2020 Kia Soul

Defect. Kia Motors America (Kia) is recalling certain 2020-2021 Soul, and 2021 Seltos vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which may result in engine damage.

Risk. A damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of a fire.

Remedy. Kia will notify owners, and dealers will inspect and, if necessary, replace the engine, free of charge. In addition, Kia will deploy Piston Ring Noise Sensing System (PNSS) software. The recall began June 11, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC209.

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional …

TECHNICAL SERVICE BULLETIN: HORN ASSEMBLY INSPECTION/REPLACEMENT (WTY041) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY041) to inspect and, if necessary, replace …

WARRANTY EXTENSION CAMPAIGN: REIMBURSEMENT FORM (WTY041) - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension campaign program launch.

WARRANTY EXTENSION CAMPAIGN: OWNER NOTIFICATION (WTY041) - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage, to all owners, for repairs related to the horn assembly in certain 2020-2025 MY Soul vehicles from 5 years / 60,000 miles to 10 years / 120,000 miles, whichever comes first, starting …

TECHNICAL SERVICE BULLETIN: WARRANTY EXTENSION CAMPAIGN: HORN ASSEMBLY INSPECTION/REPLACEMENT (WTY041) - This bulletin provides information associated with the ‘Warranty Extension Program’ (WTY041) to inspect and, if necessary, replace the horn assembly on certain 2020-2025MY Soul (SK3) vehicles produced from November 15, 2018 through August 13, 2024, The …

TECHNICAL SERVICE BULLETIN: MISFIRE CONCERN DUE TO OVERRUNNING ALTERNATOR DECOUPLER - This bulletin provides information to address unresolved misfire events on some 2020–2024MY Forte (BDm) produced from January 1, 2019 through September 30, 2024, and 2020–2022MY Soul (SK3) vehicles produced from November 1, 2018 through May 31, 2022 equipped with a Gamma …

This bulletin provides instructions to perform an engine vibration inspection using the Kia Diagnostic System (KDS) tablet on certain Kia engine/model vehicles. The piston oil ring(s) in certain Kia engines may, over time, damage the surface of the engine cylinder wall. This may lead to increased oil consumption which will eventually result in abnormal …

TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2024MY vehicles (refer to the table on pages …

TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2024MY vehicles (refer to the tables on pages …

TECHNICAL SERVICE BULLETIN: SUBSEQUENT REPAIR ACTION: ENGINE REPLACEMENT INSTRUCTIONS FOR PISTON RING NOISE DTC 1327 (SC209Y) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin …

TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model …

Reason for Dispute & Desired Resolution: I am filing an executive escalation regarding a catastrophic engine failure on my 2020 Kia Soul, which is actively included in the Piston Oil Ring Safety Recall (Campaign SC209). The engine suffered a total structural failure where a rod broke and punctured a hole directly through the engine oil pan. The vehicle is completely undrivable and presents an environmental hazard due to active fluid leakage. Standard Kia Customer Care and Roadside Support lines have officially denied emergency towing assistance and rental car coverage, stating they cannot help. The closest authorized dealership, Kia of Columbia, has an appointment backlog delaying an official inspection until October 29th. I cannot afford the out-of-pocket costs for an hour-long flatbed tow from my home or weeks of upfront rental car fees. As a consumer, I am being penalized and left stranded by a severe manufacturing defect that Kia has legally acknowledged. I demand that Kia’s Executive Resolution Team immediately issue a direct digital dispatch code to authorize a free flatbed tow to the dealership, and establish a direct-billed loaner or rental vehicle (via Enterprise) so that my livelihood is not disrupted while waiting for the scheduled recall repair and engine replacement.

The car stalled at red light. After a few minutes cranked back up.

On [XXX], my 2020 Kia Soul (2.0L Nu MPI, VIN [XXX], approximately 102,420 miles) suffered total engine failure: complete loss of motive power, stalled and would not restart. This is the exact defect covered by federal recall 21V259000 / Kia SC209 (piston oil rings causing engine damage and stalling). The SC209 recall remedy had already been performed on this vehicle at Kia of Daphne (Daphne, AL) in June 2026. The recall did not prevent the failure. Symptom history matches the defect: the vehicle has burned oil excessively its entire life (oil changed every 3,000 miles; oil like sludge by approximately 2,000 miles) - the textbook piston-ring symptom. Sputtering began June 2026; a spark-plug replacement bought two to three months before total failure. Diagnostic codes at failure: P0304 (cylinder 4 misfire), P219F (cylinder imbalance), P0014 and P0017 (camshaft/crankshaft timing correlation), P1327 (knock sensor) - internal engine and timing damage consistent with the recalled defect. On [XXX], Kia of Daphne inspected the vehicle ([XXX]). The technician found low compression and wrote the failure 'does not have to do with recall campaign sc209A' and is 'not covered under Kia warranty or recall,' quoting $5,855.28 for an engine long block. I dispute this: low compression plus lifelong excessive oil consumption is the classic signature of worn piston oil rings - the exact SC209 defect. The one-sentence dismissal does not address the documented symptom history. Kia corporate cases

On XXX my 2020 Kia Soul while on the freeway, would not accelerate and silently stalled. The check engine, oil, and battery light all came on. Putting it into Park and then Drive again, the vehicle began shifting backwards. The vehicle could not be safely driven and was towed to Kearny Mesa Kia in [XXX]. The dealer diagnosed code P0017 (crankshaft position and camshaft position correlation). The technician found the exhaust camshaft out of sync because the pin on the CVVD gear had broken, which allowed the gear to spin on the camshaft. The recommended repair is replacement of the exhaust camshaft, CVVD gear and bolt, timing chain tensioner, and valve cover gasket, quoted at $3,285.34. A borescope inspection found no valve damage. The service advisor told me this is a common problem on these vehicles. An internal engine part failing like this at about 99,000 miles is a premature failure, not normal wear. A sudden loss of camshaft timing can cause stalling or a loss of power while driving, which is a safety risk. I am the third owner and bought the car used through Carvana at about 55,000 miles, so the powertrain warranty does not cover this repair. Kia America denied my request for goodwill assistance. I ask NHTSA to look into CVVD gear and camshaft timing failures on the 2020 Kia Soul 2.0L engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2nd failed motor due to code P1327, was replaced last year for same issue, less than a year later and same issue again.

The vehicle experienced complete and sudden engine failure while actively driving on a roadway. The engine began making loud, violent knocking noises, the check engine light illuminated, and the vehicle completely stopped and lost all motive power mid-drive. I believe this is directly caused by the defective piston oil rings covered under NHTSA Safety Recall Campaign 21V-259 (Kia Campaign SC209). The vehicle had only just begun exhibiting these severe symptoms on the exact day it stopped working. The loud engine knocking, immediate check engine light, and rapid internal oil loss all occurred rapidly within hours of each other on the same day, leading directly to the total mechanical failure and seizure. The engine component is currently intact and remains completely available for physical inspection upon request. The engine in my Kia Soul is the 2.0L Nu MPI. The vehicle was towed to an authorized Kia dealership service center. The dealership confirmed that the engine has completely failed and had loud knocking sounds, but they are attributing the issue to an external leak in an attempt to deny coverage under Safety Recall SC209. The manufacturer (via the dealership, Techline, and Kia Corporate) has inspected the vehicle, but they have refused to perform the required internal engine teardown to inspect the piston rings or to honor the federally mandated recall remedy and fix my engine for free despite the recall. I have been fighting this for over two weeks now. I also provide

Vehicle Details: 2020 Kia Soul, 2.0L Nu MPI Engine Complaint Description: My vehicle is experiencing severe, excessive engine oil consumption at 99,000 miles, which has directly resulted in a P0420 diagnostic trouble code (Catalyst System Efficiency Below Threshold) due to motor oil poisoning the catalytic converter. This vehicle exhibits the exact failure mechanism, symptoms, and manufacturing defects detailed in Kia Safety Recalls SC209 and SC336 (improperly heat-treated or defective piston oil rings). However, when checking my 17-digit VIN on the Kia portal, I am informed that my vehicle is excluded from these recall campaigns. The heavy oil consumption creates a severe safety hazard. The engine rapidly drops below safe oil operating levels between scheduled maintenance intervals without illuminating an oil level warning light, putting the vehicle at high risk for sudden engine stall, total engine seizure, or an engine compartment fire while traveling at highway speeds. Because this is a known, documented manufacturing defect for this specific model year and engine type, Kia should expand Safety Recall SC209 to include my VIN and prevent a catastrophic highway failure.

My 2020 Kia Soul 2.0L has developed serious engine problems. The vehicle initially had diagnostic trouble code P0014 and later P000B. The vehicle has also experienced significant oil consumption. A mechanic inspected the vehicle and determined that the engine has sustained damage related to oil consumption and that the engine requires complete replacement. I was previously advised that the issue could involve the camshaft timing/variable valve timing system or cam phaser, but the engine itself needs to be replaced. The vehicle has approximately 113751 miles. I have maintained the vehicle and have documentation showing that I performed regular oil changes in accordance to the user manual. I am concerned about the premature engine failure and the potential safety consequences if the engine loses power or fails while the vehicle is being driven. My VIN currently does not show an applicable recall. I am reporting this problem because I believe the engine failure and oil-consumption issue should be documented and reviewed for a potential safety-related defect or pattern involving this vehicle/engine.

The contact owned a 2020 Kia Soul. The contact stated that while attempting to operate the vehicle, the engine seized and the vehicle failed to start. When attempting to start the vehicle, a knock turnover was present, and the check engine warning light illuminated. The contact referenced NHTSA Campaign Number: 21V259000 (Engine); as the cause of the failure. The vehicle was towed to an authorized dealer, and the dealer confirmed the total engine failure was directly associated with the recall. However, the dealer refused to perform the repair, claiming that the vehicle had exceeded the extended warranty, despite a federal safety recall not being bound by warranty expiration rules. The manufacturer was notified of the failure. The failure mileage was 154,937.

The contact owns a 2020 Kia Soul. While driving 65 MPH, the vehicle lost motive power, and the check engine warning light illuminated. The contact pulled over to the side of the road and added oil to the engine before continuing to drive. The vehicle was taken to a dealer for diagnosis, and the contact was informed that the engine and catalytic converter needed to be replaced. The contact associated the failure with NHTSA Campaign Number: 21V259000 (Engine). The manufacturer was notified of the failure. The failure mileage was 182,000.

I’m having trouble with my pearl white paint peeling off my car. I am available for an inspection. The car has not inspected by anyone at this time. Waiting on instructions. This started last year July and just keeps getting worse every day.

I own a 2020 Kia Soul with approximately 39,000 miles. I brought the vehicle to an authorized Kia dealer in connection with an engine safety recall (sc209). During the recall process, the engine failed Kia’s required testing, and I was advised that engine replacement was being submitted for approval. Kia subsequently requested my historical oil-change records and advised the dealer that the PWA case would be closed and denied if additional maintenance records were not provided within five business days. I no longer have complete receipts for oil changes that were performed over the approximately six years I have owned the vehicle. My concern is that the vehicle failed testing performed as part of an acknowledged safety recall, yet the recall remedy may be denied solely because I cannot produce a complete historical set of oil-change receipts. The vehicle has fewer than 40,000 miles. I am requesting that NHTSA review whether conditioning the recall-related engine replacement on complete maintenance documentation is consistent with the required remedy for this safety recall.

This car was purchased in December of 2025 with 26K miles on it. There are stall issues when using the auto start stop feature. I had to power down the car and restart it up to get the car to move. It also will throw the check engine light code and then after you drive it, it goes away which makes it difficult to take to a service shop for diagnosis. Recently the car is now at 28K (9 mo later) and it has an intermittent stutter when driving; I can only describe it as a push/pull motion and its random, during this time the check engine light came on again. On my way to take it to a service station for diagnosis, it went away. Not sure if this has been reported by other 2020 Kia Soul owners.

Last year the left rear driver side door the paint started to peel off. It is now 12 inch area. I brought this up to Bulldawg, Athens, Ga. KIA where the care was purchased and got a so sorry, nothing we can do. No accident, no harsh weather.

The vehicle has experienced intermittent stalling and near-stalling while driving. The problem began after a prior Kia engine replacement related to DTC P1327/P132700. After the engine replacement, the vehicle developed additional drivability and warning-light concerns, including P0420 and communication/CAN faults. An authorized Kia dealer later documented that the vehicle had stalled a few times, identified P0420, reported a clogged catalytic converter, and found 11 additional lost-communication/CAN-related codes. The dealer stated that approximately eight additional diagnostic labor hours would be required to investigate the remaining faults. The vehicle was returned with the intermittent stalling condition unresolved. The stalling presents a safety risk because the vehicle can lose motive power unexpectedly while being driven. The vehicle remains available for inspection. The dealer confirmed the stalling complaint and performed diagnostic testing, but the complete cause has not been determined. Kia previously performed an engine replacement related to the earlier P1327 condition, and the current stalling occurred afterward.

The contact owns a 2020 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the spark plugs and coils needed to be replaced. The vehicle was repaired. The contact stated that while driving at an undisclosed speed, the taillights were inoperative, there was oil leaking from the bottom of the vehicle and the vehicle stalled. The contact stated that after the vehicle was restarted, the vehicle returned to normal operation. The failure had occurred on several occasions. The vehicle was taken to a dealer to be diagnosed and the dealer stated that there was an oil consumption issue with the vehicle; however, cause of the failure was not yet determined. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the bolts needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Back in 2021 there was a safety recall for the engine burning oil and having a high risk of catching fire. I leased this car from the Kia dealership in Asheville, NC and was guaranteed that the issue was not with this car. Here I am a year later and I have to basically put oil into the car at least every two weeks because the engine is burning the oil so fast and the car is basically running terribly. I have made multiple complaints to a bunch of mechanics including the dealership where they are trying to over charge me for a full engine replace because my vin doesn’t follow with the recall notice.

I am filing this complaint regarding a serious paint defect on my Kia in which the exterior paint is peeling off in large sheets. I purchased the vehicle used from Dean McCurry Kia, and the dealership was aware of the paint issue before selling the vehicle to me but failed to properly repair or disclose the condition before the sale. The paint has continued to deteriorate and is now peeling extensively, leaving exposed areas of the vehicle. I have contacted both Dean McCurry Kia and Kia regarding the problem, but both have refused to take responsibility or provide a reasonable solution. I believe this is a pre-existing manufacturing or paint defect that was known to the dealership before the vehicle was resold to me, and I am concerned that Kia and the dealership are refusing to address a potentially widespread safety and quality issue. I am requesting that NHTSA document and investigate this complaint and determine whether this paint defect affects other Kia vehicles and warrants further action.

Making a left turn car stalled in middle of turn lane.

Engine piston recall defect. Car has been at the dealership 12 days today and has been diagnosed and has been submitted to a Kia corporate case for repair free of charge. Car had no warning lights on and basically blew up on me driving home from my overnight work shift Thursday into Friday, July 31 morning. Every day they tell me they will give me a loaner and every day they lie. I have called until I’m blue in the face and no action has happened. I’m making a report because I’m about to lose my home and the car in the shop being repaired both because I’m stranded at my house as a single woman with a child with no alternate transportation. It is at the Kia dealership in Southhaven Mississippi 745 East Goodman Rd. I maintained this vehicle and paid every single note on time and did nothing wrong. I’m gonna lose everything because of this recall repair needed that I never knew anything about. It wasn’t on my auto report in 2024 when I bought the car somehow or I probably wouldn’t have bought it with any engine issues but I was unaware. The car literally never had any lights on or issues until the morning when it blew up. During this time I thought I was supposed to get alternate transportation and that hasn’t happened. Because I invested in Kia I’m the only one suffering right now about to lose my home and job because they have my car and won’t give me alternate transportation. A free repair is no good if you’re going to lose everything you work hard to maintain while it’s bein

The contact owns a 2020 Kia Soul. The contact stated that while driving approximately 55 MPH, the check engine and oil warning lights illuminated, and the vehicle stalled. There was smoke coming from the engine compartment. The vehicle was pulled over to the side of the road, and two hubcaps were damaged, and the vehicle was restarted. The vehicle was taken to the residence. The contact stated that when the vehicle arrived at the residence, there was no oil inside the engine. The contact added oil to the engine, and the vehicle was taken to the dealer. The vehicle was not diagnosed. The contact stated that an oil change was performed at approximately 54,000. The manufacturer was not notified of the failure. The failure mileage was 56,375.

The contact owns a 2020 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle was erratically shaking, and the check engine warning light was illuminated. The vehicle was towed to the dealer, where it was diagnosed with piston rings failure. The contact was informed that there was a hole in the catalytic converter. The contact was informed that the engine, catalytic converter, the two Oxygen sensors, radiator hoses, heater coil hoses, motor mounts, and the serpentine belt needed to be replaced. The contact was informed that the engine was replaced in 2022 under an unknown recall. In addition, the contact was informed that the mileage on the vehicle was 108,000, at the time that the recall repair was completed. The contact was informed that the warranty only covered the replacement of the engine. The contact stated that the failure was a consequential failure associated with the engine failure. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 165,000.

The engine shut down unexpectedly while driving. The dealer confirmed it was due to internal oil consumption. There's a known history of engine failure in these vehicles due to manufacturing defect, including shutting down while driving, noise coming from the engine and even a risk of fire. The warning oil lamp never came up, there was no oil leak spots in my driveway. My safety definitely was at risk, and Kia was sued and lost for these same reason before. I towed the car to Kia City in South Orlando but they wanted to charge me $7500 for fixing the engine under the excuse that the warranty had expired. This is not true, since this vehicle was purchased as a certified pre-owned vehicle with only 3000 miles and still is under the ten year powertrain warranty. I towed the vehicle back home after almost a week in the dealer.

I want to make a complaint about my 2020 Kia Soul. It is a great car, but the white paint will not stay on the car no matter what I do. It keeps flaking off all over the car. Just recently, it was my right passenger side door. It looks horrible. The car is under a car loan and is loosing paint as I pay off. I want to make Kia aware of this issue. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle stalled without warning while releasing the accelerator pedal. The vehicle restarted after each failure. The first dealer diagnosed the vehicle and retrieved DTC: P04100 (Camshaft Position Sensor A Circuit); however, the repair failed to fix the vehicle. The vehicle was taken to Hendrick Kia of Concord (7550 Hendrick Auto Plaza NW, Concord, NC 28027); and the technicians informed the contact that the vehicle was not properly repaired. The vehicle was returned to the first dealer, and the dealer failed to duplicate the failure. The dealer dismissed the contact’s concern that the vehicle was consuming an excessive amount of engine oil. The contact was informed that adding one quart of oil per 1,000 miles was within normal operation of the vehicle. Upon investigation, the contact related the failure to Kia recall SC199. The manufacturer was notified of the failure and provided a case number and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 34,000.

At 63387 miles my backup camera on my 2020 KIA Soul EX stopped working without warning. It will blink on and off occasionally but is generally just a black screen when placed in reverse. All of the other screens work fine. This is concerning to me as it is an important safety feature. It seems like KIA would repair such an item at no charge. I called my local KIA outside of Dallas about the issue and I was told the repair would cost at least $800. I’ve gotten used to using my mirrors again but it’s concerning I no longer have a backup screen.

Vehicle has 22000 miles and has a major/excessive oil consumption and engine failure. Exhaust camshaft (broken pin) Exhaust CVVT (broken pin) These components breaking caused the vehicle to stall and completely shut the vehicle down while driving 70 MPH on the freeway. The vehicle was inspected by a Kia certified mechanic and mentioned this is a well known concern. The only indicator that there was an issue was an engine light which gave a code representative of a faulty senor, not a major engine concern.

On XXX my family and I were heading home from a family vacation. My engine burned through the oil that was put in my car on XXX. No low oil pressure light came on and there was no warning my vehicle had problems with the oil. We took our car to a Kia dealership in [XXX] and that’s when I was informed that my engine was burning oil. We had no prior knowledge that there was a problem. The service guy we were working with admitted that this issue was due to the fault engines from Kia and submitted a claim to get my engine replaced that was denied due to “low oil” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Jeff Smith Kia in Perry was doing the maintenance they went out of business Kia Hutchinson I told several employees more than once that I was having problems the car would slowly shut down and cut off start then stop on the hey I had to call tow trucks have rentals there was a chainsaw sound underneath had to constantly place oil in the car Kia Never contacted me about a recall the dealerships never communicated recalls on the engine and oil burning they placed me and my grandchildren at risk and say I have to pay $110000 for a new engine. A belt. Cadillac converter and I simply do not have that. School starts in a week 1/2 and I cannot get four children to school or make it to my Dr appointments tremendous hardship and safety concern because a mechanic told me the shutting down is a mechanism to keep the engine from catching on fire and exploding. I have been told by several Kia owners they had the same issue. Walmart mgr told me it is a manufacturer issue I should not have to pay for repairs.

Vehicle paint is bubbling and pealing. This is the Snow White Pearl paint. Dealer's response is that it is not their problem and the manufacturer states that they will not make any repairs or compensation. There are also numerous rust spots all over the car as shown in attached photos.

The car began making a weird noise and stalling. Then close to home if shut off, I was able to restart it and drove a short distance to home. Realized couldn't drive it like that and contacted City Kia Greater Orlando dealer. Towed the car to the indicated destination and after about four days (it was the July 4th weekend) they sent me a diagnostic of engine failure due to internal combustion and want to charge me $7500. Offered another alternative for about $1500 but acknowledged that would likely not solve the issue. I declined and informed them that I was told about the engine recall, that my vehicle year and model (2020 Kia Soul) was included in the lawsuit that caused the recall, and that I was never told by the dealer or Kia about the engine recall and about a particular software upgrade that was supposed to alert me about the possibility of engine failure due to a Kia manufacturing defect. They informed me that my vehicle was out of warranty and that my VIN number was not in a particular list of vehicles. I don't understand how is it possible, since I purchased that vehicle in the same dealer with about 3000 miles at the time of purchase and the vehicle has been properly maintained in the same dealer, as the maintenance records show, including a good maintenance badge from CarFox. I believe this is extremely unfair, how I am supposed to accept that I have a useless vehicle when I did everything right and my car obviously should've been included in that engine recall. H

I own a 2020 Kia Soul that received Recall SC209. Kia performed the recall remedy and considered the recall complete. Before the engine failed, the vehicle had a documented history of excessive oil consumption. The vehicle was previously diagnosed by an independent third-party mechanic shop for excessive oil consumption, and I repeatedly had to add significant amounts of engine oil between oil changes to keep the engine operating. Despite this known condition, the excessive oil consumption continued after the recall was completed. Eventually, the engine suffered a connecting rod bearing failure and seized. The Kia dealership has denied warranty or recall coverage solely because Recall SC209 had already been completed. Kia Consumer Affairs also denied assistance and stated that the engine failure is not covered because the recall was previously performed. My concern is that the symptoms leading up to the engine failure—including excessive oil consumption followed by connecting rod bearing failure—are consistent with the defect addressed by Recall SC209. In my opinion, the recall remedy did not correct the underlying defect on my vehicle. I am requesting that NHTSA investigate whether the SC209 recall remedy is effective for vehicles that continue to experience excessive oil consumption and subsequently suffer catastrophic engine failure after the recall has been completed. I have maintenance records, documentation from the independent mechanic shop showing excessive oil consum

A service campaign/safety recall was issued, necessitating an engine replacement. Bramlett Kia in [XXX], performed this service in late May/early June of 2025. It took them an entire six weeks to do the work. Upon completion of the job, my husband attempted to drive it off their lot, only for the transmission to go out immediately. Kia also replaced the transmission. After this was done, my husband drove the car back to our house in [XXX]. It sat in our garage from June until two weeks ago. My brother has been driving the car between [XXX], and [XXX]. Two nights ago, as he was leaving work, the vehicle started, ran for 30 seconds and made a rumbling sound before breaking down. He restarted the car and started driving it, but the car quickly overheated. As an emergency measure, he drove it to a service shop in [XXX], where it was discovered that the AC compressor and serpentine belt had come loose. This was because the bolts securing the engine were overtightened during the engine replacement in [XXX], and two of them had broken off while the vehicle was in motion, thus allowing the compressor and serpentine belt to loosen. We had the car towed to Cavenaugh Kia in [XXX]. They will not perform the work and say that the vehicle should go back to the dealership in [XXX]. The Alabama dealership says it is not their problem. Kia Customer Affairs also says that because the work was performed just over a year ago, it is no longer covered under warranty. Furthermore, they will not pay

While driving on the interstate at approximately 70 MPH, the vehicle suffered a sudden and complete loss of forward motive power. The engine revved, but the vehicle completely ceased forward acceleration and could not maintain highway speeds. This created an immediate safety hazard, forcing me to navigate across active lanes of highway traffic without power to reach the shoulder, narrowly avoiding a rear-end collision. Once stopped, the vehicle completely refused to engage any forward gears (Drive). However, the transmission will still engage and move backward in Reverse. This is the second time this vehicle has experienced a total transmission failure in 6 years, despite having previously had the transmission replaced at an authorized dealership under Kia Service Campaign SC199. The replacement Intelligent Variable Transmission (IVT) component has suffered an identical, catastrophic mechanical failure to the first unit. The manufacturer’s previous campaign remedy failed to permanently resolve this severe highway safety defect.

I recently bought this 2020 Kia soul the 2 L engine and I’ve noticed every 700 miles 1 quart of oil in this concerns me because how do I not affect it would’ve ran dry and burn the motor up that me is safety. I understand that they have it to replace motor and engine for the original owner, but since I am second owner of this vehicle I don’t qualify for the hundred thousand miles 10 year warranty. My vehicle has 88,700 miles and I’m sure what not to do next.

There are hundreds of on-line complaints regarding 2020 Kia Soul with paint flaking and peeling off. This is especially true for cars painted white. This is happen to the Soul I purchased a few years ago. I can no longer use a car wash. Please see pictures. The exposed areas will lead to rust and corrosion. If the metal supporting the engine, cabin, or bumpers flakes off or has holes, the vehicle loses its ability to protect occupants during a collision. A rusty car can be highly dangerous if the corrosion has spread to critical structural or mechanical components. Rust on surface areas will eventually let water leak through to a vehicle's frame, suspension, or braking system which will significantly compromise safety and increases the risk of catastrophic failure. One of the attached photo's will show paint that came off the car with painters tape which I used on the back of a credit card to show the relative size of another area where paint has come off!!!

I was driving when the vehicle stalled while slowing down. It stalled several more times at a stop light, and then when slowing down or accelerating slowly. I then noticed the engine started making a noise. I have parked it and not been able to drive it since. No safety indicators popped up during the stalling. When the engine started making a noice the check engine light then turned on. The car has only 65958miles on it. I believe it should be apart of the SC209 recall list but it is not.

There was a recall-SC209A for a faulty piston ring. This vehicle “passed” prior to my purchase. I was unaware that my vehicle was part of the recall- when the VIN is entered in the NTSB website, no active recalls show. Starting in 10/24, the vehicle began having problems accelerating, and when I brought to my local mechanic it was found to be nearly empty on oil despite a recent oil change. I have since experienced continuing issues with low oil and oil consumption. The latest incident was in XXX on a trip to [XXX] . The car seized in the highway, and was brought to a local Kia dealer. They diagnosed a bad transmission, and it was replaced. Despite this, the car has continued to burn oil. I have brought the car to my local Kia in Schaumburg where it was purchased. It was today that I found out it was part of the recall. I asked for an oil consumption test, and I was told this would be at a $200 cost to me. I am worried for my families safety taking this car on the road- the oil light doesn’t come on when it is low. Kia hasn’t offered to retest the car, and I feel at significant risk continuing to drive it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Kia Soul. The contact stated that the check engine warning light illuminated while driving. The contact stated that he was a mechanic, and the contact had retrieved a diagnostic code indicating a vibration in the pistons. The dealer and the manufacturer were not contacted. The vehicle was not repaired. The failure mileage was 112,704.

My 2020 Kia Soul had its engine replaced under safety recall SC209 (NHTSA Campaign 21V259). At 136,202 miles, this replacement engine suffered a secondary catastrophic failure, dropping heavy metal shavings into the oil lubrication system and causing the engine to stall. Kia of Orange Park (Repair Order 183972) diagnosed the failure but refused to honor the 15-year/150,000-mile Class Action Engine Settlement extension, forcing me to pay out-of-pocket at an independent shop. The manufacturer's safety recall remedy has failed."

The contact owns a 2020 Kia Soul. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to O’Reilly’s where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle as not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure and a case was filed. In addition, the contact was advised to take the vehicle to the dealer for diagnostic testing. The failure mileage was approximately 109,256.

The contact owns a 2020 Kia Soul. The contact received a notification of NHTSA Campaign Number: 21V259000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the lack of specialize mechanical technician. The manufacturer was made aware of the issue. The contact had not experienced a failure.

I own a 2020 Kia Soul that, according to Kia Customer Care, had the SC209 engine recall repair completed in 2021 at approximately 28,000 miles under a previous owner. I have the exact repair date written down and can provide it if needed. On May 12, 2026, while driving, the vehicle suddenly stalled and shut off, switching into accessory mode without warning. I was able to restart it afterward. Today, approximately 20 minutes ago, the same issue occurred again while driving — the engine stalled unexpectedly and switched into accessory mode. After the first incident on May 12, I checked the oil level and it appeared full. Today, after the second stall, I checked the oil again and found it significantly low, around 1–2 quarts remaining. The vehicle required approximately 3 quarts of oil to return to full. I want this formally documented because I am concerned there may be an ongoing engine issue related to excessive oil consumption and/or engine failure despite the prior SC209 recall repair having been completed. I have only had the car 27 days.

This vehicle burns over 2 quarts of oil between oil changes. Had 3 oil consumption tests. Kia states that this motor is supposed to burn that much oil. My catalytic converter is now going bad due to the amount of burnt oil clogging it. Why have these engines not been recalled?

Car just starting shutting off only will drive a certain amount of time then turns off again

The engine consumes oil and requires repeat oil changes or refilling the engine oil prior to expected or recommended service date. This causes a severe emissions issue.

The contact owns a 2020 Kia Soul. The contact stated that the vehicle was repaired under Kia Recall: SC209; however, the repair failed to prevent the failure. The contact stated that while driving at various speeds, the contact became aware of a n excessive oil consumption. No warning light was illuminated. The vehicle was diagnosed by an independent mechanic, and it was determined that the engine was consuming an excessive amount of engine oil; however, the cause of the failure was unknown. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the cost. The contact stated that oil was being added approximately every 2 days. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.

Engine shut off while making a turn. Took car to mechanic and he stated that the car did not display any error messages. The car also over heated while driving in freeway.

My Car would shut off in the middle of the road after I stopped to make a turn or even stop at a stop light. Also the engine is burning oil. Mechanic says the the engine needs to be replace. Something with the oil piston and the exhaust is burning oil. I am not sure

The contact owns a 2020 Kia Soul. The contact stated that while driving approximately 15 MPH, the engine started knocking on the passenger side of the vehicle underneath the hood. The contact accelerated to 45 MPH and continued driving. After refueling, while continuing to drive at 45 MPH, the vehicle suddenly lost engine power, and the vehicle started coasting. The vehicle was stopped, restarted, and the contact continued driving. A short while after restarting the vehicle, the failure reoccurred. The contact stopped the vehicle, waited, then restarted the vehicle a second time. The vehicle was driven to the destination. An image of an engine was displayed on the instrument panel, and the vehicle continued to make a knocking sound. The vehicle was towed to a certified mechanic, who diagnosed that the engine was failing and needed to be replaced. The certified mechanic informed the contact about NHTSA Campaign Number: 21V259000 (Engine); and associated the vehicle with the recall; however, the VIN was not included. The vehicle was not repaired. The vehicle was then towed to the dealer, who confirmed the diagnosis; however, the dealer had not repaired the vehicle. The manufacturer was informed of the failure. The manufacturer declined to provide the engine replacement under recall or warranty. The failure mileage was approximately 79,000.