2009 Volvo S60

Defect. Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk. An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy. Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.

Defect. VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.

Risk. POSITIONING OF THE SEAT BEYOND THE INTENDED MAXIMUM CAN CAUSE INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.

Remedy. DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT [email protected].

Defect. VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Risk. AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy. VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

The contact owns a 2009 Volvo S60. The contact stated that while driving at an undisclosed speed, the column turn signal lever detached. The contact stated that the turn signal and headlight switches were inoperable due to the failure. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure, and an appointment was scheduled for a future date. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,000.

Driving at 25 mph and the airbag spontaneously deployed. Exploded. Dust. Noise. No impact no accident. Hurt my hand. Busted the turn signal arm Caused me to drive over a median and damage the under carriage of the car.

I am unable to service my car to fix the recall, because there is no Volvo dealer where I live.

TL* THE CONTACT OWNS A 2009 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE REAR DRIVER'S SIDE DOOR OPENED INDEPENDENTLY ON 10/19. CONSUMER MENTIONED THAT WHEN SHE HITS A BUMP THE DOOR AJAR WARNING LIGHT ILLUMINATED, AT ANY SPEED. CONSUMER ALSO STATED DOOR WOULD NOT OPEN FROM OUTSIDE WHEN UNLOCKED, THIS WOULD HAPPEN ONCE IN AWHILE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.*DT*JB

ACCELERATING ON INTERSTATE AND ALL OF A SUDDEN COMPLETY LOST ENGINE POWER. ENGINE WOULD CONTINUE RUNNING, BUT WOULD NOT ACCELERATE. COULD HAVE EASILY GOTTEN INTO A WRECK IF THERE HAD BEEN MORE TRAFFIC ON THE INTERSTATE. ENDED UP GETTING TOWED AND HAVING TO REPLACE THE THROTTLE UNIT WHICH COST ALMOST $1000, THIS COULD HAVE BEEN A VERY DANGEROUS SITUATION WITH A VERY BAD OUTCOME IF TRAFFIC HAD BEEN HEAVIER.

I KEEP GETTING A MESSAGE THAT THE TIRE PRESSURE MONITORING SYSTEM NEEDS SERVICE EVEN THOUGH THE TIRES HAVE THE CORRECT PRESSURE. I BELIEVE THERE IS A DEFECT IN THIS SAFETY RELATED SYSTEM. IT IS AN ISSUE THAT MANY VOLVO OWNERS HAVE REPORTED, YET VOLVO CONTINUALLY FAILS TO ADDRESS THE ISSUE. *TR

2009 VOLVO S60 AWD - WHEN FILLING WITH GASOLINE AT VARIOUS GAS STATIONS, GASOLINE OVERFLOWS AND SPILLS OUT OF THE FUEL FILLER NECK WHEN THE TANK IS FULL. THIS IS WITH THE LOCK MECHANISM ENGAGED ON THE GAS PUMP HANDLE. I HAVE OBSERVED THIS AT MULTIPLE GAS STATIONS AND DIFFERENT PUMPS AT THOSE GAS STATIONS. I HAVE TAKEN OTHER VEHICLES TO THE SAME STATIONS AND PUMPS AND FILLED THEIR TANKS IN THE SAME FASHION, AND THE LOCK MECHANISM ON THE PUMP HANDLE AUTOMATICALLY DISENGAGES AND NO GAS OVERFLOWS WHEN THE TANK IS FULL AND REACHES CAPACITY. I HAVE ALREADY TAKEN THIS VEHICLE ONCE PREVIOUSLY IN SEPTEMBER 2009 AND THEY FOUND NO ISSUE. I AM TIRED OF DEALING WITH IT AND WORRIED ABOUT A FIRE OCCURRING DUE TO THIS. THE GAS SPILLS OUT AND ON TO THE PAINT ON THAT SIDE OF THE VEHICLE AND ONTO THE GROUND. *TR