2017 Ford Fusion complaints

Shortly after turning on the car, the check engine light came on, but the car seemed to be running normal. After about 5 minutes, the wrench light came on. When this happened, I was unable to accelerate and the transmission was having difficulty shifting. I pulled over to the side to restart the engine to see if it would reset, and it did not. On the way to the dealership, the situation got worse, in terms of acceleration. After diag optics were run, it was determined the throttle body needs replacing.

I left work, got into my car, turned the car on and the airbag light turned on, now the light is always on

2017 Ford Fusion Ex with the 2.0L Ecoboost engine. Check Engine Light came on (around 85,000 miles on the car - Jan 2023). Car is misfiring. Ford dealership diagnosed the issue as Coolant leaking into the engine block (which is causing the misfire). Dealership said to immediately stop driving the car due to coolant issue could overheat the engine (possible fire risk). Research on internet shows this is a widely reporting defect where coolant is leaking into the engine block. Fix is to install an entire new engine. Ford unwilling to admit defect due to extreme cost of having to replace engines. Cost of new engine installation is $7000 plus. Having a defective engine block that allows coolant to leak into the cylinders is a clear defect with multiple people having the same issue. I understand there was the same issue with another version of the Ecoboost engine on the fusion and a recall was done for that. A recall needs to be initiated for the 2.0L Ecoboost engine on the 2017 Fusions have the same serious coolant leaking into he engine block issue. Car being brought to Akins Ford in Winder GA for repairs on 03/31/23.

The contact's daughter owns a 2017 Ford Fusion. The contact stated that after starting the vehicle, the check engine warning light was illuminated. Additionally, the contact stated that the vehicle was experiencing excessive coolant consumption. The contact used a personal OBD reader to retrieve a DTC code for cylinder #2 misfire. The vehicle was taken to an independent mechanic, where it was diagnosed that the failure was related to Ford Technical Service Bulletin Number: 22-2229. The mechanic referred the contact to the dealer for additional diagnostic tests and repairs. The vehicle was taken to the local dealer, where it was diagnosed that the Engine Long Block and its subcomponents needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 88,000.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was sputtering. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the cylinders, causing a misfire in cylinder #2. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 120,000.

The contact owns a 2017 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

THE CAR WOULD NOT START DUE TO THE THROTTLEBODY FAILED TO OPERATE. LUCKILY, THE CAR WAS PARKED WHEN THIS OCCURED AND HAD TO BE TOWED TO NEAREST FORD DEALER. WHO INFORMED ME IF I HAD BEEN DRIVING AND IT HAD FAILED DURING OPERATION, CAR WOULD HAVE COME TO A DEAD STOP WHILE DRIVING AND/OR IN MY CASE FAILED TO START. THEY SAID THROTTLEBODY GIVES THE ENGINE THE AIR IT NEEDS TO PREFORM. WE WERE OUT OF TOWN AND DUE TO DRIVE ON A MAIN HIGHWAY FOR TWO HUNDRED MILES AT 70MILES PER HOUR! I HAVE INCLUDED INVOICES FROM THE FORD DEALER, INVOICE FROM AUTO DEALER- WHO HAD REPAIRS DONE ON CAR, AND THE CARFAX REPORT-THAT DID NOT SHOW ANY THROTTLEBODY RECALLS OR REPAIRS, NOR DID THE AUTO DEALER'S REPORT. THE CAR WAS CERTIFIED FOR 21,953 MILES BY THE STATE OF FLORIDA AND CARFAX. HOW IS THAT A CAR'S THROTTLEBODY WOULD FAIL AFTER 21,000 MILES, UNLESS IT WAS ALREADY DEFECTIVE IN THE BEGINNING!?? THE REPORTS INDICATE THE VEHICLE WAS A 1 OWNER CAR AND 21,953 MILES WITH PASSING THRU TWO SYSTEMS AND NEVER DETECTED. I HAD ONLY OWED THE CAR FOR 61 DAYS UNDER 24,000 MILES WHEN IT FAILED!

I had both a check engine light and wrench power train light come on. My vehicle was emitting white smoke from the exhaust and a sloshing water sound in my dash behind the steering wheel. My car has 96,000 miles on it and is serviced regularly. I had it at the dealership in Dec 2022 for an oil change and they didn’t indicate any issues. By Jan 2023 my car needs a new engine.

Upon trying to stop at a stop sign my son was unable to stop in time and rolled into the roadway which caused a collision with another vehicle. He depressed the brakes and clearly heard a grinding noise and never felt the pumping feeling under his foot for the antilock breaks. He thought he couldnt stop due to ice on the roadway, but have since seen the brake recall on my vehicle. The accident caused the vehicle to become a total loss. The witnesses said my son stopped at the stop sing and pulled into the roadway in front of car going 50mph. That could not have happened by the angle of the car at the time of the accident. Had he stopped like the 'witnesses" said, he would have entered the roadway a couple second later and then become t-boned by the other car. He was hit on the rear quarterfinal coinciding with my sons story he could not stop. My son has held to his story that he tried to stop and the car would not stop. I have felt on occasion since Dec my brakes feeling a little off at times but never on a consistant basis to get it looked at. My vehicle had a small leakage in Dec which we could not locate and it never occurred since. We checked the brake fluid and all fluids routinely since. Never seen the leak since. I also put four brand new tires on my vehicle two days prior to the accident. It does appear in the photos after the accident there were new parts on the wheel in the area of the brakes. I only owned this vehicle for 9 months prior to this incident.

My transmission shift linkage is broken and keeps detaching from the transmission shift lever. According to the recall that is already out there for this issue, 2014-2016 Ford fusions are covered. My vehicle was manufactured in 2016 but is a 2017 model year. As such its using the affected parts but not part of the recall. The cost to repair it is well outside what I can afford.

The contact owns a 2017 Ford Fusion. The contact stated that the coolant level was low, and the engine was overheating. The contact stated that the check engine warning light was intermittently illuminated. The contact took the vehicle to a certified mechanic who diagnosed that the engine was misfiring. The contact was referred to the dealer. The vehicle was taken to the dealer who diagnosed that the coolant was leaking into the cylinders and that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 149,000.

The contact owns a 2017 Ford Fusion. The contact stated while having a routine oil change performed on the vehicle, the mechanic noticed that coolant was leaking into the engine, and that cylinders #2 and #3 were miss firing. The spark plugs were replaced; however, the failure reoccurred. On another occasion, while attempting to start the vehicle, the vehicle would not start, with the check engine warning light illuminated. An independent mechanic diagnosed the vehicle and stated that the timing belt was worn and that the timing belt needed to be replaced. The vehicle was not repaired. The dealer was contacted but offered no assistance. The manufacturer was contacted, and the manufacturer stated that the vehicle was out of warranty. The failure mileage was 139,000.

While sitting in a fast food, drive-through line, I heard a pop and my brake pedal pressed all the way to the floor and the brakes completely failed and r he car started to roll forward. There was no warning. There was nothing wrong with the brakes whatsoever but all the pressure on the brake pedal and the brakes failed. after getting out of the fast food line, I parked in the parking lot of the restaurant and checked under the hood and there was brake fluid everywhere on the passenger side of the engine compartment. There was no brake fluid inside of the brake fluid compartment. On Monday, 3/13/2023. I had the vehicle towed to a mechanic shop to look at I have yet to get a response on what the problem is. Not less than five minutes before getting in the fast food drive-through line I was driving on the freeway. Had this had happened on the freeway. I probably wouldn’t be here talking to you making his complaint.

The contact owns a 2017 Ford Fusion. The contact stated upon starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the short block needed to be replaced. The dealer informed the contact that the vehicle could not be repaired under Ford Campaign Number: 21N12; because the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 64,000.

Front driver and passenger seat belts do not lock or retract. Mine and my children life are at risk because it’s a safety issue, and requirement to have a seatbelt worn while driving but as well having a proper working seatbelt. Yes, the car is currently at the dealer now which confirmed it does not work properly. No warning lights came on to let me know that the seat belt was malfunctioning.

The contact owns a 2017 Ford Fusion. The contact stated that while attempting to start the vehicle, the transmission selector could not be shifted from park to drive. Upon inspection, the contact discovered that the transmission shift cable bushing had detached. The contact was able to reattach the shift cable bushing, but the failure persisted. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 65,000.

This is for a 2017 Ford Fusion Platinum. Lug nuts have deformed and have to replaced at ~63,000miles. Why? Shops do the regular rotation and balance. I had a 2013 Ford Fusion Titanium and had the same results at different shops for the same rotation and balance. Why? My father's 1978 F100 had 430,000+ and were original. Quality is now poor. Les Schwab looked and said they needed to be replaced now. We can't check the torques.

On July 21, 2022 I was driving my 2017 Ford Fusion I was driving on route 95 when my car started to over rev and began shaking, then I lost complete engine power. I nearly getting ran off the road from the cars behind me. Thank goodness I was in the right-hand lane when this incident happened. I had my 2017 Ford Fusion towed to Purvis Ford service center in Fredericksburg Virginia. The tech called me letting me know that my torque converter has failed and needs to be fixed. The cost was going to be $6,250 plus $200 diagnosis fee. I was made aware of the recall on the Fusions torque converter failure. I was told my Vin number isn't a part of the recall. I believe my car needs to be a part of this recall everything stated in the recall description my vehicle had done. What do I need to do to continue to get my vin number on this national recall.

The contact’s son owns a 2017 Ford Fusion. The contact stated that while his son was driving at an undisclosed speed, the vehicle hesitated and the engine misfired. The check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant had leaked into cylinder #3, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was transferred to the NHTSA Hotline. The failure mileage was approximately 58,000.

The TCM (Transmission Control Module) is faulty in this vehicle causing unstable gear shift that slow and stop the vehicle making it extremely unsafe to drive. I've been made aware Ford employees are familiar with this issue in the 2017 Ford Focus yet I have seen no attempt by Ford to contact owners (me) to address and fix this issue.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle stalled, the check engine warning light then illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.

I was driving my 2017 Ford Fusion it lost power to the engine. The car just revs when you hit the gas, the transmission failed. I was nearly ran off the road on route 95 back in July 2022, thank goodness I made it to the shoulder. I had my car towed to Ford service center and was made aware of the recall on the torque converter, also was informed that my vehicle isn’t a part of the recall. I find it very odd that my car has been doing everything that the recall is explaining.

The contact owns a 2017 Ford Fusion. The contact stated that when attempting to shift gear there was a warning light and a message stating that shifter failure and “Shift Assist Fault, See Manual”. The contact depressed the brake pedal while moving the gear shifter for the gear shifter to function properly. The failure reoccurred intermittently and had since increased in frequency. The contact stated that several attempts were needed for the gear shifter to properly register the desired gear. The contact stated that the vehicle occasionally shifted into reverse independently. The contact took the vehicle to the dealer who confirmed that the failure was related to NHTSA Campaign Numbers: 22V413000 (Power Train), 19V362000 (Power Train), 18V471000 (Power Train) and 18V169000 (Power Train) related to the shifter cable bushing. The contact was informed that the VIN was not included in the recalls. The shifter cable bushing and cap was replaced. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 85,400.

The bushing that attaches transmission shift cables disappeared. The car flashed "shift sys fault" and kept turning on the emergency brake and disabled the engine from starting. After googling the warning, I found an article about the recall from ford and what the problem was. After finding a picture of the problem I was able to verify that the bushing was gone and cable was detached. Once the cable was reattched, the car functioned correctly. Unfortunately my car was not part of the 2022 recall for this malfunctioning part

Failure of shifter cable bushing, which has been documented as recall in 2016 model but not yet for 2017

I got in my 2017 Fusion SE to leave my house. As I started out of my driveway, I noticed that the steering was hard and I had a " Steering Assist Fault, Service Required" lamp on. I did not drive the car that day. The car drove fine the day before. I called my local mechanic to take my car into the shop to have him check the vehicle. As I drove the vehicle to the shop, I noticed that it was very hard to steer and the steering made a grinding noise. The shop called later and advised that the rack and pinion sensor was bad and needed replacing. The shop advised that the only way to repair it was to replace the rack and pinion. My mechanic advised that he has seen this problem with other 2017 Ford Fusions. The shop advised that the cost would be $3000.00. I was shocked at the cost, but I authorized the repair. The mileage on the vehicle was 39,650. I am just thankful that I was not driving the car on the road at the time that this went bad. There was no warning with this. I did look on this web sight and found that this is not an uncommon problem with the 2017 Fusions. I believe that because the sensor cannot be replaced on its own, that Ford should fix this dangerous problem and do a recall. How long until this happens a second time? Should I sell this vehicle before it happens again? I just hope I am not driving the next time the sensor goes out.

The Shifter Cable Bushing disintegrated on my 2017 Ford Fusion, causing it to not shift into drive while parking my car. This did not result in damage or an accident, but the car was stuck in gear, and I could not move the car. I was told there is no recall for my car on this, but there is on others. I had to get it repaired at my own cost. The issue could cause more problems with similar cars like mine. A warning on my dash told me there was a problem with the shifter mechanism and that the car wasn't in gear. If the car had been in neutral at the time of the problem, it could have rolled away, with me thinking that the car was in park.

DEFECT IN LEFT DRIVER REAR LIGHT.. WHEN IT RAIN WATER GOES INTO THE TRUNK TIRE AREA BECAUSE OF THE SEAL AROUND LIGHT

The contact owns a 2017 Ford Fusion. The contact stated while driving 75 MPH, the vehicle started shaking uncontrollably with the check engine warning light illuminated. The contact stated that she was able to drive the vehicle to her residence and later had the vehicle towed to the dealer. The dealer diagnosed the vehicle and determined that coolant was leaking into cylinder #2 and that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: 22-2134 which expired on November 30, 2022, and the contact experienced the failure on December 1, 2022. The contact stated that the dealer and the manufacturer denied the repair because the TSB had expired. The approximate failure mileage was 107,300.

Over the past 6-8 months, I have replaced the front passenger brake line two times and the front driver side brake line once. If needed, I have receipts showing I have purchased brake fluid and new brake lines on three separate occasions in recent months. I have pictures of the most recent brake line failure. On all three occasions the brake lines have split/burst, I’ve had no warning the brakes are failing or losing fluid or pressure. The low brake fluid light does not come on till minutes after the brakes fail. don’t know there’s a problem till I try to stop and the pedal goes straight to the floor. Right before the brake pedal hits the floor, there’s minimal braking power and you can gradually slow down. The last time this happened I was on the PA turnpike outside of Pittsburgh traveling 70mph. This was extremely unsafe, I thought for sure I was going to cause a major accident as I could not the stop the car in rush hour traffic.

My 2017 Ford Fusion suddenly has a brake fluid leak and all fluids have been previously checked on a routine basis. My brakes suddenly wouldn’t work while driving and trying to come to a stop and I had to pull on my emergency brake and then put in park as it will not stop completely while sitting at a red light or intersection. I have read the multiple complaints that have been reported with this problem and I am also reporting this issue with my 2017 Ford Fusion as well!

Was told all 20 Lug Nuts were swollen and needed replacing. After paying $219.80 and researching this I saw that numerous people were compiling about having to pay for something that Ford created and is a know major issue for. I then cam upon this site & form.

On 12/08/2022, my 2017 Ford Fusion started as normal in a busy parking lot, but once I idled/moved just a little, it became locked as if the emergency brake was on (it was not) and would not shift out of park, regardless of trying to put in neutral, reverse, etc. (It would show N or R on the dash, but remained deadlocked in Park.) There was this error message: "SHIFT SYS FAULT Service Required." It took several people to push the car to a safe area out of the way of traffic. Had to have the car towed at owner's expense to the closest Ford dealership. There were not other messages or signs of the problem prior to this failure on 12/08/2022. Ford dealer on 12/10/2022 removed and replaced transmission shifter cable bushing and installed cap. Ford dealer agreed that most certainly, this 2017 Ford Fusion has the EXACT same recall #22s43 that other 2017 Fusions have had. However, when Ford dealer entered this vehicle VIN, nothing showed up in OASIS. So I had to pay for this repair out of pocket. Like others have stated, the Ford recall #22s43 is too narrow in scope. So why in the world am I having to pay 100% of the cost to fix the EXACT SAME bushing/cap issue (recall 22s43) that others are having with the EXACT SAME YEAR, MAKE, & MODEL?!?! Just because my VIN wasn't included in Ford's original recall? DOES NOT MAKE SENSE! If it's the same issue as the other vehicles are having (of the same year, make, model) why am I paying for the error and they aren't?

The contact owns a 2017 Ford Fusion. The contact stated while driving 35 MPH, the temperature gauge showed that the engine was overheating. The message “Engine Overheating – Stop Vehicle” was displayed. The vehicle was towed to the dealer to be diagnosed; however, no failure was found. The contact stated that the coolant reservoir was empty. The contact stated that coolant was added; however, the failure recurred. The contact stated that on another occasion while exiting her driveway, the vehicle failed to properly accelerate. The vehicle was taken to an independent mechanic, and he stated that the vehicle was experiencing a failure like the failure listed in Customer Satisfaction Program: 21N12. The vehicle was not repaired. The contact made several attempts to schedule an appointment; however, none of the dealers would assist. The contact stated that another dealer informed her that the Customer Satisfaction Program was no longer valid. The manufacturer was not contacted. The failure mileage was 122,150.

Both front windows go down automatically when trying to close the window. Has been fixed at dealer twice. In order to close window, you have to “pulsate” the button to almost closed. If you go all the way up, window goes down. Have had this same issue with other Ford vehicles

The problem is in the gear shifting. The problem is the same problem many others are having on 2017, but are not included in the recall. The recall is Fords number for this recall is 18S08. Several hundreds have filed a complaint but Ford will not expand the recall to include the 2017. This is a safety issue that needs to be addressed by Ford and NHTSA. The current recall effected 650,000 cars but not the 2017 Ford Fusion.

2017 Ford Fusion with only 60k+ miles on it is having engine issues. Coolant leaks into the engine, resulting in a cylinder misfire which can cause an accident and significant engine damage—I now need a whole new engine. I am not the only Ford Fusion owner having this problem—numerous complaints have been made about this same issue. A recall should be issued as it is a defect caused by the manufacturer and the burden to repair or replace should not fall on the owner.

Unknown vehicle needs to be jumped after every drive. i just picked up the car. only have had it for 4 days. have had to jump it twice. it has 61,000 miles on it. i have taken the battery out and in for a charge and tested and it it good was also purchased 7/22. all of the interior screens and lights come on but the start/stop button green light blinks. don't understand why there isn't a recall.

My Motor vehicle shift selector bushing broken out the ford issue is also in the 2017 models

The shift cable bushing, which was covered on other Ford vehicles in a recall issued on 15 June 2022, failed on my 2017 Fusion. This occurred while in a parking lot. The car would not start as it was stuck in reverse. I had the issue repaired at a Ford dealer and it cost me $351. This is a known defect yet it would seem as though the scope of the recall was too narrow. Fortunately, the car did not roll away, however, it was a very busy lot and I was stranded in the middle of it until a tow truck could remove it.

The contact owns a 2017 Ford Fusion. The contact stated that after his son came to a stop at a stop signal, there was a loss of power steering functionality, and the steering wheel became difficult to maneuver. The TPMS warning light was intermittently illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the power steering control module needed to be updated and the steering gear assembly needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 59,250.

My 2017 Ford Fusion , with 58,228 miles on it has a bad engine, which is a known issue, yet not a recall. My engine overheated as I was driving on the expressway. I called Ford, case # CAS040244200, but my powertrain warranty expired 7/22 . Please read what has happened to others while their engine overheats while driving a 2017 Ford Fusion when coolant gets into the cylinder (in my case it's cylinder #3). Also Ford was aware of this issue...TSB# 19-2208, but has yet to place a recall

When putting my car in park, I received a warning "SHIFT SYS FAULT" Confirm Park Brake Apply Before Exiting the Vehicle. My parking brake was never on. When I got back in my vehicle, my gear shift would not let me take put my vehicle into gear. I googled and found it was the gear shift bushing and there was a recall on this part. I was able to take my vehicle to the repair shop and told them there was a recall. They informed me the recall was not for my vehicle because the recall was for automatic transmissions on 2016 and before. How can this exact same part be a recall on an automatic vehicle, but not on an electronic "dial" gear shift?

The contact owns a 2017 Ford Fusion. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact stated that the power train fault warning light was illuminated. The vehicle was not diagnosed. The manufacturer was contacted, and a case was filed. The failure mileage was 65,689.

Which drive home from work one day when my brakes just gave out. Prior to my brakes given out in August. My brakes begin to feel loose. I set my car down for a few months and as recently as December 10 a had my car towed to Ford where they have. Let me know that my front brake lines have malfunction I need to be replaced.

Car wouldn’t shift to park!

The transmission shifting cable bushing has gone bad. My car will not shift into park it’s stuck in neutral. Ford tried transferring but couldn’t. I was instructed to file report online. I have a case number for assistance for repairs.

Seat back broke in a collision.

Purchased vehicle used from a state agency, transmission lurches, won’t go into gears, stays in neutral then launches into gear. Can put transmission into drive but the car won’t move for several seconds, will go into drive without warning.

The transmission failed AGAIN... the Original transmission failed at 75,106 miles and Ford would not replace it even though it was in the batch flagged as having a Transmission issue (assembled in Mexico with my VIN in the range). I filed a report like this for that one as well. I ended up having to pay $4,700 out of pocket the first time. This next time, the replacement transmission failed at 99,108 miles but this time was covered by the replacement transmission warranty (3yr unlimited mileage)