2003 Chevrolet Venture

Defect. DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Risk. A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Remedy. DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Defect. K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk. WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Defect. ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Risk. A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy. DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.

Defect. CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Risk. FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy. DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Defect. ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Risk. IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy. DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

Defect. CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

Risk. THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy. OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Defect. ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.

Risk. THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.

Remedy. DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.

Defect. CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Risk. PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy. DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Driving on a driveway (estimated speed 5-10 mph) when I noted that the driver side door didn't seem completely closed. I tugged on the door handle to shut it and instantaneously felt the driver-side side airbag deploy, scraping my left forearm, left ear, and rupturing the left eardrum. There had been no collision or accident involving the car or any other structure. The vehicle has not been in a prior accident, and has not had additional electric work performed to any of its systems since manufacturing. The vehicle is available for inspection, it has not been inspected yet by a manufacturer or dealer, and the airbag affected my safety by causing physical harm due to faulty deployment.

I was adding fuel to my car and noticed a strong fuel smell. I only traveled a few miles but my fuel gauge dropped from 3/4 to 1/4 full in only a few miles. When I got home I told my husband. He checked the vehicle and found that fuel was leaking from the inlet on the fuel tank. My husband searched the issue an found a recall for some 2003 and 2004 Chevrolet and other GM products listed as NHTSA Campaign # 07V349000 and NHTSA Action # EA07006. It does list the same vehicle I have a 2003 Chevy Venture van. The recall covers just certain months of production. From our research it seems that a broader recall in needed

LEFT TURN SIGNAL WIRING SHORTED OUT & AS RESULT ALL LIGHTS ON LEFT FRONT DO NOT WORK NOW. PIGTAILS NOT AVAILABLE FOR THIS APPLICATION!!!

THE BUTTONS FOR MY CONTROL DASH WHERE RADIO AND HEAT ADJUSTMENT ARE, THE PANEL,. GETS BLAZING HOT TO THE TOUCH. EVERYTIME WE DRIVE IT. IT'S OVERHEATING SO MUCH I AM CONCERNED IT WASN'T FIXED BY A RECALL PREVIOUSLY CLAIMED. THE BUTTONS DECALS HAVE MELTED OFF ON SOME BUTTONS. THIS HAPPENS WHEN THE CAR IS ON. I RECENTLY PURCHASED THIS VAN PRIVATELY IN ILLINOIS.

AFTER REFUELING, THE VEHICLE BEGAN LEAKING FUEL FROM THE TANK NEAR THE AREA WHERE THE FUEL INLET ENTERS THE TANK. THERE IS A SAFETY RECALL BULLETIN, 06230, AND THE VIN NUMBERS OF VEHICLES AFFECTED DOES INCLUDE MY VEHICLE. HOWEVER GM WILL NOT COVER THE COST TO REPAIR, CLAIMING MY VEHICLE IS NOT AFFECTED. OBVIOUSLY IT IS AFFECTED OR IT WOULD NOT BE LEAKING FUEL FROM THE EXACT SAME AREA COVERED BY THE RECALL! THERE ARE SEVERAL COMPLAINTS ON THE NHTSA WEBSITE STATING THE SAME EXPERIENCE. WHY WON'T GM COVER THE REPAIR EVEN WHEN THERE IS A RECALL? TO MAKE MATTERS WORSE, GM NO LONGER MAKES THE REPLACEMENT TANK AND I CAN NOT FIND AN AFTERMARKET TANK EITHER.

TAMARA INFLATES INCLUDES MY BRAKES AS I HAVE TO PRESS THE BRAKE PEDAL ALL THE WAY TO THE FLOOR AND THE VAN WOULD STILL NOT STOP. ALSO MY DRIVER'S SIDE WINDOW WILL NOT GO DOWN.

THE ENGINE RPM SURGES WITHOUT PUSHING THE GAS. THE ENGINE WILL GRADUALLY PROPEL THE VEHICLE TO AROUND 50-60 MPH WITH NO MECHANICAL MOVEMENT OF THE GAS PEDAL. THIS HAPPENS ABOUT EVERY DAY OR TWO. HAVE TO PUT THE CAR IN NEUTRAL OR FIRMLY PRESS THE BRAKES TO GET THE VELOCITY DOWN. THE CAR IS IN MOTION AND STATIONARY WHEN THIS HAPPENS. IT HAPPENS SPORADICALLY. CHANGING ALL TYPES OF PARTS AND STILL NO RESOLUTION. I ALSO SEE ALOT OF THE SAME ISSUES ON LINE WITH OTHER OWNERS OF THIS VEHICLE.

THE LOWER INTAKE MANIFOLD HEAD GASKET CRACKED OR RUPTURED RESULTING IN THE ANTI- FREEZE COOLANT TO LEAK INTO THE MOTOR OIL. REQUIRED REMOVAL OF ENTIRE INTAKE MANIFOLD ASSEMBLY AND REPLACEMENT OF DEFECTIVE RUPTURED HEAD GASKET. COST 9 HOURS MECHANIC LABOR AND $ 975.00 FOR PROFESSIONAL REPAIR.

TL* THE CONTACT OWNS A 2003 CHEVROLET VENTURE. WHILE PUMPING FUEL THE CONTACT OBSERVED FUEL LEAKING FROM THE REAR DRIVER SIDE OF THE VEHICLE. THE VEHICLE WAS DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 199,874. UPDATED 01/27/17*LJ UPDATED 02/02/17.*JB

TL* THE CONTACT OWNS A 2003 CHEVROLET VENTURE. WHEN THE CONTACT ATTEMPTING TO START THE VEHICLE, THE FRONT DRIVER SIDE AIR BAG INADVERTENTLY DEPLOYED WITHOUT AN IMPACT OCCURRING. THE CONTACT SUSTAINED BRUISES AND INTERNAL INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.

MY GAS TANK IS LEAKING

TL* THE CONTACT OWNS A 2003 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THERE WAS A STRONG ODOR OF BURNING WIRES. THE CONTACT MENTIONED THAT WHILE ATTEMPTING TO PARK, THE TURN SIGNAL LAMPS FAILED TO ILLUMINATE. THE CONTACT PARKED AND OBSERVED THAT THE LAMPS WERE MELTED AND THE BULBS WERE DARK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2003 CHEVROLET VENTURE. WHILE DRIVING 55 MPH, THE GEAR SHIFTER FAILED TO REMAIN IN DRIVE AND PARK. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 98V131000 (POWER TRAIN). MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 192,000.

DRIVER OF VEH. #1 2003 CHEV VENTURE LS WAS EAST BOUND THROUGH A CONTROLED INTERSECTION, WHEN VEH. 2 A 1997 JEEP WAS WEST BOUND IN INTO THE INTERSECTION AND MADE AN ABRUP LEFT TURN IN FRONT OF VEH. #1. BOTH VEHICLES STRUCK EACH OTHER IN THE LEFT FRONT CORNER OF EACH VEHICLE. VEH. #1 WAS DECLARED TOTALLED BY TRAVELERS INSURANCE CO. THE LF PORTION OF THE VAN WAS SHOVED BACK IN TO THE MOTOR, RADIATOR, ALONG WITH THE LF WHEEL AND ASSEMBLY. THE DRIVERS AIRBAG DID NOT DEPLOY FROM THE NEAR HEAD ON CRASH.

TL* THE CONTACT OWNS A 2003 CHEVROLET VENTURE. WHILE INSPECTING THE VEHICLE, THE CONTACT NOTICED A FUEL LEAK FROM THE INLET TUBE TO THE FUEL TANK. IN ADDITION, THE CONTACT NOTICED FUEL VAPORS EMITTING FROM THE UNDERNEATH THE FRONT DRIVER SIDE OF THE VEHICLE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 03/18/15*LJ UPDATED 9/13/2017*CN

ON OR AROUND THIS DATE MY VEHICLE STARTED TO LEAK FUEL FROM THE FUEL TANK INLET CHECK VALVE WELD.THERE APPEARS TO HAVE BEEN A RECALL/SPECIAL COVERAGE # 07203 FOR THIS PROBLEM DATED 8/7/07.I AM INFORMED BY GM THAT THIS EXPIRED LAST YEAR?? I ALSO REALIZE THAT DESPITE FAIRLY LOW MILEAGE MY VEHICLE IS 11 YEARS OLD BUT IT IS IN VERY GOOD CONDITION AND CURRENTLY REGISTERED AND HAS PASSED SAFETY INSPECTION IN MA. MY QUESTION TO YOU IS HOW CAN SOMETHING AS DANGEROUS AS THIS HAVE A EXPIRATION DATE?? *TR

ABOUT A WEEK AFTER I GOT MY MINI VAN THE FUEL GAUGE QUIT WORKING, THE IGNITION SWITCH STARTED STAYING ON IN THE START POSITION, AND I'VE GOT A RATTLE IN THE ENGINE THAT NOBODY CAN SEEM TO FIND. ALL OF MY FRIEND'S HAVE HEARD THIS SOUND IN THE ENGINE, BUT THE TECHS KEEP TELLING ME IT'S NORMAL. *TR

EMERGENCY BRAKE CABLE IS HANGING LOOSE UNDER VAN DUE TO BRACKETS HOLDING CABLE HAVING RUSTED OUT. THE ROCKER PANEL ON THE DRIVER'S SIDE IS BADLY RUSTED, AS IS THE ROCKER PANEL ON THE PASSENGER'S SIDE. *TR

THE FUEL GAUGE FLOATS ALL OVER THE PLACE YOU NEVER KNOW HOW MUCH GAS IS IN THE VAN, AND I CAN SMELL GAS FUMES REAL STRONG WHILE SITTING STILL AND SOME TIMES THEY ARE STRONG ENOUGH TO SMELL WHILE DRIVING, WAS READING THE RECALL LIST FROM GM ON THIS 2003 CHEVY VENTURE AND I DON'T THINK MY VAN HAS BEEN RECALLED I AM GOING TO NOTIFY THE DEALERSHIP (MANS CHRYSLER ) AND SEE WHY THEY NEVER TOLD ME ABOUT ALL THE RECALLS BEFORE THEY SOLD ME THE VAN. THIS VAN MAY NEED THE FUEL TANK REPLACED AND THE STEERING HAS THIS POPPING SOUND IN THE RIGHT FRONT SIDE MAY NEED TO GET THAT CHECKED ALSO ACCORDING TO THE RECALLS I SEEN ON HERE. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET VENTURE. THE CONTACT STATED THE DRIVER SIDE SEAT BELT FAILED. THE CONTACT MENTIONED THAT THE LATCH PLATE FAILED TO FIT INTO THE BUCKLE. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. IN ADDITION, THE CONTACT STATED THAT THE REAR VIEW MIRROR ADHESIVE MELTED AND BROKE OFF.THE APPROXIMATE FAILURE MILEAGE WAS 170,000.