2003 Kia Sorento complaints

ENGINE COOLANT OVERFLOW CONTAINER IS CRACKED. *TR

2003 KIA PART # 25430-3E201 TSB # KT2007073101 DRIVING DOWN ROAD COOLANT OVER FLOW TANK SPLITS LEAKS FLUID OUT, RUINS ENGINE, FIND OUT KIA HAD A TSB OUT TO REPLACE TANK WITH STRONGER RE-ENGINEERED TANK. NEVER NOTIFIED PUBLIC, BAD DESIGN COSTS ME THOUSANDS OF DOLLARS BECAUSE NOT COVERED UNDER WARRANTY. I AM LEFT STRANDED 10 PM AT NIGHT ON SIDE OF INTERSTATE IN POURING RAIN. *TR

MY VEHICLE STARTED ACTING UP WHENEVER I TURNED ON THE AIR CONDITION I WOULD LOSE POWER. THE ENGINE LIGHT WOULD COME ON AND THE STEERING WHEEL WOULD GET REAL TIGHT AND I WOULD NOT BE ABLE TO TURN IT. THE VEHICLE IS CURRENTLY AT A KIA DEALERSHIP WHERE IT HAS BEEN FOR 3 WEEKS NOW WAITING ON PARTS. NOT TO MENTION I CALLED KIA ROADSIDE ASSISTANCE FOR 4 DAYS STRAIGHT BEFORE A TOW COMPANY FINALLY CAME AND TOWED MY CAR TO THE DEALERSHIP. I WAS TOLD I NEEDED A CRANK SHAFT, TIMING BELT, AND A ENGINE WHICH IS ALL COVERED UNDER WARRANTY, BUT THEY HAVE NOT RECEIVED ANY OF THE PARTS NEEDED FOR MY CAR. I AM STILL WITHOUT A VEHICLE KIA SAYS THEY DO NOT DO LOANER CARS OR RENTALS SO I AM JUST FRUSTRATED WITH THE WHOLE ORDEAL. *JB

TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT RECEIVED A RECALL NOTICE IN JULY OF 2007 REGARDING THE CRANK SHAFT BOAT. HE TOOK HIS VEHICLE TO THE DEALER AND THEY STATED THAT THE PARTS FOR THE REPAIR WERE UNAVAILABLE. WHILE DRIVING 25 MPH, THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL AND THE ENGINE FAILED SIMULTANEOUSLY. HE TOOK HIS VEHICLE TO THE LOCAL KIA DEALER AND THEY STATED THAT THE TIMING BELT CAUSED THE FAILURE. AN INSPECTOR FROM CARFAX STATED THAT THE ENGINE FAILED BECAUSE OF THE CRANK BOAT SHAFT. THE MANUFACTURER REFUSED TO REPAIR THE VEHICLE WITHOUT A SERVICE CHARGE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 67,000.

2003 KIA SORENTO. GAS TANK WILL NOT FILL AND WHEN ATTEMPTING TO FILL THE CAR WILL SPEW GAS ONTO THE CONSUMER AND ALL OVER THE CAR AND SURROUNDING AREA CREATING A POTENTIAL FIRE HAZARD. ACCORDING TO KIA I HAVE TO REPLACE THE ENTIRE GAS TANK ASSEMBLY BECAUSE IT'S DEFECTIVE. FOR NOW I HAVE TO PUMP THE GAS IN EXTREMELY SLOWLY AND IT TAKES APPROXIMATELY 12 TIMES LONGER THAN NORMAL. *TR

COOLANT SPILLING FROM THE RESERVOIR (WHICH WAS REPLACED IN DECEMBER 2006, THE PART WAS ON NATIONAL BACK ORDER. I WAITED 5 WEEKS FOR THE PART TO ARRIVE). THE CAR STALLED SEVERAL TIMES AND STEAM CAME FROM THE RIGHT SIDE OF THE HOOD. TODAY IS 8/31/07, SIMILAR INCIDENT HAPPENED WITH THE CAR. THE DEALER SAID THAT THE HOSE FROM THE COOLANT RESERVOIR WAS CRACKED. I ASKED SINCE THE PART WAS RELATED TO THE RESERVOIR WHY DID I HAVE TO PAY ADDITIONAL FOR THE HOSE REPAIR ($193.30). THE DEALER SAID THE HOSE WAS A SEPARATE PART. I DON'T UNDERSTAND WHY KIA DOESN'T RECALL THE RESERVOIR AND ANY ASSOCIATED PARTS. *TR

TL*THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING 15-20 MPH, ANOTHER VEHICLE CRASHED INTO THE DRIVER SIDE DOOR OF THE CONTACTS VEHICLE. THE PASSENGER SIDE FRONT SEAT BELT DISENGAGED, WHICH CAUSED THE PASSENGER TO SUSTAIN BRUISES TO THE CHEST. THE DEALER HAS NOT INSPECTED THE VEHICLE AND THE INSURANCE COMPANY HAS NOT YET DETERMINED IF THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 86,000. *UPDATED 12/12/07 *BF MISSOURI ACCIDENT REPORT. UPDATED 12/12/07 *TR

ON JULY 20, 2007 DRIVING HOME FROM WORK IN THE RAIN, ON THE HIGHWAY MY CAR MADE A LOUD NOISE AND I LOST STEERING AND DID EVERYTHING I COULD TO NOT HIT CARS BESIDE OF ME AND THE POOR GUY BEHIND ME FROM CRASHING IN TO ME. CALLED MY HUSBAND WHO CAME AND PICKED UP THE HARMONIC BALANCE OFF THE HIGHWAY, LIFTED THE HOOD TO FIND A LARGE BOLT (NOW I KNOW CRANKSHAFT BOLT) BROKEN. WHICH I HAVE. I SEARCHED AND FOUND WHERE THERE WERE SEVERAL COMPLAINTS AND THAT KIA WAS GOING TO RECALL. I CALLED KIA ON THE 1ST OF AUG. (CAR HAS BEEN SITTING IN MY DRIVEWAY BECAUSE IT HAS 68000 MILES AND I AM THE SECOND OWNER), WHO HAD MY CAR TOWED TO THE RUSTY WALLACE KIA IN LOUISVILLE, TN. (CHECKED THE MAIL WHEN I CAME HOME AND THERE WAS A RECALL ON CRANKSHAFT BOLTS) IMAGINE THAT. IT IS STILL SITTING THERE AT THE DEALERSHIP. THEY KEEP TELLING ME THE DISTRICT MANAGER IS TRYING TO DECIDE WHETHER OR NOT TO FIX IT. I HAD SPOKEN TO A COUPLE OF TECH'S. AND THEY TOLD ME MY MOTOR WAS GONE. THE BOLT BROKE OFF INSIDE THE MOTOR. KIA IS NOW JERKING ME AROUND. I HAVE HAD TO PUT OFF VACATION AND MY HUSBAND AND I ARE SHARING A VEHICLE WHICH IS COSTING ME A FORTUNE IN GAS BECAUSE WE WORK IN OPPOSITE DIRECTIONS AND I WORK ABOUT 30 MILES FROM MY HOME. CAN NOT GET ANY HELP. I HAVE RESEARCHED AND FOUND HUGE COMPLAINTS ABOUT THIS. KIA HAS KNOWN ABOUT THIS. *JB

IN SEPTEMBER, 2006, AT APPROXIMATELY 55200 MILES, THE AIRBAG FAILURE LIGHT CAME ON. DIAGNOSIS BY THE DEALER ON 5 SEPT 2006 (INVOICE 107484) REVEALED "ORDERED DRIVERS AIR BAG, FAULT B1346, 1ST STAGE RESISTANCE TO [SIC] HIGH." ON 25 SEPT 2006, AFTER FIRST ORDERING THE WRONG PART(INVOICE 107945), THE DEALER REPLACED THE DRIVER-SIDE AIR BAG (INVOICE 108174). ON 31 JULY 2007, AT APPROXIMATELY 59200 MILES, THE AIR BAG WARNING LIGHT CAME ON. THE CAR WAS BROUGHT TO THE DEALER ON 1 AUGUST, AND ON 2 AUGUST THE DEALER REPLACED THE AIR BAG. THE DEALER INVOICE INDICATES "56910R00 REPLACED DRIVERS SIDE AIR BAG. RESISTANCE TO [SIC] HIGH." (INVOICE 119075). ON THE MORNING OF 3 AUGUST 2007, AT APPROXIMATELY 59220 MILES, THE AIRBAG WARNING LIGHT CAME ON. THIS CAR HAS NEVER BEEN INVOLVED IN A COLLISION. THE AIR BAGS HAVE NEVER BEEN DEPLOYED. THE CAR HAS LESS THAN 60,000 MILES ON IT AND IS ONLY 4-1/2 YEARS ONLY. DESPITE THE DRIVER-SIDE AIRBAG BEING REPLACED TWICE, THE CAR IS INDICATING FOR THE THIRD TIME THAT THE DRIVER-SIDE AIRBAG HAS FAILED. *JB

NO WARNING OF FAILURE. HAPPENED AT 61000 MILES 1000 OVER WARRANTY. CRANKSHAFT BOLT BROKE , AND THE MECHANIC SAD HE NEVER SAW SOMETHING LIKE THIS. SO I THINK KIA SHOULD BE RESPONSIBLE ..HE GOT THE PARTS FROM KIA, AND ON 7/15/07 THE BOLT CAME OFF AGAIN WHILE CAR WAS IN PARKING LOT OF WIFE'S WORK PLACE. KIA SHOULD FIX IT . I WAS PLANNING ON GETTING A MINI VAN, AND IT WON'T BE A KIA, DEPENDING ON WHAT THEY DO ABOUT MY SERENTO. *AK

I WAS DROPPING OFF SOMEONE AT WORK WHEN THE CAR MADE A THUMP AND ALL THE DASH WARNING LIGHTS CAME ON. I DROVE IT HOME ABOUT TWO MILES AWAY, AND TOOK IT TO A AUTOMOBILE SERVICE CENTER THE NEXT DAY. THEY TOLD ME THAT THE CRANKSHAFT PULLEY WAS READY TO FALL OFF. THE NEXT DAY I HAD IT TOWED FROM THE SERVICE CENTER TO THE DEALER. THE DEALER SAID THE SAME THING AS THE SERVICE CENTER, AND THAT IT WAS UNDER WARRANTY. ALSO, IT A NEEDED A 60000 MILE SERVICE FOR WHICH I PAID EXTRA. WHEN I WENT TO PICK THE CAR 5 DAYS LATER THE CAR WAS MAKING A BELT NOISE, IT WAS SLOW IN STARTING, THE DASH LIGHT WOULDN'T COME ON, AND THE AIRBAG LIGHT WAS ON. WHEN I TOOK IT BACK TO THE DEALER, THEY TIGHTENED THE BELTS AND CHECKED THE OTHER PROBLEMS AT A COST OF $150, AND THAT THESE OTHER PROBLEMS WERE NOT UNDER WARRANTY, AND WOULD COST $1400 TO FIX THEM. I HAVE NEVER HAD A PROBLEM WITH THIS CAR UNTIL THE CRANKSHAFT PULLEY FAILED, AND COULD NOT SEE WHY IF A WARRANTY FAILURE CAUSED SOMETHING ELSE TO FAIL, WHY WASN'T IT FIXED UNDER WARRANTY? ALSO, THE PERSON WHO WORKED ON THE CA RCOMPLAINED ABOUT THE OIL PAN WITH THE SEALER THAT WAS USED TO SEAL THE ENGINE.*AK

BOTH REAR INTERIOR DOOR PANELS AND LIFTGATE ARE RUSTING OUT ON VEHICLE THAT IS 1.5 YEARS OLD (AND GARAGE KEPT). KIA STATES THEY HAVE A "5-YEAR/50K MILE BUMPER-TO-BUMPER WARRANTY" FOR POOR CRAFTSMANSHIP & FAULTY MATERIALS. APPARENTLY, A BRAND NEW VEHICLE RUSTING OUT DOESN'T MEET KIA'S DEFINITION AS COVERED UNDER WARRANTY AND WILL NOT FIX IT. KIA'S WARRANTY IS OVERSTATED. NO VEHICLE (EVEN ONE'S BUILT INTO 1950'S RUST OUT WITH IN A YEAR. POOR MATERIALS....LOUSY WARRANTY. *TR

LAST FEB. THE COOLANT RESERVOIR CRACKED, LOST ALL COOLANT. TOWED TO DEALER. THEY FIXED IT AND TOLD ME THAT I NEEDED A NEW BELT. I DIDN'T WANT ANYTHING MORE TO HAPPEN AS I TAKE MY 90 YEAR OLD MOM AROUND, THEY REPLACED ONE BELT FOR $120. NEVER RAN RIGHT AFTER THAT, WITH SCREECHING NOISES AND NO MORE A/C. TODAY, JUST AS I WAS DRIVING ONTO THE HIGHWAY-I STARTED LOSING MY STEERING AND I IMMEDIATELY PULLED OVER OFF THE RAMP, THEN IT STALLED AS I WAS PULLING OVER. I HAVE READ ABOUT THIS HAPPENING TO A LOT OF PEOPLE AND WAS JUST WAITING FOR IT TO HAPPEN. WELL IT DID AND THANK GOD I WASN'T GOING 70 ON THE HIGHWAY YET. IT HAS BEEN TOWED TO DEALER AND THEY SAID IT WAS THE BOLT ON THE DRIVE SHAFT THAT BROKE. THEN HE SAID THAT SINCE I'M ONLY 8000 MILES AWAY FROM 60K, THEN I SHOULD JUST DO THE TIMING BELT SERVICE NOW BECAUSE IF I DON'T AND IT GOES, THEN MY ENGINE WILL BLOW. SO I GUESS THIS IS WHAT I HAVE TO WAIT TO HAPPEN NEXT AND I'M SURE IT WILL. THOUSANDS OF PEOPLE CAN'T BE WRONG. DON'T BUY A KIA!!!!!!!!!!!!! *TR

TL*THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING 45 MPH, THE CRANK SHAFT FAILED AND THE VEHICLE WAS TOWED. THE TOTAL COST OF THE RENTAL EXPENSE WAS $600. THE CONTACT STATED THAT WHEN THE CRANKSHAFT FAILED, HE WAS STRANDED. THE KIA DEALER CLAIMED TO HAVE REPAIRED THE VEHICLE. THERE ARE NO WARNING INDICATORS PRESENT WHEN THE FAILURE OCCURS. THE MANUFACTURER STATED THAT THEY COULD NOT BE OF ASSISTANCE. THE VEHICLE WAS REPAIRED UNDER WARRANTY. THE CURRENT MILEAGE IS 48,000 AND FAILURE MILEAGE WAS 40,000. THE CONSUMER STATED THE REPAIR WAS COVERED UNDER RECALL, SINCE A RECALL WAS ISSUED, HOWEVER HE IS REQUESTING REIMBURSEMENT FOR THE RENTAL CAR. THE RADIATOR ASSEMBLY WAS REPLACED DUE TO A LEAK AT THE LOWER SEAM. UPDATED

CRANKSHSFT PULLEY BOLT BROKE ON 2003 KIA SORENTO V6 MODEL. THIS CAUSED LOSS OF POWER STEERING IN VEHICLE. *AK

TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT AFTER HE GETS AN OIL CHANGE, THE VEHICLE'S EXTERIOR AND INTERIOR LIGHTS BLOW OUT. AS OF MAY 17, 2007, THE DOME LIGHT IS CURRENTLY OUT AND HAS BEEN SINCE NOVEMBER 25, 2005. KIA MOTORS STATED THAT EVEN THOUGH HER VEHICLE WAS UNDER WARRANTY, SHE STILL HAD TO PAY FOR THE REPAIR COSTS. KIA ALSO STATED THAT IN ORDER TO KEEP HER WARRANTY, THE CONTACT WOULD NEED TO PAY $1,000 PLUS THE REPAIR COSTS. THE DEALER AND THE MANUFACTURER HAVE NOT PROVIDED A SATISFACTORY EXPLANATION AS TO WHAT IS CAUSING THE FAILURE. THE FAILURE HAS OCCURRED APPROXIMATELY EIGHT TIMES. SHE STATED THAT THE BATTERY HAD TO BE REPLACED EVEN THOUGH IT WAS ALSO STILL UNDER WARRANTY. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 62,000 AND FAILURE MILEAGE WAS 34,600. THE DEALER STATED GAS PEDAL STICKS WHEN ACCELERATING . THE CONSUMER STATED SHE HD TO PURCHASE 2 BATTERIES. UPDATED 06/07/07 *TR

COOLANT TANK CRACKED. CALLED KIA AND THEY SAID THAT IT WAS NOT COVERED BY WARRANTY BUT THAT THE PART HAD BEEN RE DESIGNED. SO I GUESS THERE WAS A PROBLEM WITH THE TANKS. BUT KIA WOULD NOT COVER THE REPLACEMENT OF THE DEFECTIVE TANK.*AK

"THE BATTERY AND BRAKE LIGHTS WERE ON THE DASHBOARD. ALSO, THE VEHICLE LOST POWER STEERING. OPENED THE HOOD AND THE ENGINE AREA AND FOUND THE ALTERNATOR BELT FELL OFF ITS PULLEY. THE POWER STEERING BELT RAN OFF THE ALTERNATOR BELT. THIS WAS WHY THE VEHICLE HAD NO POWER STEERING. CHECKED THE CRANK SHAFT PULLEY, AND FOUND THE CRANK SHAFT PULLEY HAD PLAY, AND THE CRANKSHAFT BOLT BACKED OUT OF PLACE. KIA HAS A PIT STOP HIGHLIGHT , STATING THAT THE CRANK SHAFT BOLT BACKED OUT OF PLACE DUE TO IMPROPER TORQUE SETTINGS ON THE CRANK SHAFT BOLT. HIGHLIGHT KT2006042501. REMOVED THE RADIATOR TO GAIN ACCESS TO THE CRANK SHAFT PULLEY. REMOVED THE CRANK SHAFT PULLEY AND INSPECTED. FOUND THE CRANK SHAFT SPROCKET PIN SHEARED OFF DUE TO THE CRANK SHAFT PULLEY BACKING OUT PLACE. THE CRANKSHAFT SPROCKET HOLDS THE PULLEY IN PLACE. THE CRANK SHAFT PULLEY, SPROCKET, AND BOLT WILL HAVE TO BE REPLACED. REMOVED THE TIMING BELT AND TO REPLACE THE SPROCKET. INSTALLED EVERYTHING BACK IN PLACE AND STARTED THE VEHICLE. OIL WAS NOW LEAKING FROM BEHIND THE TIMING COVER. REMOVED ALL PARTS AGAIN TO GAIN ACCESS TO THE TIMING BELT. FOUND OIL WAS LEAKING FROM BEHIND THE TIMING SPROCKET. REMOVED THE SPROCKET, AND FOUND THE CRANK SHAFT RUBBER SEAL HAD SIGNS OF WEAR AND WAS SLIGHTLY BENT. REPLACED THE CRANK SHAFT RUBBER SEAL, AND REINSTALLED SPROCKET AND TIMING BELT. STARTED VEHICLE, AND NO SIGNS OF LEAKS WERE NOTICED. ROAD TESTED VEHICLE , AND VEHICLE DROVE PROPERLY. THE OWNER COMPLAINED AND QUESTIONED THE RESULT O

AS I WAS DRIVING DOWN THE FREEWAY, THE ENGINE STALLED AND ALL LIGHTS ON THE DASH CAME ON. I WAS ABLE TO PULL TO SAFETY (JUST BY SHEER LUCK) AND CALLED KIA 1-800 FOR TOWING SERVICE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP. I WAS INITIALLY TOLD THAT THE TIMING BELT WAS MALFUNCTIONING. SUPPOSEDLY THE ANALYZER SHOWED THAT THERE WERE "MULTIPLE MISFIRES. I WAS ASKED IF THE CAR WAS MISSING PRIOR TO THE STALL. I TOLD THEM IT RAN AS SMOOTH AS SILK. I AUTHORIZED THEM TO REPLACE THE TIMING BELT DESPITE THE FACT THAT IT HAD BEEN REPLACED AS PART OF SCHEDULED MAINTENANCE TWO MONTHS EARLIER. THE DEALERSHIP THEN CALLED AND TOLD ME THEY HAD "GOOD NEWS AND BAD NEWS". THE TIMING BELT WAS REPAIRED BUT IT APPEARED THE HEAD WAS BLOWN AND THAT KIA REFUSED TO PAY FOR REPAIRS BECAUSE THE OVERFLOW BOTTLE WAS CRACKED. THEY STATED THAT THE HEAD BLEW BECAUSE THE ENGINE OVERHEATED AND WAS CAUSED BY MY NEGLIGENCE. THE GAUGES NEVER INDICATED THAT THE CAR OVERHEATED. THEY ARE UNABLE TO TELL ME HOW MUCH THE REPAIRS WILL COST BECAUSE THERE MAY BE FURTHER DAMAGE ONCE THEY TEAR IT DOWN. THE ESTIMATE IS BETWEEN $2500 AND "WORE CASE SCENARIO" $4700 I AM FURIOUS. THE CAR IS NOT YET FOUR YEARS OLD AND STILL HAS 36,000 MILES LEFT ON THE WARRANTY. *JB

I HAVE NOW HAD THE CRANK SHAFT PULLEY BREAK 3 TIMES, THE ENGINE AND OTHER PARTS HAVE HAD TO BE REPLACED DUE TO THIS. IT MAKES THE VEHICLE SUDDENLY INOPERABLE AND UNSAFE.*AK

TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING THE STEERING WHEEL LOCKED AND COULD NOT TURN LEFT OR RIGHT. THE MECHANIC STATED THAT A BOLT AND BALANCER DETACHED FROM THE HINGES. THE CONTACT SUGGESTED THAT THE POWER STEERING MAY HAVE BEEN LOW IN FLUID. THE CURRENT AND FAILURE MILEAGE WERE 79,000.*AK

CRANKSHAFT PULLEY BROKE OFF. KIA DEALER RECOMMENDS ENGINE REPLACEMENT. COST WOULD BE $7000. RESEARCHING THIS TOPIC FIND OTHERS WITH SAME SITUATION. THIS IS A SERIOUS SAFETY PROBLEM. THE POWER STEERING BECOMES INOPERABLE AND THE POWER SHUTS OFF WHILE DRIVING. *JB

CUSTOMER WOULD LIKE TO KNOW IF ANY PENDING SAFETY RECALLS OR INVESTIGATIONS FOR THE 2003 KIA SORENTO**CC *JB

I OWN A 2003 KIA SORENTO LX. I USED IT MAINLY TO GO FROM HOME TO WORK. THIS HAPPENED 2 DAYS AGO, MARCH 16, 2006, AT 32247 MILES. WHILE MAKING A RIGHT TURN FROM A STOPLIGHT, I HAD COMPLETE LOSS OF VEHICLE CONTROL, IT WOULD NOT LET ME STOP IT AND I COULD NOT CONTROL THE STEERING WHEEL, IT KEPT TURNING SHARPLY TO THE RIGHT, AND I LANDED ON THE SIDEWALK. LUCKILY, IT HAPPENED WHEN I WAS JUST ENTERING MY NEIGHBORHOOD, GOING AT MODERATE SPEED, AND THERE WERE NO CARS BESIDES OR BEHIND ME. TO THINK IF I WERE DRIVING 65-70 MPH ON THE HIGHWAY AND HAVE THIS HAPPENED AND LOSE CONTROL, I WOULD HAVE BEEN DEAD. BUT IT IS THE SECOND TIME IT HAPPENS IN 3 1/2 YEARS. THE FIRST TIME WAS ABOUT 1 1/2 YEAR AGO, BUT I DID NOT PAY ATTENTION TO IT SINCE I THOUGHT IT WAS DUE TO WET CONDITIONS. I WAS ENTERING THE MULTI-LEVEL PARKING LOT WHERE I WORK. I WAS GOING UP TO THE 4TH FLOOR WHERE I PARK, AND WHEN I TURNED LEFT ON THE 3RD FLOOR, THE CAR WENT OUT OF CONTROL, KEPT GOING ROUND, AND I COULD NOT STOP. LUCKILY AGAIN, IT WAS SO EARLY IN THE MORNING THAT THERE WERE NO CARS IN THAT FLOOR. SURELY, A SAFETY-RELATED DEFECT EXISTS. WHAT HAPPENED FRIDAY ALMOST GOT ME KILLED. IT HAS HAPPENED ONLY TWICE IN ALL THESE YEARS, BUT, NO MATTER WHAT HAPPENS, I WILL NEVER FEEL SAFE ON THIS CAR AGAIN. I CANNOT TAKE ANY OTHER CHANCE OF BEING KILLED BECAUSE OF A CAR'S DEFECT. I WILL BE NOW USING MY HUSBAND'S CAR TO TRAVEL BACK AND FORTH TO WORK. BESIDES THAT BIG PROBLEM, I HAVE ENCOUNTERED OTHER PROBLEM WITH MY SORENTO. THE

I WOULD LIKE TO MAKE A COMPLAINT ABOUT MY 03 KIA SORENTO. I BOUGHT THIS CAR USED IN 2004. MY HUSBAND CALLED KIA TO CHECK TO SEE IF THE WARRANTIES WHERE TRANSFERABLE AND THE REPRESENTATIVE TOLD HIM THEY WERE. SINCE I HAVE HAD THIS VEHICLE, I HAVE HAD TO REPLACE THE REAR TAIL/BRAKE LIGHTS 3 TIMES, I HAVE HAD TO REPLACE THE COOLANT BOTTLE, MY ROTORS WERE VIBRATING WHEN I BRAKED SO I HAD THEM SURFACED AND NOW THEY VIBRATE AGAIN. MY BLOWER FAN HAS GONE OUT AND NOW MY CRANKSHAFT BOLT HAS BROKE LAST WEEK. THE VEHICLE IS CURRENTLY AT THE DEALER. I DIDN'T BUY AN EXTENDED WARRANT BECAUSE I WAS UNDER THE IMPRESSION THAT THE ENGINE, TRANSMISSION ECT WAS COVERED UP TO 100,000 OR 5 YEARS, WHICH I WAS INFORMED THAT IT WAS ONLY FOR THE ORIGINAL OWNER. AT FIRST, I WAS JUST THINKING THAT IT WAS JUST MY BAD LUCK, UNTIL I STARTED RESEARCHING IT ON THE INTERNET AND DISCOVERED THAT MANY PEOPLE SEEM TO BE HAVING THE SAME PROBLEMS AS I AM AND THAT IS ONLY THE THOSE OF USE WHO ACTUAL POST IT ON THE INTERNET, I AM SURE THAT THERE ARE PROBABLY MANY MORE THAT ARE NOT REPORTED. AT THIS TIME, I DON'T EVEN KNOW HOW MUCH THIS IS GOING TO COST ME AT FIRST THE DEAL TOLD ME $765.00, THEN THEY SAID MAY BE $3700.00. I THINK IT IS RIDICULES THAT SO MANY PEOPLE ARE HAVING A PROBLEM WITH THE CRANKSHAFT BOLT BRAKING OFF AND RUINING THE MOTOR OF A VEHICLE THAT IS 3 YEARS OLD AND KIA HAS NOT DONE ANYTHING ABOUT IT. I ALSO HAVE SEEN THAT MANY PEOPLE HAVE HAD THERE COOLANT BOTTLE LEAKING, AGAIN LIKE MINE, BUT THEY HAVE

2003 KIA SORRENTO - CONSTANTLY REPLACING HEADLIGHTS AND TAIL LIGHTS. RECENTLY STARTED EXPERIENCING INTERIOR LIGHTING PROBLEM. LIGHTS COME ON AND WILL NOT GO OUT DURING DRIVING AND WHILE HEAT IS ON. DASH LIGHTS GO OUT AND WILL NOT COME ON - NO ASSISTANCE FROM THE DEALERSHIP. *JB

I HAVE HEARD ABOUT THE CRANKSHAFT BOLTS BREAKING OFF IN THE KIA SORENTO'S. THAT IS A MAJOR SAFETY PROBLEM, AND I AM SCARED TO DRIVE MY 2003 OVER 45 MILES AN HOUR. MY SERVICE DEPT, DICK EDWARDS KIA, INFORMED ME TO HAVE THEM CHECK THE TORQUE ON THE BOLT EVERYTIME I GO IN FOR SERVICE. KIA SHOULD OWN UP TO THIS PROBLEM AND NOT HAVE ITS OWNERS SCARED TO DRIVE IT. *JB

2003 SORENTO EX PURCHASED NEW. REPLACED THE LEFT FRONT ROTOR ABOUT 3 MONTHS AGO, BUT BREAKING HAS RETURNED TO SIGNS OF A WARPED ROTOR AGAIN. VIBRATION IN THE STEERING WHEEL WHEN BRAKES ARE APPLIED AND LOUD NOISE IN FRONT WHEEL AREA (NON-METAL) SOUND. CAR HAS NEW BRAKE PADS AND RECENT ALIGNMENT. ROTORS ARE NOT LASTING. *NM

2003 KIA SORENTO WOULD LOOSE POWER STEERING ASSISTANCE WHEN TRANSITIONING FROM MODERATE SPEEDS (30-50 MPH) TO LOW SPEED (5-10 MPH), SUCH AS WHEN EXITING A HIGHWAY BY SLOWING IN A CENTER TURNING LANE AND TURNING LEFT IN FRONT OF ONCOMING TRAFFIC. FIRST OCCURANCE WAS AT 19,000 MILES (SEPT 2003), KIA DEALER WAS UNABLE TO REPLICATE PROBLEM AND RETURNED THE VEHICLE TO ME. PROBLEM CONTINUED INTERMITTENTLY UNTIL 30,000 MILES (MAY 2004) WHEN I RETURNED TO DEALER AND THEY DISCOVERED A TSB ON THIS ISSUE. DEALER REPLACED P/S SENSOR AND LOADED IMPROVED SOFTWARE CODE. THERE WERE A NUMBER OF NEAR COLLISIONS DUE TO THIS FAILURE. *NM

2003 KIA SORENTO WITH HISTORY OF POWER STEERING FAILURES WHICH RESULTED IN NO POWER STEERING ASSISTANCE WHILE TURNING AT LOW SPEEDS. PROBLEM FIXED MAY 2004 (AFTER THEE VISITS TO DEALER) ALTHOUGH TSB IDENTIFYING CORRECTIVE ACTION WAS ISSUED A YEAR EARLIER. STEERING RACK FOUND TO BE SEEPING FLUID DURING ANNUAL INSPECTION AT 63,760 MI. TAKEN TO DEALER AT 70,000 MILES FOR EVALUATION. DEALER ADVISED THAT SEALS NOT SERVICEABLE, STEERING RACK AND HOSES REQUIRE REPLACEMENT AT COST OF $2000 - NOT COVERED UNDER WARRANTY. KIA CUSTOMER SERVICE ADVISED THAT STEERING RACK COVERED UNDER WARRANTY UNTIL 60,000 MI; NOT PART OF 100,000 MI POWERTRAIN WARRANTY. I HAVE BEGUN A SEARCH FOR A NEW VEHICLE, AND KIA PRODUCTS AREN'T ELIGIBLE FOR CONSIDERATION. *NM

I DRIVE A 2003 KIA/SORENTO/4D. ON OR ABOUT DEC 15 2006 I NOTICE A LOUD NOISE AN SERVER VIBRATION COMING UNDER VEHICLE. I TOOK SUV TO FAMILY MECHANIC. HE COULD NOT FIND PROBLEM AND RECOMMENDED THAT I TAKE VEHICLE TO KIA DEALER. ON DEC 27 2006 KIA DEALER TECH INITIAL DIAG READS 4X4 IS STAYING ENGAGED ALL THE TIME. SUSPECTED SWITCH FAILURE. THEREFORE FRONT DIFF STAYING ENGAGED ALL THE TIME. THIS HAS CAUSED INTERNAL DAMAGE TO FRONT DIFF AND FRONT PROPELLER SHAFT. ESTIMATE COST TO REPAIR/2,775.00 I AM AT A LOST CAUSE VEHICLE IS NO LONGER UNDER WARRANTY, BUT I FEEL BECAUSE 4X4 RELEASE/ENGAGE SWITCH FAILURE THAT I SHOULD NOT HAVE TO ENDURE THE FINANCIAL BURDEN. REPAIRING THIS MANUFACTURES DEFECT. *JB

2003 KIA SORRENTO-THERE HAS BEEN NO CRASH==THE DRIVE LINE FROM THE REAR MAKES A NOISY THUMP ALMOST EVERY TIME I STEP ON THE BRAKES AND RELEASE THEM--KIA SERVICE IN MIDDLETOWN, NY SERVICE MANAGER AND KIA ZONE REP STATE THAT IS NORMAL OPERATION OF VEHICLE--I DISAGREE AND INFORMED THEM I WILL BE TAKING VEHICLE TO ANOTHER MECHANIC,I HAVE BEEN DRIVING FOR 34 YEARS AND NEVER ENCOUNTERED THIS SITUATION IN A VEHICLE. *JB

TL* - THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP THREE TIMES CONCERNING THE HORN NOT WORKING. EVERY TIME HE TOOK SIT TO THE DEALERSHIP THEY STATED THAT THEY FIXED THE PROBLEM, BUT THE FAILURE RECURRED ON AND OFF. *AK

A SCREW THAT HOLD THE CRANK SHAFT & THE TAMPER GET BROKEN WHILE I WAS DRIVING TO MY HOUSE. THE DEALER IN PUERTO RICO SAID THAT I HAVE TO PAY$2,521.00 TO FIX IT. BUT I HEARD FROM AN INSURANCE AGENT THAT KIA WAS TOLD BY SOME GOVERNMENT AGENCY, I THINK THAT AGENCY IS NHTSA; TO MODIFY THE SCREW INVOLVED IN MY INCIDENT, CAUSING THE LOST CONTROL OF MY SORENTO. THE STEERING GET HARD TO MOVE.

DT*: THE CONTACT STATED WHILE ATTEMPTING TO TURN ON THE DEFOGGER/DEFROST SYSTEM, THE HEATER FAILED TO OPERATE, AND NO HEAT WAS PRESENT. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED ANTIFREEZE FLUID LEAKED OUT OF THE RESERVOIR TANK BECAUSE IT WAS FRACTURED AND NEEDED TO BE REPLACED. THE REPLACEMENT PARTS WERE NOT AVAILABLE AT THE DEALER, AND THE MANUFACTURER WAS ALERTED, WHO CONFIRMED THE PARTS WERE NOT AVAILABLE. THE DEALER INSTRUCTED THE CONTACT TO MONITOR THE LEVEL OF ANTIFREEZE FLUID DAILY AND ADD MORE ANTIFREEZE IF NEEDED.

FIRST INCIDENT - CAR STALLED AND FLUID STEAMED FROM THE HOOD. IT HAD TO BE TOWED AFTER SEVERAL RESTARTS TO DRIVE TO THE DEALER. THE COOLANT RESERVOIR WAS CRACKED. THIS PART IS ON NATIONAL BACKORDER AND I HAVE SO FAR BEEN WAITING APPROX. FOUR WEEKS FOR THE PART. THE DEALER SAID KIA HAS HALTED MANUFACTURING/DISTRIBUTING THE PART JUST FOR NEW CARS AND REQUESTED THAT THE PARTS BE SHIPPED TO THE DEALERS FOR REPAIR INSTALLATIONS. THE DEALER CUSTOMER SERVICE IS GREAT AND I HAVE NO COMPLAINT ABOUT THE DEALER. *NM

I HAD A 1 YEAR OLD BATTERY REPLACED, WHICH WAS DEFECTIVE (NON-KIA DEALER). AFTERWARDS, I NOTICED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. KIA DEALER SAID IT WAS DUE TO A BAD SENSOR ($300 PART, $300 LABOR). IT WAS TOO EXPENSIVE FOR ME TO PURSUE CORRECTING. I TOLD THE DEALER TO FORGET THE REPAIR. *NM

ENGINE AND COOLING SYSTEM. *JB

WHERE DO I START?....WELL NOT LONG AFTER WE GOT THE PIECE OF JUNK WE HAD TO TAKE IT TO THE KIA DEALER BECAUSE THE ENGINE LIGHT KEPT COMING ON, THEY SAID IT WAS BECAUSE THE GAS CAP WASN'T BEING TWISTED ENOUGH AND AIR GOT IN. WELL FOR ABOUT 2 WEEKS THE ENGINE LIGHT STAYED OFF, WE TOOK IT BACK NUMEROUS TIMES BUT IT KEPT COMING BACK ON. THEN ON ONE OCCASION I WAS STRANDED ABOUT 40 MILES FROM HOME...THE CAR WAS DEAD, WE HAD IT TOWED TO THE DEALER, ALL THE BELTS HAD COME OFF, THEY TRIED TO MAKE EXCUSES WHY KIA WOULDN'T FIX IT UNDER THE WARRANTY, THANK GOD WE WON THAT BATTLE...KEEP IN MIND, THE ENGINE LIGHT IS STILL ON AT THIS POINT. NOW THIS YEAR THE HEATER WON'T STAY HOT AFTER ABOUT 30 SECONDS IT TURNS COLD, AS COLD AS THE AIR. THEN WITH NO WARNING THE CAR OVER HEATS AND DIES ON ME. WE HAVE IT TOWED TO THE DEALER THEY SAY IT IS MY FAULT BECAUSE WHEN I SEEN THE LIGHT COME ON I SHOULD HAVE PULLED OVER, "THE LIGHT NEVER GOES OFF" KIA WON'T FIX IT UNLESS WE PAY FOR IT, AND THE COST IS $10,000. WE HAVE ONE YEAR LEFT AND IT WOULD BE PAID OFF...LESS THAN $7,000 AND NOW THIS. I AM SO ANGRY, THIS IS NOT RIGHT. I THINK THE KIA COMPANY NEEDS TO BE INVESTIGATED. SOMETHING NEEDS TO BE DONE THEY ARE RIPPING EVERYONE OFF. TAKING MONEY FROM WORKING PEOPLE AND SCAMMING THEM. THEY ARE NO BETTER THAN THIEVES AND LIARS. THEY ARE SELLING A PRODUCT ALONG WITH A PROMISE TO SERVICE IT SHOULD SOMETHING GO WRONG BUT NOT HONORING THAT PROMISE. OH AND DID I MENTION THE HEAD LIGHTS ARE ALWAYS GOING OUT? *JB

DT*: THE CONTACT STATED WHILE TRAVELING 35 MPH, WITHOUT WARNING THERE WAS A LOSS OF POWER. THE VEHICLE WAS PULLED OVER AND THEN TOWED TO THE DEALERSHIP, WHO REPLACED THE CRANKSHAFT. THE PROBLEM RECURRED FIVE WEEKS LATER AND THE VEHICLE WAS TOWED A SECOND TIME. THE DEALERSHIP PUT LOCK SPRAY IN TO KEEP THE PIN ON THE CRANKSHAFT FROM FALLING OUT.

1) UPON PURCHASE, EXHAUST SMELL WAS STRONG INSIDE SUV, LEADING TO HEADACHES AND QUEASINESS. 2) TOOK IT IN WITHIN WEEKS (?) 3) A CORRECTION WAS MADE, PART REPLACED. SINCE THEN, THE EXHAUST SMELL IS INTERMITTENT, AND NOT AS STRONG. SERVICE DOES NOT SEE FURTHER ISSUE. *JB

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS A NOISE AND A VIBRATION WAS NOTICED. UPON FURTHER INSPECTION, UNUSUAL WEAR ON THE INNER TREAD OF THE FRONT TIRES WAS ALSO NOTICED. THE VEHICLE WAS DRIVEN TO THE DEALER WHO COULD NOT DUPLICATE THE PROBLEM. UPDATED 9/11/2006 - THE LEFT FRONT STRUT WAS NOISY DUE TO LOOSE BOTTOM STRUT BOLT. THE DEALER TIGHTENED END AND SECURED BOLT. THE CONSUMER FELT VIBRATION IN BRAKE PEDAL WHEN REVERSING AND MAKING TURNS. THE DEALER RESURFACED THE BRAKE ROTORS AND PADS. THE VIBRATION RETURNED. THE DEALER INDICATED THAT THE ROTORS WERE WARPED AND REPLACED THEM. THE VEHICLE'S ENGINE MADE NOISE. THE DEALER ADJUSTED ALL THE BELTS. THE CD PLAYER WOULD NOT EJECT PROPERLY. *NM

I AM THE ATTORNEY FOR THREE MINOR CHILDREN. THEY WERE SERIOUSLY INJURED, AND THEIR FATHER WAS KILLED IN A ROLLOVER IN LAS VEGAS, NEVADA IN FEBRUARY, 2006. THE REAR B.F. GOODRICH TIRE ON THE 2003 KIA SORENTO THAT THE FATHER WAS DRIVING BLEW OUT AND SEPARATED, RESULTING IN THE ROLLOVER. THE TIRE WAS APPARENTLY PLUGGED THE DAY BEFORE AT A LAS VEGAS TIRE SHOP. *JB

VEHICLE IS A 2003 KIA SORENTO WITH 70,000 MILES, PURCHASED NEW. VEHICLE APPEARS TO HAVE SERIOUS ELECTRICAL ISSUES. I HAVE, TO DATE, REPLACED LIGHT BULBS APPROXIMATELY 38 TIMES. THIS INCLUDES HEAD LIGHT BULBS (HIGH AND LOW), FOG LIGHT BULBS, TAIL LIGHT BULBS AND BRAKE LIGHT BULBS. ALSO THE CLOCK ONLY WORKS INTERMITTENTLY AND THE POWER SUN ROOF HAS CEASED WORKING. DEALER OFFERS NO SOLUTION. THIS HAS BEEN ONGOING SINCE THE FIRST MONTH OF OWNERSHIP. *NM

THE RESERVOIR ON MY 2003 KIA SORENTO RUPTURED AND ALL THE COOLANT LEAKED OUT WHILE I WAS DRIVING. I PULLED OFF THE HIGHWAY AND INTO A GAS STATION AND THE LET THE CAR COOL. I THEN ADDED IN ANTI- FREEZE AND FILLED IT WITH WATER AND DROVE ANOTHER 10 MILES AND DROPPED THE CAR AT A REPAIR SHOP. THE NEXT DAY THE CAR WOULD NOT START. THE KIA DEALERSHIP IS SAYING IT IS NOT COVERED UNDER WARRANTY. *JB

I HAVE HAD MY KIA SORENTO FOR ALMOST A YEAR AND I HAVE REPEATEDLY HAD TO CHANGE THE HEADLIGHTS AND TAIL LIGHTS. AT LEAST 8 TIMES FOR THE HEADLIGHTS AND 4 FOR THE TAIL. *NM

WHILE DRIVING ON SATURDAY, 7/15/06, I NOTICED A HIGH PITCHED NOISE WHILE STEERING. I WAS UNDER THE IMPRESSION THAT THE POWER STEERING FLUID WAS LOW. AFTER HAVING AN OIL CHANGE AND CAPPING OFF MY FLUIDS, THE NOISE CONTINUES AND REMAINS WHILE DRIVING. IT IS LOUD ENOUGH TO HEAR OVER THE RADIO AND THE AIR CONDITIONER AT THE SAME TIME. I HAVE PLACED THIS CAR IN THE SHOP FOR NUMEROUS REPAIRS SINCE ITS PURCHASE IN 2003 AND HAVE SPENT COUNTLESS AMOUNTS OF MONEY ON VARIOUS PROBLEMS, INCLUDING REPLACING THE BULBS, REPAIRING THE BRAKS, THE CHECK ENGINE LIGHT COMING ON IMMEDIATELY AFTER PURCHASE, THE AIR BAG SENSOR REMAINS ON AND THE LIST GOES ON AND ON. I HAVE PLACED NUMEROUS COMPLAINS TO KIA DIRECTLY AS WELL AS FILED A COMPLIANT WITH THE BETTER BUSINESS BUREAU TO NO AVAIL. IT WOULD BE MY ASSUMPTION THAT KIA WILL ONLY BE CONCERNED ABOUT FIXING THESE ISSUES OR RECALLING THESE VEHICLES ONLY AFTER SOME SERIOUS INCIDENTS HAVE OCCURRED.

I PURCHASED MY 2003 KIA SORENTO WITH 17,000 MILES ON IT. I AM THE SECOND OWNER. SINCE I HAVE HAD THIS CAR, I HAVE HAD TO REPLACE AND/OR RESURFACE MY ROTORS AND BRAKE PADS AT LEAST 6 TIMES IN TWO YEARS. I HAVE TALKED TO TWO KIA DEALERSHIPS (ONE IN CLARKSVILLE, TN - THE OTHER IN MEMPHIS, TN) AND BOTH LIED TO ME AND SAID THEY DIDN'T SEE THAT TYPE OF PROBLEM EVER. I HAVE TAKEN MY CAR TO TWO OTHER MECHANICS THAT I TRUST AND THEY HAVE TURNED MY ROTORS, REPLACED MY ROTORS WITH GENUINE KIA PARTS AND NOTHING SEEMS TO HELP. JUST THIS WEEK, I HAD TO TAKE MY CAR IN AGAIN. AT THAT TIME, MY MECHANIC TALKED TO OUR LOCAL KIA DEALERSHIP, WHO THEN TOLD HIM THAT THEY NOW SEE THIS PROBLEM FREQUENTLY. I AM TIRED OF SPENDING MY OWN MONEY ON THIS PROBLEM THAT IS OBVIOUSLY A KIA DEFECT. KIA KNOWS THIS IS A PROBLEM AND SOMETHING NEEDS TO BE DONE. I WILL NEVER BUY A KIA AGAIN. I ONLY WISH I HAD RESEARCHED THIS PROBLEM BEFORE I BOUGHT MY CAR. THEN I WOULD HAVE FOUND OUT THAT THERE WAS A CLASS ACTION LAWSUIT AGAINST KIA AT ONE TIME OVER THEIR SEPHIA HAVING THE SAME EXACT PROBLEMS. MY HUSBAND HAS A 1995 FORD RANGER AND WE'VE NEVER HAD TO DO ANY BRAKE REPAIR.

DT*: THE CONTACT STATED WHILE DRIVING 65 MPH THERE WAS A SCREECHING NOISE THAT CAME FROM THE ENGINE. THE DEALER DETERMINED THAT THE BOLT ON THE DRIVE SHAFT PULLEY HAD SHEARED OFF AND THAT THE CRANK SHAFT NEEDED TO BE REPLACED. THE MANUFACTURER HAS BEEN ALERTED. UPDATED 7/13/2006 - *NM

DT*: THE CONTACT STATED THE HORN WORKS INTERMITTENTLY. THE VEHICLE HAS BEEN TO THE DEALER FIVE TIMES FOR THE PROBLEM. THE FOURTH TIME, THE DEALERSHIP REPLACED THE DRIVER SIDE AIRBAG, WHICH DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER HAS BEEN ALERTED. THE VEHICLE IS A 2003 KIA SARENTO.*AK