2000 International Harvester 3800

Defect. ON CERTAIN SCHOOL BUSES AND TRUCK MODEL VEHICLES MANUFACTURED BETWEEN FEBRUARY 28, 1999, THROUGH APRIL 5, 2004, THE ANTI-LOCK BRAKE SYSTEM ELECTRONIC CONTROL UNIT (ECU) MAY MISINTERPRET A CORRUPT WHEEL SPEED SIGNAL.

Risk. THE CORRUPT WHEEL SPEED SIGNALS MAY IMPROPERLY ACTIVATE THE ABS, INSTEAD OF DEACTIVATING THE ABS. THIS MAY RESULT IN THE DRIVER EXPERIENCING A HARD PEDAL FEEL AND A DECREASE IN DECELERATION AT THE END OF THE STOP, RESULTING IN EXTENDED STOPPING DISTANCES WHICH COULD CAUSE A VEHICLE CRASH, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy. INTERNATIONAL WILL NOTIFY ITS CUSTOMERS AND INSPECT AND REPAIR THE AFFECTED VEHICLES FREE OF CHARGE. THE RECALL BEGAN AUGUST 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL CUSTOMER SERVICE AT 1-800-327-4236.

Defect. ON CERTAIN SCHOOL AND TRANSIT BUSES BUILT WITH BOSCH ZERO OFFSET PIN SLIDE (ZOPS) HYDRAULIC DISC BRAKES, THE ZOPS HYDRAULIC DISC BRAKES MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION, WHICH CAN RESULT IN EXCESSIVE OR ABNORMAL HEAT GENERATION AT ONE OR MORE OF THE BRAKES.

Risk. THE COMBINATION OF THE FOLLOWING FACTORS MAY COLLECTIVELY RESULT IN AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY: POTENTIAL FIRE AT A WHEEL END, HIGH INCIDENT RATES OF STUCK CALIPERS, AND EVACUATION AND CONTAINMENT CONCERNS RELATING TO MULTIPLE PASSENGERS.

Remedy. INTERNATIONAL WILL NOTIFY ITS CUSTOMERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN OCTOBER 29, 2004.

Defect. VEHICLE DESCRIPTION: SCHOOL/TRANSIT BUSES AND MEDIUM DUTY TRUCKS. THE CASTINGS USED ON THE POWER STEERING PUMPS WERE NOT BUILT TO MATCH THE ENGINEERING DRAWINGS, RESULTING IN A THIN WALL IN THE PUMP CASTING OR A COMPLETE CONNECTION OF TWO PASSAGES THAT ARE SUPPOSED TO BE SEPARATED TO CONTROL FLUID FLOW. THE FLUID FLOW MAY BE REDUCED TO LESS THAN THE MINIMUM REQUIRED FLOW RATE TO PROVIDE FULL POWER ASSIST TO THE BRAKE SYSTEM WITH LOW ENGINE SPEED.

Risk. AN INCREASE IN STOPPING DISTANCE AT SLOW ENGINE SPEEDS CAN RESULT, INCREASING THE POSSIBILITY OF A CRASH.

Remedy. DEALERS WILL INSPECT AND REPLACE ALL PUMPS THAT HAVE THE DEFECTIVE CASTING NUMBERS.

DURING AN INSPECTION THE TECHNICIAN FOUND DISCOVERED THAT THE PASSENGER SIDE FRONT CALIPER HAD FROZE AND ALSO FOUND SIGNS OF OVERHEATING. THE TECHNICIAN REPAIRED AND REPLACED RIGHT CALIPER AND INSTALLED A PAD SET. *MR *CB *NLM

THE BRAKES OVERHEATED. THE TECHNICIAN REPLACED AND REPAIRED THE FRONT PADS, CALIPERS AND ROTORS. *MR *CB *NLM

DURING INSPECTION THE RIGHT REAR PADS ON THE VEHICLE WERE WORN EXCESSIVELY, AND THERE WERE SIGNS OF OVERHEATING ON THE CALIPER AND WHEEL. *MR CB* *JB

PROBLEMS WITH VEHICLE'S FRONT AND REAR BRAKE OVERHEATING. EXCESSIVE DRAG ON PADS AND CALIPERS. REPORTED PROBLEM TO MECHANIC. *MR *CB *JB

WE OWN 7 VEHICLES THAT ARE EXPERIENCING SIMILAR PROBLEMS AND HAVE THE POTENTIAL OF AN ADDITIONAL 13 POSIBLE. NO SAFETY DEFECT LISTED.*AK

PROBLEM WITH ABS LIGHT STAYING ON. ADJUST AND REPLACE SENSOR SEVERAL TIMES, TO NO AVAIL.

INTERMITTENT LIGHT ON DASH, INDICATING ANTI - LOCK BRAKE SYSTEM IS NOT FUNCTIONING. *AK

THE POWER STEERING PUMP (LUK #LF73C) FAILED ON FOUR OCCASIONS CAUSING LOSS OF POWER STEERING WHILE MAKING LEFT OR RIGHT TURNS UPON ACCELERATION - ENGINE RPM INCREASED, BUS #69. NLM

THE POWER STEERING PUMP (LUK #LF73C) FAILED ON FOUR OCCASIONS CAUSING LOSS OF POWER STEERING WHILE MAKING LEFT OR RIGHT TURNS UPON ACCELERATION, BUS #62. NLM