2022 Ford F-150 complaints

I bought a used Ford f-150 from Toyota used care dealership on [XXX]. On [XXX] while vehicle was being driven on [XXX], north of Santa Clarita, on the way down to San Diego. I was in the backseat, my friend who was the driver notified me. That we had to pull over and check because he was noticing smoke, then we pulled over and the truck was leaking a fluid that was on fire for about 20 minutes. We had exited the vehicle, called 911, the fire then stopped after about 20 minutes. The fire department came and then put out a small fire within the truck. We then had to wait on the side of the rode for 5 hours waiting for a tow truck to pull the truck. I got the truck towed to a ford service center because the truck still had new vehicle manufacturer warranty with Ford. The truck was given full warranty and Ford covered the damages and fixed the vehicle giving it the green light in there service report. I then waited until March 4th 2025 to receive my truck back. On [XXX], the truck was being driven down southband the [XXX], on the [XXX], again due to smoke and also hearing a loud banging, my friends had to pull over and the truck is going to be towed to the service center which it was first fixed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Drivers side DRL out causing a safety hazard for other drivers

It was the transmission. It downshifted at a high speed going down the highway. Took it to the dealership and they said they could see it downshifted but had no fix for it or did not know why.

Deafening sound emitted from speakers in vehicle while driving. Events are as follows: Volume stuck on 0 (minimum) changed source from wireless CarPlay Spotify IOS to FM. Popping started. No volume adjustment possible. Source change did not fix. On/off button did not fix. Key cycle with door open did not fix. Several attempts. Audio turns off, but with ignition immediately starts popping. Drove for at least 1 minute to safe spot while the popping/ static continued at max volume. Disconnected negative terminal on battery. The only way to fix the issue. Ears still ringing after two hours.

Still waiting for a fix. Been over a year for a fix but still nothing.

Sudden, loud static and crackling noises emitting from the B/O Unleashed sound system. It was so sudden, loud and startling, I could see it scaring a driver enough to make them panic and cause an accident. I was concerned that it was going to blow the speakers.

The manufacturer has failed to remedy this safety recall for my F-150 vehicle in a timely manner. Ford initially identified the axle bolt fault as Customer Satisfaction Program 22B34 on Feb. 14, 2023 to a limited range of vehicles but then expanded the action as a recall notification 23S65 on Dec. 22, 2023 covering all 2021-2023 trucks with their "Trailer Tow Max Duty package". Based on these dates, Ford has had over 2 years to engineer a solution to this safety recall but has not done so.

There are several issues with the truck, the worst being misfire issues while driving at highway speeds. Several times now I have been on the interstate at speeds and the truck will all of a sudden lose speed and shutter. The engine light will blink, and this will happen for a couple miles and then it goes back to normal. If you pull the codes on the truck, you get P0300, P0301, and P0305. This is in the dealership again now. The previous two times the dealership has done nothing because they can not duplicate the issue, but they do pull the codes.

My F150, like many others that I've read about in the forums, has an issue with the internal cabin temperature. It blows way too hot and isn't adjustable as designed. Clearly, this in itself is not a safety concern and rather an inconvenience that Ford won't seem to figure out and fix. The issue is that when the heat is turned to High (which is meant to be around 85F), it blows out air at around 160F and this can easily burn someone who touches the vents - such as my young kids. Ford needs to resolve this safety (and inconvenient) concern.

This is a 2022 Ford F15 . In 2023 ,at 34000 miles the tranfer case broke down in the middle of the road,waiting at a stop light. The truck needed to be towed. The dealer fixed it under the warranty. In 2024 at 57000 miles ,the same transfer case broke down as i was getting out of my driveway. Again it was towed to the dealer. In Feb 2025 i drove out of state and i observed a white smoke behing me. I stoped at a rest area and discover the the undercarriage is full of oil and the transmission got overheated. When I got back home i saw a lot of oil spots from the trans on my driveway. Now the car is at the dealer again. The worst part is even if I had an appointment 2 weeks later from the date i called, representative told me it will take another 2 weeks to fix the trans! Every time the truck was at the dealer it took 2 weeks to get fixed and every time they told me theyy don’t have a loaner. That is my work truck and i can’t miss 2 weeks of work! I asked the representative what is going on with a car that is still under warranty and the transfer case broke twice in 2 years. The answer was that Ford knows about this problem but they do not have a solution to fix it properly. I asked him what I’m suppose to do after the warranty runs out? Same guy told me that Ford will issue a recall and as long as there is a recall they will fix it with no extra charge but there is no recall on transfer cases from Ford! For a truck that I paid $90000 that is not acceptable. Please let me know m

The contact owns a 2022 Ford F-150. The contact stated that upon entering the vehicle after a rainstorm, there was an excessive amount of water inside the vehicle on and around the front dashboard. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the front windshield bonding agent had failed, resulting in heavy water leaking inside the vehicle. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 22V451000 (Visibility); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 35,000.

The contact owns a 2022 Ford F-150. The contact stated while driving 65 MPH, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact has engaged the “Smith System” to drive the vehicle. On a separate occasion, the vehicle started making a squealing sound. The contact attempted to depress the brake pedal once or twice; however, the brakes failed to respond. The vehicle was then taken to a dealer where it was diagnosed with rear brake failure. The rear brake was rebuilt; however, the failure and the squealing persisted. The vehicle has been taken to the dealer two more times, but the dealer was unable to determine the cause of the failure or duplicate the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 16,917.

The contact owns a 2022 Ford F-150. The contact stated that the power outlets in the front and rear of the vehicle were inoperable. There were no warning lights illuminated. The contact stated that the failure was related to TSB: 24-2020. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact called another local dealer, Summerville Ford (9700 Dorchester Rd, Summerville, SC 29485); but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 40,000.

The contact owns a 2022 Ford F-150. The contact stated while driving at an undisclosed speed, the contact became aware that there was fluid leaking on the passenger's side rear wheel. The vehicle was taken to the dealer where it was diagnosed with a fractured passenger's side rear wheel bolt. The contact was informed that the passenger's side rear wheel bolt needed to be replaced. The vehicle was not repaired. The contact was informed that the parts were not available. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 29,700. VIN tool confirms parts not available.

The contact owns a 2022 Ford F-150. The contact stated that while parking, pulling forward slowly, or reversing, the electric parking brake engaged without application. The brake warning light was illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V509000 (Parking Brake). The vehicle was taken to an independent mechanic who determined that the outer rear brake pads were paper thin, and needed to be replaced. The contact stated that the inner brake pads were brand new. There was premature brake wear on the outer brake pads. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 38,000.

(2022 Ford F150 Supercrew XLT) The sunroof wind deflector screen that pops up when you open the sunroof broke at 75mph and could have caused an accident or killed a motorcyclist. The vehicle only has 38000 miles on it. I observed that the wind screen was attached to the roof by 4 small screws. The product is made of plastic and cannot sustain highway driving. I observed another complain on the internet at 70mph same thing. Mullinex Ford of Apopka Fl is where the vehicle was purchased. I believe the screen should be made of metal to prevent it from breaking. I am terrified of replacing it because I am certain it will break again. website part #fl3z-16500a26-c.

Transmission issue starting at 60,000 miles with minor miss-shifts and hard shifting brought the truck in at 71,000 miles to get looked at after seizing had occurred. Initial incident occurred about two months before I brought the truck in where I put the truck in reverse and it would lock up the transmission, it would do one revolution and stop. We put the truck in drive. It would unload the whole drive train and get stuck. One revolution going forward, proceeded to put the truck in park it would decompress the drivetrain this would happen 3 to 4 times before the transmission would release and allow you to drive normally took the truck into the shop. They opened up the transmission and found that the CFD drum had ruptured causing the transmission to intermittently lock up

Loud noise like bomb went off when started vehicle then static in radio speakers wouldn’t stop. I have a 2022 ford f150 lariat with B&O unleashed speakers. Lots of complaints and told to report this issue. Radio came on next day but scared it will happen again.

The panoramic sunroof on 2022 Ford F150 spontaneously exploded while traveling down a smooth road with no traffic around.

The contact owns a 2022 Ford F-150. The contact stated that while driving on uneven terrain, there was an abnormal clanking sound coming from underneath the vehicle. No warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed that a front shock suspension needed to be replaced. The vehicle was not repaired due to the cost. Upon further investigation, the contact related the failure to an unknown Technical Service Bulletin. The manufacturer was made aware of the failure. The failure mileage was approximately 36,240.

The contact owns a 2022 Ford F-150 Hybrid. The contact stated that after depressing the recirculate button to recycle the air in the vehicle due to allergies, the recirculate system was activated temporarily. The contact stated that allergens were entering the vehicle. The contact stated that the failure caused him to become distracted by allergies and to be distracted while reaching out to the recirculate button again, nearly causing the vehicle to veer off the road. The contact stated that the recirculating system only activated for up to 10 minutes when engaged. The vehicle was taken to the dealer, where the contact was advised that there was no fix for the failure because the recirculating system was operating as designed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 6,000. The VIN was not available.

The contact owns a 2022 Ford F-150. The contact stated that while operating the vehicle, the front low-beam headlights and fog lights turn off and on independently. Additionally, after turning the vehicle off, the fog lights continued flickering off and on. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure and informed the contact that the vehicle was previously repaired under the NHTSA Campaign Number: 22V686000 (EXTERIOR LIGHTING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 40,000.

The contact owns a 2022 Ford F-150. The contact stated that while her husband was attempting to reverse out of the parking spot; while depressing the accelerator pedal, the vehicle failed to accelerate as intended. A warning message "Park brake fault service now" displayed on the instrument panel. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the VIN not being included in any recalls. The contact related the failure to NHTSA Campaign Number: 23V509000 (Parking Brake) however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Passenger side vertical DRL is not working.

DRL lights have gone out at under 3 years.

The contact called on behalf of her husband who drives a 2022 Ford F-150 fleet vehicle owned by his employer. The contact stated that the driver's side front door latch had to be pulled extremely hard to close. The contact stated that when the outside temperature was freezing and it was wet outside, the driver's side front door failed to open as needed. The contact was unable to exit the vehicle due to the door latch being frozen. The contact's husband had to hold the door while driving. Additionally, the contact stated that the vehicle unintendedly shifted from drive into park while her husband was stopped at a traffic light and attempting to close the driver's side front door. Additionally, the driver's side window also failed to roll down in freezing temperatures. The contact's husband had sustained injuries to his left arm while attempting to slam the door closed, but medical attention was not required. The contact’s husband had to crawl over the center console to exit the vehicle. There was no warning lights illuminated. The contact stated that the failure was related to SSM: 50543. The vehicle was taken to the local dealer, where it was diagnosed and determined that the door latch needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 42,113.

Transmission slipped from 4 to 1st while driving almost crashing my truck

The contact owns a 2022 Ford F-150. The contact stated that on several occasions while the vehicle was parked during inclement weather, the driver’s side door failed to open. The contact stated that on one occasion while the vehicle was parked and attempting to exit the vehicle, the driver’s side door failed to open. The contact stated that after the vehicle had warmed up, the door opened as intended. The vehicle was taken to a dealer where it was diagnosed and determined that an unknown part needed to be replaced. The vehicle was repaired but the failure reoccurred. The manufacturer was notified of the failure. The failure mileage was approximately 42,000.

I was driving around 35-40mph, slowing down, heading to a right hand turn lane. No vehicles in front of me. As I crossed over my lane into the turn lane my e-brake automatically came on and my pre collision braking light came on. No warning, nothing caused by me, and I have no clue how it happened. I had to physically pull the e-brake lever to release the brakes on a major road.

Windshield wipers stop working for minutes at a time. Then work and pause off an on half way up the Windshield. The tailgate won't stay up. It will drop open all on its own when driving even when it's locked.

The contact owns a 2022 Ford F-150. The contact stated that the driver’s side daytime running headlight was flickering while driving. The contact stated that the passenger’s side headlight was dim and the driver’s side fog light failed to operate as needed. The dealer was notified about the failure and related the failure to NHTSA Campaign Number: 23V802000 (Exterior Lighting); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 56,000.

The contact owns a 2022 Ford F-150. The contact stated that the underbody heat and noise insulator was slightly detaching from the vehicle coming into contact with the driveshaft. The contact researched Online and found NHTSA Campaign Number: 21V986000 (Power Train, Structure), however, the VIN was not included. The dealer was not contacted. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 37,000.

Daytime running lights failed and are built into the housing, this is a known issue across many F150’s 2021+

The daytime running light on my headlights is an LED strip that completely lost all use. Ford is having us replace the whole headlight unit for their manufacture issue. Ford refuses a fix and says a $1700 replacement headlight unit is the only way to get it fixed. It is their headlight components for the LED daytime running light.

The contact owns a 2022 Ford F-150. The contact stated while entering the vehicle and closing the front driver's door, the rear windshield shattered without impact. The vehicle was not taken to the dealer. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

I am constantly receiving error messages that pop up while driving telling me that there is a headlight system malfunction. I have also had adaptive cruise control lane. Keep assist and associated features.Uh pop up as error warnings. My headlights are cornering headlights while driving. They have failed by moving to the downward and inward position and stayed in that position, significantly reducing my visibility. My alarm constantly goes off for no reason. While driving, the speaker system makes a very loud noise. That almost sounds like a gunshot.Hitting the windshield, which is extremely frightening and will cause you to jerk in response. I have taken this back to the dealership five times trying to get this diagnosed, and it still cannot be fixed. I have asked that this be considered a lemon. Due to covid, my diagnostic time was pushed back beyond the one year mark, so I was not able to get the first diagnosis until after mao one year of owning the vehicle.

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V686000 (Exterior Lighting); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2022 Ford F-150. The contact stated the vehicle failed to shift out of 4WD into 2WD as needed. The contact stated that while driving at various speeds, there was an abnormal rattling sound coming from the rear-end of the vehicle with a burning sulphury odor. There was no warning lights illuminated. The vehicle was taken to a dealer to be diagnosed, and the contact was informed that the rear end needed to be taken apart to determine the cause of the failure. The vehicle had not been diagnosed or repaired. The contact learned of NHTSA Campaign Number: 23V896000 (Power Train); however, the VIN was not included. The manufacturer was made aware of the failure and filed a complaint. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 39,000.

Ford has an outstanding Technical Service Bulletin (24-2039) that they have not notified me in a timely manner. If they had done so, it was have been replaced by Ford at their expense, either as part of bumper to bumper warranty or as a recall. Instead, the only way to find error is to have Service department run a system wide check. Ford dealer technician also feels its should be part of a recall. It's an expensive repair, $655 to replace the DC/AC inverter. This should be a recall item and notices should go to car owners.

Parking light flickers when key is in close proximity or truck is unlocked from the remote. Parking light continues to flicker when truck ignition is on and truck is stationary in park. Once the vehicle is put into drive the flickering stops.

Started truck then we heard a loud pop, similar to a gun shot. Then we heard crackling through the speakers. Audio volume controls were ineffective as well as radio on/off controls. Turned truck off and restarted no pop this time but the crackling continued. I called my local Ford dealer to schedule a service appointment for the next afternoon. Then next day when I was driving the truck to work the crackling continued for several minutes then the sound system went back to normal. That afternoon, 12/4 after work I drove the truck to the dealer I had purchased the truck from to drop it off. I reported the situation to the service advisor and he said since the sound system does not throw codes it would not be able to be diagnosed unless the problem duplicated itself which I would have to leave the truck for an extend period of time.

The contact owns a 2022 Ford F-150. The contact stated that while reversing the vehicle, the back-up camera malfunctioned, causing the screen image to become frozen and still, creating a visibility hazard for the driver. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not notified the failure. The approximate failure mileage was 30,000.

The contact owns a 2022 Ford F-150. The contact stated while driving at 20 MPH, the contact rear-ended the vehicle in front of the contact's vehicle. The contact stated that the vehicle that was in front of the contact's vehicle slammed on the brakes, and the contact rear-ended the vehicle. The contact's vehicle was severely damaged to the front of the vehicle. In addition, the air bags did not deploy. The Police and the Paramedics were at the crash location. A police report was filed. The vehicle was towed to the collision center. The contact was the only occupant in the vehicle. The contact was transported to the local hospital. The contact received medical treatment to the right side of his body and multiple X-rays. In addition, the contact sustained severe pain to the right side of his body and sustained pain to his head which required prescribed pain and muscle relaxer medication. The manufacturer was not made aware of the failure. The failure mileage was approximately 8,800.

The contact owns a 2022 Ford F-150. The contact stated while driving 45 MPH in the rain, the windshield wipers moved up an inch and stopped operating. The contact stated that upon deactivating and reactivating the windshield wipers, the failure recurred. The contact stated that the failure was persistent. The vehicle was taken to the dealer, where it was diagnosed and determined that the windshield wiper motors had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V842000 (Visibility). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The manufacturer advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 39,000.

My rear passenger side window will not go back up. It is constantly receiving power to pull the roll the window down. This is a known problem in the community. If you visit any Ford F-150, Explorer, or Maverick forum, there are post about work arounds on how to get the window up and temporarily get the window to stay up until the part comes in to repair it the correct way. Many of the people are posting that it is a known problem and the Dealerships are just "Yeah, we know, the parts are on back order, we can get you scheduled when it comes in". My argument is that if it is a known issue, why is the Manufacturer waiting until the owner reports it to perform the repair. Especially, because due to the constant power being applied, it could burn up the power window motor, safety interlocks for auto up/down, or if the materials get too hot eventually causing other electrical issues. From what I have found online it appears to be a known problem affecting mainly 2021-2022 year model vehicles.

At idle, the vehicle will shutter and idle rough, nearly stalling in traffic. I have taken it to the dealership twice to two separate dealerships and it's under factory warranty and they have no repair or fix for the problem.

The structural integrity of the hood and front bumper failed due to unsafe modifications performed by Rocky Ridge and endorsed by Ford Motor Company. The hood's structural reinforcements and crush zones were cut to fit a hood scoop, and sections of the front bumper were removed, compromising crashworthiness. The vehicle is available for inspection upon request and I have documented with images. The modifications to the hood and front bumper compromised the vehicle’s crashworthiness, potentially increasing the risk of severe injury or death in a collision. The removal of structural reinforcements and crush zones on both components prevents them from functioning as designed to absorb and distribute impact forces during a crash, endangering all occupants of the vehicle. The problem has been confirmed by an independent collision repair center, a Ford Certified Collision Center and my insurance company USAA. Both parties have stated that the modifications to the hood and bumper are unsafe, and the insurance company has refused to authorize repairs that replicate the original modifications due to safety concerns. The vehicle has been inspected by my insurance company and a collision repair center. Both confirmed the safety concerns resulting from the modifications and highlighted that the affected components cannot be repaired or replaced without compromising safety. Images were provided to Ford Motor Company and inspected by Ford Collision Center Manager. There were no warning lam

The main dashboard screen either works delayed after starting, and also unknowingly screen freezes. Have ALMOST backed up into another vehicle not knowing screen was frozen, have been into shop 4 times for repair and NOT ONCE has been repaired.

Three warnings light up: Antilock Brake Fault, Hill Start Assist Warning, and Pre-Collision Assist Not Available. Brakes failed. I was fortunate that no one was in front of me but the truck barely stopped. Took full pedal to the floor to force lockup. I am filing the matter as it does appear to be a frequently occurring concern in 2021 and 2022 models based on what I have read to date.

The contact owns a 2022 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle went into sleep mode. The error message was displayed that the battery was low. While opening the door at night, there were no interior lights illuminated. The vehicle was taken to the local dealer, who informed the contact that the vehicle was working as designed. The dealer tested the battery and determined that the battery was working as designed. The vehicle was not repaired. The manufacturer was contacted and referred the contact to another local dealer and the NHTSA Hotline. The failure mileage was approximately 15,000.