2012 BMW 528i

Defect. BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi vehicles. An improperly sealed electrical connector on the water pump may be exposed to water and short circuit.

Risk. An electrical short increases the risk of a fire.

Remedy. Dealers will inspect and replace the water pump and plug connector as necessary, and install a protective shield, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact BMW customer service at 1-800-525-7417.

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Risk. The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

Remedy. BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.

Defect. BMW of North America LLC (BMW) is recalling certain model year 2014 BMW 328i xDrive Sports Wagon, 2012-2014 BMW 320i Sedan, 328i Sedan, 320i xDrive Sedan, 328i xDrive Sedan, 2012-2013 BMW 528i Sedan, 528i xDrive Sedan, 2013-2014 BMW X1 sDrive28i, X1 xDrive28i Sports Activity Vehicle, 2013-2014 BMW X3 xDrive28i Sports Activity Vehicle, 2012-2014 BMW Z4 sDrive28i Roadster, and 2014 BMW 428i Coupe, and 428i xDrive Coupe. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail. Note: This recall is an expansion of recall 13V-454.

Risk. A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.

Remedy. BMW will notify owners, and dealers will install a locking ring in the camshaft to retain the camshaft seal disk in the proper location, free of charge. The recall began on December 2, 2014. Owners may contact BMW customer service at 1-800-525-7417.

Defect. BMW of North America LLC (BMW) is recalling certain model year 2012-2014 320i, 328i, 320i xDrive, and 328i xDrive sedans; model year 2014 328i xDrive Sports Wagons; model year 2012-2013 528i and 528i xDrive sedans, model year 2013-2014 X1 sDrive28i and X1 xDrive28i vehicles and model year 2012-2014 Z4 sDrive28i roadsters. Due to insufficient lubrication, the vacuum pump that supplies brake power assistance may fail.

Risk. A failure of the brake vacuum pump results in a reduction in braking power that could increase the risk of a crash.

Remedy. BMW will notify owners, and dealers will modify the vehicles to prevent insufficient vacuum pump lubrication, free of charge. The safety recall began on January 31, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at [email protected].

Car engine timing chain guides are faulty and there have been lawsuits that were settled and no recall on the actual part with drivers still having issues with the N20 engine now getting quotes for over $15,000. is this not an incident where it’s not the fault of a driver but manufacturing? This needs to become a recall for all N20 engine timing chain and guides as the faulty part is causing complete engine failure. seems very deceptive when a BMW only last 100,000 miles.

Vehicle has oil leak bad

The failure involved the breaking of the oil chain, which resulted in catastrophic engine damage. Consequently, the timing chain and splash shield were also compromised due to the initial failure. The incident appears to be caused by a malfunction or defect in the oil chain assembly. The affected components are available for inspection and further investigation. This information may be useful for evaluating the need for a recall or identifying underlying manufacturing or design issues.

On [XXX], the water pump's electrical plug connector became defective, ultimately putting myself and [XXX] son in a dangerous situation. While on the highway coming home from work/daycare, the car overheated rapidly, my car started slowing down in the middle of the highway. The car ultimately stopped and had to pull to the side. I tried to call 2 BMW dealerships in San Jose, but at that time the recall remedy was unavailable and said there was nothing they could do for me. So I had to tow to my home. Towed to my mechanic the next day, and they had to fix it. The car was repaired after being in the shop for 1 week. I took the car home and shortly after, the car overheated again. Luckily, I was on my way home and in the neighborhood. This was a very traumatic experience that I never set foot in the care since then and am requesting a refund for the repair that wasn't even fixed in the first place. I do not want to use the car anymore given it is a huge safety risk for me and my son. I travel to the city 4 days a week for work and daycare. I have the receipts for repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had just purchased a car but a month ago I was driving to lunch and I was at a stop sign when the light turned green I started to go the car started shaking and smoke was coming out of the front under the hood I had just an oil change so I took it back to the oil change shop. They could not figure out why the engine blew and I had to take it to a different BMW shop where I have to purchase a rebuilt motor and pay for the repairs. I can request all records from the automotive shop if needed.

The turbocharger wastegate actuator issues causing a drivetrain malfunction. The actuator has been changed several times ,that regulates the westgate yet there’s a loss in power. Safety when merging onto freeway as you accelerate the warning light comes on and vehicle losses power other vehicles have to slow significantly to avoid possible running into vehicle entering freeway

The contact owns a 2012 BMW 528I. The contact stated while the vehicle was parked, the vehicle failed to start. The contact attempted to restart the vehicle. After several attempts, the vehicle failed to start. Several unknown warning lights were illuminated. The vehicle was towed to an independent mechanic; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that on another occasion, while driving 60 MPH, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was able to coast to the side of the road. No warning lights were illuminated. The vehicle was towed to the residence. The vehicle was then towed to the contact's office. An independent mechanic arrived and diagnosed the vehicle with engine failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 160,000.

The contact owns a 2012 BMW 528I. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The contact stated that while the vehicle was parked, there was condensation underneath the vehicle. The contact stated that while driving approximately 50 MPH, the "Engine Malfunction" message was displayed, and the vehicle stalled. The vehicle was restarted 20 minutes later after several attempts. The failure reoccurred several times until the vehicle was taken to the residence and parked. The vehicle was towed to a dealer where it was diagnosed that the control unit seal pump needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was taken to the same independent mechanic on several occasions where it was diagnosed that the ignition coil and timing chain had fractured into the oil pan valve cover, and the oil pan gasket, oil pan, and spark plugs needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 136,898.

The contact owns a 2012 BMW 528i. The contact stated that while the vehicle was parked, the vehicle was started, however, the vehicle failed to start. The contact stated the vehicle eventually started. In addition, the contact stated that when the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The contact stated that the steering wheel seized and the vehicle lost motive power. The vehicle was towed to the contact's residence. The dealer was made aware of the failure and confirmed that the parts were not available. In addition, the contact stated that previously the vehicle was taken to the dealer where it was diagnosed with a failed coolant pump and unknown sensor. The contact was informed that the coolant pump and the unknown sensor needed to be replaced. The unknown sensor was replaced, however the contact was informed that the coolant pump was unavailable. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The contact was offered to have the vehicle towed to the dealer, however the parts were not available. The failure mileage was 111,000. VIN tool confirms parts not available.

Vehicle leaked oil to where it caused an engine fire.

The contact owns a 2012 BMW 528I. The contact stated that there was water leaking from the vehicle. There was an undisclosed electrical failure. The contact stated that the vehicle was consuming an excessive amount of engine oil. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

While driving error message came up on screen saying add a quart of oil, car was smoking and engine block caught fire.

The drivetrain disintegrated. Car started running really rough, and then just stopped completely. Would crank but would not move. Yes, it is available. Car would barely go, and then just stopped in the road. I had to have it towed to a mechanic. No, I had not received a warning of this possible hazard. No, it was not inspected by any of the above, but was inspected by numerous mechanics. Yes, drivetrain light/warning came on, as well as, drive at a slower rate when the car started to drive roughly. The turbo also went out on the car. May 28, 2024

Headlights fill with condensation and cause short circuit and headlight and turn signal malfunction. Headlights fill with condensation and moisture even on sunny summer days. No warnings prior to headlights and turn signals malfunctioning. BMW says to drive with headlights on to dispel condensation but the headlights produce no heat to do so and do not illuminate because circuits are damp and not working.

N20 引擎 汽油泵浦故障

The contact owns a 2012 BMW 528I. The contact stated while driving 40 MPH, the transmission warning light illuminated on the instrument panel. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 17V138000 (Power Train) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 87,000.

Picked up from a stop light no aggressive but normally and a few seconds after going around 20-30ish mph the car stalls and goes into neutral. I was really confused and panicking of what happened, the cars behind me almost crashed into me and I was trying to manage to pull the car over to the side of road and thankfully I did. This could have caused a serious injury to me and others. As I was able to pull off to the side of the road I try to start my car back up and it cranks and cranks for a few seconds which it normally never does and finally when it starts back up the car just starts miss firing like crazy and the check engine light comes on and the car is throwing codes all over the place like drive train malfunction, engine malfunction, low oil pressure, check engine oil, auto stop start malfunction. I was super confused so I shut it off and tried to start it again but it didn’t help at all. I drove slowly into a parking lot and got it towed to a independent repair shop to which they diagnosed the timing chain guides breaking and falling into the oil pump, clogging the oil pump then causing further damage due to no oil going to the top of the motor. I was very confused how all of this could have happened since I took care of my car . If the car had given me a service warning light I would have went and got my engine serviced for this job. Now The thing is these timing chain jobs aren’t cheap and replacing the oil pump chain is even more expensive since it requires loweri

Car engine caught on fire while driving today and stopped. No smoke or other issues prior. Worried this is related to the recall issued by BMW recently, however my car is not covered under the recall yet. The car is currently located in Vancouver Canada. It was purchased in Tulsa, OK

The contact owns a 2012 BMW 528i. The contact stated while driving approximately 35 MPH, there was an abnormal sound coming from the vehicle. The drivetrain malfunction warning light illuminated. The vehicle was towed to an independent mechanic and diagnosed with a defective oil pump. The vehicle was repaired. The contact related the failure to NHTSA Campaign Number 14V176000 (Engine and Engine Cooling). The manufacturer was not notified of the failure. The approximate failure mileage was 109,000.

Casually picking up from a stop light when my car just randomly decided to turn off on the middle of the road and go into neutral. I lost power steering and brakes. I was able to manage to pull over and restart the car and I was welcomed with a bunch of check engine lights and many other malfunctions. Got the car towed and comes out that the timing chain has failed as well as the oil pump and resulted in damage to the camshaft and cylinder head of the motor. This is just insane how all of this happened in just a few seconds. I took care of my car did oil changes on time, coolant, brakes, transmission fluid. I took care of my car. Bmw put me in a very unsafe condition that day and I’m very upset because that could have ended very bad for me. The n20 motor has been very well known to fail at any time without any warning and bmw has yet to recall this motor. It became very bad to the point to where they even got sued but only limited the warranty up to 100K miles. Many people experienced this problem before 100K and some experienced it earlier. Their is no given time when this timing chain can fail on you. In my case so many things were damaged in the engine and I even contacted bmw NA and they didn’t even care to help. Bmw put me in a very bad spot and they want me to replace the engine and pay labor and pay more than what the cars worth! Bmw is crazy for this and I hope all of these engines get recalled and get replaced free of charge without worrying about how many miles you

I own bmw 528i 2012. These engines are straight up bad. Timing chain failed at 149K miles with no signs of failure. Just driving down the road when suddenly the car just turns off and goes into neutral on its own. I simply pulled over restarted the car to cylinder misfires, car struggling to accelerate, smoke out the exhaust, and a loud rattling sound. I pulled over had the car towed. I had my car taken to a independent shop for repairs and diagnostics and what I got told was absolutley crazy. The timing chain guides broke off the timing chain, went down into the oil pump and those pieces settled into the pump restricting oil from going to the top of the motor causing the timing chain to start slacking and breaking from the top. He also said one of the Camshaft caps also has a crack in it.The car has been parked in my driveway for 6 months because repairing the motor would cost a ton, and putting in a remanafactured motor with labor cost would cost just as much as buying the same car again. BMW had a lawsuit about the N20/N26 but thats only covered upto 100K miles. Considering my car was running good I had no reason too change anything on this car. Oil changes were done almost every 3-5K miles and the car had no sounds no lights on the dash. I tried to claim the SULEV/PZEV Warranty which is covered upto 150K miles and the dealerships either never contacted me back or they just said no. I even contacted the HQ of BMW and they also refused any repair even with SULEV Warranty. B

I had been having problems with my seatbelt alarm coming on for a while with nothing in the seat of the passenger and then as I was trying to turn in to park I heard a click from my steering wheel as if it didn’t want to turn and the driver seat restraint malfunction error popped up . Now my horn will not work as well . I’m told that the dealership is the only place it can be repaired. I’m worried that it will deploy on me while driving . I’m sure this is an issue others have experienced as well .

The contact owns a 2012 BMW 528i. The contact stated while at a standstill the vehicle stalled randomly. The contact stated that drive train failure warning message was displayed. The vehicle was taken to a dealer and was awaiting diagnostic testing. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14V627000 (Service Brakes, Hydraulic) however, the VIN was not included. The manufacturer was informed of the failure and informed the contact that they were unable to assist. The failure mileage was approximately 90,000. The VIN was not available.

EARLY 528I, F10 MODELS HAVE FACTORY SOFTWARE GLITCH THAT IMPROPERLY SET FRONT BRAKE MILEAGE TO AN ERRONEOUS 3100 MILES WHEN RESET AFTER FRONT BRAKE REPLACEMENT. BMW DOES NOT TAKE OWNERSHIP OF SOFTWARE ISSUE AND PLACES SOFTWARE UPGRADE COST ON CUSTOMER THROUGH DEALERSHIP. ISSUE DOES NOT ARISE UNTIL AFTER WARRANTY HAS EXPIRED. CUSTOMERS THAT REFUSE TO PAY FOR COST OF BMW SOFTWARE MALFUNCTION CONTINUOUSLY HIT THE RESET OPTION FOR FRONT BRAKES WHICH CONSISTENTLY RESET TO AN ERRONEOUS MILEAGE OF 3100 MILES. THIS CONTINUOUS ERRONEOUS RESET APPROACH DOES NOT ALLOW FOR PROPER BRAKE WEAR ASSESSMENT BASED ON MILEAGE AND LEADS TO LOSS OF AWARENESS ON FRONT BRAKE PADS REPLACEMENT WHICH CAN CAUSE ACCIDENTS DUE TO LOSS OF FRONT BRAKES. MY WIFE KEPT HITTING THE RESET OPTION TO REMOVE THE ERRONEOUS ALARM SO OFTEN THAT SHE ACTUALLY WAS DRIVING WITH EXTREMELY LOW PADS AND ALMOST GOT INTO AN ACCIDENT ON THE HIGHWAY. THIS IS NOT SAFE AND BMW SHOULD COVER FACTORY SOFTWARE UPGRADE SINCE CUSTOMERS DO NOT HAVE THE CAPABILITY TO ALTER OR UPGRADE SOFTWARE ON THE VEHICLES.

THE VEHICLE LOST POWER, WHILE IN MOTION, IN THE MIDDLE OF THE ROAD AFTER ACCELERATING. THE CAR GAVE AN ERROR CODE OF DRIVETRAIN MALFUNCTION. MY CAR LOST POWER IN THE MIDDLE OF A BUSY CITY STREET, AND IT COULD HAVE EASILY LED TO A TERRIBLE ACCIDENT. POSSIBLY RELATED TO NHTSA CAMPAIGN NUMBER: 16V746000 BUT MY CAR WAS NOT INCLUDED IN THE RECALL.

I WAS DRIVING ON THE ROAD AND I ACCELERATED A LIL BIT FASTER TO BEAT THE TRAFFIC LIGHT AND THEN MY CAR LOSS POWER AND STALLED OUT AND I GOT STUCK IN THE MIDDLE OF THE BRIDGE AND I WAS CAUSING TRAFFIC THE POWER TRAIN MALFUNCTION AND THE FUEL SUPPLY LIGHT CAM ON AND THE CHARGE BATTERY LIGHT CAME ON I TRY STARTING IT BUT IT WOULDN'T START AND THE FUEL SUPPLY LIGHT KEPT COMING ON AND SOME WIRING PROBLEM WAS GOING ON WHEN TRYING TO START IT MY TV SCREEN WOULD TURN ORANGE AND THE SPEEDOMETER WHERE THE MPH/GAS/TEMPERATURE/AND RPM WOULD TWITCH LIKE SOME ELECTRICAL PROBLEM

I WAS GOING ABOUT 40 MPH WHEN I HEARD LIKE A POPPING NOISE COMING FROM THE FRONT OF THE CAR, AS SOON AS I HEARD THE NOISE MY CAR LOST ALL ITS POWER, ABOUT 2 MINUTES AFTER I NOTICED MY CAR WAS LEAVING A CLOUD OF WHITE SMOKE FROM THE EXHAUST.

TL* THE CONTACT OWNS A 2012 BMW 528I. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITH THE FUEL SUPPLY ERROR WARNING LIGHT ILLUMINATED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED AND THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TO AN INDEPENDENT MECHANIC. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 16V746000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

I WAS DRIVING ON THE FREEWAY AND MY CAR SUDDENLY STOPPED RUNNING AND SHUT DOWN ON ME MID FREEWAY! I STEPPED ON GAS PEDAL AND NOTHING! IT TURNED OFF ON ME AND WOULDN'T TURN ON! NOW IT TURNS BUT GAS WON'T WORK! I BELIEVE THERE IS A PROBLEM WITH THE GAS PUMP OF SOMETHING REGARDING GAS FUEL! I HAD TO CALL MY CAR INSURANCE TO TOW MY CAR WHEN I BECAME STRANDED ON THE FREEWAY. *TR

I WAS MERGING ONTO A HIGHWAY FROM ANOTHER HIGHWAY WHEN ALL OF SUDDEN THE CAR DECELERATED OUT IF NOWHERE AND A ERROR MESSAGE DISPLAYED ON MY DASHBOARD FUEL SYSTEM ERROR/ DRIVETRAIN MALFUNCTION ENGINE SPEED WILL BE REDUCED. THE CAR ACTED AS THOUGH I HAD ABSOLUTELY NO POWER AS I COASTED TO A SAFE PLACE OFF THE HIGHWAY.

DRIVERS SEAT BELT WON'T LOCK

MY VEHICLE JUST KILLED AS I WAS DRIVING IT. I GOT AN FUEL SYSTEM ERROR CODE AS WELL AS A DRIVETRAIN MALFUNCTION ERROR WHEN ACCELERATING. ALTHOUGH THERE WAS A RECALL ON 2012 528I FUEL PUMP THAT WAS DEEMED TO BE THE CULPRIT OF THIS PROBLEM, BMW IS SAYING MY CAR WASN'T A PART OF THE RECALL.

WAS DRIVING DOING 30 MPH ON A NO TRAFFIC CITY STREET..AND THE CAR STARTED SHAKING THEN THE ENGINE LIGHT CAME ON. PUT THE SCANNER AND CODE P0087 IS WHAT IT READ

MY CAR WAS HAVING A WHINING NOISE AND DURING THE DIAGNOSIS IT WAS FOUND THAT THE PLASTIC GUIDES WITHIN THE ENGINE BLOCK THAT KEEP THE TIMING CHAIN INTACT IS BAD. THE TECHNICIAN ALSO FOUND THAT THE GUIBO (AKA UNIVERSAL JOINT) WAS CRACKED. FROM MY RESEARCH ON THE MATTER, I READ THAT NHTSA HAD ISSUED A LETTER PERTAINING TO OTHER MAKE AND MODEL ON FAULTY OR POORLY DESIGNED GUIBO. I PRESUME THAT THE AFFECTED MODELS BE INVESTIGATED AND COVERAGE BE EXTENDED TO OTHER LINES OF BMW. THIS IS THE DIRECTIVE FROM NHTSA I AM REFERRING TO: RCAK-17V067-6564.PDF RCRIT-17V067-9870.PDF MY CURRENT MILEAGE IS ONLY ABOUT 55,000 MILES AND MAYBE THERE WERE OTHER OWNERS WHO DEVELOPED THIS FAULT WITHIN THE STANDARD OR EXTENDED WARRANTY FOR THE PRODUCT LINE THAT WAS OUTSIDE THIS RECALL. PLEASE INVESTIGATE AND TAKE CORRECTIVE ACTION.

WHEN DRIVING THE CAR ON THE HIGHWAY, A DRIVE TRAIN MALFUNCTION WARNING WOULD APPEAR FREQUENTLY ON THE DISPLAY PANEL. I TOOK THE CAR TO VALLEY BMW IN MODESTO, CA, ON NOVEMBER 2018. AFTER ON EXTENSIVE DIAGNOSTIC EVALUATION, THEY FOUND NOTHING WRONG WITH THE VEHICLE. THE ONLY SUGGESTION WAS TO REPLACE THE CAR'S BATTERY. I TOOK THE CAR TO BATTERIES PLUS BULBS FOR A SECOND OPINION. THEY DETERMINED THAT THE BATTERY WAS STILL IN GOOD CONDITION AND DID NOT NEED TO BE REPLACED. THE DRIVE TRAIN MALFUNCTION CONTINUED TO APPEAR WHEN DRIVING ON HIGHWAY. IN A SUBSEQUENT VISIT TO THE DEALER, I AGAIN MENTIONED THE ISSUE WITH THE DRIVETRAIN MALFUNCTION WARNING STILL APEARING ON THE DISPLAY PANEL. OUR CUSTOMER SERVICE AGENTS, SAID THEY COULDNT FIND ANYTHING WRONG WITH THE CAR,THEREFOR, THERE WAS NOTHING THEY COULD DO. ON A TRIP TO SAN FRANCISCO, WE EXPERIENCED A MAJOR ENGINE BREAK DOWN. THE CAR HAD COMPLETELY SHUT DOWN. FORTUNATLY,WE HAD JUST EXITED THE HIGHWAY. WE THEN HAD THE CAR TOWED TO PETTER PAN BMW DEALERSHIP AND THEY CONCLUDED THAT INDEED THE ENGINE HAD EXPERIENCED A MAJOR BREAKDOWN, IN THEIR EVALUATION, THEY ALSO NOTED THE BATTERY WAS IN GOOD CONDITION. THIS COMPLETELY CONTRADICTS THE CLAIM BY VALLEY BMW THAT THE BATTERY WAS THE ISSUE. SINCE THEN, I HAVE FOUND OUT THAT THERE IS A CLASS ACTION LAWSUIT AGAINST BMW FOR A DEFECTIVE N20 ENGINE WHICH IS THE ENGINE IN MY CAR. I ALSO WENT AS FAR AS CONTACTING THE CEO OF BMW NORTHAMERICA REGANDING THIS DEFFECTIVE MOTOR. AS EXPECT BMW REFUSED T

MY 2012 BMW 528I STALLED TWICE 2 WKS AGO WHEN I WAS SLOWING DOWN AT A TRAFFIC SIGNAL. THE DISPLAY SHOWED EITHER "DRIVETRAIN MALFUNCTION" OR "TRANSMISSION MALFUNCTION". IMMEDIATELY I TURNED ON THE HAZARD LIGHTS, SLOWLY CHANGED LANES SLOWLY AND COME TO A HALT, BY WHICH THE WARNING WAS GONE AND I DROVE HOME AT LESS THAN 15 MPH. THE NEXT MORNING THE CAR SEEMED FINE AND I WAS ABLE TO DRIVE IT TO A LOCAL MECHANIC, WHO ADVISED A BMW SERVICE. I TOOK THE CAR TO AN AUTHORIZED SERVICE CENTER (ASC) FOR VERIFICATION AND WAS DIRECTED TO COME BACK IN FEW DAYS; WITHIN THAT WEEK IT HAPPENED AGAIN. I WENT TO ANOTHER ASC TO HAVE IT FULLY DIAGNOSED. IT WAS DETERMINED THAT FAULTY GUIDES IN THE TIMING-CHAIN CAUSED IT. I HAD NO IDEA IT WAS DESIGN FLAW UNTIL I READ ABOUT IT IN ONLINE. THE SERVICE MANAGER ALSO SAID THEY HAVE SEEN IT HAPPEN IN MANY CARS AND SOMETIMES UNDER 30K MILES AND IN FEW INSTANCES NEEDING ENTIRE ENGINE REPLACEMENT FOR $15000. I SEE SEVERAL CUSTOMERS WITH N20 AND N26 ENGINES HAVING THIS ISSUE SAME AS WITH N63 ENGINES. I CONTACTED BMWUSA AND LODGED A COMPLAINT ABOUT THIS FOR REIMBURSEMENT REFERRING TO NHTSA TSB 110614, BUT WAS DENIED. I WAS TOLD BMW KNEW OF THIS ISSUE AND EXTENDED THE WARRANTY TO 7Y/70K. I WAS NOT AWARE OF THIS AND MYGARAGE ON BMWUSA IS NOT SHOWING IT. I HAVE RECEIVED SEVERAL MARKETING INFO ON NEW BMW AND LEASES INSTEAD. CLASS ACTION LAWSUITS HAVE BEEN LODGED IN NORTH AMERICA AND DEATHS IN IRELAND REQUIRING A COURT ORDER FOR MANDATORY RECALL. 1) WILLIAMS, ET AL. V

SIX MONTHS I STARTED HEARING A HIGH PITCH NOISE AND IT ONLY GOT WORSE OVER THE FEW MONTHS. TWO WEEKS AGO (01/10/2020 AND 01/17/2020), IN THE NIGHT AROUND 8PM, MY BMW 528I CAR STALLED AT A TRAFFIC LIGHT IN CULVER CITY, CALIFIRNIA. IT FLASHED AN ERROR MESSAGE ON THE DISPLAY VERY BRIEFLY AND IT APPEARED TO BE "DRIVE TRAIN MALFUNCTION". STALLED IN THE MIDDLE OF THE STREET, MY FIRST REACTION WAS TO TURN ON THE HAZARD LIGHTS AND HOPE NOBODY HITS ME FROM THE BACK, AS I WAS NOT ABLE TO DRIVE FORWARD. BEFORE I COULD TAKE MY PHONE OUT AND TAKE A PICTURE OF THE SCREEN, THE ERROR SCREEN VANISHED. I PRESUMED THE "ERROR" WOULD BE SAVED IN THE SYSTEM AND SHUT THE ENGINE OFF, RESTARTED AND STARTED TO DRIVE AND PROCEED. AT BOTH THESE TIMES THERE WERE CARS BEHIND ME AND I TURNED ON THE HAZARD LIGHT TO WARN THE OTHER DRIVERS OF MY INABILITY TO DRIVE. I TOOK THE CAR TO TWO BMW SERVICE CENTERS. ONE OF THE SERVICE MANAGERS SAID HE CANNOT SAY WHAT THE ISSUE IS WITHOUT DOING A DIAGNOSIS, BUT THE PROBABLE CAUSE IS SOMETHING TO DO WITH THA OIL-PUMP OR THE CAM-SHAFTS AND RELATED TO TIMING. I TOOK THE CAR TO ANOTHER SERVICE CENTER AND HERE I LEFT THE CAR BEHIND FOR A SPECIFIC DIAGNOSIS. I WAS TOLD THE ISSUE IS RELATED TO TIMING CHAIN AND PLASTIC PARTS THAT HOLD THE CHAIN IN PLACE, DETERIORATE OVER TIME. I WAS TOLD THAT IT IS A COMMON ISSUE AND IT IS MY LUCK THAT THE TIMING CHAIN DID NOT RIP APART AND CAUSE AN ENGINE SEIZURE, WHICH WOULD HAVE COST ME $15000 IN REPAIRS THAN WHAT I WAS BILLED AROUND $6000.

WHILE DRIVING DOWN THE 95 HIGHWAY MY CAR SHOWED A FUEL SUPPLY ERROR THEN POWERED DOWN AND STOPED AND WOULDN'T RESTART. I HAD IT TOWED TO A HOTEL AND THE FOLLOWING MORNING IT STARTED WHILE THE TOW TRUCK LOADED IT TO TAKE TO THE DEALER. I HAD A FULL TANK OF GAS AT THE TIME. I COULD HAVE BEEN KILLED WITH MY KIDS. TOWED IT TO BMW AND ALL THEY TOLD ME WAS TO REPLACE MY BATTERY EVEN THOUGH I HAD A PERFECTLY GOOD BATTERY AND THE AND EVERYTHING REQUIRING A BATTERY WORKED LIKE RADIO, LIGHTS ETC. I BOUGHT A NEW BATTERY FROM THEM AND THE TECH DROVE THE CAR FOR 30 MILES. WITHIN 2 HOURS AFTER LEAVING THE DEALERSHIP MY CAR DID THE SAME THING WHILE EXITING THE HIGHWAY AND SLOWING DOWN AT A STOP LIGHT. A DIAGRAM FLASHES ON THE CONSOLE AND THEN A MESSAGE ABOUT THE FUEL SUPPLY. I WAS ASSISTED BY CALLING 911 TO GET MY KIDS AND I TO SAFETY AND MY CAR OUT THE WAY. THERE IS A RECALL ON THE FUEL MODULE OR PUMP FOR MY YEAR AND MAKE BUT BMW CLAIMS MY VIN IS NOT INCLUDED. THIS IS DANGEROUS, PEOPLE CAN GET KILLED IF THE CARS ARE STALLING WHILE IN MOTION.

WHILE DRIVING MY CERTIFIED 2012 BMW 528I, WHICH HAS AN N20 ENGINE, THE "DRIVETRAIN MALFUNCTION, MAXIMUM OUTPUT NO LONGER AVAILABLE, DRIVE MODERATELY" WARNING LIGHT APPEARED ON MY DASH AND ALERTED ME THAT THERE WAS A POTENTIAL ISSUE WITH MY VEHICLE. PRIOR TO THE ALERT SIGNALING MY ATTENTION, I WAS DRIVING ON A HEAVILY TRAFFICKED HIGHWAY WITH SPEED LIMITS RANGING FROM 35 MPH TO 60 MPH. I DROVE APPROXIMATELY 20 MINUTES / 13 MILES TO MY DESTINATION BEFORE THE "DRIVETRAIN MALFUNCTION" INDICATOR LIGHT ALERTED ME. LUCKILY, I WAS NEAR A DRIVEWAY TO PULL OFF INTO A PARKING LOT WHEN THE WARNING LIGHT APPEARED. AS SOON AS THE WARNING LIGHT APPEARED MY CAR IMMEDIATELY BEGAN TO IDLE ROUGHLY, AND MY ENGINE WAS NOT RUNNING AT FULL CAPACITY. I WAS ONLY ABLE TO PULL INTO A PARKING STALL AND MOMENTS FOLLOWING THE "DRIVETRAIN MALFUNCTION" ALERT, AN OIL LIGHT ALSO ALERTED ME ON MY DASH. MY CAR IS UP TO DATE ON ALL REQUIRED SERVICES. I HAVE SERVICED MY VEHICLE AT MY LOCAL BMW DEALERSHIP. AT ALL SERVICE APPOINTMENTS I REQUESTED CURRENT BULLETINS. MY VEHICLE HAD NO KNOWN PROBLEMS, OR WARNING INDICATORS OR ALERTS THAT I WAS MADE AWARE OF. WHEN I SAFELY PULLED OFF THE ROAD INTO A PARKING LOT MY CAR SHUT DOWN COMPLETELY, WOULD NOT RESTART, AND LOCKED UP. I WAS NOT ABLE TO PUT MY CAR IN NEUTRAL. MY VEHICLE WAS TOWED TO THE BMW DEALERSHIP WHERE THE DEALERSHIP INSPECTED THE VEHICLE AND ALERTS. THE DEALERSHIP DIAGNOSED THE VEHICLE AND SAID THAT THE TIMING AND OIL PUMP CHAIN MALFUNCTIONED AND THE TOTAL COS

TL* THE CONTACT OWNS A 2012 BMW 528I. WHILE DRIVING AT A LOW RATE OF SPEED, THE DRIVE TRAIN MALFUNCTION WARNING INDICATOR ILLUMINATED. THE CONTACT PULLED OVER TO THE SIDE OF THE HIGHWAY AND SHUT OFF THE VEHICLE. THE VEHICLE WOULD NOT RESTART. THE CONTACT HAD THE VEHICLE TOWED TO AN UNKNOWN BMW DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2012 BMW 528I. THE CONTACT NOTICED THAT THE VEHICLE WAS INCLUDED IN SEVERAL TECHNICAL SERVICE BULLETINS. HE WAS CONCERNED THAT BMW HAD SEVERAL LAWSUITS REGARDING THE TIMING BELT. THE MANUFACTURER EXTENDED THE WARRANTIES FROM 50,000 TO 70,000 MILES RELATED TO THE TIMING CHAINS, SPROCKETS, OIL PUMPS, TENSIONERS, AND GUIDES. THE CONTACT WAS CONCERNED THAT THE MANUFACTURER WAS NOT FULLY RESOLVING THE ISSUE. THE VEHICLE WAS CURRENTLY AT BMW OF FAIRFAX (8427 LEE HWY, FAIRFAX, VA 22031, (800) 641-4873) FOR THE TIMING CHAIN. THE CONTACT STATED THAT THE TIMING CHAIN WAS BEGINNING TO RUB AGAINST OTHER PARTS OF THE ENGINE. THE CONTACT WAS CONCERNED THAT THE REPAIR WOULD COST $12,000 TO $16,000 TO REPLACE THE ENTIRE ENGINE IF THE TIMING CHAIN FAILED. THE MANUFACTURER STATED THAT THE CONTACT'S VEHICLE DID NOT QUALIFY FOR THE EXTENDED WARRANTY SINCE IT WAS ALREADY OVER 70,000 MILES. THE FAILURE MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2012 BMW 528I. THE CONTACT STATED THAT THE FUEL SUPPLY WARNING INDICATOR ILLUMINATED WHILE DRIVING VARIOUS SPEEDS. AFTER THE WARNING, THE VEHICLE STALLED AND THEN ABRUPTLY STOPPED. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT TOOK THE VEHICLE TO BMW OF TULSA (9702 S MEMORIAL DR, TULSA, OK 74133, (918) 663-4444) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 124,038.

DEFECTIVE DRIVE TRAIN - ON MARCH 11, 2019 MY DRIVE TRAIN MALFUNCTION AND WHICH DAMAGE MY ENGINE. THIS IS AN SAFETY CONCERN BECAUSE MY CAR STOP ON THE FREEWAY WHILE I WAS DRIVING. BMW MFG KNEW ABOUT THE DEFECTIVE DRIVE TRAIN PRIOR TO ME PURCHASING CAR FROM FIELDS BMW ON JULY 2013. BMW NORTH AMERICA OFFER TO PAY 21,000 FOR THE ENGINE REPLACEMENT AND THEY WANT ME TO PAY 6,000.00 AND I FEEL BMW KNOW ABOUT THE FAULTY DESIGN IN 2012 AND DID NOT INFORM THE CONSUMER. WHEN I PURCHASE THE CAR, IT HAD 18,000 MILES ON IT AND I PUT 62,000.00

TL* THE CONTACT OWNS A 2012 BMW 528I. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY SHUT OFF AND "DRIVE TRAIN MALFUNCTION" DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (BMW OF DALLAS, 6200 LEMMON AVE, DALLAS, TX) WHERE IT WAS DIAGNOSED THAT THE ENGINE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS UNKNOWN.

THE FRONT PASSENGER OCCUPANCY SEAT SENSOR IS DEFECTIVE/NOT WORKING EVEN THOUGH THE CAR HAS ONLY 25,000 MILES. THIS IS A SAFETY ISSUE AND THERE ARE SO MANY OWNERS HAS SIMILAR ISSUE WITH THIS DESIGN

WHILE DRIVING, MY CAR STALLED SUDDENLY WITHOUT GIVING ME A PRIOR WARNING. IT PUT ME IN AN EXTREMELY DANGEROUS SITUATION. BMW DIAGNOSED IT: FAILURE IN THE FUEL SUPPLY SYSTEM. THIS MUST BE INVESTIGATED. THIS PROBLEM HAS ALSO SEEN IN OTHER BMW MODELS. I HAVE 80000 MILES ON MY CAR. THE CAR IS ALWAYS SERVICED BY BMW DEALERSHIP.

TL* THE CONTACT OWNS A 2012 BMW 528I. WHILE DRIVING AND MAKING A LEFT TURN, THE VEHICLE STALLED ON THE SIDE OF THE ROAD AND WAS NOT ABLE TO RESTART. THE DRIVE TIMING CHAIN AND OIL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO UNITED BMW CPO (LOCATED AT 11458 ALPHARETTA HWY, ROSWELL, GA 30076, (678) 497-0818) WHERE IT WAS DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE CONTACT STATED THAT THE VEHICLE REMAINED AT THE DEALER FOR NINE MONTHS AND WAS NEVER REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 128,856. *DT *TR

GOT FUEL SUPPLY ERROR ON THE VEHICLE, AFTER DIAGNOSE WAS THE FUEL PUMP. BOUGHT NEW FUEL PUMP AND MODULE AT BOSTON BMW IN ALLSTON MA. AFTER 3 MILES FUEL PUMP FAILS AGAIN. NOW AFTER ANOTHER 5,000 MILES FUEL PUMP FAILING AGAIN, GOT ERROR MESSAGE AND CAR TURNED OFF. SMH, 3 NEW FUEL PUMPS IN LESS THAN A YEAR! THIS IS INSANE! BMW KEEP SAYING MY CAR IS NOT IN THE RECALL OF FUEL PUMP WHEN IT SHOULD BE! WORST PART IS THAT IS THAT BOTH TIMES I BEEN DRIVING 40+ MILES AND VEHICLE JUST SHUTS OFF IN THE MIDDLE OF THE ROAD!

I PURCHASED MY BMW 528 XI DRIVE CPO IN JANUARY 2015. IN AUGUST 2018 MY ENGINE OIL PRESSURE LIGHT CAME ON IN THE CAR AND THEN THE DRIVE TRAIN MALFUNCTION LIGHT.I TRIED TO RUN A SELF DIAGNOSTIC ON THE CAR AS THIS IS A FEATURE BUILT IN AND THE ENGINE OIL CHECK WOULD ONLY GO UP TO 15% AND CUT OFF. I TOOK IT INTO BMW OF BLOOMFIELD FOR SERVICE MENTIONING THIS TO THEM. THEY CHANGED THE OIL AND CLEARED THE CODES GOT THE CAR BACK. FAST FORWARD TO JUST A FEW WEEKS AGO, I AM DRIVING ON THE HIGHWAY AND THE ENGINE OIL PRESSURE AND DRIVE TRAIN MALFUNCTION LIGHT COME ON AND THE CAR STOPS ON ME. I COULD HAVE GOTTEN KILLED. I HAD IT TOWED TO BMW AND THEY CHECK IT AND SAY THAT THE ENGINE IS GONE DUE TO LOW PRESSURE AND REPAIRS ARE 20,000 PLUS. REMIND YOU I BARELY DRIVE THE CAR AS I WORK IN NY AND TAKE THE BUS . I ONLY DRIVE THE CAR ON EVENINGS AND WEEKENDS. I CONTACTED THE CORPORATE BMW OF NA OFFFICE AND THEY ACT LIKE THEY DON'T CARE. ADVISED ME TO TALK TO THE SERVICE MANAGER TO SEE WHAT COULD BE DONE. BASED OM WHAT I HAVE RESEARCHED THIS SEEMS TO BE A COMMON ISSUE WITH THESE TYPES OF CARS AS IT IS A DEFECT IN THE ENGINE. NOW I AM NOT SURE WHAT TO DO BUT WILL BE CONSULTING AN ATTORNEY.

LAST WEEK I WAS ON THE NJ TURNPIKE WHEN ALL OF A SUDDEN MY CAR STALL AND LOST POWER, I BARLEY GOT OFF THE TURNPIKE WHEN THE CAR CAME TO A COMPLETELY STOP. NO WARNING MESSAGES OR NOISES JUST STOPPED. FORTUNATELY NO ACCIDENT OCCURRED DUE TO THIS BUT COULD HAVE BEEN AN UGLY ONE. THE CAR WOULD NOT START AND WAS TOWED TO THE BMW DEALER. THE CAR WAS INSPECTED, OIL WAS CLEAN, NO WATER DAMAGE, HOWEVER THEY TELL ME I NEED A NEW ENGINE (13K) HAS THE ENGINE SEIZED WITHOUT TELLING ME WHAT CAUSED IT.THE CAR HAS 83K MILES. I'VE BEEN A BMW OWNER FOR 19 YEARS. I NOW HAVE MIXED FEELINGS ABOUT BMW AND THE WAY I FEEL NOW I WILL NEVERY BUY ANOTHER BMW AS I'M NOT GETTING THE ATTENTION I THIN I DESERVE. ANY ADVICE IS GREATLY APPREICATED!