2022 Ford F-150 complaints

The slip yoke on the driveshaft was under-lubricated from the factory. It is an issue that is common to F150 trucks. I believe that the failure of this component could lead to damage to the differential or driveshaft, which, if either component fails, could be a safety issue. My biggest concern is that this issue seems to be fairly common, and I am unsure if it has been investigated to determine if a recall is warranted.

The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, an abnormal fume leaked into the interior of the cabin from the catalytic converter. In addition, upon further inspection, the contact noticed an unknown leak from the exhaust gasket. The contact sustained headaches however medical attention was not sought. The vehicle was taken to a local dealer where it was diagnosed that the suspension, driveshaft, and other unknown repairs were needed. The contact was advised by the local dealer that the failure was related to an unknown TSB. The vehicle was repaired however, the failures reoccurred. The manufacturer was made aware of the failure. The failure mileage was approximately 30,000.

Factory LED day light running lamps on driver and passenger head lights went out and there is no way to replace them without changing out the entire headlight assembly.

My vehicle had a wiper motor recall that came out when I bought it. I had to wait 2 years for parts and I had it done in May of this year. Vehicle harldy sees any rain so the wipers have only been used a few times since then. Well today I was driving and it started to rain and the wipers wouldn't turn on. What's the point of a recall if they are just going to install more defective parts. Sad part is the original wiper motor worked with no problems. Also this engine has cylinder deactivation on it and is operating when it isn't suppose to. So if I'm accelerating from a dead stop it turns on cylinder deactivation and I loose power and acceleration. The ford dealers and ford customer service people don't care I have an unsafe vehicle.

I have a 2022 F-150 STX 4x4 with 47000 miles. It has been making a strange creaking/clicking/popping noise from the rear diff/axles when slowing to a stopped position and when accelerating from a stopped position. It is present during all drives. I am concerned that it within the drivetrain which gives me concern that it could cause to the vehicle and or passengers.

I have a 2022 Ford F-150 Platinum with B&O Sound system. Yesterday, while driving I experienced a loud boom followed by loud staticky crackling sounds coming from the sound system. I thought I had been hit by another vehicle or somebody had thrown something at the car. I stopped immediately to see if glass was broken and got out of vehicle for fear it was going to burn or blow up. The crackling sound continued even after turning off the sound system and turning off the vehicle. The crackling continued for approximately 30 minutes. This morning, I started the car and the crackling sound was not present. This is a safety issue because it caused me to be alarmed and behave in abrupt manner to get out of the car, and may have even caused hearing damage.

This complaint is concerning the recall 22C22 for the 2022 Ford F150 park lamps flickering, I took my vehicle in for service to get this recall performed because the recall was open, when I picked up my vehicle I was told that the recall had just been put on hold by Ford, this was around August 15, 2024. I was also told that I would be contacted by them, the dealership/service advisor when the recall was open again, this has not happened, its been several weeks and I have not heard anything back, I have called Ford and also done a live chat with them over my Ford Pass app and still have no answers. The park lamps continue to flicker to the point that one of the headlights is beginning to fail, the LED DRL are very dim or just don't light up at all anymore, these are the same lights that flicker so much and so often that they look like strobe lights, Ford is saying that this is unrelated which I firmly believe it's not accurate, the excessive flickering very likely caused the lights to fail. Now they want me to take it in to them and get it diagnosed and to replace the headlight assembly which cost well over $1200 dollars just for the part. They have failed to address the actual cause of the problem to begin with. LED park lamps should not fail on a 2 year old vehicle, in most cases LED light should last years and possibly even the life of the vehicle. I am a Master Technician for a major automotive brand and also ASE certified with over 30 years of experience and I firmly bel

When driving the vehicle shut off power for 5sec but doesn’t shut off vehicle (all electrical off ) then kick back on ,idling high

The display becomes unresponsive randomly and driver cannot use camera to reverse the vehicle until vehicle is completed turned off, locked and unlock it and start again. This creates a safety hazard in the middle of reversing vehicle and also creates a confusion while using navigation.

The contact owns a 2022 Ford F-150. The contact stated while operating the vehicle, the check engine warning light had remained illuminated, and the vehicle would not properly accelerate while depressing the accelerator pedal. Additionally, while driving at various speeds, the transmission unexpectedly downshifted. The vehicle was taken to the local dealer who reprogrammed the PCM, but the failure persisted. The contact also stated that while the vehicle was parked, the vehicle rolled. The failure had occurred with the engine running and with the vehicle turned off. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 70,000.

See attached document for complaint.

While driving A/C unit will slowly stop blowing cold air. It is very random when this happens and the vehicle has to sit a for a while before it starts working again. Vehicle was purchase in August 2023 and the issue did not start until about 2 months ago and has now happened 4 times. First time I drover for hours before it happened, this last time I was only driving for 20 minutes. I think this is related to the Ford TBS 22-2089. I am just over the 36,000 mile Warranty, but under the 3 year Ford Warranty, so I will probably have to pay for this out of pocket. This should be a recall for affected vehicles as this is a very expensive fix to have on a 2 year old truck that was no fault of the owners.

The vents stop pushing air, regardless of setting, so windshield defroster does not work to clear the windshield of fog. Happens while driving and no adjustments to climate control change airflow unless I turn the car off and back on. Occurs infrequently and without clear cause. Dealership failed to reproduce the problem when I took it in.

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was not available.

The contact owns a 2022 Ford F-150. The contact stated that the vent clips had detached from all the air vents. The vehicle had been taken to the dealer where the clips had been replaced under warranty; however, the failure occurred. The contact stated that the failure would occur in warmer weather. The vehicle was returned to the dealer; however, the vehicle was not repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not under recall for the failure or covered under warranty. The manufacturer had referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 15,000.

This complaint was already documented here: NHTSA ID Number: 11487857 Turned my truck on to hear a LOUD pop, scared everyone inside. Speakers continued to crackle and pop, at a lower volume. No audio or music played. Thinking it would go away, I continued out of our neighborhood. When it didn't, I stopped and turned the truck off, as well as locking the vehicle, with the same crackling noise coming from the speakers despite everything being shut off. Turned the truck back on and went through audio settings. The only thing that made it stop was switching from "Stereo" to "Surround" mode in the settings.

The front of the truck started smoking when it was pulled over at a gas station on 07/26/2024, the hood was too hot to open, and the front of the truck proceeded to start on fire. It took the fire department 20 minutes to arrive on the scene at which point there was not much left of the front of the truck. Everyone was able to get out of the vehicle and no injuries occurred. The truck is obviously totaled, but we are unaware as what caused this truck to blow up.

Fresh air intake cowling allows small debris to build up and does not allow consumer ability to clean/service it. This results in water backing up and spilling to AC filter and blower motor, thus leaking into passenger side of cab. Dealer and Ford state this is a non-warrantable item, and that the consumer should be aware to maintain it themselves despite being able to. Dealership also does not clean this during routine service, nor notify the consumer about it condition.

The attached document will explain in details about the back up failing on multiple occasions and Ford Motor Company has no fixes for this at this time. It is a SAFETY concern due to the back up camera with small children around. This is the third APIM module since Jan 2024. Now Ford says tells their dealers not to do anything with them to wait until around October or November and they will send out another bulletin on how to handle this problem. Then once that is done who knows how long it take. Big Safety issue here. F150 is the number one selling truck on the road as Ford says so that makes this even a bigger issue.

This morning, as soon as I started the vehicle and started backing down the driveway, an unbelievably loud popping sound emitted from the speakers. I immediately slammed on the brakes having no idea what had just happened. This has happened previously but have not heard in a few months so I thought the problem was corrected. It is the loudest noise I have ever experienced and is extremely dangerous as it happens at different times and is just ear splitting. My ears are still ringing and it happened at 8:45am this morning.

The computer/s that control every piece of equipment does not function as designed! The cruise control adjusted the speed (upward) without touching the controls. The lane keeping function will drag the truck into a turnout lane, left or right especially on a two lane highway with turn out lanes. The windshield wiper control has to be constantly manipulated to keep the windshield clean during snow and or rain storms. The instrument panel constantly changes which distracts the driver as so does the computer screen. The pre collision equipment works only sometimes. All the computers installed affect the function of other computers which causes driver distraction, like txt and driving.

Rear end differential bearing failure, second time. Result in high vibration and substantial metal flacks in differential oil. Ford reporting rebuild is required again.

The contact owns a 2022 Ford F-150. The contact stated while driving at various speeds on several occasions, the transmission would only shift from first through fourth gear and the vehicle was hesitating. There were no warning lights illuminated. The vehicle was taken to a dealer where it was diagnosed that the TCM software update needed to be performed. The vehicle was repaired but the failure persisted. The vehicle was taken to another dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired but the failure persisted in second gear. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 9,271.

Cover for transmission/exhaust/engine on underside of vehicle tears at mount pint and hangs down and could completly tear away causing potential vehicle damge or damage to other vehicles on road. Problem is noted on internet forums as Ford's saggy diaper problem. Cover is made of a non durable foam-fabric material and is mounted by 4 screws and tears away by mount points and hangs down. This is 2nd time happening on truck, first time was replaced under warranty. Picutre is taken after I pushed it back into place but is still torn by mounting bolt and hangs down when driving. I ordered a replacement from Amazon for $99.99 and will attempt to repair myself.

The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle independently decelerated. The contact stated that the transmission shifted from 10th gear to 5th gear unexpectedly. The vehicle was taken to the dealer where it was diagnosed with a failed CDF drum assembly. The contact was informed that the CDF drum assembly needed to be replaced. The contact stated that the failure reoccurred. The contact stated while driving 80 MPH, the vehicle decelerated independently. The contact stated that the transmission shifted from 10th gear to 5th gear unexpectedly. In addition, the contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer; however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 27,882.

Since I have purchased the 2022 Ford F-150 I have had several incidents where the cruise control has set itself. A couple incidents have resulted in me slamming on the brakes to avoid collision. I have taken it to the dealer a few times and they have replaced everything that has to do with the cruise control and it still sets itself from time to time but it's sporadic. The dash lights/instrument cluster has went completely out 2-3 time and came back on. When it does come back on the drive mode disabled light is on and I can't change the drive modes. The entertainment/map screen has froze up several time. The map will freeze and I can't change the music or do anything on the screen.

Starting at roughly 2000 on the odometer the truck began shifting very harshly, missing gears, slipping gears, lurching forward during shifts. Upon acceleration through the first four or so gears, there is a very loud "thunking" sound presumably upon shift. There have been 4-5 times I was turning across traffic at a safe distance, and the truck would not accelerate, missing several gears. I was almost hit hard several times because of the truck failing to drive. Dealership turned me away 3 times, saying they would not be able to diagnose anything without a CEL code. Since the truck doesn't throw any fault codes they would not take it in for troubleshooting or attempt to reproduce the issue. The issues were reproduced by a local shop I took the truck to for a third party opinion. The loud thunk was thought to be too low a lubricant level on the slip yoke where the drive shaft meets the transmission. The shop checked and there was sufficient lubricant. They reproduced the thunk sound driving slowly with several technicians witnessing the issue standing within sight distance. These known and reproducible issues with the 10R80 transmission and there have been an exorbitant number of reports of this behavior in owner message groups, all with the same lack of resolution. Dealerships either don't fix the issue, won't troubleshoot without a CEL code, or say the transmission is working as designed.

The wheel wells on the front of my vehicle do not properly fit the well. One has been replaced twice the other once and recently the dealer made the decision to cut the wheel wells so they would no longer rub. I was told it was the best they could do. The other choice is to keep replacing them when they fail. I am concerned that somthing from the road may fly up in their and get lodged in the exposed under section. I feel there should be another alternative but Ford doesn't want to pay to get a resolution. If those well covers were not needed they wouldn't have them n their in the 1st place. So I know they are needed.

Vehicle lost power while driving on highway requiring vehicle to be guided to shoulder. Once on shoulder, truck died and would not restart. After being towed to dealership, the vehicle was found to have a failed fuel pump. At the time of the incident, vehicle had 27671 miles on odometer.

Weatherstripping on sunroof is deteriorating. This could affect the safety of the driver as well as any passengers in the vehicle if it was to start leaking. Furthermore, if water entered the cabin it could affect any electrical components that might interfere with the driving of the vehicle thus causing a safety hazard to any vehicles that would be nearby if this was to happen. The vehicle was taken to the local Ford dealership on 5/29/2024 for inspection. The repair was denied because the whole sunroof would need to be replaced in order to fix the weatherstripping. No one else has looked at the weatherstripping. It was first noticed on 5/24/2024.

Ear-splitting static-like noise upon starting the truck. Followed by loud static that would persist even when audio was turned off. Extremely distracting while driving. Took to dealer who said nothing to be done until Ford figures out a fix. Told me to keep checking back. No warning lamps or messages. I wish Ford to put a higher priority on fixing this issue. 2022 F150.

Engine shut down while traveling down a mountain with a 4.8% grade at 50 mph; the transmission was in 3rd gear to contain the speed with no pressure on the brakes. There was an initial chime as when the vehicle is first turned ON, followed by the wipers traveling halfway up the windshield, all screens went completely dark as if the vehicles key had also been turned OFF. Brakes were initially soft and then on subsequent push came back. Vehicle went through it's normal power up cycle and then engine restarted as I was still traveling at a good speed down the mountain. The engine has shut off on it's own before with all screens going dark while sitting at stop lights. To get it restarted I had to put the vehicle in park, press the brake and push the start button. I assumed this issue was with the auto start/stop feature and now always drive with it selected off. I've never had this issue with it off. This was the first time the issue happened while the truck was in gear and moving. The auto Start/Stop feature was ON. For previous issues I've had the Ford dealership check it and no error codes or issues were found.

The contact owns a 2022 Ford F-150. The contact stated that the driver's side headlight was flickering while driving. The vehicle was taken to the dealer several times, where the failure could not be replicated. The contact stated that the failure persisted. The vehicle was taken to the dealer, where the contact was informed that the failure was related to NHTSA Campaign Number: 23V802000 (Exterior Lighting); however, the VIN was not included. The vehicle was not diagnosed or repaired. The contact was referred to the manufacturer for assistance. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 4,500.

The contact owns a 2022 Ford F-150. The contact stated while driving at approximately 35 MPH the vehicle independently braked. The contact lost control of the vehicle and due to road conditions the vehicle jumped the curb. The contact stated that he was not aware of any warning lights. The contact stated that the front passenger tire crashed into the curb and blew out. The contact stated that the vehicle hit a traffic sign and then a fence. The contact stated that the passenger front door had scrapes and marks. The side view mirror on the passenger side was sheared off by the traffic sign. The contact stated that the police and EMS arrived. The contact stated that no air bags had been deployed. The contact stated his daughter was seated in the passenger front seat and had abrasions and bruising on her neck, right shoulder, and chest from the seat belt. The contact stated that he also had bruising on his neck and left shoulder from the seat belt. The contact stated that both he and his daughter had neck and back pain and were both transported by ambulance to the hospital. The contact stated that the police issued him a citation for "careless driving" but no report was issued. The vehicle was towed to a collision repair shop. The contact stated that he had received a recall notification from the manufacturer for NHTSA Campaign Number: 23V509000 (Parking Brake), however, the crash had occurred before him receiving the recall letter. The vehicle was still at the collision repair

A/C and hvac system does not work properly. On lowest setting you have somewhat cool air and once you turn dial to 60 degrees it’s heat. This is unsafe because I can not regulate the temperature in vehicle correctly whatsoever and trying to defrost windows is also a nightmare. The air conditioning is also not even cold enough on its lowest setting. Multiple people are having same issues with 2022-2023 f150s

Throwing an Active Air Dam fault, I noticed this was an issue with the F150 Lightning. However it is also doing it on the gas 2022 F150.

When starting from a stop, with my 2022 Ford F150 FX4 in drive, sometimes the parking brake will automatically turn on without me activating it while driving. This causes my truck to skid to a halt and I have to manually disengage the parking brake to resume driving. I am concerned about the increased risk for harm to myself or others from a collision due to the unintended stopping. I don't know if the brake lights turn on or not when this happens either, but the vehicle remains in drive and the red park brake active light comes on (lower right corner of the instrument cluster). The local Ford dealership has had the truck in twice for this condition, but they have said they cannot reproduce the problem. I have recorded a video of it happening and sent it to Ford. The recall on my truck having to do with the parking brake that was issued September 2023 has been repaired by the local Ford dealership as of October 2023, but this is still occuring. No advanced warning is given when this occures. It is sudden, and seemingly random, but so far has only occurred when starting from a stop. Other potentially useful information: This has occurred with my vehicle 6 times in the last two weeks with today being the most recent. I have auto hold turned ON. I set the parking brake when I am parked in my driveway. I turn right from my driveway in the mornings. Most of the occurrences of this have been on a slope, but one occurrence has occurred on level ground. Ford has not found an answer f

When moving from Park to Drive, vehicle surges forward at full throttle. I have had the truck for 18 months and it has happened 4 times over the past 18 months and has been witnessed by a passenger.

The contact owns a 2022 Ford F-150. The contact stated while operating the vehicle, the transmission made a loud clunking sound, and the vehicle was jolting while down-shifting from fourth gear through first. The cause of the failure was not yet determined. The manufacturer and local dealer were not notified of the failure. The contact was concerned that the failure was related to a "Max Towing" feature added to the vehicle. No other information was available. The failure mileage was 13,000.

Bluetooth connects with loud static and does not allow hands free cell phone usage. Also, navigation screen freezes while using GPS.

Failure: Total loss of brakes, hard pedal, no airbags deployed, at estimated speed between 5 and 10 mph. Safety concern: Total loss of ability to slow down, stop or avoid impact. Crashed into a shop wall as a dealership technician with the brake lamps evidently applied before and after the impact. Reproduced: Vehicle in for ABS related faults on dash, which is why it was being pulled into the Ford dealer by a Senior Master Ford technician. Inspection by others: Not yet, vehicle has been left at impact site per management. No, there were no warnings, chimes, messages or any other symptom or sign to indicate a concern was going to happen.

Transmission has failed/malfunctioned resulting in two separate inspections/repairs by Ford of West Covina, CA. First inspection on [XXX] and mileage in at 8,954. Complaint of harsh downshift in transmission. Service involved the teardown of the transmission found E clutches burnt. Found excessive clutch material in the main control body valves and scored sticking unable to return freely. Performed overhaul. Replaced E clutches and seals. Replaced main control body. Installed new solenoid strategy. Post road test vehicle OK, however the mileage out of shop was 8,952 on [XXX]. Second inspection on [XXX] and mileage in at 11011. Complaint of clunking noise heard when shifting and going into gear. Service found leaking hydraulic circuit. Teardown found CDF cylinder bushings scored and HUB scored rings torn. Found main control body valves scored sticking unable to return freely Performed overhaul replaced seals. Replaced CDF cylinder and HUB. Replaced main control body. Installed new solenoid strategy. Post road test vehicle OK. Mileage out of shop was 11020 on [XXX]. Two days after this service, transmission made very loud clunk and jerking movement when going into gear and continues to have harsh downshift, clunking noises, and jerking movement when going into gear causing the vehicle to jump forward when braking. This action is putting others at risk of injury/death in the event the transmission fails and is unable to change gear. No warning lamps messages or have appeared. Pr

The contact owns a 2022 Ford F-150. The contact stated that while driving at various speeds and turning, there was an abnormal sound coming from the front end. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the integrated wheel end needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 5,000.

The display screen went black. Without it there is no back up camera ( and many other features). This is a king cab long bed. Very dangerous to drive without these important safety features working properly. The dealer says it is a “common problem”. It is a $1500 repair if it were not still under warranty.

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle failed to shift into reverse. The contact stated that the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the vehicle jumped forward and there was an abnormal sound coming from the rear axle. The vehicle was taken to the dealer several times. However only a temporary repair was provided. The failure reoccurred. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 18,000. VIN tool confirms parts not available.

The contact owns a 2022 Ford F-150. The contact stated that the display screen would display black and reboot itself before restarting. In addition, while driving the vehicle the rearview camera image remained on while driving forward. The vehicle was taken to the dealer where it was diagnosed that the APIM (Accessory Protocol Interface Module) needed to be replaced for the third time. The vehicle was not repaired. The manufacturer was made aware of the failure and two cases were opened. The failure mileage was approximately 27,275.

Loud, oscillating static through speakers when starting vehicle. Measured at 106db. Audio controls non-responsive. Shutting off vehicle and opening door eventually caused it to stop. Resumed again when restarting vehicle. Eventually stopped after letting it sit 30 minutes. This is extremely dangerous. Not only is this a level that can lead to hearing damage, but if this happened while driving, it could easily result in an accident.

Component: The optional "Pro Power Onboard" system reports detecting a ground fault on the center infotainment screen when executing the onboard test function on the same screen or when plugging in a standard electrical outlet tester unit. The outlet tester reports the ground and hot wires are reversed when plugged into any outlet on the vehicle. Safety: My safety has not yet been impacted, however as the system states a ground fault was detected, there is a potential short in the vehicle's electrical systems that could cause damage to more critical components. Reproduced: The first dealership the vehicle was taken to refused to inspect the problem. They plugged devices into the outlets on the vehicle that did not have ground pins on their plugs (a phone charger and a vacuum cleaner) and both operated normally. Inspected: I have an active case file open with the manufacturer to attempt to resolve the issue. The case was opened after the first dealership failed to acknowledge the issue with the vehicle. Other: There were no warning lamps or other messages prior to the problem. The first instance of the message occurred while driving with no outlets were in use. The vehicle does not produce any DTC codes at time of writing.

After a recurring dashboard alert to tell me that front sensors and rear braking were offline, I took the vehicle for warranty repair. The Ford dealer indicated that the repair would cost $519, because it was a wiring failure and not a failure in a part. According to the service advisor, the failure is a common failure that occurs at a tee where the wiring branches to a sensor just behind the rear bumper. He said that it is not covered by Ford's "bumper to bumper" warranty because it's a wiring failure and not a part failure (although the subject wiring harness does carry a Ford part number). Since my 2022 truck had only about 14,000 miles and had been lightly used (no off-road use), I balked at the notion that it should not be Ford's responsibility to replace the wiring harness. I paid only the diagnosis fee ($155) and took the truck home. On investigation, I found the harness and sensor wire he described to be easily accessible and easily damaged by any sort of road debris. I also found the wiring from the harness to the sensor to be unsupported, leading me to conclude that resonance due to normal road vibrations could have led to metal fatigue in the wire. It's my view that Ford's conclusion that this is normal wear and tear on a truck is ludicrous. I expressed this view in a letter to Ford's Consumer Relationship Center, but the response was simply to back the dealer's determination. They did provide the option to seek a second dealer opinion, but my concern is more about

As vehicle is downshifting there is sometimes a slight jerking or hard jerking associated when doing so. This happens a lot also when letting up off of the accelerator or slightly riding the accelerator for example is slow moving traffic. This is a significant jerking, not a smooth jerking when switching gears.