2006 Volvo S60

Defect. Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy. Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.

Defect. VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Risk. AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy. VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Defect. CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Risk. LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Defect. CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.

Risk. A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

The contact owned a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) and would like to be removed from the recall distribution list. The manufacturer was not contacted.

The contact owns a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted to schedule an appointment for the recall repair; however, the contact was unable to secure an appointment. The manufacturer was contacted and opened a case. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 Volvo S60. The contact stated that the air bag was replaced under NHTSA Campaign Number: 21V766000 (Air Bags) and approximately 2 weeks later, while the vehicle was idling at a stop sign, the air bag compartment on the driver's side started smoking and the air bag warning light illuminated. The smoke then dissipated. There were no injuries or medical attention needed. The contact returned the vehicle to the dealer who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. the manufacturer was made aware of the failure. The approximate failure mileage was 84,190.

My 06 s60 has blown 3 charge air hoses in the EXACT same spot. (The hose behind the radiator.) A golf-ball sized hole blows out in a bend in the hose while driving. The car will idle , but throttle up at all. The dealer says this is a fluke.

Lug bolts 19 MM are rusted into the 330 MM Brembo Disk brakes, They take over 220 ft lb of force to break lose, and you can not do that safety on the side of the road to change a flat tire

The contact owns a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I was expected to pay over one thousand dollars to have the recall remedy performed. My home and location of car is Ketchikan, Alaska. There is no Volvo dealer in Ketchikan and no roads connecting town with the mainland road system. The car would have to be shipped by either aircraft or oceangoing vessel to the mainland for access to a Volvo dealer. This would cost a lot of money. I perform all maintenance and repairs myself so I contacted Volvo asking then to ship me the air bag for installation. Volvo responded that I must take the car to a dealer at my own expense. The practical reality is that transporting the car to a dealer for this (or any other recall) is completely unreasonable, making it virtually impossible to have the recall repair performed unless Volvo will simply supply the part so I can install it.

A FEW MONTHS BACK, THIS VEHICLE WAS LEAKING GASOLINE FROM THE AREA OF FUEL PUMP. THE FUEL PUMP IS LOCATED UNDER THE REAR SEAT OF THE VEHICLE, SO THERE WAS ALSO A STRONG ODOR INSIDE THE CAR. THE VEHICLE FUEL TANK WAS FILLED JUST PRIOR TO THIS HAPPENING. SO, FOR 20 MILES, MYSELF AND MY WIFE WERE SUBJECTED TO GASOLINE FUMES, AND AT THE SAME TIME, RAW GASOLINE WAS SPILLING UNDERNEATH THE CAR WHILE DRIVING. MY REPAIR SHOP DIAGNOSED, AND REPAIRED CAR BY INSTALLING A NEW FUEL PUMP. AFTER FURTHER INVESTIGATION , I HAVE FOUND THAT VOLVO CARS DID RECALL, AND REPAIR SOME MODELS OF 2003 AND 2005... EVEN MY 2004 WAS REIMBURSED FOR THIS. I BELIEVE THAT VOLVO KNOWS THAT'S THERE IS A PART DEFECT, NOT A PART FAILURE... THIS IS A STATIONARY, HARD COMPOSITE PLASTIC THAT IS THE SAME CULPRIT AS THE EARLIER YEARS INVOLVED. I AM ASKING THE NHTSA TO FURTHER INVESTIGATE VOLVO CARS TO INSURE THAT NO ONE ELSE HAS THIS SCARE. IT COULD HAVE BEEN CATASTROPHIC FOR MYSELF AND ALL OTHERS ON THE ROADS THAT DAY

THE PASSENGER SIDE LIGHT WORKS INTERMITTENTLY THIS HAS BEEN A SLIGHT ISSUE SINCE 2006 WHEN I HAVE HAD NEW LIGHTS INSTALLED ON A REGULAR BASIS. DESPITE ME GOING TO THE DEALER FOR OVER THE LAST 11 YEARS OR SO IT IS ONLY GETTING MORE FREQUENT IN AGE. IT IS NOT THE BULB BUT THE WIRING IN THE VEHICLE THAT IS FAULTY. THIS CAN BE DANGEROUS ESPECIALLY WHEN COMBINED WITH THE FOG THAT THE LIGHTS HAVE PUT ON THE GLASS OVER THE YEARS. I HAVE PAID TO HAVE THE FOG REMOVED TWICE AND THE WIRING HARNESS CHECKED. AFTER LIVING IN 5 DIFFERENT STATES I SEE THIS IN ALMOST EVERY S60 IN THE MID 2000 ALWAYS ONE HEAD LIGHT OUT. IT WILL COME BACK ON WHEN YOU ENCOUNTER A BUMP SO IT IS A MISSED CONNECTION AT SOME POINT IN THE WIRE HARNESS. THIS CREATES SUCH LIMITED VISION IN NIGHT AND I AM CONSTANTLY GETTING HONKED AT. I HAVE PULLED OVER AND JIGGLED THE WIRES WHICH WILL ALLOW THE LIGHT TO WORK UNTIL YOU TURN A CORNER, HIT A BUMP OR IT JUST FADES. I BELIEVE THE HEADLAMPS SHOULD ALL BE REPLACED AND THE WIRING FIXED THIS IS SUCH AN ISSUE IN THE EVENINGS.

ENGINE THROTTLE. CAR SLOW DOWN TO A CRAWL WHILE DRIVING SPEED AT 60 MILES ON HIGHWAY , CHECK ENGINE LIGHT. TRYING TO FIND IF A RECALL . OTHER MUST BE HAVING THIS PROBLEM . THIS IS 2006 S60 VOLVO

TL* THE CONTACT OWNS A 2006 VOLVO S60. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD TO SHIFT THE GEAR TO NEUTRAL, TURN OFF AND RESTART THE VEHICLE IN ORDER TO ACCELERATE THE VEHICLE OUT OF THE INTERSECTION. THE VEHICLE WAS TAKEN TO BE DIAGNOSED. THE VEHICLE WAS DIAGNOSED AS NEEDING A NEW FUEL PRESSURE SENSOR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 44,500.

MY COMPLAINT IS AGAINST SYLVANIA ULTRA HEADLIGHTS, PURCHASED FROM AUTOZONE. "THE HEADLIGHTS FAILED SHORTLY AFTER 2 MONTHS, THEY ARE THE MOST EXPENSIVE HEADLIGHTS THEY SELL (THINKING THEY ARE THE BEST) I PURCHASED A PAIR. HAD THEM REPLACED AT A LOCAL MECHANIC - THEY WERE INSTALLED CORRECTLY. - THIS ACTION WAS REPEATED FOR 3 SETS OF REPLACEMENTS. THE 4TH TIME AROUND I DID NOT PURCHASE HEADLIGHTS - I TOOK IT TOO THE MECHANIC AND ASKED HIM TO CHECK THE WIRING AND REPLACE THE HEADLIGHTS YET AGAIN. THE MECHANIC CALLED AUTOZONE - THEY ASKED DO YOU WANT THE GOOD ONES OR THE BAD ONES ? THE MECHANIC SAID LOOKING AT ME - THE GOOD ONES OF COARSE. THEN THE SALES PERSON ON THE PHONE DESCRIBED HOW SUCKY THE OTHER ONES ARE TO THE MECHANIC. ABOUT 30 MINS LATER - AUTOZONE DELIVERED THE HEADLIGHTS THAT WERE SYLVANIA BUT NOT THE ULTRA.WHEN I WAS IN AUTOZONE - THEY CLAIMED THESE ULTRAS ARE THE BEST. THESE BOGUS ULTRA HEADLIGHTS ARE A SAFETY HAZARD AND IT APPEARS THEY KNOW THEY ARE BAD - I SMELL A SCAM BEING PERPETRATED AGAINST THE PUBLIC PRODUCING A SAFETY HAZARD AND UNNECESSARY EXPENSE/RIP OFF.

VEHICLE TURNS IT SELF OF WHILE DRIVING.I FELL VERY UNSAFE DRIVING THIS CAR, BECAUSE SOMEONE MIGHT HIT ME FROM BEHIND. THE DEALER TELLS ME IT'S A FUEL SENSOR MODULE. IT'S A FAULTY PART MENTIONED ALL OVER THE INTERNET.

THIS REPORT CONCERNS THE FAILURE OF THE PARKING BRAKE ASSEMBLY ON MID 2000S VOLVO SEDANS AND SPECIFICALLY, A 2006 VOLVO S60, 2.5T. SPECIFICALLY, A DE-LAMINATION OF THE PARKING BRAKE SHOE ASSEMBLY, WHICH RESULTS IN A TENDENCY FOR A METAL COMPONENT OF THE SHOE ASSEMBLY TO DISLODGE AND JAM BETWEEN THE BRAKE PAD AND ROTOR, RESULTING IN THE BRAKE SUDDENLY LOCKING UP WITH NO WARNING. WHILE THE EVENT GIVING RISE TO THIS REPORT OCCURRED AT APPROXIMATELY 20MPH, AT HIGH SPEEDS, A BRAKE JAM EVENT OF THIS NATURE COULD RESULT IN SERIOUS INJURY OR DEATH. THE ONSET OF THE DE-LAMINATION OF THE PARKING BRAKE SHOE ASSEMBLY OCCURS WITH NO WARNING, OTHER THAN A MILD BUMPING NOISE WHEN THE VEHICLE IS PLACED INTO REVERSE OR DRIVE AT LOW SPEEDS. UPON INQUIRY TO SEVERAL VOLVO-SPECIFIC REPAIR SHOPS, AS WELL AS MULTIPLE REPORTS ON ONLINE VOLVO-SPECIFIC FORUMS, THIS PROBLEM IS KNOWN TO BE A RELATIVELY COMMON ISSUE AFTER APPROXIMATELY 4-8 YEARS OF NORMAL WEAR AND/OR 50,000-100,000 MILES OF USE ON THE EMERGENCY BRAKE SHOES. HOWEVER THERE IS NO SERVICE BULLETIN ISSUED BY VOLVO AS TO THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 VOLVO S60. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE BECAME INVOLVED IN A CRASH WITH ANOTHER VEHICLE AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT HEARD A LOUD BANG AND A BURNING ODOR EMITTED FROM THE AIR BAG. HOWEVER, THE AIR BAG DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

ETM FAILS CAUSING ME TO LIMP HOME OR HAS ERRATIC THROTTLE BEHAVIOR, HAD REPAIRED BASICALLY THEY JUST STATED IT HAD TO BE CLEANED BUT THE INJECTORS WHERE FINE. AFTER SPENDING OVER $600.00 DOLLARS NOW THEY ARE STATING I NEED TO SPEND ANOTHER $600.00 ON THE PART TO REPLACE BECAUSE THE MOTOR IS CAUSING IT TO FAIL. I AM USUALLY DRIVING DOWN THE ROAD AND THEN A MESSAGE WILL DISPLAY 'REDUCE ENGINE PERFORMANCE CAUSING ME TO GO FROM 65 DOWN TO 40 MILES PER HOUR AND I FEAR THAT ONE DAY IT IS GOING TO CAUSE AND ACCIDENT DUE TO A MECHANICAL FAILURE ON BEHALF OF VOLVO ETM FIASCO. VOLVO HAS KNOWN THIS IS A FAULTY DESIGN BECAUSE BACK IN 1999 TO 2002 THERE WAS A RECALL AND THEY WERE ISSUED A 10 YEAR WARRANTY OR 200,000 MILE WARRANTY AFTER REPEAT FAILURES. I AM FILING A COMPLAINT BASED ON SAFETY CONCERNS AND DEMAND A RECALL AND BASED ON THE SAME ISSUE 'FAULTY DESIGN' AND VOLVO HAS KNOWN THIS CONTINUES TO BE A PROBLEM. 2006 SEEM TO HAVE A VERY HIGH REPAIR AND THIS SO HAPPENS TO BE ONE OF THOSE CARS. THANKS! *TR

I HAVE MADE A RECENT COMPLAINT REGARDING SAFETY CONCERNS WITH A FAULTY ETM (ELECTRONIC THROTTLE MODULE) ON MY VEHICLE. I DROPPED IT OFF AT MY LOCAL AUTHORIZED DEALER FOR VOLVO AND I DID NOT TELL THEM THAT THE CAR PRODUCED AN ERROR CODE P2135 / ECM-9200 -- THROTTLE POSITION SENSOR --FAULTY SIGNAL, BECAUSE I WANTED TO SEE WHAT ERROR CODES THEY WOULD PULL OFF. IT IS MY UNDERSTAND EVEN IF I RESET THE 'CHECK ENGINE' LIGHT THE DEALER IS ABLE TO PULL THE CODES OF THE COMPUTER. WELL IN THIS CASE THE DEALER CALLED ME TODAY AND ADVISED ME THAT NO CODES COULD BE PULLED BUT WANTED TO KNOW IF THE PERSON WORKING ON MY CAR COULD TAKE IT HOME WITH HIM AND TAKE A READER. I SAID NO, BUT I DID NOT TAKE MY CAR THERE BECAUSE I WANT SOMETHING FOR FREE. I AM BEYOND FRUSTRATED WITH THE VOLVO BECAUSE OF THE FAULTY DESIGN. WHAT WILL IT TAKE NEXT TIME FOR ME TO BE ON THE FREEWAY AND DRIVING AND THE ERROR TO BE DISPLAYED AND CAUSE ME TO DROP MY SPEED DOWN AND GET INTO AN ACCIDENT? I FEAR THAT DAY WILL COME SOMEDAY IF NOT ME SOMEONE ELSE. *TR

IN MY 2006 VOLVO S60 THE ETM WENT OUT AFTER ONLY 48000 MILES. THE ENGINE HAS A ROUGH IDLE AND WON'T GO OVER 40 MPH. IT'S IN LIMP MODE. A REPLACEMENT FOR THE ETM IS UPWARDS OF $1,000 AND THE DEALER NEEDS TO BE THE ONE TO SERVICE TO MATE THE ETM TO THE CAR. LOOKING ON THE FORUMS AND AROUND IT AMAZES ME HOW COMMON THIS PROBLEM IS. THE RECALL THAT WAS FOR 1999-2002 MODELS SHOULD BE EXTENDED TO ALL MODEL YEARS THAT ARE AFFECTED BY THIS FAULTY PART TO ENSURE THAT ALL VOLVO OWNERS ARE SAFE FROM THIS POTENTIALLY DANGEROUS PROBLEM. *TR

I WAS DRIVING MY 2006 VOLVO S60 AND THE ENGINE SHUT OFF WITHOUT WARNING. THE ELECTRICAL SYSTEM SHUT OFF AND I WAS NOT EVEN ABLE TO PUT THE FLASHERS ON SO THAT OTHER DRIVERS COULD KNOW THAT THERE WAS A PROBLEM. I WAS ABLE TO PULL THE CAR TO THE SIDE OF THE ROAD (WITH DIFFICULTY SINCE THE POWER STEERING NO LONGER WORKED) AND PUT THE CAR IN PARK AND RESTART IT. *TR

THE ELECTRONIC THROTTLE MODULE HAD TO BE REPLACED IN MY 2006 VOLVO S60. THE CAR ONLY HAS 72,702 MILES! THIS IS AFTER HAVING PAID SEVERAL HUNDRED DOLLARS TO HAVE THE ETM CLEANED SEVERAL MONTHS AGO. THE COST TO REPLACE THE ETM WAS OVER $800. AS I SEARCH THE INTERNET, THESE CARS SEEM TO HAVE PROBLEMS WITH THIS PARTICULAR PART. IT'S RIDICULOUS TO THINK THAT I'M GOING TO HAVE TO KEEP PAYING FOR THIS PART, ESPECIALLY WHEN THE CAR IS ONLY 5 YEARS OLD AND HAS FAR LESS THAN 100,000 MILES!!! I DEMAND A RECALL AND WARRANTY REPLACEMENT! THE SERVICE MANAGER AT MY LOCAL VOLVO DEALERSHIP TELLS ME THESE UNITS NEED TO BE CLEANED OR SERVICED ABOUT EVERY 30K MILES. I HAVE A COPY OF MY RECEIPT FROM THIS WEEKS SERVICE. THIS PART SHOULD BE COVERED UNDER A WARRANTY BY THE MANUFACTURER! BELIEVE ME, I'M ACTIVE ON THE WEB AND I'M GOING TO TELL EVERYONE I KNOW TO STAY AWAY FROM VOLVOS. *TT