2005 Toyota Tacoma complaints

I WAS DRIVING DOWN A COUNTY TWO LANE ROAD. AS I APPROACHED A SLIGHT CURVE, THE POWER STEERING SEEMED TO FAIL AND THE TRUCK RAN OFF THE EDGE OF THE ROAD. I IMMEDIATELY SLOWED THE VEHICLE, AND WITH LOTS OF MUSCLE I STEERED THE VEHICLE BACK ONTO THE ROAD. I JUMPED OUT OF THE VEHICLE TO CHECK FOR DAMAGE SUCH AS A LEAKING STEERING HOSE OR BROKEN SERPENTINE BELT. NOT SEEING ANY IMMEDIATE DAMAGE, I SLOWLY DROVE THE VEHICLE ABOUT A MILE AND A HALF TO MY HOME. AFTER A THROUGH INVESTIGATION OF THE STEERING SYSTEM, I DISCOVERED THE INTERMEDIATE SHAFT THAT ATTACHES THE STEERING COLUMN TO THE RACK & PINION, HAD A FROZEN/BINDING UNIVERSAL JOINT. THIS UNIVERSAL JOINT IS EXPOSED TO THE ELEMENTS AND DOES NOT HAVE A LUBRICATION FITTING. THIS ITEM IS NOT MENTIONED IN THE MANUAL UNDER PERIODIC MAINTENANCE. UNDER A DIFFERENT CIRCUMSTANCE, SUCH AS MY WIFE DRIVING THE VEHICLE, THIS INCIDENT MY HAVE CAUSED A LOT OF DAMAGE TO THE OCCUPANTS AND OTHERS AROUND THE VEHICLE. *TR

I HAVE A TOYOTA TACOMA 2005 THAT HAS A VERY RUSTY FRAME LAST STATE INSPECTION, WAS TOLD THE FRAME IN TWO SPOTS IS VERY SOFT AND IT MORE THAN LIKELY WILL NOT PASS INSPECTION NEXT YEAR. THERE ARE NUMEROUS REPORTS ON THE INTERNET ABOUT OWNERS OF THIS YEAR MODEL ALSO HAVING THE SAME PROBLEM. *TR

THE TOYOTA TACOMA BECAME DIFFICULT TO STEER, AS THOUGH THE POWER STEERING WAS FAILING. TO NEGOTIATE THE VEHICLE THROUGH A BEND IN THE ROAD I HAD TO EXERT SIGNIFICANT AMOUNT OF FORCE ON THE STEERING WHEEL AND HAD TO MANUALLY FORCE THE WHEEL BACK TO CENTER. THIS MOMENTARILY INHIBITED ME FROM KEEPING THE VEHICLE CENTERED IN THE LANE. THIS PROBLEM HAS SINCE RECURRED INTERMITTENTLY. ON INSPECTION I WAS ABLE TO DETERMINE THE CAUSE OF THE IMPAIRED STEERING CONTROL TO BE CORROSION OF THE UNIVERSAL JOINT #2 STEERING INTERMEDIATE SHAFT PART # 45203-04020. ON SEARCHING FOR A REMEDY I LEARNED THIS PART HAS BEEN REDESIGNED TO ADDRESS THE PROBLEM, AND THE REPLACEMENT PART IS 45220-04020. APPLICATION OF PENETRATING OIL TO THE STEERING INTERMEDIATE SHAFT UNIVERSAL JOINT HAS REDUCED THE SEVERITY OF THE PROBLEM BUT NOT PERMANENTLY RESOLVED IT. IF THIS PROBLEM OCCURRED WHILE A YOUNGER, OLDER OR OTHERWISE PHYSICALLY WEAKER OPERATOR WAS DRIVING THEY MAY HAVE HAD DIFFICULTY KEEPING THE VEHICLE IN ITS LANE. *TR

THERE IS A HOLE IN THE FRAME BELOW THE DRIVERS DOOR DUE TO RUST. VEHICLE MAY BE UNSAFE DUE TO A FAULTY FRAME. PRIOR YEARS HAD PROBLEMS WITH THE FRAME. MY HUSBAND DRIVES THE TRUCK 500 MILES A WEEK TO WORK. TOYOTA CLAIMS NOTHING IS WRONG AND WILL NOT DO ANYTHING ABOUT IT. *TR

THE STEERING ALL OF A SUDDEN BECAME SURPRISINGLY HARD TO TURN AS IF THE POWER STEERING FAILED. THIS IS A COMMON OCCURRING PROBLEM IN THIS MAKE AND MODEL OF TRUCK AND IS A SAFETY CONCERN. THE ONSET OF THIS PROBLEM IS INCREDIBLY FAST WHICH COULD LEAD TO SERIOUS CRASHES AND INJURIES!!! THE CAUSE IS A FAULTY PART DESIGN (PART IS EXPOSED TO THE ELEMENTS AND SEIZES) AND NEEDS TO BE REMEDIED ASAP. THE FAULTY PART # 45203 - 04020, INTERMEDIATE SHAFT. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE AT THE DEALER FOR UNRELATED REPAIRS, THE TECHNICIAN NOTICED RUST THROUGHOUT THE ENTIRE FRAME. THE CONTACT WAS UNAWARE OF THE NECESSARY REPAIRS TO CORRECT THE FAILURE. THERE WAS A MANUFACTURER'S RECALL FOR CORROSION OF THE FRAME HOWEVER, THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 89,960. UPDATED 4/1/13 *CN THE CONSUMER STATED HE HAS SINCE TRADED THE VEHICLE.

THE VEHICLE HAS NEVER BEEN IN AN ACCIDENT AND IS NOT MODIFIED IN ANY WAY. THE VEHICLE IS 8 YEARS AND HAS 64,000 MILES. AIR BAG INDICATOR LIGHT CAME ON. DEALER DIAGNOSED FAULTY SPIRAL CABLE, $500 REPAIR. AFTER REPAIR, CONDITION RETURNED. SUBSEQUENTLY A RECALL WAS ISSUED BY TOYOTA FOR THE SPIRAL CABLE. NEW SPIRAL CABLE WAS INSTALLED BY DEALER. AIRBAG INDICATOR LIGHT RETURNED WITHIN 1 WEEK. RETURNED TO DEALER, NEW DIAGNOSIS: NEED TO REPLACE ENGINE WIRING HARNESS. COST $2300 + TAX. DISPUTE STARTED WITH TOYOTA USA. TOYOTA SUBSEQUENTLY OFFERED TO PAY FOR 1/2 OF THE COST OF THE REPLACEMENT PART, LEAVING ME TO PAY THE OTHER HALF AND THE REPLACEMENT LABOR. TEXT OF RECALL: "DUE TO COMBINATION OF FACTORS, A PART IN THE STEERING WHEEL ASSEMBLY IN YOUR VEHICLE CALLED THE SPIRAL CABLE MAY BECOME DAMAGED. IF DAMAGE OCCURS, THIS CAN AFFECT THE ELECTRICAL CONNECTION TO SEVERAL SYSTEMS, INCLUDING THE DRIVER'S AIR BAG. SUCH DAMAGE WOULD CAUSE THE AIR BAG WARNING LIGHT TO STAY ON AFTER STARTING THE ENGINE, AND THE AIR BAG MAY NOT WORK. THIS COULD INCREASE THE RISK OF INJURY TO THE DRIVER IN A CRASH IN WHICH THE AIR BAG IS DESIGNED TO INFLATE." THE CRITICAL PART OF THE RECALL NOTICE IS "THE SPIRAL CABLE MAY BECOME DAMAGED. IF DAMAGE OCCURS, THIS CAN AFFECT THE ELECTRICAL CONNECTION TO SEVERAL SYSTEMS, INCLUDING THE DRIVER'S AIR BAG". IT APPEARS THAT TOYOTA RECOGNIZES THE EFFECT OF A DAMAGED SPIRAL CABLE (THE ISSUE OF THE RECALL) ON OTHER SYSTEMS BUT REFUSES TO REPAIR ANY SUCH DAMAGE WHEN FOUND. T

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE STEERING WHEEL SUDDENLY BECAME EXTREMELY DIFFICULT TO MANEUVER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THERE WERE RUSTED COMPONENTS WITHIN THE STEERING WHEEL. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. THE VIN WAS NOT AVAILABLE.

DURING A ROUTINE OIL CHANGE I NOTICED A LARGE RUST HOLE IN THE PASSANGER SIDE FRAME RAIL. THE HOLE IS ROUGHLY 10-12 INCHES LONG ON THE INSIDE OF THE RAIL ROUGHLY UNDER THE PASSANGER SIDE FLOOR BOARD. I HAVE NOTICED ALOT OF SURFACE RUST OVER THE PAST COUPLE OF YEARS AND HAVE TRIED TO SEAL THE AREA..PAINT OR UNDER COAT... NOTHING SEEMS TO STOP THE RUST. I TOOK THE TRUCK TO THE DEALER WHERE YES THEY DO AKNOWLAGE THE HOLE BUT SAID SINCE THE TRUCK WAS OUT OF WARRANTY THEY WERE NOT PREPARED TO DO ANY THING ABOUT IT,,,SEE YA HAVE A NICE DAY. I UNDERSTAND THIS HAS BEEN AND STILL IS A MOJOR PROBLEM FOR TOYOTA. I CONTACTED TOYOTA AND LOGGED IN A COMPLAINT AND HAVE YET TO HEAR BACK. *TR

2005 TOYOTA TACOMA. CONSUMER REQUESTS REIMBURSEMENT FOR RECALL REPAIRS ON VEHICLE. *SMD THE CONSUMER STATED HIS REQUEST FOR REIMBURSEMENT WAS DENIED FOR THE RECALLS AND TOYOTA NEVER PROVIDED HIM WITH AN EXPLANATION. THE CONSUMER HAS SINCE TRADED THE VEHICLE.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA PRE-RUNNER. THE CONTACT STATED THAT WHILE COMPLETING A THREE-POINT-TURN, SHE APPLIED THE BRAKES AND THE RPM'S STARTED INCREASED ABNORMALLY. THE VEHICLE THEN ACCELERATED WITHOUT WARNING, CAUSING THE CONTACT TO CRASH INTO A PARKED VEHICLE. THE CONTACT WAS NOT INJURED. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND ADVISED HER THAT HER VEHICLE SHOULD NOT HAVE EXPERIENCED THE FAILURE DUE TO NHTSA CAMPAIGN ID NUMBER 09V388000 (VEHICLE SPEED CONTROL) BEING PERFORMED ON THE VEHICLE PREVIOUSLY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 73,469. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT HE NOTICED A HOLE IN THE FRAME OF THE VEHICLE DUE TO RUST. THE VEHICLE WAS TAKEN TO A DEALER, WHO CONFIRMED THERE WAS A HOLE IN THE FRAME OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 98,000.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED AFTER SHIFTING HER VEHICLE IN REVERSE GEAR, THE RPMS INCREASED. THE CONTACT SHUT THE VEHICLE OFF AND RESTARTED IT THREE TIMES AND IT BEGAN TO FUNCTION NORMALLY; HOWEVER, WITHIN IN MINUTES WHILE DRIVING APPROXIMATELY 35 TO 40 MPH THE ACCELERATOR PEDAL JAMMED WITHOUT WARNING. THE CONTACT IMMEDIATELY PLACED THE VEHICLE INTO NEUTRAL GEAR AFTER THE BRAKES FAILED. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 59,000.

TO WHO IT MAY CONCERN: WOULD YOU BE ABLE TO RESEARCH AND COVER A 2005 TOYOTA TACOMA PROBLEM PLAGUING TOYOTA CUSTOMER. THE ISSUES IS A PROBLEM WITH THE DESIGN OF THE FRAME. THE FRAMES ARE FAILING AT THE ENGINE MOTOR MOUNT(VERY VERY DANGEROUS) AND CAUSING THE CARS TO BE ALMOST BE IN-REPAIRABLE(TOYOTA ADVISE ME IT WOULD BE 10,000 FIX). TOYOTA IS OFFERING NO ASSISTANCE AND THERE ARE TONS OF CUSTOMER FEEDBACK ONLINE TO SHOW THERE IS A PROBLEM WITH THEIR FRAMES. FOR MY TRUCK I HEARD A NOISE COMING FROM THE ENGINE ON 12/24/2012 AND TOOK INTO A DEALER ON 12/26/2012. THEY SAID IT WAS THE FAN HITTING THE FAN SHROAD THEY SAID THEY FIXED IT. I STARTED HEARING THE NOISE AGAIN AND HAD TO TAKE IT IN ON 1/5/2013...THEY FIRST SAID IT WAS MY MOTOR MOUNTS AND WOULD NEED TO ORDER THE PART..WHEN THEY WERE GOING TO INSTALL THE PART THEY NOTICE A CRACK IN THE FRAME WHERE IT CONNECTS TO THE MOTOR MOUNT. THEY SAID THERE WAS NO OTHER SIGNS IF DAMAGE ANY WHERE AND DID NOT KNOW HOW THAT HAPPENED...MEANING THE FRAME FAILED FROM THE TORQUE OF THE ENGINE.. THEY ADVISE I WOULD NEED TO GET NEW FRAME ($10,000)...I CALLED TOYOTA AND ADVISE THEY WOULD NOT ASSIST. *TR

2005 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO SAFETY RECALL NOTICE. *TGW THE CONSUMER STATED HE TOOK THE VEHICLE TO THE DEALER, WHERE THEY FOUND THREE OTHER THINGS WRONG WITH THE VEHICLE, WHICH DID NOT PERTAIN TO THE RECALL. THE CONSUMER STATED IS SEEMED THE DEALER WANTED TO GET PAID FIRST, FOR OTHER THINGS, THEY CLAIMED WERE WRONG WITH HIS VEHICLE. UPDATED 02/06/13

AS THE DRIVER APPROACHED A RED LIGHT, THERE WAS A LOUD NOISE. HE PLANNED TO GET THROUGH THE INTERSECTION, PULL OVER TO INVESTIGATE. WHEN THE LIGHT TURNED GREEN, HE ACCELERATED AND THE FRONT LEFT WHEEL POPPED OFF THE AXLE AND ROLLED AWAY. THE TRUCK FELL AND HIT THE PAVEMENT. UPON INVESTIGATION IT WAS DETERMINED THAT THREE LUGS BROKE OFF SIMULTANEOUSLY AND WERE NOT LOCATED AT THE SCENE. TWO LUGS REMAINED BUT BROKE OFF WHEN THE VEHICLE ATTEMPTED TO MOVE. THE VEHICLE HAD FOUR NEW TIRES INSTALLED ON 12/27/12, AND OIL CHANGE AND NEW BRAKES INSTALLED ON 12/31/12. AT THE TIME THAT WORK WAS DONE, THE MECHANICS DID NOT OBSERVE ANY ISSUES WITH THE LUGS. THE WHEELS ARE ALLOY AFTERMARKET INSTALLED BY THE DEALER BEFORE THE VEHICLE WAS SOLD. THE VEHICLE HAD JUST EXITED THE HIGHWAY WHEN THE INCIDENT OCCURRED. THE POLICEMAN ON THE SCENE SAID THE DRIVER WOULD NOT HAVE SURVIVED IF THIS HAPPENED FIVE MINUTES EARLIER WHEN HE WAS STILL ON THE HIGHWAY. IS THIS INCIDENT RELATED TO THE ISSUES OUTLINED IN THIS CASE?: NHTSA CAMPAIGN NUMBER:05E077000 VEHICLE/EQUIPMENT MAKE:TOYOTA VEHICLE/EQUIPMENT MODEL:20" ALLOY WHEEL MFG COMPONENT DESC:WHEELS:LUGS/NUTS/BOLTS MFG INVOLVED IN RECALL:TOYOTA MOTOR NORTH AMERICA, INC. TYPE OF REPORT:(E) VEHICLE MFG RESPONSIBLE FOR RECALL:TOYOTA MOTOR CORPORATION REPORT RECEIVED DATE:12-22-05 DEFECT SUMMARY: CERTAIN TOYOTA TUNDRA AND SEQUOIA TRUCKS EQUIPPED WITH TOYOTA RACING DEVELOPMENT (TRD) 20" ALLOY WHEELS SOLD AND INSTALLED BY TOYOTA DEALERS AS AN AFTERMARKET ACCESSORY

2005 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO VEHICLE HEADLIGHTS. *SMD THE CONSUMER STATED THE PLASTIC COVERS THAT COVERED THE HEADLIGHTS HAD TURNED YELLOW. THE CONSUMER STATED THE COVERS SHOULD HAVE BEEN MADE OUT OF GLASS, INSTEAD OF PLASTIC.

VEHICLE WAS AT DEALER SHOP FOR BRAKE JOB AND TECHNICIAN REPORTED RUSTED-THROUGH FAILURE OF FRAME WHICH RENDERS THE VEHICLE UNSAFE TO DRIVE. THIS IS A SECOND GENERATION TACOMA, 2005 MODEL YEAR. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE SPARE TIRE FELL AND DETACHED FROM THE VEHICLE. THE SPARE TIRE WAS LOCATED UNDER THE VEHICLE AND THE CONTACT STATED THAT THE ENTIRE CROSS MEMBER ON THE REAR OF THE VEHICLE BECAME RUSTED. THE CONTACT STATED THAT HALF OF THE REAR CROSS MEMBER ALSO FRACTURED AND DETACHED FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE CROSS MEMBER THAT WAS LOCATED IN THE CENTER OF THE VEHICLE WAS ALSO COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 145,000.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH AND COMPLETING A TURN, THE STEERING WHEEL SLOWLY RETURNED TO A STRAIGHT POSITION. THE FAILURE RECURRED WHENEVER THE CONTACT WAS ATTEMPTING A TURN IN EITHER DIRECTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

THE SUN VISORS IN MY TRUCK WILL NOT KEEP IN THE UP POSITION. IT STAYS HANGING BLOCKING MY VIEW. I HAVE ASKED TOYOTA TO REPAIR IT, BUT SINCE IT IS PAST THE WARRANTY PERIOD, THEY WILL NOT REPAIR IT. IT IS A GREAT DANGER TO HAVE MY VISION BLOCKED BY THIS OBJECT. I STRONGLY FEEL THE MATERIALS USED IN THE ARM OF THE SUN VISORS ARE DEFECTIVE. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED WHILE DRIVING 25 MPH, A CRASH OCCURRED. THE CONTACT STATED THAT THE FLOOR MAT CAUSED THE ACCELERATOR PEDAL TO GET STUCK. THE DRIVER APPLIED THE BRAKE PEDAL AND THE VEHICLE CRASHED INTO A TREE. THE DRIVER AND PASSENGER SUSTAINED INJURIES. THE VEHICLE WAS DESTROYED AND THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER HAVING REPAIRS PERFORMED ON THE VEHICLE UNDER NHTSA CAMPAIGN ID NUMBER: 12V092000 (AIR BAGS:FRONTAL), THE AIR BAG WARNING LIGHT ILLUMINATED SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THERE WAS AN ECM AIR BAG MALFUNCTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE AND REFERRED HER TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 110,000.

I HAVE A 2005 TACOMA REGULAR CAB. IT HAS ROUGHLY 58K ON THE ODO AND THE FRAME IS RUSTED FROM THE FRONT TO THE BACK INSIDE AND OUT. IN SOME PLACES, SUCH AS THE REAR LEAF SPRING ATTACHMENT POINTS IT IS TO THE POINT WHERE SCALE FLAKING OFF AND ROT APPEARS TO BE TAKING PLACE. THIS IS UNSAFE AND UNACCEPTABLE FOR A VEHICLE PRODUCED IN TODAY'S DAY AND AGE! WHY ISN'T ANYTHING BEING DONE AS WAS THE CASE FOR THE PRE 2004 TRUCKS? AFTER TALKING WITH SEVERAL OTHER 2005+ TACOMA OWNERS, IT APPEARS AS THOUGH THE PROBLEM WAS NEVER SOLVED AND THE NEW 2ND GENERATION TRUCKS HAVE IT JUST AS BAD AS THE EARLY TACOMAS. AGAIN, THIS IS UNSAFE AND I TRULY HOPE TOYOTA IS WILLING TO STAND BEHIND THEIR TRUCKS AS THEY DID WITH THE EARLIER TACOMAS. *TR

THE DRIVER SIDE SUN VISOR WILL NOT STAY FLAT AGAINST THE ROOF. IT APPEARS THE INTERNAL SPRING OR MECHANISM IS DEFECTIVE AND NO LONGER HOLDS THE VISOR IN A CORRECT POSITION. VISOR NOW JUST FLAPS DOWN OBSTRUCTING VIEW. *TR

JUST STARTED MY TRUCK UP TO GO TO WORK AS USUAL AND AFTER ABOUT 1/2 A MILE THE AIRBAG LIGHT CAME ON. MY TRUCK HAS NEVER BEEN IN AN ACCIDENT AND THE AIRBAGS HAVE NEVER BEEN DEPLOYED BEFORE SO I WANTED TO GET IT CHECKED OUT WHEN I GOT TO WORK. AS AN ASE CERTIFIED TECHNICIAN I HOOKED UP MY SCAN TOOL AND PULLED CODE B1801-OPEN IN D SQUIB CIRCUIT. SO I EXAMINED IT MORE AND PULLED UP AIRBAG OPERATION DATA PASSENGER BUCKLE SW (SEATBELT) UNPLUGGED=UNSET PLUGGED IN=SET D SEAT POS WITH SEATBELT UNBUCKLED=BKWRD BUCKLED=FRWRD DRIVER BUCKLE SW UNPLUGGED=UNSET AND PLUGGED IN=UNSET. I FOLLOWED THE TOYOTA MOTOR SALES USA INC TROUBLE TREE FOR THIS DTC AND CAME TO THE CONCLUSION THAT THE SPIRAL CABLE NEEDS REPLACED. WENT ONLINE AND GOOGLED THE DTC AND HAVE FOUND SEVERAL COMPLAINTS AND QUESTIONS ABOUT THIS DTC. SEVERAL FAILURES OF THE SPIRAL CABLE. THIS SEEMS LIKE IT IS A MANUFACTURING DEFECT THAT HAS BEEN DESIGNED TO FAIL. I FEEL TOYOTA NEEDS TO STEP UP AND CORRECT THE DEFECTIVE PARTS. *TR

LAST YEAR DURING VEHICLE INSPECTION I WAS TOLD MY FRAME HAD RUST. I CHECKED WITH TOYOTA AND THEY HAD A RECALL FOR MODEL YEARS UP TO 2004 FOR FRAME RUST ISSUES. THIS YEAR WHILE MY TRUCK WAS ON THE LIFT FOR MECHANICAL WORK, THE MECHANIC INFORMED ME THAT THE RUST ON MY FRAME WAS GETTING SERIOUS AND THERE WERE SOME POSSIBLE WEAK AREA'S. AGAIN I CONTACTED TOYOTA AND THEY SAID THEY HAVE HAD NO ISSUES NOR SEEN ANY RUST ON THE TRUCK FRAME. I ASKED IF THERE WAS A POSSIBILITY OF A SPLIT YEAR AND THE DEALERSHIP TOLD ME THAT 2005'S HAD A NEW DESIGN AND FRAME MANUFACTURER. I FILED A CASE WITH TOYOTA CASE #[XXX] JUST SO I WOULD BE ON RECORD. I HAVE ALSO SEEN MANY COMPLAINTS ON THE INTERNET WHEN I DID A SEARCH FOR FRAME RUST 2005 TOYOTA TACOMA. TOYOTA WILL DO NOTHING TO HELP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

REPLACEMENT OF SPIRAL CABLE ASSEMBLY, DIAGNOSIS, PAPER WORK TO TAKE 4 HOURS TO SIX HOURS TO COMPLETE. THIS WAS QUOTED TO ME BY YOUR TOYOTA DEALERSHIP ( PRECISION TOYOTA) IN THE TUCSON AREA. YET THE NOTIFICATION STATES ONLY 30 MINUTES IS NEEDED TO REPLACE. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE, THE TIRE WOULD DEFLATE. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE WHEEL DEVELOPED A CRACK AND IT NEEDED TO BE REPAIRED. THE CONTACT WAS ALSO INFORMED THAT THEY WOULD NOT COVER THE REPAIR COSTS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 33,000. UPDATED 08/08/12*LJ UPDATED 08/08/12

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT NOTICED THAT THE ENTIRE FRAME WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIANS STATED THE CORROSION WAS SUPERFICIAL AND WOULD NOT CAUSE A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. UPDATED 08/07/12*LJ

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT AN ABNORMAL TICKING NOSE WAS HEARD FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE U-JOINT NEEDED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 74,500 AND THE CURRENT MILEAGE WAS 76,000.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT A LOUD NOISE WAS EXHIBITED FROM UNDER THE HOOD WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE FAILURE WAS LOCATED AT THE TRANSMISSION BELL HOUSE, WHICH WAS MADE OF ALUMINUM AND CAUSING THE ABNORMAL NOISE. THE DEALER REPLACED THE TRANSMISSION BELL HOUSE SEVERAL TIMES UNDER THE WARRANTY BUT THE FAILURE WAS NOT CORRECTED. THE BELL HOUSE CONTINUED TO EXHIBIT THE LOUD NOISE. THE CONTACT ALSO STATED THAT THE SUB FRAME WAS CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 35,000 AND THE CURRENT MILEAGE WAS 92,000.

SUDDEN ONSET OF STEERING INTERMEDIATE SHAFT U-JOINT SEIZING MAKING STEERING DIFFICULT. ALSO LOST RETURN-TO-CENTER OF STEERING. THIS COULD POSE A SERIOUS RISK OF OVER-STEERING INTO ONCOMING TRAFFIC WHEN MAKING A LEFT HAND TURN AT A TEE INTERSECTION. THE UNPROTECTED U-JOINT IS EXPOSED TO STRIKING OF ROAD DEBRIS AND SALT SPRAY. THE U-JOINT DOES NOT HAVE GREASE FITTINGS OR ANY OBVIOUS MEANS OF LUBRICATION. INTERNET RESEARCH SUGGESTS THIS IS A VERY COMMON DEFECT FOR TOYOTA TACOMAS WITH APPROXIMATELY 75K OR MORE MILES STARTING WITH MODEL YEARS 2005 AND NEWER. *TR

RUST HAS DEVELOPED ON FRAME OF MY 2005 TOYOTA TACOMA. DESPITE PRIOR RUST ISSUES WITH THIS MODEL TOYOTA HAS NO PROGRAM IN EFFECT TO LOOK AT THE TRUCK. *TR

SRS LITE CAME ON AND NEVER HAS GONE OUT, FOR THE DRIVERSIDE AIR BAG. AFTER INVESTAGATING THIS PROBLEM, IT SEEMS THAT HUNDREDS OF THESE TOYOTAS HAVE THE SAME PROBLEM. AT THE DEARSHIP, DIAGNOSIS, IS ABOUT $115.00 TO PULL THE CODE, AND THEN RUN UP TO ABOUT $500.00 FOR REPAIRS. THE SPIRAL CABLE IN THE STEERING COLOMNE HAS A SHORT LIFE. 35K MILE ON SOME AND UP IN MILES AFTER THAT FOR OTHERS. SRS SYSTEMS SUCH AS THIS I UNDERSTAND IS LIFETIME WARRENTY. THAT MAY BE CUT SHORT IF THE AIR BAG DOES NOT INFLATE IF NEEDED. TOYOTA SHOULD BE RESPONABLE, AND FIX THIS PROBLEM, AS THE COST OF REPAIR IS OUT OF REACH FOR MANY PEOPLE. USING INFERIOR WIRES, THAT IS NOT THE CONSUMERS FAULT. I BOUGHT THIS TOYOTA NEW, THINKING THAT TOYOTA WILL LAST A LONG TIME, IT HAS BEEN SERVICED AT THE DEALERSHIP REGULAR, AND ON TIME. PLEASE HELP IN THIS MATTER, AS IT AFFECTS MANY OWNERS AND LIFE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT

AIR BAGS LIGHT CAME ON FOR NO REASON. *TT

2005 TOYOTA TACOMA. CONSUMER STATES LOUD NOISE COMING FROM ENGINE AND THAT THE ENGINE WAS OFF KILTER *TGW THE CONSUMER STATED WHEN HE OPENED THE HOOD, HE DISCOVERED THE ENGINE WAS DRASTICALLY LEANING TOWARDS THE DRIVER'S SIDE OF THE VEHICLE. THE NOISE WAS THE ENGINE'S COOLING FAN HITTING THE SHROUD MEANT TO PROTECT IT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER. AN INSPECTION REVEALED THE MOTOR MOUNT WHICH WAS ATTACHED TO THE FRAME OF THE VEHICLE BROKEN FREE AND COLLAPSED INTO THE FRAME ITSELF. THERE WAS ALSO EXTENSIVE RUST ON THE FRAME ON THE REMAINDER OF THE FRAME. A TOYOTA SPECIALIST TOOK PICTURES OF THE FAILED MOTOR MOUNT AND RUSTED FRAME. THE CONSUMER STATED TOYOTA HAS A LONG HISTORY OF FRAME RUST ISSUES, AS A RECALL WAS ISSUED FOR PREVIOUS MODELS. *JB

2005 TOYOTA TACOMA SR5 DBL CAB, 6 CYL, 4.0 ENG. 50K MILES, 4 WHEEL DRIVE, MANUAL TRANSMISSION: DRIVER SIDE AIRBAG LIGHT TURNED ON AND STAYS ON. I HAVE SEARCHED THE INTERNET FOR INFO. ON IT AND HAVE FOUND A LOT OF PEOPLE HAVE BEEN HAVING THIS PROBLEM. GOING BY THE INFO. FOUND ON LINE, FROM GOOGLE TO NEWSGROUPS IT SEEMS THAT THE SPIRAL CABLE IN THE STEERING COLUMN IS FAILING AT A ALARMING RATE. THE TOYOTA DEALERS ARE JUST CHARGING FOR DIAGNOSTICS AND NOT ADMITTING A PRODUCT DEFECT. I AM TAKING MINE TO THE DEALER AND IS $117.00 JUST TO DIAGNOSE IT.. AND I KNOW THIS TAKES THEM 10 MIN OR LESS TO HOOK IT UP TO THE COMPUTER AND GET THE ERROR CODES PRINTED. THIS DEALERS ARE CHARGING $90 TO $120 JUST FOR THE DIAGNOSTIC.. AND IT SEEMS THE REPAIRS CAN GO FROM $300 UP TO $800.00. SRS (AIR BAG) ISSUES SHOULD BE COVERED FOR THE LIFE OF A VEHICLE OR SRS (AIR BAGS) SHOULD BE OPTIONAL! IF IT IS A REQUIRED PART LIKE A SEAT BELT TOYOTA SHOULD COVER THE PART FREE. PLEASE TAKE TIME TO REVIEW MY COMPLIANT AND THOSE OF OTHERS. *TR

MY 2005 TOYOTA TACOMA QUAD CAB SR5 HAS AN ISSUE WITH THE TRANSMISSION. AT A COMPLETE STOP WITH MY FOOT FIRMLY ON THE BRAKE MY TRUCK LUNGES FORWARD IN A VERY DANGEROUS ABRUPT MANNER AS THOUGH SOMEONE REAR ENDED ME. THIS HAPPENS OFTEN AT STOP LIGHTS A FEW SECONDS AFTER I COME TO A COMPLETE STOP. A SECOND ISSUE IS THAT MY PAINT IS CRACKING AND PEELING ON MY ROOF AND MY CLEAR COAT IS NOTICEABLY BAD ON THE EDGES OF MY HOOD AND DOORS. MY TRUCK IS NOT OF APPROPRIATE AGE OR WEATHER CONDITIONS TO HAVE THESE TYPES OF PAINT PROBLEMS. TOYOTA REFUSES TO INVESTIGATE OR PAY FOR MY ISSUES AND JUST RECOMMENDS THAT I GO PAY A DEALER TO FIX IT OUT OF MY POCKET. I SEE SEVERAL OTHERS WITH THE EXACT SAME PROBLEMS ON MANY BLOGS, CLASS ACTION ANYONE? *TR

I OWN A 2005 TOYOTA TACOMA, 4X4, 4-CYLINDER, 5-SPEED MANUAL, PURCHASED NEW. IT HAS 92,000 MILES ON IT AND I HAVE FILED TWO COMPLAINTS, GOING BACK THREE YEARS, WITH MY DEALER AND WITH TOYOTA HEADQUARTERS REGARDING EXCESSIVE RUST ON THE FRAME OF MY VEHICLE. BOTH HAVE TOLD ME IT IS ACCEPTABLE FOR THE FRAME TO BE RUSTING. I DISAGREE. A VEHICLE THAT SHOULD EASILY LAST OVER 200,000 MILES SHOULD BE BUILT ON QUALITY FRAMES. AT SOME POINT IT WILL CAUSE ISSUES AND COULD BE A DANGER IF JOINTS START RUSTING. I HAVE SEARCHED ONLINE AND SEEN OTHER SIMILAR TRUCKS AND ALL OWNERS COMPLAIN OF THIS ISSUE. THE FRAME AND BRACKETS ARE ALL RUSTING EXCESSIVELY, MUCH MORE EXCESSIVELY THAN ANY OTHER CAR I HAVE EVER OWNED. THIS STARTED OCCURRING SHORTLY AFTER OWNING THE CAR AND IT HAS GOTTEN TREMENDOUSLY WORSE. THERE HAS NEVER BEEN FRAME DAMAGE TO THE TRUCK AND THE TRUCK IS IN EXCEPTIONAL CONDITION, HAS BEEN WASHED WITH REGULARITY AND EVEN GARAGED. I AM SUBMITTING THIS COMPLAIN WITH THE HOPE OTHERS ARE ALSO COMPLAINING. I KNOW TOYOTA DID A RECALL OF THEIR PREVIOUS MODELS DUE TO THIS ISSUE AND NOTHING IN THEIR PRODUCTION HAS IMPROVED THE WAY THESE FRAMES ARE MADE AND I BELIEVE A RECALL SHOULD BE CONSIDERED TO REMEDY THESE MODEL YEAR ISSUES TOO. *TR

2005 TOYOTA TACOMA. CONSUMER STATES UNINTENDED ACCELERATION *TGW THE CONSUMER STATED APPROXIMATELY 2 1/2 YEARS AGO, HE EXPERIENCED HIS FIRST SUDDEN ACCELERATION PROBLEM. THE CONSUMER STATED AS HE HAD HIS RIGHT FOOT ON THE BRAKE, THE VEHICLE FELT AS THOUGH IT WANTED TO CONTINUE TO MOVE FORWARD. WHEN THE CONSUMER ARRIVED HOME, HE CHECKED THE FLOOR MAT, BUT IT WAS FOUND TO BE PROPERLY SECURED. THE CONSUMER RECEIVED A SAFETY RECALL NOTICE REGARDING SUDDEN ACCELERATION ISSUES. WHEN HE CONTACTED THE DEALER, HE WAS INFORMED THE PARTS WERE NOT AVAILABLE AND HE WOULD RECEIVE A CALL WHEN THEY ARRIVED. THE SECOND OCCURRENCE HAPPENED WHILE DRIVING 10 MPH. THE CONSUMER HAD HIS FOOT ON THE BRAKE PEDAL, WHEN THE ENGINE SUDDENLY BEGIN TO REVVED UP WITH THE REAR WHEELS SPINNING AND HOPPING WHILE SLOWLY MOVING FORWARD. THE CONSUMER TURNED THE IGNITION IN THE OVER DRIVE POSITION AND THERE WAS SOME DIFFICULTY TRYING TO PLACE THE SHIFTER IN THE PARK POSITION. THE CONSUMER FINALLY TOOK THE VEHICLE TO THE DEALER TO HAVE THE RECALL PERFORMED. HOWEVER, TWO MONTHS LATER,WHILE SLOWING DOWN, WITH HIS FOOT ON THE BRAKE, THE ENGINE BEGAN TO REV AGAIN. THE CONSUMER EXPERIENCED UNWANTED ACCELERATION SEVERAL MORE TIMES. *JB

SPIRAL CABLE, AIR BAG, STEERING COLUMN, CHARGED $609.82 BY DEALER TO REPAIR, WAS IN OTHER REPAIR SHOP THIS WEEK, HEARD ANOTHER CUTOMER COMPLAIN OF SAME PROBLEM, ALSO HAD 2005 TOYOTA TACOMA. EVERY SINGLE LIGHT CAME ON, ON THE DASH, SCARED THE LIVING DAYLIGHTS OUT OF ME. MANUAL SAYS TAKE IMMEDIATELY TO DEALER. WHAT A RIP OFF. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE DEALER ADVISED THE CONTACT THAT THE SPIRAL CABLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, DID NOT OFFER ANY ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 95,261. UPDATED 10/27/11*LJ

MY AIRBAG LIGHT CAME ON WHEN DRIVING ONE DAY. AS I DID RESEARCH, IT SEEMS THAT THE SPIRAL CABLE IN THE STEERING WHEEL IN THE NEWER TACOMAS ARE FAULTY. THERE ARE ENTIRELY TOO MANY OF THESE THINGS GOING BAD. A SIMPLE SEARCH ON GOOGLE FOR TACOMA SPIRAL CABLE BRINGS UP SCORES OF PEOPLE WITH THESE THINGS GOING BAD, SOME AT 30-40 THOUSAND MILES! IT IS REDICULOUS THAT TOYOTA HAS HAD THIS ONGOING PROBLEM AND DONE NOTHING! AFTER ALL THE CRAP ABOUT UNINTENDED ACCELERATION AND FLOORMATS I WOULD EXPECT THEM TO ADDRESS THIS ISSUE, BUT APPARENTLY SAFETY SYSTEMS ARE'T THAT IMPORTANT TO THEM. NOT ONLY DO THEY HAVE CHRONIC FAILURES, BUT THE DEALERSHIPS ARE MORE THAN HAPPY TO CHARGE $100 TO DIAGNOSE THE PROBLEM, EVEN THOUGH ALMOST EVERY CASE IS THE SPIRAL CABLE. THE TOTAL BILL COMES TO ANYWHERE FROM 4-500 DOLLARS DEPENDING ON THE DEALERSHIP, FOR A REPAIR THAT SHOULDN'T HAPPEN IN THE FIRST PLACE. NORMAL WEAR AND TEAR IS ONE THING, BUT SINCE WHEN IS THERE NORMAL WEAR AND TEAR ON AIR BAGS? *TT

2005 PRERUNNER SR5 HAD GRINDING SOUND FROM RIGHT FRONT AT ABOUT 40MPH WHEN TURNING LEFT. NO SOUND WHEN TURNING RIGHT. DEALER CHECKED AND DETERMINED LEFT FRONT WHEEL BEARING WAS BAD. REPLACED LEFT FRONT WHEEL BEARING ($516.32). WHEN LEAVING DEALER LOT AFTER PICKING UP THE TRUCK I NOTICED THE SOUND STILL CAME FROM THE RIGHT FRONT WHEEL . BROUGHT BACK TO DEALER WHO CHECKED AGAIN AND DETERMINED RIGHT FRONT WHEEL BEARING WAS BAD. ALSO SAID LEFT REAR MAY BE GOING BAD. COST TO REPLACE RIGHT FRONT WHEEL BEARING $337.01 (DEALER DIDN'T CHARGE LABOR THIS TIME). ABOUT 1 YEAR AFTER BEARINGS REPLACED THE GRINDING SOUND HAS RETURNED. VEHICLE NOW HAS ABOUT 107K MILES. RELUCTANT TO RETURN TO DEALER AND PAY ANOTHER $800-$1000 TO REPAIR WHEEL BEARINGS THAT APPEAR TO BE EITHER POOR QUALITY OR INSTALLED INCORRECTLY. DEALER CLAIMS REPLACING WHEEL BEARINGS AT 80K MILES IS NOT ABNORMAL. *TR

TRUCK BEGAN MAKING LOUD NOISES IN ENGINE COMPARTMENT. TRUCK WAS DIAGNOSED AS HAVING BAD MOTOR MOUNTS. AT TIME OF REPAIR, MOTOR MOUNT ASSEMBLIES WERE NOTED BY MECHANIC TO HAVE BROKEN OFF THE FRAME DUE TO BAD/WEAKENED WELDS. MOTOR IS RUBBING ON FAN/RADIATOR SHROUD. OWNER HAS DONE INDEPENDENT RESEARCH, INCLUDING COMPLAINTS FILED ON THIS SITE, AND HAS NOTED THAT THIS HAS BEEN AN ON-GOING ISSUE WITH 2005 TACOMAS. *TR

I HAVE A 2005 TOYOTA TACOMA PRERUNNER 4X4 WITH ONLY 83,000 MILES. THERE IS RECURRING ISSUES WITH THE FRONT WHEEL BEARINGS GOING OUT. FRONT LEFT HAS BEEN REPLACED 3 YEARS AGO, THEN FRONT LEFT STUB AXLE WAS REPLACED LESS THAN A YEAR LATER UNDER WARRANTY BY TOYOTA. THE RIGHT FRONT WHEEL BEARING ALSO WENT OUT 2 YEARS AGO AND WERE REPLACED AND NOW THE LEFT SIDE IS GOING OUT AGAIN. *KB

MY AIR BAG LIGHT WENT ON FOR NO REASON - NO SERVICE OR IMPACT TO TRIGGER THE SENSOR. I PAID A TOYOTA DEALER $112 FOR A DIAGNOSTIC CHECK AND THEY FOUND CODES B1660 & B1801, REQUIRING ME TO REPLACE THE SPIRAL CABLE. THE COST WAS ABOUT $570 BEFORE TAX. I DID NOT HAVE THE MONEY TO DO THE REPAIR, SO THE AIR BAG LIGHT IS STILL ON. THE TOYOTA REPRESENTATIVE TOLD ME THAT THE AIR BAG WOULD NOT FUNCTION IN A CRASH IF THIS WAS NOT REPAIRED. THIS IS A DEFECTIVE PART AND SHOULD BE REPLACED BY TOYOTA WHETHER I AM UNDER WARRANTY OR NOT BECAUSE IT IS A SAFETY FEATURE OF THE VEHICLE, AND OTHER MECHANICS WILL NOT WORK ON AIR BAGS. *KB

DRIVER'S SIDE VISOR BRACKET BREAKS AND VISOR WILL NOT STAY UP OUT OF THE WAY AND BLOCKS DRIVER'S VIEW. *TR