2003 Mini Cooper S

Defect. BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.

Risk. If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.

Remedy. MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.

Defect. ON CERTAIN VEHICLES, THE LOWER SCREW CONNECTION OF THE REAR STRUTS TO THE CHASSIS MAY FAIL. THE HEAD (TOP) OF THE SCREW SECURING THIS CONNECTION MAY BREAK. THE REMAINING PORTION OF THE SCREW WILL STILL HOLD THE STRUT IN PLACE.

Risk. IF LEFT UNATTENDED OVER A PERIOD OF TIME, AND DEPENDING ON DRIVING CONDITIONS, THE REMAINING PORTION OF THE SCREW MAY BREAK. IF IT BROKE, THE CHASSIS WOULD LEAN DIRECTLY ON THE TIRE DIMINISHING THE DRIVER'S ABILITY TO CONTROL THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL REPLACE THE LOWER SCREW CONNECTION OF THE REAR STRUTS. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.

The contact owns a 2003 Mini Cooper S equipped with Falken Tires, Tire Line: Sincera SN250 A/S, Tire Size: 235/45R17, DOT Number: FMHR3120. The contact stated that while washing the vehicle, he noticed that a bubble had developed on the front driver’s side tire. The contact was concerned for his safety while driving the vehicle. The contact stated that he rotated the tire to the rear driver’s side but was concerned and uncertain if the bubble might cause a risk to his safety while driving. The vehicle had not yet been diagnosed. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 101,000.

I WAS STARTING MY VEHICLE AND IT MADE A BAD KNOCKING NOISE THEN IT WAS LIKE CRUNCHING NOISE SO I STOPPED TURN IT OFF AND WAITED FOR A WHILE WENT BACK TO THE CAR STILL MAKING A STRANGE NOISE BUT ONCE I PUT IT IN THE DRIVE IT STOPPED MAKING NOISE DROVE DOWN THE ROAD A BIT AND TALKING ABOUT APPARENTLY SLIPS OFF OF THE CAR SO IT JUST PULLS OVER INSIDE ALL THE ALL THE WEARING LIGHTS CAME ON SO PULLED OVER APPARENTLY THIS HAPPENS QUITE OFTEN BUT THE HARMONIC BALANCER SEPARATED AND WITH SPINNING AGAINST ITSELF AND KNOCKED THE PIECES OFF OF IT AND THROUGH THE SERPENTINE BELT SO THAT NEEDS TO REPLACE NOW THAT SHOULD NOT HAPPEN IT'S ONE PIECE IS THIS ONE PIECE THIS NEEDS TO BE RECALLED FOR THESE WHATEVER CARS HAD THESE HARMONIC BALANCERS IS DANGEROUS AND IT COULD BLOW YOUR CAR UP THANK YOU

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT STATED THAT ON THREE OCCASIONS, THE MAT OCCUPANCY SENSOR ON THE FRONT PASSENGER'S SEAT WAS REPLACED DUE TO THE WARNING LIGHT BEING ILLUMINATED. THE VEHICLE WAS TAKEN TO MINI OF BIRMINGHAM LOCATED AT 2001 TOM WILLIAMS WAY, BIRMINGHAM, AL 35210, 205-267-4505. THE CONTACT WAS INFORMED THAT THE MAT SENSOR NEEDED TO BE REPLACED AT A COST OF $1,200. THE CONTACT WAS ALSO INFORMED THAT THE PART MAY ALSO BE AVAILABLE AT THE LOCAL JUNKYARD. THE MAT SENSOR WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE CONTACT WAS INFORMED THAT THE SEAT SHOULD BE REPLACED WHICH WAS STILL PENDING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.

WE KNOW OF TWICE THAT OUR CAR'S POWER STEERING PUMP FAILED WHILE IN MOTION. AFTER BMW WAS FINALLY FORCED INTO A RECALL FOR THE POWER STEERING PUMP FAILURE AND WE RECEIVED A NOTIFICATION, WE TOOK OUR CAR TO CENTURY BMW IN GREENVILLE, SC. THE SERVICE DEPARTMENT CHECKED OUR WORK REGARDING REPLACEMENT PUMP, FAN, ETC. AND DEEMED IT 100% SATISFACTORY. WE SUBMITTED THE PAPERWORK AND INVOICE FOR THE REPAIR AND WAITED (REQUESTED . AFTER 16 WEEKS AND NO REIMBURSEMENT OR NOTIFICATION, WE CALLED AND WAS INFORMED BY THE SERVICE DEPARTMENT MANAGER THAT BMW WOULDN'T PAY US ANYTHING BECAUSE WE DIDN'T USE OEM PARTS. WHY WOULD WE KEEP REPLACING THE PUMP (THIS WAS THE 3RD PUMP THAT WE KNOW OF) WITH A DEFECTIVE ONE (BY ZF) THAT KEPT QUITTING? WE REPLACED IT WITH DORMAN (WELL-KNOWN MANUFACTURER OF QUALITY PARTS) WHICH HAD A LIFE-TIME WARRANTY (LIFE-TIME!) AND WAS MUCH CHEAPER. THE SD MANAGER EVEN SAID THAT SINCE HE'D SEEN SO MANY REPAIRS USING THAT BRAND OF POWER STEERING PUMP HE HAD RESEARCHED THEM AND FOUND NOTHING WRONG WITH THEM. BUT BMW DECIDED THEY WOULDN'T PAY FOR THIS. THERE WAS NOTHING IN THE RECALL LETTER THAT SAID OEM HAD TO BE USED OR THEY WOULDN'T REIMBURSE FOR REPAIRS. I BELIEVE BMW SAW SO MANY DORMAN PUMPS USED THEY KNEW THEY COULD SAVE A LOT OF MONEY BY REFUSING TO PAY. WE FILED A COMPLAINT WITH THE SC DEPT. OF CONSUMER AFFAIRS BUT BMW WOULDN'T ANSWER THEM SO THEY JUST DROPPED IT, LETTING BMW GET BY WITH THIS. WE WERE ONLY REQUESTING $721.04 WHICH IS LESS THAN HALF OF WHAT A REPAI

POWER STEERING PUMP FAILED WHILE DRIVING

OCCASIONALLY THE STEERING OVER MY MINI COOPER S IS BECOMING VERY HARD. IT SEEMS LIKE THE POWER STEERING IS FAILING. THE CAR THEN CAN ONLY BE STEERED WITH A LOT OF DIFFICULTY. I CAN NO LONGER RISK TO HAVE MY DAUGHTER OR WIFE DRIVE THIS CAR. I CHECKED THE STEERING FLUID AND IT IS AT OPTIMAL LEVELS. IT USUALLY HAPPENS AT LOWER SPEED, BUT I HAVE NOT DRIVEN IT ON THE FREEWAY SINCE THIS ISSUE STARTED TO APPEAR.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT NOTICED FUEL LEAKING UNDERNEATH THE VEHICLE. THE CONTACT CHECKED UNDER THE HOOD AND DISCOVERED THAT THE FUEL FILTER HAD A LEAK. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

AFTER BATTERY WENT DEAD, REPLACED WITH NEW BATTERY AND SHORTLY AFTER AIR BAG LIGHT ILLUMINATED. HAD INDEPENDENT SHOP CLEAR CODE IN 2015 INSPECTED HARNESS FOUND NOTHING OUT OF ORDINARY. 3 DAYS LATER AIR BAG LIGHT RETURNED. NOW IN FEBRUARY 2018 HAD MINI OF TOWSON DIAGNOSE AIR BAG LIGHT THINKING THE DEALERSHIP CAN RESET AIR BAG LIGHT PROPERLY. DEALERSHIP RECOMMENDED UPGRADING WIRING HARNESS UNDER SEAT FOR 525 DOLLARS. I HAVE BEEN ON MULTIPLE FORUMS AND THIS AIR BAG LIGHT IS A COMMON PROBLEM FOR 02-03 MINIS, INCLUDING 05-06, AND 12-15 YEAR MINIS. MY CONCERN IS THAT MINI KNOWS THIS IS A DEFECTIVE PART FROM THE MANUFACTURER BUT REFUSES TO STAND BY THEIR PRODUCT EVEN WHEN IT COULD AFFECT THE SAFETY OF THE PURCHASER OF ITS VEHICLES. IN THE EVENT NHTSA RECEIVES ENOUGH COMPLAINTS TO FORCE MINI TO ISSUE A RECALL FOR THIS ISSUE, I WOULD LIKE TO BE INCLUDED AS ANOTHER DISSATISFIED CONSUMER. THANK YOU FOR YOUR TIME, GARRETT

I WAS APPROACHING A CORNER ON A BACK ROAD AND HALF WAY THROUGH THE POWER STEERING FAILED WHICH CAUSED THE CAR TO GO OFF THE ROAD ROLLING TWO AND A HALF TIMES LANDING ON THE ROOF.

THE MANUAL TAILGATE RELEASE CABLE WAS NOT FITTED IN THIS AND OTHER EARLY PRODUCTION MINI COOPER S CARS, THOUGH THE OWNER'S MANUAL INDICATES THAT THIS SAFETY FEATURE IS PART OF THE DESIGN. THE MANUAL TAILGATE RELEASE CABLE ALLOWS ACCESS TO THE BATTERY COMPARTMENT, WHICH IS IN THE TRUNK OF THE VEHICLE, WHEN THERE IS AN ELECTRICAL MALFUNCTION SUCH AS A BATTERY FAILURE. WITHOUT THE MANUAL RELEASE CABLE, THE BATTERY IS INACCESSIBLE IN THE EVENT OF A FAILED BATTERY OR OTHER ELECTRICAL MALFUNCTION. THE BATTERY IN MY CAR FAILED AND LEFT ME STRANDED ON THE SIDE OF THE HIGHWAY WITH NO CONVENIENT ACCESS TO REMOVE THE BATTERY. FURTHER, THE ABSENCE OF THIS MANUAL RELEASE CABLE MEANS THAT THE TAILGATE COULD NOT BE USED AS AN EGRESS FOR VEHICLE OCCUPANTS IN THE EVENT OF AN EMERGENCY.

POWER STEERING WENT OUT WITHOUT WARNING, CAUSING LOSS OF CONTROL WHILE VEHICLE WAS IN MOTION; MINI USA ADVISED IT WAS STILL DRIVEABLE, BUT TO BE CAUTIOUS DUE TO LACK OF CONTROL/POWER STEERING; WHEN PARKED, SMOKE BEGAN TO PLUME FROM UNDER HOOD WHERE A FIRE WAS NOTICED IN BACK OF ENGINE. CALLED MINI USA BACK AND THEY ADVISED US TO NOT DRIVE VEHICLE, AS IT WAS A SAFETY HAZARD. CONTACTED MINI TO SET UP RECALLED PART (HYDRAULIC POWER STEERING), BUT THEY WERE NOT WILLING TO HAVE CAR TOWED TO DEALER (120 MILES FROM MY RESIDENCE).

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 05/18/16*LJ UPDATED 06/14/16.*JB

TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHILE DRIVING 40 MPH AND ATTEMPTING TO MAKE A TURN, THE POWER STEERING FAILED. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED CONTUSIONS TO THE FACE AND LOST A TOOTH. THE OCCUPANTS OF THE OTHER VEHICLE SUSTAINED UNKNOWN INJURIES. MEDICAL ATTENTION WAS NOT REQUIRED. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 213,000.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING BECAME VERY DIFFICULT TO MANEUVER. AFTER TURNING OFF AND RESTARTING THE VEHICLE 30 MINUTES LATER, THE POWER STEERING RETURNED TO NORMAL, BUT THEN FAILED AGAIN. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRO-HYDRAULIC POWER STEERING FAILED AND NEEDED TO BE REPLACED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE DEALER WANTED TO CHARGE FOR THE REPAIR BECAUSE OF THE MILEAGE ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 181,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHILE OPERATING THE VEHICLE AT LOW SPEEDS, THE STEERING WHEEL REQUIRED EXCESSIVE FORCE IN ORDER TO TURN. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE POWER STEERING FLUID LEAKED FROM THE POWER STEERING FLUID RESERVOIR. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 136,000.

SUDDENLY OUT OF NOWHERE AS SOON AS I STARTED THE CAR TO BACK OUT OF MY DRIVEWAY & GO TO WORK THE STEERING WAS COMPLETELY LOCKED UP, ONLY HAVING APPROXIMATELY AN INCH TO INCH AND A HALF OF MOBILITY IN EITHER DIRECTION. I THEN TURNED THE CAR OFF, LET IT SIT OFF FOR ABOUT 5 MINS THEN RE-STARTED IT AND THE STEERING WAS STILL THE SAME WAY.

POWER STEERING PUMP FAILED AT 69,000 MILES. PUMP AND FAN WERE REPLACED UNDER WARRANTY, BUT DEALER REQUIRED ADDITIONAL WORK TO BE PERFORMED TO KEEP EXTENDED WARRANTY IN FORCE. THE WORK INCLUDED REPLACEMENT OF ALL POWER STEERING HOSES AT A COST OF OVER $600.00

STEERING FLUID CONTINUOUSLY LEAKS - REPLACE HYDRAULIC HOSE TWICE - KNOWN DEFECT - MINI REFUSED TO FIX FOR FREE ENGINE COOLING - FAN RUNS AFTER SHUTOFF CONTINUOUSLY - KNOWN DEFECT - MINI REFUSED TO FIX FOR FREE ELECTRICAL - DOORS, WINDOWS, SUNROOF FIRE OFF ON THEIR OWN WHILE CAR IS MOVING AND WHEN IS PARKED. WILL DO THIS AT HIGHWAY SPEED OR WHEN SITTING OUTSIDE (RAIN OR SHINE) - CAR UNLOCKS ITSELF AND WINDOWS ALL OPEN UP -KNOWN DEFECT - KIND OF DISTRACTING AT HIGHWAY SPEED -MINI REFUSED TO FIX FOR FREE. DEALERS WILL NOT FIX THESE ISSUES UNLESS YOU MAKE THEM RECALL VEHICLES WITH MULTIPLE SMALL PROBLEMS ( NOT JUST ONE BIG PROBLEM) - THIS MODEL HAS 73 TSBS THAT DEALERS CHARGE YOU TO FIX EVEN THOUGH THE PROBLEMS ARE KNOWN AND DANGEROUS ISSUES. IN MY MIND, MANY SMALL PROBLEMS CAN BE MORE DANGEROUS THAN A FEW BIG ONES - STEERING, DOOR LOCKS, COOLING - NOT GOOD. THIS IS AN OLD CAR BUT THESE PROBLEMS ARE OLD TOO - KNOWN TSBS SHOULD NOT BE SUBJECT TO WARRANTY TIME FRAMES, THEY ARE STILL DANGEROUS AFTER THE WARRANTY EXPIRES. WHEN THESE CARS ARE ROUTINELY SERVICED, THESE KNOWN/DANGEROUS ISSUES NEED TO BE CORRECTED OR THE CARS SHOULD BE TAKEN OFF THE ROAD. I USED THE DATE OF THE LAST INCIDENT, NOT THE FIRST ONE. THANK YOU. *TR