2022 Ford F-150 complaints

While entering the highway, speakers produced a deafening static noise, no way to control or stop the noise. It was certainly well above the level for hearing damage concerns, but also made it nearly impossible to drive safely. System was completely unresponsive to any attempt to turn off/reset/etc. There were no indicators/etc, and it finally stopped itself randomly. The only way I can try to describe how extreme this problem is, is to say imagine someone firing a gun next to your ear while you attempt to drive. Had it happened only a few minutes later while merging into traffic, it very possibly could have caused an accident.

I was driving and all the sudden an insanely loud sharp BEEP noise started and would not stop. It was coming from the speakers. I could not get it to stop. It was so loud I have lost hearing in my left ear. I had to exit the truck and disconnect the battery. Others are having this issue and Ford has no recall.

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V842000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2022 Ford F-150. The contact stated while driving approximately 60 MPH, the vehicle downshifted from 10th gear to 3rd gear. The vehicle slid across the roadway. There were no warning lights illuminated. The vehicle was taken to the local dealer and the contact was informed that the vehicle could be driven in low gear; however, the vehicle was not diagnosed or repaired. The contact stated that while driving at an undisclosed speed, the transmission seized in 1st gear. The vehicle was towed to Village Motors, Inc. (784 Wooster Rd, Millersburg, OH 4465) but was not diagnosed or repaired. The manufacturer was contacted and referred him to the local dealer. The failure mileage was approximately 10,703. The contact stated that the dealer was unable to do anything for the vehicle because the issue could not be replicated nor did the dash show any codes. But finally the contact was able to provide proof of the failure to the dealer. Neither the dealer nor the manufacturer have a solution to this issue.

Purchased a vehicle with a cord dealership and found out it had a recall (22C22) front light flicker. I was unable to take the vehicle off the lot. Found out this recall has been in effect since roughly August 2022 with no remedy to fix as of yet. I have been checking daily for updates and still nothing! I really want this vehicle and it’s been 5 months since the recall to effect with no fix! Aggrivating

Rear window shatter and blowout. Glass sent into the bed. Simply by shutting the door hard. Im a 3rd party bodybuilder who was sent this truck to add a landscaping package to, brand new, no mileage. For the initial measurement it was brought into the shop. After measurements when we were complete it was moved back outside. Simply revering back 20 feet and parking it outside the roll up doors, got out, shut the door and window blew out. Rear window has become a large bubble facing out towards the bed and some glass tempered glass blew into the bed. Local Ford dealer Service Manager was contacted and I was told Ford has no provisions for rear glass replacement from breakage. I was offered our pictures showing the large bubble it made, or the video surveillance. Didnt want it. Provided me with an 800-392-3673 who took my information and then scheduled with that same dealership for the next morning. Same Ford truck team member also contacted the warranty support fleet team, who promptly said no warranty and didnt have to look at any pictures or video since they offer no glass warranty other than front window glass with special circumstances. Did not care there were Ford forums listing the same damage or this issue littered on Google.

Axle bolts sheared off on both driver and passenger sides. Problem was discovered during tire rotation.

Any 2021 f150 or newer with the max tow package has faulty rear axle shaft bolts that are installed from the factory. These bolts shear off within the first 10k of driving and ford has yet to issue a recall for this. A sheared off axle shaft bolt can cause a failure in the rear differential or a wheel to fall off potentially causing an accident. There are many reports of this failure all over the internet. Just google "2021 f150 axle shaft bolt sheared off" for more examples like the one I am submitting

Shortly after taking delivery of my brand new F150, I noticed a substantial grinding sound and vibration intermittently presenting at both high and low speeds, with no change when shifting gears or slowing down. No warning lights were activated. All instances appeared to occur during below freezing temperatures. I immediately brought to our local Ford dealer who believes the vehicle is partially engaging the four wheel drive system in error. They have reported this to Ford and advises there is no known diagnoses or solution.

I was leaving the neighborhood and all of the sudden the forward collision warning went off for no reason, luckily the vehicle did not apply automatic brakes. I'm afraid if I was driving on the highway and the system went off for no apparent reason it could apply brakes and cause a crash. The electrical system is randomly setting off all kinds of error messages including random alarms in the middle of the night. The truck is less than a year old with only about 10K miles...the major concern is the forward collision warning that could potentially cause a crash.

On Friday, December 9th 2022 I started my truck via pressing the push start button in the truck. The vehicle started and went through its normal start up procedures. However - once the Sync 4 infotainment screen began to come to life an extremely loud Pop - followed by a max volume static played for a few seconds. I was extremely confused and immediately attempted to turn the volume down using the volume control but it had no effect. At first - the pop was so loud I thought the noise was my window shattering but realized it was my stereo after the static began. Their was no active audio playing when this event occurred and after the static subsided, my speakers were unable to play any sounds until I turned the vehicle off overnight. My ears are still ringing from this event 2 days later - this is a massive safety hazard and one that seems to be getting no attention from Ford.

On the morning of 12/7/2022 I got in the truck and turned it on. All the speakers made a super loud pop/bomb/gun going off sound. Then all the speakers were making a super loud crackling sound. Had no control over the audio volume, ect. Turned it the truck off and back on, still nothing but the crackling sound. 12” screen and digital dash were acting weird also (delayed coming on and not synced when powering on). After several minutes started the crackling stopped and it started playing music from my carplay. Kids said they smelt a burning smell. On 12/9/2022 it happened again. Got in and before I even started it it made a loud bomb going off sound when the digital dash and 12” screen was starting up. Then it was fine.

The 2022 Ford F-150 trucks are all having rust issues on the drivetrain and suspension parts. The Ford dealer has admitted there is a huge problem. It seems Ford has eliminated a coating on these parts which has allowed rust to develop even before they leave the factory. I took my truck to a local dealer and he refused to fix it under warranty. By checking the online forums you will see this is a huge problem. Rust does not fix itself. Over time it is very possible these parts will fail. I went online with a Ford customer service representative and was told someone would contact me the next day. That has been three weeks, no contact. I first noticed my rust issues a week after I took delivery of the vehicle

At times when starting vehicle or when driving the sound system makes a tremendously loud gunshot noise and then full volume static from all of the speakers. Only goes away after disconnecting battery or pulling fuse 28. This scares the crap out of you and could easily cause an accident. Ford dealers have no fix from Ford and per the internet I have found that many many other F150 and Raptor owners are having this same issue. This needs to be addressed by Ford ASAP before a tragedy occurs. It is that loud and frightening!

1150 miles on 2022 Ford F-150 super cab 5.0 4x4 10 speed auto the transmission went into a shuddering at 48 mph in 9th gear on level road light acceleration happened the next day also same condition. Also t he e truck lurches forward at times when coming to a stop and shifting out of 3rd gear it jumps need to make sure your not close to anything also when parking put truck in park and it jumped forward

The contact owns a 2022 Ford F-150. The contact stated while driving approximately 5 MPH on a mountain dirt road and taking a turn to the right, the brake pedal was depressed and the contact had a braking power failure. The contact turned the vehicle to the left and crashed into the side of the mountain. The contact stated no warning light was illuminated. The contact stated that the vehicle rolled up the side of the mountain on the passenger side. The contact stated that the vehicle rolled onto its side and was left on the roadside. The contact stated that the side curtain air bags on the driver's and passenger's side had deployed when the vehicle rolled onto its side. The contact stated that he had called for a tow, but the vehicle had not been taken to a dealer or mechanic to be diagnosed. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 8,000.

I started my truck up this afternoon and heard a deafening boom and then loud crackling. At first I thought something fell on my roof and the glass was breaking. After getting out and looking around I realized the noises were coming from the speakers and under the back seat, amp area. The crackling went on for about 5 minutes and didn't stop by shutting the radio off or shutting the truck off. This seems like a very terrible safety issue.

Twice the Truck has had the audio system go haywire. Upon startup the truck speakers hada loud pop followed by and extremely loud static type noise that hurt my ears and I still have a headache 12 hours later. The noise would not stop , the radio appeared normal but no buttons or knobs would change or lower the noise. Upon multiple restarts the noise would not go away I drove 15 minutes to the dealer so they could experience the noise 1st hand. Had there been young children in my truck I feel like they might have suffered hearing damage it was that loud, sounded like a gas leaf blower running at full speed in the cabin of my truck.

While driving the vehicle speaker system shorted out and begin playing static and popping noises at full volume. The intensity was so high that the vibrations caused my vision to blur and almost crash the vehicle.

What component or system failed or malfunctioned, and is it available for inspection upon request? Excessively Loud Popping Noise B&O Unleashed. How was your safety or the safety of others put at risk? It is so loud that when it happened I slammed on my brakes thinking something exploded. Luckily I was in a gravel driveway on my way out when it happened. It seems to be a problem with AppleCarPlay. It happened when I tried playing an audiobook via wireless carplay and it happened again today with wired carplay and playing some music. Has the problem been reproduced or confirmed by a dealer or independent service center? I have not had a dealer look at it yet to others to look at. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The sound is so deafening that my head is ringing and pounding with just a minute the sound going off. I have not had anyone look at it. I want it to stop as quickly as possible. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or messages.

Turned on radio, very loud pop over the speakers followed by static. From being on Ford forums I quickly changed audio sources to make it stop. But for those who do not know this, it could easily cause an accident with being startled and distracted. Ford has not come up with a fix and there are many documented cases.

The contact owned a 2022 Ford F-150. The contact stated while driving 65 mph, he started to smell a burning odor inside the cab. The contact stated no warning light was illuminated. The contact was able to park on the side of the road and when exiting the vehicle he saw a fire had started under the engine. The contact and his family were able to exit the vehicle safely. The contact stated no one was injured nor sought medical attention. A fire department was able to extinguish the fire. A fire report was not filed. A police report was filed. The insurance company deemed the vehicle a total loss. The vehicle was towed to towing lot. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed. The manufacturer had not been informed of the failure. The failure mileage was approximately 1,800.

Windshield wiper doesn’t work into a raining time.

Extremely ear piercing loud noise like an explosion coming from radio when vehicle was started. Glad I was not driving as it startled me. This could of caused a major safety issue. From an operational standpoint no volume from the radio until I started the vehicle the next morning. I researched the event and found other owners affected by the same or similar issue. This is why I'm on this site reporting my same experience.

Extremely loud short static noise when trying to play audio through B&O Unleashed sound system that was factory equipped with my F150. After static I lost all audio. I changed input and the extremely loud short static noise happened again, this time with continuous clicking at full volume after the static stopped. Volume controls were completely unresponsive, I also could not turn audio off. The full volume continued until the vehicle was turned off and parked for over 10 minutes. After that everything worked as it should.

I have the B&O Unleashed sound system, I started the truck up and a very loud noise came from all the speakers. Scared the heck out of me. If I was driving done the road when this happened who knows what could have happened?

Rear axle bolts on max tow package 9.75 axle sheared off of both ends. Second one resulting in axle fluid to leak out of the end, requiring entire axle replacement.

Windshield wipers stopped working. Restarted the truck and this happened repeatedly every 3-5 minutes. Electronic curtesy wiper control also disabled on the screen. (Can't turn off function)

The contact owns a 2022 Ford F-150. The contact stated that while driving in inclement weather, the windshield wipers inadvertently failed to function as needed. The contact stated that he checked the windshield wipers and noticed that the driver’s and passenger’s side woodruff key had separated. The vehicle was repaired; however, the failure recurred with the driver’s side woodruff key. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to take the vehicle to the dealer for assistance. The failure mileage was approximately 13,000.

Multiple warning lights came on while going 55MPH down a straight road. Warning lights consisted of Antilock break system fault, Pre-collision assist not available, and Hill start assist warning. I did not have and breaks at all.

There are two things that have been happening, and are widely prevalent on different online forums as well. 1) While the vehicle is on the stereo will end up going into a loud max volume crackling and popping and won't shut off even when the truck is turned off. This has already caused an accident. Please see attached forums: https://www.f150gen14.com/forum/threads/dangerous-b-o-sound-system-issue.9254/ https://www.fordraptorforum.com/threads/gremlins-ii-crackling-static.93548/ https://www.f150gen14.com/forum/threads/extremely-loud-electrical-pop-followed-by-loud-static.9591/ https://www.fordraptorforum.com/threads/my-ears-are-hurting-b-o-sound-system-goes-crazy-safety-issue.91946/ 2) Headlight DRL on Ford Raptor flickers while driving and is clearly a violation of NHTSA safety guidelines.

The contact owns a 2022 Ford F-150. The contact stated that while stopped, the engine revved up with the brake pedal but the vehicle failed to respond, moved, and crashed into a GMC pickup. The driver placed the shifter into the park position and turned off the vehicle and removed the keys, but the vehicle continued on for approximately 4 minutes. There were no warning indicator lights illuminated. There were no reported injuries, air bag deployment, or fire. A police report was filed. The vehicle was towed to the local dealer but the vehicle was not diagnosed or repaired. The manufacturer sent two engineers and the insurance company sent an engineer to evaluate the vehicle and requested to take possession of the event data recorder but the owner declined. The manufacturer was contacted, who provided a case number but no additional assistance was provided. The approximate failure mileage was 3,500.

Twice I have been driving my 2022 Ford F150 and I have tried to turn the wipers on when it started raining, and the wipers did not move. 1) This initial time this happened was early Spring 2022. I was driving in the freeway, and it started to rain. I was using the wipers on intermittent, and everything was fine. At some point I turned the wipers off because it stopped raining. When it started to rain again, I turned the wipers on, and nothing happened. I turned them on and off for the next hour or so, with no wiper action. Finally, after about 90 minutes I turned them on again and the wipers worked. 2) The second incident was on 9/17/2022. I was driving in the mountains when it started to rain. The wipers were working fine. The rain stopped, and I turned the wipers off. Then a downpour started. I tried to turn the on, and nothing happened. I turned the wipers on and off several time. Still no wiper action. This became a dangerous situation on a curvy mountain road. I should have stopped driving due to the lack of wiper action and the fact it was dusk and I was about out of daylight. I chose to drive on, but that was a reckless decision at best. About an hour later the wipers started to work again. I've taken the truck into Crater Lake Ford for the wipers. In the end, I gather they tested them, found they were working fine, and did nothing to fix the problem. I'm very concerned that I will get caught out in a rainstorm again and the same problem will happen again.

The truck show a warning when on reverse, the rear brake assiste does not work since I bought the truck and dealer has no fix to it.

EXCESSIVE LOUD STATIC NOISE / CRACKING FROM MY 2022 F150 PLATINUM B & O UNLEASHED RADIO. LASTED FOR ABOUT 3 TO 5 MINUTES WHILE ON SATELLITE RADIO.

B&O Unleashed Stereo system will produce deafening sound, volume maxed out. The sound is a screeching pulsing sound. It makes your ears ring it is so loud. When you turn the vehicle off it still makes the sound. Turning any of the radio dials does not lower the volume or get it to shut off. You have to get out of your vehicle and wait for the stereo to shut off, can be up to 10 minutes for that to happen. There is no way to drive with it make that noise. You have to pull over and wait for it to stop. This has happened twice in my 6 months of ownership, dealer say the typical, "Can't reproduce it".

Car was in the driveway and refused to start. Back light flashed and the battery died. I stated to the dealership that the adaptive cruise was not working. The dealership stated that it was working and that they test drove it and it was working. I brought it in a second time and stated the adaptive cruise was not working. Again the dealership stated that it was working. Third time I complained and they admitted that the factory had not installed adaptive cruise and that the vehicle did not have the sensors for the Pre-collision Assist w/AEB. They would wait for the parts and install the necessary hardware. Prior to delivery my vehicle had a Factory Hold on it . Ford did not warn me that safety features I had paid for were not installed. Ford had their dealer deny that my vehicle was missing these safety features. These missing safety features and Ford"s denial put myself and others at risk. These safety features was why I bought a new truck in the first place. Ford and its dealers did not act in a responsible or ethical manner with complete disregard for safety.

After starting the vehicle, I heard a loud pop and then loud static that couldn't be turned off. The sound is very deafening and hazardous to babies with developing ears. Has happened twice already in the past week.

When applying brakes, the response time in incredibly slow. Sometimes when the brake is applied half way down, the truck tends to skid on the road.

This brand new 2022 truck is less than a month old. Windshield wipers were turned on at normal speed (not intermittent) and the wipers froze at the vertical position. Adjusting the wipers control knob did nothing, and about 15 seconds later the wipers resumed proper function. Five minutes later, they froze again at the same position. This was very dangerous to lose visibility in a heavy rain.

I had just purchased my truck not even 30 days and the wipers went out. It was a very rainy day and the wipers just stopped. I had to pull over and get a tow truck to take me to the dealer. I was unable to see and almost hit a car parked on the side of the road because I could not see. I have talked to Ford and the dealer and they both tell me that this is an ongoing issue with no resolution. They have over 600 customers for the 2022 model year with the same issue on non working wipers . They told me it could be 2 to 8 months before they start producing wiper motors for repair. They suggest rainx until the issue is resolved??? My truck is currently parked in the dealer lot. This truck was not appart of the recall like my other truck was. Shouldnt this be part of the recall also and maybe a stop sale until they fix this?

The contact owns a 2022 Ford F-150. The contact stated that he had placed the vehicle into park, engaged the parking brake, and removed the key from the ignition as he went to unload a trailer attached to the vehicle. While the contact was removing a tractor from a trailer, the vehicle independently rolled forward without warning. As the vehicle continued to roll forward, the vehicle jackknifed to the left which brought the vehicle to a stop. The failure bent both the trailer hitch and the trailer frame. Despite the failure, the vehicle resumed normal operation and the contact was able to drive the vehicle to the dealer for an inspection. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired or diagnosed. The failure mileage was approximately 7,000.

The contact owns a 2022 Ford F-150. The contact stated while driving 70 MPH, the fuel tank detached from underneath the vehicle. There were no warning lights illuminated. The vehicle was towed to the local dealer. The failure was diagnosed that the fuel tank was not properly bolted to the subframe of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The manufacturer was aware of the failure and informed the dealer through Service Bulletin: 22S42. The approximate failure mileage was 700.

The contact owns a 2022 Ford F-150. The contact stated while driving 55 MPH and attempting to overtake another vehicle, the vehicle excessively accelerated. The contact pumped the brake pedal several times to slow the vehicle. The contact pulled over and turned off and restarted the vehicle and drove safely to the residence. The vehicle was not diagnosed. The dealer was contacted, and an appointment was scheduled. The manufacturer was not contacted. The failure mileage was 3,200.

I was driving on the interstate at 60mph when we were caught in a downpour. We were pulling a 7000lb trailer and the windshield wipers completely stopped working. Visibility was virtually zero. I was in the right lane and was able to navigate to the shoulder. I could tell I was on the shoulder due to the rumble strips. Once on the shoulder I was able to get the wipers to reset and become functional again. Every time I get caught in rain I get to the right lane in case of a failure. The vehicle is available for inspection. Our safety was put at risk. The problem has not been reproduced but an appointment is scheduled with the dealership. The vehicle has not been inspected (not sure where to take it). There were no warnings prior to the failure.

The contact owns a 2022 Ford F-150. The contact stated that after parking the vehicle and placing the vehicle in park, the vehicle inadvertently moved forward approximately 10 inches. The vehicle was not taken to the dealer or independent mechanic to be diagnosed. The manufacturer was not notified of the failure. The failure mileage was 3,000.

The tailgate opens without warning and no warning is given when it opens. The tailgate opens without warning while driving, parked and not running. This has opened on me several time causing numerous safety issues to include contents of my bed falling out on the roadway while driving. The tailgate has opened as my young daughter was walking by and it nearly striking her in the head. As I left the store today when I returned to my vehicle the tailgate was down and had opened while I was not in or near the vehicle. I contacted the dealership where the vehicle was purchased and was told that there is no recall or fix for the issue at this time. I was told they are aware of the issue but could not fix it. There are no lights, sounds or warnings to when the tailgate will open.

APIM (SYNC4) went out and does not work. The APIM controls most functions in the truck. I do not have a working display screen, cannot charge phone, cannot use any of the features I paid to use, no back up camera, and no radio. The trucks user/owners manual is also apart of the APIM (SYNC4) system. Nothing connected with the APIM works. I have waited over 1 month for replacement APIM and Ford has still not sent a replacement. I believe this is happening with new Ford Broncos using the same APIM (SYNC4). There are tons of Ford owner forums complaining about this same issue. I believe Ford and Ford Service is hiding this problem. My Ford Service records shows "Services Performed" as "Unknown."

Pushed washer fluid button in. Washer fluid came out but wipers did not engage like required. Tried turning wipers on in all positions got nothing. When left in on position wipers move in half inch increments but no more than 3” from home position. Took to local repair center but they cannot get new one. I’m aware of 2021 F150 doing same thing which there is a recall. Not sure what to do. Still driving car without proper safety equipment l

Brand new truck, windshield wipers won't go on. Brought to dealer, said I need a new wiper motor. Parts on backorder with no ETA. Dealer said pickup your truck if you need it and we will call you when part arrives.