Owners filed 7 complaints about this vehicle with federal regulators, most often about the service brakes, air. No safety recall has been issued.
| Component | Reports | Crashes | Fires | Injuries | |
|---|---|---|---|---|---|
| Tires | 1 | 0 | 0 | 0 | |
| Service Brakes, Air › Supply › Hoses, Lines/Piping, and Fittings | 1 | 0 | 0 | 0 | |
| Service Brakes, Air | 1 | 0 | 1 | 1 | |
| Power Train › Axle Assembly | 1 | 0 | 1 | 0 | |
| Fuel System, Diesel | 1 | 0 | 0 | 0 | |
| Equipment Adaptive/Mobility | 1 | 0 | 0 | 0 | |
| Engine and Engine Cooling | 1 | 0 | 0 | 0 |
THIS TRUCK ATTEMPTED TO TRANSPORT A BOAT. IT ARRIVED AND WAS IN COMPLETE POOR CONDITION AND WAS UNABLE TO PERFORM THE SERVICE I PAID FOR. THE THEY REFUSED TO REFUND MY MONEY AND LEFT. THEIR EQUIPMENT NEED TO BE INSPECTED. THEY POSE A GRAVE DANGER TO VESSELS, MOTORIST AND PEOPLE AROUND. *TR
2001 FREIGHTLINER CONVENTIONAL, UNIT 1 AND 2 WERE TRAVELING WESTBOUND ON THE OHIO TURNPIKE. UNIT 2 WHILE TRAVELING IN THE LEFT LANE WAS STRUCK BY DEBRIS FROM A BLOWN TIRE FROM UNIT 1. UNIT 1 WAS TRAVELING IN THE CENTER LANE. *BF (OHIO TRAFFIC CRASH REPORT # 10-0382-91)*JB
BRAKES ON THE LEFT REAR WHEEL OF THE VEHICLE'S TRAILER CAUGHT ON FIRE.*MR THE FIRE DEPT STATED THE REAR BRAKES BECAME HOT AND CAUGHT ON FIRE DUE TO LACK OF OIL THE TRAILER AXLE *CB *JB
AIR LEAK FROM BRAKE SYSTEM AIR HOSE CONNECTION AXLE.
FUEL LIFT PUMP LOSES PRESSURE OVER TIME CAUSING INTEGRATED CIRCUIT IN FUEL SYSTEM TO FAIL TO FUNCTION. DRIVER OF VEHICLE RECEIVES A WARNING LIGHT ON DASH,; THE ENGINE COMPUTER SOMETIMES DE-RATES THE ENGINE AND SOMETIMES SHUTS OFF THE ENGINE. THIS HAS HAPPENED TO ONE PARTICULAR BUS THAT SHUT OFF WHILE DRIVING DOWN THE ROAD ON A ROUTE. BUS TAKEN TO AUTHORIZED DEALERSHIP. IF THE DEALERSHIP CAN RESET THE CODE AND IT DOESN'T FAULT, THE VEHICLE IS RETURNED TO US CLAIMING NO PROBLEMS EXIST. THE BUS THEN DIES OUT AGAIN. LIFT PUMP MALFUNCTION ALSO DAMAGES INJECTOR PUMP. SHORTLY AFTER HAVING THE LIFT PUMP REPLACED, THE BUS IS DOWN AGAIN FOR AN INJECTOR PUMP. AT LEAST 3 OTHER SCHOOL DISTRICTS HAVE ALSO REPORTED SIMILAR TYPE INCIDENTS. WE HAVE A TOTAL OF 36 UNITS POWERED BY THE CUMMINS ISB225 ENGINE. WE ARE CONCERNED THAT THIS WILL CONTINUE OVER TIME AND THAT THE MANUFACTURER IS AWARE OF THE PROBLEM, BUT SELDOM DOES IT GET ADDRESSED WITH THE FIRST TRIP TO THE AUTHORIZED DEALER. BUSES THAT DON'T HAVE EXTENDED WARRANTY COVERAGE WILL BEGIN TO SEE MORE EXPENSIVE BILLS FOR REPAIR. *JB
2000/2001 FREIGHTLINER SCHOOL BUSES WITH THE CAT 3126 ENGINE THE INJECTION PUMP HIGH PRESSURE OIL FEED LINE MAY BURST CAUSING ENGINE FAILURE OR POSSIBLE FIRE FROM SPRAYING OIL ONTO ENGINE. WE HAVE HAD 16 OCCURANCES OF THIS FAILURE SO FAR. ONE BUS HAS HAD 2 FAILURES.
THE REAR BRAKES LOCATED ON THE TRAILER (NO MAKE/MODEL OF TRAILER PROVIDED) LOCKED UP AND CAUGHT ON FIRE, CONSUMER SUFFERED INJURY. (OHIO TRAFFIC CRASH REPORT). *MJS
7 of 7 complaints, reproduced as filed.
No unusual pattern of severe incidents in the complaint record.
Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.
Most recent recall on file: none. Source: NHTSA Office of Defects Investigation.