2013 Can-Am Spyder RT

Defect. Bombardier Recreational Products Inc. (BRP) is recalling all model year 2013 Can-Am Spyder RT motorcycles. Prolonged idling or slow speed riding in warmer temperatures may result very high temperatures in the engine compartment.

Risk. Very high temperatures in the engine compartment may increase the risk of skin burns or a vehicle fire.

Remedy. BRP has notified owners. Dealers will repair the vehicles free of charge. The recall began on May 26, 2015. Owners may contact BRP customer service at 1-888-272-9222.

Defect. Bombardier Recreational Products (BRP) is recalling certain model year 2013 Can-Am Spyder RT series and ST series motorcycles. The tandem brake master cylinder manifold inlet may melt allowing the brake fluid to leak out.

Risk. Brake fluid may leak onto a heat source, increasing the risk of a fire.

Remedy. BRP will notify owners and dealers will install heat shields and a heat deflector, free of charge. The recall is expected to begin in early September 2013. Owners may contact BRP at 1-888-638-5397.

EXCESS HEAT HAS MELTED THE BRAKE LINE TWICE, MASTER CYL. MELTED, BRAKS GET SOFT AND INHIBIT STOPPING POWER, ELECTRICAL WIRINGIS DEGRADING FROM EXCESS HEAT, GAS TANL GET SO HOT THE GAS STARTS TO BOIL, PANELS ARE MELTING AND WARPING FROM EXCESS HEAT. THE UNIT HAS BEEN DECLARED UN SAFE TO RIDE. BRP REFUSES TO ADDRESS THE SAFETY ISSUES, ALL RECALLS AND UPGRADES HAVE BEEN DONE AND THE PROBLEM IS JUST GETTING WORST, BRP, WILL NOT FIX ONLY OFFERS TO HIDE THE COMETIC DAMAGE

CAN"T STOP AN OIL LEAK. AFRAID IT MIGHT GET HOT AND CATCH ON FIRE!!! *DT

WHILE RIDING ON THE HIGHWAY IN MOTION, DURING A CLEAR DAY ON JULY 16 2016. THE SUBJECT VEHICLE SUFFERED A BLOWN REAR TIRE LEAVING A LARGE CENTER STRIP OF BLENDED STEEL AND RUBBER SHAPED AS A WIDE BELT THAT EXTENDED PAST THE REAR OF THE BIKE. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT P). WHILE ATTEMPTING TO BRING THE BIKE TO A SAFE HALT TO THE SIDE OF THE HIGHWAY, THE ROTATION OF THE WHEEL USING THE STATED BELT BEAT THE PLASTIC REAR END OF THE VEHICLE TO A TOTAL DISMEMBERMENT OF CRUCIAL PARTS. WITH THE REAR END OF THE VEHICLE BEING RIPPED AWAY FROM THE VEHICLE, THE ATTACHED PASSENGER'S PLASTIC SEAT MOUNT WAS ALSO DESTROYED. FINELY AS THE VEHICLE WAS BEING BROUGHT DOWN TO A STOP TO THE SIDE OF THE HIGHWAY, SOMEHOW WITH THE VIBRATION OF THE ROTATING BLOW TIRE AND WHEEL, THE RIGHT FRONT WHEEL STABILIZING CAST IRON MECHANISM BROKE DISLODGING THE LOWER BALL JOINT THAT STABILIZED THE HORIZONTAL POSITION OF THE RIGHT FRONT WHEEL. SEE THE MULTIPLE PHOTOS ATTACHED IN (EXHIBIT K). THIS SENT THE VEHICLE IN A VIOLENT CLOCK WISE SPIN THAT FINELY OVERCAME THE RIDER'S GRIP DISLODGING THE SEAT AND RIDER ON TO THE SIDE OF THE HIGHWAY, AND THEN FINELY COMING TO A COMPLETE STOP FACING THE ONCOMING HIGHWAY TRAFFIC. HOWEVER, AT NO TIME DID THE VEHICLE HIT ANY CAR, CURB, WATER, ICE, TRASH, OR WALL DURING THE RIDE OR DISLODGING OF THE RIDER. NOOR DID IT FLIP OR TURN OVER AT ANY TIME, IN FACT THE VEHICLE DURING ITS REDUCTION IN SPEED, AS WELL AS THE CLOCK WISE SPIN EVER LEAVE THE FINAL LANE THAT T

SEE THE ATTACH NHTSA_COMPLAINT.PDF THE VEHICLE WAS IN MOTION. CAN AM SPYDER SERIAL/VIN # [XXX], MODEL # 000B9DC00. I HAVE PUT THAT I WAS GOING 75 MILES PER HOUR, NOT SURE OF THE NUMBER AS THIS IS A BIKE. MY GOAL IS TO KEEP UP WITH TRAFFIC. HOWEVER THE SPEED LIMIT ON THE HIGHWAY IS 75 MPH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. WHILE DRIVING 70 MPH, A BRAKE WARNING LIGHT ILLUMINATED AND THE VEHICLE REQUIRED A LONGER DISTANCE TO STOP. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED BRAKE FLUID LEAKING BENEATH THE VEHICLE. FUMES OF SMOKE WERE SEEN BENEATH THE SEAT. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 13V386000(SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TAKEN TO THE DEALER AGAIN WHERE IT WAS DIAGNOSED THAT THE BRAKE MASTER CYLINDER AND BRAKE FLUID RESERVOIR WERE MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 10,000.

I RECEIVED A RECALL NOTICE ABOUT THE ELEVATED TEMPERATURE IN THE ENGINE COMPARTMENT ON FEBRUARY 26, 2015. IN THE SAFETY RECALL NOTICE I WAS ADVISED TO CONTACT BRP DEALERSHIP, WHICH I DID IMMEDIATELY. I WAS TOLD THE PART WAS ON BACK ORDER AND TO CALL BACK IN APRIL I CONTACTED THEM AGAIN IN APRIL, WAS TOLD THE STATES WITH THE HOTTEST TEMPERATURE WAS FIRST CALL BACK IN A MONTH. I CALL IN MAY, WAS TOLD AGAIN, THE PART WAS NOT AVAILABLE. CALLED BACK IN JUNE WAS TOLD THE TOOL TO FIX THE PROBLEM WAS NOT AVAILABLE. MEANWHILE IN OHIO THE SUMMER MONTHS ARE HERE, AND THIS STILL HAS NOT BEEN RESOLVED. I CONTACTED BRP IN CANADA, NO RESPONSE. THIS CAN AM WAS PURCHASED NEW OFF THE SHOW ROOM FLOOR IN 2014, AND I AM ADVISED TO NOT RIDE IT WHEN ITS HOT, OR IN TRAFFIC. I AM NOT A HAPPY CAMPER RIGHT NOW, I PURCHASED THE BIKE TO ENJOY THE SUMMER MONTHS, RIDE WITH THE LEGION RIDERS AND IT SITS IN THE GARAGE.

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE); HOWEVER, THE MANUFACTURER'S REMEDY WAS INCOMPLETE. THE MANUFACTURER STATED THAT THEY WOULD BE REPLACING THE BODY PANEL WITH NEW IMPROVED BODY PANELS AND AN UPGRADED FUEL SYSTEM KIT. THE CONTACT RECEIVED TEMPLATES TO USE TO CUT OUT PIECES OF THE BODY PANEL. THE MANUFACTURER STATED THAT THIS WAS THE ONLY AVAILABLE REPAIR FOR THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. .. .UPDATED 07/21/15 *BF

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. WHILE DRIVING 55 MPH, THE HEAT EMITTING FROM THE TOP OF THE VEHICLE MEASURED 169 DEGREES FAHRENHEIT. IN ADDITION, THE CONTACT HAD TO CONTINUOUSLY STEER THE VEHICLE IN ORDER TO KEEP IT IN POSITION. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE). THE VEHICLE WAS TAKEN BACK TO THE DEALER; HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000. MA 08/05/15 UPDATED 9/24/2015 *JS

WHILE RIDING MY CAN AM SPYDER FOR APPROXIMATELY 30 MINUTES, I WAS STOPPED AT A RED LIGHT FOR OVER A MINUTE. I THEN BEGAN TO FEEL EXCESSIVE HEAT FROM THE RIGHT SIDE OF THE BIKE, WHERE MY LOWER THIGH AND KNEE TOUCHES THE PANEL OF THE BIKE. I ALSO BEGAN TO SMELL A STRONG ODOR OF BURNING PLASTIC (SORT OF LIKE WHEN A RESISTER OR COMPUTER CHIP GETS FRIED). I IMMEDIATELY DROVE HOME WHERE I CHECKED THE BIKE FOR BURNT PLASTIC. I DID NOT NOTICE ANY BURNT PLASTIC, HOWEVER I DID NOT REMOVE ANY OF THE PANELS TO CHECK UNDERNEATH THEM. IT WAS APPROXIMATELY 77F WHEN THIS HAPPENED. I AM VERY CONCERNED THAT THE EXCESSIVE HEAT WILL MELT COMPONENTS UNDERNEATH THE PANELS OR START A FIRE. THE PANEL WAS VERY HOT TO THE TOUCH. I DID RECEIVE A VERY SLIGHT BURN TO MY THIGH AREA AFTER THE RIDE.

WE HAVE BEEN WAITING FOR A RECALL FIX THAT WAS INFORMED BY BRP WOULD BE IN MAY 2015. THROUGH SOCIAL MEDIA WE WERE TOLD BY BRPCARE THAT THE FIX WAS READY AND SUPPLIED PICTURES. WE HAVE SCHEDULED THE WORK BUT AM NOT HAPPY WITH THE FIX AS IT CHANGES THE APPEARANCE OF THE VEHICLE. WHEN I CALLED NHTSA I WAS INFORMED THAT SHE COULD NOT FIND ANY INFORMATION THAT THIS FIX WAS APPROVED. *TR

WE ARE PAYING FOR A MOTORCYCLE WE CANNOT RIDE DUE TO A RECALL AND NO ONE CAN SEEM TO TELL US WHEN IT WILL BE FIXED. RECALL LETTER STATES IT WILL BE RESOLVED BY MAY OF 2015 - 2 DAYS LEFT IN MAY AND STILL NOT NOTIFIED OF HOW IT WILL BE FIXED - WE CANNOT RIDE THIS VEHICLE AS IT COULD CATCH ON FIRE - WE LIVE IN FLORIDA WHERE TEMPERATURES ARE EXTREMELY HOT - CONSEQUENTLY, WE HAVE NOT BEEN ABLE TO RIDE OUR MOTORCYCLE DUE TO THIS RECALL - WE CONTACTED BRP AND THEY ADVISED US NOT TO RIDE THE VEHICLE SO WE ARE MAKING PAYMENTS ON SOMETHING WE CANNOT USE OR SELL DUE TO A RECALL - NOT A HAPPY CONSUMER!

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. WHILE DRIVING APPROXIMATELY 15 MPH, THE MOTORCYCLE BEGAN TO OVERHEAT AND STALLED WITHOUT WARNING. THE MOTORCYCLE WAS ABLE TO RESTART HOWEVER, THE FAILURE RECURRED ON TWO OTHER OCCASIONS. THE MOTORCYCLE WAS TAKEN TO THE DEALER WHERE IT WAS INFORMED THAT THE CONTACT WAS DRIVING TO SLOW WHICH CAUSED THE MOTORCYCLE TO OVERHEAT. THE COMPUTER WAS REPROGRAMMED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE), HOWEVER THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 900.

WE WERE PART OF A NATIONAL BIKE CLUB RIDE TO A BEACH RESORT ACCOMPANIED BY APPROXIMATELY 300 RIDERS. WHEN WE DEPARTED ABOUT 7 AM, TEMPERATURES WERE IN THE LOW 70'S. THE ROUTE WAS MOSTLY DOWNHILL AND WE MAINTAINED AN AVERAGE SPEED OF ABOUT 50, 60 MPH. AFTER JUST OVER ONE HOUR WE ARRIVED AT THE RESORT WHERE WE ALL MOVED TO A LARGE GRAVEL PARKING AREA NEAR THE BEACH. WITHIN SECONDS AFTER I SHUT DOWN AND DISMOUNTED, GREY SMOKE STARTED SEEPING UP BETWEEN THE BODY PANELS WHICH QUICKLY TURNED INTO BLACK SMOKE SMELLING STRONGLY OF BURNING INSULATION. IN LESS THAN A MINUTE FIRE BROKE OUT FROM THE FRONT TOP VENTS AND BURNED THROUGH THE UPPER PLASTIC BODY PANELS EXTENDING MORE THAN 3 FEET INTO THE AIR. A FAST THINKING MEMBER RUSHED UP WITH A CO2 FIRE EXTINGUISHER AND STARTED EXTINGUISHING THE FIRE THAT BY THEN FLOWED OUT FROM UNDER THE BIKE AN THREATENED BIKES PARKED NEARBY. FORTUNATELY, THE FIRE WAS PUT OUT WITHIN 2 OR 3 MINUTES WITH NO DAMAGE TO OTHER PROPERTY OR ANY INJURIES. AT NO TIME DURING THE RIDE OR AT ANY OTHER TIME, EVEN WHEN AMBIENT TEMPERATURES WERE OVER 80 DID THE TEMPERATURE GAUGE REGISTER MORE THAN NORMAL. IT WASN'T UNTIL THE DAY AFTER THE INCIDENT THAT A FRIEND INFORMED ME THAT THERE HAD BEEN A RECALL ON THE YEAR & MODEL WARNING OF POSSIBLE FIRE HAZARD. ALSO, UPON CLOSE INSPECTION IT WAS NOTED THAT ONE OF THE FUEL LINES WAS BURNED, AND WAS LEAKING. *TR

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER ROADSTER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS UNAVAILABLE.

2013 CAN AM SPYDER RT. CONSUMER WRITES IN REGARDS TO RECALL RECEIVED REGARDING ELEVATED TEMPERATURE IN THE ENGINE COMPARTMENT. *SMD THE CONSUMER IS CURRENTLY WAITING FOR THE BIKE TO BE REPAIRED. *JB UPDATED 12/17/15 *JB

ON 26 MARCH 2015 I RODE HOME AFTER WORK OF APPROXIMATELY 30 MILES. THE OUTSIDE AIR TEMPERATURE THIS DAY WAS APPROXIMATELY 85 DEGREES AS A HIGH THAT DAY. UPON ARRIVING HOME, I LEFT MY 2013 CAN AM SPYDER RT SE-5 OUT SIDE THE GARAGE AS DIRECTED BY THE INTERIM RECALL NOTICE. I GOT OFF MY SPYDER AND NOTICED A STRANGE SOUND COMING FROM UNDER THE SEAT. I REMOVED MY HELMET AND LIFTED THE SEAT. THE SOUND WAS COMING FROM THE GAS TANK. I REMOVED THE GAS CAP AND COULD SEE GAS BOILING IN THE TANK. I HAVE NOTICED STRONG GAS SMELLS AND REPORTED THAT EARLY, BUT NEVER HAVE I HAD GAS BOILING IN THE TANK. I PUT THE GAS CAP BACK ON AND PUT MY HELMET IN THE GARAGE. I REOPENED THE GAS CAP IT WAS STILL BOILING AND WAS GOING TO FILM THIS, BUT WAS FEARFUL SOMETHING MIGHT HAPPEN. I CONTACTED MY DEALER WHO RETURNED MY CALL THE NEXT DAY. HE RELATED THEY HAD EXPERIENCED THAT BEFORE DURING THE SUMMER MONTHS. THEY SAID IT WAS STILL SAFE TO RIDE AND TAKE THE APPROPRIATE PRECAUTIONS AND WE WOULD HAVE TO SEE HOW THE RECALL DESIGN DISSIPATES THE HEAT. I CONTACTED A SECOND DEALER WHO RELATED THEY CONTACTED BRP AND NO ONE HAS REPORTED OR DEALT WITH ISSUES LIKE THIS? THEY RECOMMENDED I TRANSPORT THE UNIT TO THEM APPROXIMATELY 3 HOURS AWAY. I CALLED A THIRD DEALER AND WAS ADVISED OF THE PENDING RECALL. BOILING GAS IS SCARY IN MY BOOK, SINCE WHEN YOU ARE RIDING THE SPYDER YOU ARE RIDING VIRTUALLY ON TOP OF THE GAS TANK. THIS IS A BIT DISCOURAGING FOR THE AMOUNT OF MONEY TO PURCHASE THIS UNIT. *TR

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) AND STATED THAT THE PARTS WERE NOT AVAILABLE UNTIL MID MAY 2015. THIS WAS AN UNREASONABLE TIMEFRAME BECAUSE THE DEALER AND THE MANUFACTURER HAD NO INTERIM REPAIR TO APPROVE FOR THE AUTHORIZED DEALER. THE DEALER DID NOT PROVIDE A SPECIFIC DATE WHEN THE PART WOULD BECOME AVAILABLE TO REPAIR THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIRS. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL*THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THERE WAS A BURNING FUEL ODOR AS WELL AS EXCESSIVE HEAT COMING FROM THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 700.

TO BRP CAN AM SPYDER 2013 CAN AM SPYDER RT LIMITED 9-29-2014 I HAVE A BRAND NEW CAN AM SPYDER RT LIMITED STOPPED ON ME 2 TIMES IN FIRST GEAR WITH 120 MILES. NEXT THIS BIKE STOPPED ON ME AGAIN 11 TIMES OVER THE WEEKEND. THIS BIKE SHUTS OFF AT EVERY LIGHT I STOP AT. WHICH IS DANGEROUS. I WAS ALMOST REAR ENDED AT LEAST 2 TIMES .. I TOLD MY SALESMAN THAT I HAVE A STRONG GAS SMELL IN MY GARAGE .I TOOK BIKE AND DEALERSHIP TOLD ME TO LEAVE OVERNIGHT DUE TO STRONG GAS SMELL AND SHUTTING OFF. MY BIKE WAS READY FOR PICK UP THE NEXT DAY. I WAS TOLD THE CANISTER WAS OK AND THE LOUD FUEL SMELL SHOULD BE GONE .I WAS ADVISED THAT ALL RECALLS FOR THIS MODEL HAVE BE DONE. I WAS TOLD DEALER DID A GAS TREATMENT AND WAS ADVISED BIKE IS A 2013 MODEL WHICH HAD GAS SITTING IN TANK FOR A LONG TIME . I WAS ASK IF I TOP OFF GAS AND I TOLD THE DEALER NO! I READ ALL THE BOOKLET AND WATCH VIDEO PERTAINING TO THIS BIKE ALONG WITH SIGNING UP FOR SPYDERLOVER.COM. . I KNOW ALL BIKE HAVE BREAK IN PERIODS, BUT THIS IS TOTALLY UNACCEPTABLE AND SURELY NOT SAFE. I WAS INFORMED TO JUST RIDE MY BIKE AND TO REV THE ENGINE WHEN IT SEEMS LIKE IT'S GOING TO SHUT OFF. NOW WITH 500 MILES THE FUEL SMELL IS EVEN STRONGER AND I HAVE LOST COUNT ON HOW MANY TIMES IT SHUTS OFF IN 1ST GEAR AT A LIGHT OR JUST SITTING IN THE GARAGE. I CALL THE DEALER AGAIN. THEY INFORMED ME THAT AFTER 1,000 TO 1,500 MILES THESE ISSUES SHOULD GO AWAY AFTER THE 600 SERVICE. NOW, . THE REASON FOR THIS LETTER IS THAT THIS BIKE IS NOT SAFE BECAUSE OF

VEHICLE IS EXTREMELY HOT. RIGHT FOOT GETS UNBEARABLE HEAT. GAS FUMES PRESENT AT EVERY STOP. GAS FUMES FILL GARAGE WHEN BIKE IS HOT AND PARKED. CAN AM REFUSES TO DISCUSS THE DANGER OF GAS FUMES WHICH ARE EXTREMELY DANGEROUS IN A CLOSED ENVIRONMENT.THIS SAFETY ISSUE MUST BE ADDRESSED AS INDIVIDUAL OWNERS ARE POWERLESS TO GET CAN AM TO RESPOND TO THIS DANGEROUS SITUATION. PLEASE HELP *TR

I BOUGHT MY 2013 CAN AM SPYDER RT NEW IN FEB 2014. OVER THE YEAR THAT I HAVE OWNED THE BIKE, I HAVE NOTICED EXCESSIVE HEAT UNDER THE SEAT ALONG WITH A GAS SMELL. I HAD TALKED WITH VENDOR ON SEVERAL OCCASIONS AND HEARD VARIOUS OTHER EXPLANATIONS. I DID NOT GIVE IT TOO MUCH THOUGHT UNTIL I READ THE FORUMS AND SAW THIS WAS A COMMON SEVERE ISSUE. UNTIL RECENTLY THE CAN AM WAS KEPT IN AN OPEN AIR CARPORT, SO I NEVER NOTICED THE ODOR AFTER A RIDE. I HAD EXPERIENCED GAS FUMES AND SMELLS ON RIDES AND JUST DIDN'T THINK IT WAS A DEAL WHEN THE VENDOR KEPT TELLING ME NOT TO OVER FILL THE TANK. I DON'T OVER FILL THE TANK AND STOP AFTER THE FIRST CLICK WHICH THEN CAUSES THE TANK NOT TO BECOME FULL AND HAVING TO STOP MORE OFTEN TO REFUEL ON LONG RIDES. WHEN WE MOVED INTO OUR NEW HOUSE WE NOW HAVE A TWO CAR GARAGE AND AFTER THE LAST FEW RIDES, I GAS UP BEFORE COMING HOME AND NOTICE A STRONG GAS ODOR AND LEAVE THE GARAGE DOOR OPEN FOR AN HOUR OR UNTIL THE FUMES DISSIPATE. NOW READING OF THE MAJOR HEAT AND FUME ISSUES IS EXTREMELY SCARY TO ME AND CAUSES SOME CONCERN IF THE MANUFACTURE NEW OF THIS ISSUE WHEN THE UNIT WAS SOLD TO ME IN FEB 2014. I WILL HAVE TO PAY ATTENTION THE NEXT TIME ON A RIDE AND SEE IF THE GAS IS BOILING AS REPORTED ON OTHER UNITS. I HAVE READ ON THE FORUMS AND FACEBOOK A RECALL IS PENDING TO RESOLVE THE HEAT ISSUE WHICH HOPEFULLY WILL RESOLVE THE GAS FUME ISSUE AS WELL. *TR

MY SPYDER HAS BEEN LEAKING OIL SINCE THE DAY I BOUGHT IT NEW. I HAVE OWNED IT FOR 6 MONTHS, HAS BEEN IN THE SHOP SEVERAL TIMES. STILL LEAKING. GAS FUMES SO BAD COMING FROM THE ENGINE AFTER RIDING I CAN NOT CLOSE THE GARAGE DOOR FOR AT LEAST AN HOUR/. SMELLS OF GAS REALLY STRONG EVERY TIME I AM ON THE BIKE. GAS CAP SO HOT I CAN HARDLY TOUCH IT WHEN I NEED TO GET GAS. *TR

PURCHASED MY 2013 CAN-AM SPYDER ON 03/05/14, IN SPRINGFIELD, MI. MY HOME ADDRESS IS NEW IBERIA, LA. I DROVE THE BIKE BACK HOME. MY FIRST FUEL STOP I WAS OVERWHELMED BY THE STRONG SMELL OF GASOLINE AND I CAN SMELL GAS FUMES EVERY TIME I FUEL UP. AT EVERY FUELING I HAVE TO USE GLOVES OR A RAG TO PUT OVER THE GAS CAP TO UNSCREW IT BECAUSE IT IS SO HOT. THEN WHEN I TRY TO UNSCREW THE CAP IT JUST RATCHETS WITH OUT UNSCREWING IT. I HAVE SPENT AT LEAST 30 TO 45 MINUTES TRYING TO UNSCREW THE CAP AND AFTER TANK COOLS OFF THE GAS CAP RELEASES, THEN YOU CAN FUEL UP. ON SEVERAL OCCASIONS I HAVE HAD TO PRY THE GAS CAP WITH A SCREW DRIVER TO REMOVE IT AND THEN YOU CAN HEAR THE FUEL BOILING IN THE TANK. I HAD 3 GAS CAPS FROM ANOTHER RECALL AND TRIED ALL 3 CAPS AND THEY DID THE SAME THING, JUST RATCHET AND NOT UNSCREW. WHILE TRAVELING I WAS IN PENSACOLA, FL AND COULD NOT REMOVE THE GAS CAP AND WENT TO THE DEALERSHIP THERE AND THEY REPLACED THE GAS CAP AFTER IT COOLED OFF. THE NEXT DAY I HAD TO RE-FUEL AND THE CAP THEY JUST PUT ON WOULD NOT UNSCREW. THURSDAY OCTOBER 30, 2014, I HAD TO REFUEL AND COULD NOT OPEN THE FUEL TANK AND HAD TO PRY IT OPEN WITH A SCREW DRIVER TO PUT FUEL TO GET HOME. WHILE DOING SO THE CAP WAS SO TIGHT THAT THE TOP PORTION BROKE OFF LEAVING THE BOTTOM PORTION IN THE FUEL TANK NECK. IT GETS SO HOT MY RIGHT FOOT ACTUALLY BURNS FROM THE ENGINE HEAT. WHEN I WANT TO CRANK THE BIKE AFTER FUELING THE BIKE DOES NOT WANT TO CRANK. IT SPINS THE ENGINE FOR A LONG TIME BEFORE IT C

THE BIKE GETS VERY HOT. I HAVE ALREADY HAD THE EXAUST WRAPPED BUT IT IS STILL VERY HOT TO RIDE. *TR

600 MILE SERVICE COMPLAINED TO DEALER OF EXTREME FUEL SMELL AFTER RIDES. WAS TOLD THAT THE PURGE VALVE WAS BAD AND THEY REPLACED IT UNDER WARRANTY. RODE HOME AND NOTICED THAT THE FUEL SMELL WAS THE SAME. WHEN I CHECKED UNDER THE ROADSTER I FOUND FUEL DRIPPING FROM THE BOTTOM OF THE ROADSTER. I CALLED DEALER AND WAS TOLD TO TOP OFF THE FUEL TANK BEFORE PUTTING VEHICLE IN GARAGE. DEALER SAID THAT THIS WAS NORMAL. 4600 MILE SERVICE AGAIN COMPLAINED OF EXTREME FUEL SMELL AFTER RIDES. ASKED DEALER ABOUT HOT HOT RIGHT FOOT WAS TOLD BY DEALER THIS WAS NORMAL AND THE ROADSTER WAS OPERATING NORMALLY. 9200 MILE SERVICE COMPLAINED OF EXTREME FUEL SMELL AND HEAT ON RIGHT FOOT, NO HEAT LEFT HAND GRIP, AND INTERMITTENT HEAT ON RIGHT HAND GRIP, WARPED RIGHT HAND CENTER BODY PANEL. WHEN SERVICE WAS COMPLETE I ASKED ABOUT NO HEAT ON HAND GRIPS. TECHNICIAN FOUND LOOSE CONNECTORS AT BOTH HAND GRIPS AND THAT THE CONNECTIONS COULD BE A PROBLEM IF THERE WERE GAS FUMES IN THE AREA. BODY PANEL ORDERED AND REPLACED UNDER WARRANTY. TOLD BY DEALER THAT THE PANEL WAS BENT FROM FACTORY NOT HEAT. TECHNICIAN AND SERVICE MANAGER DID NOT AGREE AND BOTH SAID IT WAS CAUSED BY EXCESSIVE HEAT. *TR

HAVE OWNED RT LIMITED FOR LESS THAN ONE YEAR WITH HEAT ISSUES. WHILE RETURNING FROM EVENT IN NORTH CAROLINA BIKE RAN FINE IN THE COOLER TEMPERATURES. AS SOON AS RETURNED TO THE SOUTH, ENGINE BEGAN TO RUN HOT AND CHECK ENGINE LIGHT ON AND OFF AS WELL AS BIKE CHUGGING AND RUNNING ROUGHLY. BIKE SHUTTING DOWN AND HAD TO LET COOL OFF BEFORE WOULD RESTART. HAVE HAD EXTREME HEAT ISSUES SINCE PURCHASING BIKE ESPECIALLY IN HOTTER MONTHS HERE IN HOUSTON AREA. HAVE HAD UPDATES DONE PER BRP RECOMMENDATIONS TO NO SUCCESS. BIKE IS NOT SAFE AND FEAR RIDING ANY LENGTH OF TIME OR PROLONGED DISTANCE. WHEN PARKED IN GARAGE AFTER RIDING FIND THERE IS A STRONG GAS SMELL IN THE GARAGE. FOR THIS REASON USUALLY LEAVE BIKE IN YARD FOR UPTO 30 MINUTES PRIOR TO PUTTING GARAGE FOR FEAR OF FIRE CONSUMING HOME. NOT SURE WHAT THIS REPORT WILL DO BUT FEEL LIKE SOMEONE SHOULD BE MADE AWARE OF HOW UNSAFE AND POTENTIALLY DANGEROUS THESE VEHICLES ARE. DEALERS ARE AT A LOSS FOR WHAT TO DO AS I HAVE EXPERIENCED SAME PROBLEMS WITH A 2013 ST LIMITED MODEL THAT WAS TRADED DUE TO BRAKE FAILURE AND EXTREME HEAT ISSUE MELTING PARTS. THOUGHT THE RT MODEL WOULD BE BETTER BUT FIND MYSELF IN SAME SITUATION. *TR

SMELL GAS VAPORS IN THE GARAGE AND HOUSEBAFTER DRIVING IT. SEAT FRONT TOP WHERE IT MEETS THE BODY(STORAGE COMPARTMENT) TO HOT TO TOUCH OR SIT ON WITHOUT A SHEEPSKIN PAD AND STILL VERY UNCOMFORTABLE AND LIKELY DANGEROUS. RIGHT FOOT GETS SO HOT FROM THE MOTOR YOUR CAN'T KEEP YOUR FOOT IN PLACE. HAVE TO WEAR HEAVY BOOTS. HAVE HAD THE RECALL AND ELECTRONIC UPDATES. *TR

NOTICED BAD FUEL SMELL FROM DAY ONE OF OWNING THE SPYDER. WOULD LEAVE OUTSIDE WHILE IT COOLED OFF OR PUT A BOX FAN ON IT TO BLOW THE VAPORS OUT OF THE GARAGE. IN AUGUST OF 2013 I NOTICED THE BRAKE LIGHTS STAYING ON, REMOVED SIDE PANEL TO FINED THE WIRES MELTED AND SHORTED TOGETHER. I ALSO NOTICED THE PLASTIC ON THE MASTER CYLINDER SHOWED SIGNS OF MELTING AND OF GETTING HOT. I REPAIRED THE WIRES WITH HIGH TEMPERATURE ELECTRICAL TAPE. I RECEIVED A SAFETY RECALL NOTICE FROM BRP IN SEPTEMBER FOR HEAT RELATED PROBLEMS. THE DEALER FOUND THE FUEL EVAPORATOR CANISTER ALMOST BURNED THROUGH, IT WAS REPLACED AND COVERED IT WITH TIN FOIL HEAT SHIELD. THE DEALER DID NOT THINK THE BRAKE MASTER CYLINDER WAS MELTED BAD ENOUGH TO WARRANT CHANGING AND COVERED IT WITH TIN FOIL HEAT SHIELD. I HAD THEM TO LEAVE THE WIRING AS I HAD ALREADY REPAIRED IT. THE BAD FUEL SMELL CONTINUED WITH THE NEW FUEL EVAPORATOR CANISTER AND THE FUEL BOILS WHERE YOU CAN HEAR IT AFTER A RIDE. IF YOU LOOK UNDER THE SPYDER AFTER A RIDE YOU CAN SEE FUEL VAPORS SPEWING AND DRIPPING FROM THE VENT LINE, AND IT WILL CONTINUE FOR MAYBE AN HOUR OR LONGER. IT IS SOMETIMES HARD TO PUT FUEL IN BECAUSE IT MAKES THE GAS PUMP NOZZLE KEEP CUTTING OFF. *TR

I WAS RIDING ON HIGHWAY 291 IN LEES SUMMIT MO TRAVELING AT 65 MPH. THE DAILY TEMP WAS BETWEEN 92 - 95 DEGREES. THE FAN WAS BLOWING THE HOT AIR OUT FROM THE BIKES RADIATOR AREA AND WITH THE BIKE BEING IN MOTION THE HOT AIR WAS BEING ROUTED ONTO MY RIGHT LEG AND I COULD FEEL MY LEG GETTING HOT TO THE POINT THAT I WAS UNABLE TO KEEP MY FOOT ON THE FOOT PEG FOR LONGER THAN 10-15 SECONDS AFTER WHICH, I NEEDED TO KEEP SHIFTING THE LOCATION OF MY FOOT ON THE FOOT PEG. I ALSO NOTICED THAT THE RIGHT SIDE PANELS AND THE AIR COMING FROM UNDER THE SEAT WAS UNCOMFORTABLY HOT. ALSO WHEN REFUELING THE GAS TANK FILLER NECK WAS TOO HOT TO TOUCH. DURING THE FIRST LONG TRIP ON THIS BIKE (WEEKEND OF OCT 25-26) FROM GRAIN VALLEY MO TO EUREKA SPRINGS AR (540 MILES ROUND TRIP). TEMPS WERE IN THE 70'S DURING THE TRIP TO AR AND WHEN REFUELING I NOTICED THAT THE GAS TANK FILLER NECK WAS OVERLY WARM. THE RETURN TRIP, WITH TEMPS IN THE MID 80S, THE HEAT ON MY RIGHT LEG WAS BECOMING UNCOMFORTABLE, THE RIGHT SIDE PANELS WERE HOT AND THE HEAT UNDER THE SEAT WAS OVERLY WARM. REFUELING, THE GAS TANK FILLER NECK WAS ALMOST TOO HOT TO TOUCH. *TR

I TOOK A TRIP TO GEORGIA ON OCTOBER 24, , AND ON SUNDAY MORNING, OCTOBER 26, WHEN I STARTED THE SPYDER TO LEAVE, IT BEGAN TO STALL AT IDLE, IT CUT OFF REPEATEDLY, AND IDLED ROUGH. IT WOULDN'T MAINTAIN THE NORMAL IDLE RANGE OF 1200-1300 RPM. I FINALLY WAS ABLE TO DRIVE IT OFF, AND AS I RODE, THE IDLE WAS ROUGH FOR A FEW MILES, BUT AFTER I GOT IT ON THE FREEWAY, IT SEEMED OKAY. ONCE AGAIN, THE HEAT ISSUE AND FUEL SMELLS BECAME EVIDENT AS I RODE BACK TO ALABAMA, AND THE OUTSIDE TEMPERATURE ROSE. IT SEEMS THAT ANY OUTSIDE TEMPERATURES ABOVE 70 DEGREES AND THE HEAT FROM THE VEHICLE BECOMES WORSE WITH THE RESULTING FUEL SMELL AND A LOT OF HEAT COMING FROM THE ENGINE AND FUEL TANK WHEN GOING TO FILL UP. I WAS A BIT WORRIED BEING SO FAR FROM HOME, BUT I GOT BACK OKAY. *TR

ON FRIDAY, 24 OCTOBER 2014I RODE THE SPYDER TO THE DEALER, WHERE THE TECHNICIAN, [XXX], CONNECTED IT TO THE B.U.D.S. COMPUTER. I AM ALSO SENDING [XXX]. A COURTESY COPY OF THIS EMAIL. THE COMPUTER OBTAINED INFORMATION THAT POINTED TO A PROBLEM WITH THE PURGE VALVE AND VAPOR RECOVERY CANISTER, AS WELL AS A PROBLEM WITH THE ENGINE CONTROL MODULE (ECM). THIS IS IN ADDITION TO HEAT AND GAS VAPOR ISSUES WHEN THE AMBIENT OUTSIDE TEMPERATURE IS 75 DEGREES AND ABOVE. YESTERDAY AFTERNOON 27 OCTOBER 2014, I TOOK THE SPYDER ON A RIDE YESTERDAY OF ABOUT 30 MILES ON LOCAL ROADS. AFTER I RETURNED HOME AND SHUT OFF THE SPYDER BRIEFLY TO OPEN THE GARAGE DOOR, IT DIDN'T WANT TO START. THE STARTER TURNED THE MOTOR OVER, BUT THE MOTOR WOULD NOT START. AFTER 4 ATTEMPTS, I WAS FINALLY ABLE TO GET IT STARTED. I AM FORTUNATE THAT THIS DID NOT HAPPEN OUT ON THE ROAD. THE SPYDER HAD A STRONG GAS VAPOR SMELL, WHICH WAS STILL EVIDENT THE MORNING IN MY GARAGE. I CHECKED THE SPYDER THIS MORNING AND IT STARTED WITH NO PROBLEM. I SUSPECT THE ECM AND PURGE VALVE CODES THAT THE B.U.D.S. COMPUTER DETECTED ARE TO BLAME, BUT THE HEAT ISSUE IS SOMETHING THAT BRP NEEDS TO ADDRESS. I, ALONG WITH MANY OWNERS OF THE CAN-AM SPYDER, HAVE CONCERNS WITH SAFETY AND HEAT ISSUES. I WILL SAY THAT I ENJOY THE SPYDER, BUT I WOULD ENJOY IT FAR MORE IF MY CONCERNS WITH SAFETY AND RELIABILITY ARE ADDRESSED. MY SPYDER IS STILL UNDER BRP ORIGINAL WARRANTY, AND I'D LIKE THESE PROBLEMS TO BE ADDRESSED BY BRP UNDER THOSE TERMS AND NOT

I PURCHASED A CAN AM SPYDER RT 2013 ON AUGUST 23, 2013. FROM DAY ONE I'VE HAD EXCESSIVE FUEL SMELLS AFTER RIDES,ALSO GAS BOILING IN FUEL TANK AFTER RIDES. YOU CAN ACTUALLY HEAR AND SEE THE GAS BOILING IN THE TANK. THERE IS EXCESSIVE HEAT COMING OUT FROM AROUND THE GLOVE BOX AREA AND ALSO AROUND THE PASSENGER RIGHT FOOT REST. NEEDLESS TO SAY ALL THIS HEAT MAKES FOR AN EXTREMELY UNCOMFORTABLE RIDE. I HAVE HAD ALL RECALLS AND UPDATES DONE TO DATE. SEPTEMBER 2013 TOLD MY DEALER OF EXCESSIVE FUEL SMELLS WHILE THE BIKE WAS IN HAVING THE HEAT SHIELDING RECALL WORK PERFORMED. HE SAID THAT HE DID NOT SMELL THE FUEL COMING FROM THE BIKE. I WENT BACK A WEEK LATER TO HAVE WORK DONE TO THE AIR RIDE SUSPENSION THAT WAS BROKEN UPON RECEIVING MY NEW BIKE. WHILE HE WAS WORKING ON THE BIKE REPAIRING THE AIR RIDE SUSPENSION HE NOTICED THE SMELL AND REPLACED MY EVAP.CANISTER. THIS WAS AFTER I HAD THE RECALL DONE. HE HAD TO REMOVE THE RECALL WORK AND REPLACE MY EVAP CANISTER AND THEN REINSTALL THE RECALL WRAPPING. TODAY OCTOBER 28, 2014 WENT FOR A RIDE FUELED UP ON THE WAY HOME.I RODE HOME APPROXIMATELY 20 MINUTES. WHEN I PARKED THE BIKE I COULD HEAR THE FUEL BOILING AND COULD SEE IT IN THE TANK. OBVIOUSLY ALL THE UPDATES AND RECALLS ARE NOT HELPING. I ALSO HAD HANDLING ISSUES WITH THE BIKE FROM BRAND-NEW. THAT I HAD TO HAVE CORRECTED WITH MY OWN MONEY SPENT. *TR

VEHICLE GIVES OFF SUCH A STRONG FUEL ODOR AFTER A RIDE, WE NOW PARK THE VEHICLE OUTSIDE OUR ENCLOSED GARAGE FOR A FEW HOURS SO THE ODOR WILL NOT BE OVERWHELMING IN OUR GARAGE. ALSO, THE VEHICLE'S FUEL TANK IS VERY HOT TO THE TOUCH WHEN RE-FILLING WITH GAS. VEHICLE WAS TAKEN TO AN AUTHORIZED BMP DEALERSHIP ABOUT THE STRONG FUEL ODOR AND THEY DID NOT FIND ANYTHING WRONG. *TR

THIS IS MY THIRD COMPLAINT REGARDING THIS VEHICLE. IN ADDITION TO THE SEVERE HEAT AND GASOLINE ODOR PROBLEMS WHICH I DESCRIBED IN EARLIER COMPLAINTS, THE VEHICLE HAS BECOME VERY HARD TO START WHEN THE ENGINE IS WARM. NORMAL IDLE RPM IS 1,300 TO 1,400. WHEN THIS CONDITION OCCURS - AS IT HAS ON MULTIPLE OCCASIONS - THE RPM DOES NOT EXCEED 500, AND THERE IS LIMITED THROTTLE RESPONSE. THE ENGINE STALLS, AND THERE IS AN OVERPOWERING ODOR OF GASOLINE EMANATING FROM THE VEHICLE AS IF THE THROTTLE BODY IS BEING FLOODED WITH GASOLINE. THE DEALER AND BRP (BOMBARDIER RECREATIONAL PRODUCTS) HAVE BEEN MADE AWARE OF THIS PROBLEM. BRP HAS PROPOSED THAT MY DEALER REPLACE THE PURGE VALVE AND OXYGEN SENSOR TO ADDRESS THIS PROBLEM, AS WELL AS THE PREVIOUSLY MENTIONED HEAT PROBLEM. I AM WAITING FOR THE DEALER TO OBTAIN THE REPAIR PARTS. I WAS TOLD BY A REPRESENTATIVE FROM BRP THAT IF THESE REPAIRS DID NOT FIX THE PROBLEMS, THERE WOULD BE NOTHING MORE THAT THEY COULD DO TO ADDRESS THEM. I, AS WELL AS MANY OTHERS, BELIEVE THAT THERE ARE MAY DESIGN FLAWS WITH THIS VEHICLE. THE FRAME FOR THE 2013 RT WAS INTENDED TO HAVE A NEW ENGINE, A 1330 CC INLINE THREE CYLINDER RATHER THAN THE 998 CC V-TWIN. THE BRP REPRESENTATIVE ADMITTED TO ME THAT THE NEW ENGINE FOR THIS VEHICLE "WAS NOT READY" AT THE TIME OF PRODUCTION OF THE 2013 MODEL, AND THEY WERE FORCED TO USE THE OLDER ENGINE. THIS ENGINE RUNS VERY HOT, AND BEING FULLY ENCLOSED BY PLASTIC PANELS EXACERBATES THE PROBLEM. IT IS INFURIATING TO SPEND $27,0

DURING A TRIP IN SEPTEMBER OF 2013 TO UPSTATE NY, THE BIKE STARTED TO GIVE OFF A STRONG SMELL OF GAS & MELTING PLASTIC. THE BIKE WENT INTO LIMP MODE SO I PULLED INTO A NEAR BY GAS STATION IN ORDER TO GET OFF THE ROAD. I LET THE BIKE SIT FOR ABOUT 15 TO 20 MINUTES SO IT WOULD RESET. WHEN I STARTED THE BIKE UP AGAIN IN REMAINED IN LIMP MODE. I CONTACTED THE NEAREST LOCAL DEALER AND RODE THE BIKE TO THEM FOR SERVICE. UPON INSPECTION THE TECHNICIAN DISCOVERED THAT THE LOWER RIGHT HAND BODY PANEL WAS DAMAGED DUE TO EXCESSIVE HEAT IN ADDITION THE FUEL EVAPORATOR CANISTER HAD MELTED AND HAD DEVELOPED NOTICEABLE HOLE. *TR

WENT FOR A RIDE HAD FUEL SMELL WHEN STOP AT LIGHT ,TOOK A BREAK AT FAST FOOD PLACE AND SMELLED FUEL AGAIN LOOK ON DRIVEWAY SAW FUEL VAPORS , WENT HOME PARKS IN GARAGE ,LATER SMELLED FUEL, HAD TO OPEN DOORS AND WINDOWS TO LET THE SMELL OUT , THIS HAPPEN SEVERAL TIMES ,WENT TO DEALER TO FIND OUT WATT GOING ON WITH THE SPYDER THEY WORK ON IT 3 -4 TIMES . THIS BIN GOING BACK TO DEALER ALL SUMMER LONG ABOUT THE HEAT AND SMELL THEY DON'T KNOW WHAT TO DO ABOUT IT. *TR

I PURCHASED THIS WHEN THERE WAS A LARGE REBATE FOR BUYING THE 2013 SPYDERS. I HAVE BEEN PLAGUED WITH A HOT SEAT AND RIGHT FOOT SINCE THE BEGINNING. I WIND UP HAVING TO MOVE MY RIGHT FOOT TO THE REAR PASSENGER FLOOR BOARD TO ESCAPE THE HEAT AND THERE ARE TIMES WHERE MY INNER THIGHS ARE BURNED WHERE THE HEAT IS COMING UP AROUND THE SEAT. I FOUND OUT THAT THERE WAS A RECALL ON THIS BIKE AND WILL BE HAVING THIS DONE AS SOON AS THEY GET THE PARTS IN BUT FROM READING INFORMATION ON A BLOG THAT I SUBSCRIBED TO, IT PROBABLY WON'T HELP. I ALSO UNDERSTAND THAT THERE IS AN INVESTIGATION GOING ON AND WANT TO ADD MY INFORMATION TO IT. THANKS *TR

PURCHASED DEMO THE END OF SEPTEMBER 2013. LIMITED RIDING BEFORE PUT AWAY FOR THE WINTER. STARTING IN THE SPRING I STARTED NOTICING A STRONG GASOLINE SMELL AND EXTREME EXCESSIVE HEAT. FUEL CAP IS EXTREMELY HOT AND GAS IS BOILING WHICH MAKE FILLING HARD AS NOZZLE KEEPS SHUTTING OFF. THIS IS OCCURRING IN AMBIENT TEMPERATURES AS LOW 53 DEGREES. THE RECALL AND ALL SERVICE BULLETINS HAVE BEEN COMPLETED AND THE FUEL CANISTER HAS BEEN REPLACED IN SEPTEMBER 2014. WITHIN 200 MILES, THE GAS SMELL RETURNED AND IS NOTICEABLE BY MY HUSBAND RIDING BEHIND ME AT 15 MPH. WHEN STOPPED IN TRAFFIC THE SMELL IS OVERWHELMING. THE EXTREME HEAT CONTINUES AND I TO WEAR EXTRA PROTECTION ON MY LEGS. I HAVE KEPT OUR DEALER ADVISED OF THE HEAT ISSUES. *TR

I WAS TRAVELING IN STOP AND GO TRAFFIC WHEN THE SPYDER STARTED PRODUCING EXCESS HEAT FROM UNDER THE MACHINE AND AROUND THE GAS TANK. I STOPPED AT A GAS STATION TO FILL THE TANK AS IT HAD ABOUT AN 1/8 OF A TANK. THE GAS CAP WAS SO HOT IT COULDN'T BE TOUCHED FOR TEN MINUTES. YOU COULD HEAR THE GAS BOILING IN THE TANK. UPON GETTING THE CAP OFF, IT TOOK SEVERAL MINUTES TO PUMP GAS INTO THE TANK AS THE NOZZLE KEPT SHUTTING OFF. THE OUTSIDE TEMPERATURE WAS 83 DEGREES. IT WAS GIVING OFF A VERY STRONG GAS SMELL. I RETURNED TO MY DEALER AND EXPRESSED MY CONCERNS AND THEY SAID THEY WOULD CONTACT BRP. THE DEALER HAS WRAPPED THE HEADER PIPES AND REPLACED THE EVAPORATOR CANISTER AND PURGE VALVE MANY TIMES. AT THIS TIME MY SPYDER HAS 22500 MILES AND THE GAS CAP CAN'T BE TIGHTENED COMPLETELY BECAUSE IT WON'T UNSCREW IF THE SPYDER IS WARM. I AM STILL HAVING ALL THESE PROBLEMS WITH MY SPYDER AND BRP HASN'T BEEN ABLE TO FIND A SOLUTION. *TR

I PURCHASED MY CAN-AM SPYDER IN AUGUST OF 2013. THE RECALL FOR THE HEAT ISSUES WAS COMPLETED IN SEPTEMBER OF 2013 BY MY DEALER. OVER THE LAST YEAR I HAVE HAD INCIDENTS OF A GAS SMELL, SOMETIMES VERY STRONG, AND HEAT FROM THE ENGINE AREA. RECENTLY, A BURNING PLASTIC SMELL HAS BEEN OCCURRING. IT IS NOTICED AT DIFFERENT SPEEDS. FIRST INCIDENT WAS AROUND 40 MILES PER HOUR ON A 2 LANE ROAD, NEXT TIME WAS GOING DOWN A FAIRLY STEEP HILL AROUND 30 MILES PER HOUR, AND THE THIRD INCIDENT WAS ON A 50 MILE PER HOUR 2 LANE ROAD. THESE INCIDENTS WERE ON DIFFERENT DAYS. THE BURNING PLASTIC SMELL WAS ALSO NOTICED BY MY RIDING PARTNER BEHIND ME. I AM VERY CONCERNED WITH THE FIRES THAT HAVE OCCURRED WITH THESE MACHINES AND THE INVESTIGATION BEING DONE BY NHTSA. I HAVE BROUGHT THE SPYDER RT TO MY DEALER BUT THEY SAID THEY DID NOT SEE ANY ISSUES THAT COULD BE CAUSING THE BURNING PLASTIC SMELL. *TR

EXCESSIVE HEAT COMING FROM UNDER SEAT CAUSING REDNESS OF LEGS WHERE TOUCHING SEAT & GLOVE BOX GETS HOT TO TOUCH. *TR

I HAVE THE 2013 SPYDER RTL SINCE 11-23-2013. EVER SINCE GETTING IT THERE HAS BEEN EXCESSIVE HEAT COMING FROM THE BIKE, ESPECIALLY ON THE RIGHT SIDE WHERE THE RADIATOR EXHAUST IS VENTED. THE BIKE GETS EXTREMELY HOT WHETHER SITTING STILL OR MOVING. VERY UNCOMFORTABLE ON THE RIGHT LEG AND ANKLE. UNDER THE SEAT AND THE CENTER STORAGE AREA GETS EXTREMELY HOT AFTER RIDING. I FEEL THIS IS VERY DANGEROUS TO THE RIDER. *TR

MY RETURN FROM A SPYDER GATHERING WAS ABOUT 100 MILES TOTAL, INCLUDING SOME STOP AND GO TRAFFIC THRU SEATTLE, AIR TEMPERATURES IN THE LOW 80S (F), AND COMPLETED WITH ABOUT 40 MILES OF OPEN HIGHWAY CRUISING AT 50-60MPH AND AIR TEMPS IN THE HIGH 70S. DURING THIS ENTIRE RIDE, I STRUGGLED TO FIND A POSITION IN WHICH I COULD PLACE MY RIGHT BOOT WHERE IT WAS NOT UNBEARABLY HOT! THE SPYDER NEVER SHOWED ANY SIGNS OF OVERHEATING, BUT MY BOOT SURE DID!!! I WILL ADD THAT I WAS RIDING IN JEANS, LEATHER CHAPS, HIKING BOOTS AND HEAVY SOCKS. POSITIONING MY BOOT IN SUCH A WAY AS TO TRY TO COOL IT DOWN SOME WOULD PLACE IT CONCERNING FAR FROM THE BRAKE PEDAL. I WAS FORCED TO CHOSE BETWEEN SOME HEAT RELIEF AND SAFETY. ? TOWARDS THE END OF MY RIDE, I FINALLY WAS STOPPED BY A TRAFFIC LIGHT, AT WHICH POINT I SMELLED GASOLINE FUMES VERY STRONG THRU MY FULL FACE HELMET! I ALMOST BAILED OFF, BEING CONCERNED THAT THERE WAS A RISK OF FIRE! I TRIED TO LOOK UNDER THE BIKE TO SEE IF FUEL WAS LEAKING BUT THE LIGHT TURNED GREEN AND I HAD TRAFFIC BEHIND ME. THE FUEL GAUGE AT THIS POINT READ A BIT LESS THAN HALF A TANK. I WAS HOME IN MY DRIVEWAY IN JUST ANOTHER 5 MINUTES. MY WIFE AND MY NEIGHBOR BOTH CAME OUT TO MEET ME AND ASK HOW MY FIRST LONG RIDE WENT. THEY BOTH SMELLED THE GASOLINE ALSO. I OPENED THE SEAT, WHICH WAS ALSO EXTREMELY HOT UNDERNEATH AND ALLOWED THE SPYDER TO COOL DOWN BEFORE PARKING IT BACK IN MY GARAGE. *TR

AFTER BUYING MY SPYDER I NOTICED EXCESSIVE HEAT COMING FROM THE ENGINE AREA UNDER MY SEAT. AT TIMES ITS SO HOT THAT I CAN BARELY TOUCH MY GAS CAP WITH IS LOCATED UNDER THE SEAT. THERE HAVE BEEN A FEW TIME THAT AFTER RIDING FOR A EXTENDED PERIOD AND STOPPING THE BIKE I'VE NOTICED THE SMELL OF GASOLINE. I'VE CHECKED FOR FUEL LEAKS AND FOUND NONE, AND CALLED THE DEALERSHIP TO COMPLAIN. THEY TOLD ME THAT IT WAS PROBABLY THE FUEL TANK OVER PRESSURIZING BECAUSE OF THE HEAT AND VENTING TO THE AIR. I WAS ADVISED TO PARK THE BIKE OUT SIDE UNTIL IT COOLED DOWN BEFORE BRINGING IT INTO THE GARAGE. WHILE RIDING THE HEAT COMING UP FROM UNDER THE SEAT IS REALLY BAD, MAKING RIDING NOT MUCH FUN. I'VE CALLED BRP TO COMPLAIN ABOUT THE PROBLEM BUT AS OF YET HEARD ANY THING BACK FROM THEM. I'VE READ THAT SEVERAL SPYDER'S HAVE CAUGHT FIRE, AND STILL NOTHING HAS BEEN DONE. MY FELLOW SPYDER RIDERS HAVE ALL COMPLAINED ABOUT THE HEAT PROBLEM, OTHER THAN THAT THE BIKE IS GREAT. I JUST WANT BRP TO COME UP WITH A SOLUTION TO THE HEAT PROBLEM. *TR

EXCESS HEAT COMING FROM ENGINE COMPARTMENT CREATED HEAT BLISTERS ON RIGHT CALF. ALSO, AN INTERMITTENT FUEL SMELL THAT EMANATES FROM THE ENGINE COMPARTMENT. *TR

HEAT UNDER THE SEAT IS TO HOT TO RIDE SAFETY. ALWAYS TRYING TO SHIFT AND OPEN LEGS TO TRY AND GET SOME RELIEF. HEAT COMING OFF THE RIGHT SIDE HAS ACTUALLY CAUSED A RED HEAT RASH ON MY RIGHT SHIN FROM MY ANKLE UPWARDS. WHEN REFUELING I AM SO SCARED THAT THE GAS IS GOING TO FLAME UP BECAUSE OF THE FUMES AND THE HEAT RADIATING FROM UNDER THE SEAT WHICH MUST BE LIFTED TO REFUEL. I HAVE TRIED PLACING ALUMINUM FOIL UNDER THE SEAT IN THE HOPES OF DISSIPATING THE HEAT BUT IT HAS NOT WORKED. I STORE MY CAN AM SPYDER IN A TRAILER AND MUST LEAVE ALL THE DOORS OPEN FOR SEVERAL HOURS UNTIL THE FUMES SUBSIDED. I AM AFRAID OF A FIRE AND HAVE MOVED THE TRAILER FAR AWAY FROM MY OTHER VEHICLES AND HOUSE. *TR

DURING THE SPRING, SUMMER, FALL = I.E.WARM / HOT DAYS / MONTHS THERE IS AN INCREDIBLE AMOUNT OF HEAT [ 100 + DEGREES] COMING FROM THE ENGINE COMPARTMENT. THIS MOTORCYCLE HAS THE FRONT , BOTH SIDES , AND REAR PANELS THAT ENCASE THE MOTORCYCLE. AIR COMES IN FROM THE FRONT THEN GOES AROUND THE ENGINE WITH NO PLACE FOR THE HOT AIR TO GO EXCEPT UP AND OUT WHICH HEATS UP THE SIDE PANELS AND UP THROUGH THE CENTER WHICH HEATS UP THE GAS TANK. AT TIMES WHEN STOP TO REFUEL; WHEN YOU REMOVE THE GAS CAP YOU CAN FEEL THE HEAT COMING FROM INSIDE THE GAS TANK. THIS HEAT DEAL IS EXTREMELY EXCESSIVE AND CAN BURN YOUR FEET, ANKLES,AND LEGS. IF YOU'VE HAD ANKLE REPLACEMENT [METAL ALLOY] THIS HEAT IS UNBEARABLE. BEEN IN CONTACT WITH BRP ON THIS AND SEEM TO BE GETTING THE RUN- AROUND. TRYKE IS AT MY DEALER WAITING FOR THIS PROBLEM TO BE SOLVED. UNSAFE. UNDERSTAND BRP HAS KNOWN ABOUT THIS THE LAST YEAR AND A HALF. CAN YOU HELP. THIS IS TOO NICE A VEHICLE TO HAVE SITTING AT THE DEALER COLLECTING DUST. CAN YOU HELP. *TR

I PURCHASED A 2013 CAN AM SPYDER IN JULY 2013. FROM THE FIRST DAY I PURCHASED THE VEHICLE I HAVE EXPERIENCED WHAT I CONSIDER A DANGEROUS AMOUNT OF HEAT RADIATING FROM THE ENGINE. ALSO, I CAN SMELL GAS FUMES AND I AM TOLD THAT IS BECAUSE THE GAS IS ACTUALLY BOILING DUE TO THE HEAT PROBLEM. I HAVE TRIED DIFFERENT FIXES RECOMMENDED BY OTHER OWNERS AND THEY DID REDUCE THE HEAT SOMEWHAT BUT IT STILL FEELS LIKE I AM RIDING ON A BOMB JUST WAITING TO EXPLODE. SINCE I PAID OVER $27,000 I CAN'T JUST PUT IT AWAY. THE REPUTATION IS SO BAD THE UNIT HAS REALLY DEPRECIATED AND THE ONLY PERSON WILL TO BUY THE VEHICLE WOULD BE SOMEONE WHO DID NOT DO THEIR HOMEWORK. ARE YOU AWARE OF SIMILAR COMPLAINTS AND DO YOU HAVE ANY SUGGESTIONS? I CAN'T GET ANYONE AT BRP TO DISCUSS THE ISSUE. IT IS NOT THE DEALERS FAULT. *TR

2013 RT LIMITED 204 DEGREES HEAT OFF OF BIKE PANELS GAS IS BOILING IN GAS TANK NHTSA CHECK THE BIKE OUT SMELL OF GAS IN GARAGE AFTER RIDING MOTORCYCLE 3750 MILES. *TR

FUEL WILL LEAK OUT OF EVAP CANISTER DUE TO HIGH HEAT CONDITION IN ENGINE COMPARTMENT. REAR AIR BAG LEAKS DOWN AND AFFECTS HANDLING, DEALER SAYS THEY ALL DO IT. *TR