2020 Volvo S60

Defect. Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.

Risk. A short circuit in a high-voltage battery increases the risk of a fire.

Remedy. Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.

Defect. Volvo Car USA, LLC. (Volvo Car) is recalling certain 2019-2024 S60 vehicles. The passenger air bag may not be secured properly, which can cause the air bag to deploy improperly.

Risk. An air bag that does not deploy properly in a crash increases the risk of injury.

Remedy. Dealers will inspect and tighten the bolts securing the passenger air bag, as necessary, free of charge. Owner notification letters were mailed January 5, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10254.

Defect. Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.

Risk. Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.

Remedy. Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.

Defect. Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.

Risk. If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.

Remedy. Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.

On two separate occasions in the past two months June 6 and Aug. 15, this vehicle experienced a severe unintended engine surge / unintended acceleration event while at a complete stop with my foot firmly on the brake. On both occasions, the engine RPMs spiked above 1,000 RPM, forcing the vehicle to pull heavily against the brakes as if trying to race forward into the intersection. On the most recent event (Aug. 15) when stopping at a red light it appeared that the supercharger kicked in, pulling against the brakes. Six or eight pedestrians were crossing directly in front of the vehicle. If I had taken my foot of the brake I would have hit them. 1.June 12, 2026 Service Visit (RO #192480, attached): Following the June 6 incident, the vehicle was brought to Beyer Volvo Cars Falls Church, Va. The repair order explicitly notes:"Tech found the front sunroof drains to have clogged with dirt/debris and the floorboard to be full of water.""Interior was removed to dry out carpets and the sunroof drains were cleared." Clogged sunroof drains cause water ingress down the A pillar. 2.Diagnostic Code & Part Replacement: During this visit, fault code 161615 was retrieved. The technician noted "unable to duplicate the problem at this time" regarding the engine flare, and no physical inspection or remediation of the flooded wiring harnesses or module connectors beneath the carpet was performed. This same A6 electrical code 161615 was noted on a previous service on 25 Sep. 2025, (RO#184284, att

See attached document for complaint.

The car has “detected” a crash many times and automatically stopped even on the highway. It jerks and to slam on the brakes and then keeps going. It’s very dangerous and I have a strong theory it’s the model in general and not an isolated situation with my car.

The contact owns a 2020 Volvo S60. The contact stated that while at a stop light, the vehicle erroneously drove forward and crashed into a second vehicle. The contact indicate that during the crash the collision avoidance feature did not activate. No injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer and local dealer were notified of the incident. The failure mileage was 16,000.

It is unknown what caused this issue but ever since I bought my vehicle on April 5, 2021, I have been experiencing vibration issues when driving between 65-75 MPH. I have had my vehicle inspected at multiple Volvo Service Centers across Texas and no one can seem to figure out what is causing the vibration issues. My front rotors have been replaced 3 TIMES, my rear rotors have been replaced once, I have had multiple tire rotations, alignments and balancing from Volvo Service Centers and even from Discount Tire. With all of these items serviced/repaired/replaced, the vibration is still present in the steering wheel traveling at highway speeds. I went on a test drive today, 6/22/22, with a Volvo Service Technician and he confirmed that the vibration is valid. He also stated that the only thing left to do is to replace all 4 tires, at my cost, to see if the vibration goes away. He advised that when new cars are on the lot parked waiting to be sold, dealerships typically inflate the tires to about 50 PSI so as to avoid any "flat spots" on the tires. He also stated that many dealers also typically do not inflate tires on their new fleet due to the rough ride it causes. I have contacted Volvo regarding this issue without any remedy or advice. Additionally, my Volvo dealer cannot say for sure that they will reimburse me for tires, if I do choose to replace my current ones, even though this issue has been present since day 1.

Ongoing Problem as mentioned in Volvo's Technical Journal "Speed Dependent Vibrations at Highway Speeds" Ref No: TJ 20803.20.0 . At any speed of 75 mph and above the front continuously vibrates. The tires have been replaced two times in less than 2 weeks and road forced balanced by the dealership twice. The vibration does not go away. The dealership does not want to address the issue. The car is NEW.

I turned the car on and got an error message that said the turn indicator system failed. After trying to clear the message from the dash using the button on the steering wheel, I discovered that nothing on the steering wheel was working, including the windshield wipers or any buttons on the steering wheel. I called the manufacturer and they told me not to drive it and they towed it to the dealer. The dealer said they had see this before as either a software issue or electrical issue and would need to replace the stalks and buttons.

2020 VOLVO S60 T-6 R WENT IN FOR SERVICE AT VOLVO DEALER, 5/12/21, MILEAGE 24,018. TECHNICIAN NOTED REAR BRAKES LESS THAN 2MM & ROTORS GROOVED, NEEDS TO BE REPLACED. I WAS TOLD THIS IS NOT UNDER WARRANTY, IT'S NORMAL WEAR. THIS VEHICLE HAD SERVICE AT THE SAME DEALER ON 12/8/20, MILEAGE 16,952 THE SERVICE REPORT STATED, "BRAKES IN THE GREEN 7MM OR MORE". THE VEHICLE IS DRIVEN HIGHWAY MILES MAINLY, REGARDLESS OF THAT FACT, BRAKE PADS DON'T NOT WEAR DOWN 5MM IN 7,000 MILES ON A NEW CAR UNLESS THERE'S AN UNDERLYING PROBLEM, THERE HAS ALREADY BEEN A RECALL ON THE REAR AUTOMATIC PARK BRAKE, SEEMS LIKELY THAT THERE'S ADDITIONAL PROBLEMS WITH THE REAR BRAKES. THE REPLACEMENT COST ME $888.00

MY 2020 S60 T5 R-DESIGN HAD 3 BROKEN SENSORS, A SAFETY RECALL, MALFUNCTIONING BRAKES WHICH CAUSED THE CAR TO VEER, AND MOST RECENTLY A LEAKING A/C HOSE. ALL PROBLEMS FROM THE FACTORY (OUT OF THIN AIR) WITHIN THE FIRST 12 MONTHS OF MY LEASE. AFTER NUMEROUS COMPLAINTS TO VOLVO CAR USA, I WAS OFFERED A GENERIC AND DISMISSIVE ANSWER THAT VOLVO 'IS NOT IN THE POSITION' TO OFFER A TRADE ASSIST OR ANY HELP. NO EXPLANATION TO A LOYAL VOLVO CUSTOMER. THEY'RE SIMPLY 'SORRY' THAT I HAD TO TAKE OFF WORK TO SERVICE THEIR CAR AND WAS TOLD TO UBER HOME (NO COURTESY LOANER). AFTER THE MOST RECENT SERVICE VISIT, I DEMANDED VOLVO EITHER REPLACE THE CAR OR TERMINATE THE LEASE, BUT THE AGENT THOUGHT SERVICING THE VEHICLE 5 TIMES (BECAUSE PARTS WERE BREAKING) WAS ABSOLUTELY NORMAL. SHE WAS STUNNED I DO NOT HAVE A POSITIVE ATTITUDE NOW THAT MY CAR WAS FIXED. I DEMANDED CONTACT TO THE REGIONAL MANAGER, BUT MY AGENT (WHO TURNED OUT TO BE SUPERVISOR) REFUSED TO FORWARD ANY INFORMATION. MY CAR WOULD GO THROUGH A REVIEW PROCESS WITH 'SPECIAL PARAMETERS', BUT THE SUPERVISOR OF THE HEADQUARTERS OF VOLVO CARS USA WAS INCAPABLE OF ANSWERING WHAT THE PARAMETERS WERE, WHEN THIS REVIEW WOULD TAKE PLACE, OR WHO IS REVIEWING MY CASE' NOTHING WAS TRANSPARENT, AND FOR ALL I KNOW, THIS REVIEW COULD HAVE BEEN ARBITRARY. AS EXPECTED, 'VOLVO IS NOT IN THE POSITION'' VOLVO SENT AN AUTOMATED CUSTOMER SATISFACTION SURVEY, TO WHICH I PROVIDED FEEDBACK OF MY AWFUL EXPERIENCE. SADLY, THE SAME AGENT HANDLING MY CASE RESPOND

2020 VOLVO S60. CONSUMER WRITES IN REGARDS TO DISSATISFACTION WITH TIRE PRESSURE MONITORING SYSTEM. *LD *JS

'THE BRAKE FLUID IS LOW STOP SAFELY' MESSAGE CAME ON AT LESS THAN 87 MILES ON THE ODOMETER WHILE THE ENGINE WAS RUNNING ON MY DRIVEWAY. A VOLVO DEALER STATED THE FOLLOWING: FLUID WAS LOW NO EXTERNAL LEAK FOUND TOPPED OFF BRAKE FLUID TO FULL MARK 'THE BRAKE FLUID IS LOW STOP SAFELY' MESSAGE CAME ON AGAIN AT LESS THAN 191 MILES ON THE ODOMETER WHILE I WAS DRIVING ON A LOCAL ROAD AT ABOUT 35 MILES AN HOUR SPEED.