2015 Ford Explorer complaints

THE SUV IS ONLY 3 YEARS OLD WE BOUGHT IT NEW FROM THE LOT THEN. I NOTICED TODAY THE HOOD IS BUBBLING UP AND THE PAINT IS CHIPPING OFF. THIS DRIVERS DOOR IS CRACKING AT THE SEEM. VERY POOR QUALITY FROM FORD.

I WAS LEAVING THE CRACKER BARREL IN LAKE CITY, TN. I COULDN'T STEER THE CAR. I MADE IT DOWN THE HILL AND TURNED INTO A CONVIENENT STORE PARKING LOT. MY HUSBAND LOOKED UNDER THE HOOD TO SEE IF HE COULD SEE ANYTHING. ALL HE SAW WAS A VERY CORRODED BATTERY. WE HAD HAD THE CAR SERVICED ONE MONTH EARLIER AND THEY DIDN'T SAY ANYTHING ABOUT THE BATTERY. ANYWAY, I CALLED RAY VARNER FORD IN CLINTON, TN WHERE I HAD BOUGHT THE CAR AND TOLD THEM THE PROBLEM. THEY SAID IT WOUL HAVE TO BE TOWED IN, SO I CALLED A TOW TRUCK.THE SERVICE MAN SAID THEY WOULD CHECK IT OVER AND CALL ME LATER WHICH HE DID. THE NEWS WAS DEVASTATING WHEN HE SAID IT WAS THE ELECTRONIC STEERING RACK THAT HAD GONE OUT AND IT WOULD COST $1,731 PLUS TAX. I ALMOST FAINTED. MY CAR HAD GONE OUT OF WARRENTEE ON APRIL 24TH AND AT THE TIME OF THE INCIDENT, MY CAR ONLY HAD 25,896 MILES ON IT. I IS NOT MANY MILES FOR A CARE THAT IS 42 MONTHS OLD. THAT AMOUNT OF MONEY IS TWO MONTHS OF MY SOCIAL SECURITY. A LITTLE WHILE LATER HE CALLED AND SAID MY BATTERY WAS LEAKING ACID AND EVEN THOUGH THE DEALER CHARGES WAY MORE FOR A BATTERY THEN YOU CAN BUY SOMEWHERE ELSE, I TOLD HIM TO PUT A NEW ONE IN. WE STILL WONDERED WHY THE GUYS WHO SERVICED MY CAR DIDN'T NOTICE THE CORROSION, UNLESS IT STARTED AFTER THEY SERVICED IT. THE TOTAL BILL CAME TO $2,166.79 AND THEN I WAS REALLY UPSET. I WAS HOPING THEY WOULD GIVE ME A BREAK SINCE I HAD SUCH LOW MILES ON MY CAR, EVEN THOUGH THE 36 MONTH WARRANTEE HAD ALREADY EXPIRED. I READ ON THE INTERNET THA

TAKATA RECALL INVOLVING VEHICLES IN SOUTHERN FLORIDA FOR A SIMILAR FORD VEHICLE

WHEN I ACCELERATE MY VEHICLE YOU CAN SMELL TGE EXHAUST FUMES AND I INSTANTLY CAN'T BREATHE, GET A HEADACHE, NAUSEATED, AND AFTER A FEW MINUTES I GET VERY SLEEPY. I HAVE TO ROLL MY WINDOW DOWN AND STICK MY HEAD OUT TO BE ABLE TO BREATHE. IT DOESN'T DO IT EVERY TIME BUT IN A 3 HOUR TRIP, IT HAPPENS AT LEAST 4 TIMES DEPENDING ON HOW MUCH ACCELERATING IS HAPPENING. IF MY AC UNIT IS ON HIGH THEN IT WILL AUTOMATICALLY GO TO BARELY BLOWING AND AS I LET OFF THE ACCLERATOR THEN IT WILL EVENTUALLY CYCLE BACK TO HIGH EVEN THOUGH IT IS ON HIGH. IT IS MAKING ME VERY SICK BECAUSE I'M IN MY CAR SO MUCH. I HAVE TAKEN TO FORD REPEATEDLY, TWO DIFFERENT DEALERSHIPS, AND THEY CAN'T GET IT FIXED. SOMETIMES TO GET THE AC TO GO BACK TO NORMAL, I HAVE TO STOP SOMEWHERE AND TURN THE CAR OFF AND BACK ON. THIS HAS BEEN HAPPENING TO ME SINCE A FEW MONTHS AFTER I BOUGHT THE CAR IN FEB 2017. MY DOCTOR SAYS THE ONLY WAY TO CORRECT PROBLEM IS TO GET RID OF THE CAR BUT I DON'T THINK IT NEEDS TO BE ON THE ROAD AT ALL. IT'LL JUST MAKE SOMEONE ELSE SICK TOO.I STARTED NOTICING THE SMELL IN LATE APRIL 2017 AND IT JUST GOT STRONGER AND I STARTED TAKING IN TO FORD WHEN IT STARTED GETTING REALLY BAD. THE VEHICLE HAD 30000 + MILES WHEN I BOUGHT IT.

POWER STEERING LOSS WHILE DRIVING. 2015 FORD EXPLORER XLT WITH 40,908 MILES ON IT. RECEIVED ALERTS ABOUT THE STEERING LOSS AFTER STEERING HAD GONE OUT. NO WARNING PRIOR TO THE STEERING LOSS. ALERTS INCLUDED "STEERING LOSS STOP SAFELY", "SERVICE ADVANCETRAC" AND "TERRAIN MANAGEMENT SYSTEM FAULT" IMMEDIATELY HAD THE EXPLORER TOWED TO CLOSEST FORD DEALER.

ONGOING ISSUE SINCE BUYING VEHICLE. CABIN FILLS WITH TERRIBLE EXHAUST ODOR DURING RAPID ACCELERATION ONTO HIGHWAY, OR WHEN GOING UP STEEP HILLS.

'TAKATA RECAL' WHEN MY CAR HAS BEEN SITTING IN THE DRIVEWAY FOR A FULL DAY WITHOUT BEING DRIVEN OR STARTED. THE FOLLOWING DAY YOU GO TO START THE CAR. IT STARTS NO PROBLEM, ONCE YOUR IN REVERSE THE BATTERY LIGHT WILL COME ON AND AS SOON AS YOU PUT IT IN DRIVE I LOSE ALL POWER AND FUNCTION TO STEER. IF I HIT THE GAS PETAL IT WILL REGAIN POWER. THE LIGHT WILL DISAPPEAR ONLY IF I HIT OK. THIS HAPPENS EVERY TIME WITHOUT FAIL. I ALSO SMELL CARBON DIOXIDE OR GAS FUMES FROM TIME TO TIME

HAVE NOTICED THE POPPING NOISE WHEN TURNING THE STEERING TO THE RIGHT. NOTICED SOMETIMES AN OIL LEAK BY THIS SIDE 1 YEAR BEFORE. THIS LEAK WAS NOTIFIED TO THE DEALER IN EVERY SCHEDULED MAINTAINANCE APPOINTMENT. NEVER WAS CORRECTED. NOW THEY TOLD ME I HAVE TO CHANGE THE RACK AND PINION AND WARRANTY IS EXPIRED. I DON'T KNOW IF THIS UNCOREECTED LEAK COULD BE ASSOCIATED WITH THIS RACK AND PINION PROBLEM I HAVE NOW.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. WHILE DRIVING HOME WITH THE AIR CONDITIONING ACTIVATED, THE RE-CIRCULATION BUTTON WAS PRESSED AND THE CONTACT BECAME DROWSY AND SLEEPY. THE CONTACT STATED THAT THERE WAS AN EXHAUST ODOR IN THE VEHICLE. THE CONTACT BECAME NAUSEATED AND VOMITED INSIDE THE VEHICLE. THE CONTACT WAS CONCERNED THAT HER CHILD WAS ALSO AFFECTED BY THE EXHAUST FUMES. THE CONTACT STATED THAT HER CHILD WOULD CRY WHILE RIDING IN THE VEHICLE. THE VEHICLE WAS TAKEN TO BROADWAY AUTOMOTIVE (LOCATED AT 1010 S MILITARY AVE, GREEN BAY, WI 54304, (920) 499-3131) WHERE IT WAS DIAGNOSED THAT THE GROMMETS IN THE REAR COMPARTMENT OF THE VEHICLE (WHERE THE EXHAUST PIPE WAS LOCATED) WERE FRACTURED AND CAUSED THE CARBON MONOXIDE ODOR INSIDE THE VEHICLE. THE CONTACT WAS INFORMED THAT THE VEHICLE NEEDED TO BE KEPT FOR AN ADDITIONAL DAY DUE TO THE PARTS BEING ORDERED TO HAVE THE REPAIR COMPLETED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.

LOSS OF POWER: WHILE DRIVING MY 2015 FORD EXPLORER XLT WITH 3.5L V-6 ENGINE ON THE HIGHWAY (10/04/18), THE WRENCH LIGHT CAME ON AND THE CAR STARTED TO SHUDDER AND LOSE SPEED. PUSHING DOWN ON THE ACCELERATOR HAD NO AFFECT AND THE CAR RAPIDLY DECELERATED. THE ENGINE WAS RUNNING VERY ROUGH WITH HEAVY VIBRATION. THIS WAS A TERRIFYING AND NEARLY FATAL EXPERIENCE AS FASTER MOVING TRAFFIC STARTED PASSING ME ON BOTH SIDES AS I TRIED TO MOVE OFF THE HIGHWAY. I WAS ABLE TO MOVE THE CAR TO THE SIDE OF THE HIGHWAY AND LIMPED OFF THE NEAREST EXIT. ONCE OFF THE EXIT I SHUT THE CAR OFF AND SAT FOR 20 MINUTES WHILE I RE-GAINED MY COMPOSURE AND CALLED MY HUSBAND. WHEN HE ARRIVED HE STARTED THE EXPLORER AND THE WRENCH LIGHT WAS CLEARED. MY HUSBAND DRIVE THE CAR HOME USING ONLY BACK ROADS WHILE I FOLLOWED IN HIS CAR. WE CALLED OUR LOCAL FORD DEALER AND SCHEDULED AN APPOINTMENT. WE STARTED RESEARCHING THIS ISSUE AND FOUND THIS TO BE A WELL KNOWN PROBLEM WITH THE THROTTLE BODY ON FORD'S V6 ENGINES WHICH ARE USED ON MULTIPLE SUV'S, CROSSOVERS AND SEDANS. THE RESEARCH I'VE SEEN SHOWS THIS ISSUE HAS AFFECTED MORE THAN 10,000 OWNERS. HOWEVER, IT'S NOT CLEAR IF THE THROTTLE BODY IS FAULTY DUE TO A MANUFACTURING OR DESIGN DEFECT. IT'S ALSO NOT CLEAR IF REPLACING THE THROTTLE BODY IS A PERMANENT FIX. I'M TERRIFIED TO DRIVE THE CAR ON THE HIGHWAY AND SINCE THIS HAPPENED WE'VE ONLY USED IT FOR SHORTER TRIPS AROUND TOWN. THE FORD DEALER CHECKED THE CAR TODAY (10/08/18) BUT SINCE THE WRENCH LIGHT WAS CLEARE

WHEN AT IDLE, EITHER IN PARK OR DRIVE, THE ENGINE RPMS WILL FLUCTUATE AND GO DOWN TO A POINT WHERE THE ENGINEER STALLS OR ALMOST STALLS.

TRAVELING ON HIGHWAY AT 60 MPH VEHICLE SUDDENLY DECELERATED TO 5 MPH WITHIN 3 SECONDS. ENGINE BEGAN RUNNING ROUGH AND STOPPED. PULLED TO SHOULDER OF ROAD. MONTHS BEFORE THIS INCIDENT WARNING LIGHT ON INSTRUMENT CLUSTER WOULD INTERMITTENTLY STATE TRANSMISSION NOT IN PARK WHEN PARKING VEHICLE. SERVICE TECHNICIANS COULD NOT REPRODUCE ERROR. VEHICLE TAKEN IN FOR SERVICE ON 9/21/2018. REPORT ON VEHICLE ON 9/28/2018 STATED THAT POWER TRANSFER UNIT DAMAGED BEYOND REPAIR, STEERING COLUMN SWITCH NEEDED REPAIR WHICH MEANT STEERING UNIT NEEDED REPLACING AND INTERLOCK SWITCH ON SHIFTER NEEDED REPLACING. TOTAL COST $5150.00. TRADED VEHICLE IN AND PURCHASED DIFFERENT VEHICLE. VEHICLE NOT PURCHASED FROM DEALERSHIP WHICH ANALYZED REPAIR WORK.

AT APPROXIMATELY 57,000 MILES, MY COMPLETE STEERING MECHANISM FAILED AS I WAS DRIVING MY VEHICLE DOWN A ROAD, WHILE OUT OF STATE ON A VACATION. BOTH OF MY CHILDREN WERE IN THE VEHICLE WHEN THIS OCCURRED AND LUCKILY NO ONE WAS INJURED. THE VEHICLE WAS TOWED TO A FORD DEALERSHIP WHERE THE COMPLETE RACK AND PINION SYSTEM HAD TO BE REPLACED ($1,900.00). WHILE WAITING FOR A TOW TRUCK, I LOCATED A FORD RECALL HAD BEEN COMPLETED FOR THE PREVIOUS THREE OR FOUR MODEL YEARS (2011-2014) FOR THE EXACT SAME FAILURE. THIS IS A KNOWN ISSUE AND I DON'T UNDERSTAND WHY MY MODEL YEAR (2015) ISN'T INCLUDED. WE WERE ON A VACATION AND TRAVELED DOWN THE INTERSTATE AND GLAD THIS DIDN'T OCCURRED WHILE DRIVING 75 MPH.

EXHAUST SMELL WHEN THE CAR ACCELERATES. THE CABIN SMELLS LIKE ROTTEN EGGS.

AIRBAG LIGHT COMES ON & STAYS ON FROM TIME TO TIME, THIS HAS BEEN HAPPENING ON & OFF FOR ABOUT THE LAST 10 MONTHS. TOO MY VEHICLE IN FOR THIS ISSUE TO BE CHECKED A COUPLE TIMES BUT SINCE THE LIGHT WENT OFF TECH WAS UNABLE TO DIAGNOSE PROBLEM. FINALLY YESTERDAY I WAS ABLE TO GET MY VEHICLE TO THE DEALERSHIP WHILE THE LIGHT WAS STILL ON. I AM STILL IN MY EXTENDED WARRANTY PERIOD 5YR/60,000 MILES BUT APPARENTLY WHATEVER REPAIR MY SYSTEM NEEDS TO FUNCTION PROPERLY IS NOT COVERED EVEN THOUGH THE MANUAL STATES THAT MY VEHICLES SAFETY BELTS & AIRBAG SYSTEM ARE COVERED FOR AN EXTENDED SAFETY RESTRAINT COVERAGE PERIOD. THIS IS A SERIOUS SAFETY CONCERN & FROM WHAT I'VE RESEARCHED THIS IS A KNOWN ISSUE BY FORD. IF I DON'T PAY $800 MY AIRBAGS WILL NOT DEPLOY IN THE VENT I HAD AN ACCIDENT

I WAS DRIVING ON THE INTERSTATE AT 70 MPH AND I HEARD A LOUD CLUNK AND MY ENGINE LOST ACCELERATION. I COULD NOT INCREASE MY SPEED AND THE CAR WOULD NOT GO. I HAD TO PULL OFF THE ROAD AND THE CAR WAS RUNNING ROUGH AND WHEN I PUSHED ON THE ACCELERATOR PEDAL THE CAR BARELY MOVED. I WAS ALMOST REAR END BY A TRUCK BUT LUCKILY I WAS ABLE TO PULL OVER SAFELY. THE WRENCH ICON CAME ON MY DASH AND SAID TO TAKE TO DEALER. WHEN I GOT HOME I TOOK IT TO THE FORD DEALER AND THEY DID A DIAGNOSTIC TEST AND IT SHOWED A P2111 FAULT CODE. THE THROTTLE BODY WAS FAULTY AND HAD TO BE REPLACED. THIS MALFUNCTION PUT ME IN A VERY DANGEROUS POSITION.

I WAS IN DOWNTOWN DES MOINES AND RECEIVED A "SERVICE STEERING FAULT NOW" WARNING. I CONTINUED TO DRIVE TO FIND A PARKING SPOT. WHILE PARALLEL PARKING, I RECIEVED THE WARNING AGAIN BUT THIS TIME THE STEERING WENT OUT. I WAS UNABLE TO TURN THE WHEEL AT ALL. I WAS ON THE RAILROAD TRACKS AS A TRAIN WAS COMING AT THIS POINT. I CONTINUED TO TRY TO MOVE THE STEERING WHEEL ANYWAY I COULD TO AT LEAST GET OFF THE TRACKS. O FINALLY TURNED THE CAR OFF AND RESTARTED IT AND WAS ABLE TO MOVE THE STEERING WHEEL AND GET OFF THE TRAIN TRACKS. WE THEN TOOK IT BACK TO THE DEALER AND THEY HAD IT FOR 3 DAYS. ALL THEY DID WAS RESET THE COMPUTER SYSTEM TELLING ME IT COULD HAPPEN AGAIN. WE THEN CONTACTED FORD XORP. AND THEY ALSO DID NOTHING BECAUSE THEY DIDNT SEE IT AS AN ISSUE. IF A COMPANY DOESN'T CARE ABOUT THE PEOPLE BUYING THEIR PRODUCTS, HOW AM I SUPPOSE TO FEEL SAFE IN THEIR VEHICLES?

I WAS DRIVING MY 2015 FORD EXPLORER WITH APPROXIMATELY 34,200 MILES 55-60 MPH ON US 141 IN NORTHERN WI WHEN I SUDDENLY LOST POWER STEERING AND TRACTION CONTROL. I HAD AN ALARM TRIGGERED AND A FAULT WARNING ON THE DASH INDICATING A STEERING FAULT AND CLEARED BY PRESSING THE OK ON THE DASH, BUT HAD VERY HEAVY STEERING AND AN INDICATION THAT THE TRACTION CONTROL WAS OFF. I WAS ABLE TO GET TO A FORD DEALER BUT THEY WERE NO ABLE TO LOOK AT THE CAR FOR SEVERAL HOURS. THEY SUGGESTED I RESTART THE CAR TO SEE WHAT WOULD RESET. THE SYSTEMS DID RESET AND I WAS ABLE TO CONTINUE ON MY TRIP HOME WITHOUT INCIDENT. NO CODES WERE TRIGGERED AND I NOW HAVE AN APPOINTMENT WITH MY DEALER TO CHECK OUT THE PROBLEM. IN SEARCHING THE INTERNET ON EXPLORER STEERING PROBLEMS, I NOTICED THAT THERE WAS A RECALL ON STEERING LOSS FOR 2011-2014 EXPLORERS AND YET THERE ARE STILL MANY COMPLAINS OF STEERING LOSS FOR MODEL YEARS 2015 FORWARD. IT SEEMS THAT THIS VERY DANGEROUS ISSUE HAS NOT BEEN RESOLVED.

THIS MAY BE A DUPLICATE COMPLAINT BECAUSE I'M NOT SURE I SUBMITTED MY PREVIOUS COMPLAINT FORM PROPERLY. YESTERDAY I WAS TRAVELLING DOWN THE FREEWAY AT 65 TO 70 MPH WHEN MY STEERING FROZE UP. THANK GOD I WAS IN THE RIGHT LANE AND GOING STRAIGHT BECAUSE IF I HAD BEEN IN THE PROCESS OF TURNING AND THERE WERE OTHER VEH. AT AN INTERSECTION THERE WOULD HAVE ALMOST CERTAINLY BEEN AN ACCIDENT. ALSO THANK GOD MY WIFE WAS'NT DRIVING BECAUSE SHE WOULD HAVE NEVER BEEN ABLE TO STEER THE CAR OFF THE FREEWAY. I WAS ABLE TO WRANGLE THE CAR TO A NEARBY FORD DEALERSHIP BUT AFTER TURNING THE ENGINE OFF AND BACK ON THE PROBLEM WENT AWAY. AS I HAVE RESEARCHED THIS PROBLEM WITH FORD EXPLORERS FURTHER I HAVE FOUND THAT THIS IS A REOCCURING PROBLEM AND HAS BEEN REPORTED ON NUMEROUS OCCASIONS. IN MY WILDEST IMAGINATION I CANNOT BELIEVE THAT SOMETHING HAS NOT BEEN DONE ABOUT THIS PROBLEM. THIS PROBLEM WILL ABSOLUTELY RESULT IN DEATH OR SERIOUS INJURY TO SOMEONE SOON. I HOPE IT'S NOT ME OR MY FAMILY.

I JUST FILED A COMPLAINT ON MY VEHICLE STEERING PROBLEM AND AS I HAVE BEEN SURFING THE WEB I FIND THAT MANY OTHER PEOPLE HAVE HAD THE SAME PROBLEM. I AM A RETIRED UTAH HIGHWAY PATROLMAN WITH 36 YEARS EXPERIENCE AND I HAVE NEVER SEEN A MORE DANGEROUS PROBLEM THAN THIS. I CANNOT BELIEVE TJHAT SOMETHING HAS NOT BEEN DONE ABOUT THIS PROBLEM. I CAN GUARANTEE IT IS ONLY A MATTER OF TIME UNTIL SOMEONE IS KILLED OR SERIOUSLY INJURED AS A RESULT OF THIS PROBLEM.

THE STEERING WHEEL LOCKED UP WHILE GOING 55 MILES AN HOUR OVER A BRIDGE GOING STRAIGHT

WE WERE DRIVING AT ABOUT 45 MILES AN HOUR WHEN ADVANC TRAC AND POWER STEERING LIGHT CAME ON. THE STEERING GOT SUDDENLY VERY HARD TO MANEUVER HUSBAND HAD BOTH HAND TRYING TO KEEP IT STEADY, HE HAD TO PULL VERY HARD TO BE ABLE TO PULL IN GAS STATION TO GET OUT OF TRAFFIC. BLINKERS NO LONGER WORKED, TERRAIN KNOB TURNED OFF AND DIDN'T WORK. THIS COULD HAVE BEEN A FATAL ACCIDENT IF WE WERE GOING AT HIGHER SPEEDS! THIS PROBLEM NEEDS TO BE RECALLED SO THAT NO ONE GETS KILLED

THE "ELECTRONIC STEERING GEAR" IS DEFECTIVE AT 80,000 MILES. THE PART MAKES LOUD NOISES ON TURNS. REPAIR SHOP SAYS INORDINATE NUMBER OF PROBLEMS HAVE COME IN WITH THIS PART & FAILURE COULD CAUSE STEERING TO FREEZE UP & CAUSE SERIOUS WRECK. SHOP SAYS CAN'T BE REPAIRED & MUST BE REPLACED. PART & LABOR COSTS OVER $2K. THIS CRITICAL, EXPENSIVE PART SHOULD NOT FAIL AT SUCH LOW MILEAGE & CAUSE SUCH HIGH RISK OF INJURY OR DEATH.

ALL STEERING STOPPED WHILE GOING 45/50 MPH ON A MAIN ROAD! GOT THE STEERING SENSOR FIXED FOR $551 AND 2 DAYS LATER THE LIGHT IS ON AGAIN SO IT'S GOING BACK IN..... I'M PREGNANT WITH 2 BOYS U DER 2 AND A 7 YR OLD AND THIS OS RIDICULOUS!!!

OPERATING VEHICLE IN MOTION. WARNING LIGHTS AND ERRORS SHOWED ON DASH WITHOUT ANY WARNING THAT SOMETHING WAS WRONG. POWER STEERING INSTANTLY STOPPED WORKING WHILE VEHICLE WAS OPERATING ON CITY STREET. VEHICLE BECAME VERY DIFFICULT TO HANDLE. PULLED OVER AND SHUT VEHICLE OFF.

THIS VEHICLE IS ALL WHEEL DRIVE AND COMES EQUIPPED WITH A TERRAIN MANAGEMENT SYSTEM TO MONITOR AND ADJUST TO ROAD CONDITIONS. I HAVE OWNED THE VEHICLE 6 MONTHS AND HAVE EXPERIENCED A TERRAIN MANAGEMENT FAULT (FAILURE) IN THE SYSTEM WHICH WILL DISENGAGE THE POWER TRAIN AND LOSE FORWARD MOTION, I HAVE HAD THIS HAPPEN TWICE IN THE ROADWAY IN FORWARD MOTION WHILE IN TRAFFIC ON A FOUR LANE ROADWAY ON THE FIRST FAILURE AND A TWO LANE ROADWAY IN FORWARD MOTION ON SECOND FAILURE. BOTH FAILURES REQUIRED ME TO PLACE THE VEHICLE IN PARK, TURN OFF THE ENGINE AND WAIT A FEW SECONDS FOR THE SYSTEM TO RESET. NOT A SAFE OPTION WHEN SITTING IN TRAFFIC OR ON A MAJOR ROADWAY.. FORD DEALERS LACK THE KNOWLEDGE TO ADDRESS OR CORRECT THE ISSUE AND FORD CUSTOMER SERVICE HAS NO KNOWLEDGE OF THE STATED FAILURE AND OFFERS NO SOLUTION TO ADDRESS OR CORRECT. THE SYSTEM FAILURE WILL CREATE A SAFETY ISSUE FOR THE OCCUPANTS OF THE VEHICLE WHICH COULD RESULT IN INJURY OR DEATH.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS AN INTERNAL FAILURE CONCERNING AN ODORLESS CARBON MONOXIDE LEAKAGE. THE VEHICLE WAS NOT INCLUDED IN NHTSA ACTION NUMBER: EA17002 (STRUCTURE, ENGINE AND ENGINE COOLING). THE DEALER (AUTOMAX FORD, 3301 E CENTRAL TEXAS EXPY, KILLEEN, TX 76543, (254) 699-2629) WAS INFORMED THAT THE CONTACT HAD A CARBON MONOXIDE TESTER THAT DETECTED A HIGH LEVEL OF CARBON MONOXIDE. THE DEALER USED THEIR OWN TESTING DEVICE FOR CARBON MONOXIDE AND ALSO DETECTED A HIGH LEVEL. THE DEALER INDICATED THAT THE MANUFACTURER HAD NO REMEDY OR RECALL TO PROVIDE A PERMANENT SOLUTION UNLESS IT WAS FOR THE POLICE INTERCEPT VEHICLES. THE DEALER STATED THAT REPLACING THE BODY PLUGS IN THE REAR WOULD PROVIDE A REMEDY, BUT THE FAILURE CONTINUED. THE CONTACT'S WIFE EXPERIENCED NAUSEA, HEADACHES, AND WAS UNABLE TO STAND FOR A LONG PERIOD OF TIME. THE CONTACT'S WIFE UNDERWENT MEDICAL TREATMENTS, WHICH CAUSED A LOSS OF EMPLOYMENT DUE TO HEALTH ISSUES GENERATED FROM THE FAILURE WITH THE VEHICLE. THE CONTACT WAS WAITING FOR A BUY BACK OFFER. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

CURRENTLY OWN A 2015 FORD EXPLORER SPORT WHICH HAS 56000 , WHILE DRIVING EAST BOUND ON THE I84 DOING THE SPEED LIMIT AT 65MPH SUDDENLY NO STEERING! COMPLETELY LOCKED'-WHOA'- TALK ABOUT SCARY' ALMOST CRASH INTO AN 18 WHEELS BESIDE ME , I QUICKLY HIT MY HAZARDS AND CAME TO A CRAWL AT THE SIDE OF THE ROAD INTO A BANK' I TRULY THOUGHT I WAS GOOD AS DEAD.. I HAD TO TOW THE CAR TO MY HOME BECAUSE FORD DEALERSHIP WAS CLOSED AT THE TIME '-THIS HAS BEEN A COMMON PROBLEM WITH FORD ACROSS THEIR FLEET FOR YEARS'. AS OF RIGHT NOW I HAVE A 50K CAR WITH 57K MILES JUST SITTING'. WILL BE BRINGING IN TO MY DEALER ASAP AND A CAL TO CORPORATE.. THEY WILL HAVE TO HANDLE THIS ASAP ''. THEY WILL KILL SOMEBODY IF THEY HAVEN'T ALREADY

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. WHILE DRIVING AT A LOW SPEED, THE STEERING COLUMN SEIZED AND THE SERVICE STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO COWLES FORD (13779 NOBLEWOOD PLAZA, WOODBRIDGE, VA) WHERE IT WAS DIAGNOSED THAT THE ELECTRIC POWER STEERING FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

WHILE DRIVING W ON M-81 HIGHWAY 5 MILES WEST OUTSIDE CASS CITY, NI. SUDDENLY LOST POWER STEERING ASSIST ENTERING CURVE.. VEHICLE DEPARTED ONTO GRAVEL WHILE TRYING TO CRANK WHEEL CCW TO GET BACK IN LANE.. THEN WHILE TRYING TO CORRECT WHEEL CW TO STAY IN WESTBOUND LANE, VEHICLE CROSSED INTO EASTBOUND LANE BEFORE REGAINING CONTROL AND REDUCING SPEED - POWER STEERING REMAINED IN MANUAL MODE UNTIL REACHING HOME - NO PRE-WARNING, POWER ASSIST DISENGAGED UPON DISPLAY WARNING FOR "STEERING FAULT", "TERRAIN MANAGEMENT", AND "ADVTRACTION". WOULD HAVE BEEN MANAGEABLE IF FAULT OCCURED ON STRAIGHT ROAD, BUT AT ENTRANCE TO CURVE AT HIGHWAY SPEED, WAS UNABLE TO HAVE ENOUGH TIME TO MUSCLE VEHICLE UNDER CONTROL. BAD SITUATION IF WIFE OR DAUGHTER HAD BEEN DRIVING. TAKING VEHICLE TO DEALERSHIP TODAY, STARTED UP WITH POWER ASSIST FUNCTIONAL ONCE AGAIN, STILL SHOWS FAULTS FOR TERRAIN AND TRACTION CONTROL. POWER STEERING SHOULD NOT DISENGAGE IF A FAULT IS DETECTED IN TERRAIN MANAGEMENT OR TRACTION CONTROL. NO INJURIES, BUT SOME WRIST STRAIN IN MANEUVERING THE STEERING WHEEL UNDER MANUAL CONTROL. NO MEDICAL TREATMENT SOUGHT.

THE EXHAUST LEAKING INTO THE CAR IT TERRIBLE, IT'S GIVING ME HEADACHES AND MAKING ME FEEL SICK. IT HAS BEEN GOING ON SINCE I PURCHASED THE CAR IN 2015 BUT I CAN'T TAKE IT ANYMORE. THE PROBLEM OCCURS WHEN EXCELERATING AT ANY SPEED. TAKING OFF FROM A STOP LIGHT OR ENTERING A HIGHWAY.

US SERVICE MEMBER OVERSEAS (WHICH COMPLICATES THE SOLUTION). PURCHASED VEHICLE IN US IN AUGUST 2015. CURRENTLY ABOUT 45,000 MILES ON A 2015 FORD EXPLORER SPORT AND LOUD POP FROM STEERING COLUMN AT LOW SPEEDS. LOCAL MECHANIC SAYS ENTIRE STEERING COLUMN NEEDS REPLACED AND OVER 2600 EURO ($3000). SHOULDN'T HAPPEN AT LOW MILES. OTHERS EXPERIENCING SIMILAR ISSUES ACROSS MODEL YEARS.

WHILE DRIVING ON A SIDE STREET IN MY NEIGHBORHOOD MY STEERING LOCKED UP & A LIGHT CAME ON THAT SAID STEERING FAULT I COULD NOT MOVE THE STEERING WHEEL AT ALL I TURNED CAR OFF & LOOKED UNDER HOOD HAD NO IDEA WHAT I WAS LOOKING AT CLOSED HOOD GOT BACK IN CAR STARTED UP DEFAULT LIGHT WAS OFF & CAR SEEMED FINE NEXT DAY DRIVING IN MY NEIGHBORHOOD SAME THING HAPPENED TURNED CAR OFF AND ON AND CAR SEEMED FINE I DROVE STRAIGHT TO DEALERSHIP WHERE I PURCHASED THEY TOLD ME IT'S A DEFECT IN ELECTRIC POWER STEERING RACK ITS GONNA COST A LOT TO FIX BECAUSE I BOUGHT CAR IN MARCH 2015 IT'S NO LONGER COVERED BECAUSE WE ARE NOW IN AUGUST AFTER DOING SOME RESEARCH I SEE MANY PEOPLE ARE HAVING THIS SAME PROBLEM & IT WAS A RECALL IN 2014 MODELS SAME EXACT PROBLEM THIS IS A SAFETY ISSUE & SHOULD BE RECALLED BEFORE SOMEONE GETS KILLED

AIR BAG INDICATOR LIGHT STAYS ON.

WHILE DRIVING IN THE CITY THE STEERING BECAME DIFFICULT, THEN THE NOTIFICATION SYSTEM SAID STEERING FAILURE PLEASE STOP, THE DRIVE SELECTOR FAILED AND THE BLINKERS FAILED ALL AT THE SAME TIME. AFTER STOPPING THE STEERING WAS UNTURNTABLE BY THE AVERAGE PERSON. HAD THIS FAILED AT FREEWAY SPEED IT WOULD HAVE BEEN DEADLY IF NOT FATAL. AFTER TOWING THE VEHICLE TO THE DEALER THEY REFUSED TO DO ANYTHING WARRANTY WISE. THE VEHICLE HAS 37K MILES. THEY FAILURE WAS THE EPS AND THE RACK AND PINION HAD TO BE REPLACED. 2K DOLLARS. I READ ON THE INTERNET OF OVER 65 INSTANCES OF THIS HAPPENING ON THE SAME YEAR MAKE AND MODEL, ALL WITH LOW MILES.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED AND THE TRACTION CONTROL AND STEERING WHEEL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT ABLE TO RESTART AFTER THE CONTACT TURNED OFF THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 54,000.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. WHILE DRIVING 70 MPH, THE RUBBER PILLAR TRIM ON THE DRIVER'S SIDE OF THE WINDOW SHIELD DETACHED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000. ... *BF *TR

LOSS OF POWER STEERING WHILE DRIVING

WHILE DRIVING "STEERING FAULT" DISPLAYED AND POWER STEERING STOPS WORKING MAKING IT NEARLY IMPOSSIBLE TO STEER.

TL* THE CONTACT OWNS A 2015 FORD EXPLORER. THE CONTACT STATED THAT EXHAUST FUMES WERE SEEPING INTO THE REAR CABIN OF THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO EMPIRE FORD LINCOLN (106 JONESBORO ROAD, ABINGDON, VA 24210), BUT NO FAILURE WAS FOUND. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 59,220. *TT THE REAR EXHAUST WAS REPLACED.*JS

WHILE TURNING THE STEERING WHEEL TO THE RIGHT A KNOCKING SOUND CAN BE HEARD. TOOK VEHICLE TO MY LOCAL FORD DEALER AND IT WAS DIAGNOSED WITH HAVING A BAD STEERING GEAR AND IT NEEDED TO BE REPLACED FOR $1600 PLUS TAX. THE VEHICLE HAS 35,766 MILES ON IT AND IS OVER THE 3 YEAR WARRANTY BY 5 MONTHS. FORD WOULD NOT GIVE ASSISTANCE ON REPLACING THE PART. SOMEONE NEEDS TO LOOK INTO THESE FAULTY STEERING COMPONENTS BEFORE SOMEONE IS SERIOUSLY INJURED. POWER STEERING GEARS SHOULD NOT GO OUT WITH THAT FEW MILES. SEEING BY THE COMPLAINTS ON THIS PAGE I AM NOT THE ONLY ONE WITH THIS ISSUE.

MY WIFE WAS DRIVING AT 30MPH WHEN POWER STEERING FAILED TOOK IT TO SHOP AND THEY SAID IT WAS ELECTRONIC POWER STEERING MODULE THAT FAILED. A 3 YEAR OLD VEHICLE WITH 40000 MILES ON IT .LOOKS LIKE ALOT MORE PEOPLE HAVE HAD SAME PROBLEM.

I HAVE HAD THE SAME PROBLEM FOR SOME TIME, AND WOULD NORMALLY BE RESOLVED BY TURNING OFF THE VEHICLE TO 'RESET' THE WARNING AND TURN BACK ON AND IT WOULD BE FINE. BUT TODAY, THE STEERING ASSIST FAULT SERVICE SOON WARNING CAME ON AND DID NOT GO OFF. AND I HAVE NO POWER STEERING FUNCTION IN MY FORD EXPLORER AND THE ADVANCE TRAC SYSTEM FAULT WARNING ALSO INDICATED. IN THE PAST I HAVE HAD THIS HAPPEN WHILE DRIVING DOWN A HIGHWAY AND LOOSING POWER STEERING FUNCTION AND HAVE HAD IT HAPPEN WHEN PULLING OUT OF MY GARAGE AND LOST ALL POWER STEERING FUNCTION AND WHILE DRIVING AT LOW SPEEDS IN A TOWN AREA AND LOST ALL POWER STEERING FUNCTION. THERE IS A FORD RECALL FOR THIS EXACT PROBLEM IN FORD EXPLORERS YEARS 2011-2013, BUT I BELIEVE THIS IS THE EXACT SAME ISSUE I AM HAVING WITH MY 2015 FORD EXPLORER.

WINDSHIELD SEALS HAVE COME UN-AFFIXED. PROBLEM DISCOVERED WHILE DRIVING. AFTER REACHING SPEED OF 45MPH LOUD SOUNDS LIKE FOLLOWING A DUMP TRUCK DISPERSING ROCKS. SOUNDS INCREASED IN VOLUME AND INTENSITY BUT NOT VISIBLE WHILE DRIVING. LONG BLACK FRAME COVER ALSO LOOSE.

STEERING FAILED AT 65 MPH NOT ALLOWING ME TURN THE VEHICLE. HURT WRIST TRYING TO AVOID OTHERS CARS.

MY WIFE HAS FOR A WHILE HEARD SOME NOISES FROM THE STEERING AND WE BELIEVED THIS TO BE A MINOR ISSUE. WE HAVE HAD THE CAR IN FOR SERVICE A NUMBER OF TIMES AND TO OUR SURPRISE THEY HAVE NOT FOUND ISSUES. NOW THE MILEAGE OF THE CAR (38K+) AND AGE (3Y+) IS BEYOND WARRANTY AND AT OUR LAST VISIT TO THE FORD DEALER WE WERE INFORMED THAT IT WAS AN ISSUE WITH THE "RACK AND PINION" AND IT NEEDED TO BE REPLACED AT A COST OF $1800 ! WE HAVE COMPLAINED AND THE DEALER WILL CHECK WITH FORD TO SEE IF THEY WILL COVER THIS. I URGE ALL FORD OWNERS TO HAVE THE RACK AND PINION CHECKED SPECIFICALLY BEFORE THE WARRANTY RUNS OUT AS THIS SEEMS TO BE A COMMON PROBLEM.

WINDSHIELD TRIM ON FORD EXPLORER FLEW OFF ON THE HIGHWAY WHILE TRAVELING 70MPH.

THE AIRBAG LIGHT CAME ON WHILE DRIVING AND REMAINED ON (STATIONARY AND IN ALL DRIVING CONDITIONS) AT ABOUT 61,000 MILES WHILE ON A ROAD TRIP. THE CAR WAS TAKEN TO GRAPEVINE FORD IN GRAPEVINE, TX AT 62,654 TO BE DIAGNOSED. THE CAUSE WAS SECOND ROW OPEN HARNESS WITH CODES B141B AND B141C. CHECK OASIS FOUND TSB #16-001, APPLIED TO REPAIR. PER TSB, REPOSITIONED HARNESS AND REPLACED CONNECTORS. PER TSB, CLEARED CODES. THE REPAIRS WERE COVERED UNDER CPO WARRANTY WITH $100 DEDUCTIBLE.

AT 53,000 MILES I NOTICED THE RUBBER TRIM AROUND WINDOWS AND DOORS WAS STARTING TO DEGRADE AND DETACH FROM THE VEHICLE. I TOOK THE CAR TO GRAPEVINE FORD IN GRAPEVINE, TX. THEY SAID THAT WAS NORMAL WEAR AND TEAR AND NOT COVERED BY WARRANTY.

HAVE HAD 2015 EXPLORER IN LOCAL FORD DEALER 6 TIMES TO HAVE EXHAUST FUMES IN CABIN RESOLVED. THEY HAVE PERFORM REPAIRS TO CURRENT TSB'S. STILL HAVING EXHAUST FUMES IN CABIN AFTER NORMAL ACCELERATION. STARTING TO SMELL FUMES WHEN ENTERING CABIN AFTER REMOTE START. CURRENTLY VECHILE IN SHOP AGAIN!