Owners filed 1 complaints about this vehicle with federal regulators, most often about the electrical system. It has been recalled 3 times.
What fails
Component
Reports
Crashes
Fires
Injuries
Electrical System
1
0
0
0
3 safety recalls
Part 573 reports
Vehicle Speed Control10V267000
Filed Jun 15, 20102,085 vehiclesNavistar, Inc
Defect. NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 INTERNATIONAL TRUCKS AND IC COMMERCIAL BUSES MANUFACTURED FROM DECEMBER 4, 2001 THROUGH DECEMBER 14, 2009 EQUIPPED WITH INTERNATIONAL VT365 ENGINES HAVING ENGINE CALIBRATION PAN2PVR0, PAN2PVR1, OR PAN2PWR. THE ENGINE NORMALLY RESPONDS TO A FAILED OPEN ACCELERATOR POSITION SENSOR CIRCUIT FAULT BY RETURNING THE ENGINE TO LOW IDLE SPEED OF 800 RPM AND DISABLING THE DRIVER'S ABILITY TO INCREASE THE ENGINE SPEED. HOWEVER IF THE OPEN CIRCUIT CORRECTS ITSELF WITHIN 30 SECONDS OF INITIATION, ENGINE SPEED COULD SUDDENLY INCREASE TO A HIGH IDLE SPEED OF 1200 RPM.
Risk. THIS INCREASE TO HIGH IDLE SPEED MAY OCCUR WITHOUT WARNING CAUSING A SUDDEN AND UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy. NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.
Service Brakes, Hydraulic10V104000
Filed Mar 16, 201087 vehiclesNavistar, Inc
Defect. NAVISTAR HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 AND 2011 IC CE, HC, AND BE COMMERCIAL BUSES AND INTERNATIONAL 1300, 3200, 3300, 4100, 4200, 4300, 4400, AND MXT TRUCKS MANUFACTURED FROM NOVEMBER 19, 2003 THROUGH FEBRUARY 9, 2010. THE PARKING BRAKE MAY RELEASE IF THE BRAKE SYSTEM ELECTRONIC CONTROL UNIT (ECU) SOFTWARE MISINTERPRETS INPUT SIGNALS GENERATED FROM CYCLING THE IGNITION SWITCH MORE THAN ONCE AT A SPECIFIC FREQUENCY.
Risk. RELEASE OF THE PARKING BRAKE MAY CAUSE SUDDEN, UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL DAMAGE, OR DEATH.
Remedy. NAVISTAR WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES BY REPROGRAMMING THE VEHICLE'S BRAKE SYSTEM ECU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 14, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890.
Defect. ON CERTAIN TRUCKS, ONE OR BOTH REAR AXLE HOUSINGS MAY CONTAIN THINNER MATERIAL THAN WHAT IS NECESSARY FOR NORMAL VEHICLE OPERATION. OVER TIME, THIS THINNER MATERIAL MAY RESULT IN A FATIGUE FAILURE OF THE REAR AXLE HOUSING, POSSIBLY IN THE LOCATION OF THE BRAKE FLANGE.
Risk. A CRACK IN THE BRAKE FLANGE LOCATION OF THE REAR AXLE HOUSING MAY RESULT IN A WHEEL END LOCKUP OR WHEEL SEPARATION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy. DEALERS WILL INSPECT THE VEHICLE'S REAR AXLES AND, IF NECESSARY, REPLACE THE AXLE HOUSINGS. THE RECALL BEGAN ON MAY 18, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7815.
What owners reported
Newest filings
Electrical System
Filed May 29, 2014AZ
ENGINE START HARNESS HAS A 40 AMP FUSE INSTALLED IN A 30 AMP RATED FUSE HOLDER. HOLDER WILL OVER HEAT (MELT) WITHOUT BLOWING FUSE, CAUSING THE METAL CONTACTS TO CHAR / LOOSEN,CAUSING AN OPEN RUN CIRCUIT, WHICH CAUSES THE ENGINE TO STALL. THIS CAN HAPPEN AT ANY TIME, IDLE, RUNNING IN STOP AND GO TRAFFIC AND AT FREEWAY SPEEDS. WHEN THIS OCCURS YOU LOOSE ALL ENGINE BASED ASSIST, ELECTRICAL, POWER STEERING,LIGHTING. NAVSTAR (INTERNATIONAL) HAS ADDRESSED THIS ISSUE ON SCHOOL BUS CHASSIS, BUT SAYS THE PROBLEM DOESN'T EXIST ON APPROXIMATELY 250 CHASSIS SOLD TO GULF STREAM MOTORHOMES FOR FITTING OF THE COACH. THE DEALER FIX IS TO REPLACE THE FAILING FUSE HOLDER WITH THE SAME FAILING PART UNTIL WARRANTY EXPIRES,THEN THEY RECOMMEND THE REPLACEMENT WIRING HARNESS PROVIDED TO SCHOOL BUS OWNERS AT NO COST, FOR A COST OF APPROX. $600 PARTS AND LABOR.THIS FUSE ASSEMBLY HAS BEEN REPLACED BY INTERNATIONAL 2 TIMES AND I HAVE REPLACED IT TWICE MYSELF. I ALWAYS CARRY SPARES AS I HAVE EXPERIENCED A FAILURE LAST JULY IN SOUTHERN ARIZONA IN 107 DEGREE HEAT. *TR
No unusual pattern of severe incidents in the complaint record.
Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.
Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.
Most recent recall on file: Jun 15, 2010. Source: NHTSA Office of Defects Investigation.