1997 Ford Thunderbird

Defect. SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk. DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy. SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Defect. CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy. AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

1997 FORD THUNDERBIRD. CONSUMER WRITES IN REGARDS TO VEHICLE VIN# NOT LISTED ON DEFECTIVE BRAKE PADS/ROTORS RECALL NOTICE. *SMD

I SMELL GAS WHEN DRIVING AT HIGH SPEED OF 60 AND ABOVE ON FREEWAY MOSTLY. ONCE IN A WHILE I CAN SMELL IT WHEN DRIVING AT LOWER SPEEDS OF 25 -30MPH. I USED TO THINK THAT I HAD SPILLED GAS ON THE OUTSIDE OF CAR WHEN IT FIRST STARTED HAPPENING, BUT NOW A YEAR LATER, I STILL SMELL GAS AND I DO SMOKE IN MY CAR, BUT WHEN I SMELL THE GAS, I WILL PUT THE CIGARETTE OUT. IS THERE SOME KIND OF RECALL ON THIS PROBLEM, THAT CAN REPAIR IT. I HAVE PUT $4000.00 INTO RESTORING THE CAR AND I AND PUTTING ANOTHER $800.00 INTO IT NEXT WEEK, NOVEMBER 2013, TO REPLACE ALL OF THE BELTS AROUND THE ENGINE. I HAVE ALREADY REBUILT THE TRANSMISSION FOR $1800.00 AT AAMCO, AND PUT A $2200.00 PAINT JOB ON IT, BEFORE I KNEW OF THE GAS SMELL. I HAVE ALSO REPLACED ALTERNATOR AND BATTERY. AM I FIGHTING A LOSING BATTLE WITH THIS CAR? *TR

IN THE MIDDLE OF AUGUST I SMELT GAS WHEN I DROVE. AND THE SMELL HAS BECOME STRONGER AND STRONGER. TODAY (10/10/2011) I WENT TO A VEHICLE REPAIR SHOP AND WAS TOLD THE LEAKING IS ON THE TOP OF FUEL TANK AND COULD NOT BE REPAIRED IN THE SHOP. I CHECKED ONLINE AND FOUND MANY PEOPLE HAVE EXPERIENCED THIS VERY DANGEROUS LEAK. PLEASE CLICK THE LINK: HTTP://WWW.CARGURUS.COM/CARS/DISCUSSION-T872_DS478881. THIS CAR MUST BE RECALLED FOR FUEL LEAKING. *KB

TL* THE CONTACT OWNS A 1997 FORD THUNDERBIRD. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED HOME AND WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE CONTACT ALSO STATED THAT PRIOR TO THE FAILURE, THE VEHICLE WOULD DECELERATE WHILE DRIVING AT VARIOUS SPEEDS. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

THE PLASTIC INTAKE MANIFOLD ON MY 1997 FORD THUNDERBIRD CRACKED SPILLING OUT ALL MY COOLANT AND CAUSING MY ENGINE TO OVERHEAT, THIS IS A DESIGN FLAW THAT SHOULD BE COVERD BY FORD MOTOR COMPANY, THIS HAPPEND WHILE DRIVING DOWN GRATIOT AVE. IN ROSEVILLE MI AT 40 MILES PER HOUR WITH NO PREVIOUS WARNING, THIS FAILURE HAPPEND 7/3/2011 SATURDAY OVER THE FORTH OF JULY WEEKEND, WHERE I COULDN'T GET IT TO A OPEN FORD DEALERSHIP, NOW I CONNOT USE MY VEHICAL FOR WORK MONDAY 7/4/2011. WILL THIS REPAIR BE COVERD BY FORD MOTOR COMPANY? *TR

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

I HAVE A 1997 FORD THUNDERBIRD THAT HAS A MANIFOLD PROBLEM. I AM BEING TOLD BY FORD THAT IT DOESN'T FALL UNDER THE RECALL FROM 2005 BECAUSE IT WASN'T BUILT IN THE RIGHT PLANT. I HAVE READ A LOT OF INFORMATION THAT ALL OF THE 1997 T-BIRD HAVE THIS PROBLEM AND NEED TO BE FIXED. NOT ONLY IS DOES MY CAR NOT RUN RIGHT, BUT I ALSO AM NOT FACING REPLACING MY CATALYTIC CONVERTER, AS WELL DUE TO THE LEAKAGE. WE ARE TALKING ABOUT $1700 IN REPAIR. *TR

WHEN I BOUGHT THE CAR, A YEAR AGO, IT RAN GREAT. ONE DAY AS I AS COMING UP A HILL, MY CAR STARTED SHAKING. IT WAS A CRACKED INTAKE MANIFOLD, THAT OF WHICH FORD WAS IN A CLASS ACTION LAWSUIT IN 2005. WHICH COVERED A "SELECT FEW" OF THUNDERBIRDS. HOWEVER NOW THAT MY MANIFOLD CRACKED, THERE "NOT AT FAULT." WE HAD THE CAR FIXED, ONLY TO LEARN AFTERWARDS THAT FORD HAD SEVERAL ISSUES ABOUT THE FAULTY INTAKE. *TR

ENGINE IDLE RACING. CAN'T STOP UNLESS PLACED IN NEUTRAL, WHERE CAR WOULD RUN OVER 2000 RPM. DEALER REPLACED IDLE AIR CONTROL AND POWER CONTROL MODULE. DEALER STATED THAT IDLE AIR CONTROL BURNS OUT THE POWER TRAIN CONTROL MODULES ON MANY V-6 FORD ENGINES. CAR HAD ONLY 34,518 MILES CHECKED OTHER SURGES THAT THIS IS A SAFETY ISSUE OF RACING ENGINES IN ACCIDENTS OF V-6 MOTORS AND FORD REFUSING ANY RECALLS FOR POSSIBLE FIRE OF IDLE AIR CONTROL AND THE BURNING OUT OF POWER TRAIN CONTROL MODULE. *TR

1997 FORD THUNDERBIRD WITH SHIFTING PROBLEMS. CONSUMER STATES THAT THE SHIFTER LEVER AFTER PRESSURE ON BRAKE PEDAL DOES NOT RELEASE SHIFTER HANDLE. HE HAD THE BRAKE LIGHT/RELEASE SWITCH REPLACED AND PROBLEM STILL EXISTS. *KB THE CONSUMER HAD DIFFICULTY REMOVING THE SHIFTER OUT OF PARK.

PLASTIC INTAKE MANIFOLD FAILURE. *JB

MY WIFE DROVE HER 1997 FORD THUNDERBIRD TO WORK TODAY. SHE PARKED HER CAR IN THE COMPANY GARAGE AND WALKED INTO WORK. THE CAR THEN BEGAN TO BURN AND TOTALED THE CAR. AFTER HAVING IT TOWED TO A LOCAL GARAGE, BASED UPON THE KNOWLEDGE OF THE MECHANIC, TO WHOM, I HAVE USED TO SERVICE MY VEHICLES FOR OVER 10 YEARS, TOLD ME THAT THE INTENSITY OF THE FIRE WAS NEAR THE STEERING COLUMN, AND AND POWER STEERING SWITCHES. UPON RESEARCHING THE ABOVE FACTS, FOUND THE RECALL ABOUT THE VARIOUS FORD TRUCKS AND THIS SIMILAR PROBLEM. WE HAVE LIABILITY INSURANCE ON THIS CAR, AND NOW WE HAVE LOST THE CAR TO NO FAULT OF OUR OWN. ARE THERE OTHER FORD CARS WITH THE SAME PROBLEM?

TL*THE CONTACT OWNS A 1997 FORD THUNDERBIRD. WHILE DRIVING 40 MPH, IN HEAVY TRAFFIC THE CONTACT NOTICED SMOKE RISING FROM UNDER THE HOOD. THE TEMPERATURE GAUGE NEEDLE SHIFTED TO THE HOT INDICATOR. THE VEHICLE WAS TOWED TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE ENGINE WAS LEAKING COOLANT AND THE PLASTIC INTAKE MANIFOLD WAS CRACKED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 73,500. *UPDATED 12/12/07 *BF UPDATED 12/12/07

TL*THE CONTACT'S DAUGHTER OWNS A 1997 FORD THUNDERBIRD. WHILE DRIVING 55 MPH, THE VEHICLE OVERHEATED AND THE CONTACT NOTICED THAT ANTIFREEZE WAS LEAKING. HER DAUGHTER NOTICED A CRACK ON THE INTAKE MANIFOLD, WHICH SHE BELIEVED MAY BE THE CAUSE OF FAILURE. AS OF AUGUST 31, 2007, THE DEALER HAS NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 57,000 AND CURRENT MILEAGE WAS 60,000.

MY MECHANIC HAS INFORMED ME OF A DANGEROUS SITUATION WITH MY AUTOMOBILE THAT COULD LEAD TO AN ACCIDENT. ALL THE BALL JOINTS IN THE FRONT END ARE WORN EXCESSIVELY. HE SAYS THE EXCESSIVE WEAR IS A RESULT OF THE DUST SEALS DISINTEGRATING ALLOWING DIRT AND WATER TO ENTER THE BALL JOINTS. HE INDICATED THAT THIS IS PROBABLY A RESULT OF THE USE OF INAPPROPRIATE OR DEFECTIVE MATERIALS FOR THE SEALS. I AM GOING TO HAVE THE BALL JOINTS REPLACED. I WILL ASK THE MECHANIC TO KEEP THE OLD PARTS FOR ME. *NM

DT*: THE CONTACT STATED WHILE PERFORMING GENERAL MAINTENANCE ON THE VEHICLE, IT WAS DETERMINED THE PLASTIC SEALS ON ALL FOUR UPPER AND LOWER BALL JOINTS AS WELL AS THE SEALS ON THE STABILIZER BAR WERE FRACTURED AND DETERIORATING. THE MANUFACTURER WAS ALERTED.

INTAKE MANIFOLD SPLIT CAUSING COOLANT LEAKAGE. *NM

DT: THE CONTACT STATED THE FLOOR SHIFTER WAS STICKING IN PARK WHEN THE WEATHER WAS COLD. IT TOOK FIVE TO TEN MINUTES TO MOVE THE SHIFTER INTO OTHER GEARS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THE DEALER SAID THE PART WAS UNAVAILABLE, AND THEY WOULD HAVE TO GO TO A JUNK YARD TO LOCATE ANOTHER SHIFTER. NO REPAIRS HAVE BEEN MADE. *AK

1997 FORD THUNDERBIRD MOTOR DIED WHILE DRIVING.*MR ***NOT IN REPOSITORY. *NM

I PURCHASED THIS 1997 FORD THUNDERBIRD LX SPORT AS A USED VEHICLE IN OCT. 2002. I NOTICED THAT DURING THE FIRST FEW WEEKS OF OWNING THIS VEHICLE IT WOULD INTERMITTENTLY LEAK A SUBSTANTIAL AMOUNT OF COOLANT ONTO MY DRIVEWAY BUT I COULD NEVER SEE WHERE IT WAS COMING FROM. SOMETIMES IT WOULD GO FOR DAYS WITHOUT LEAKING AND THEN ONE DAY THERE WOULD BE OVER A QUART OF COOLANT ON THE DRIVEWAY. I BROUGHT THE CAR INTO A SHOP THAT PUT THE CAR ON A LIFT TO LOOK FOR THE LEAK BUT THEY COULD NOT FIND ONE. I CONTINUED TO DRIVE THE CAR AND ADD COOLANT EVERY TIME THE "LOW COOLANT" LIGHT APPEARED ON THE DASH PANEL. IN MAY 2005 I WAS ON THE 91 FREEWAY AND SUDDENLY WITHOUT WARNING THE "LOW COOLANT" LIGHT CAME ON AND THE TEMP CAME UP QUICKLY SO I TRIED TO CHANGE LANES TO THE RIGHT TO EXIT THE FREEWAY AND THE BACK OF THE CAR BROKE LOOSE AND I ALMOST TURNED SIDEWAYS. I FOUND OUT LATER THAT THE REAR TIRES AND WHEEL WELLS WERE SOAKED IN COOLANT. THIS WAS THE FIRST TIME THAT I FOUND OUT THAT MY INTERMITTENT LEAK THAT NO ONE COULD FIND WAS MY INTAKE MANIFOLD AT THE BASE OF THE THERMOSTAT HOUSING. I WENT TO RANCHO SANTA MARGARITA FORD AND ASKED ABOUT RECALLS AND THEY TOLD ME THAT THE RECALL FOR THE INTAKE MANIFOLD HAD EXPIRED A COUPLE OF MONTHS AGO AND THAT THERE WAS NOTHING THAT THEY COULD DO. I CALLED FORD MOTOR CO. CUSTOMER RELATIONS AND WAS TOLD THE SAME THING. THE CAR NOW SITS PARKED UNREPAIRED. I CANNOT AFFORD TO PAY ALMOST TWO THOUSAND DOLLARS TO CORRECT FORDS ENGINEERING BLUNDER. *JB

INTAKE MANIFOLD CRACKED CAUSING COOLANT TO LEAK OUT. FORD WILL NOT REPAIR UNLESS I PAY FOR IT. CLASS ACTION LAW SUIT PENDING. FORD AGREED TO REPLACE ON VEHICLES 7 YEARS OLD OR LESS. MY VEH IS 8 YEARS OLD WITH 26000 MILES. BAD DESIGN FOR INTAKE. *NM

DT: 1997 FORD THUNDERBIRD LX V8 4.6 LITERS. 1997 FORD THUNDERBIRD LX HAD A COOLANT LEAK. THE PLASTIC INTAKE MANIFOLD OVERHEATED. COULD SMELL ANTIFREEZE WHEN GETTING OUT OF VEHICLE. THE ANTIFREEZE WAS LEAKING IN THREE PLACES. VEHICLE HAD THE ORIGINAL PARTS. THE CONSUMER WAS THE SECOND OWNER OF THE VEHICLE. HAD NOT CONTACTED THE MANUFACTURER. DID HAVE SOMEONE LOOK AT VEHICLE , WHO CONFIRMED THAT THE INTAKE MANIFOLD WAS PLASTIC AND VEHICLE WAS LEAKING ANTIFREEZE, AND THAT THE O RINGS NEEDED TO BE REPLACED. MANUFACTURER WAS AWARE OF THIS PROBLEM. THE CONSUMER FOUND ON THE INTERNET THAT A TECHNICAL SERVICE BULLETINS WAS SENT OUT ON FEBRUARY 2, 2002 DISCUSSING THIS PROBLEM. HOWEVER, THE CONSUMER WAS UNAWARE OF THE TECHNICAL SERVICE BULLETIN. *AK

UPPER INTAKE MANIFOLD ON MY 1997 4.6 L THUNDERBIRD CRACKED AND BLEW ALL THE COOLANT INTO THE ENGINE COMPARTMENT. I HAD TO PAY FORD TO REPLACE THE UPPER INTAKE AND THE PLUGS THAT WERE FOULED OUT. THEY REFUSED ANY RESPONSIBILITY EVEN WITH A FORMAL WRITTEN COMPLAINT TO THEIR HOME OFFICE. IT IS MY UNDERSTANDING THIS IS HAPPENING TO A LOT OF THEIR 4.6 L ENGINES IN A VARIETY OF VEHICLES.*JB

HEADLIGHT LENSES ON 1997 THUNDERBIRD CLOUD OVER DUE TO WEATHERING AND LIMIT AMOUNT OF LIGHT EMITTED. NIGHT VISION AND OBJECT ILLUMINATION IS SERIOUSLY COMPROMISED. VIGOROUS POLISHING TEMPORARILY REMOVES HAZE, BUT IT HAS BEEN MY EXPERIENCE THAT THE CONDITION RETURNS MORE QUICKLY. I RECENTLY HAD TO SWERVE INTO A LARGE POT HOLE TO AVOID A CITY RECYCLE CAN THAT HAD OVERTURNED AND, BEING DARK GREEN, IMPOSSIBLE TO SEE AT NIGHT. I DAMAGED MY LEFT FRONT WHEEL. *AK

DT: THE CONSUMER STATED A YEAR AGO WA SINVOLVED IN 2 REAR END COLLISIONS WHILE DRIVING 3 MPH. THIS HAPPENED WITH FOOT ON THE BRAKE IN BUMPER TO BUMPER TRAFFIC. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, BUT IT WAS NOT LOOKED AT, THEY INSTEAD TRIED TO SELL CONSUMER ANOTHER VEHICLE. PLANNED TO HAVE THE VEHICLE INSPECTED AT CONSUMER'S OWN EXPENSE AT ANOTHER MECHANIC. DEALERSHIP STATED THEY KNEW THAT THE PROBLEM EXISTED. . THE MANUFACTURER TOLD HE WOULD HAVE TO HAVE THE PROBLEM DIAGNOSED, BUT THE DEALERSHIP WOULD NOT LOOK AT THE VEHICLE. WHEN THE VEHICLE WAS FIRST PURCHASED,IT WOULD DRAG BETWEEN GEARS. IN THE LAST YEAR, NOTICED SURGING. HAD TO PUT THE VEHICLE IN NEUTRAL TO STOP, AND ANOTHER TIMEHAD TO PUT ON THE EMERGENCY BRAKEON. THERE WERE NO POLICE REPORTS TAKEN, THERE WASNO DAMAGE OR INJURIES.*AK

TO WHOM IT MAY CONCERN! MY 1997 FORD THUNDERBIRD IS NOT LISTED WHY? I HAVE A LOT OF PROBLEMS WITH THE SMOG STUFF EVERY YEAR I PAY A LOT OF MONEY. WHEN TEMPERATURES ARE HOT OUTSIDE OVER 90 THE ENGINE LIGHT COMES ON AND SAYS SERVICE ENGINE, OR WHEN I GO UP A LONG HILL AND MY CAR OVERHEATS THE ENGINE LIGHT COMES ON AND SAYS SERVICE ENGINE AND IT IS ALWAYS ABOUT AN OXYGEN SENSOR OR OTHER SMOG RELATED ITEMS THAT ALWAYS COST $300 TO $650 I AM GOING B BROKE BEING ON A FIXED INCOME. FORD CAN'T FIX MY FRONT END VIBRATION I HAD ALL ALIGNMENTS DONE WHEEL BALANCING 4 TIMES NOTHING HELPS. MY STEERING WHEEL VIBRATES ALSO. PLEASE HELP! MANFRED GAUER . *JB

WHILE DRIVING APPROXIMATELY 40 MPH CONSUMER HEARD A NOISE, THEN WATER SPILLED FROM THE ENGINE. VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE, AND IT WAS DETERMINED THAT INTAKE MANIFOLD CRACKED. *AK

CONSUMER'S VEHICLE WAS HIT FROM THE REAR WHILE DRIVING, AND THIS CAUSED THE DRIVER TO LOSE CONTROL OF THE VEHICLE, AND IT CRASHED INTO THE CONCRETE BARRIER. VEHICLE FLIPPED INTO A DITCH. UPON IMPACT, BOTH AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED INJURIES, AND WAS TRANSPORTED BY AMBULANCE TO A HOSPITAL. VEHICLE WAS TOWED ANDS TOTALED BY THE INSURANCE COMPANY.*AK THE CONSUMERS VEHICLE WAS HIT IN THE FRONT WHILE PARKED OFF THE ROAD. UPDATED 02/28/06

VEHICLE WOULD NOT HOLD ANY RADIATOR FLUID,CAUSING THE TEMPERATURE GAUGE TO RISE. TRIED TO REFILL THE RADIATOR FLUID, BUT 5 MINUTES LATER IT RAN OUT. COULD NOT DRIVE VEHICLE. TOOK THE VEHICLE TO MY MECHANIC,WHO TOLD ME THAT THE INTAKE MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. HE REPLACED THE INTAKE MANIFOLD,SO THE I WOULD BE ABLE TO DRIVE THE VEHICLE.

ENGINE FRONT COVER GASKET FAILED IN LINE WITH RECALL 99B29. FORD DOES NOT INCLUDE MY CAR BUILT 04/97 IN RECALL CAMPAIGN 99B29 INDICATING THE ORIGINAL RECALL HAS BEEN INADEQUATE. *AK

THE INTAKE MANIFOLD CRACKED, LOSS OF ALL ANTIFREEZE AND VEHICLE BEING TOWED TO DEALERSHIP. VEHICLE ONLY HAS 60,000 MILES ON. THE LETTER FROM FORD TO REPLACE THIS EXPIRED IN MAY 2004! I HAD COMPLAINED TO MY DEALERSHIP ABOUT LOSS OF ANTIFREEZE, GAS, THEY FOUND NO PROBLEMS. OF COURSE, NOW I HAVE TO PAY FOR THE ENTIRE REPAIR. EVEN THOUGH I SEE THAT MANY T-BIRD OWNERS ARE HAVING THE EXACT PROBLEM. THIS SHOULD HAVE BEEN A MANDATORY RECALL FROM FORD. BECAUSE EXISTING PROBLEMS ARE BEING REPORTED!*AK

THE INTAKE MANIFOLD WAS DEFECTIVE. ALL OF THE COOLANT LEAKED AND SUBSEQUENTLY THE VEHICLE WAS TOWED. THE DEALER STATED THE DEFECT WAS OUTSIDE OF THE SEVEN YEARS OF THE ORIGINAL RECALL. *JB

CRACKED INTAKE ON MY 97 T BIRD. *JB

ENGINE MANIFOLD CRACKED ALLOWING ANTIFREEZE TO ESCAPE. TOOK CAR FOR REPAIR. LEARNED LATER THAT REPAIR WAS A RECALL. ASKED FORD FOR REIMBURSEMENT. REIMBURSMENT DENIED.*AK

INQUIRY REGARDING LATCH LOCKING IN THE DRIVER AND BACK SEAT OF 1997 FORD THUNDERBIRD.*MR THE PASSENGER SIDE FRONT SEAT LATCH WILL NOT REMAIN LOCKED WHEN THE SEAT WAS IN AN UPRIGHT POSITION. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THERE WAS NOTING WRONG WITH SEAT. THE VEHICLE WAS TAKEN TO A COLLISION SPECIALIST WHO WELDED THE RECLINER AND INSIDE SEAT TRACK PIVOT TO KEEP THE SEAT BACK IN THE POSITION THE CUSTOMER REQUESTED. *NM

WHILE REVERSING OUT OF THE GARAGE VEHICLE SUDDENLY ACCELERATED TO THE MAXIMUM SPEED. CONSUMER'S FOOT WAS DEPRESSED ON THE BRAKE PEDAL WHEN THIS OCCURRED. CONSUMER IMMEDIATELY TURNED THE IGNITION OFF, AND REMOVED THE KEY FROM THE IGNITION. VEHICLE STOPPED AND ROLLED INTO THE GATE. THE GARAGE HAD A 33 FEET LONG SKID MARK ON THE GROUND. DEALERSHIP HAS BEEN CONTACTED. *AK *LA

I AM THE ORIGINAL OWNER OF A 1997 FORD THUNDER BIRD WITH THE 4.6 ENGINE. THE INTAKE MANIFOLD IS CRACKED . I HAVE BEEN INFORMED THIS IS A RECALLED PART ON SOME CARS BUT IT SEEMS MY CAR IS NOT INCLUDED IN THE RECALL. THE ORIGINAL REPAIR PART IS NOT AVAILABLE ANY LONG DO TO THE FLAW. SINCE THIS IS THE CASE IT WOUD SEEM TO ME ALL VEHICLES WITH THIS INTAKE MANIFOLD WOULD BE INCLUDED IN THE RECALL. *AK

I WAS DRIVING MY CAR TO PAY THE POWER BILL. I HAD MADE A COMPLETE STOP AND THEN TURNED LEFT UP THE ROAD ABOUT 4/10'S OF A MILE WHEN I PULLED INTO THE PARKING SPACE I NOTICED WHITE STEAM COMING FROM THE ENGINE COMPARTMENT. I OPENED THE HOOD A THE ENGINE WAS COVERED IN ANTIFREEZE. I CALLED FOR A TOW HOPING IT WAS A BLOWN HOSE OR AT WORST A HEAD GASKET. SO I DIDN'T DRIVE IT FURTHER TO PREVENT FURTHER DAMAGE. THE DEALERSHIP LOOKS AT IT AND SAYS IT IS A CRACKED INTAKE MANIFOLD. WHICH LEADS TO A $1135 BILL FOR PARTS AND LABOR. SOME ONLINE RESEARCH BROUGHT A CONCERN...IS THE INTAKE MANIFOLD PLASTIC? IF SO, WHY!? *NM

REQUEST FOR REIMBURSEMENT FOR REPLACEMENT OF THE INTAKE MANIFOLD. *MR THE CONSUMER WAS TOLD THAT THE MANIFOLD WOULD ONLY BE REPLACED UPON FAILURE. THE VEHICLE HAD BEEN LOSING ANTIFREEZE. EACH TIME THE VEHICLE WAS TAKEN TO THE DEALER, HE WAS TOLD THAT EVERYTHING WAS FINE. THE MANIFOLD FINALLY FAILED AND WAS OUT OF WARRANTY. THE DEALER WOULD NOT HONOR THE OPEN RECALL. THE CHECK ENGINE LIGHT WAS INTERMITTENT DUE TO A BAD SENSOR. *SC *JB

INTAKE MANIFOLD LEAKS. CONSUMER HAS TO PUT COOLANT IN THE VEHICLE EVERY 2 TO 3 DAYS. *AK

INTAKE MONIFOLD FAILED TO CONTAIN 220 DEGREE F ENGINE COOLANT. *AK

I HAD TO REPLACE THE COOLANT INLET MANIFOLD ON MY 1997 FORD THUNDERBIRD. THIS SHOULD HAVE BEEN COVERED BY FORD RECALL #97M91 BUT FOR SOME REASON FORD HAS EXCLUDED MY VIN NO. FROM THE RECALL. THIS PROBLEM WAS CLEARLY CAUSED BY A DEFECTIVE PART AND WAS REPLACED WITH AN "UPGRADED" PART.*AK

1997 FORD THUNDERBIRD WITH A 4.6 LITER OHC ENGINE THAT HAS A CRACKED INTAKE MANIFOLD. THE ENGINE HAS 81,000 MILES AND THE PLASTIC INTAKE MANIFOLD CRACKED AND LEAKED ANTIFREEZE ALL OVER THE ENGINE. THE REPLACEMENT PART COSTS $541.00 FROM THE LOCAL FORD DEALER, AND THE LABOR TO REPLACE WILL COST AROUND $550. THE REPLACEMENT PART IS MADE OUT OF PLASTIC EXCEPT FOR THE PART THAT IS CRACKED (THERMOSTAT HOUSING) WHICH IS MADE OUT OF ALUMINUM. FORD KNOWS THERE IS A PROBLEM WITH THE PLASTIC INTAKE MANIFOLD, AND HAS HAD A RECALL ON ON CERTAIN MODEL 4.6L ENGINES. UNFORTUNATELY, I WAS INFORMED BY FORD TODAY THAT MY 1997 FORD THUNDERBIRD WITH A 4.6L ENGINE IS NOT COVERED BECAUSE THE ENGINEERS AT FORD MOTOR COMPANY HAVE NOT INCLUDED THE SERIAL NUMBER (VIN) FOR MY THUNDERBIRD IN THEIR RECALLS. SURPRISINGLY, THE PART THAT IS DEFECTIVE IN MY CAR AND WILL COST OVER $1000 TO REPAIR IS NOT COVERED UNDER THEIR RECALL/WARRANTY PROGRAM. THIS PART IS THE EXACT SAME PART THAT IS INSTALLED IN ALL OF THE OTHER VEHICLES THAT ARE ALLOWED A REPLACEMENT/RECALL. DUE TO MY ROTTEN LUCK, MY CAR'S VIN HAS NOT BEEN INCLUDED UNFORTUNATELY. SINCE THE REPLACEMENT PART HAS REPLACED THE PLASTIC THERMOSTAT HOUSING WITH ALUMINUM, IT IS CLEAR TO ME THAT SOMEONE AT FORD MOTOR COMPANY RECOGNIZES A DESIGN FLAW IN THE ORIGINAL PLASTIC INTAKE MANIFOLD. PLEASE ADVISE ME OF ANYTHING THAT YOU CAN DO TO HELP RESOLVE THIS PROBLEM. THANK YOU FOR PROVIDING A RESOURCE TO EXPOSE THESE TYPES OF PROBLEMS. WES HARDIN. *AK

WHILE DRIVING, THE BRAKES GOT STIFF. WHEN MAKING A TURN, THE TIE RODS SNAPPED OFF. THE VEHICLE WAS TAKEN TO THE DEALER WHICH FOUND A CRACK IN THE MASTER CYLINDER. THE MASTER CYLINDER ALONG WITH OTHER PARTS WERE REPLACED. PLEASE PROVIDE FURTHER DETAILS. *PH

A LEAKING FUEL LINE ON MY 1997 FORD THUNDERBIRD, (V6 ENGINE), WITH 113000 MILES ON THE CAR. I HAD THE CAR TOWED TO A FORD DEALER WHO SUGGESTED REPLACING COMPLETELY BOTH FUEL LINES, BECAUSE THERE SEEMED TO BE CORROSION, SO THAT WAS DONE AT A COST TO ME OF $548. AS FAR AS I KNOW THIS CAR HAS NEVER BEEN IN ANY ACCIDENTS, ALTHOUGH I BOUGHT THE CAR USED A FEW YEARS AGO. LUCKILY I NOTICED FUEL LEAKING FROM THE FUEL LINE, AND THEN HAD THE CAR TOWED BY AAA TO THE FORD DEALER. SO NO FIRE OCCURRED. THE CAR BEING JUST 6 YEARS OLD, I AM SURPRISED THAT THERE WOULD BE A LEAKING FUEL LINE. APPARENTLY CORROSION RESULTED IN THE FUEL LINE LEAKING UNDERNEATH THE CAR NEAR THE GAS TANK. *AK

THE HOOD OF MY CAR INADVERTENTLY COMES OPENS. IT DOES NOT COME COMPLETELY OPEN BECAUSE OF THE SAFETY LATCH. I AM VERY CAREFUL TO MAKE SURE IT IS SECURELY CLOSED AFTER I OPEN IT. I BELIEVE THIS CAN BE VERY DANGEROUS IF THE HOOD SHOULD COME ALL THE WAY UP WHILE I AM DRIVING. *LA

PROBLEM WITH THE TRANSMISSION OR TORQUE CONVERTER. *PH THE CONSUMER WAS TOLD THAT THE VEHICLE WAS EXPERIENCING TRANSMISSION SHUDDER OR A PROBLEM WITH THE TORQUE CONVERTER. *NLM

WHILE DRIVING VEHICLE STARTED TO MISFIRE AND STALL. INTAKE MANIFOLD CRACKED AND LEAKED ANTI FREEZE WHICH CAUSED THE PROBLEM. MANUFACTURER HAD AN OWNER NOTIFICATION ON THIS ISSUE TO REPLACE THE PLASTIC INTAKE MANIFOLD, BUT THIS VEHICLE NOT COVERED FOR TWO MONTHS DUE TO VIN. *AK

ENGINE DEVELOPED A COOLANT LEAK DUE TO A SPLIT IN THE PLASTIC INTAKE MANIFOLD. RECALL 97M91 WHICH IS ONLY GOOD FOR 7 YEARS FROM THE START OF THE ORIGINAL WARRANTY WAS UP 2 DAYS PRIOR TO INCIDENT. FOMOCO AND DEALER WOULDN'T COVER, TO BAD FOR ME. RECALL DOESN'T COVER REPLACEMENT UNLESS IT IS LEAKING WITHIN THAT 7 YEARS. DESIGN HAS BEEN CHANGED TO AN ALUMINUM CROSSOVER THAT HOPEFULLY WONT SPLIT AND COSTS APPROX $800 TO FIX. *JB

CONSUMER COMPLAINED ABOUT HAVING FUEL LINE PROBLEMS. THE FUEL LINE THAT COMES OUT OF THE GAS TANK AND RUBS AGAINST THE BODY OF THE VEHICLE LEAKS GAS UNDER THE VEHICLE GOING IN THE DIRECTION OF THE ENGINE. MANUFACTURER WAS CONTACTED, AND STATED THAT THEY WERE AWARE OF THE PROBLEM, BUT THERE WAS NOTHING THEY COULD DO. DEALER WAS CONTACTED, AND FIXED THE PROBLEM BY REMOVING THE WHOLE FUEL LINE SYSTEM AND REPLACING IT.*AK