2016 Ford F-150 complaints

While driving, the transmission sticks or will not shift. A wrench flashes and has only produced a check engine light one time. Code P0715 - Irregular signal coming from the input/turbine speed sensor in transmission. If it does shift, it is hard and jerks the vehicle. This has only happened a few times while driving but I found a Ford TSB for earlier models (2011-2013) having the same issue.

Rear windshield shattered and exploded from inside cab to out Got into truck to drive got on road about 20 mph. Nothing around. And all of sudden out of no where rear windshield popped and started shattering. I tried to take pictures. I’ll take more in morning. The hole his pushing outward towards the bed. 2016. F150 sport. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Brake fluid leak.brakes quit working immediately while on freeway causing us to zig zag to avoid crashing with other vehicles!

The contact owns a 2016 Ford F-150. The contact stated while driving at approximately 30 MPH and coming to a traffic sign, the contact depressed the brake pedal and felt the brake pedal go the floorboard. The contact stated that the vehicle lost braking functionality. The contact engaged the parking brake and the vehicle came to a stop. The contact stated that he placed the vehicle in neutral and observed that the "check brake" and "low brake fluid" warning lights were illuminated. The contact drove the vehicle back to his residence. The contact had not taken the vehicle to a dealer or independent mechanic to have the vehicle diagnosed. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 22V150000 (Service Brakes, Hydraulic). The manufacturer had not been informed of the failure. The failure mileage was approximately 90,000.

Rear-view backup camera inoperative. Started with broken/fuzzy images with lines then went to blue screen after several weeks. Completely inoperative now. Electrical connections at tailgate have been checked, camera replaced to no avail. Available for inspection if necessary. Safety issue as I can no longer see my front sidewalk when backing into or out of my driveway as children frequently ride scooters up and down the street’s sidewalks. The vehicle has not currently been inspected by anyone for this issue. No warning lamps or messages, just the inoperative display when the camera should be on. Everything else works as intended.

Both exhaust manifolds are warped and snapped the rear studs off. Occasionally lose power when pushing the accelerator. It has been going for awhile now. I didn’t know what it was until I saw other people were having the same problems.

Front differential grinding when driving. Ford Replaced IWE check valve and problem came back about a month later. Windshield washer fluid pump failed.

The rear bench seats in my Super Crew cab F150 do not lock when in the down/seated position. However, on page 154 of the owners manual it states the the following: Returning the Seat to the Seating Position WARNING Make sure that cargo or any objects are not trapped underneath the seat cushion before returning the seat cushion to its original position, and that the seat cushion locks into place. Failure to do so may prevent the seat from operating properly in the event of a crash, which could increase the risk of serious injury. I have tried to contact Ford many times about this conflicting info. Took my truck to a dealership and they didn't think the seats locked down but couldn't provide any guidance why the manual states otherwise. My main safety concern is if its safe to have someone seated in the back seats if the seats don't lock down. Especially, a child seat.

Vehicle transmission/drive train shifted into neutral and dash flashed Service AdvanceTrac & Hill Decent Control Fault warnings while traveling on highway at 70 MPH towing trailer. No advanced warning of issue or warning of power loss. Transmission shift controls had no control of power train. Engine appeared to go into idle mode. This system fault placed the safety of vehicle driver, passengers and nearby vehicles at high risk. Luckily vehicle was topping a rise and gravity maintained speed to coast to shoulder of busy highway. And there was a shoulder on the highway. Turned off vehicle, restarted and appears to be operating normally. Waiting for dealer service to diagnose vehicle.

1st incident - Sudden loss of power when accelerating onto the highway, had to make emergency maneuver into brake down lane. No warning lamps until issue occurred, than every warning light came on! 2nd incident - Sudden loss of power when going to pass a car, once again had to make emergency maneuver and ended up cutting car off I was passing. No warning lamps until issue occurred, than every warning light came on!

What component or system failed or malfunctioned, and is it available for inspection upon request? ENGINE/OIL LEAK How was your safety or the safety of others put at risk? IF THE OIL LEAKS OUT ENOUGH WHILE DRIVING THE MOTOR WILL CEASE UP, AND CAN CAUSE AN ACCIDENT. Has the problem been reproduced or confirmed by a dealer or independent service center? YES Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? YES Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO, IT APPEARED ABOUT 2 MONTHS AGO. I THOUGHT IT WAS JUST A BAD OIL CHANGE, BUT IT HAS ACCURED 2 MORE OIL CHANGES SINCE.

The exhaust manifold warps causing a leak in the manifold in the 3.5 Ecoboost engines. After research, it is a common problem with many Ford owners. This problem causes an emission leak, power loss, and distinct noise. I have not had this confirmed by a dealer as of yet, but it is a very common problem. My truck started having this problem around 45,000 miles. No warning lights or messages have been displayed.

Brake pedal is hard to push down and doesn't work. Pedal is stuck high then slams to the ground with no warning. On several occasions I have almost rear ended the vehicle in front of me. This is a safety issue for myself, my children, and other drivers. This has happened numerous times. Ford has a recall for this same reason on other years and models of the Ford F-150. They need to include the 2016 in the recall as well. There is an internal brake fluid leak. I have taken to local dealer and they tell me there is no problem. When the brakes fail there is no warning, no lights, no chimes, nothing.

Truck engine is stalling out while driving and coming to a stop. The engine turns off, but all electrical power remains. This has occurred six times in a two month period with the first occurrence happening on February 1, 2022. An engine stalling out while the truck is on the road way is a dangerous situation whether stopped at a red light or while in motion, but especially so if it were to occur while driving at high speeds on a highway. There were no warning messages or indication lights prior or subsequent to the occurrences. The truck was brought to the local Ford dealership on February 28, 2022. The service department at the dealership was unable to diagnose the issue because the computer did not provide them with a diagnosis. The truck is being brought back to the dealership for a second evaluation on March 6, 2022.

I remote started my vehicle this morning and when I went out to get in my truck, I noticed smoke in the cab and a burning smell, as if an electrical issue. After investigating, I found my entire rear window was shattered. Apparently when using the remote start it engages the rear window defroster. It appears to have been the reason for the window shattering.?.? I always remote start my vehicle during the cold months and never experienced this before. No warning messages or anything. After researching, found this exact situation seems to be happening for my make and model with no recall in place yet.

The contact owns a 2016 Ford F-150. The contact stated that the back over prevention camera failed to operate as needed. There were no warning lights illuminated. The vehicle was taken to the local dealer but was not diagnosed or repaired. The contact was concerned about possibly running over a pedestrian due to the failure. The manufacturer was not contacted. The failure mileage was approximately 10,323.

I was driving my 2016 Ford F150 truck on an I-91 at usual highway speeds 65 mph in cruise control when I felt and heard a loud bang and the truck jerked and I applied the brakes and came to a stop. I was unable to move the vehicle off the highway. As it turned out the driveshaft was sheared off the transaxel transfer case. I called 911 and the state police and local fire department arrived. The towing company could not move the back wheels when they pulled the truck onto the towtruck platform as the back axel was locked up. This could have resulted in an injury to myself or to other cars around me. Fortunately I was on dry pavement and the vehicle did not swerve into other traffic. The truck was towed to the local Ford dealer. I was told that the transfer case had a crack and leaked oil causing it to seize up. However, I have had no oil leak in my driveway where I park the vehicle and have had no incidents in which the tranfer case has been hit by any large or hard object to cause any cracks in the case. No warning lights went on prior to this incident and the truck had been driven earlier in the week without incident or warning.

2016 F150 47,000 miles. Rear glass shattered for no apparent reason, impairing rear vision. This is a known documented problem for thousands of owners have complained to Ford with no resolve unless it is under warranty.

The contact owns a 2016 Ford F-150. The contact stated that after stopping and making a right turn, the vehicle lost power steering assist and locked up, while driving 5 MPH. The contact stopped, turned off, and then restarted the vehicle however, the power steering assist did not return. The vehicle was driven to the residence in manual steering mode. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the power steering unit needed to be replaced. The vehicle was not repaired due to the part not being available. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,500.

The contact owns a 2016 Ford F-150. The contact stated that the vehicle was parked and idling, when the contact returned to turn off the vehicle, there was an abnormal gasoline odor surrounding the vehicle. The contact stated no warning light was illuminated. The contact had not taken the vehicle to the local dealer. The contact had an independent mechanic diagnose the vehicle and was advised that a gasoline feeding tube under the driver’s side seat located on the frame was too short for its connection to the fuel pump and to the engine. The independent mechanic informed the contact that the connection was under pressure and was leaking gasoline and could detach from the connector and spray gasoline onto the engine. The contact called a local dealer and provided the dealer with the part number for the hose (FL34-9J278-AE). The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 85,000.

We bought this used truck from the ford dealership only 3 months prior! the car max report and other research we did before buying showed 0 issues like this with the truck. we used auto start, which does turn rear defrost on max, leaving a store parking lot. driving through parking lot pulling up to stop light less than 5 minutes after starting truck and as we begin to slow down we heard a terrifying loud explosion sound. we turned around and the entire rear windshield had shattered into tiny glass pieces. some small pieces of glass hit us and some was on the backseat and on the truck bed cover. there were no significant holes of any size or items around the inside or outside of the truck that could have caused the damage. thankfully we were slowing down while driving otherwise we could have been in a wreck with how loud the sound was! dealership we bought it from refused to acknowledge the issue or even help pay for damage! no warning lights or anything else showed up before or after it happened. we did our reasearch after to find what caused it and now it is obvious based on others reported experiences that it was from the rear defrost being on thanks to the auro start function. we still have not had it fixed since quotes from dealership and 3rd party places without insurance are around $700-$1000. with insurance we would have to pay a $500 deductible and they would cover the rest. we have a powerslide window on the rear windshield to which increases the cost too! we even p

The cam phasers fail intermittently causing shuttering/stalling randomly while driving. A large amount of people have had this same issue. Truck will intermittently rev up while in gear. If you're not on the brake, you will move forward/backward. Tons of check engine lights etc

Transmission has downshifted to first gear multiple times on its own while going highway speeds in 6th gear. Vehicle showed an orange wrench in the vehicle information system on dash.

The rear power door locks freeze and won't latch in cold temperatures 15-20 degrees F, unable to keep the doors closed, cannot operate the truck safely. The power lock assembly fail to respond in freezing cold weather.

My door latch wouldn't close in the cold. And then it opened on the highway one day without me doing anything

Rear window shattered while sitting in the driveway. Vehicle was on and running at the time warming up

The contact owns a 2016 Ford F-150. The contact stated that while driving at 50 MPH, the transmission suddenly downshifted into an unknown gear, and the vehicle jerked and shuddered. Additionally, the engine revved loudly. The dealer was made aware of the failure; however, the vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and informed the contact to take the vehicle to a dealer for diagnostic testing. The failure mileage was approximately 46,000. 26 Apr 2022 update: Traded vehicle to dealership in York, PA on 25 Feb 2022 due to being told that the parts were unavailable from Ford. Later on, got a call from a different Ford dealership that they located a replacement part (AL3Z 7G276 D) Molded Lead Frame. I repurchased the vehicle from the dealership (at a higher price) and had the work performed by L&L Ford in East Berlin, PA. Ford agreed to a cost share of the repair, however my outlay was $348.74 plus the cost of purchasing the vehicle back from the dealership (~$1600). The Molded Lead Frame contains the Transmission Range Sensor component. At this point, this issue has cost me approx. $2000.00 to resolve when it should have been a safety recall.

On 12/20/21, while driving home on State Route 7 from work, the low brake fluid warning appeared. I tried the brakes and as I tried to slow down, the pedal went all the way down. I almost went off the road but after pumping it was able to slow a bit. I was merging onto Interstate 8 West and slowly drove to figure out where to get off. The best off ramp was Imperial since it was uphill and managed to pull over after getting off and stopping the truck. Replaced the lost liquid and my brother in law followed me to his home. Same issue with brakes and slowly took it to his home. Took the vehicle to Ford dealer assuming that a recall on F150 due to master cylinder failure and leaking fluid onto the booster, which occurred to my vehicle that it would be covered in good faith by Ford. My VIN was not listed although the issue was similar to the recall. After calling the NHTSA and Ford, there was nothing else that I could do at that time but pay the service. My complaint is that I almost had an accident due to an issue that Ford had recalled various trucks and did not include my truck. The least that Ford can do is in good faith and that it was not an accident due to this failure, that repayment is made on the cost to repair master cylinder and booster.

The line that sprays the windshield washer fluid freezes up ALL THE TIME when it is cold out. This makes it almost impossible to see at times. I end up having to pull over on the side of the road and try to get it working again. The thing I found that works the best is pinching the hose in different areas and then pouring washer fluid on the line through the spaces in the cover. I was out for the last three hours and it never worked a single time! This is EXTREMELY dangerous to both myself and my passengers (which includes my wife and 10 year old son)...but also to every other driver or pedestrian out on the road. Every time I take it into a Ford dealership they claim not to know anything about the problem and they don't know how it can be fixed. I know how it can be fixed. Run the hose on the INSIDE of the hood like every other vehicle so that the engine heat can keep it warm. Instead...Ford runs it in this plastic cavity in between the hood and the windshield. And if it's not bad enough that it's exposed to the cold....they then put vent slits in the housing even further exposing it to the elements. The fact that washer fluid, that is designed not freeze in the first place, is somehow freezing in the lines so neither nozzle works is crazy to me. I have never had this happen on a vehicle before, but is a CONSTANT problem with my Platinum F-150.

Doors will not latch when trying to close them.

Revision of 11448462 filed on 1/23/22 My wife and I were driving to our house in our 2016 Ford F150 and were approaching the final turn into our subdivision. When approaching our road to turn, I turned my directional signals on to show that I was turning left and was slowing down. Also, there was a line of cars behind me. I immediately saw that my turn signals were not working, and were not aware that I was turning left, and continued going straight to ensure that the cars behind me did not ram me in the rear. As soon as I could, I pulled the truck off the right side of the road into a small drainage ditch. No damage to the truck at that time. Electrical components failed; My safety and my wife's safety were put at risk. This problem with the turn signals has been noted by Woody Anderson Ford, Huntsville Al. My truck, after we arrived home, sat in our driveway for approximately a week while I went through my Ford User Manual and several repair manuals looking for the problem. I did not find any reference to that specific problem. However, during that week, while sitting in the driveway, the truck continued to develop more problems, specifically the engine developed problems that would not allow it to run, and the transmission locked- preventing the wheels to roll. The truck is now at Woody Anderson Ford, Huntsville, Ala. .As of this last Friday, at $ 100 an hour for diagagonise. They have told me that the truck is probably unfixable. These two faults, If they had happed to th

We bought our 2016 F150 in 2019. We are not able to latch the driver's door so it is not closed and unable to be driven. There was a recall for this issue but we don't show anything via our VIN number. If it was fixed in a recall, it doesn't work now. What can we do in order to have it fixed?

My wife and I were traveling to our home in the truck. When preparing to turn left off the main road, I noticed that the turn signals were not working, requiring me to go to the right off the side of the road, as there was heavy traffic behind us. While on the side of the road, I tried the windshield wipers, window sprayer, and turn signals. None were working. I turned the engine off and then restarted the truck, and limped home. After getting home, the truck was parked while looking for a mechanic to fix whatever was wrong with it. It was recommended to me that the "Wiper Multi-switch" be replaced. This did not eliminate the problem. I then arranged for the Ford Dealer, Woody Anderson Ford, to take the truck in and fix it. The Dealer says the truck has had a major electrical failure and doubts that can be fixed.

I was driving on the interstate and the vehicle displayed a Blind Spot failure in the middle of the instrument cluster. At that same moment the truck abruptly down shifted almost causing me to loose control and the car behind me to take evasive action off the shoulder of the road. The truck engine was still running but pressing on the accelerator had no response. I had to attempt to navigate two lanes to my left through traffic with no power and in a coast mode. If I were pulling my trailer I would probably not be alive to write this. I took truck to Dave Knapp Ford dealer (where I bough it new). They indicate it is module in the transmission with known issues in various years. They pulled computer info and confirmed what I have written here with exact mph etc. They indicate that this is not a recall. I believe all F150 drivers should be aware of this and are at risk of death or injury.

The emission system,faulty exhaust manifold warped with broken exhaust studs breaking

The contact owns a 2016 Ford F-150. The contact stated that while the vehicle was at the dealer for an unknown repair, the dealer informed the contact that the lug nuts were corroded on all four wheels. The lug nuts were all replaced. The vehicle was repaired and remained at the dealer. The manufacturer was made aware of the failure and referred the contact to file a complaint with NHTSA. The failure mileage was approximately 78,000. The VIN was unavailable.

3.5L Ecoboost - Warped/broken exhaust manifold studs that is due to extreme heat produced by the twin turbos. There's no warning lights and by the time some symptoms starts developing, studs are probably broken or warped which causes a leakage prevents the manifold from properly dissipating the heat/exhaust which can possibly cause additional heat to be repelled back to the engine. Early signs could be a minor to moderate chirping sound that might radiate somewhere around the driver or front passenger lower console when accelerating while driving.

It is now winter and frequently experience temperatures below 10 degrees F. The rear driver side door power lock will not work (will not lock / unlock) when activated by key fob or by pressing button on door. All other doors will lock / unlock as normal. When the plunger is pushed or pulled on the affected door, it will then lock / unlock.

The contact owns a 2016 Ford F-150. The contact stated the gear shift indicator light turned off intermittently and would not be able to shift gears. The contact took the vehicle to the local dealer and had the sunroof track replaced; however, the repair did not resolve the failure. The contact called Cavalier Ford Greenbrier Sales (1515 S Military Hwy, Chesapeake, VA 23320: (757) 424-1111) and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 87,000.

Re: [XXX]. On 10/11/21, I brought my 2016,Ford, F-150 into Hollingsworth Richardson, Baton Rouge, LA for an oil change, and tire rotation. I was informed by the Intake Clerk that the technician could not rotate the tires because he could not remove the lug nuts. Later, I discovered that from. About 2010 to 2015, Ford Manufacturing used composite materials over the lug nuts that would swell, thus rendering the lug nuts immovable. I contacted Ford Manufacturing, and made a complaint. They were to respond within 24 hours. Two days later, after not receiving a response, I contacted Ford via chat, and was told that my case had been summarily closed. This potentially dangerous defect required me to purchase 24 replacement lug nuts at a cost of $73.00, then take my vehicle to a local mechanic, who used a compression air wrench to remove the defected lug nuts, and replace them with those that I purchased. The mechanic who did the replacement work did not charge me for his work, having had the same problem with Ford. Regarding the on-line chat FMC, and their dismissal of my complaint, I took screen shots with my cell phone, Nd saved it to my picture file. If there is a Class Action Suit Log pending, I would like my name to be added to the list. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

While driving, I applied the brakes and the pedal went to the floor. I received a low brake fluid warning. I checked and there was almost no fluid in the master cylinder. It was determined that the master cylinder rear seal had failed. The brake fluid had leaked into the brake booster, which failed. I was driving on the interstate when the brakes failed suddenly and without warning. The vehicle is now at the Ford dealer for repair and they have confirmed the failure of the seal in the master cylinder. I am aware of a prior recall on this issue #20S31 - but the dealer informs me that my VIN # is not part of the recalled vehicle group. However, my sudden failure is exactly what the subject of the prior recall covered. I have the exact model and engine as was involved in the recall.

While driving at 50 mph, automatic transmission put itself in 1st gear. Tires squealed, and engine revved. luckily, no other traffic in area. Transmission self corrected after a few seconds. The weather was dry. Temperature in the low 40's. Other similar occurrences were when starting from a stop sign or red light, transmission stayed in 1st gear. On all above occasions, the dashboard display simply said to see owners manual. My impression is the transmission is believing I am in manual mode for a few seconds.

The passenger door won’t latch when I open it. Then won’t latch to close. And my rear camera traffic warning randomly goes off without nothing being in the way annoying to say the least…….please help

Wheel lug nuts outer layer has deformed making it impossible to tighten lug nuts correctly. Dealer stated this is a common occurrence, but usually happens after 100,000 miles. My vehicle is at 60,996 miles. Dealer stated only option is to change lug nuts at a cost of 129.00 dollars or tires could not be rotated until new lug nuts were purchased. What happens if you have a flat tire on the side of the road? With distorted lug nuts, a person could not get proper torque and wheel could separate from vehicle while driving.

My local ford dealer found during a service request that the Driver’s side exhaust manifold has warped and broken studs for the manifold, causing an exhaust leak that poses a potential safety issue from gases leaking into the passenger cabin and creating a considerable amount of noise, as well as some performance loss.

Unknown

Mushroomed Lug Nuts needs replacements04

PERIODOCALLY, UNABLE TO SECURELY LATCH PASSENGER DOOR.

The contact owns a 2016 Ford F-150. The contact stated while exiting the driveway of his residence, he heard an abnormal noise while turning in either direction. The contact stated no warning light was illuminated. The contact continued driving the vehicle to a fast-food restaurant when the steering wheel became difficult to turn and the vehicle drove over a street divider bumper. The contact was able to get the vehicle out of the road. The contact stated that an unknown steering warning light was illuminated. The contact towed the vehicle to an independent mechanic and was informed that the rack and pinion needed to be replaced. The vehicle was not repaired. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the rack and pinion to be replaced. The vehicle was not repaired but was pending repairs. The manufacturer had been informed of the failure. The failure mileage was approximately 120,000.

THE REAR WINDOW (NON SLIDING) IS SEVERELY LEAKING DURING HARD RAIN AND WHEN GOING THRU A CAR WASH. THE HEADLINER IS SOAKED AND THIS COULD BECOME A SAFETY HAZARD BECAUSE THE PROBLEM COULD CAUSE MILDEW AND MOLD UNDER THE HEADLINER WHICH COULD CAUSE BREATHING PROBLEMS TO INFANTS AND TODDLERS RIDING IN CAR SAFETY SEATS AS WELL AS OTHER PASSENGERS RIDING IN THE VEHICLE. i WOULD EXPECT FORD MOTOR COMPANY TO RECALL AND REPAIR ALL FORDS THAT HAVE THIS PROBLEM.