2024 Mazda CX-90 complaints

I am submitting a safety complaint regarding my 2024 Mazda CX-90 (VIN: [XXX] ). My vehicle previously received the steering recall repair related to increased steering effort/power steering concerns. Despite the recall remedy being completed, I continue to experience intermittent abnormal steering behavior consistent with the ongoing NHTSA investigation into post-recall “sticky steering” concerns on repaired CX-90 vehicles. Symptoms include intermittent steering resistance, a notchy or sticky feeling during small steering corrections, and inconsistent steering return-to-center behavior. The issue is most noticeable during highway driving and long curves where small steering inputs are required. The steering occasionally feels as though it hesitates or briefly resists movement before correcting. I brought the vehicle to the dealership, but the concern was dismissed and/or they were unable to duplicate the issue. No warning lights or fault codes were present at the time. However, the steering behavior remains concerning from a safety standpoint because it affects normal steering feel and driver confidence during operation. I understand NHTSA is currently investigating whether the original recall remedy fully corrected the steering defect in affected Mazda CX-90 vehicles. I am submitting this complaint because my vehicle appears to exhibit symptoms consistent with those reports after recall completion INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.

Low voltage battery system Safety is at risk because vehicle could loose power and be forced into a turtle mode cause injury from sudden slow down Yes there were warning lights This is a continued problem identified but other owners and consistently replaced

Steering wheel became stuck when making a long left turn while driving on the freeway. The turn lasted approximately 30 seconds. Around 3-4 seconds into the turn, the steering wheel suddenly locked up for approximately 1-2 seconds. Eventually the steering wheel was released resulting in a sudden jerk, leading to the car veering to the right lane. A correction was made using the steering wheel to maintain center lane. Once again the steering wheel got stuck, resulting in the same jerk behavior. This occurred three times in the 30-second turn. I have not attempted this route since this incident. Prior to this incident, the front end suspension made a grinding noise when turning the steering wheel left (e.g., backing up into the garage). There is minor vibration on the steering wheel but not too noticeable due to the low speeds. A recall was previously performed back in 2025 to correct the grinding suspension. However, it returned several months after along with the minor steering wheel issue. I plan to report this at the next scheduled maintenance interval.

The vehicle started to hydroplane in rain on the highway and the lane keeping assist aggressively tried to push me back, which ended up causing us to hydroplane more and causing the vehicle to flip around backwards and we ended up sliding completely off the highway into a ditch totaling the vehicle.

The steering wheel on our Mazda CX-90 has been getting stuck when turning the vehicle. This failure occurs when there is a slight turn in the wheel (approximately 25-45 degrees). The steering wheel gets stuck and the driver has to use force to "break" it loose. This action causes the vehicle to overcorrect into either the lane next to vehicle or into oncoming traffic. I have done research and Mazda has acknowledged that this is a known issue and even issued a recall for our 2024 Mazda CX-90. However, Mazda has also more recently come forward and said that their corrective action does not always correct the recalled issue. We recently had a near miss into oncoming traffic while trying to "unstick" our steering wheel. We have called and email Mazda and they have stated there is nothing new they can do to correct this issue.

When I’m driving, the steering wheel suddenly gets stuck and pulls against me with force. This is extremely dangerous, especially on the freeway or when going over a bridge — the car pulls in the opposite direction of where I’m steering. The brakes also start squealing very loudly. It feels like the steering wheel is about to lock up while I’m driving, and I’ve had to physically fight it to keep control of the car. This is a serious safety risk, and it feels like the vehicle could lose steering at any moment.

Vehicle steering issues. Steering wheel binds, jerks, increased effort while turning.

The contact leases a 2024 Mazda CX-90. The contact stated that on two separate occasions while stopped and the ON/OFF feature was activated, the vehicle shut off. The contact stated that several warning messages including the "Engine Malfunction ", "Charging System Malfunction", and "Eye Active Sense System Malfunction" appeared on the instrument panel. The contact then stated that she had received a recall notice for NHTSA Campaign Number: 24V816000( Electrical System, Power Train). The vehicle was taken to the dealer and the vehicle was serviced. The contact stated that while driving at a 20 MPH, the vehicle shut off as the previous warning messages appeared on the instrument panel. The contact managed to restart the vehicle; however, an audible beeping sound persisted. Due to the failure, the contact pulled over and had the vehicle towed to the dealer. The dealer kept the vehicle for nearly two weeks where they replaced the mild hybrid battery. Despite the latest repair, the contact expressed concern about the vehicle being that the failure occurred while her two young children were in the vehicle. The manufacturer was notified of the failure in a letter and requested to have them replace the vehicle under her lease. The manufacturer denied the contact's request and closed the case. The failure mileage was approximately 31,000.

There is a recurrent steering wheel issue. The issue was first addressed during the national recall campaign 6524A / NHTSA 24V-022 where it received the recall repair. The exact same dangerous issue has returned. The issue currently, is best described as having to wrestle with the steering wheel at all speeds when minor corrections are needed. That is, the steering becomes binding, catching, and creating a ratcheting sensation in both low speed maneuvers and at minor corrections during highway driving. This constant position "sticking" of the steering wheel requires me to physically pull and jerk the wheel to break it free from its position; hence the "wrestling" analogy. The vehicle was not received immediately at the dealership due to "work backlog". It is pending current review of the recurence of this symptoms.

Hybrid battery failed causing electrical issues. - Fix in October 2024. During this time Service repair for the recall related to the power steering. Car became jerky and would lose the ability to hold turns. Took to mazda and told there was a gear housing need to be replaced. Was quoted at 4000 for the repair due to car having 49000. Mazda customer service stepped in and dropped the price in half. Eventually cover the majority of the cost as we reported this as a safety issue and it only camp up after the recall was performed for the power steering and the suspension was fixed. In the service report, Technician stated that the steering has fuse to the sway bar. I am now very concerned the sway bar is unsafe. Mazda did not comment on this when I ask. It appears as the fix one thing more continue to break. with The issues the lane assist continues to have issues seems to struggle with alignment issues. Car was with Mazda for 7 weeks during the 1st year of owning it. I am also concerned with some of the finding as I look at them with details pertaining to original purchase and miles being reported on our documents. Living in Kentucky the Lemon law does help with providing any sort of real action plans on CPO. Break have been squeaky causing uneven feedback. This issue has worsened over time. Car was purchased CPO - in April of 2025.

Component/System: Steering System (Electronic Power Steering / Steering Rack) What happened? I am experiencing a recurring and escalating failure of the steering system on my Mazda CX-90 PHEV. Currently, the steering wheel momentarily "locks up" or experiences a sudden, significant increase in resistance (stickiness) during left turns, especially when a large steering angle is applied. This occurs intermittently and without any warning lamps or error messages on the dashboard. Safety Risk: This failure poses a severe safety risk as it hinders my ability to complete turns smoothly and predictably. The sudden resistance requires unexpected physical effort to overcome, which could lead to a loss of vehicle control or a collision, especially in tight maneuvers or emergency situations. History & Inspection: Previous Symptoms: Approximately one year ago, the vehicle exhibited a "grinding/squeaking" noise when the steering wheel was turned to full lock. Prior Repair: A dealership inspected the vehicle and performed a recall repair (related to Recall 24V-022) by applying grease to the steering components. This temporarily resolved the noise. Recurrence: The noise has recently returned, and the new issue of "momentary locking" has now emerged. Inspection Status: The vehicle has been previously inspected for the related recall, and the current malfunctioning system is available for inspection upon request. Additional Context: I am reporting this because I believe the initial recall fix

My 2024 Mazda CX-90 MHEV has experienced multiple life-threatening sudden engine stalls and a complete loss of motive power while driving in active traffic lanes. The first incident occurred on December 31, 2024, when the vehicle abruptly shut down with an "Engine Malfunction" dashboard alert. The vehicle was towed to an authorized Mazda dealership (Palatine, IL), where it was held for a week, but technicians stated they could not replicate the issue and returned the car to me as safe. On March 30, 2026, the exact same failure recurred. While driving, the engine suddenly shut off completely at a traffic intersection. After turning the vehicle off for 5 minutes, it was restarted and driven to another authorized Mazda dealership (Crystal Lake, IL) for specialized diagnostic scanning. The second dealership successfully retrieved stored diagnostic trouble code (DTC) P061B, which is directly linked to safety recall 24V-815 (Loss of Drive Power from Software Errors). Crucially, the detailed diagnostic scan revealed that this code was historically stored with a timestamp dating back to December 2024. This proves that the safety defect was active and detectable during the first dealer visit 16 months prior, but was completely missed by the first dealership, leaving my family with an ongoing crash hazard. To address the failure, the dealership replaced the low-pressure fuel pump in the fuel tank and a mass airflow (MAF) sensor. However, Mazda Corporate customer experience has formally

The vehicle experienced a sudden and repeated malfunction of the hybrid/electrical system and powertrain, resulting in the vehicle becoming inoperable. The vehicle is currently at the dealership and is available for inspection upon request. While driving in traffic, multiple warning messages appeared, including "Hybrid System Malfunction," "Charging System Malfunction," "Engine Malfunction," "Brake" and "i-ACTIVSENSE System Malfunction." The vehicle lost functionality and could not operate normally, creating a dangerous situation in active traffic. I was forced to slowly maneuver the vehicle to the shoulder after several restart attempts. This issue has been reproduced multiple times. The vehicle has previously been inspected and repaired by an authorized dealership, including recent repairs (12V battery and engine mounts). Despite these repairs, the same critical malfunction occurred again shortly after the vehicle was returned as repaired. The vehicle is currently being inspected again by the dealership. The issue has not yet been permanently resolved. Prior to the failure, the vehicle had a history of similar warning messages and abnormal behavior beginning at approximately 20,000 miles. These issues have continued intermittently despite multiple repair attempts. The repeated failures, including the most recent incident, indicate an ongoing unresolved defect that creates a significant safety concern. This issue is a continuation of a previously reported complaint (NHTSA Re

I own a 2024 Mazda CX-90. The vehicle has an intermittent steering concern where the steering wheel feels like it sticks, catches, or becomes notchy during normal driving. It is most noticeable when making small steering corrections to stay centered in the lane, and I have also noticed it during turns, including while entering an on-ramp. The component/system I believe is malfunctioning is the steering system, potentially the electric power steering and/or steering gear assembly. This creates a safety concern because the steering does not always feel smooth or predictable. When the steering wheel momentarily resists input or feels stuck, it can require extra effort to correct. This could increase the risk of delayed steering input, overcorrection, or difficulty maintaining the intended path of travel, especially at highway speeds or on curved roads. Mazda Safety Recall 6524A / NHTSA Campaign 24V-022 was previously performed on this vehicle. Despite the recall repair being completed, the sticky/notchy steering condition is still occurring intermittently. The problem was evaluated by a Mazda service department. During the service visit, Mazda service personnel also felt issues with the steering. I was informed they are looking for Mazda to follow up, including any additional guidance related to NHTSA Recall Query RQ26002, which I understand is reviewing sticky steering/increased steering effort after the original 24V-022 recall remedy. I am submitting this complaint because the

While driving the "power steering failure" light came on, and then went off. I checked my VIN and it says there's no recalls needed for the vehicle, but I have read that there's a lot of this happening. It happened twice in less than 2 months of ownership.

The car thinks the key fob is inside the vehicle when it is not. If you get out of the vehicle it will not self lock even if you have that feature set up. It will also beep consistently for about 10 seconds when you press the lock button on the key fob when your outside of the car, indicating that there is a key fob in the car....but there is not. The most concerning thing is you can get into the car and start it without any key fob inside the vehicle. It always thinks the key fob is in it, at all the time and will start without any key fob in it. This is not an occasional thing. It has been like this since we pirchased it from Mazda as a CPO vehicle. It's been doing this for all 2 months that we've owned it. We currently have an appointment with the dealership to take it in for them to hopefully fix it as well as other issues.

When turning on the heater or AC, the car blows out a coolant smell out of the vents. It does it every time the heat is turned on or switched over to AC. We have another appointment with the dealership to have this looked at, as well as many other issues we're having with this vehicle.

The steering seems to stick when turning wide turns. Seems to happen both directions. It feels like it’s being held or assisted in place, but the steering control is disabled.

While driving at highway speeds (55–65 mph), the steering intermittently sticks or resists movement during turns. It feels like the steering binds or hesitates before responding, requiring additional force to correct the turn. This occurred multiple times on a Reno–Sacramento trip on 5/7/2026. This is a serious safety concern because it affects the ability to maintain lane control at highway speeds. Mazda Corporate has been notified on 5/7/2026. Roseville Mazda-appointment scheduled 5/16/2026.

Steering is horrible specifically to the left in a curve it doesn't go back to center when letting it you have to force it which is jerking car back right into other lane off the road. The brakes squeal awful the car has about 40,000 miles on it. Can't see any recall on any of this with my car but it definitely has issues.

I am reporting a persistent and dangerous "sticky steering" defect in my 2024 Mazda CX-90. While driving at various speeds, the steering wheel exhibits sudden, momentary resistance and physical binding, requiring increased manual force to overcome. In several instances, the vehicle veers into other lanes and, if not corrected, would enter into the median/other lanes of traffic. This vehicle has been to the dealership three times for this specific issue and has been out of service for a cumulative total of 36 days. Despite a "repair" attempt by the dealership, the nonconformity persists. The dealership initially attempted to attribute this mechanical binding to the Lane Keep Assist (LKA) system; however, I have personally conducted road tests with the LKA system fully disabled, and the physical "stickiness" remains present. I am aware of NHTSA’s 2026 Recall Query (RQ26) regarding the effectiveness of Mazda’s steering remedies for this model. Even though my vehicle does not fall under the recall for this issue, my vehicle is currently exhibiting the exact failure symptoms that the federal government is investigating as a potential safety risk. The sudden increase in steering effort is unpredictable and poses a significant risk of over-correction or loss of control, especially in highway traffic. During the most recent repair attempt by the dealership, they were unable to duplicate the issue; however, it is very prominent and concerning. There is no warning of when it will occur

On April 29, 2026, my 2024 Mazda CX-90 Turbo S Premium Plus experienced a steering malfunction while I was entering a right turn. The vehicle had Mazda steering recall 6524A / NHTSA Campaign 24V-022 marked closed/completed before this crash. I was traveling on a familiar road and attempted a normal right turn that I make regularly. As I attempted to turn, with no warning lamps, warning messages, or prior warning immediately before the incident, the steering wheel suddenly required abnormal effort, felt stuck, and would not turn normally. I was in complete shock from the sudden steering issue and abnormal resistance. The vehicle then struck the curb, left the roadway, and traveled down an embankment/grade of approximately 15 feet into a residential yard. The crash involved significant driver-side/front-left damage. The front driver-side wheel/tire separated and was found near the vehicle. The driver-side airbags deployed. Scene evidence included curb/edge impact damage, debris, and a deep ground-level rut/indentation below the roadway. This incident placed me and others at serious risk because the vehicle left the roadway and entered a residential property. The vehicle and failed components are available for inspection upon request. To my knowledge, the only prior inspection or repair related to the steering system was performed by the Mazda dealership in December 2025, when recall 6524A was marked closed/completed along with other recalls. The vehicle has not yet been indepen

I purchase my vehicle used around November 2025, in February 2026 we started to notice a little bit of stiffness while driving in curves it usually happens when taking a right curve. Now it has got worse to the point where it feels like the steering wheel is getting stuck while taking a curve. It looks like previous owner had already done a recall on this vehicle for that issue but it has started to have issues again.

This issue I’ve seen on different forums just happened to me. Lower radiator hose leaking. Car is at 37000 miles and under no circumstance should this be happening to a new vehicle, Mazda has known about the issue apparently in my model year the manufacturing over tighted the clamp causing it to fail prematurely. This can be catastrophic especially since these leaks are just waiting to happen. If someone was on the highway it would be dangerous

The steering sticks both left and right while driving. The danger of overcorrection and/or running off the road. This has not been looked at by anyone yet. I know this is a reportable defect but it's not attached to this vehicle yet. No warning lights. This was noticed within the first week of owning the vehicle (second owner).

When driving at highway speeds, steering wheel locks in leftward position. I cannot manually move the steering wheel at this time for around 15 seconds. It happens unexpectedly and is a safety hazard. I brought it to Mazda dealership and they did not fix it. They performed an airbag clockspring replacement and this has not fixed the issue.

The power steering system in our 2024 Mazda CX-90 intermittently "sticks" while steering, requiring noticeably increased effort to turn the wheel before it suddenly releases. The symptom matches the defect described in NHTSA Recall 24V-022 (sticky steering due to worm gear friction in the power steering assembly) and the ongoing NHTSA Recall Query into vehicles where the 24V-022 remedy has failed to resolve the issue. Component: Power steering gear / worm gear assembly. The vehicle is available for inspection upon request. Safety risk: The intermittent increase in steering effort followed by sudden release creates a real risk of overcorrection, particularly during lane changes, highway driving, and turns from a stop. The driver cannot predict when the wheel will resist or release, which compromises the ability to maintain a consistent lane position and respond to road conditions. Dealer/service confirmation: UNKNOWN at this time — we are scheduling a dealer inspection. We will update if the dealer reproduces or documents the condition. Manufacturer/police/insurance inspection: None to date. No crash has occurred. Warning lamps or messages: None. No dashboard warnings, no error codes, and no messages have appeared before or during the sticking events. The condition is purely tactile through the steering wheel and is intermittent. The vehicle's recall status shows no active open recalls, suggesting any prior remedy under 24V-022 was already performed, yet the sticky steering sy

The sterring wheel becomes stiff and hard to steer. It veers to the right. Almost like it locks up. Very concerning.

1) What component or system failed? The issue appears to involve the vehicle’s electrical system and hybrid system, as well as brake-related electronic systems. The vehicle displayed multiple warnings including “Hybrid System Malfunction” and “Critical Vehicle Malfunction.” The electronic parking brake system was also affected during the incident, including a situation where the brake could not be released while the vehicle was in motion. The affected components are available for inspection upon request. 2) How was safety put at risk? Safety was put at risk because the malfunction occurred while driving and involved critical system warnings and brake-related issues, including the inability to release the electronic parking brake. The sudden appearance of a “Critical Vehicle Malfunction” warning during operation created concern about potential loss of vehicle control and safe braking capability in traffic. 3) Has the problem been reproduced or confirmed by a dealer? The issue has not been fully resolved. The vehicle previously underwent service for a high-voltage hybrid battery replacement, but the current symptoms continue to occur repeatedly. The problem has not yet been confirmed as permanently resolved by the dealer. 4) Has the vehicle been inspected by manufacturer, police, insurance, etc.? UNKNOWN 5) Were there warning lamps or symptoms before failure? Yes. Over the past two weeks, multiple warning lights and messages have appeared almost daily, including: Check Engine L

The contact owns a 2024 Mazda CX-90. The contact stated that while operating the vehicle, the steering wheel was stiff and was sticking while turning. Additionally, the vehicle failed to drive straight. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 24V022000 (STEERING); however, the failure reoccurred. The vehicle was driven to the dealer, where the failure was associated with the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 54,950.

Steering randomly gets stuck in a ‘notch’ on sweeping left hand turns and needs to be forced back to centre with a lot of effort. Mazda dealer has dismissed the issue on 3 separate occasions as they cannot replicate on the very short test drive they take it on near the shop despite asking them to take it on a longer test. I do not feel confident or safe driving the car on the highway due to this defect.

Steering wheel feels stuck about the 2:30 position, requiring to pull steering wheel back .

We bought or Mazda cx 90 pre owned from a dealer so all recalls, billions etc had been taken care of. We been to notice a “sticky” steering wheel which is gradually getting worse. When taking on/off ramps on interstate we must yank steering wheel to correct direction as the wheel doesn’t move on its own. We are very concerned we will be in a serious wreck due to this. There is not a current recall or bulletin out from Mazda. We do plan to contact Mazda to have them hopefully give us a new steering column. This should be a recall for all 2014 Mazdas as this is a serious safety concern.

This was an issue included in a prior recall (NHTSA #24V022000). My car received the Mazda repair for this recall but this did not solve the problem. Steering wheel still sticks when turning. I then have to overcorrect in the opposite direction to unstick out of the turn which results in the car suddenly jolting in the opposite direction once the steering wheel becomes unstuck. I see this as dangerous as it could cause an accident.

Radiator leaking at seems causing engine to overheat. The radiators on 2024 and earlier CX-90 are failing at the seems of the radiator. This is a known issue to Mazda, hundreds of vehicles are having to be repaired for this manufacturing defect and they are charging the consumer $2800.00 to repair something which should be covered under a recall. This vehicle is a lemon and they refuse to stand behind their product.

Steering wheel is constantly sticking and making it difficult to make certain turns. This is especially difficult on exit ramps and is a serious safety issue:

The parking cameras will fail to activate unexpectedly when backing up or if the cameras are activated using the manual button. The issue is similar to what is described in Mazda Safety Recall 6223J: "Images of the front-, side-, and rear-view cameras may flicker and, in some cases, may no longer appear on the center display monitor. Improper processing logic in the view monitor camera control module may cause image deterioration. Loss of front-, side-, and rear-view camera images when in reverse and/or using the 360-degree monitor can increase the risk of a crash. There is no warning preceding the occurrence of this defect." I brought this issue to the dealer and Mazda USA but it remains a problem. The issue most recently occured on April 15, 2026, but has happened multiple times in the past.

The fuel tank pressurization systems on my 2024 Mazda CX-90 PHEV have failed, and the vehicle is currently available for inspection at Dolan Mazda in Reno. This defect puts the safety of myself and others at risk because the vehicle gurgles and sprays raw gasoline out of the filler neck during refueling, creating a severe fire and environmental hazard at public gas stations. The issue first appeared on March 23, 2026, during a road trip from Reno to Las Vegas, with dashboard warnings stating Fuel Tank Malfunction, Avoid Refueling, Have the vehicle inspected and Engine Malfunction. The vehicle was inspected and supposedly repaired by Jerry Seiner Mazda on March 24, 2026, but the problem recurred during the return trip from Las Vegas to Reno on March 29, 2026, when it again spit fuel at the pump. The failures consistently occurred midway through long road trips at refueling stops in Tonopah, Beatty, and Hawthorne, Nevada. During these incidents, the vehicle was completely unable to accept fuel, causing significant distress as I was nearly stranded with young children in remote desert areas with limited resources. I barely managed to reach my destination on the remaining range. Although I have documented these specific malfunction messages and safety incidents, the vehicle has been at Dolan Mazda since April 17, 2026, where the dealer and manufacturer have been unable to reproduce the issue in a stationary shop environment despite it being the second formal repair attempt for a

Breaks squeal consistently only 34,000 miles was doing it when I bought it last year and they said it was just cause it was sitting and would get better never really has always squeals when breaking Steering when turning is glitchy catchy sticks like doesn't turn smooth or go back to center smooth causing you or car to jerk turn unsafe like I see recalls for these same similar things but my car doesn't currently have a recall for any of it by entering vin

In the past month or two the steering has become sticky, stiff or notchy initially occurring while completing turns on sweeping highway entrance ramps. This exact issue has now progressed to all driving conditions even when making minor steering adjustments on straight roads. I have not yet contacted the dealer or manufacturer with this concerning safety problem.

Was involved in an auto accident where the person t-boned my car on the passenger side. Airbags on the left side of the car including driver and steering wheel airbags did not deploy on impact.

The steering wheel in the car is sticky when turning both right and left, it is more pronounced in deeper turns such as on and off-ramps.

The steering rack is the component that has failed. On multiple occasions while I am driving on the freeway the steering will randomly pull in the opposite direction of the turn that I am on. Or if it the pavement is uneven it will hit the bump and stick and get harder to steer or pull one way or the other. I have been in 3 near accidents at freeway speeds. I have taken it to the dealer and they say they can not replicate it so they are not fixing it or addressing my concerns. There are no warning lights and no warning when it is going to happen so I have to grip the steering wheel tightly with both hands to prevent from being pulled or pushed into and accident. It has already been recalled once for this same behaviour.

I am writing to formally report a serious safety defect regarding the steering system of my 2024 Mazda CX-90. While driving at various speeds, the steering wheel frequently exhibits a "sticking" or "binding" sensation. In several instances, the steering wheel has become momentarily stuck in a fixed position, requiring significant physical force to "break it loose" and regain control of the vehicle's direction. Safety Risk: This condition is unpredictable and creates a hazardous driving environment. The sudden resistance and the excessive effort needed to maneuver the vehicle pose a high risk of over-correction, which could lead to a lane departure or a collision. This mechanical failure compromises the fundamental ability to steer the vehicle safely. Request: I am submitting this report to ensure this issue is documented for safety investigations and to urge a review of potential defects in the steering rack or electronic power steering (EPS) calibration for this model.

Report “sticky” or unexpectedly heavy steering, even after a recall repair.the steering wheel feeling jumpy or locking up, with sudden changes in effort.

After multiple visits to the dealer—and despite a manufacturer recall addressing the issue of remaining fuel levels and estimated range—the error message has reappeared.During my most recent visit to the dealer, I was informed that they could not detect any errors.

Since about 9 months ago, the steering wheel has been “pulling/tugging” when driving on a curb, even the slightest curb, specially when over 50mph. No warnings lights on, vehicle has has an alignment in the last year. And it is not a “line assist” problem. I turned that off for a while be sure. Vehicle was inspected by an authorized Mazda service provider, and they suggest changing the steering train to fix the issue. I particularly remember this issue came up after hybrid battery was replaced. Not sure if related or not. It is a huge safety issue, as when driving at high speed it is very hard to manage.

STEERING WHEEL SEEMS LIKE IT STICKS WHEN CORNERING OR TURNING WE ALMOST HAD AN ACCIDENT GOING AROUND A CORNER

Steering wheel gets "Stuck" when making a sweeping left turn and needs force to return to neutral. Suspension "creaks" and "grinds" when going over bumps or hills.

The contact owns a 2024 Mazda CX-90. The contact was informed about a previous recall associated with the steering that was repaired prior to owning the vehicle, but the failure persisted. The contact stated that while driving on several occasions at various speeds and turning, the steering wheel jerked in the opposite direction, then became soft, and then more difficult to steer. The vehicle was not diagnosed or repaired, but the contact was informed of a steering investigation. On another occasion, the contact stated that when the vehicle was stopped and the ON/OFF feature was activated. There was an abnormal knocking sound coming from the engine compartment. The contact stated that after turning off and restarting the vehicle, and after refueling the vehicle, the messages "Engine Malfunction – Inspect Vehicle" and "Hybrid System Malfunction" was displayed. The check engine warning light was illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 56,050.