator pedal, with the check engine warning light illuminated. The vehicle was taken to a dealer and the turbo was replaced. The contact stated that months later, the vehicle hesitated and jerked while depressing the accelerator pedal with the check engine warning light illuminated. The vehicle was taken back to the dealer where a part on the transmission was replaced; however, the failure returned, and the check engine warning light illuminated. The vehicle was taken back to the dealer and the contact was informed that the transmission needed to be replaced. The contact took the vehicle to an independent mechanic and had the transmission replaced. The contact stated that months later, the vehicle began to sputter with an abnormal knocking sound coming from the vehicle. The check engine warning light returned, and the vehicle was taken to the nearest dealer. The vehicle was diagnosed with engine failure. The vehicle was not repaired and remained with the dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 87,000.

2019 Santa Fe, this vehicle was serviced by Hyundai three times for a "Knock Sensor" notification. 12/3/2019: ECM manufacturers recall 14,242 miles 7/13/2021: Knock Sensor hardware notification - 38,615 miles 12/15/2024 repaired 1/7/2025: Knock Sensor hardware notification – 79,882 miles Panel indicating motor issues, vehicle becomes unable to accelerate above 60 mph. We have documented communications between dealers and Hyundia corporate with case#

We have had our vehicle for over 2 years with routine maintenance. On 1/25/26 We were driving home and oil light came on then check engine light. The oil pressure the issue.

SUV driving great for 2 years with routine maintenance- engine light pops up, doesn’t go away, and i take it to a local shop. SUV has low oil pressure of 5 and needs replaced. No sounds or driving issues prior.

Issue with idle on-off. After idling at light etc. car will stall. First time would not re-start , I was towed. Mechanic replaced turbo feature but problem persists and I am not using the on -off feature in an attempt to not have this happen, yet it does.

Transmission: yes, available upon inspection I own a 2019 Hyundai Santa Fe. I have brought it in for repairs on the transmission a couple of times. The check engine light has come on but the computer was not displaying the problem. I am aware that this is not uncommon for the year, make, and model. Recently, I was driving my car on a high-speed highway when the transmission went out. While suppressing the gas, the transmission slipped and would not accelerate. As cars were passing me on either side, my car decelerated and cars behind me came close to rear-ending me. Again, this was at high speeds and put my safety in jeopardy. I was finally able to find a gap in the cars and able to get to the shoulder but not after several minutes of unsafe conditions. After this incident, I brought it back to the service center and the computer analysis did display that it is an internal transmission problem. The service center has inspected the transmission. Yes, the warning lamps were displaying, first about 8 months prior. As stated previously, the actual problem was not displaying. Attached document is previous work done for transmission due to incorrect computer diagnostics.

Rear camera malfunction just like other models

Upon going for an oil change at Express Lube in Newton , NJ I was advised that there are multiple widespread & ongoing problems with a crack that forms in the oil pan next to the drain/fill plug. My vehicle was diagnosed with that very problem. I believe a a recall to should be done by Hyundai to replace these oil pans. Thank you

I have unusable camera in my 2019 Sante Fe, that is not included in a recent recall. Tried to find what “Problem” actually is on current recall to compare to mine. My picture is too bright and contrast ruins ability to identify objects behind me. Is the recall based on a similar problem? As your current Hyundai recall states: "An inoperative rearview camera will reduce rearward visibility while driving in reverse, increasing the risk of injury to bystanders." Local dealership has tried to fix, but after almost a month has not. Question is should recall be extended beyond current model years?

Rearview cameras are unusable due to high brightness and contrast issues. Seems same problem possibly as recent recall even though not in same model years. Hyundai dealership has been unable to resolve since November 6 and as recall highlights "increasing the risk of injury.." Attached photo of condition, usually worse than this photo in bright sunlight.

The paint is failing, it is coming off in sheets, there is no damage to the car where the paint is coming off.

The seat is able to forward face up to 40 lbs with a seatbelt install and 35 lbs with a latch install. When trying to install this seat with the seatbelt the instruction manual states not to lock the seatbelt after install however if the seatbelt inst not locked the seatbelt moves easily with some pressure (i.e. child pushing legs against back seat) and then becomes so lose that is can fall over. ALternately, i have tried the install with locking the seatbelt and this solution only lasts 1-2 car rides longer. (i.e. i would need to reinstall my seat every other time my child rode in the car). Currently the seat is installed with the latch system as this is the only way to get a safe install however my son is currently 34lbs and it will soon be unsafe to ride rear facing with the latch system which will then force me to turn him front facing before I or my son are ready.

Peeling paint as a result of manufacturing issue (no primer was ever added prior to paint). I have spoken with Hyundai twice and both times they have refused to repair since vehicle is no longer in warranty. I would like for Hyundai to take accountability for this for myself and all other 100’s of people who are dealing with this. They show no honor to those of us who have invested multiple thousands into their business.

The contact owns a 2019 Hyundai Santa Fe. The contact stated that while driving at approximately 22 MPH, the vehicle struck a pot-hole which caused the driver seat to move out of place. The contact stated that while accelerating, the front driver seat would shift backward and while shifted into reverse the seat would move forward. The vehicle was taken to a local dealer where it was diagnosed that the seat rail was damaged and the seat rail and seat needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 92,000.

CRANK SHAFT SEAL LEAK ON A 44700 2019. HOWEVER THERE IS A RECALL ON THE CRANKSHAFT SENSOR. THEREFORE WHY WOUL THIS CAR NEED A SEAL WITH THIS YESR AN LESS MILEAGE. SOMEONE NEEDS TO LOOK INTO THIS. BECAUSE THE DEALER WANTS 2448.00 TO FIX THIS.

The Forward Collision Assist would intermittently disable during driving. The Lane Keeping Assist light illuminated and would not allow me to disable it causing the vehicle to drive straight only and to make left or right turns extremely hard to turn the vehicle. This incident occurred on [XXX] and was dropped off at Johnson Hyundai in Wake Forest on that date. After a week of no contact of a diagnosis, I had to visit the dealer and was told the steering column was the issue and needed to be replaced. I contacted Hyundai America to report this issue and currently waiting on a response from their warranty to see if they will cover all or a percentage of the replacement of the steering column since my mileage is over their 100k (113k to be exact) coverage. While I appreciate their efforts, I also feel this could have resulted in a very serious incident had my daughter been driving on the highway when this occurred. Thankfully, she was picking me from home and it happened as we drove off from our house in our neighborhood. A steering column should outlast any other part(s) of a vehicle. If not, this is a huge safety concern. My [XXX] was also in the car at the time and I cannot even imagine how I would recover if something worse were to happen while he's on board. Hopefully this reporting will keep something bad from happening to others who own this type of vehicle but failed to report it. Thank you for your time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (

My car just stalls at a stop ligth , no check engine light, no warning, and takes several attempts to start. It happened 3 times in two weeks one of those time while in the highway. One a the stop ligth and one driving in the neighborhood.

I had a tow-hitch installed and attached a cargo tray which I previously used with my 2010 Santa Fe. On June 21, 2024 at the end of the first day of our extended vacation the items on the passenger side of the cargo tray had melted. This included elements of the cargo tray itself, a Coleman chair, a brand new (1st use) Yeti cooler, cargo net and bungee cords. The following day I went to a Hyundai dealership in Charlestown, WV who verified the tow hitch was installed correctly but mentioned that the exhaust from my Turbo 2.0 engine was extremely hot and probably contributed to the melting. We were not able to find a way to elevate the tray away from the exhaust or add a shield to divert the heat. We had to discontinue use of the tray and purchase a trailer which connected several feet behind the car. As mentioned, I previously used this same tray with my 2010 Sant Fe without any difficulty or heat issues. I am concerned because of the potential for a fire with items igniting due to the extreme heat. I did not find any warnings about this nor any verbal precautions from the dealer when I purchased the car. If I had been carrying items more flammable I could potentially of had a fire start on the tray while the car was in motion resulting in more severe damage or harm to persons.

Continuous issue of front driver passenger power seat front level button failure. Continuous Headlights, fog lights getting fused every 4 months. Indoor back roof light works and sometime just does not work for months.

Enciende la alerta de choque y para sin tener vehiculos cerca.

I had a serious issue with the Santa Fe lane keeper system. I was driving on I15 in a winding portion through the Virgin River Gorge in relatively high traffic on a corner. I have used this feature many times in the past and expected a gentle nudge on the steering wheel. But unexpectedly the steering wheel turned hard left, almost causing a total loss of control. I am safe driver always checking for other drivers doing what they shouldn't, but I never expected my car to be the one making dangerous movements. If I hadn't had a firm grip on the wheel, I would have been out of control on a narrow bridge in heavy traffic. Am I the only one with this problem?

Front CV Joint inner axle boot losing grease due to manufacture insufficient torque or poor quality of the clamp material.

Seatbelt wont snap or lock. This is a safety issue

For the past month my car has been stalling in traffic. The car stalls and then turns back on a few seconds later. It also stalls when I am accelerating after stopping for a red light. This situation is very dangerous and it means that I cannot drive my car expecting to be safe at all. It seems like the motor and the transmission are involved which makes the stalling very dangerous as those are major systems.

Seat belt won't snap on the driver side.

Fire while driving - Electrical - No Warnings Reference NHTSA Recall 23V181000 Fire Extinguished once by fire extinguisher (civilian) then again by Union, MO fire department. Hyundai had the vehicle towed to their inspection facility. Inspection report being withheld. Claim has been denied. Hyundai now refusing to return vehicle.

My Santa Fe developed difficulty starting beginning the afternoon of February 18. While waiting in stop-and-go traffic to park for a sporting event, the ISG (idle stop-and-go) activated at least 40 times. After at least the 40th time, the Santa Fe did not turn back on. After about 10 minutes, I was able to start it. This happened while I was stuck in very heavy traffic exiting the freeway. After that, it would always take multiple attempts to start the car even though the battery had more than enough power to turn over the starter. After a couple of days of dealing with this, I took the Santa Fe to my local Hyundai dealer. After diagnostics, they were able to reproduce the problem and they determined that the starter had developed an intermittent short which was likely caused by the multiple ISG activations on Sunday, 2/18/2024. While they verbally agreed with me that repeated activation of the ISG was the likely cause of the starter short, they wouldn't put that in the written service statement. At the time of this problem, my Santa Fe was 1,887 miles past the 5-year 60,000 mile bumper-to-bumper warranty. I had purchased the Santa Fe a few months ago as certified pre-owned with about 58,500 miles on it so, even though being the 2nd owner, I retained the remainder of the bumper-to-bumper warranty as well as the 10 year 100,000 engine/drivetrain/transmission warranty. Oddly enough the starter, which is attached to the engine is categorized as part of the car's electrical syste

There is a system in the car that starts and stops engine, supposedly only at lights to save on fuel. Mine has stopped in the middle of a highway on my way up to Tahoe. Luckily I had just left light and only driven enough to reach the speed of about 10 miles per hour so the cars behind me were able to stop and not hit me. I had to completely turn the car off, put in park and restart car to get it to operate. It has stalled out like a stick shift would if not handled properly, but it is an automatic transmission, on numerous times. Sometimes this will cause the vehicle to completely shut down and sometime it will sputter for a few minutes and then slowly pick speed up and stop. The IGS button to turn this feature on and off when you get into the vehicle will sometimes stay off (not supposed to) and sometimes turn back off as it is supposed to each time the vehicle is turned on or off. It doesn't register as a recall, but I have done my research and saw that at one point you guys had done an investigation into this exact problem with my car. It doesn't show up on diagnostic and it doesnt do this every time I drive. So I have no way to show mechanics the isues. But this puts my life and anyone in my cars lives at risk. Not to mention any cars behind me if this happens on the highway again. I dont know what to do :( Can you please help me?

Oil Pan leaks after an oil change. Oil pan has a hairline crack just below the drain plug after normal tightening of the plug. Excessive oil was found on my driveway. No obvious engine damage, considering the vehicle was only moved from one spot to the other. The dealer stated the oil pan isn't covered under warranty. I simple internet search revealed there was a high number of complaints. It was a "Do It Yourself repair." The cost to fix was to replace the oil pain, new tools and 5 quarts of oil.

2019 Hyundai the white paint is peeling. It was not caused by road damage. I asked the dealership and was told I was past the warranty due to my mileage.

At various times the vehicle will not start. It takes multi times to to start the vehicle. The starter and battery have been tested and both are in excellent condition. Both key phob batteries have been replaced and the vehicle at times won’t start but the dash lights turn on. After twice of trying to start the breaks get really stiff. I’ve learned if I get out of the vehicle and open the hood and close it the car will start then any other time getting out and back in it does not start. I even placed the key phob in the designated location of the battery died and still won’t start. The check engine is not on either.

On August 24, 2023, I was walking to my car, a 2019 Santa Fe in my driveway. The back windshield spontaneously shattered! It was only 70 degrees out and I had my window cracked open a bit. The noise sounded like a gun shot. I was extremely fortunate that I was not behind the windshield or that I was driving. I have no explanation as to what happened. I called my insurance company, and the windshield is being replaced by Safelite on Tuesday, 8/29/23. However, I have to pay for $483 for a new windshield, my deductible is $500. I am more concerned about safety. I have seen other complaints about Hyundai windshields. Please Hyundai address this issue.

The Airbag light keeps coming on and saying it’s not activated, the wiring also keeps blowing out brand new headlights due to faulty wiring.

The systems forward collision and lane departure warning are randomly turned off. Dealership is not aware of how to fix

Engine Failure. Engine stalls during deceleration. If it doesn’t stall while braking, it immediately stalls around 5 mph when I come to a stop sign or red light. Vehicle start/stop button will not work to start the vehicle back up. It is to sit for 10-20 minutes and then it will start. If I don’t let it sit, it gives me a message on the dash that the vehicle is already on/running even though it is not. I have done regular maintenance and have had it serviced 4 times for the same issues. It has 126,000 on it. The dealership said it was the oxygen sensors and spark plugs. We had those fixed and the problem continued. The dealership is now wanting me to pay $11,000 for a used motor to be installed. Check engine light keeps repeating oxygen sensor malfunction. This has been happening since July of 2022.

On May 20,2023 my 2019 Hyundai Santa Ultimate turbo died while I was sitting at a red light in the far right lane in an extremely busy street. Car was running perfectly fine prior to it dying. For almost 15 mins my car wouldn’t turn over. Then it just started it right up. Took it home my husband checked for any codes, nothing. I checked the Blue Link app, no issues detected. On June 29th at approximately 9:08AM my car dies again while sitting at a red light. Next to an off ramp to an extremely busy freeway. I’m almost in a full panic the car restarts up. Within 5 mins it dies again. This time blocking a drive way to a driveway at a gas station. All 3 times were identical. All three have no warning. No indicator warning lights and nothing detected in the blue link app. Can’t get it to do it again. So frustrating.

On June 28th at approximately 1130pm, my son was involved in a single vehicle accident. Upon impact with the tree the car immediately burst into flames