2013 Ford Flex complaints

2013 NA 3.5L FIRED FLEX FUEL PUMP CONTROL MODULE (PART # AA8Z 9D370 B) FAILURE HAS LED TO ME BEING STRANDED 3 TIMES AND CAUSED THE VEHICLE TO STALL TWICE (ONCE WHILE IN MOTION). FORD HAS RECALLED THE 2013-2015 FORD FLEX WITH THE 3.5L ECOBOOST (TURBOCHARGED) ENGINE FOR THE SAME ISSUE (FUEL PUMP CONTROL MODULE FAILURE/REPLACEMENT), AND USES THE SAME PART IN BOTH VEHICLES (PART # AA8Z 9D370 B). VEHICLE FAILED TO START WHEN PARKED 3 SEPARATE TIMES, RESULTING IN IT BEING TOWED TO A DEALERSHIP TWICE. VEHICLE STALLED ONCE WHILE STATIONARY, AND ONCE WHILE IN MOTION WITHOUT WARNING. DEALER INDICATED THAT THE FUEL PUMP CONTROL MODULE IS AT FAULT AND NOT UNDER RECALL. FORD OPENLY RECALLED THE TURBOCHARGED FLEX FOR THE SAME PART THAT HAS FAILED IN THE NATURALLY ASPIRATED VERSION THAT I HAVE.

TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO JACK DEMMER FORD (37300 MICHIGAN AVE, WAYNE, MI 48184, (734) 721-2600) WHERE IT WAS DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE BATTERY WAS REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THERE WAS INSUFFICIENT FUEL PRESSURE GOING TO THE ENGINE, WHICH CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V621000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT RECEIVED CASE NUMBER: TAS13866368. THE APPROXIMATE FAILURE MILEAGE WAS 52,000.

CAR BATTERY DYING. SAID SYNCH LINE IS IN, BUT IT'S NOT. DOOR AJAR LIGHTS FOR BOTH DRIVER AND PASSENGER SIDE ARE ALWAYS ON. WHEN COME TO A STOP, BEEPS AND SAYS ENGINE ON, SHIFT TO PARK. CAN'T LOCK DOORS. HAVE TO MANUALLY LOCK DOORS, OTHERWISE THE ALARM ALWAYS GOES OFF. SO CANNOT LOCK THE HATCH. THIS IS A SAFETY AND THEFT PROBLEM. INTERIOR LIGHTS STAY ON FOR HOURS AT A TIME. CANNOT SEE WHEN BACKING OUT OF PLACES AT NIGHT BECAUSE THE INTERIOR LIGHT IS ON. THIS IS GOING TO CAUSE AN ACCIDENT.

2013 FORD FLEX SE PURCHASED IN DECEMBER 2012 WITH 60,000 MILES IS EXPERIENCING FRONT AND REAR PASSENGER DOOR LATCHING PROBLEMS. THE FRONT PASSENGER DOOR 'DOOR AJAR' LIGHT IS TRIGGERED AFTER THE DOOR HAS BEEN CLOSED. WHEN THIS PROBLEM BEGAN, OPENING AND CLOSING THE DOOR WOULD BE ENOUGH TO ENGAGE THE SENSOR BUT OVER THE PAST MONTH IT HAS NOT BEEN EFFECTIVE. THIS IS A PROBLEM FOR A FEW REASONS: FIRST, IT DOES NOT AUTOMATICALLY LOCK THE DOORS WHEN THE CAR IS IN MOTION WHICH IS A POTENTIAL SAFETY HAZARD UNDER NORMAL DRIVING CONDITIONS OR IF THE VEHICLE WAS TO BE IN AN ACCIDENT. THE DOOR COULD POSSIBLY FLY OPEN DURING A COLLISION LEAVING THE PASSENGERS VULNERABLE TO BEING THROWN FROM THE VEHICLE OR OBJECTS COMING INTO THE VEHICLE. SECOND, THE CABIN LIGHT REMAINS ON WHILE DRIVING WHICH CREATES A GLARE ON THE WINDSHIELD MAKING IT IMPOSSIBLE TO SEE OUTSIDE THE VEHICLE. THIRD, THE CABIN LIGHTS STAY ON AFTER THE VEHICLE IS LOCKED WHICH CAUSES AN UNWARRANTED STRAIN ON THE VEHICLE BATTERY. AS FOR THE BACK RIGHT PASSENGER DOOR, IT IS NOT LATCHING. I FEAR THAT AT ANYTIME THE DOOR MAY COME UNLATCHED WHILE DRIVING. IF THIS PROBLEM CONTINUES AND THE DOOR DOES NOT LATCH, THE VEHICLE WILL BE INOPERABLE. SINCE MY WARRANTY EXPIRED AND THERE ARE NO RECALLS, I AM EXPECTED TO PAY THE PRICE TO MAINTAIN DOOR LATCHES ON A VEHICLE.

TL* THE CONTACT OWNS A 2013 FORD FLEX. AFTER STARTING THE VEHICLE, THE STEERING WHEEL WAS VERY DIFFICULT TO TURN. MOMENTS LATER, WHILE DRIVING, THE "CHECK CHARGING" INDICATOR ILLUMINATED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 109,000.

MY 2013 FORD FLEX HAS DOOR LATCH SENSOR ISSUES. WHEN I AM DRIVING ANYWHERE (CITY, HIGHWAY, INTERSTATE) MY INTERIOR LIGHTS WILL RANDOMLY TURN ON AND I GET A 'DOOR AJAR' NOTIFICATION WHEN THE DOORS ARE CLEARLY CLOSED. IT IS ALARMING AND HAS ALMOST CAUSED ACCIDENTS. WHEN I RESEARCHED THE PROBLEM ONLINE, IT IS AN EXTREMELY COMMON PROBLEM THAT HAS CAUSED NUMEROUS ACCIDENT AND COST FLEX OWNERS THOUSANDS UPON THOUSANDS OF DOLLARS,ONLY TO HAVE THE PROBLEM REOCCUR IN 6 MONTHS TO A YEAR. I RECENTLY CONTACTED MY FORD DEALERSHIP AND THEY TOO ARE AWARE OF THE PROBLEM AND STATED THAT IT IS A VERY COMMON PROBLEM IN FLEX'S AND I WILL PROBABLY HAVE TO REPLACE THE LATCH SYSTEM EVERY 2-3 YEARS. AT $350-500 A LATCH THIS IS A VERY DANGEROUS AND COSTLY PROBLEM TO BE SO COMMON. THE SOLUTION MOST SUGGEST IS TO GROUND THE WIRE GOING TO THE LATCH, WHICH WILL TOTALLY DEFAULT THE SENSOR ALL TOGETHER AND MAKE THE VEHICLE THINK THAT THE DOORS ARE CLOSED AT ALL TIMES, WHICH IS ALSO VERY UNSAFE.

"FORD FLEX POWER STEERING ASSIST FAILURE AND TRAC CONTROL MALFUNCTION. THE EPAS MOTOR ON MILLIONS OF VEHICLES ARE FAILING AND VERY DANGEROUS FOR FLEX OWNERS. I HAVE FOUND THAT FROM RESEARCH ON THIS ISSUE THAT THE EPAS MOTOR IS ACTUALLY OVERHEATING AND BURNING UP THE ELECTRIC MOTOR. FORD MANUFACTURER HAS DELIBERATELY LIED TO NHTSA ABOUT WHAT THE ACTUAL PROBLEM IS. THIS IS A VERY UNSAFE CONDITION FOR WHICH THEY PRESENTED A RECALL ON CERTAIN 2013 VEHICLES. I SPOKE WITH MY LOCAL DEALERSHIP ABOUT THE ISSUE AND THEY RESPONDED THAT MY VIN NUMBER DOES NOT FALL IN THE CAMPAIGN OR TECHNICAL SERVICE BULLETINS. CAMPAIGN FOR THE RECALL IS EXACTLY WHAT IS GOING ON WITH MY VEHICLE BUT YET FORD WANTS TO CHARGE ME MONEY FOR THE REPAIRS AND DIAGNOSTIC WHEN THEY ARE WELL AWARE THAT THIS IS A MANUFACTURER ISSUE. IT IS A VERY UNSAFE CONDITION WHICH HAS KILLED AND INJURED PEOPLE. THEY JUST HAVEN'T GOTTEN TO THE POINT TO WHERE THEY ADMIT THAT IT IS ON WAY MORE VEHICLES THAN THEY ARE ADMITTING TO. I AM VERY DISAPPOINTED THAT NHTSA IS NOT FORCING FORD TO REPAIR THE VEHICLES THAT HAVE THE SYMPTOMS OF THE EXACT RECALL ON A CASE-BY-CASE BASIS AT VERY LEAST. I WAS TRAVELING AROUND 70 MILES AN HOUR DOWN INTERSTATE I-40 WHEN SYSTEM FAILED AND ALMOST FLIPPED MY VEHICLE. HOW CAN A DEALERSHIP NOT BE RESPONSIBLE FOR THIS OR HOW MANY PEOPLE HAVE TO DIE BEFORE THEY DO TAKE RESPONSIBILITY? RECALL NUMBER IS 15 S18 OR 15V340000.

TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE ENTERING THE VEHICLE AND INSERTING THE KEY INTO THE IGNITION, THE VEHICLE WOULD NOT START. THE CONTACT HAD THE VEHICLE TOWED TO REDLANDS FORD INC (1121 W COLTEN AVE, REDLANDS CA 92374) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS AT THE DEALER BEING REPAIRED. THE MANUFACTURER WAS ALSO CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 34,000.

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT THE VEHICLE STALLED THREE TIMES WITHOUT WARNING. ADDITIONALLY, THE VEHICLE WOULD NOT START. THE CONTACT CALLED A LOCAL DEALER (MCDONALD FORD, 6790 MIDLAND RD, FREELAND, MI 48623) AND WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER A RECALL. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND OPENED CASE NUMBER: CAS13638921. THE MANUFACTURER STATED THAT IF THE VEHICLE FAILED, THE CONTACT SHOULD TAKE IT TO A LOCAL DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 75,000.

REPEATED STEERING FAILURES. INITIAL FAILURE (SPRING 2016) OCCURRED SEVERAL MONTHS AFTER COLLISION REPAIR (DECEMBER 2015) DONE AT DEALER SERVICE DEPARTMENT. REPAIRED VEHICLE CAME BACK WITH TIGHTER STEERING THAN PREVIOUSLY EXPERIENCED. FAILURE IN SPRING 2016 INVOLVED COMPLETE LOSS OF POWER STEERING UPON STARTUP OF VEHICLE. SHUT DOWN AND RESTART DID NOT RESTORE POWER STEERING OPERATION. STEERING GEAR REPLACED BY DEALER SERVICE DEPARTMENT. SECOND FAILURE (SPRING 2017) INVOLVED LOSS OF TRACTION CONTROL, STABILITY CONTROL, CRUISE CONTROL DUE TO FAILURE OF POWER STEERING CONTROL MODULE. POWER STEERING CONTROL MODULE REPLACED BY DEALER SERVICE DEPARTMENT. THIRD FAILURE (NOVEMBER 28, 2017) IS LOSS OF POWER STEERING GEAR UPON VEHICLE STARTUP. SHUT DOWN AND RESTART RESTORED POWER STEERING OPERATION.

MY INTERIOR DOME LIGHTS COME ON OFTEN WHEN I ATTEMPT TO DRIVE CAR AT NIGHT MAKING IT IMPOSSIBLE TO SEE. THEY DO GO OFF AFTER I DRIVE FOR A SHORT DISTANCE. THIS VERY DANGEROUS.

THE DOOR AJAR SENSOR ALWAYS THINKS THE DOOR IS AJAR. THIS MEANS THE DOORS WON'T LOCK WHEN THE CAR IS RUNNING, AND THE DOME LIGHT STAYS ON WHEN DRIVING. IT CAN ALSO CAUSE THE ALARM TO GO OFF IF THE CAR IS LOCKED.

PASSENGER SIDE DOORS GIVE FALSE DOOR AJAR NOTIFICATIONS. FIRST OCCURRENCE WAS REPAIRED JUNE 2017. REAR PASSENGER DOOR NOW SHOWS THE NOTIFICATION AS OF NOVEMBER 2017. FALSE NOTIFICATION LEADS TO DOME LIGHTING AND EXTERIOR LIGHTS STAYING ON. BATTERY WAS DRAINED AND REPLACED IN JUNE 2017. DOORS FAIL TO LOCK USING AUTOMATIC DOOR LOCK WHILE IN MOTION. DEALER DETERMINED IT WAS A FAULTY DOOR LATCH ASSEMBLY WHICH SEEMS TO BE IMPACTING OTHER FORD VEHICLES.

POWER STEERING HAS GONE OUT A FEW TIMES IN MY FLEX. FIRST TIME WAS AFTER IT WAS PARKED, THE WHEELS WERE TURNED OUT, IT WAS STARTED, AND IT WAS VERY DIFFICULT TO TURN AND MANEUVER THE VEHICLE IN THE PARKING LOT. SECOND TIME, WAS THIS MIRING, I BACKED OUT OF THE DRIVEWAY, AND WHEN I PUT THE CAR IN DRIVE ON OUR STREET IT WAS AGAIN VERY HARD TO STEER. BOTH TIMES WHEN I TURNED THE CAR OFF AND BACK ON, IT WAS LIKE NOTHING WAS WRONG.

PASSENGER AND REAR PASSENGER DOOR AJAR SWITCHES KEEP COMING ON. THE DOORS WILL NOT LOCK WHEN VEHICLE IS IN MOTION. ALSO WHEN YOU LOCK THE DOOR AFTER USING THE VEHICLE THE LIGHTS INSIDE THE VEHICLE STAY ON.

I WAS DOING A U-TURN ON A CUL DE SAC AND ALL OF A SUDDEN THE STEERING WHEEL JERKED AND THE MOTOR DIED AND WHEN I RESTARTED THE CAR I HAD NO POWER STEERING CAPABILITIES AND THE WARNING LIGHTS FOR THE POWER STEERING CONTROL AND THE ADVANCE TRAC CAME ON AND THE TURN SIGNALS WOULD NOT STAY ON WITHOUT HOLDING THEM IN THE UP OR DOWN POSITION.

OVER THE PAST 6 MONTHS, MY POWER STEERING WOULD FAIL LEAVING ME IN MANUAL MODE. I WOULD STOP AND RESTART THE CAR AND THE POWER WOULD RETURN. I TOOK THE CAR IN THIS WEEK AND IT WILL NOW COST ME $2000 TO REPAIR IT. PRIOR TO TAKING IT TO MY DEALERSHIP, I RESEARCHED POSSIBLE RECALLS. SURE ENOUGH, THERE WAS ONE IN 2015 FOR "CERTAIN" 2013 FORD FLEX. BUT MY VIN WAS NOT IN THE RECALL. I CALLED FORD CUSTOMER SERVICE AND ALL THE REPRESENTATIVE DID WAS READ SCRIPTS TO ME LETTING ME KNOW THAT MY CAR WAS NOT IN THE RECALL. THIS IS THE SECOND THING ON MY CAR THAT HAS GONE WRONG THAT WAS COVERED FOR OTHER "CERTAIN" FLEX--THE FIRST WAS THE FUEL PUMP. DISAPPOINTED THAT IDENTIFIED PROBLEMS ARE NOT COVERED FOR ALL!!!

DOOR AJAR LIGHT COME ON WHILE DRIVING EVEN IF THE DOOR IS CLOSED.

THE REAR PASSENGER DOOR CLOSED ELECTRICAL CONTACT DOES NOT SHOW DOOR CLOSED. DOME LIGHTS STAY ON AND DRAIN BATTERY. DEALER WANTS $400 TO REPAIR IT AND WHEN TOLD TO CUT THE WIRE HE LAUGHED. THE CAR WAS IN MOTION WHEN THIS HAPPENED THE FIRST TIME. IT DOES NOT SHUT OFF.

THE DOOR FRONT DRIVER SIDE DOOR SENSOR WENT BAD AND TELLS CAR THAT DOOR IS AJAR. THIS WAS REPLACED UNDER WARRANTY LAST YEAR. NOW YESTERDAY THE SAME THING HAS HAPPENED TO THE FRONT PASSENGER SIDE DOOR SENSOR. THIS WAS QUOTED TO ME AT $700. THIS IS RIDICULOUS FOR A BAD DOOR SENSOR THAT FORD HAS PUT BAD AND FAULTY SENSORS ON. I FEEL THAT I SHOULD NOT BE LIABLE FOR .THE FORD DEALERSHIP IN TOWN SAID, "THIS IS A PROBLEM WITH FORD FLEX". THIS DOOR AJAR SENSOR KEEPS LIGHTS ILLUMINATED DRAINING THE BATTERY, EVEN THOUGH THE DOOR IS SHUT. THIS KEEPS THE LIGHTS ON WHEN DRIVING, AND AT NIGHT MAKES IT VERY VERY HARD TO SEE AND DRIVE. THIS WILL CAUSE AN ACCIDENT DUE TO FAULTY DOOR SENSORS.

I WAS PULLING INTO MY DRIVEWAY AND MY STEERING COLUMN LOCKED UP COMPLETELY. THE IDIOT ALARM STARTED GOING OFF AND I RECEIVED AND ERROR CODE. THE ERROR READ POWER STEERING FAILURE. I TOOK IT TO TIRE KINGDOM AND THEY SAID I WAS PART OF THE 15V3400000 RECALL. I CALLED FORD AND THEY WOULD NOT COVER THE REPAIR EVEN THOUGH IT'S EXACTLY THE SAME SAFETY RECALL ISSUE I AM HAVING AND MY CAR IS ON THE RECALL LIST. THEY SAID SORRY YOUR VIN ISN'T LISTED AS BEING AFFECTED. IT'S CLEARLY THE SAME ISSUE AND IS. WING AFFECTED. IT'S DANGEROUS THAT I WASN'T NOTIFIED AND NOW THAT I'M HAVING THE PROBLEMS THAT CAUSED THE RECALL IN THE FIRST PLACE THEY STILL WON'T FIX IT.

DRIVER DOOR SENSOR FAILURE. HAVE TAKEN IT TO THE DEALER, DOOR IS CLOSED AND LATCHING, BUT SYSTEM DOESN'T THINK IT IS. UNABLE TO LOCK DOORS, INTERIOR DOME LIGHTS STAY ON CAUSING VISIBILITY ISSUES AT NIGHT. PLUS ANNOYING DINGING ALERTS IN STOP AND GO TRAFFIC

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, ALL THE VEHICLE DOORS FAILED TO LOCK. THE CONTACT ALSO STATED THAT THE DOME LIGHT WAS CONSTANTLY ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT PASSENGER SIDE DOOR MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE BATTERY TO THE VEHICLE HAD TO BE REPLACED TWICE DUE TO THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, THEY FILED A COMPLAINT WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000. THE VIN WAS INVALID.

AS I'M DRIVING THE CHECK ENGINE LIGHT TURNS ON AND IT SLOWS DOWN MY CAR TO TWO MILES PER HOUR ONCE I TURN IT BACK OFF AND BACK ON IT STARTS WORKING AGAIN BUT AS SOON AS I DRIVE FOR A COUPLE OF MILES OR NOT EVEN A COUPLE OF MINUTES THE LIGHT COMES BACK ON AND MY CAR GO STRAIGHT TO DRIVING TO MILES PER HOUR I WANT TO KNOW WHAT COULD BE WRONG WITH THIS AND WHY IS IT DOING IT

DOOR AJAR WARNING - PASSENGER DOOR ELECTRICAL PROBLEM SHOWING THE DOOR IS OPEN ALL OF THE TIME. SINCE THE CAR THINKS THE DOOR IS OPEN, THE CAR WILL NOT LOCK WHILE IN MOTION. PUTTING ALL PASSENGERS IN THE CAR IN DANGER. IT ALSO KEEPS THE INTERNAL LAMPS ON BECAUSE THE CAR THINKS THE DOOR IS OPEN CAUSING THE BATTERY LIFE TO DECREASE AT A QUICKER RATE.

PASSANGER DOOR THINKS ITS AJARED. DOOR IS SECURED ITS JUST THINK ITS OPENNED. WON'T ALLOW ME TO LOCK AUTOMATICALLY AND WILL SET OFF THE ALARM. OTHER THAN HAVING THE INDICATION WHILE DRIVING, MOST OF THE PROBLEMS ARE WHEN IT IS PARKED AND LOCKED (IF I COULD). I'M JUST DEALING WITH THE ALARM ISSUE NOW, DOME LIGHTS ALWAYS ON, AND SOON TO BE DEAD BATTERY.

TONIGHT WAS THE SECOND TIME IT HAPPENED. WHILE I WAS DRIVING, THANK GOODNESS I WAS NOT DRIVING FAST AND WAS STILL ON OUR DRIVEWAY THAT THE ENGINE JUST STALLED FOR NO REASON. I TRIED RESTARTING THE CAR BUT IT WOULD NOT START. I HAD TO TRY STARTING IT MANY TIMES AND AFTER AWHILE IT FINALLY STARTED AGAIN.

PASSENGER REAR DOOR SENSOR THINKS DOOR IS OPEN AT ALL TIMES. EFFECT ALARM SYSTEM, ETC. VEHICLE HAS APPRX 65000 MILES.

I WAS DRIVING DOWN THE STREET AND ALL OF A SUDDEN MY POWER STEERING WENT OUT. THIS HAS HAPPENED MANY TIMES BEFORE AND I WOULD TRY TO GET TO A POINT WHERE I COULD PULL OVER TO THE SIDE OF THE HIGHWAY, RESTART THE CAR AND IT WOULD BE GOOD. THIS TIME IT DIDN'T WORK. I HAVE BEEN ON ROADS IN CURVES MANY TIMES AND IT WOULD GO OUT IN THE MIDDLE OF THEM. I SHUTTLE MY KIDS EVERYDAY AND THIS IS DANGEROUS FOR THEM AND MYSELF. I SEARCH FOR A RECALL A WHILE BACK AND DIDN'T SEE ANYTHING. I AM A SINGLE MOTHER OF 3 AND I DON'T HAVE MONEY TO SPEND OUT ON SOMETHING LIKE THIS WHEN IT SHOULD NOT BE A PROBLEM I'M HAVING WITH A FAIRLY NEW VEHICLE. I WAS TOLD THE PROBLEM IS THE POWER STEERING GEAR AND THE ANGLE POSITION SENSOR. I HAVE NOTICED THAT OTHER 2013 FORD FLEX WERE ISSUED A RECALL FOR THIS PROBLEM, BUT MINE WAS NOT. I CALLED THE FORD MANUFACTURER AND SPOKE WITH 3 DIFFERENT REPRESENTATIVES (REPS) AND A SUPERVISOR. TWO REPS TOLD ME THERE WAS NOTHING THEY COULD DO AND THE OTHER REP AND SUPERVISOR STATED I WOULD NEED TO TAKE MY VEHICLE TO A FORD SERVICE DEPARTMENT AT A DEALERSHIP AND IT WOULD BE THEIR DISCRETION ON WHETHER THEY WILL FIX IT, DISCOUNT IT OR SOMETHING. I DON'T THINK IT IS THE DEALERSHIP'S RESPONSIBILITY AS THEY DID NOT MAKE THE VEHICLE, THEY ONLY SELL THEM. I SPOKE WITH THE SERVICE DEPARTMENT MANAGER AT LANCE CUNNINGHAM FORD IN KNOXVILLE, TN AND HE AGREED AND STATED HE DIDN'T KNOW WHY THEY WOULD TELL ME THAT. HE WAS ALSO NICE ENOUGH TO SAY THAT HE WOULD HELP ME OUT THE BEST HE COU

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT THE DRIVER SIDE DOOR AJAR LIGHT WAS CONSTANTLY ILLUMINATED. THE CONTACT STATED THAT DUE TO THE FAILURE, THE BATTERY HAD TO BE REPLACED TWICE. THE CONTACT ALSO MENTIONED THAT ON A SEPARATE OCCASION, WHILE REVERSING THE VEHICLE THE GEAR SHIFT BECAME INOPERABLE WITHOUT WARNING. THE VEHICLE WAS RESTARTED, AND THE VEHICLE OPERATED AS NORMAL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, THEY INFORMED THE CONTACT THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,492. THE VIN WAS INCOMPLETE.

SERVICE ADVANCETRAC AND COLLISION WARNING NOT AVAILABLE NOTIFICATIONS PRESENT WHEN DRIVING, SPECIFICALLY OCCURRING WHEN TURNING. FORD DEALERSHIP INDICATED THE POWER STEERING CONTROL MODULE (PSCM) WAS DETECTING A MOTOR POSITION SENSOR FAULT AND RECOMMENDED REPLACEMENT OF ELECTRONIC STEERING GEAR. I SPOKE WITH FORD CUSTOMER SERVICE AND THE GRAND LEDGE MICHIGAN FORD DEALERSHIP REGARDING RECALL SAFETY RECALL 15S18 AND BOTH INDICATED THAT MY VIN WAS NOT INCLUDED IN THE RECALL. I WOULD LIKE TO FIND OUT IF MY VIN MAY HAVE BEEN IMPROPERLY EXCLUDED FROM THE RECALL IF THE RECALL STATES FORD FLEX MODELS 2011-2013 ASSEMBLED IN OAKVILLE FOR ALL ENGINES.

THE SENSOR FOR THE RIGHT REAR DOOR BEING CLOSED IS COMING ON WHEN THE DOOR IS ACTUALLY CLOSED. THIS IS ALSO CAUSING THE CAR'S DOOR OPENING SENSORS TO BE ACTIVATED, MAKING THE INTERIOR LIGHTS, HEAD AND TAIL LIGHTS, AND KEYLESS ENTRY LIGHTS TO TURN ON SPORADICALLY. BECAUSE THE DOOR OPEN SENSOR LIGHT IS ON ALL OF THE TIME, IT IS IMPOSSIBLE TO DETECT WHEN THE DOOR IS ACTUALLY OPEN, CREATING A SAFETY HAZARD. THE COMPANY IS AWARE OF THIS DEFECT PER BULLETIN SB-10054930-1306 AND HAS NOT ISSUED A RECALL. THE DEFECT DID NOT OCCUR ON MY VEHICLE UNTIL IT WAS WELL BEYOND ITS NEW VEHICLE WARRANTY.

UPON ENTERING AND STARTING VEHICLE DISPLAYS DOOR AJAR WHEN IT IS CLEARLY CLOSED AND LOCKED. REQUIRES SEVERAL HARD CLOSES OF THE DOOR TO DEACTIVATE SENSOR. ALSO RANDOMLY TRIGGERS CAR ALARM. APPEARS TO WORK PROPERLY IN COOLER WEATHER. DEALER RECOMMENDS A DOOR LATCH REPLACEMENT FOR AN ESTIMATED OF $500

WE SMELLED EXHAUST FUMES WHEN WE FIRST BOUGHT THE CAR...2013. THE DEALER FIXED IT BUT WE ARE SMELLING THEM AGAIN, ESPECIALLY WHEN WE STEP ON IT OR ARE CLIMBING A STEEP GRADE. CONSIDERING THE FORD EXPLORER PROBLEMS, WE THINK THIS MAY ALSO BE SOMETHING HAPPENING WITH THE FLEX.

FRONT PASSENGER DOOR AJAR SENSOR NOT WORKING. DOOR REPORTS BEING OPEN WHEN IT'S NOT. INTERIOR LIGHTS STAY ON, DRAINING BATTERY, INTERFERING WITH DRIVING. HAPPENS WHEN 1ST GETTING INTO CAR, BUT ALSO DURING OPERATION. HAPPENING NEARLY ALL THE TIME NOW.

THE ELECTRIC STEERING IS MAKING A CLUNK NOISE WHEN TURNING AT LOW SPEEDS. (CAN'T REALLY HEAR IT AT HIGHER SPEEDS) THAT IS AN EARLY WARNING OF AN EPAS FAILURE. (ELECTRIC POWER ASSIST STEERING) EVENTUALLY THE STEERING WILL WHINE AND FAIL WHEN DRIVING GOING INTO MANUAL MODE. THAT IS A SAFETY ISSUE! SINCE MY WIFE IS DRIVING THE CAR WITH MY YOUNG DAUGHTER IT HAS ME NERVOUS AND WORRIED.

2013 FORD FLEX DOOR AJAR SWITCH KEEPS DOOR LOCKS FROM LOCKING. WHEN MANUALLY LOCKING DOORS THEY IMMEDIATELY POP BACK UP. ALSO THE DOME LIGHT STAYS LITE, MAKING NIGHT TIME DRIVING DANGEROUS. THIS IS A VERY COMMON PROBLEM WITH THIS VEHICLE.

I PARKED MY CAR TO GO FOOD SHOPPING AND WHEN I CAME BACK TO LEAVE, THE STEERING WHEEL BECAME LOCKED AND IT WOULD NOT TURN

I WAS DRIVING CAR AND IT STALLED OUT OF NOWHERE. HAD CAR TOWED HOME AND MECHANIC SAID IT IS EITHER THE FUEL PUMP OR FUEL MODULE. NOW CAR ONLY STARTS SOMETIMES AND WILL TURN OFF. NOT SAFE TO DRIVE AT ALL. I TRIED CALLING FORD SERVICE DEPARTMENT BUT THEY SAY THAT MY VIN. IS CLEAR DON'T SEE HOW THIS IS POSSIBLE AS MY CAR IS DOING SAMETHING AS MANY OTHER FORD FLEXS ON THE ROAD HOW DO I GET THEM TO ADD MY VIN. TO RECALL LIST PLEASE AS MY CAR IS DOING SAMETHING AS THE CARS ON RECALL LLIST.

TL* THE CONTACT OWNS A 2013 FORD FLEX. UPON STARTING THE VEHICLE, THE POWER STEERING AND ASSIST TRAX WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (BOB WONDRIES FORD 400 S ATLANTIC BLVD, ALHAMBRA, CA 91801 (626) 289-3591) WHERE IT WAS DIAGNOSED THAT THE STEERING WHEEL MODULE MALFUNCTIONED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RESEARCHED RECALLS ONLINE AND FOUND NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000.

2013 FORD FLEX SE. CONSUMER WRITES IN REGARDS TO DOOR AJAR SENSOR FAILURE. *LD THE CONSUMER STATED THAT THE DOOR AJAR ALARM SOUNDS EVEN THOUGH THE DOORS ARE CLOSED AND WOULD NOT LOCK. DUE TO THE DOORS NOT LOCKING, THE INTERIOR LIGHT DO NOT TURN OFF WHEN THE VEHICLE IS OFF. ALL DOORS MUST BE LOCKED MANUALLY. *JS

CONSTANT DOOR AJAR WARNING WHEN ALL DOORS ARE CLOSED (OR OPEN) DRAINS BATTERY AND CONTINUALLY SETS OFF CAR ALARM. DOORS NO LONGER LOCK WHEN CAR IS IN MOTION. DOORS CANNOT BE LOCKED ONCE PARKED OR ALARM WILL SOUND WITHIN 10-15 MINUTES. ISSUE HAS DRAINED MULTIPLE BATTERIES AND STRANDED OWNER. DOME LIGHTS COME ON UNEXPECTEDLY WHILE DRIVING AT NIGHT - ISSUE OCCURS ON STREETS AND HIGHWAYS. FORD DEALER RECOMMENDS REPLACING ALL DOOR LATCHES AT >$200 A PIECE WITH NO GUARANTEE OF ISSUE NOT RECURRING.

FORD MOTOR COMPANY (FORD) IS RECALLING CERTAIN MODEL YEAR 2013-2015 FORD TAURUS, FORD FLEX, LINCOLN MKS AND LINCOLN MKT VEHICLES EQUIPPED WITH 3.5L GTDI ECOBOOST ENGINES AND 2013-2015 FORD TAURUS POLICE INTERCEPTOR VEHICLES. A COMPONENT WITHIN THE FUEL PUMP ELECTRIC MODULE (PEM) MAY OVERHEAT CAUSING A LOSS OF ELECTRICAL POWER TO THE FUEL PUMP. CONSEQUENCE A LOSS OF POWER TO THE FUEL PUMP WILL CAUSE THE ENGINE TO STALL OR PREVENT THE VEHICLE FROM STARTING, INCREASING THE RISK OF A CRASH. WHAT OWNERS SHOULD DO FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE FUEL PEM PART NUMBER AND REPLACE THE FUEL PEM, AS NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 1, 2016. OWNERS MAY CONTACT FORD CUSTOMER SERVICE AT 1-866-436-7332. FORD'S NUMBER FOR THIS RECALL IS 16S31. I HAD THIS PART SUDDENLY GO OUT ON ME ON 6/22/2017 AND HAD IT TOWED TO MY DEALERSHIP. I HAD RECEIVED AN OIL CHANGE AT OUR LOCAL WALMART AND WHEN THEY WENT TO PULL IT OUT OF THE GARAGE THE CAR WOULD NOT START. SO I HAD IT TOWED. I HAD THIS PART REPLACED 6/23/2017 AND I WAS TOLD THAT MY VIN # WAS NOT ISSUED FOR THE RECALL. EVEN THOUGH THEY ADMITTED THAT THE VEHICLE WAS MANUFACTURED WHERE THE RECALLS CAME FROM AND THE DATES OF PRODUCTIONS OF THE RECALL. THIS VEHICLE MET THOSE CONDITION BUT FOR SOME REASON MY VIN WAS NOT ON THE RECALL LIST SO THEY WILL NOT PAY FOR MY PART OR LABOR TO REMOVE AND REPLACE IT.

THE DRIVER'S DOOR LATCH DOES NOT READ THE DOOR IS SHUT, KEEPING THE DOORS FROM BEING LOCKED WHILE THE CAR IS DRIVEN. ALSO MAKES LIGHTS STAY ON SO IT KILLS THE BATTERY.

OVER THE LAST FEW MONTHS, AS I AM DRIVING MY VEHICLE, MY STEERING WILL SEIZE AND STOP OPERATING. THE COMPUTER COMES UP WITH THE FOLLOWING MESSAGE, "POWER STEERING ASSIST FAILURE". I TOOK THE CAR TO A MECHANIC TO HAVE IT DIAGNOSED AND WAS TOLD THERE IS A SAFETY RECALL FOR THIS EXACT ISSUE. THE INFORMATION IS AS FOLLOWS: NHTSA CAMPAIGN NUMBER 15V340000, FORD FLEX 2011-2013, FORD RECALL #15S18. I CALLED THE LOCAL FORD DEALERSHIP, BIRD KULTGEN, AND THEY STATED THAT IT DOES NOT PERTAIN TO MY VEHICLE BECAUSE WHEN THEY PULLED MY VIN, IT DID NOT GIVE THEM A RECALL MESSAGE. I CALLED THE FORD COMPANY AND THEY SAID THE SAME THING. THE RECALL LISTED IS FOR FORD FLEX 2013, WHICH IS WHAT I HAVE. BOTH THE FORD DEALERSHIP AS WELL AS THE COMPANY STATED - SORRY. ISN'T IT POSSIBLE FOR THIS TO HAVE AN EFFECT ON OTHER VIN'S AS WELL? THAT IS WHAT I WAS ASKING FOR THEM TO LOOK INTO. IF MY STEERING FAILS, AND I AM ON THE HIGHWAY, WHICH IS WHAT I DRIVE DAILY TO WORK, I WILL CRASH. THE DEALERSHIP AS WELL AS FORD STATED - MAYBE IT WILL COME UP IN A WEEK, WHO KNOWS.

TL* THE CONTACT OWNS A 2013 FORD FLEX. WHILE DRIVING AND MAKING A RIGHT OR LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED THE FORD MANUFACTURER WHO STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V390000 (STEERING). THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

THE DOOR AJAR WARNING COMES ON EVEN WHEN THE DOORS ARE CLOSED. WITH THIS HAPPENING THE OVERHEAD LIGHTS STAY ON AN ALARM SOUNDS AND TELLS YOU TO SHIFT TO PARK WHEN YOU STOP THE DOORS DON'T LOCK BECAUSE IT THINKS THE DOORS ARE OPEN AND THE ALARM GOES OFF WHENEVER THE CAR SENSES THE DOORS ARE AJAR WHEN SHUT OFF AND THE LIGHTS DON'T TURN OFF ALL NIGHT LONG BECAUSE IT THINKS THE DOORS ARE OPEN.

THE REAR TOE LINK ON THE PASSENGER SIDE FAILED WHILE DRIVING, CAUSING THE VEHICLE TO BECOME UNCONTROLLABLE.

I PLACED THE SUV IN PARK, TURNED IT OFF (THE CAR WAS STATIONARY). AS I LEANED ON THE VEHICLE TO GET OUT OF IT, I NOTICE IT ROLLED BACK. BECAUSE IT WAS UNUSUAL, I PUSH ON THE CAR FRAME TO ENSURE EVERYTHING WAS OKAY. WHEN I PUSHED THE VEHICLE, IT CONTINUED TO ROLL OUT OF MY GARAGE. I HAD TO RUN AND JUMP IN THE CAR, RESTART IT, AND PUT IN IN THE PARK POSITION AGAIN. THIS CAUSED GREAT CONCERN FOR ME BECAUSE MY SMALL CHILDREN WERE IN THE CAR. AFTER THIS OCCURRED, I CALLED FORD TO REPORT IT. RECENTLY, I'VE DONE RESEARCH AND REALIZED THAT SOME OF THE 2012-2014 FORD FLEX VEHICLES WERE RECALLED DUE TO THIS PROBLEM. HTTP://FOX6NOW.COM/2014/08/14/FORD-RECALL-YOUR-CAR-COULD-ROLL-AWAY-EVEN-IF-ITS-PARKED/. WHEN I CALLED FORD TO REPORT, I SPECIFICALLY ASKED THEM DID THEY HAVE ANY KNOWLEDGE OF THE VEHICLE BEING IN PARK BUT DISENGAGING AND ROLLING AND THE RESPONSE I RECEIVED WAS NO. THE PERSON SUGGESTED I PUT THE EMERGENCY BRAKE ON UNTIL I COULD FIGURE OUT WHAT WAS WRONG. THIS SEEMS TO HAVE NOT BEEN THE TRUTH AS THERE WAS A RECALL FOR THIS PROBLEM IN 2014. ALTHOUGH MY VEHICLE WAS NOT INCLUDED IN THAT RECALL, I AM HAVING THAT PROBLEM.

DOME LIGHT WILL NOT TURN OFF, CAUSING DRAIN ON BATTERY, UNSAFE DRIVING CONDITIONS AT NIGHT. THIS SEEMS TO BE AN ESCALATION OF DOOR AJAR WARNINGS FOR BOTH DRIVER SIDE DOOR AND PASSENGER SIDE DOOR. HAVE ALREADY HAD TO REPLACE BATTERY.