International Truck & Engine Corporation: Suspension › Rear › Axle › Non-powered Axle Assembly
International Truck & Engine Corporation reported this defect to federal regulators on Apr 24, 2007 and put the number of vehicles at risk at 1,172. The repair is free for as long as the recall stands.
The defect
ON CERTAIN TRUCKS, ONE OR BOTH REAR AXLE HOUSINGS MAY CONTAIN THINNER MATERIAL THAN WHAT IS NECESSARY FOR NORMAL VEHICLE OPERATION. OVER TIME, THIS THINNER MATERIAL MAY RESULT IN A FATIGUE FAILURE OF THE REAR AXLE HOUSING, POSSIBLY IN THE LOCATION OF THE BRAKE FLANGE.
The risk
A CRACK IN THE BRAKE FLANGE LOCATION OF THE REAR AXLE HOUSING MAY RESULT IN A WHEEL END LOCKUP OR WHEEL SEPARATION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
The remedy
DEALERS WILL INSPECT THE VEHICLE'S REAR AXLES AND, IF NECESSARY, REPLACE THE AXLE HOUSINGS. THE RECALL BEGAN ON MAY 18, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7815.
24 model years covered
Newest firstWhat this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 07V179000.
Full record for the 2008 International 4200 → · Recalls carrying a do-not-drive advisory → · Where this data comes from →