2004 GMC Safari

Defect. CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Risk. THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy. HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Defect. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk. WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy. PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

TL* THE CONTACT OWNS A 2004 GMC SAFARI AWD. THE CONTACT WAS DRIVING APPROXIMATELY 3-5 MPH AND COMING TO A STOP WHEN THE ABS ACTIVATED ABNORMALLY AND CAUSED THE BRAKES TO PULSATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED THE CONTACT THAT THE HUBS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000. UPDATED 03/23/12 *BF UPDATED 04/09/12

TL*THE CONTACT OWNS A 2004 GMC SAFARI. THE CONTACT STATED THAT THE VACUUM HOSE FAILED IN HER VEHICLE. SHE TOOK THE VEHICLE TO A MECHANIC, WHO DISCOVERED A HOLE IN THE AIR CONDITIONING LINE. THE FAILURE WAS CAUSED BY THE AIR CONDITIONING LINE RUBBING AGAINST THE FUEL LINE. THE MECHANIC STATED THAT THE REPAIR FOR THE AIR CONDITIONING LINE WOULD COST BETWEEN $800-$1,000. SHE WAS ADVISED TO CALL THE MANUFACTURER BECAUSE THE DEFECT APPEARED TO BE WEAKENING THE FUEL LINE. THE MANUFACTURER STATED THAT THERE WAS NO RECALL FOR THE ISSUE AND REFERRED HER TO NHTSA. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 134,000.

THE REAR END WAS MAKING A NOISE AND WAS TAKEN TO THE CAR DEALER CHECKED THE VEHICLE. THE DEALER SAID THAT THE PROBLEM WAS WITH THE CARRIER BEARINGS AND THE RING & PINION (FACTORY DEFECT). THE VEHICLE HAS BEEN MAKING THIS NOISE SINCE IT WAS PURCHASED AND THE WARRANTY WILL NOT COVER REPAIRS. THE COST IS ESTIMATED TO BE 1500.00 DOLLARS. WE HAVE SENT IT TO THE DEALER ON 3 DIFFERENT OCCASIONS AND THEY SAY THE WARRANTY REFUSES TO PAY FOR THE REPAIRS. *TR

STEERING WHEEL OF 2004 GMC SAFARI IS RAPIDLY DECAYING. NO CLEANING CHEMICALS HAVE BEEN USED ON THE STEERING WHEEL. I WORK IN AN OFFICE, SO THERE ARE NO EXTRAORDINARY CHEMICALS ON MY HANDS. *NM

WHILE PARALLEL PARKING VEHICLE TURNED 90 DEGREES TO THE LEFT WITHIN TWO-CAR LENGTHS. VEHICLE HAD BEEN TO THE DEALER ON FOUR OCCASIONS. DEALER CHECKED THE TIRE PRESSURE, DID A COMPLETE WHEEL ALIGNMENT, AND ROTATED THE TIRES. BUT, PROBLEM STILL RECURRED. *AK